Air Cleaner 1501.3 Anchor, Clutch 1701.2 Arm Clutch w/bearings 1081-4 1.0 562-2 1.0 Arm Deck Lift 1105-1.5 Arm Idler Mule Drive 1504-8.5 1104-8.4 Arm Idler Pump / Trans. 334.5 1036.5 529-3.5 1103-5.7 1702.3 Spring Anchor Pin 1703.2 Arm Idler Pump HP 563-3.8 Arm Pump Control 316-1 1.5 508-1 1.5 1502-1.3 1102.3 1704.4 Arm Weldment Wheel Drive 1075.3 Axle 1002-6 1.0 Bearings (each) Brake, Flange 1108.3 Control Arm 302-1.3 501-1.5 Motion Control 1109-2.3 Steering Fork / Rear 1507-3.3 Trans Shaft / PTO 1006-1.5 1503.5 Wheel / Drive 1005-1.3 1506.3 Rear Cross Shaft 1705.3 Bell Crank 304.5 1007.5 Belts Alternator 1577-1.5 1177-1.5 Belt Guide 309.3 1013.3 558-2.3 1205.3 Blade / Mule 305.5 1008.5 502-2.5 1510-2.5 1110-1.5 Blade / Right 307.3 1009.3 Clutch HP 1076-1.5 560-2.5 Pump / Transmission 306-1.5 1010.5 503-1.5 1560.3 1111-2.5 1706.2 Pump HP 559-2.8 1179.8 Wheel Drive / Drive Set 1011-1.2 1559-4.7 Blower Bearings 1508-1 1.2 Blower Cover 1509-1 2.3 Blower Housing w/ Bearings 1510-1 2.0 Blower Impeller 1511-1 2.4 Blower Sheave 1532-1.5 Bottle Coolant 1185.3 Brake Band 1015-3.5 561.3 1533.8 1112-3.5 Bracket / Arm 1014-3.3 1113-3.8 Cable 1707.3 Caliper 1708.2 Mount Plate 1709.2 Bracket -Motion Control 1115-2 1.0 1710.5 Threaded Hub 1711.5 UHT Anchor Cable 1712.4 Bushings - Drive Levers 311.3 1019.3 504.3 Fuel tank 1713.2 Panhard Rod Assy 1714.2 Motion Control Flange 1715.6
Choke Cable 506.5 1515.5 1118.5 1716.5 Console, LH Narrow Assy 1717.3 Console, RH Narrow Assy 1718.4 Console, Panel w/decal 1719.6 Cover-Motion Control 1720.1 Cylinder Rebuild 1517 1.3 Damper 1502.3 1119.3 1721.2 Deck Anti-Scalp / Roller 1000.1 840-1.1 1614.1 1200-5.1 1722.1 Bearings -Castor Wheel 301-4.3 1003-4.3 841-2.2 1606.3 1106.3 1723.3 -Cross Shaft 1724.3 -Cutter Housing 303-2.5 1004-2.5 842-3.5 1201-4.5 1725.3 -Jack Shaft 1202-1.5 1726.3 Strut 1107.3 Belts Deck / Drive 305-1.5 1008.5 845.5 1603-3.5 1203-3.5 1727.3 Belt/Gear Box Cover 308.3 1012.3 846.2 1602.2 1728.1 Belt Cover Wireform 1729.1 Bushings Castor Wheel 301-4.3 1016-4.3 848-2.2 Bushings Deck Frame 1078.3 849.2 1612.2 Bushings Support 313.3 1017.3 847-4.2 1607.3 Castor Strut / Fork 314.3 1020.3 852-4.2 1617.3 1117.3 1730.3 Castor Support 315.3 1021.3 Cross Shaft Assy Rear 1731.7 Cross Shaft Bearing Support 1732.2 Cutter Housing Sub Assy 317-2.5 1022-2.5 853-3.5 1607-4.5 1207-4.5 1733.5 Cutter Housing w/spindle 1734.5 Deck / Complete Assy 1735 1 Deck Lift -Adjuster 1736.2 Deck Lift -Front Assy 1737.7 Deck Lift -Trunnion 1738.3 Deck Shell 318 2.5 1024 2.5 856 2.5 1601 1.5 1200-9 2.5 1739 2 Deck Support Frame 1079.8 857.8 1620 1.0 1120-9 2.5 Discharge Chute Assy 1740.1 Discharge Chute Bracket 1741.2 Discharge Chute 1742.1 Discharge Tube 1638.5 Floorpan 1743.1 Foot Pedal 1744.2 Gearbox 1625-1.7 -Gear Left 1626-2.4 -Gear Right 1627-2 1.5 -Input Pinnion 1629-1.7 -Connector Tube 1630-1 1.5 -End Assy 1631-1 1.2 -Center Assy 1632-1 1.5 -Out Put Cap 1633-2.7 -Seal Kit 1628-2.9 Height of Cut Assy 1745.5 -Pin 1746.1
-Grommet 1747.2 -Pawl, Transfer Lock 1748.2 -Rod, Transport Lock 1749.4 -Spring 1750.1 Idler Arm Assy 326.3 1032.5 861-6.5 1608-2.5 1208-2.5 1751.5 Idler Pulley 336.3 1038.3 862.3 1529.5 1210.3 1752.3 Jack Shaft Assy./Housing 1524.7 1209-1.8 Misc. 865 1211 1753 -- Misc. Weld 866 1212 1754 -- PTO Guard 1605.5 PTO Drive Shaft 1636-7.5 PTO Shaft U-Joint 1637-7.5 Pin Weld 1213-4.3 Pulley Cutter 351-2.5 1053-2.5 867-3.3 1614-4.5 1214-4.3 1755.3 Pulley Jack Shaft 1215-1.5 Rod Deck Lift/Deck Lock 1611.3 1155-6.5 Rod End Spherical/Pivot 1610.5 1216-3.4 Spindle Shaft 319-2.5 1074-2.5 869-3.5 1617-4.5 1217-4.5 1756.5 Spring Deck 360-1.3 1088.3 870.3 1618-3.3 1218-3.3 1757.3 Spring Deck Support 1608.3 1161-6.7 Striper Bearings 950.3 950.3 950.3 Strut Weldment 1219-3.5 1758.3 -Bushing 1759.2 Support Link Rear 1087.3 868.3 1604.3 Support Rod HP 1080.4 859.4 Tube Discharge 1603.5 Engine Deck 320 2.5 1025 2.5 521 4.5 1533-1 1133 5.0 Extension / Crank / Fan 1586-5 1.3 1186-5 1.3 Electrical Actuator/Cylinder 1514.8 Alarm 1540.5 Alternator 1176-1.5 Battery 1026-1.5 509.5 1523.5 1123.5 1760.5 Clutch 511-2 1.0 1524-0 1.0 1124-0 1.0 1761 1.0 Clutch Pigtail 511-3.5 1524-1.5 1124-1.5 1762 Fuse 1763.2 Harness 325.8 1031.8 513.5 1550 1.5 1121 1.5 1764 1.5 Harness Console 512.8 Hour Meter 515.5 1542.5 1125.5 Hour Meter/Fuel Assy-NLZ 1765.3 Ignition / On / Off 1030.3 516.5 1526-1.5 1126.5 1766.2 Plug Cap 1767.2 Module / Interlock 322.5 1027.5 517.5 1543.5 1127.5 Relay 1549.5 1187.5 1768.2 TVS Diode 1837.2 Switch Blade 321.3 1026.3 510.3 1529-1.5 1129.5 1769.2 Brake 1130.5 1770.2 Deck Lift 1545.5 Drive Lever 1544.5 1131.5 1771.2
Fan / Radiator Sensor 1585-2.3 1185-2.3 Hood Engine Assy 1579-1.5 1179-1.8 Neutral/Normal Open 323.3 1028.3 518.3 1547.5 OPC 324.3 1029.3 519.3 Seat 1546.5 1132.5 1771.2 Solenoid 520.5 1128.5 Tilt 1548.5 1176.5 Troubleshooting 390.5 1090.5 590.5 1541.5 1190.5 1772 -- Fan Cooling Elec/XP 1178-2 1.3 Fuel Gauge 1534-1.3 1134-2.3 Fuel Line 1535.3 1135-1.5 1773.3 Fuel Tank 327-7.5 1033-7.5 522-7.5 1534.5 1134.5 1774 1 Cap 1775.1 Cover, Plastic 1776.1 Fitting w/line & Screen 1777.2 Gasket 1778.2 LH Vent Tube 1779.6 Sender w/gasket & Tube 1780.3 RH Vent Tube 1781.6 Vent Manifold 1782.5 Vent Drain Tube 1783.3 Fuel Valve 328-7.3 1034-7.5 523-7.5 1535.3 1135.5 1784.3 Gauge Temp / Volt 1581-1.5 1181.5 Guard Engine 1136.3 Handle Assembly / Motion 329.8 1035.8 524 1.0 1538.3 1138.1 1785.1 Grip 1786.2 Handle -Brake 1014-3.3 1537-1.3 1137.3 1787.5 Brake Release Rod 1788.2 Grip 1789.2 Bypass Valve 1790.2 Spring, Compression 1791.2 Washer, Special 1792.2 Heat Shield 1175-1.5 Hopper 1580 1.7 Arm/Fill Sensor 1583-1.4 Bumper 1581.1 Dampner/Braces 1582.3 Defector/Diffuser 1584.8 Door/Hopper 1585 1.0 Handle 1590.1 Hopper Complete 1587 1.7 Motor 1586-1.7 Screen 1589.3 Shock Door 1588.3 Shock Hopper 1591.3 Hose Engine oil Drain 1793.2 Hydraulics Aux Power Motor 1559 1.0 Dipstick 1794.1
Filter Head 333-1.5 528-1.5 1550.5 1142.5 Gasket 357 1.0 545 1.0 1554-1 2.5 1153 2.5 Guard / Assy 1795.3 Hose / Pump to Motor 330-1.5 525-1.5 1551.5 1140.5 Hoses / Low 331-1.5 527-1.5 1552.5 1139.5 Fan 1795.2 Filter 1796.2 Reservoir 333.5 528.5 1553.5 1143.5 Reservoir - Flush 380.5 580.5 1580-1.5 1180.5 NLZ Cradle 1797.5 Pump Inspec/ Flow Test 359.5 547.5 1556-1.5 1153-1.5 Pump Repair 1555-1 3.0 1155-1 3.0 Pump Replacement 355-1 1.5 543-1 1.5 1552-1 2.0 1152-5 2.0 UHT, NLZ Tranny 1798 1.0 XP Aux. Pump 1179-1 1.3 Seal 358-1 1.0 546-1 1.0 1555-1 1.0 1154-1 1.0 Wheel Motor 373-2 1.3 556 1.3 1558 1.3 1173-9 1.3 Wheel Motor Seal 374-2 2.0 558 2.0 1574-9 2.0 1174-9 2.0 Idler Pulley Mule / Drive 1522-4.3 1145-8.5 Pump/Short 337.5 530-3.5 1522.7 1146-5.5 1799.4 Transmission/Drive 1039.5 1523 1.0 Wheel Drive 1040.3 Jackshaft Assy 1524.7 Latch Neutral 349.3 1052.3 539.3 Levers Blade 338.3 1041.3 565.3 Brake 1512.5 Deck Lift 1640.3 1147.5 Drive 339.3 1042.3 531.3 1525.5 Motion Control 1800.3 OPC 340.5 1044.5 532.5 Speed Shift Control 341.3 1043.3 533.3 1526.8 Belt Linkage Blade 346.3 1047.5 566.3 Brake/Weldment 1046.3 1513.5 1149.3 Control Arm 342.3 534.3 Deck Lift Link 1801.3 Drive 343.3 1049.3 535.3 Foot Lever 1802.2 Pump 1548-1.3 1148.3 Side Link 1803.3 Speed 345.3 536.3 1527.5 Mainframe 1804 12.00 Rear Guard Plate 1805.3 Panhard Rod Assy 1806.3 Miscellaneous 347 -- 1050 -- 537 -- 1500 -- 1150 -- 1700 -- Miscellaneous Weld 348 -- 1051 -- 538 -- 1500-1 -- 1151 -- 1807 --
Motor Mounts 1507.8 1190-1.5 Muffler 1582.5 1182.7 1808.4 Bracket 1809.2 Exhaust Manifold 1810.7 Guard 1811.1 Pivot with Bushing HP 1083.5 Pulley Brake Drum HP 569-2.5 Brake Drum 1084.4.5 Clutch with Shaft 568-2.8 Engine 352-8.5 1054-9.5 567.5 1528 1.0 1178-5.5 Engine Upper 353-8.8 1055-9.8 541-2 1.0 1812 1.0 Pump 354-1.5 542-1.5 1531.5 1177.5.5 1813.5 Shaft HP 1085-4.8 Transmission/Drive 1056-8.5 1530.5 Wheel 1057-1.4 Hoses Radiator 1505.5 1180-2.5 PTO Brake Spring Assy 1536.8 ROPS 1814 1.0 ROPS-Upper Assy 1815.4 ROPS-Bumper 1816.1 ROPS-Spring Pin Assy 1817.2 Radiator Replacement 1504 1.0 1183-2 1.0 Radiator Repair 1584-2 1184-2 -- Seat 1537.5 1156-7.5 1836.3 Seat Armrest Pad / Set 1818.1 /.2 Seat Back Cover 1819.3 Seat Base Plate 1820.3 Seat Belt 1560-7.3 1160-7.3 1821.3 Seat Bottom Cover 1822.3 Seat Isolator 1823.3 Seat Latch Plate 1824.2 Seat Mount Frame 1538.8 1157-1.5 Seat Rod 1158.1 1825.1 Seat Support Plate 1826.3 Seat Track 1159-7.5 1827.4 Shaft/Jackshaft 1560.5 Spring Drive 360.3 1058.3 549-2.3 1561-4.3 Motion Control Lever 1828.3 Mule 1162-1.3 Pump 361-1.3 549-2.3 1562-5.3 1163-2.3 1829.2 Neutral HP 548-2.3 1164.3 Steering Fork/Rear 1520-3.5 Throttle Cable 364.3 1059.3 552.3 1566-1.5 1166.5 1830.5 Tracking Cable 363.3 Transmission Complete 1060-8 1.3 Output Shaft 1062-5.5 Couplers 1063-5.5
Rebuild 1065-5 2.0 Shift Plate 1064-5.5 U-Joint 1567.8 Wheel Assemblies Drive Complete 370.3 1071-6.5 553.5 1613.3 1167.2 1831.2 Drive Rim 371.8 1072.8 554.8 1565-6.5 1168.5 1832.5 Drive Tire Only 372.8 1074.8 555.5 1563-6.5 1169.5 1833.5 Castor Assembly 366.3 1067.3 872.2 1635.2 1170.3 1834.3 Castor Rim 367.8 873.8 1171.5 Castor Tire 369.8 1069.8 875.8 1172.5 Steering Rim Assy. 1566.3 Hub Drive 374.5 1089-1.5 557.5 1141-9.8 1835.3 Metro 21 and ULTRA VAC/QDS Metro 21 Belt BBC 1331-6 Belt Self Propelled 1330 Blade Rake Assy. 1332-6 Bracket Belt Guide 1303-3 Cable Brake 1304-5 Bracket Control 1305-1 Retainer 1306-5 Throttle 1307-1 Traction 1308-1 Chute Discharge/Door 1309 Cover Rocker 1310 Deck 1333 Fuel Line 1311 Fuel Tank 1312 Grass Bag Frame/Hinge 1313 Handle Bail 1316-2 Bottom 1315 Top 1314-2.4 Height Lever/Adjuster Assy1317-4.5 Lever Shift 1318.3 Miscellaneous 1329 Muffler Guard 1319.3 Pivot Arm 1320-4.3 Pulley Drive (Engine) 1321.8 Pulley 1322-3.3 Shroud 1323.4 Trailing Shield 1324.3 Transmission Internal Repair 1326 1.3 R & R 1325.8 Wheel Assy. 1327.1 Wheel Rebuild 1328.4 Ultra Vac & QDS Description Failure Code Labor Time Bagger Weldment 985-1.5 Bearings ea. 975-1.5 Belt 976-1.5 Chute 987-1.5 Hood Assy. 986-1.5 Housing Weldment 988-1 1.0 Idler Arm 977-1.5 Idler Pulley 978-1.3 Impeller 981-1 1.0 Mics. 979-1 --- Pulley, blower 980-1.3 Spring 982-1.3 Tube 984-1.3 Latch 983-1.3