Memorandum of Registration Owner... Signature... Address......... State... Phone No...Mobile No... Selling Dealer...... Signature & Seal... Date of Sale (warranty start date)... Date of expiry... Vehicle Model... Chassis No... Engine No... Date of Registration... Registration No... Battery Make & No... Ignition Key No... BOOK COPY Memorandum of Registration Owner... Signature... Address......... State... Phone No...Mobile No... Selling Dealer...... Signature & Seal... Date of Sale (warranty start date)... Date of expiry... Vehicle Model... Chassis No... Engine No... Date of Registration... Registration No... Battery Make & No... Ignition Key No... FOR HMFCL USE (to be sent to HMFCL) 1
Memorandum of Registration Owner... Signature... Address......... State... Phone No...Mobile No... Selling Dealer...... Signature & Seal... Date of Sale (warranty start date)... Date of expiry... Vehicle Model... Chassis No... Engine No... Date of Registration... Registration No... Battery Make & No... Ignition Key No... FOR SERVICING DEALER USE Memorandum of Registration Owner... Signature... Address......... State... Phone No...Mobile No... Selling Dealer...... Signature & Seal... Date of Sale (warranty start date)... Date of expiry... Vehicle Model... Chassis No... Engine No... Date of Registration... Registration No... Battery Make & No... Ignition Key No... FOR SELLING DEALER USE 3
Manufacturer s Limited Warranty 1. NEW VEHICLE LIMITED WARRANTY (HEREINAFTER CALLED WARRANTY ) 5 Subject to the following terms and conditions, HINDUSTAN MOTOR FINANCE CORPORATION LIMITED (hereinafter called HMFCL) warrants that any items of BASIC WARRANTY ITEMS and SPECIFIC ITEMS, as each such term is defined below, of the new vehicle manufactured by HMFCL (hereinafter called New MITSUBISHI PAJERO SPORT ) will be free from any defects in material and workmanship under normal use and maintenance. Any parts warranted here under which proves defective within the warranty period applicable to such parts will be repaired or replaced free of charge by any authorized HMFCL-MITSUBISHI dealer, for New MITSUBISHI PAJERO SPORT. 2. COVERED ITEMS (1) BASIC WARRANTY ITEMS BASIC WARRANTY ITEMS, which are parts of the New MITSUBISHI PAJERO SPORT Vehicle other than SPECIFIC ITEMS, NOT-COVERED ITEMS and those cases described in Section NOT-COVERED DAMAGES OR CONDITION are warranted for the first 3 years or 1,00,000 kilometers, whichever occurs first, from when this New MITSUBISHI PAJERO SPORT is first delivered to original purchaser as set forth on the Memorandum of Registration (hereinafter called the Warranty Start Date ). (2) SPECIFIC ITEM (BATTERY, TYRE AND TUBE) The original equipped battery, Tyre and Tube is warranted for the first 12 months or 20,000 kilometers, whichever occurs first, from the Warranty Start Date by the respective manufacutrer. 3. NOT-COVERED ITEMS (1) SPECIAL TRANSACTED ITEMS SPECIAL TRANSACTED ITEMS, which are those parts listed below, are not covered under this WARRANTY by HMFCL but by the manufacturer concerned of each such part. Music system, CD player and others, on this new MITSUBISHI PAJERO SPORT. (2) EXPENDABLES AND LUBRICANTS EXPENDABLES AND LUBRICANTS, which are those parts listed below, are not covered under this WARRANTY. 1) EXPENDABLES Air cleaner element Oil filter element Clutch facing, brake pad, brake lining and brake rotor Fuel filter element Windscreen wiper blade Drive-belts Fuse Lamp bulb Other expendable parts
Manufacturer s Limited Warranty 2) LUBRICANTS AND OTHERS Engine oil Differential gear oil Manual transmission oil Steering gear oil Battery electrolyte Power steering fluid Brake and Clutch fluid Transfer gear oil Refrigerant Grease Window washer fluid Coolant Fuel Automatic transmission fluid 4. NOT-COVERED DAMAGES OR CONDITION This warranty does not cover: Fair wear and tear of any part, normal maintenance service items and the parts and material used in connection with such service (as described and specified in Your Car Care Plan in this Service Booklet). Normal deterioration, discoloration, fading, flawing or damage to plated parts, paint coat, rubber parts, leather upholstery and soft trim caused by daily use, wear and exposure. Minor irregularities not affecting quality, performance or function of vehicle or parts thereof (e.g. slight noise or vibration) or which appear only in particular abnormal operations. Damage caused by insufficient or improper maintenance (e.g. negligence of the daily and periodic inspection services and maintenance) as described in this Service Booklet and Owner s Manual installed in the New MITSUBISHI PAJERO SPORT. Damage caused by using a part not approved by HMFCL and being repaired or replaced by any person or any entity, other than authorized HMFCL-MITSUBISHI dealer. Damage caused by traffic accidents, abuse or negligence of the proper handling as set forth in the Owner s Manual, misuse of the New MITSUBISHI PAJERO SPORT, use of the New MITSUBISHI PAJERO SPORT under unusual conditions such as in races or rallies, and modifications of or to the New MITSUBISHI PAJERO SPORT or any parts not recommended or approved by HMFCL. Damages caused by external influences such as chemical pollution, acid rain, floods, traffic accident, hail, sand, salt, tree sap, bird droping, stones, fire or disasters whether due to human fault, negligence or act of God. Damage in cargo body or cargo cabin by loading. 6
Manufacturer s Limited Warranty Incidental or consequential damages such as loss of use of the New MITSUBISHI PAJERO SPORT, loss of time, expenses for fuel, telephone, travel, lodging, legal fees, transportation loss or damage to personal property or commercial loss or loss of revenues. Any new MITSUBISHI PAJERO SPORT vehicle for which the odometer reading has been altered so the kilometers cannot be determined. 5. TERRITORIAL SCOPE When new MITSUBISHI PAJERO SPORT vehicle purchased in the country is registered, WARRANTY will not be valid in other country. THIS WARRANTY IS THE ONLY WARRANTY PROVIDED BY HMFCL IN CONNECTION WITH THE NEW MITSUBISHI PAJERO SPORT. HINDUSTAN MOTOR FINANCE CORPORATION LTD. Chennai Car Plant Adhigathur P.O. Kadambattur - 631 203 Tiruvallur District Tamil Nadu 7
Your Car Care Plan Pre-delivery Inspection Service To help you get maximum enjoyment and satisfaction from your New MITSUBISHI PAJERO SPORT, the vehicle has been inspected and prepared by an authorized HMFCL-MITSUBISHI dealer. Initial Service HMFCL offers you 3 Initial Services at 1,000 km, 10,000 km and 20,000 km for your new vehicle. The inspections and lubricants listed on the reverse side of Initial Service Coupon will be performed free of charge at any authorized HMFCL-MITSUBISHI dealer. Only lubricants and materials used will be charged. Periodic Inspection and Maintenance Service Proper maintenance and care of the vehicle are indispensable for safe driving and lower overall running cost. The periodic inspection services designated in this book are the minimum requirements which should be performed on your initiative by authorized HMFCL-MITSUBISHI dealers. Severe Usage Service Severe operating conditions include the following cases. Driving in a dusty area in an area in which the vehicle is likely to be exposed to salty air or brine. Driving on rough roads, on submerged roads, or hilly areas Driving in cold zones Engine idling for a long time or short-distance travel during cold weather Frequent, sudden application of brakes Towing of a trailer Use as a taxi or as a rent-a-car More than 50% of operation time in heavy city traffic in hot temperature of 32 C (90 F) or higher More than 50% of operation time at speeds of 120 km/h (75 mph) or higher in hot temperature or 30 C (86 F) or higher Operation under excessive load If the vehicle is used under severe operating conditions inspections must be performed more frequently than specified for periodc Inspection Service 8
Your Car Care Plan Do it Yourself You can carry out many inspection and maintenance items on your vehicle yourself. Prior to long-distance travel or, preferably, before you use your vehicle every day, carry out these inspection and maintenance items. Certain maintenance items must also be carried out periodically in accordance with distance travelled. For these items, see your Owner s Manual. Driving in Foreign Countries It is important to point out to our valued customers that different countries throughout the world have vehicles designed to be more suited to those conditions which exist in a particular country. If you are concerned in anyway, please contact HMFCL-Hindustan Motor Finance Corporation for information of the country you will drive before your departure. The local conditions or regulations may change for a particular country in the following way: Local fuels and lubricants may not be suitable for use in your vehicle. Damage may occur to the mechanism if the wrong fuels or lubricants are used. Modification of your vehicle may be required in some cases, due to local regulations or different driving conditions. The correct customer care service for your particular vehicle may not be available due to the fact that the importer may not distribute all of our model range. Certain parts of your vehicle may, therefore, not be available. All of the above could be inconveniences to you. Please check them together with the HMFCL-MITSUBISHI dealer before your departure to foreign countries. Road Test The road test is included in the periodic inspection. This test is to be conducted after completion of all work concerned with items indicated as service items for each periodic inspection. Check the following items while driving the vehicle. Check free play of steering wheel. Check efficiency of service brake and hand brake system. Check driveability of engine. Check condition of instruments, gauges, indicators, exterior lamps, heater and ventilators. Engine Oil Use engine oil meeting the requirements of the appropriate API classification as follows : Diesel-powered vehicles... For Service CD or higher. 9
Pre-Delivery Inspection PRE-DELIVERY INSPECTION Pre-Delivery Inspection PRE-DELIVERY INSPECTION To be filled in by servicing dealer. Date :... Mileage :... Servicing Dealer : Owner... Address...... Job No.... Date... Model... Kms... Registration No... Chassis No... Engine No... Signature & Seal : Selling Dealer Servicing Dealer Owner s Seal Seal & Signature Signature -FOR HMFCL/DEALER S USE- (To be returned by servicing dealer to HMFCL) 11
Owners Feedback Yes No Owner... A. YOUR EXPERIENCE 1. Were all the features and their functions explained to you? 2. Were you given product information/specs. on enquiry? 3. Was the delivery team cordial and helpful? 4. Was the delivery area neat, clean and property lit? 5. Did you get the car of your choice? 6. Was your car delivered as promised? 7. Were the service booklet, owners manual, Warranty details explained and handed over to you? 8. Was your car clean during delivery? Address............ Tel. No... Regn. No... Chassis No... Engine No... Kms... Dealer... Workshop... To be sent to : Service Department Hindustan Motor Finance Corporation Limited, Chennai Car Plant, Adhigathur, P.O. Kadambathur 631 203, Tiruvallur Dist., Tamil Nadu. Email : customersupport@hmfcl.com 12
You are charged only for lubricants and materials used. To be filled in by servicing dealer. Date :... Mileage :... Servicing Dealer : First Initial Service FIRST INITIAL SERVICE 1,000 KM / 1 MONTH (Whichever is earlier) First Initial Service Coupon FIRST INITIAL SERVICE 1,000 KM / 1 MONTH (Whichever is earlier) Owner... Address...... Job No.... Date... Model... Kms... Registration No... Chassis No... Engine No... Signature & Seal : Selling Dealer Servicing Dealer Owner s Seal Seal & Signature Signature -FOR DEALER S USE- (To be returned by servicing dealer to HMFCL) 13
First Initial Service Coupon 14 FIRST INITIAL SERVICE COUPON 1,000 KM / 1 MONTH Service Operations V - belt for tension Radiator hoses Engine coolant level Brake fluid level Battery electrolyte level Suspension arms, dust cover condition Drive shaft boot Transmission oil Transfer oil Differential oil Exhaust pipe connections Parking brake lever play and stroke Road test Washing and vaccuming Reset service reminder system if required * Above schedule is for normal usage only. Please refer Periodic Inspection Service table for severe usage.
You are charged only for lubricants and materials used. To be filled in by servicing dealer. Date :... Mileage :... Servicing Dealer : 2nd Initial Service 2ND INITIAL SERVICE 10,000 KM / 6 MONTHS (Whichever is earlier) 2nd Initial Service Coupon 2ND INITIAL SERVICE COUPON 10,000 KM / 6 MONTHS (Whichever is earlier) Owner... Address...... Job No.... Date... Model... Kms... Registration No... Chassis No... Engine No... Signature & Seal : Selling Dealer Servicing Dealer Owner s Seal Seal & Signature Signature -FOR DEALER S USE- (To be returned by servicing dealer to HMFCL) 15
2nd Initial Service Coupon 2ND INITIAL SERVICE COUPON 10,000 KM / 6 MONTHS Service Operations V-belt for tension Radiator hose Brake fluid level Battery electrolyte level Brake pedal play Air cleaner element Suspension system Steering linkage Drive shaft boot Transmission oil Transfer oil Differential oil Tyre rotation Wheel Alignmant Brake pads and disc Fuel hose Replace engine oil Replace engine oil filter Road test Washing and vaccuming Lubricate propeller shaft grease nipple Reset service reminder if required Check DTC using MUT-III 16 * Above schedule is for normal usage only. Please refer Periodic Inspection Service table for severe usage.
You are charged only for lubricants and materials used. To be filled in by servicing dealer. Date :... Mileage :... Servicing Dealer : 3rd Initial Service 3RD INITIAL SERVICE 20,000 KM / 12 MONTHS (Whichever is earlier) 3rd Initial Service Coupon 3RD INITIAL SERVICE COUPON 20,000 KM / 12 MONTHS (Whichever is earlier) Owner... Address...... Job No.... Date... Model... Kms... Registration No... Chassis No... Engine No... Signature & Seal : Selling Dealer Servicing Dealer Owner s Seal Seal & Signature Signature -FOR DEALER S USE- (To be returned by servicing dealer to HMFCL) 17
3rd Initial Service Coupon 3RD INITIAL SERVICE COUPON 20,000 KM / 12 MONTHS Service Operations V - belt for tension Fuel hose / brake hose and pipes Engine coolant level Brake fluid level Radiator hose Brake pedal play Air cleaner element Battery electrolyte level Suspension system Drive shaft boot Steering linkage Transmission oil Transfer oil Differential oil Parking brake lever play and stroke Tyre rotation Wheel alignment Brake pads and discs EGR systems Replace fuel filter Replace engine oil Replace engine oil filter Road test Washing and vaccuming Lubricate propeller shaft grease nipple Reset service reminder if required Check DTC using MUT-III * Above schedule is for normal usage only. Please refer Periodic Inspection Service table for severe usage. 18
4th Service 4TH SERVICE 30,000 KM / 18 MONTHS (Whichever is earlier) PAID SERVICE 4th Service Coupon 4TH SERVICE COUPON 30,000 KM / 18 MONTHS (Whichever is earlier) Owner... Address... To be filled in by servicing dealer. Date :... Mileage :... Servicing Dealer :... Job No.... Date... Model... Kms... Registration No... Chassis No... Engine No... Signature & Seal : Selling Dealer Servicing Dealer Owner s Seal Seal & Signature Signature -FOR DEALER S USE- (To be returned by servicing dealer to HMFCL) 19
4th Service Coupon 4TH SERVICE COUPON 30,000 KM / 18 MONTHS Service Operations V - belt for tension Parking brake lever play Engine coolant level and stroke Radiator hose Brake pads and discs for wear Air cleaner element Brake fluid level Battery electrolyte level Suspension system Steering linkage Drive shaft boots Transmission oil Transfer oil Differential oil Lubricate propeller shaft grease nipple Brake pedal play Fuel hose / brake hose and pipes Tyre rotation Wheel alignment Replace engine oil Replace engine oil filter Engine idle speed Road test Washing and vaccuming Reset service remainder if required Check DTC using MUT-III 20 * Above schedule is for normal usage only. Please refer Periodic Inspection Service table for severe usage.
5th Service 5TH SERVICE 40,000 KM / 24 MONTHS (Whichever is earlier) PAID SERVICE 5th Service Coupon 5TH SERVICE COUPON 40,000 KM / 24 MONTHS (Whichever is earlier) Owner... Address... To be filled in by servicing dealer. Date :... Mileage :... Servicing Dealer :... Job No.... Date... Model... Kms... Registration No... Chassis No... Engine No... Signature & Seal : Selling Dealer Servicing Dealer Owner s Seal Seal & Signature Signature -FOR DEALER S USE- (To be returned by servicing dealer to HMFCL) 21
5th Service Coupon 22 V belt for tension Radiator hoses Replace engine coolant Valve clearance 5TH SERVICE COUPON 40,000 KM / 24 MONTHS Service Operations Replace air cleaner element Replace brake and clutch fluid Battery electrolyte level Suspension system Steering linkage Drive shaft boots Transmission oil Transfer gear oil Differential gear oil Lubricate propeller shaft grease nipple Exhaust pipe connections for leakage Brake pedal play Parking brake lever play and stroke Tyre rotation Wheel alignment Brake hoses and pipes Brake pads and discs for wear Brake shoe linings and drums for wear Fuel hoses and pipes Replace engine oil Replace engine oil filter Replace fuel filter Engine idle speed Exhaust gas recirculation system (EGR) Road test Washing and vacuuming Reset service reminder if required Check DTC using MUT-III * Above schedule is for normal usage only. Please refer Periodic Inspection Service table for severe usage.
6th Service 6TH SERVICE 50,000 KM / 30 MONTHS (Whichever is earlier) PAID SERVICE 6th Service Coupon 6TH SERVICE COUPON 50,000 KM / 30 MONTHS (Whichever is earlier) Owner... Address... To be filled in by servicing dealer. Date :... Mileage :... Servicing Dealer :... Job No.... Date... Model... Kms... Registration No... Chassis No... Engine No... Signature & Seal : Selling Dealer Servicing Dealer Owner s Seal Seal & Signature Signature -FOR DEALER S USE- (To be returned by servicing dealer to HMFCL) 23
6th Service Coupon 6TH SERVICE COUPON 50,000 KM / 30 MONTHS Service Operations V - belt for tension Radiator hoses Engine coolant level Air cleaner element Brake fluid level Timing belt tension Battery electrolyte level Suspension system Lubricate suspension arm Steering linkage Drive shaft boots Brake pedal play Parking brake lever play and stroke Brake pads and discs Tyre rotation Wheel alignment Replace engine oil Replace engine oil filter Transfer gear oil Differential gear oil Lubricate propeller shaft grease nipple Transmission oil Brake hose and pipe/ fuel hose Engine idle speed Road test Washing and vaccuming Reset service reminder if required Check DTC using MUT-III * Above schedule is for normal usage only. Please refer Periodic Inspection Service table for severe usage. 24
7th Service 7TH SERVICE 60,000 KM / 36 MONTHS (Whichever is earlier) PAID SERVICE 7th Service Coupon 7TH SERVICE COUPON 60,000 KM / 36 MONTHS (Whichever is earlier) Owner... Address... To be filled in by servicing dealer. Date :... Mileage :... Servicing Dealer :... Job No.... Date... Model... Kms... Registration No... Chassis No... Engine No... Signature & Seal : Selling Dealer Servicing Dealer Owner s Seal Seal & Signature Signature -FOR DEALER S USE- (To be returned by servicing dealer to HMFCL) 25
7th Service Coupon 26 7TH SERVICE COUPON 60,000 KM / 36 MONTHS Service Operations V - belt for tension Parking brake lever play Radiator hoses Engine coolant level Air cleaner element Brake fluid level Battery electrolyte level Replace fuel filter Suspension system Steering linkage Drive shaft boots Transmission oil Transfer gear oil Differential gear oil Lubricate propeller shaft grease nipple Exhaust pipe connections for leakage Brake pedal play Tyre rotation Wheel alignment Brake hoses and pipes Fuel hose and pipes Brake pads and discs for wear Replace engine oil Replace engine oil filter Replace fuel filter Engine idle speed Exhaust gas recirculation system (EGR) Road test Washing and vaccuming Reset service reminder if required Check DTC using MUT-III * Above schedule is for normal usage only. Please refer Periodic Inspection Service table for severe usage.
8th Service 8TH SERVICE 70,000 KM / 42 MONTHS (Whichever is earlier) PAID SERVICE 8th Service Coupon 8TH SERVICE COUPON 70,000 KM / 42 MONTHS (Whichever is earlier) Owner... Address... To be filled in by servicing dealer. Date :... Mileage :... Servicing Dealer :... Job No.... Date... Model... Kms... Registration No... Chassis No... Engine No... Signature & Seal : Selling Dealer Servicing Dealer Owner s Seal Seal & Signature Signature -FOR DEALER S USE- (To be returned by servicing dealer to HMFCL) 27
8th Service Coupon 8TH SERVICE COUPON 70,000 KM / 42 MONTHS Service Operations V - belt for tension Radiator hoses Engine coolant level Air cleaner element Brake fluid level Battery electrolyte level Suspension system Steering linkage Drive shaft boots Brake pedal play Parking brake lever play and stroke Brake pads and discs for wear Brake hose and pipe / Fuel hose Tyre rotation Wheel alignment Replace engine oil Replace engine oil filter Transmission oil Transfer gear oil Differential gear oil Lubricate propeller shaft grease nipple Engine idle speed Road test Washing and vaccuming Reset service reminder if required Check DTC using MUT-III * Above schedule is for normal usage only. Please refer Periodic Inspection Service table for severe usage. 28
9th Service 9TH SERVICE 80,000 KM / 48 MONTHS (Whichever is earlier) PAID SERVICE 9th Service Coupon 9TH SERVICE COUPON 80,000 KM / 48 MONTHS (Whichever is earlier) Owner... Address... To be filled in by servicing dealer. Date :... Mileage :... Servicing Dealer :... Job No.... Date... Model... Kms... Registration No... Chassis No... Engine No... Signature & Seal : Selling Dealer Servicing Dealer Owner s Seal Seal & Signature Signature -FOR DEALER S USE- (To be returned by servicing dealer to HMFCL) 29
9th Service Coupon 30 9TH SERVICE COUPON 80,000 KM / 48 MONTHS Service Operations V - belt for tension Tyre rotation Radiator hoses Replace engine coolant Replace air cleaner element Replace brake and clutch fluid Battery electrolyte level Suspension system Steering linkage Drive shaft boots Replace transmission oil Replace transfer gear oil Replace differential gear oil Lubricate propeller shaft grease nipple Exhaust pipe connections for leakage Brake pedal play Wheel alignment Brake hoses and pipes Brake pads and discs for wear Brake shoe linings and drums for wear Fuel hoses and pipes Replace engine oil and engine oil filter Replace fuel filter Engine idle speed Exhaust gas recirculation system (EGR) Road test Washing and vaccuming Reset service reminder if required Check DTC using MUT-III Parking brake lever play and stroke * Above schedule is for normal usage only. Please refer Periodic Inspection Service table for severe usage.
10th Service 10TH SERVICE 90,000 KM / 54 MONTHS (Whichever is earlier) PAID SERVICE 10th Service Coupon 10TH SERVICE COUPON 90,000 KM / 54 MONTHS (Whichever is earlier) Owner... Address... To be filled in by servicing dealer. Date :... Mileage :... Servicing Dealer :... Job No.... Date... Model... Kms... Registration No... Chassis No... Engine No... Signature & Seal : Selling Dealer Servicing Dealer Owner s Seal Seal & Signature Signature -FOR DEALER S USE- (To be returned by servicing dealer to HMFCL) 31
10th Service Coupon V - belt for tension Radiator hoses Engine coolant level Air cleaner element Brake fluid level Battery electrolyte level Suspension system Steering linkage Drive shaft boots Brake pedal play Parking brake lever play Brake pads and discs for wear Brake hose and pipe / fuel hose 10TH SERVICE COUPON 90,000 KM / 54 MONTHS Service Operations Tyre rotation Wheel alignment Replace engine oil Replace engine oil filter Transmission oil Transfer oil Differential gear oil Lubricate propeller shaft grease nipple Engine idle speed Road test Washing and vaccuming Reset service reminder if required Check DTC using MUT-III 32 * Above schedule is for normal usage only. Please refer Periodic Inspection Service table for severe usage.
11th Service 11TH SERVICE 1,00,000 KM / 60 MONTHS (Whichever is earlier) PAID SERVICE 11th Service Coupon 11TH SERVICE COUPON 1,00,000 KM / 60 MONTHS (Whichever is earlier) Owner... Address... To be filled in by servicing dealer. Date :... Mileage :... Servicing Dealer :... Job No.... Date... Model... Kms... Registration No... Chassis No... Engine No... Signature & Seal : Selling Dealer Servicing Dealer Owner s Seal Seal & Signature Signature -FOR DEALER S USE- (To be returned by servicing dealer to HMFCL) 33
11th Service Coupon 34 V - belt for tension Radiator hoses Engine coolant Air cleaner element Replace timing chain Clutch fluid level Brake fluid level Battery electrolyte level Suspension system Steering linkage Drive shaft boots Transmission oil Transfer gear oil Differential gear oil 11TH SERVICE COUPON 1,00,000 KM / 60 MONTHS Service Operations Lubricate propeller shaft grease nipple Exhaust pipe connections for leakage Brake pedal play Tyre rotation Wheel alignment Brake hoses and pipes Fuel hose and pipe Brake pads and discs for wear Replace engine oil Replace engine oil filter Replace fuel filter Engine idle speed Exhaust gas recirculation system (EGR) Valve clearance Replace air purifier filter Road test Washing and vaccuming Reset service reminder if required Check DTC using MUT-III Parking brake lever play and stroke * Above schedule is for normal usage only. Please refer Periodic Inspection Service table for severe usage.
Periodic Inspection and Maintenance When your vehicle is given a periodic inspection by an authorized HMFCL-MITSUBISHI dealer, the following symbols are used in order to assure perfect and uniform service operations. I : Inspection (means adjustment or top up as required) R : Replace or change L : Lubrication C : Clean FWD : Front-wheel drive vehicles RWD : 4WD : Rear-wheel drive vehicles 4-wheel drive vehicles 35
Periodic Inspection Service I : Inspection R : Replace or change L : Lubrication C : Clean SL NO. KILOMETERS OR TIME IN YEARS (MONTHS),WHICH EVER COMES FIRST ITEM X 1,000 KMS 10 20 30 40 50 60 70 80 90 100 110 120 130 140 150 160 170 180 190 200 OPERATION INSIDE THE ENGINE COMPARTMENT MONTHS 1 6 12 18 24 30 36 42 48 54 60 66 72 78 84 90 96 102 108 114 120 1 V-belts for cracks,fraying,wear and adjust its tension I I I I I I I I I I I I I I I I I I I I I 2 Check Vacuum pump oil hoe for damage I I I I I I I I I I I I I I I I I I I I I 3 Check intake air hose and turbocharger oil hose for damage. I I I I I I I I I I 4 Replace engine timing belt ( Incl timing belt B ) I R I R 5 Check condition of crank case emission hose I I I I I I I I I I 6 Check valve clearance I I I I I 7 Radiator hose for damage and proper connection I I I I I I I I I I I I I I I I I I I I I 8 Engine coolant level in reservoir I I I I R I I I R I I I R I I I R I I I R 9 Air cleaner element Normal usage C C C C R C C C R C C C R C C C R C C C R Severe usage REPLACE WHEN REQUIRED 10 Brake & Clutch fluid I I I I R I I I R I I I R I I I R I I I R 11 Battery electolyte level I I I I I I I I I I I I I I I I I I I I I 12 Fuel filter R R R R R R R R R R 36
Periodic Inspection Service I : Inspection R : Replace or change L : Lubrication C : Clean SL NO. ITEM KILOMETERS OR TIME IN YEARS (MONTHS),WHICH EVER COMES FIRST X 1,000 KMS 10 20 30 40 50 60 70 80 90 100 110 120 130 140 150 160 170 180 190 200 OPERATIONS UNDER THE VEHICLE MONTHS 1 6 12 18 24 30 36 42 48 54 60 66 72 78 84 90 96 102 108 114 120 1 Suspension system for damage and looseness I I I I I I I I I I I I I I I I I I I I I 2 Suspension arm ball joints for play,dust cover damage I I I I I I I I I I I I I I I I I I I I I 3 Lubricate propeller shaft grease nipple L L L L L L L L L L L L L L L L L L L L 4 Drive shaft boot for damage I I I I I I I I I I I I I I I I I I I I I 5 Steering linkage for damage and loose connections (including seals and boots) 6 Manual transmission Oil I I I I I I I I I I I I I I I I I I I I I Normal usage I I I I I I I I R I I I I I I I R I I I I Severe usage I I I I R I I I R I I I R I I I R I I I R 7 Transfer gear oil(4wd) Normal usage I I I I I I I I R I I I I I I I R I I I I Severe usage I I I I R I I I R I I I R I I I R I I I R 8 Differential gear oil Normal usage I I I I I I I I R I I I I I I I R I I I I Severe usage I I I I R I I I R I I I R I I I R I I I R 9 Exhaust pipe connections for gas leakage and pipe installation I I I I I I I I I I I I I I I I I I I I I OPERATIONS INSIDE THE VEHICLE 1 Brake padel and clutch pedal free play I I I I I I I I I I I I I I I I I I I I I 2 Parking brake lever play and stroke I I I I I I I I I I I I I I I I I I I I I 37
Periodic Inspection Service I : Inspection R : Replace or change L : Lubrication C : Clean SL NO. ITEM OPERATIONS OUTSIDE THE VEHICLE X 1,000 KMS MONTHS KILOMETERS OR TIME IN YEARS (MONTHS),WHICH EVER COMES FIRST 10 20 30 40 50 60 70 80 90 100 110 120 130 140 150 160 170 180 190 200 1 6 12 18 24 30 36 42 48 54 60 66 72 78 84 90 96 102 108 114 120 1 Wheel alingment and tyre rotation I I I I I I I I I I I I I I I I I I I I 2 Front wheel and rear wheel bearing for play I I I I 3 Brake hoses and pipes for leakage I I I I I I I I I I I I I I I I I I I I I 4 Brake pads and discs for wear 5 Brake shoe linings and drums(drum in disc) for wear 6 Fuel hoses and pipes for leakage or deterioration Normal usage I I I I I I I I I I I I I I I I I I I I I Severe usage REPLACE WHEN REQUIRED I I I I I I I I I I I I I I I I I I I I I I I I I I I I I I I I I I I I I I I I I I OPERATION AFTER ENGINE IS WARMED UP 1 Automatic transmission Fluid Normal usage Severe usage I I I I I I I I R I I I I I I I R I I I I I I I I R I I I R I I I R I I I R I I I I 2 Engine oil 3 Engine oil filter Normal usage Severe usage Normal usage Severe usage I I I I R:Every 10000 Kms or 6 months R:Every 5000 Kms or 3 months R:Every 10000 Kms or 6 months R:Every 5000 Kms or 3 months 4 Engine idling speed I I I I I I I I I I I I I I I I I I I I I 5 Exhaust gas recirculation (E.G.R) system I I I I I I I I I I I I I I I I I I I I I OTHERS 1 Body conditions for damage I I I I I I I I I I I I I I I I I I I I I 2 Check the common rail engine (Small injection quantity learning) I I I I I I I I I I I I I I I I I I I I I 3 Road test I I I I I I I I I I I I I I I I I I I I I 4 Check electronic control system diagnosis output using MUT III I I I I I I I I I I I I I I I I I I I I I 38
Periodic Inspection Service Severe usage specification apply to only vehicle used under severe operating conditions severe operating conditions include : 1. Driving in a dusty area or in an area in which the vehicle is likely to be exposed to salty air or brine 2. Driving on rough roads, on submerged roads, or hilly areas 3. Driving in cold zones 4. Engine idling for a long time or short - distance travel during cold weather 5. Frequent sudden application of brakes 6. Towing of a trailer 7. Use as a taxi or as a rent - a - car 8. More than 50% of the driving is in heavy city traffic and ambient temperature is 32 C or higher 9. More than 50% of the driving is at 120 km/n or higher and the ambient temperature is 30 C or more 10. Operation under excessive load. 39
Periodic Inspection Service Record When the engine oil and the oil filter of your vehicle are replaced by an authorized HMFCL-MITSUBISHI dealer at regular intervals. The dealer will record the operation on the oil change record sheet. Oil Change Record Date------------------------------------------------------------ ---------------------------------------------------------------km Date------------------------------------------------------------ ---------------------------------------------------------------km Date------------------------------------------------------------ ---------------------------------------------------------------km 10,000 km or 6 months oil change 20,000 km or 12 months oil change 30,000 km or 18 months oil change Date------------------------------------------------------------ ---------------------------------------------------------------km Date------------------------------------------------------------ ---------------------------------------------------------------km Date------------------------------------------------------------ ---------------------------------------------------------------km 40,000 km or 24 months oil change 50,000 km or 30 months oil change 60,000 km or 36 months oil change Date------------------------------------------------------------ ---------------------------------------------------------------km Date------------------------------------------------------------ ---------------------------------------------------------------km Date------------------------------------------------------------ ---------------------------------------------------------------km 70,000 km or 42 months oil change 80,000 km or 48 months oil change 90,000 km or 54 months oil change Date------------------------------------------------------------ ---------------------------------------------------------------km Date------------------------------------------------------------ ---------------------------------------------------------------km Date------------------------------------------------------------ ---------------------------------------------------------------km 1,00,000 km or 60 months oil change 1,10,000 km or 66 months oil change 1,20,000 km or 72 months oil change 40
Periodic Inspection Service Record Record all Service Operations carried out along with Parts replaced. Date Kilometers Servicing items Servicing dealer 41
Periodic Inspection Service Record Record all Service Operations carried out along with Parts replaced. Date Kilometers Servicing items Servicing dealer 42
Lubricant / Coolant Capacities Sl.No. Items Quantity Recommended lubricants Oil pan 5.5 litres 1 Engine oil* Oil filter 0.8 litre Please refer to Chapter 8-Selection of engine oil Total 6.3 litres 2 Brake fluid* 1.2 litres DOT 4 + 3 Clutch fluid 0.25 ml DOT 4 + 4 Washer fluid 2.3 litres 5 Power steering fluid 1.0 litre ATF DEXRON III / ATF DEXRON II 6 Engine coolant* 8.2 litres DIA QUEEN SUPER LONG LIFE COOLANT or equivalnet (Includes 0.65 litre in the reserve tank) 7 Manual transmission fluid 3.4 litres Gear oil API classification GL-4 SAE 75W-85 8 Automatic transmission fluid 9.7 litres ATF SP III 9 Transfer oil 2.5 litres Gear oil API classification GL-4 SAE 75W-85 10 Differential oil Front 1.2 litres Hypid gear oil API classification GL-5 or higher SAE 80W Rear 2.1 litres 11 Refrigerant (air conditioning) With rear air conditioning 855-895 g HFC-134a (R 134a) NOTE : * Requiring routine inspection or replenishment. 43
NOTES :..............................