Page 1 of 7 11/29/ Document ID: 2545922 #10-00-89-017: Car and Truck Fix it Right the First Time Issues - (Nov 11, ) Subject: Car and Truck "Fix It Right the First Time" Issues Models: and Prior GM Passenger Cars and Trucks This bulletin is being revised to include updated information. Please discard Corporate Bulletin Number 08-00-89-029Z (Section 00 - General Information). In order to access this bulletin electronically, go to the SI Home Page and select the "Newest Bulletins" icon. The documents are arranged by sub-section and then by date (newest to oldest). Scroll down to "General Information" then click on the latest "Field Product Reminder" bulletin. Field Product Reminder -- Car Issues -- Fix It Right the First Time Model Year (s) 2004-2004- 2009-2008- 2009 Vehicle Line(s) / Condition Aura, G6, Malibu, Malibu Maxx -- Intermittently Brake Lights (Stop Lamps) Do Not Function Correctly, Cruise Control Inop, DTCs C0131/C0161/C0277 CTS, SRX, STS -- Information to Prevent Incorrect Installation of Air Cleaner Cover to Air Cleaner Housing HHR, Impala -- Info on Front Passenger Heated Seat Insufficient Heat and Proper System Operation G8 -- Automatic Transmission 6th Gear Whine at Approximately 109 km/h (68 mph) Do This Disconnect the C2 or X2 connector, add dielectric lubricant and reconnecting the connector per the procedure. Always make sure air box is assembled correctly. Compare performance to the passenger seat in a like car to see if seat heater is normal. Install new transmission mount. Don't Do This BCM. Completely removed from the housing the (outlet side) cover if just replacing the filter element. heater element. any other front suspension parts. Ensure that the General Motors. All rights reserved. Reference Information/Bulletin 08-05-22-009C 08-06-01-020A 09-08-50-013A 10-07-30-012
Page 2 of 7 11/29/ 2009-2009- - - - Acadia, Aura, Enclave, Envoy, G5, G6, H2, H3, Outlook, Sierra, Sky, Solstice, Suburban, Tahoe, Terrain, Torrent, Vue, Yukon -- Buzz Noise During Call When Using Bluetooth Corvette -- Visor Mounted Garage Door Opener Will Not Program / Universal Home Remote System Does Not Operate Garage Door LaCrosse -- Power Steering System Moan or Metal Grind Noise When Turning Steering Wheel Malibu -- Engine Surge During High Ambient Temperatures Impala -- No Crank/No Start, Solenoid Clicks Impala, Malibu -- Sunroof Sunshade Cloth Comes Loose from Sunshade Panel Cobalt, G5 -- Increased Rear Compartment Lid Closing Effort, Trunk Ajar Displayed in DIC with Trunk Closed, Poor Rear Compartment Lid Fit/Alignment Cruze -- License Plate Will Not Fit in Front Bracket During Pre- Delivery Inspection (PDI) Process Camaro -- Front Seat Cushion Cover J-Channel Retainer Comes Loose from Front of Seat Frame Camaro, Sky, Solstice -- Radio Display Screen Scratches and Scuffs customer's phone is an older GSM type, and the noise is heard on the land-line side only before attempting the microphone replacement. Reset the garage door opener first and then contact the toll free number for assistance with programming the garage door opener. replace steering gear and I shaft with new part and install new calibration. Install new calibration. Check battery cable ground connection. Reglue the sunroof sunshade cloth to the sunshade panel. Adjust decklid. Inform the customer a fix is under development. Cut the j-clip on the seat cover and reinstall the cover. Polish the radio faceplate screen. Perform this microphone replacement for newer phones that do not use GSM. sunvisor / garage door opener. replace the power steering pump or hose parts for this issue. starter. sunroof sunshade. latch. radio or faceplate. seat cover. radio faceplate. 10-08-44-003B 10-08-97-001 PI0172A PI0245 PI0249 PI0250A PI0252 PI0254 PI0258 09-08-44-015C
Page 3 of 7 11/29/ - - Aura, Malibu, Vue -- Check Engine Light Illuminated, DTC P0AA1 Set Colorado, Express, Savana, Sierra, Silverado -- Intermittent MIL/Check Engine Light On, DTC P013B and P013D Set Equinox, LaCrosse, SRX, Terrain -- Engine Oil Leak from Oil Pan at Mounting Area SRX -- MIL-Check Engine Light On, DTC P182E Set battery energy control module wiring harness. inspect the connections and make sure the O2 sensor is tight. Clean bolt hole with brake cleaner, air dry & apply thread locker to bolt threads. Make sure you are pulling back firmly on the shifter when adjusting the shift cable. battery energy control module. O2 sensor. oil pan. switch without verifying the cable adjustment. 10-06-130-002A PI0065C PI0263 PI0231A Field Product Reminder -- Truck Issues -- Fix It Right the First Time Model Year (s) - 2008 Vehicle Line (s) / Condition Acadia, CTS, CTS-V, CTS Sport Wagon, CTS-V Sport Wagon, Enclave, Traverse, Yukon, Yukon Denali, Yukon XL, Yukon XL Denali -- Park Assist Blocked See Owners Manual Message Repeatedly on DIC Outlook -- SIR Light On, DTC B0014 and B0021 Set in SDM Do This Reprogram the rear object sensor control module. connector between seat mounted side impact airbag and body harness, reroute harness. Don't Do This rear object sensor control module or rear. Grease the existing connector or replace the harness. Reference Information/Bulletin PI0267 08-09-41-011C
Page 4 of 7 11/29/ 20087-2000- Outlook, Traverse -- Whine/Moan Noise from Power Steering System During Low Speed Maneuver Allure, Camaro, Envoy, G8, Grand Prix, Impala, LaCrosse, Monte Carlo, Rainier, SAAB 9-7X, Sierra, Silverado, TrailBlazer, Yukon -- AFM Engine, Valve Tick Noise at Start Up When Engine has been Off for 2 Hours or M Sierra, Silhouette, Suburban, Yukon, Yukon Denali, Yukon XL, Yukon XL Denali -- Pass Side Air Bag Door Not Flush with Dash Pad/Warped Blazer, Bravada, Express, H2, Jimmy, Rainier, S- 10, Savana, Sonoma, Yukon, Yukon Denali, Yukon XL, Yukon XL Denali - Pitman Arm Shaft Seal Service Kit Perform a thorough bleed of the system. Check oil level and fill if low before doing any repairs. Reposition the locking tabs. leaking pitman shaft seal. power steering pump before performing the bleed procedure in the bulletin. Use this bulletin on NON AFM engines. air bag assembly. entire gear. 10-02-32-002 10-06-01-007A 08-09-41-005A 10-02-33-001A
Page 5 of 7 11/29/ 2006-2005- Equinox, Terrain - - Interior Headliner Sagging at Dome Lamp Area Canyon, Colorado -- Broken Front Floor Console Compartment Lid/Armrest Latch All Vehicles -- Reporting Missing or Inaccurate Navigation Radio Map Disc Information- Complete/Submit - Fuel Tank Slow or Difficult to Fill Yukon, Yukon Denali, Yukon XL, Yukon XL Denali - - Driver or Passenger Heated Seat Inoperative, Slow to Warm, DTC(s) Set Yukon, Yukon Denali, Yukon XL, Yukon XL Denali - - Front Seat Cushion Cover Becomes Detached re- glue the magnets. only the center console lid latch. Labor operation C9952. Ask the customer to report concerns to the GM Navigation Disc Center at: http://www.gmnavdisc.com. Check for kinked vent hose. Correct terminal tension and reroute harness. Install 3M Automotive Acrylic Plus Attachment Tape to the seat frame per the procedure. headliner. console lid and/or armrest assembly. Labor operations C2740 or C2860. parts fuel filler pipe or tank. memory seat module, thermoelectric device (TED), or element. seat cover. PI0253A PI0262 10-08-44-006 PI0261 10-08-50-008A 08-08-50-001B Use unapproved
Page 6 of 7 11/29/ - 2009 Body Mount Bolt Stripped or Will Not Loosen - Squeal Noise from Front of Truck / Independent of Brake Apply Mounting Points for Pickup Box Accessories Diesel Exhaust Fluid (DEF) Filling Instructions and General information Terrain -- Whine Noise Heard When Using OnStar or Bluetooth (Install Noise Filter) Escalade EXT Silverado 1500, Suburban, Tahoe Sierra 1500, Sierra Denali, Yukon, Yukon XL, Yukon Denali, Yukon Denali XL, G8 GT -- Engine Oil Consumption on Aluminum Block Engines with Active Fuel Management (AFM) Create access hole to repair. Lube front axle seals. Mount accessories in correct location with acceptable loads. Add only 3.5 gallons of DEF at PDI. Verify concern occurs only when using OnStar or Bluetooth feature. Obtain the filter and install per instructions. Install AFM oil deflector and clean carbon from cylinder running boards that attach to body mounts. axle seals. Overload or use cargo management point for attachment. 10-08-61-001 PI0257 09-08-66-011A Overfill. 10-06-04-013 radio or VCIM for this concern. Perform repairs without doing an oil consumption test first. 10-08-44-005 10-06-01-008A Outlook, Traverse -- Front Driver Power Seat Inoperative, Driver Seat Will motor drive cable. seat adjuster assembly. 07-08-50-013A
Page 7 of 7 11/29/ Not Move Forward/Backward - Equinox, Terrain - - Front Seat Power Lumbar Support Inoperative seat lumbar support actuator mounting screws. seat lumbar mechanism. PI0246 GM bulletins are intended for use by professional technicians, NOT a "do-it-yourselfer". They are written to inform these technicians of conditions that may occur on some vehicles, or to provide information that could assist in the proper service of a vehicle. Properly trained technicians have the equipment, tools, safety instructions, and know-how to do a job properly and safely. If a condition is described, DO NOT assume that the bulletin applies to your vehicle, or that your vehicle will have that condition. See your GM dealer for information on whether your vehicle may benefit from the information. WE SUPPORT VOLUNTARY TECHNICIAN CERTIFICATION