VIN Vehicle Make Model Model Year Unit Number 4V4NC9EG38N264159 Volvo VNL 2008 Vehicle s Serial Number Software Version Network Brakes Bendix EC-60 Advanced ABS N/A BB40966 BB40928 J1939 Vehicle ECU Volvo Vehicle ECU 07230134 21967862 J1939 Engine Volvo D13 07284249 22270806 J1939 Transmission Volvo I-Shift Transmission 00004015 22189648 J1939 Safety Restraint System Volvo SRS Airbag ECU 00000158 20452787 J1587 Volvo ECC-ECU 00124112 20549727 J1587 Instrument Cluster Volvo Information Display 07213080 21061198 J1939 Engine - Vehicle Mgt System Volvo Gear Selector ECU 08421290 21246345 J1939 Volvo Module 00000201 21150223 J1939 Volvo Link 06003475 21128140 J1587 Page 1 of 5
Vehicle Key Data Points Parameter Value Parameter Value Battery Potential 15.10 volts Coolant Level Not Available Engine Oil Level Normal Odometer 1,265,346.60 km Total Avg Fuel Econ 2.40 km/l Total Engine Hrs 21,071.70 hrs Road Speed Limit 105.00 km/hr Cruise Spd Limit 105.00 km/hr DPF Soot Level Low Engine Derate No Derate Malfunction Indicator Lamp Off Red Stop Lamp Off Amber Warning Lamp On Protect Lamp Off Parking Brake Switch On DPF Lamp Command Off Exhaust System High Temperature LamOff ABS On ABS, Trailer Not Available Engine Speed 0 rpm Fuel 50% Vehicle Issues 4 Active Fault(s) Present Faults Active Brakes Additional Axle - Left Wheel Speed Sensor Open or Shorted (Flash Code 14-3) Active Instrument Cluster Battery Voltage - Abnormally high voltage or short circuit to higher voltage SID 5 2 46 PID 158 3 2 Active Instrument Cluster Data Link, MID 142 - Bad intelligent device or component PSID 239 12 31 Active Transmission Air Pressure, Transmission - Data valid but below operational range Brakes J1939 Engine Communications -OR- J1939 Invalid Data (Engine/Retarder) -OR- J1939 Supply Pressure -OR- J1939 Electronic Stability Program (ESP) Messages Invalid Data -OR- Invalid Data From Transmission -OR- Timeout or invalid data on ETC7/VP15 (for Hill Start Assist (HSA) function) -OR- Timeout or invalid data on XBR -OR- J1939 Hill Start Assist (HSA) switch error or unavailable -OR- Timeout or Invalid data for Electronic Stability Program (ESP) AWD operation (Flash Code 11-10 or 11-12 or 11-13 or 11-3 or 11-4 or 11-5 or 11-6 or 11-7 or 11-8) Brakes Drive Axle - Left Wheel Speed Sensor Open or Shorted (Flash Code 4-3) PID 37 1 1 SID 231 2 2 SID 3 2 16 Brakes Stop Lamp Switch Defective (Flash Code 12-2) SID 55 2 N/A Page 2 of 5
Fan Connection, engine - Abnormally high voltage or Stepper Motor, phase 1 - Abnormally high voltage or Stepper Motor, phase 2 - Abnormally high voltage or Stepper Motor, phase 3 - Abnormally high voltage or Stepper Motor, phase 4 - Abnormally high voltage or Pressure Sensor, Refrigerant, high pressure side - Abnormally low voltage or short-circuit to lower voltage 5 volts supply to the sensor - Abnormally low voltage or short-circuit to lower voltage SID 15 3 3 SID 16 3 3 SID 17 3 2 SID 18 3 1 SID 19 3 2 SID 22 4 3 SID 232 4 3 J1708 Data Link - Abnormal update rate SID 250 9 2 Stepper Motor, Fresh Air and Recirculation - Abnormally low voltage or short-circuit to lower voltage Engine Intake Manifold Pressure - Data erratic, intermittent or incorrect Engine Coolant Level - Data valid but below normal operational range (Most severe level) Engine Transmission Oil Temperature - Data valid but above normal operating range (Most severe level) Engine Engine Exhaust Gas Recirculation Differential Pressure - Mechanical system not responding or out of adjustment Engine NOx Sensor - Voltage above normal or shorted to high source SID 5 4 1 PID 102 2 1 PID 111 1 116 PID 177 0 1 PID 411 7 2 PPID 270 3 N/A Engine NOx Sensor - Current below normal or open circuit PPID 270 5 37 Engine Data Link, MID 130 - Abnormal update rate PSID 205 9 4 Engine Accelerator Pedal 1 Idle Validation Switch - Voltage above normal or shorted to Engine - Vehicle Mgt System J1708/1587 Data Link - No data received from J1708/1587 Data Link Instrument Cluster Battery Voltage - Abnormally low voltage or short circuit to lower voltage Instrument Cluster Forward Rear Axle Temperature - Abnormally high current or short circuit to ground Instrument Cluster Rear Axle Temperature - Abnormaly high current or short circuit to ground SID 230 3 1 SID 250 9 N/A PID 158 4 4 PID 77 6 N/A PID 78 6 N/A Instrument Cluster Data Link, MID 232 - Bad intelligent device or component PSID 235 12 12 Page 3 of 5
Turn signal lamp left front - Current below normal or open circuit Turn signal lamp right front - Current below normal or open circuit PSID 13 5 2 PSID 14 5 4 Low Beam, Left - Current below normal or open circuit PSID 2 5 1 Background lighting dashboard - Current above normal or grounded circuit PSID 20 6 6 Data Link, MID 128 - Abnormal update rate PSID 200 9 3 Data Link, MID 144 - Abnormal update rate PSID 201 9 3 Data Link, MID 136 - Abnormal update rate PSID 204 9 17 Data Link, MID 130 - Abnormal update rate PSID 205 9 2 Power supply 1 - Voltage above normal or shorted to Power supply 2 - Voltage above normal or shorted to Power supply 3 - Voltage above normal or shorted to Power supply 4 - Voltage above normal or shorted to Power supply 5 - Voltage above normal or shorted to Power supply 6 - Voltage above normal or shorted to PSID 34 3 1 PSID 35 3 1 PSID 36 3 1 PSID 37 3 1 PSID 38 3 1 PSID 39 3 1 Low Beam, Right - Current below normal or open circuit PSID 4 5 1 Power supply, ignition key in driving position - Voltage below normal or shorted to low source Turn signal lights/error code - Bad intelligent device or component Dimmer, instrument lighting - Voltage below normal or shorted to low source SAE - J1939 Data Link - Data erratic, intermittent or incorrect The Light (LCM) cannot interpret information through the SAE J1587/1708 data link Transmission module, Battery Voltage - Data valid but below operational range PSID 40 4 7 PSID 41 12 1 PSID 42 4 33 SID 231 2 15 SID 250 2 N/A PID 158 1 1 Page 4 of 5
Transmission Clutch load on plate - Data valid but above normal operational range - Most severe level PPID 50 0 11 Transmission Clutch load on plate - Root cause not known PPID 50 11 2 Transmission Data Link, MID 136 - Abnormal frequency, pulse width, or period PSID 204 8 88 Transmission Data Link, MID 136 - Abnormal update rate PSID 204 9 25 Transmission Data Link, MID 216 - Abnormal update rate PSID 210 9 20 Transmission Split Engagement System - Data valid but below normal operational range - Most severe level PSID 23 1 2 Transmission Clutch System - Special instructions PSID 27 14 1 Transmission Clutch System - Abnormal frequency, pulse width, or period PSID 27 8 5 Transmission J1587 Data Link - Abnormal update rate SID 250 9 N/A Data Link, MID 128 - Abnormal update rate PSID 200 9 8 Data Link, MID 130 - Abnormal update rate PSID 205 9 63 Gear Selector Position - Bad intelligent device or component PSID 9 12 43 J1939 Data Link - Data erratic, intermittent or incorrect SID 231 2 55 J1587 Data Link - Abnormal update rate SID 250 9 23 Vehicle ECU Vehicle Speed - Intermittent or incorrect data PID 84 2 68 Vehicle ECU J1939 Data Link, MID 130 - Abnormal update rate PSID 205 9 50 Vehicle ECU Data Link, MID 223 - Abnormal update rate PSID 207 9 1 Vehicle ECU Software Error - Voltage below normal or shorted to low source PSID 230 4 3 Vehicle ECU Software Error - Current below normal or open circuit PSID 230 5 3 Vehicle ECU J1939 Data Link - Intermittent or incorrect data SID 231 2 2 Page 5 of 5