Selection SELECTION CRITERIA Mechanisms, usually subject to small MEDIUM loads but rather often to maximum loads HEAVY VERY HEAVY The average operating time per day of the hoist is to be calculated in the in the following manner: 2 x H x N x T 2 x x x Tm = = = 3. hours x V x F the "medium" load spectrum and average operating time per day of 3. hours the group "" is shown in table "LOAD SPECTRUMCLASS OF OPERATING TIME". F loading capacity of kg and reeving the type of the hoist MHM " MH " is shown in table 1 TYPE SELECTION". % max. load. 1.2.. 1 1 Am M 3 % operating time % operating time Mechanisms, usually subject to maximum almost maximum loads % operating time Mechanisms, usually subject to medium loads but frequently maximum loads 33 % max. load LIGHT Mechanisms, usually subject to very small loads and in exceptional cases only to maximum loads % max. load kg m m/min medium hours average operating time per day Tm in hours DEFINITION SELECTION EXAMPLE Loading capacity Average lifting path of the hook (H) Hoisting speed (V) Reeving Load spectrum Cycles per hour (N) Average operating time per day(t) Class of Operating Time Load Spectrum (Duty operation mode) % max. load To choose the right hoists the following criteria should be taken account: 1. What will be the maximum loading capacity? 2. What will be the maximum lifting height? 3. What hoisting speed is to be employed?. Will an auxiliary reduced lifting speed be required?. What will the operational conditions be?. What will the travelling speed be, if required?. How do you need to operate the hoists? The type of the hoists is to be defined in accdance with the load spectrum, the average operating time per day in hours, the loading capacity and the reeving. 9 % operating time GROUP DIN / FEM 9. GROUP ISO 31 Type Selection CAPACITY, kg REEVING SERIES 3 MH 3 MHM MH 2 MHM 3 3 MH 2 3 3 SIZE MH 3 MHM MHM MH 3 MHM MHM MH 3 MHM MHM MHM MH MH 3 MHM MH MHM MH MHM MH MH MH MH MH MH 2 MH 2 MH 32 MH MH 3 2 Tel. +39 2 9 33 9; Fax +39 2 9 3 9; email: mail@bcp.bg; http: \\www.bcp.bg 9 Balkancarpodem Ltd. All rights reserved. MH MH 3
Type selection Table 1 Capacity, kg Type DIN ISO 31 FEM 9. REEVING Size of drums 1 2 3 Lifting speed, m/min V1 V1/M1 V2 V2/M2 / / / / Lifting height H, m MH 3 MHM MHM MHM MHM MH 3 MHM MHM MHM MHM MHM MHM,, 2, 1 2,, 31, 2,, 2, 1 2,, 31, 2,, 3, 91,,,, 39,,, 9, 13 2 3, 1 / M MH MH 3 2 MH 3 MH 3 M MH 3 / / M MH MH 3 MHM MHM M MH 3, MHM, MHM 3, MH 91, MHM, MHM /2 /2 / / /2 /2 / / MH 39,,, MH 3 9, 13 2 3 MHM, 1 MH 3, MHM, MHM () () (2) 3, (2), (,) 9 (1), () 3 (), (91,) 22 2, 3, 3, MHM MHM MH M MHM MH 9 Balkancarpodem Ltd. All rights reserved. BALKANCARPODEM Ltd Sofia, Bulgaria; 1, Kliment Ohridski Blvd.
Table 1 cont d Capacity, kg Type DIN ISO 31 FEM 9. REEVING Size of drums 1 2 3 Lifting speed, m/min V1 V1/M1 V2 V2/M2 / / Lifting height H, m MHM MH () () (2) 3, (2), (,) 9 (1) 3 (), (91,), () 22 MHM MH MH 3 MHM MHM MH MH 3 2, 3, 3, 9, 13 2, 1, 2 33, 3, 9,, 23 2, 13, 1 /2 M MH MH 3 M MHM /2 /2 /2 /1 MHM 2, MH (), () 33 (3) (2,) 1 (9,) 1 (1) / /, (,) (92) / / / MH M MH, / 31 39, / / /2 /2 /1 / / /2 /2 / /2 /2 MH, 1, 2 MH 33, 3, MHM 9,, 23 2, 13, 1 MHM MH MH 3 MHM MHM MH 2 2, 1. (), () 33 (3) (2,) 1 (9,) 1 (1), (,) (92), 31 39, () () (13,) (21) 23 (2), (3,) 31, (3) 3, (,) MH 2 MH 2 MH 2 2 MHM MH 2, M MHM, 1, (,) (2) 33, (3), (2), () 9, (9,), 3, () () (13,) (21) 23 (2), (3,) 31, (3) 3, (,) MH MH 32 MHM 3 MH 2, MHM, 1,, 13, 9,, MH MH 3 MHM M MH Tel. +39 2 9 33 9; Fax +39 2 9 3 9; email: mail@bcp.bg; http: \\www.bcp.bg 9 Balkancarpodem Ltd. All rights reserved. /1
Table 1 cont d Capacity, kg Type DIN ISO 31 FEM 9. REEVING Size of drums 1 2 3 Lifting speed, m/min V1 V1/M1 V2 V2/M2 / /2 /2 /1,,/3,2 /2 /2 /1 Lifting height, m MH (,) (2) 33, (3), (2), () 9, (9,), 3, (,) (), (2) 2, (,) 3, (3,) 33 (3) (),, MH MH MHM (,) (2) (,) MH M MH 9,, 33, (3), (2), () 9, (9,), 3, (), (2) 2, (,) 3, (3,) 33 (3) (), 9 MH MH, MH 2 MH 2, MHM, (,), (,), (1) (,) 13, (,), 1, () MH 2 MH 2 9, M (,) (2) 33, (3), (2), () 9, (9,), (,) (1), (2) 2, 3, (39,), (,), (,), (1) (,) 13, (,), 1, () MH 32 3, (,) (1), (2) 2, 3, (39,) () (9,) (13), () (,), (23) MH,,/2, /2 MHM MH MH MH 3 /1 /2 /1 MH M, (,) (1), (2) 2, 3, (39,),3,3/1,,3,3/1, () (9,) (13), () (,), (23) /1, (,) (1), (2) 2, 3, (39,),2,,3 (13) 1 (,) (,) MH MH MH 2 MH 2 MH 3 MH 32 (9,) MH (9,) (13) 1 (,) (,) MH 1, 3,2 3,2/, 2 MH 3 1, 2, 2,/, 2,2 2,2/, 3 MH 1Bm M3, 9, 1 1) The data given in brackets are to be considered f wire ropes with high strength and smaller diameter. 9 Balkancarpodem Ltd. All rights reserved. BALKANCARPODEM Ltd Sofia, Bulgaria; 1, Kliment Ohridski Blvd.
Type designation EK N / MH 2 H V/,9 V/,9 Lifting speed /,9 m/min H Lifting height m Reeving 2 Drum s hoisting fce 2 kn Series MH Type of wire rope electric hoist MH MHM Type of wire rope electric hoist MHM / Travelling speed / m/min N Mail trolley with standard headroom K Mail trolley with reduced headroom D Double rail trolley EK Electric trolley RK Hand geared trolley SK Push travel trolley Please give the following data when placing der: voltage V frequency Hz voltage V frequency Hz load limiter emergency stop thermal protection latchkey. Climatic modification rmal NII tropical TII marine execution travelling speed m/min rail width b mm runway radius m travelling speed m/min rail distance rail b x h 1. Power circuit 2. Control circuit 3. Required. Mail trolley. Double rail trolley mm x mm x mm Travelling speeds Speed (m/min) Trolley one speed EK N EK K EK D two speeds 32 3 / / 32/ 1) Valid f fixed suspension only, without load limiter. /3 / / 2) Standard travelling speed m/min. / / / Tel. +39 2 9 33 9; Fax +39 2 9 3 9; email: mail@bcp.bg; http: \\www.bcp.bg 9 Balkancarpodem Ltd. All rights reserved.
Description of the electric hoist Hoisting mot Electric mot with conical rot and conical stat as well as asbestos free conical brake. Easy axial moving possibility of the rot. Reliable brake activation from spiral spring impact in case of electric power breakdown. Creep speed of the mot. The wide range combinations of mots and gear units expand the range of available goods and lifting speeds. Gear unit Twostage heliocentric gear unit assembled to opposite side of the mot. High quality materials are used. Suitable hardening and grinding of gear wheels teeth surfaces ensures their long life, iseless operation and high coefficient of gear unit's efficiency. Drum Equipped with helical grooves f the wire rope and efficacious rope guide, which ensures reliable arrangement of the rope in drum's grooves. The front mot flange by means of ball bearing suppts one of the drum's diaphragms. The tque from the gear unit to the second drum's diaphragm is transmitted through grooved hollow shaft. Rope guide New made construction. No special tools are required f the replacement of the rope guide. Ensures precise rope winding and unwinding. Possibility f rope deviation ±. Actuates the end limit switch in upper and bottom position of the hook. Blockhook The block hook and the purchase block are entirely new constructions, cresponding to the modern technical safety requirements. Ensures easy operation with minimum dead weight. Protection against the rope getting out of the rope rolls is also ensured. Body The body is completely new construction in box fm. Represents a robust welded construction as a flange connection between the mot and gear unit. Wire rope's outlet in all possible radial directions permits the realization of different assembly versions and positions. Rubber packed coupler This is flexible coupler as a joint unit between the hoisting mot and gear unit. The coupler wks as a shock absber and ensures resistance free mot's shaft axial replacement. Sure connection between the mot and the gear unit is warranted. 9 Balkancarpodem Ltd. All rights reserved. Trolleys Three types of trolleys are available: mail trolley with standard headroom, mail trolley with reduced headroom and double rail trolley. The hoist is hanged up mounted to the trolley in the best position, ensuring optimum load distribution on the travel wheels. The trolley could be also electric, hand geared push travel. Drive unit the same type as a main unit of the hoist powers the electric trolley. Nmal drive unit with electromagnetic brake is available. The traveling speeds are in very wide range. Stage less fitness in accdance with the width of the mail traveling track is submitted to crect wk of the trolleys. In case of double rail trolley the purchaser gives the rail's distance. Electric equipment Power circuit voltage and frequency are at purchaser's request. Control voltage to relays and contacts is 2V, frequency and Hz. The most part of electric equipment is assembled in command box, fastened to the body to other appropriate part. Terminal box of the mot holds end limit switch. BALKANCARPODEM Ltd Sofia, Bulgaria; 1, Kliment Ohridski Blvd.