SUZUKI MODULAR INSTRUMENT SYSTEM (SMIS) uses an easy to connect and expandable cable system to transmit graphic and numerical data to Multi-Function gauges. Easy to set up and install system can be used with nearly any boat and DF00 SUZUKI Outboard. Connected to the NMEA000R compatible system, the gauges can display real-time readings from compatible electronic probes and the exclusive SMIS engine interface to monitor all engine functions. (Engine Monitor with gauge only) SUZUKI MODULAR INSTRUMENT SYSTEM APPLICABLE MODELS model engine number applicability DF00T 000F-000~ Available DF00Z 000Z-000~ Available DF0T 00F-000~ Available DF0Z 00Z-000~ Available DFT 0F-000~ Available DFZ 0Z-000~ Available DF00T 000F-000~ Available DF00Z 000Z-000~ Available DFT 0F-000~ Available DFZ 0Z-000~ Available DF0T 00F-000~ Available DF0Z 00Z-000~ Available DF0T 00F-000~ Available DF0Z 00Z-000~ Available DFT 0F-000~ Available DFZ 0Z-000~ Available model engine number applicability DF00 000F-000~ Available DF0A 000F-000~ Available DF0A 000F-000~ Available DF0A 000F-000~ Available DF0A 000F-000~ Available DF0A 000F-000~ Available DF0A 000F-000 Available DF 00F-000~ Not available DF 00F-000~ Not available DF.A 00F-000~ Not available DFA 000F-000~ Not available DF 000F-000~ Not available DF 000F-000~ Not available DF 000F-000~ Not available DF. 00F-000~ Not available SUZUKI MOTOR CORPORATION reserves the right to add any improvement to change the design or to discontinue any item at any time without notice. Some items might not be compatible with local standards or statutory requirements. Please check with your local AUTHORIZED SUZUKI DEALER for details at the time of ordering. Acutual colors might differ from those appearing in this catalogue. c 00 SUZUKI MOTOR CORPORATION. All rights reserved. March 00. Part number: 000-N-0 00 TAKATSUKA, MINAMI, HAMAMATSU, JAPAN
SMIS MULTI-FUNCTION GAUGE & OPTIONAL INSTRUMENT TRIM SMIS MULTI-FUNCTION GAUGE The multi-function gauge uses a state-of-the-art high-contrast, dot matrix display to monitor real-time graphic and numerical digital data. When connected into the SMIS system, it can monitor all engine functions, act as a speedometer, tachometer, GPS*, and many others. (*GPS requires additional hardware.) The multi-function gauge is capable of all functions of the gauge except engine monitoring functions. When connected to the SMIS system, it a can be programmed to monitor all other functions. Examples of display** Examples of display** Engine trim page as a trim gauge for single engine Fuel manager page as a fuel gauge as a volt meter for single engine analog page as a tachometer for single engine Dual digital page as a hour meter and a speedometer for single engine Fuel manager page Quad analog page as a tachometer, a volt meter, a water-pressure gauge and a speedometer for single engine " SMIS Multi-Function Gauge 00-L00-000 with a gray bezel + a T-connector (-L00-000) +Operation & Installation Manual analog page as a speedometer Diagnostics page Fuel manager page " SMIS Multi-Function Gauge 00-L00-000 with a gray bezel + a T-connector (-L00-000) +Operation & Installation Manual ** The detail instructions of display-operation are explained in the Operation & Installation Manual. Engine trim page as a trim gage for single engine Gauge Kit (" Gauge Kit 0-L00-000, " Gauge Kit 0-L0-000) Available for your covenience. Refer to the following chart for the contents. Contents part name part number quantity Gauge Kit 0-L00-000 Gauge Kit 0-L0-000 *** *** SMIS Multi-Function Gauge 00-L00-000 - - SMIS Multi-Function Gauge 00-L00-000 - - Terminator Female -L00-000 - - Terminator Male -L0-000 - - Extension Cable feet -L00-000 - - Engine Interface unit -L00-000 Power Cable -L00-000 Operation & Installation Manual for Gauge - - - Operation & Installation Manual for Gauge - - - ***Quantity of T-connector(s) in a kit OPTIONAL INSTRUMENT TRIM Change the standard gray bezel to suit your application. Two different bezel finishes are available for or Multi-Function gauges. " bezel, chrome -L00-000 " bezel, white -L0-000 " bezel, chrome -L0-000 " bezel, white -L0-000
ENGINE INTERFACE & POWER CABLE & CONNECTION CABLE & CONNECTION HARDWARE ENGINE INTERFACE The most important part of the SMIS data system. DF00 of SUZUKI outboards can connect to the system, using Engine Interface Adapter. POWER CABLE The fused (A) lead connects the extension cable to the power source. CONNECTION HARDWARE T-Connector -L00-000 T-connectors link all compatible cables, data and sensor devices, and can be easily secured. Engine Interface Unit with a T-connector -L00-000 SMIS Power Cable with a T-connector -L00-000 Terminator Female -L00-000 0-ohm terminators are required for any open cable ends in the system. Engine Interface Adapter -J0-000 for single DF00 engine only Engine Interface Adapter -J0-000 for dual DF00 engine only Power Node with a T-connector -L0-000 Allows network to be powered from multiple power sources (key switch, accessory switch, etc...). For multiple ( or ) engines of DF0-0 only CONNECTION CABLE The extension cable is the mainline of SMIS. Data communication runs the length of the boat, capped at each and with a 0-ohm terminator. NMEA000 compatible sensors or other devices can be added by the use of T-connectors throughout the system. Terminator Male -L0-000 0-ohm terminators are required for any open cable ends in the system. Adapter to N network -L00-000 (Black network to Blue devices) Allows connection to other NMEA devices (Device NET). Engine Interface Adapter -J0-000 for triple DF00 engine only Extension Cable -L0-000 feet -L0-000 feet -L0-000 feet -L00-000 feet Adapter to L network -L0-000 (Blue network to Black devices)
SENSORS Speedometer-sub kit 0-J0-000 Applicable model: DF0A-0A/00 Fluid Level Sensor with a T-connector 0-L00-000 Monitors the fluid levels such as fuel, live well water level. etc. 0ft cable. Speed Sensor with a T-connector 0-L00-000 Paddle wheel-type speed sensor. 0ft cable. Contents: Part Number Qty/Kit Speedometer sender 0-00-000 Speedometer-hose union -D00-000 Hose Clamp (L: 00 mm) 00-00-000 Use Speedometer sender (0-00-000) in case that the integrated sender cannot detect a proper boat-speed. Water Temperature Sensor with a T-connector -L00-000 Surface-water temperature sensor. 0ft cable. Water Pressure Sensor with a T-connector 0-L00-000 Water Temperature Sensor with a T-connector -L0-000 (Thru-Hull type) GPS Receiver Module with a T-connector 0-L00-000 Displays the accurate location and speed on multi-function gauges. Water-pressure-sensor kit 0-J0-000 Applicable model: DF0A-0A/00 This kit can be installed as a water pressure sensor or as a speed sensor. The detail is described in the installation manual, which is contained in the package. Quantity Contents: used for in KIT water-pressure used for sensor speed sensor Sensor Connector Bolt Clip -way - Water-pressure hose (00mm) - Cap -
Example of Connection for DF00 with SMIS Multi-Function Gauge (in case of equipping the same quantities of and gauges as engines and stations, and all optional items) NOTE: (*): Quantity of T-Connector(s) -L00 in a package. (*): The required or recommended quantities are shown. Numbers in round-parentheses show the required ones if equipped. (*): While some of SMIS items have a T-connector in a package, the total of the T-connectors coming with them does not always satisfy the required quantity. category Ref. # part name (*) engine(s) part number Contents of station(s) Gauge Kit total st nd total st nd total st nd required quantity per boat (*) SMIS multi-function gauge SMIS Multi-Function Gauge with a gray bezel 00-L00-000 Gauge Kit KIT 0-L00-000 SMIS Multi-Function Gauge with a gray bezel 00-L00-000 Gauge Kit KIT 0-L0-000 engine interface Engine Interface unit -L00-000 Engine Interface Adapter for single DF00 engine only 0 -J0-000 Engine Interface Adapter for dual DF00 engine only 0 -J0-000 Engine Interface Adapter for triple DF00 engine only 0 -J0-000 power cable Power Cable -L00-000 connection cable Extension Cable feet 0 -L0-000 Extension Cable feet 0 -L0-000 Extension Cable feet 0 -L0-000 Extension Cable feet 0 -L00-000 connection hardware T-Connector (*) (*) (*) 0 (*) (*) (*) (*) 0 -L00-000 Terminator Female 0 -L00-000 Terminator Male 0 -L0-000 Adapter to N network (Black network to Blue devices) 0 -L00-000 Adapter to L network (Blue network to Black devices) 0 -L0-000 sensor Fluid Level Sensor () () () () () () 0-L00-000 Speed Sensor () () () () () () 0-L00-000 Water Temperature Sensor () () () () () () -L00-000 Water Temperature Sensor (Thru-Hull type) () () () () () () -L0-000 Water Pressure Sensor () () () () () () 0-L00-000 GPS Receiver Module () () () () () () 0-L00-000 optional trim bezel, chrome ( pieces in one package) 0 -L00-000 bezel, white ( pieces in one package) 0 -L0-000 bezel, chrome ( pieces in one package) 0 -L0-000 bezel, white ( pieces in one package) 0 -L0-000 SINGLE ENGINE OF DF00 DUAL ENGINE OF DF00 TRIPLE ENGINE OF DF00 From Master BCM From Master BCM From Master BCM : :
Example of Connection for DF0-0 with SMIS Multi-Function Gauge (in case of equipping the same quantities of and gauges as engines and stations, and all optional items) category Ref. # part name (*) engine(s) part number Contents of station(s) Gauge Kit total st nd total st nd total st nd required quantity per boat (*) SMIS multi-function gauge SMIS Multi-Function Gauge with a gray bezel 00-L00-000 Gauge Kit KIT 0-L00-000 SMIS Multi-Function Gauge with a gray bezel 00-L00-000 Gauge Kit KIT 0-L0-000 engine interface Engine Interface unit -L00-000 power cable Power Cable -L00-000 0 Power Node for multiple engine of DF0-0 only -L0-000 connection cable Extension Cable feet 0 -L0-000 Extension Cable feet 0 -L0-000 Extension Cable feet 0 -L0-000 Extension Cable feet 0 -L00-000 connection hardware T-Connector (*) (*) (*) 0 (*) (*) (*) (*) 0 -L00-000 Terminator Female 0 -L00-000 Terminator Male 0 -L0-000 Adapter to N network (Black network to Blue devices) 0 -L00-000 Adapter to L network (Blue network to Black devices) 0 -L0-000 sensor Fluid Level Sensor () () () () () () 0-L00-000 Speed Sensor () () () () () () 0-L00-000 Water Temperature Sensor () () () () () () -L00-000 Water Temperature Sensor (Thru-Hull type) () () () () () () -L0-000 Water Pressure Sensor () () () () () () 0-L00-000 GPS Receiver Module () () () () () () 0-L00-000 optional trim bezel, chrome ( pieces in one package) 0 -L00-000 bezel, white ( pieces in one package) 0 -L0-000 bezel, chrome ( pieces in one package) 0 -L0-000 bezel, white ( pieces in one package) 0 -L0-000 SINGLE ENGINE OF DF0-0 DUAL ENGINE OF DF0-0 TRIPLE ENGINE OF DF0-0 NOTE: (*): Quantity of T-Connector(s) -L00 in a package. (*): The required or recommended quantities are shown. Numbers in round-parentheses show the required ones if equipped. (*): While some of SMIS items have a T-connector in a package, the total of the T-connectors coming with them does not always satisfy the required quantity. PORT STBD PORT CENTER STBD 0 0 : :