P E11500VD2C-02A PARTS LIST RUBBER CRAWLER CARRIER MST-1500VD. Serial No and up М О П О О К Д

P E11500VD2C-02A PARTS LIST RUBBER CRAWLER CARRIER MST-1500VD Serial No. 154501 and up М О П О О К Д

PARTS LIST RUBBER CRAWLER CARRIER MST-1500VD Serial No. 154501 and up A -1

FOREWORD Thank you for purchasing this Morooka Rubber Crawler Carrier. When ordering a part, please specify the model serial number, the engine serial number and the reading of the hourmeter. READING FOR PARTS LIST For complete understanding, the parts list is written as follows. Fig. Number Figure numbers are not continuous. Description is put in front of the name of an assembly component and the item is entered next to the assembly. If part marked with is an assembly, its component is part marked with. Quantity The number of pieces per set used for assembly is specified. For assembly or part group components, the number of pieces per specified. assembly is Serial number The engine or machine serial number in which the part is used. Codes The codes and part number specified in the Part No. and Part name columns represent the following: The part specified in the line above is applicable instead of this part. Supplied as a set rather than singly. A-2

CONTENTS ITEM FIG. No. PAGE FORWARD A-2 CONTENTS 0-1 ENGINE RELATED PARTS (ENGINE MOUNTING PARTS AND RADIATOR) 10 1 1-2 ENGINE RELATED PARTS (MAIN PUMP AND MOUNTING PARTS) 105 1-4 ENGINE RELATED PARTS (AIR INTAKE SYSTEM) 111 1-6 ENGINE RELATED PARTS (EXHAUST SYSTEM) 115 1-8 FUEL TANK AND FUEL PIPING 121 1-10 FRAME RELATED PARTS (1/4) (RADIATOR COVER AND FRONT GRILL) 201 1-12 FRAME RELATED PARTS (2/4) (UNDER COVER AND STEP) 202 1-14 FRAME RELATED PARTS (3/4) (ENGINE BONNET) 203 1-16 FRAME RELATED PARTS (4/4) (BATTERY BOX) 204 1-20 CAB CAB MOUNTING PARTS 211 1-22 CAB (1/3) 221 1-24 CAB (2/3) 222 1-26 CAB (3/3) 223 1-28 OPERATOR S SEAT AND FLOOR ASS Y 225 1-30 CAB ELECTRICAL SYSTEM (1/2) 231 1-32 CAB ELECTRICAL SYSTEM (2/2) 232 1-34 PANEL ASS Y IN CAB (1/2) 235 1-36 PANEL ASS Y IN CAB (2/2) 236 1-38 FUSE BOX AND FUSE 237 1-40 CAB AUDIO ASS Y 241 1-42 AIR CONDITIONER SYSTEM (1/2) 251 1-44 AIR CONDITIONER SYSTEM (2/2) 252 1-46 AIR CONDITIONER RELATED PARTS (AIR COMPRESSOR AND MOUNTING) 253 1-48 AIR CONDITIONER RELATED PARTS (A/С CONDENSER AND MOUNTING) 254 1-50 AIR CONDITIONER RELATED PARTS (AIR CONDITIONER PIPING) 255 1-52 AIR CONDITIONER RELATED PARTS (HEATER PIPING) 256 1-54 UNDER CARRIAGE RELATED PARTS (TRAVEL MOTOR AND IDLER) 301 1-56 UNDER CARRIAGE RELATED PARTS (CARRIER ROLLER) 311 1-58 UNDER CARRIAGE RELATED PARTS (TRACK ROLLER) 321 1-60 STEERING CONTROL SYSTEM 401 1-62 DUMP CONTROL SYSTEM 421 1-64 HYDRAULIC PIPING (CONTROL VALVE AND DUMP CYLINDER LINE) 501 1-66 HYDRAULIC PIPING (MAIN PUMP CHARGE LINE) 502 1-68 HYDRAULIC PIPING (HST MAIN LINE) 503 1-70 HYDRAULIC PIPING (PARKING BRAKE AND H-L SPEED VALVE LINE) 504 1-72 0-1

ITEM FIG. No. PAGE HYDRAULIC PIPING (OIL COOLER AND DRAIN LINE) 505 1-74 HYDRAULIC PIPING (MAIN PUMP DRAIN LINE) 506 1-76 HYDRAULIC OIL TANK 551 1-78 HYDRAULIC OIL FILTER 555 1-80 OIL COOLER RERATED PARTS 561 1-82 DUMP BODY RELATED PARTS ( 3-WAY OPENABLE TYPE) 601 1-84 DUMP BODY RELATED PARTS (EARTH-MOVING TYPE) 611 1-86 ELECTRICAL SYSTEM (1/4) (CHASSIS WIRING HARNESS AND LAMPS) 711 1-88 ELECTRICAL SYSTEM (2/4) (CHASSIS WIRING DIAGRAM) 712 1-92 ELECTRICAL SYSTEM (3/4) (BATTERY AND BATTERY RELAY ) 715 1-94 ELECTRICAL SYSTEM (4/4) (BATTERY WIRING DIAGRAM) 716 1-96 MARKS AND PLATES (JAPANESE) 801 1-98 MARKS AND PLATES (ENGLISH) 811 1-100 TOOLS 901 1-102 NUMERICAL INDEX 9-1 0-2

MST-1500VD 1-1

FIG.101 ENGINE RELATED PARTS (ENGINE MOUNTING PARTS AND RADIATOR) 4

FIG.101 INDEX PART NO. DESCRIPTION Q TY SERIAL NO. 1 1-55100-0400 ENGINE ASS Y (CAT 6.6) 1 154501 ~ 2 1-55110-4110 REAR LEFT SIDE BRACKET 1 154501 ~ 3 1-55110-4120 REAR RIGHT SIDE BRACKET 1 154501 ~ 4 0-1000-31640 BOLT (M16X40) 8 154501 ~ 5 0-1100-31640 SPRING WASHER (M16) 8 154501 ~ 6 1-18110-1110 CUSHION (FQ2531) 4 154501 ~ 7 0-1000-31235 BOLT (M12X35) 8 154501 ~ 8 0-1200-31210 NUT (M12) 8 154501 ~ 9 0-1100-31230 SPRING WASHER (M12) 8 154501 ~ 10 0-1140-31232 HARD WASHER (M12) 8 154501 ~ 11 0-1200-31210 NUT (M12) 4 154501 ~ 12 0-1100-31230 SPRING WASHER (M12) 4 154501 ~ 13 0-1140-31232 HARD WASHER (M12) 4 154501 ~ 14 1-11110-1110 CUSHION (FQ3529) 2 154501 ~ 15 0-1000-31235 BOLT (M12X35) 4 154501 ~ 16 0-1200-31210 NUT (M12) 4 154501 ~ 17 0-1100-31230 SPRING WASHER (M12) 4 154501 ~ 18 0-1140-31232 HARD WASHER (M12) 4 154501 ~ 19 0-1200-31210 NUT (M12) 2 154501 ~ 20 0-1100-31230 SPRING WASHER (M12) 2 154501 ~ 21 0-1140-31232 HARD WASHER (M12) 2 154501 ~ 1-3

FIG.105 ENGINE RELATED PARTS (MAIN PUMP AND MOUNTING PARTS ) PV93217 1-4

FIG.105 INDEX PART NO. DESCRIPTION Q'TY SERIAL NO. 1 1-17610-0031 MAIN PUMP ASS Y (PV075075) 1 154501 ~ 2 1-17610-0022 GEAR PUMP ASS Y 1 154501 ~ 3 1-51610-1110 COUPLING 1 154501 ~ 4 1-51610-1120 O-RING 1 154501 ~ 5 0-1500-30735 BOLT (UNC7/16X35) 2 154501 ~ 6 0-1100-31230 SPRING WASHER (M12) 2 154501 ~ 7 0-1120-31223 PLANE WASHER (M12) 2 154501 ~ 8 1-51160-1110 COUPLING 1 154501 ~ 9 1-17160-1120 BOLT 4 154501 ~ 10 1-18160-1131 BOSS 1 154501 ~ 11 1-51160-4140 CENTER PLATE 1 154501 ~ 12 1-39160-1160 BOLT 4 154501 ~ 13 0-1500-00730 BOLT (UNC7/16X30) 8 154501 ~ 14 0-1100-01230 SPRING WASHER (M12) 8 154501 ~ 15 1-51160-1150 COVER 1 154501 ~ 16 0-1000-31030 BOLT (M10X30) 12 154501 ~ 17 0-1100-01025 SPRING WASHER (M10) 12 154501 ~ 18 0-1000-31435 BOLT (M14X35) 4 154501 ~ 19 0-1100-01435 SPRING WASHER (M14) 4 154501 ~ 20 0-1120-01432 PLANE WASHER (M14) 4 154501 ~ 1-5

FIG.111 ENGINE RELATED PARTS (AIR INTAKE SYSTEM) PV93218 1-6

FIG.111 INDEX PART NO. DESCRIPTION Q TY SERIAL NO. 1-55120-2110 ELEMENT ASS Y 1 154501 ~ 1 ( 1-55120-2130) INNER ELEMENT 1 154501 ~ 2 1-55120-2140 OUTER ELEMENT 1 154501 ~ 3 1-55120-2120 DUST PAN 1 154501 ~ 4 1-55120-2150 VALVE 1 154501 ~ 5 1-55120-2160 CAP 1 154501 ~ 6 1-55120-2170 DUST INDICATOR 1 154501 ~ 1-7

FIG.115 ENGINE RELATED PARTS (EXHAUST SYSTEM) 1-8

FIG.115 INDEX PART NO. DESCRIPTION Q'TY SERIAL NO. 1 1-18130-1110 EXHAUST MUFFLER 1 154501 ~ 2 1-18130-1140 GASKET 1 154501 ~ 3 0-1000-01035 BOLT (M10X35) 4 154501 ~ 4 0-1200-01008 NUT (M10) 4 154501 ~ 5 0-1100-01025 SPRING WASHER (M10) 4 154501 ~ 6 1-55130-4110 FRONT PIPE 1 154501 ~ 7 1-55130-4120 GASKET 1 154501 ~ 8 1-41130-1130 TAIL PIPE 1 154501 ~ 9 1-41130-1150 CLAMP 1 154501 ~ 10 0-1000-01035 BOLT (M10X35) 1 154501 ~ 11 0-1200-01008 NUT (M10) 1 154501 ~ 12 0-1100-01025 SPRING WASHER (M10) 1 154501 ~ 13 1-51130-1150 CLAMP 2 154501 ~ 14 1-33130-1180 SUPPORT 4 154501 ~ 15 0-1000-00620 BOLT (M6X20) 4 154501 ~ 16 0-1200-00605 NUT (M6) 4 154501 ~ 17 0-1100-00615 SPRING WASHER (M6) 4 154501 ~ 18 1-55130-4210 BRACKET 1 154501 ~ 19 0-1000-01235 BOLT (M12X35) 2 154501 ~ 20 0-1100-01230 SPRING WASHER (M12) 2 154501 ~ 21 0-1120-01223 PLANE WASHER (M12) 2 154501 ~ 22 0-1000-00620 BOLT (M6X20) 8 154501 ~ 23 0-1200-00605 NUT (M6) 8 154501 ~ 24 0-1100-00615 SPRING WASHER (M6) 8 154501 ~ 25 0-1120-00616 PLANE WASHER (M6) 8 154501 ~ 1-9

FIG.121 FUEL TANK AND FUEL PIPING

FIG.121 INDEX PART NO. DESCRIPTION Q TY SERIAL NO. 1-51150-1101 FUEL TANK ASS Y 1 154501 ~ 1 1-55150-1110 FUEL TANK 1 154501 ~ 2 1-51150-1130 STRAINER 1 154501 ~ 3 1-51150-1140 CAP (WITH KEY) 1 154501 ~ 1-51150-1180 KEY 1 154501 ~ 4 0-2150-01047 OIL LEVEL GAUGE TUBE 1 154501 ~ 5 0-2700-00012 CLAMP (JUBILEE 000) 154501 ~ 6 1-31150-1150 DRAIN BOLT 1 154501 ~ 7 0-2010-02418 O-RING (P18) 1 154501 ~ 8 1-32210-1180 FUEL LEVEL SENSOR 1 154501 ~ 9 0-1300-00410 SCREW (4X10) 5 154501 ~ 10 0-1100-00410 SPRING WASHER (M4) 5 154501 ~ 11 0-1130-00408 PLANE WASHER (M4) 5 154501 ~ 12 1-48150-1130 COVER 1 154501 ~ 13 0-1000-00610 BOLT (M6X10) 6 154501 ~ 14 0-1100-00615 SPRING WASHER (M6) 6 154501 ~ 15 0-1120-00616 PLANE WASHER (M6) 6 154501 ~ 16 0-1090-01020 SEMS BOLT (M10X20) 3 154501 ~ 17 0-1090-01025 SEMS BOLT (M10X25) 3 154501 ~ 18 1-51150-4310 FUEL SUPPLY HOSE 1 154501 ~ 19 1-51150-4320 FUEL SUPPLY HOSE 1 154501 ~ 20 1-51150-4330 FUEL RETURN HOSE 1 154501 ~ 21 0-4380-00202 ELBOW 2 154501 ~ 22 1-13150-1120 JOINT 2 154501 ~ 23 0-2700-00012 CLAMP (JUBILEE 000) 6 154501 ~ 24 0-1000-01030 BOLT (M10X30) 2 154501 ~ 25 0-1100-01025 SPRING WASHER (M10) 2 154501 ~ 26 0-1120-01020 PLANE WASHER (M10) 2 154501 ~ 27 0-2830-02920 SPIRAL TUBE AR 154501 ~ 28 0-2800-00202 STRAP BAND AR 154501 ~ 0-2800-00383 STRAP BAND AR 154501 ~ 1-11

FIG.201 FRAME RELATED PARTS (1/4) (RADIATOR COVER AND FRONT GRILLE) 24 2S2? a m a Deta11 A PV93221 1-12

FIG.201 INDEX PART NO. DESCRIPTION Q'TY SERIAL NO. 1 1-55510-4110 MAIN FRAME 1 154501 ~ 2 1-55520-4110 RADIATOR COVER 1 154501 ~ 3 0-1000-01025 BOLT (M10X25) 5 154501 ~ 4 0-1100-01025 SPRING WASHER (M10) 5 154501 ~ 5 0-1120-01020 PLANE WASHER (M10) 5 154501 ~ 6 1-17520-1010 FRONT GRILLE 1 154501 ~ 7 0-1000-01030 BOLT (M10X30) 9 154501 ~ 8 0-1100-01025 SPRING WASHER (M10) 9 154501 ~ 9 0-1120-01020 PLANE WASHER (M10) 9 154501 ~ 10 1-55520-1270 LEFT SIDE COVER 1 154501 ~ 11 1-55520-1260 RIGHT SIDE COVER 1 154501 ~ 12 0-1000-01020 BOLT (M10X20) 9 154501 ~ 13 0-1100-01025 SPRING WASHER (M10) 9 154501 ~ 14 0-1120-01020 PLANE WASHER (M10) 9 154501 ~ 15 1-55520-1241 FRONT BUMPER 1 154501 ~ 16 0-1000-01225 BOLT (M12X25) 8 154501 ~ 17 0-1100-01230 SPRING WASHER (M12) 8 154501 ~ 18 0-1120-01223 PLANE WASHER (M12) 8 154501 ~ 19 1-46520-2830 COVER 2 154501 ~ 20 0-1000-01220 BOLT (M12X20) 8 154501 ~ 21 0-1100-01230 SPRING WASHER (M12) 8 154501 ~ 22 0-1120-01223 PLANE WASHER (M12) 8 154501 ~ 23 1-41520-1520 HEAD LAMP BRACKET 2 154501 ~ 24 0-1000-00820 BOLT (M8X20) 8 154501 ~ 25 0-1100-00820 SPRING WASHER (M8) 8 154501 ~ 1-13

FIG.202 FRAME RELATED PARTS (2/4) (UNDER COVER AND STEP )

FIG.202 INDEX PART NO. DESCRIPTION Q'TY SERIAL NO. 1 1-55520-4250 UNDER COVER 1 154501 ~ 2 0-1000-01020 BOLT (M10X20) 7 154501 ~ 3 0-1100-01025 SPRING WASHER (M10) 7 154501 ~ 4 0-1120-01020 PLANE WASHER (M10) 7 154501 ~ 5 1-55510-1120 STEP 1 154501 ~ 6 0-1000-31225 BOLT (M12X25) 2 154501 ~ 7 0-1100-31230 SPRING WASHER (M12) 2 154501 ~ 8 1-55510-1130 STEP 1 154501 ~ 9 0-1000-31225 BOLT (M12X25) 2 154501 ~ 10 0-1100-31230 SPRING WASHER (M12) 2 154501 ~ 11 1-55510-1140 STEP 1 154501 ~ 12 0-1000-31225 BOLT (M12X25) 2 154501 ~ 13 0-1100-31230 SPRING WASHER (M12) 2 154501 ~ 14 1-11510-1210 CAP 2 154501 ~ 15 0-1000-00616 BOLT (M6X16) 4 154501 ~ 16 0-1100-00615 SPRING WASHER (M6) 4 154501 ~ 17 0-1120-00616 PLANE WASHER (M6) 4 154501 ~ 18 1-30710-1621 SAFETY BAR 2 154501 ~ 19 1-32710-1650 CUSHION 2 154501 ~ 20 1-30710-1630 PIN 2 154501 ~ 21 0-1200-01613 NUT (M16) 2 154501 ~ 22 0-1100-01640 SPRING WASHER (M16) 2 154501 ~ 23 0-1120-01632 PLANE WASHER (M16) 2 154501 ~ 24 1-55510-1240 CUSHION BLOCK 2 154501 ~ 25 0-1311-01010 BOLT (M10X110) 4 154501 ~ 1-15

FIG.203 FRAME RELATED PARTS (3/4) (ENGINE BONNET)

FIG.203 INDEX PART NO. DESCRIPTION Q TY SERIAL NO. 1 1-55520-4120 REAR SUPPORT 1 154501 ~ 2 0-1000-01230 BOLT (M12X30) 4 154501 ~ 3 0-1100-01230 SPRING WASHER (M12) 4 154501 ~ 4 0-1120-01223 PLANE WASHER (M12) 4 154501 ~ 5 1-41520-1510 SUPPORT 1 154501 ~ 6 0-1000-01235 BOLT (M12X35) 2 154501 ~ 7 0-1200-01210 NUT (M12) 2 154501 ~ 8 0-1100-01230 SPRING WASHER (M12) 2 154501 ~ 9 0-1120-01223 PLANE WASHER (M12) 2 154501 ~ 10 1-55520-4140 LEFT SIDE BRACKET 1 154501 ~ 11 1-55520-4130 RIGHT SIDE BRACKET 1 154501 ~ 12 0-1000-01225 BOLT (M12X25) 8 154501 ~ 13 0-1100-01230 SPRING WASHER (M12) 8 154501 ~ 14 0-1120-01223 PLANE WASHER (M12) 8 154501 ~ 1-55520-4320 BONNET ASS Y 1 154501 ~ 15 1-55520-4220 BONNET 1 154501 ~ 16 1-55520-4150 BRACKET 1 154501 ~ 17 0-1000-01025 BOLT (M10X25) 3 154501 ~ 18 0-1100-01025 SPRING WASHER (M10) 3 154501 ~ 19 1-55520-1230 COVER 1 154501 ~ 20 1-41520-1860 HINGE 2 154501 ~ 21 0-1000-00516 BOLT (M5X16) 4 154501 ~ 22 0-1200-00504 NUT (M5) 4 154501 ~ 23 0-1100-00513 SPRING WASHER (M5) 4 154501 ~ 24 1-29520-1521 CATCHER 2 154501 ~ 25 0-1000-00616 BOLT (M6X16) 4 154501 ~ 26 0-1200-00605 NUT (M6) 4 154501 ~ 27 0-1100-00615 SPRING WASHER (M6) 4 154501 ~ 28 1-41520-1380 HANDLE 1 154501 ~ 29 0-1000-00610 BOLT (M6X10) 2 154501 ~ 30 0-1100-00615 SPRING WASHER (M6) 2 154501 ~ 31 1-41520-1670 DAMPER 1 154501 ~ 32 1-41520-1360 BRACKET 1 154501 ~ 33 0-1000-00612 BOLT (M6X12) 2 154501 ~ 34 0-1100-00615 SPRING WASHER (M6) 2 154501 ~ 35 1-41520-1350 BRACKET 1 154501 ~ 36 0-1000-00616 BOLT (M6X16) 2 154501 ~ 37 0-1200-00605 NUT (M6) 2 154501 ~ 38 0-1100-00615 SPRING WASHER (M6) 2 154501 ~ 39 1-41520-1370 BOLT 2 154501 ~ 1-17

FIG.203 FRAME RELATED PARTS (3/4) (ENGINE BONNET)

FIG.203 INDEX PART NO. DESCRIPTION Q TY SERIAL NO. 40 0-1200-00806 NUT (M8) 2 154501 ~ 41 0-1100-00820 SPRING WASHER (M8) 2 154501 ~ 42 0-1120-00816 PLANE WASHER (M8) 2 154501 ~ 43 4-10520-1320 INSPECTION COVER 1 154501 ~ 44 0-1000-01025 BOLT (M10X25) 10 154501 ~ 45 0-1100-01025 SPRING WASHER (M10) 10 154501 ~ 46 0-1120-01020 PLANE WASHER (M10) 10 154501 ~ 47 1-55520-2160 MUFFLER SUPPORT 1 154501 ~ 48 0-1000-01020 BOLT (M10X20) 5 154501 ~ 49 0-1100-01025 SPRING WASHER (M10) 5 154501 ~ 50 0-1120-01020 PLANE WASHER (M10) 5 154501 ~ 1-18

FIG.204 FRAME RELATED PARTS (4/4) (BATTERY BOX)

FIG.204 INDEX PART NO. DESCRIPTION Q TY SERIAL NO. 1-55520-1310 BATTERY BOX ASS'Y 1 154501 ~ 1 1-55520-1170 BATTERY BOX 1 154501 ~ 2 1-55520-1180 BATTERY BOX COVER 1 154501 ~ 3 1-41520-1860 HINGE 2 154501 ~ 4 0-1000-00516 BOLT (M5X16) 4 154501 ~ 5 0-1200-00504 NUT (M5) 4 154501 ~ 6 0-1100-00513 SPRING WASHER (M5) 4 154501 ~ 7 1-29520-1520 CATCHER 2 154501 ~ 8 0-1000-00516 BOLT (M5X16) 4 154501 ~ 9 0-1200-00504 NUT (M5) 4 154501 ~ 10 0-1100-00513 SPRING WASHER (M5) 4 154501 ~ 11 1-41520-1380 HANDLE 1 154501 ~ 12 0-1000-00610 BOLT (M6X10) 2 154501 ~ 13 0-1100-00615 SPRING WASHER (M6) 2 154501 ~ 14 1-41520-1340 DAMPER 1 154501 ~ 15 1-41520-1360 BRACKET 1 154501 ~ 16 0-1000-00612 BOLT (M6X12) 2 154501 ~ 17 0-1100-00615 SPRING WASHER (M6) 2 154501 ~ 18 1-41520-1350 BRACKET 1 154501 ~ 19 0-1000-00616 BOLT (M6X16) 2 154501 ~ 20 0-1200-00605 NUT (M6) 2 154501 ~ 21 0-1100-00615 SPRING WASHER (M6) 2 154501 ~ 22 1-41520-1370 BOLT 2 154501 ~ 23 0-1200-00806 NUT (M8) 2 154501 ~ 24 0-1100-00820 SPRING WASHER (M8) 2 154501 ~ 25 0-1120-00816 PLANE WASHER (M8) 2 154501 ~ 26 0-1090-01025 SEMS BOLT (M10X25) 1 154501 ~ 27 0-1090-01020 SEMS BOLT (M10X20) 4 154501 ~ 28 1-55520-1480 MIRROR STAY 1 154501 ~ 29 1-41520-1850 U-NUT 1 154501 ~ 30 1-11520-1220 REAR VIEW MIRROR 1 154501 ~ 1-21

FIG.211 CAB MOUNTING PARTS 1-22

FIG.211 INDEX PART NO. DESCRIPTION Q TY SERIAL NO. 1 1-51530-1110 CUSHION 10 154501 ~ 2 1-51530-1120 PLATE 10 154501 ~ 3 0-1001-01630 BOLT (M16X130) 5 154501 ~ 4 0-1200-01613 NUT (M16) 5 154501 ~ 5 1-55550-4010 RUBBER SHEET 1 154501 ~ 1-23

FIG.221 CAB (1/3) Г 6 3 ^ 7 1 ^ 72 f 12 lr Ш Section A-A ffi Section B-B f t Ш Section C-C D i n Detail D PV93226 1-24

FIG.221 INDEX PART NO. DESCRIPTION Q TY SERIAL NO. 1 MA87051220001 CAB FRAME 1 154501 ~ 4 MA87051271000 BRACKET 1 154501 ~ 5 MAH 1540108016 BOLT (M8X16) 2 154501 ~ 10 MA87051275000 FRONT UPPER GLASS 1 154501 ~ 11 MA87051276000 FRONT LOWER GLASS 1 154501 ~ 12 MA10416631000 RUBBER DAM 1 154501 ~ 43 MA87051299000 RUBBER 1 154501 ~ 59 MA87051435000 MIRROR ASS Y 1 154501 ~ 62 MA87051441000 COVER 1 154501 ~ 64 MAH 1540108016 BOLT (M8X16) 6 154501 ~ 67 MA10406634100 CUP HOLDER 1 154501 ~ 68 MAA2520706012 SCREW (M6X12) 2 154501 ~ 71 MA10406599500 ASHTRAY 1 154501 ~ 72 MAA2220105012 SCREW (M5X12) 3 154501 ~ 1-25

FIG.222 CAB (2/3) 34 ffi 35 Section B-B PV93227 1-26

FIG.222 INDEX PART NO. DESCRIPTION Q'TY SERIAL NO. 15 MA87051277000 LEFT SIDE GLASS 1 154501 ~ 16 MA87051283000 RUBBER 1 154501 ~ 17 MA87051284000 RING 1 154501 ~ 20 MA87051278000 RIGHT SIDE GLASS 1 154501 ~ 21 MA87051283300 RUBBER 1 154501 ~ 24 MA87051281000 SASH ASS Y 1 154501 ~ 25 MA87051283200 RUBBER 1 154501 ~ 28 MA87051291100 CUSHION 2 154501 ~ 29 MA87051291200 CUSHION 2 154501 ~ 33 MA87051292100 CUSHION 1 154501 ~ 34 MA87051292200 CUSHION 1 154501 ~ 35 MA87051292300 CUSHION 1 154501 ~ 36 MA87051292400 CUSHION 1 154501 ~ 48 MA87051305000 FRONT INNER ROOF 1 154501 ~ 49 MA87051306000 REAR INNER ROOF 1 154501 ~ 50 MA10446036000 CUP 14 154501 ~ 53 MA87051310000 CAB DOOR ASS Y 1 154501 ~ 56 MA87051410000 REAR WINDOW ASS Y 1 154501 ~ 63 MA10311826000 RUBBER 1 154501 ~ 75 MA87051443001 COVER 1 154501 ~ 76 MAH1540108016 BOLT (M8X16) 4 154501 ~ 79 MA87051444000 COVER 1 154501 ~ 81 MAH1540108016 BOLT (M8X16) 4 154501 ~ 85 MA00401001600 GROMMET 1 154501 ~ 87 MA00401002500 GROMMET 3 154501 ~ 1-27

FIG.223 CAB (3/3) 93 84 z Ш View Z S Section A-A Ш Section B-B PV93228 1-28

FIG.223 INDEX PART NO. DESCRIPTION Q TY SERIAL NO. 41 MA87051293101 CUSHION 1 154501 ~ 44 MA10311826000 RUBBER 1 154501 ~ 45 MA11763543000 RUBBER 1 154501 ~ 80 MA10402192000 TRIM 1 154501 ~ 84 MA87051445001 COVER 1 154501 ~ 88 MA10501108000 GROMMET 1 154501 ~ 93 MAH1540108016 BOLT (M8X16) 4 154501 ~ 1-29

FIG.225 OPERATOR S SEAT AND FLOOR ASS Y PV93229 1-30

FIG.225 INDEX PART NO. DESCRIPTION Q'TY SERIAL NO. 1 MA87054111001 FLOOR 1 154501 ~ 2 MAH1540112030 SEMS BOLT (M12X30) 10 154501 ~ 6 MA87054113000 OPERATOR S SEAT ASS Y 1 154501 ~ 7 MA87054115000 BRACKET 1 154501 ~ 8 MAH1540108020 SEMS BOLT (M8X20) 4 154501 ~ 9 MAH1540110020 SEMS BOLT (M10X20) 4 154501 ~ 28 1-29540-1620 LEFT SIDE FOOT RAST 1 154501 ~ 29 MAH1540110030 SEMS BOLT (M10X30) 3 154501 ~ 33 1-29540-1610 RIGHT SIDE FOOT RAST 1 154501 ~ 34 MAH1540110030 SEMS BOLT (M10X30) 3 154501 ~ 45 1-55530-4190 FLOOR MAT 1 154501 ~ 1-31

PV93230

FIG.231 INDEX PART NO. DESCRIPTION Q'TY SERIAL NO. 1 MA87053011000 WIPER MOTOR 1 154501 ~ 2 MAF3000106000 NUT (M6) 3 154501 ~ 3 MA87053012000 WIPER ARM 1 154501 ~ 4 MA87053013000 WIPER BLADE 1 154501 ~ 5 MA87053014000 COVER 1 154501 ~ 6 MA35453021100 CUP 1 154501 ~ 7 MA87053016001 LEAD WIRE 1 154501 ~ 8 MAHA121403000 BOLT 1 154501 ~ 9 MA35554447000 BAND 1 154501 ~ 10 MA87053017000 DUCT 1 154501 ~ 15 MA35323844000 NOZZLE ASS Y 1 154501 ~ 16 MA09804040201 TUBE 1 154501 ~ 17 MA35323846000 VALVE ASS Y 1 154501 ~ 18 MA09804043501 TUBE 1 154501 ~ 39 MA87053051001 DC CONVERTOR ASS Y 1 154501 ~ 40 MAF3000106000 NUT (M6) 4 154501 ~ 49 MAF3000106000 NUT (M6) 2 154501 ~ 50 MAHA121403000 BOLT 2 154501 ~ 52 MA00511070070 WIRE BAND 3 154501 ~ 53 MA35554447000 BAND 3 154501 ~ 60 MA87053121001 LEAD WIRE 1 154501 ~ 63 MA87053063000 PLATE 1 154501 ~ 64 MAHA121403000 BOLT 1 154501 ~ 65 MAH1540108020 BOLT 1 154501 ~ 68 1-29210-1310 SLOPE ALARM UNIT 1 154501 ~ 69 MAF3000106001 NUT 4 154501 ~ 70 MA10483408000 CLAMP 3 154501 ~ 71 MA00511032070 WIRE BAND 5 154501 ~ 1-33

FIG.232 CAB ELECTRICAL SYSTEM (2/2) 56 52 34 35 36 27 28 26 25 24 Detail В 31 32 ffi Section C-C 1-34

FIG.232 INDEX PART NO. DESCRIPTION Q'TY SERIAL NO. 13 MA87053021000 WINDOW WASHER PUMP 1 154501 ~ 14 MAF3000106000 NUT (M6) 2 154501 ~ 19 MA00401000700 GROMMET 1 154501 ~ 20 MA87053025000 COVER 1 154501 ~ 21 MA87053025100 COVER 1 154501 ~ 22 MAF3010108000 NUT (M8) 2 154501 ~ 24 MA87053031000 PANEL 1 154501 ~ 25 MAI 0406718000 WIPER SWITCH 1 154501 ~ 26 MA35983016000 MARK 1 154501 ~ 27 MAI 0446229000 NUT 2 154501 ~ 28 MA35180844000 SCREW 2 154501 ~ 31 MA10446214000 ROOM LAMP ASS Y 1 154501 ~ 32 MAH2420105020 SCREW (M5X12) 2 154501 ~ 33 MAF3000105000 NUT (M5) 2 154501 ~ 34 MA87053042000 LEAD WIRE 1 154501 ~ 35 MA35969913000 CLAMP 2 154501 ~ 36 MA00511022030 WIRE BAND 2 154501 ~ 48 MA87053111001 WIRING HARNESS (C) 1 154501 ~ 51 MA19572915000 RELAY 1 154501 ~ 52 MA00511070070 WIRE BAND 3 154501 ~ 53 MA35554447000 BAND 3 154501 ~ 54 MA26733546000 WIRE BAND 1 154501 ~ 55 MA35011788000 RUBBER 1 154501 ~ 56 MA00502110083 CLAMP 1 154501 ~ 1-35

FIG.235 PANEL ASS Y IN CAB (1/2) PV93232 1-36

FIG.235 INDEX PART NO. DESCRIPTION Q TY SERIAL NO. 1 MA87053501000 PANEL ASS'Y 1 154501 ~ 2 MAF3010108000 NUT (M8) 4 154501 ~ 3 MA87053594000 COVER 1 154501 ~ 4 MAH 1940406012 BOLT (M6X12) 3 154501 ~ 1-37

FIG.236 PANEL ASS Y IN CAB (2/2) 55 33 o o \ 52 60 25 Detail Panel Box 34 9 Section A-A 18 9 Section B-B 10 j L J d Detail Starter Switch PV93233 1-38

FIG.236 INDEX PART NO. DESCRIPTION Q TY SERIAL NO. 1 MA87053502000 PANEL 1 154501 ~ 2 MA87053507000 COVER 1 154501 ~ 3 MAA2520706012 SCREW (M6X12) 154501 ~ 4 MA87053508000 COVER 1 154501 ~ 8 0-5400-00500 STARTING SWITCH ASS'Y 1 154501 ~ 9 0-5401-00000 STARTING KEY 1 154501 ~ 10 MA87053514000 LEAD WIRE 1 154501 ~ 13 MA87053521000 THROTTLE DIAL 1 154501 ~ 16 MA87053526000 PARKING BRAKE SWITCH 1 154501 ~ 18 MA19632918000 H-L SPEED SELECTOR SWITCH 1 154501 ~ 19 MA27601207000 LINER 1 154501 ~ 20 MA19615024000 BOOT 1 154501 ~ 22 MA10405556000 COMBINATION SWITCH 1 154501 ~ 25 MA87053541000 FLASHER UNIT 1 154501 ~ 28 MAH1440106016 BOLT (M6X16) 1 154501 ~ 30 MA87053546000 RELAY 4 154501 ~ 31 MAH 1440106016 BOLT (M6X16) 4 154501 ~ 33 SD10107381 DISPLAY ASS Y 1 154501 ~ 34 MA35150924100 SCREW 4 154501 ~ 37 MA87053561000 LAMP (RED) 3 154501 ~ 38 MA87053562000 LAMP (ORANGE) 2 154501 ~ 39 MA87053563000 LAMP (GREEN) 3 154501 ~ 40 MA87053564000 LAMP (BLUE) 1 154501 ~ 42 MA87053571000 HOURMETER 1 154501 ~ 46 MA87053576001 SIDE PANEL LABEL 1 154501 ~ 47 MA87053577000 STARTING SWITCH LABEL 1 154501 ~ 51 MA87053582000 BUZZER 1 154501 ~ 52 MAH1540108016 BOLT (M8X16) 1 154501 ~ 54 MA87053586000 BUZZER 1 154501 ~ 55 MAF3000104000 NUT (M4) 2 154501 ~ 56 MAH2420104016 SCREW (M4X16) 2 154501 ~ 58 MA87053592000 WIRING HARNESS (P) 1 154501 ~ 59 MA10483408000 CLAMP 5 154501 ~ 60 MA00511032070 WIRE BAND 6 154501 ~ 61 MAH1540108016 BOLT (M8X16) 1 154501 ~ 62 MAA2520706012 SCREW (M6X12) 2 154501 ~ 1-39

FIG.237 FUSE BOX AND FUSE To A /c c o n tro l panel,w iper sw itch and etc, a t upper surface in cab. ч PV93252 1-40

FIG.237 INDEX PART NO. DESCRIPTION Q'TY SERIAL NO. MA87053592000 1 MA87053592100 WIRING HARNESS (P) (SEE FIG.236-58) WIRING HARNESS (WITH FUSE BOX) 1 154501 ~ 1 154501 ~ 2 MA10412925200 COVER 1 154501 ~ 3 MA10412925300 FUSE PULLER 1 154501 ~ 4 0-5070-00005 MINI-FUSE (5A) 5 154501 ~ 0-5070-00010 MINI-FUSE (10A) 5 154501 ~ 0-5070-00015 MINI-FUSE (15A) 4 154501 ~ 5 MA87053592500 FUSE LABEL 1 154501 ~ 6 MAA2520706012 SCREW (M6X12) 2 154501 ~ MA87053111001 7 MA87053111100 WIRING HARNESS (C) (SEE FIG.232-48) WIRING HARNESS (WITH FUSE BOX) 1 154501 ~ 1 154501 ~ 8 MA17846053200 COVER 1 154501 ~ 9 MA17846053300 FUSE PULLER 1 154501 ~ 10 0-5070-00010 MINI-FUSE (10A) 5 154501 ~ 0-5070-00015 MINI-FUSE (15A) 2 154501 ~ 11 MA87053111501 FUSE LABEL 2 154501 ~ 12 MAF3000106000 NUT (M6) 2 154501 ~ 1-41

FIG.241 CAB AUDIO ASS Y Z ffl View Z x t r - a * M e Detail Speaker X t I^B M S Detail Stereo PV93234 1-42

FIG.241 INDEX PART NO. DESCRIPTION Q TY SERIAL NO. 1 MA87053212002 BRACKET 1 154501 ~ 2 MAH1540108020 BOLT (M8X20) 1 154501 ~ 3 MA10487411000 CD STEREO UNIT 1 154501 ~ 4 MA87053213000 LEAD WIRE 1 154501 ~ 5 MA35969913000 CLAMP 1 154501 ~ 6 MA00511022030 WIRE BAND 1 154501 ~ 10 MA10487412000 SPEAKER UNIT 1 154501 ~ 11 MA10446229000 NUT 1 154501 ~ 12 MA35180844000 SCREW 1 154501 ~ 13 MA10487412000 SPEAKER UNIT 1 154501 ~ 14 MA10446229000 NUT 1 154501 ~ 15 MA35180844000 SCREW 1 154501 ~ 18 MA10487413000 ANTENNA ASS Y 1 154501 ~ 19 MAF2420105016 SCREW (M5X16) 1 154501 ~ 20 MA00511032070 WIRE BAND 1 154501 ~ 1-43

FIG.251 AIR CONDITIONER SYSTEM (1/2) 54 61 54 3759 66 58 a m a Detail A 44 4342 38 73 z Ш View Z y m View Y PV93235 1-44

FIG.251 INDEX PART NO. DESCRIPTION Q'TY SERIAL NO. 1 MA10446111000 AIR CONDITIONER UNIT 1 154501 ~ 2 MAH1940106025 BOLT (M6X25) 4 154501 ~ 3 MA03500140618 WASHER (M6) 2 154501 ~ 4 MAF1440106030 BOLT (M6X30) 2 154501 ~ 8 MA87052011000 BRACKET 1 154501 ~ 9 MAH1540108020 BOLT (M8X20) 4 154501 ~ 28 MA87052031000 WIRE 1 154501 ~ 29 MA35833906100 WIRE 1 154501 ~ 30 MA07420100300 RING 154501 ~ 31 MA27933551000 CLAMP 1 154501 ~ 32 MA04322104012 SCREW (M4X12) 1 154501 ~ 37 MA10446113000 WATER VALVE 1 154501 ~ 38 MA87052027000 PLATE 1 154501 ~ 39 MA04322104012 SCREW (M4X12) 154501 ~ 40 MAH1440106016 BOLT (M6X16) 154501 ~ 41 MA35833906100 WIRE 1 154501 ~ 42 MA10446122000 WIRECLAMP 1 154501 ~ 43 MAH2420104016 SCREW (M4X16) 1 154501 ~ 44 MAF3000104000 NUT (M4) 1 154501 ~ 52 MA87052035000 WATER HOSE 1 154501 ~ 53 MA87052036000 WATER HOSE 1 154501 ~ 54 MA10446131000 HOSE CLAMP 154501 ~ 58 MA87052035000 WATER HOSE 1 154501 ~ 59 MA87052036000 WATER HOSE 1 154501 ~ 60 MA10406373000 JOINT 1 154501 ~ 61 MA10446131000 HOSE CLAMP 154501 ~ 66 MA00511070070 WIRE BAND 154501 ~ 70 MA10416659000 DRAIN HOSE 1 154501 ~ 71 MA35833905500 DRAIN HOSE 1 154501 ~ 72 MA35833905700 T-JOINT 1 154501 ~ 73 MA00502110083 CLAMP 1 154501 ~ 79 MA10446139000 PACKING 1 154501 ~ 101 MA10446141000 FILTER 1 154501 ~ 102 MA10446142000 CUP 6 154501 ~ 1-45

FIG.252 AIR CONDITIONER SYSTEM (2/2) Ш Section B-B 9 13 45 14 S Section C-C 19 S Section D-D S Section A-A 10 ш г Section E-E Section F-F PV93236 1-46

FIG.252 INDEX PART NO. DESCRIPTION Q TY SERIAL NO. 9 MAH 1540108020 BOLT (M8X20) 4 154501 ~ 10 MA35404766000 CUSHION RUBBER 1 154501 ~ 13 MA87052021000 DUCT 1 154501 ~ 14 MA87052022000 CUSHION 1 154501 ~ 15 MAH 1440106016 BOLT (M6X16) 4 154501 ~ 19 MA87052023000 CUSHION 1 154501 ~ 23 MA10446218000 CONTROL ASS Y 1 154501 ~ 24 MA87052025000 BRACKET 1 154501 ~ 25 MAH 1440106016 BOLT (M6X16) 3 154501 ~ 26 MAHA210302000 SCREW 2 154501 ~ 27 MAF3000104000 NUT (M4) 2 154501 ~ 33 MA00511070070 WIRE BAND 2 154501 ~ 45 MA00511070070 WIRE BAND 1 154501 ~ 52 MA87052035000 WATER HOSE 1 154501 ~ 53 MA87052036000 WATER HOSE 1 154501 ~ 65 MA35833796000 BAND 5 154501 ~ 66 MA00511070070 WIRE BAND 3 154501 ~ 70 MA10416659000 DRAIN HOSE 1 154501 ~ 73 MA00502110083 CLAMP 1 154501 ~ 74 MA10366169000 GROMMET 1 154501 ~ 78 MA17851431000 LP HOSE 1 154501 ~ 83 MA17851432000 LQ HOSE 1 154501 ~ 90 MA10446112000 GRILLE ASS Y 1 154501 ~ 91 MAA2420104012 SCREW (M4X12) 1 154501 ~ 92 MAF3000104000 NUT (M4) 1 154501 ~ 93 MA10406154100 SEAL 1 154501 ~ 1-47

FIG.253 AIR CONDITIONER RELATED PARTS (AIR COMPRESSOR AND MOUNTING) 1

FIG.253 INDEX PART NO. DESCRIPTION Q'TY SERIAL NO. 1 MA10446331000 AIR COMPRESSOR ASS'Y 1 154501 ~ 2 1-55920-4510 BRACKET 1 154501 ~ 3 0-1000-01030 BOLT (M10X30) 1 154501 ~ 4 0-1100-01025 SPRING WASHER (M10) 1 154501 ~ 5 0-1120-01020 PLANE WASHER (M10) 1 154501 ~ 6 0-1000-01035 BOLT (M10X35) 1 154501 ~ 7 MA10446334000 BUSHING 1 154501 ~ 8 0-1000-31035 BOLT (M10X35) 4 154501 ~ 9 0-1100-01030 SPRING WASHER (M10) 4 154501 ~ 10 0-1120-01020 PLANE WASHER (M10) 4 154501 ~ 11 MA10446338000 TENSION PULLEY ASS'Y 1 154501 ~ 12 MA10446339000 ADJUSTING BOLT 1 154501 ~ 13 MA10446338000 V-BELT 1 154501 ~ 1-49

FIG.254 AIR CONDITIONER RELATED PARTS (A/С CONDENSER AND MOUNTING)

FIG.254 INDEX PART NO. DESCRIPTION Q'TY SERIAL NO. 1 MA10480842000 CONDENSER ASS Y 1 154501 ~ 2 MA87054516000 LEFT SIDE BRACKET 1 154501 ~ 3 MA87054515000 RIGHT SIDE BRACKET 1 154501 ~ 4 MAH1440106012 BOLT 4 154501 ~ 5 MA35833965500 GROMMET 4 154501 ~ 6 MA35833965600 BUSHING 4 154501 ~ 7 MA03500150622 WASHER 4 154501 ~ 8 MAH 1440106030 BOLT 4 154501 ~ 9 0-1100-01025 SPRING WASHER (M10) 4 154501 ~ 10 MA10446352000 RECEIVER 1 154501 ~ 11 MA10446349000 HOLDER 1 154501 ~ 12 MAH 1440106025 BOLT 2 154501 ~ 1-51

FIG.255 AIR CONDITIONER RELATED PARTS (AIR CONDITIONER PIPING) 6 7 PV93239 1-52

FIG.255 INDEX PART NO. DESCRIPTION Q'TY SERIAL NO. 1 MA87054524000 DISCHARGE HOSE ASS'Y 1 154501 ~ 2 MA87054518000 SUCTION HOSE ASS Y 1 154501 ~ 3 MA10480876001 LIQUID PAPE 1 154501 ~ 4 MA87054521000 LIQUID HOSE ASS Y 1 154501 ~ 5 MAH1440106025 BOLT 6 154501 ~ 6 0-2850-01800 CORRUGATE TUBE AR 154501 ~ 0-2850-02400 CORRUGATE TUBE AR 154501 ~ 0-2850-02900 CORRUGATE TUBE AR 154501 ~ 7 0-2800-00202 STRAP BAND AR 154501 ~ 0-2800-00383 STRAP BAND AR 154501 ~ 1-53

FIG.256 AIR CONDITIONER RELATED PARTS (HEATER PIPING) 1-54

FIG.256 INDEX PART NO. DESCRIPTION Q TY SERIAL NO. 1 1-55910-4310 RETURN HOSE 1 154501 ~ 2 1-55910-4320 SUPPLY HOSE 1 154501 ~ 3 1-55910-4460 NIPPLE 1 154501 ~ 4 1-32910-1420 VALVE 1 154501 ~ 5 1-55910-4450 ADAPTER 2 154501 ~ 6 1-55910-4490 JOINT 2 154501 ~ 7 02700-10024 CLAMP 4 154501 ~ 8 0-2850-01800 CORRUGATE TUBE AR 154501 ~ 0-2850-02400 CORRUGATE TUBE AR 154501 ~ 0-2850-02900 CORRUGATE TUBE AR 154501 ~ 9 0-2800-00202 STRAP BAND AR 154501 ~ 0-2800-00383 STRAP BAND AR 154501 ~ 1-55

FIG.301 UNDER CARRIAGE RELATED PARTS (TRAVEL MOTOR AND IDLER ) A S M 5 Detail A PV921oo 1-56

FIG.301 INDEX PART NO. DESCRIPTION Q TY SERIAL NO. 1 1-17310-1111 TRACK RUBBER 2 154501 ~ 2 1-17630-0011 TRAVEL MOTOR ASS Y (BMV75) 2 154501 ~ 3 0-1000-31655 BOLT (M16X55) 32 154501 ~ 4 0-1100-01640 SPRING WASHER (M16) 32 154501 ~ 5 1-49320-1110 SPROCKET 2 154501 ~ 6 0-1000-32050 BOLT (M20X50) 32 154501 ~ 7 1-28320-1140 HARD WASHER (M20) 32 154501 ~ 1-17330-0011 IDLER ASS Y 2 154501 ~ 8 1-17330-1110 IDLER 1 154501 ~ 9 1-17330-1120 SHAFT 1 154501 ~ 10 0-2000-03150 O-RING (G50) 2 154501 ~ 11 0-6003-00210 ROLLER BEARING 4 154501 ~ 12 0-3310-03090 SNAP RING 2 154501 ~ 13 1-18330-0020 FLOATING SEAL ASS Y 2 154501 ~ 14 1-17330-1150 CAP 2 154501 ~ 15 1-17330-1240 SLIDE HOLDER 2 154501 ~ 16 1-11330-1160 LOCK PLATE 4 154501 ~ 17 0-1000-31225 BOLT (M12X25) 16 154501 ~ 18 0-1100-01230 SPRING WASHER (M12) 16 154501 ~ 19 0-1210-33024 NUT (M30) 4 154501 ~ 20 0-1100-03075 SPRING WASHER (M30) 4 154501 ~ 21 1-17330-1210 RECOIL SPRING 2 154501 ~ 22 1-17330-1221 CYLINDER 2 154501 ~ 23 1-11330-1230 TRACK ADJUSTMENT VALVE 2 154501 ~ 1-57

FIG.311 UNDER CARRIAGE RELATED PARTS (CARRIER ROLLER ) a m ж Detail A PV90664 1-58

FIG.311 INDEX PART NO. DESCRIPTION Q TY SERIAL NO. 1-17340-1100 CARRIER ROLLER ASS Y 4 154501 ~ 1 1-23340-1111 CARRIER ROLLER 2 154501 ~ 2 1-55340-1130 SHAFT 1 154501 ~ 3 0-6000-06207 BALL BEARING 4 154501 ~ 4 0-3310-02572 SNAP RING 4 154501 ~ 5 1-11330-0020 FLOATING SEAL ASS'Y 4 154501 ~ 7 1-14340-1130 CAP 4 154501 ~ 8 0-1350-00630 SCREW (M6X30) 4 154501 ~ 9 1-11340-1140 PLATE 2 154501 ~ 10 0-2000-03135 O-RING (G35) 4 154501 ~ 11 0-1000-01025 BOLT (M10X25) 4 154501 ~ 12 0-1100-01025 SPRING WASHER (M10) 4 154501 ~ 13 0-1000-00816 BOLT (M8X16) 2 154501 ~ 14 0-1100-00820 SPRING WASHER (M8) 2 154501 ~ 15 0-1000-31225 BOLT (M12X25) 16 154501 ~ 16 0-1100-01230 SPRING WASHER (M12) 16 154501 ~ 1-59

FIG.321 UNDER CARRIAGE RELATED PARTS (TRACK ROLLER ) Л 4 P V 9 21 01 1-60

FIG.321 INDEX PART NO. DESCRIPTION Q TY SERIAL NO. 1 1-51350-1210 PIVOT SHAFT 8 154501 ~ 2 1-51350-1220 BUSHING 16 154501 ~ 1-51350-1100 TRACK ROLLER ASS Y 16 154501 ~ 3 1-51350-1110 TRACK ROLLER 1 154501 ~ 4 1-11350-1120 SHAFT 1 154501 ~ 5 0-6000-06009 BALL BEARING 4 154501 ~ 6 0-3310-02575 SNAP RING 2 154501 ~ 7 1-11330-0020 FLOATING SEAL ASS Y 2 154501 ~ 8 1-11350-1130 CAP 2 154501 ~ 9 0-1350-00830 SCREW (M8X30) 2 154501 ~ 10 0-2000-03145 O-RING (G45) 2 154501 ~ 11 1-17350-1140 PLATE 16 154501 ~ 12 0-1200-33024 NUT (M30) 48 154501 ~ 13 0-1100-03075 SPRING WASHER (M30) 48 154501 ~ 14 0-3400-00000 GREASE NIPPLE 8 154501 ~ 1-61

FIG.401 STEERING CONTROL SYSTEM 30 1 3 PV92360 1-62

FIG.401 INDEX PART NO. DESCRIPTION Q TY SERIAL NO. 1 1-41420-1140 LEVER STAND 1 154501 ~ 2 0-1000-01030 BOLT (M10X20) 2 154501 ~ 3 0-1100-01025 SPRING WASHER (M10) 2 154501 ~ 4 0-1120-01020 PLANE WASHER (M10) 2 154501 ~ 5 1-41420-1240 TRAVEL CONTROL LEVER ASS'Y 1 154501 ~ 6 1-41420-1250 GRIP 2 154501 ~ 7 0-1301-00600 SCREW (M6X100) 2 154501 ~ 8 0-1120-00616 PLANE WASHER (M6) 2 154501 ~ 9 1-48420-1210 RUBBER SHEET 1 154501 ~ 10 0-1300-00520 SCREW (M5X20) 4 154501 ~ 11 1-46420-1011 12 1-55420-1070 CABLE FOR FRONT MAIN PUMP (L=4600) CABLE FOR REAR MAIN PUMP (L=4300) 1 154501 ~ 1 154501 ~ 13 1-55420-1090 BALL JOINT ASS Y 1 154501 ~ 14 1-55420-1050 BALL JOINT STUD 1 154501 ~ 15 0-3500-01030 COLLAR (Ф 10x30) 1 154501 ~ 16 1-55420-1060 FRONT SIDE MAIN PUMP LEVER 1 154501 ~ 17 1-41420-1260 BALL JOINT ASS'Y 1 154501 ~ 18 1-55420-1040 REAR SIDE MAIN PUMP LEVER 1 154501 ~ 19 1-55420-1010 FRONT SIDE MAIN PUMP BRACKET 1 154501 ~ 20 1-55420-1020 REAR SIDE MAIN PUMP BRACKET 1 154501 ~ 21 0-1520-00825 SOCKET HEAD BOLT (UNC1/2X25) 2 154501 ~ 22 0-1100-01435 SPRING WASHER (M14) 2 154501 ~ 23 1-55420-1030 BACK-UP BUZZER SWITCH BRACKET 1 154501 ~ 24 0-1000-00620 BOLT (M6X20) 2 154501 ~ 25 0-1100-00615 SPRING WASHER (M6) 2 154501 ~ 26 0-1120-00616 PLANE WASHER (M6) 2 154501 ~ 27 1-55520-1290 BRACKET 1 154501 ~ 28 1-55520-1280 COVER 1 154501 ~ 29 0-1000-01025 BOLT (M10X25) 2 154501 ~ 30 0-1000-01020 BOLT (M10X20) 2 154501 ~ 31 0-1100-01025 SPRING WASHER (M10) 4 154501 ~ 32 0-1120-01020 PLANE WASHER (M10) 4 154501 ~ 1-63

FIG.421 DUMP CONTROL SYSTEM

FIG.421 INDEX PART NO. DESCRIPTION Q TY SERIAL NO. 1-31620-0030 DUMP CONTROL LEVER ASS'Y 1 154501 ~ 1 1-31620-1510 BRACKET ASS Y 1 154501 ~ 2 1-31620-1520 LEVER ASS Y 1 154501 ~ 3 1-31620-1530 KNOB 1 154501 ~ 4 0-1220-01006 NUT (M10) 1 154501 ~ 5 1-31620-1540 E-RING 1 154501 ~ 6 1-31620-1590 LOCK ASS Y 1 154501 ~ 7 0-1000-00610 BOLT (M6X10) 2 154501 ~ 8 0-1100-00615 SPRING WASHER (M6) 2 154501 ~ 9 0-1120-00616 PLANE WASHER (M6) 2 154501 ~ 10 0-1000-00630 BOLT (M6X30) 1 154501 ~ 11 0-1200-00605 NUT (M6) 1 154501 ~ 12 1-31620-1550 TERMINAL 1 154501 ~ 13 1-31620-1610 CLAMP 1 154501 ~ 14 0-1000-00630 BOLT (M6X30) 2 154501 ~ 15 0-1200-00605 NUT (M6) 2 154501 ~ 16 0-1120-00616 PLANE WASHER (M6) 2 154501 ~ 17 0-1000-00825 BOLT (M8X25) 3 154501 ~ 18 0-1120-00816 PLANE WASHER (M8) 3 154501 ~ 19 1-55620-4010 CABLE (L=2500) 1 154501 ~ 20 1-36430-2210 JOINT 1 154501 ~ 21 0-1220-00805 NUT (M8) 2 154501 ~ 22 1-36430-2220 PIN (Ф 8X25) 1 154501 ~ 23 0-3220-01015 COTTER PIN (Ф 1.0X15) 1 154501 ~ 1-65

FIG.501 HYDRAULIC PIPING (CONTROL VALVE AND DUMP CYLINDER LINE) Л -f К IJ Hydraul Hydraul ic Pirro 1-66

FIG.501 INDEX PART NO. DESCRIPTION Q'TY SERIAL NO. 1 0-2101-01050 HOSE (1 " X I500) 1 154501 ~ 2 0-4220-01010 NIPPLE (PT1XSLEEVE) 2 154501 ~ 3 0-2700-10044 CLAMP (ABA32-44) 2 154501 ~ 4 0-4360-01010 ELBOW (PT1XPT1) 1 154501 ~ 5 0-4200-01000 NIPPLE (PT1) 1 154501 ~ 6 0-4380-01010 ELBOW (PT1XPT1) 1 154501 ~ 7 1-12670-1410 FLANGE 1 154501 ~ 8 0-2000-03135 O-RING (G35) 1 154501 ~ 9 0-1020-31025 SOCKET HEAD BOLT (M10X25) 154501 ~ 10 0-2210-00660 HOSE (3 /4"X600) 1 154501 ~ 11 0-4300-00406 ELBOW (PT1/2XPF3/4) 1 154501 ~ 12 1-23670-1420 FLANGE 1 154501 ~ 13 0-2000-03130 O-RING (G30) 1 154501 ~ 14 0-1020-30825 SOCKET HEAD BOLT (M8X25) 154501 ~ 15 0-4326-01906 ELBOW (UNF1-3/16XPF3/4) 1 154501 ~ 0-2040-03027 O-RING (914) 1 154501 ~ 16 1-19620-0011 DUMP CONTROL VALVE ASS Y 1 154501 ~ 17 0-1000-01245 BOLT (M12X30) 4 154501 ~ 18 0-1100-01230 SPRING WASHER (M12) 4 154501 ~ 19 0-1120-01223 PLANE WASHER (M12) 4 154501 ~ 20 0-2210-00455 HOSE (1/2"X550) 1 154501 ~ 21 0-2210-00465 HOSE (1/2"X650) 1 154501 ~ 22 0-4321-01904 ELBOW (UNF1-3/16XPF1/2) 1 154501 ~ 0-2040-03027 O-RING (914) 1 154501 ~ 23 0-4326-01904 ELBOW (UNF1-3/16XPF1/2) 1 154501 ~ 0-2040-03027 O-RING (914) 1 154501 ~ 24 0-4411-00404 TEE (PT1/2XPF1/2XPF1/2) 2 154501 ~ 25 0-2210-00470 HOSE (1/2"X700) 2 154501 ~ 26 0-4300-00404 NIPPLE (PT1/2XPF1/2) 2 154501 ~ 1-67

FIG.502 HYDRAULIC PIPING (MAIN PUMP CHARGE LINE) PV93242 1-68

FIG.502 INDEX PART NO. DESCRIPTION Q TY SERIAL NO. 1 0-2220-00697 HOSE (3/4"X970) 1 154501 ~ 2 0-4321-02106 ELBOW (UNF1-5/16XPF3/4) 1 154501 ~ 0-2040-03030 O-RING (916) 1 154501 ~ 3 0-4300-01006 ELBOW (PT1XPF3/4) 1 154501 ~ 4 (1-17650-0010) OIL FILTER ASS Y 1 154501 ~ 5 0-4100-01006 ADAPTER (PT1XPF3/4) 1 154501 ~ 6 0-4301-00606 ELBOW (PT3/4XPT3/4) 1 154501 ~ 7 0-4470-00602 ADAPTER (PT3/4XPF1/4) 1 154501 ~ 8 0-2220-00670 HOSE (3 /4"X700) 1 154501 ~ 9 0-2420-00665 HOSE (3 /4"X650) 1 154501 ~ 10 0-4412-00606 TEE (PT3/4XPF3/4XPF3/4) 1 154501 ~ 11 0-4321-01906 ELBOW (UNF1-3/16XPF3/4) 154501 ~ 0-2040-02520 O-RING (910) 1 154501 ~ 12 0-4212-00404 NIPPLE (PT1/2XPT1/2) 1 154501 ~ 13 0-4365-00404 ELBOW (PT1/2XPT1/2) 1 154501 ~ 1-69

FIG.503 HYDRAULIC PIPING (HST MAIN LINE) AT fn'jvlky? H ydrauliс Рите A f KD'J #? -? *! Hydraul ic Motor R. H. A-f Hydraul ic Motor L. H. PV92066 1-70

FIG.503 INDEX PART NO. DESCRIPTION Q TY SERIAL NO. 1 1-55670-3110 HOSE (1 "X2350, 210 DEG.) 1 154501 ~ 2 1-55670-3120 HOSE (1"X2200, 0 DEG.) 1 154501 ~ 3 1-55670-3140 HOSE (1 "X1950, 0 DEG.) 1 154501 ~ 4 1-55670-3130 HOSE (1 "X2150. 180 DEG.) 1 154501 ~ 5 0-2030-03523 O-RING 8 154501 ~ 6 0-2610-01057 SPLIT FLANGE 16 154501 ~ 7 0-1520-30725 SOCKET HEAD BOLT (UNC7/16X25) 32 154501 ~ 8 1-41670-1340 CLAMP 2 154501 ~ 9 0-1200-01210 NUT (M12) 2 154501 ~ 10 0-1100-01230 SPRING WASHER (M12) 2 154501 ~ 11 0-1120-01223 PLANE WASHER (M12) 2 154501 ~ 12 0-2840-02013 RUBBER SHEET AR 154501 ~ 0-2840-02020 RUBBER SHEET AR 154501 ~ 13 0-2800-00202 STRAP BAND AR 154501 ~ 0-2800-00383 STRAP BAND AR 154501 ~ 1-71

FIG.504 HYDRAULIC PIPING (PARKING BRAKE AND H-L SPEED VALVE LINE) / ' U PV93243 1-72

FIG.504 INDEX PART NO. DESCRIPTION Q TY SERIAL NO. 1 1-46620-0010 SOLENOID VALVE ASS'Y (FOR PARKING BRAKE AND H /L SPEED) 1 154501 ~ 2 0-1000-00816 BOLT (M8X16) 2 154501 ~ 3 0-1100-00820 SPRING WASHER (M8) 2 154501 ~ 4 0-2430-00295 SUPPLY HOSE (1/4"X950) 1 154501 ~ 5 0-2231-00255 PARKING BRAKE HOSE (1/4"X1550) 1 154501 ~ 6 0-2230-00271 PARKING BRAKE HOSE (1/4"X710) 1 154501 ~ 7 0-2230-00295 PARKING BRAKE HOSE (1/4"X950) 1 154501 ~ 8 0-2231-00250 H /L SPEED HOSE (1/4"X1500) 1 154501 ~ 9 0-2230-00298 H /L SPEED HOSE (1/4"X980) 1 154501 ~ 10 0-2231-00217 H /L SPEED HOSE (1/4"X1170) 1 154501 ~ 11 0-2431-00280 RETURN HOSE (1/4"X1800) 1 154501 ~ 12 0-4300-00202 ELBOW (PT1/4XPF1/4) 1 154501 ~ 13 0-4320-00202 ELBOW (PF1/4XPF1/4) 3 154501 ~ 0-2010-02411 O-RING (P11) 1 154501 ~ 14 0-4410-00202 TEE (PF1/4XPF1/4XPF1/4) 2 154501 ~ 15 0-4321-00902 ELBOW (UNF9/16XPF1/4) 4 154501 ~ 0-2040-02012 O-RING (906) 1 154501 ~ 16 0-4211-00202 NIPPLE (PF1/4XPF1/4) 1 154501 ~ 0-2010-02411 O-RING (P11) 1 154501 ~ 17 0-4300-00202 ELBOW (PT1/4XPF1/4) 1 154501 ~ 1-73

FIG.505 HYDRAULIC PIPING (OIL COOLER AND DRAIN LINE) JW H ydraulic Tank ) H f D ЧуОХуУ H ydraulic pump t'f 11,9-7 O il coole r JW Hydraul ic Motor R. H. rto 'D 'J Hydraul ic Motor L. H. / у PV93244 1-74

FIG.505 INDEX PART NO. DESCRIPTION Q'TY SERIAL NO. 1 0-2430-00645 MAIN PUMP RETURN HOSE (3/4"X450) 1 154501 ~ 2 0-2231-00640 RETURN HOSE (3/4"X1400) 1 154501 ~ 3 0-2230-00678 4 0-2230-00656 5 0-2231-00650 TRAVEL MOTOR RETURN HOSE HOSE (3/4"X780) TRAVEL MOTOR RETURN HOSE (3/4"X560) OIL COOLER INLET HOSE (3/4"X1500) 1 154501 ~ 1 154501 ~ 1 154501 ~ 6 0-4121-01706 ADAPTER (UNF1 1 /1 6XPT3/4) 154501 ~ 0-2040-03024 O-RING (912) 1 154501 ~ 7 0-4412-00606 TEE (PT3/4XPF3/4XPF3/4) 1 154501 ~ 8 0-4300-00606 ELBOW (PT3/4XPF3/4) 1 154501 ~ 9 0-4460-00606 CROSS (PF3/4XPF3/4) 1 154501 ~ 10 0-4321-01706 ELBOW (UNF1-1/16XPT3/4) 154501 ~ 0-2040-03024 O-RING (912) 1 154501 ~ 11 0-4300-01006 ELBOW (PT1XPF3/4) 1 154501 ~ 12 0-2432-01025 OIL COOLER OUTLET HOSE (ГХ2250) 1 154501 ~ 13 0-4300-01010 ELBOW (PT1XPF1) 1 154501 ~ 14 0-4400-01006 TEE (PT1XPT1XPT3/4) 154501 ~ 15 0-4212-01010 NIPPLE (PT1XPT1) 154501 ~ 16 0-4210-00606 NIPPLE (PT3/4XPF3/4) 1 154501 ~ 17 1-21670-1210 CHECK VALVE ASS Y 1 154501 ~ 18 0-2100-00630 HOSE (3/4"X300) 1 154501 ~ 19 0-4220-00606 NIPPLE (PT3/4XPF3/4) 154501 ~ 20 0-2700-10032 CLAMP (ABA22-32) 154501 ~ 21 0-4300-01010 ELBOW (PT1XPF1) 1 154501 ~ 22 0-4360-01010 ELBOW (PT1XPT1) 1 154501 ~ 23 0-4200-01000 NIPPLE (PT1) 1 154501 ~ 1-75

FIG.506 HYDRAULIC PIPING (MAIN PUMP DRAIN LINE) iw tnvvvfy? H ydraulic tank Л4 К 0 'Ь? ;Ю 7 H ydraulic Pimp PV93245 1-76

FIG.506 INDEX PART NO. DESCRIPTION Q'TY SERIAL NO. 1 0-2430-00440 RETURN HOSE (1/2"X400) 1 154501 ~ 2 0-2230-00480 RETURN HOSE (1/2"X800) 1 154501 ~ 3 0-4121-01706 ADAPTER (UNF1-1/16XPT3/4) 1 154501 ~ 0-2040-03024 O-RING (912) 1 154501 ~ 4 0-4100-00604 ADAPTER (PT3/4XPT1/2) 1 154501 ~ 5 0-4412-00404 TEE (PT3/4XPF3/4XPF3/4) 1 154501 ~ 6 0-4321-01704 ELBOW (UNF1-1/16XPF1/2) 1 154501 ~ 0-2040-03024 O-RING (912) 1 154501 ~ 7 0-4300-00304 ELBOW (PT3/8XPF1/2) 1 154501 ~ 8 1-51620-1180 THROTTLE CHECK VALVE ASS Y 1 154501 ~ 9 0-4300-00303 ELBOW (PT3/8XPF3/8) 1 154501 ~ 1-77

FIG.551 HYDRAULIC OIL TANK 1 1 1 2 14 13

FIG.551 INDEX PART NO. DESCRIPTION Q'TY SERIAL NO. 1-55660-1100 HYDRAULIC OIL TANK ASS Y 1 154501 ~ 1 1-55660-1110 HYDRAULIC OIL TANK 1 154501 ~ 2 1-11660-1231 SUCTION FILTER 1 154501 ~ 3 1-11660-1120 COVER 1 154501 ~ 4 1-11660-1130 O-RING 1 154501 ~ 5 0-1000-00816 BOLT (M8X16) 8 154501 ~ 6 0-1100-00820 SPRING WASHER (M8) 8 154501 ~ 7 1-11660-1140 BREATHER 1 154501 ~ 8 1-11660-1150 GASKET 1 154501 ~ 9 1-11660-1220 BOLT 3 154501 ~ 10 1-11660-1170 STRAINER 1 154501 ~ 11 1-11660-1160 CAP 1 154501 ~ 1-11660-0020 OIL LEVEL GAUGE ASS Y 1 154501 ~ 12 1-11660-1180 OIL LEVEL GAUGE 1 154501 ~ 13 1-11660-1190 BOLT 2 154501 ~ 14 1-11660-1210 GASKET 4 154501 ~ 15 0-4000-01000 DRAIN PLUG (PT1) 1 154501 ~ 16 0-4000-00300 PLUG (PT3/8) 2 154501 ~ 17 0-1000-01020 BOLT (M10X20) 6 154501 ~ 18 0-1100-01025 SPRING WASHER (M10) 6 154501 ~ 19 0-1120-01020 PLANE WASHER (M10) 6 154501 ~ 20 0-1200-01008 NUT (M10) 3 154501 ~ 1-79

FIG.555 HYDRAULIC OIL FILTER A I I fffl Detail A PV93247 1-80

F1G.555 INDEX PART NO. DESCRIPTION Q'TY SERIAL NO. 1-17650-0010 OIL FILTER ASS Y 1 154501 ~ 1 1-17650-1110 HEAD ASS Y 1 154501 ~ 2 1-17650-1120 ELEMENT ASS Y 1 154501 ~ 3 1-55670-1110 BRACKET 1 154501 ~ 4 0-1000-01020 BOLT (M10X20) 4 154501 ~ 5 0-1100-01025 SPRING WASHER (M10) 4 154501 ~ 6 0-1120-01020 PLANE WASHER (M10) 4 154501 ~ 7 0-1000-01025 BOLT (M10X25) 3 154501 ~ 8 0-1100-01025 SPRING WASHER (M10) 3 154501 ~ 1-81

FIG.561 OIL COOLER AND RERATED PARTS a 6 PV93248 1-82

FIG.561 INDEX PART NO. DESCRIPTION Q TY SERIAL NO. 1 1-17140-1211 OIL COOLER ASS Y 1 154501 ~ 2 1-55140-4150 LEFT SIDE BRACKET 1 154501 ~ 3 1-55140-4160 RIGHT SIDE BRACKET 1 154501 ~ 4 1-55140-4170 UPPER SIDE BRACKET 1 154501 ~ 5 1-55140-4180 LOWER SIDE BRACKET 1 154501 ~ 6 0-1000-00830 BOLT (M8X30) 6 154501 ~ 7 0-1120-00816 PLANE WASHER (M8) 6 154501 ~ 8 0-1200-00806 NUT (M8) 6 154501 ~ 9 0-1100-00820 SPRING WASHER (M8) 6 154501 ~ 10 0-1000-00820 BOLT (M8X20) 4 154501 ~ 11 0-1100-00820 SPRING WASHER (M8) 4 154501 ~ 12 0-1120-00816 PLANE WASHER (M8) 4 154501 ~ 13 0-1000-01030 BOLT (M10X30) 4 154501 ~ 14 0-1120-01020 PLANE WASHER (M10) 4 154501 ~ 15 0-1200-01008 NUT (M10) 4 154501 ~ 16 0-1100-01025 SPRING WASHER (M10) 4 154501 ~ 17 1-55910-4250 18 1-55910-4260 19 1-55910-4270 LEFT SIDE BRACKET FOR A/C CONDENSOR MOUNTING RIGHT SIDE BRACKET FOR A /C CONDENSOR MOUNTING RIGHT LOWER SIDE BRACKET FOR A/С CONDENSOR MOUNTING 2 154501 ~ 1 154501 ~ 1 154501 ~ 20 0-1000-00820 BOLT (M8X20) 4 154501 ~ 21 0-1120-00816 PLANE WASHER (M8) 4 154501 ~ 22 0-1200-00806 NUT (M8) 4 154501 ~ 23 0-1100-00820 SPRING WASHER (M8) 4 154501 ~ 1-83

FIG.601DUMP BODY RELATED PARTS ( 3-WAY OPENABLE TYPE) А В M DetalI A PV923 6 7 1-84

FIG.601 INDEX PART NO. DESCRIPTION Q TY SERIAL NO. 1 1-55710-1200 DUMP BODY 1 154501 ~ 2 1-17710-1231 HINGE PIN BRACKET (WELDED) 2 154501 ~ 3 1-17710-1120 L.H. SIDE DOOR 1 154501 ~ 4 1-17710-1130 R.H. SIDE DOOR 1 154501 ~ 5 1-17710-1140 REAR SIDE DOOR 1 154501 ~ 6 1-11710-1150 REFLECTOR 2 154501 ~ 7 1-23710-1160 PIN 2 154501 ~ 8 0-3400-00100 GREASE NIPPLE 2 154501 ~ 9 0-3230-00640 SPRING PIN (Ф 6x40) 2 154501 ~ 10 1-12710-1170 LEVER 4 154501 ~ 11 0-1220-01408 NUT (M14) 4 154501 ~ 12 0-1120-01432 PLANE WASHER (M14) 4 154501 ~ 13 1-16710-1310 HINGE PIN 2 154501 ~ 14 1-16710-1360 BUSHING 2 154501 ~ 15 0-3400-00100 GREASE NIPPLE 2 154501 ~ 16 0-1001-31200 BOLT (M12X100) 2 154501 ~ 17 0-1200-31210 NUT (M12) 2 154501 ~ 18 0-1100-01230 SPRING WASHER (M12) 2 154501 ~ 1-17710-1400 L.H. SIDE CUSHION ASS'Y 1 154501 ~ 1-17710-1500 R.H. SIDE CUSHION ASS Y 1 154501 ~ 19 1-17710-1440 SPRING CASE ASS Y 1 154501 ~ 20 1-17710-1410 HOOK 1 154501 ~ 21 1-17710-1460 L.H. SIDE ARM ASS Y 1 154501 ~ 1-17710-1480 R.H. SIDE ARM ASS Y 1 154501 ~ 22 1-17710-1420 PIN ASS Y 2 154501 ~ 23 1-17710-1430 SPRING 1 154501 ~ 24 1-17640-0011 DUMP CYLINDER ASS Y 2 154501 ~ 25 1-17710-1320 CYLINDER PIN 4 154501 ~ 26 1-16710-1330 WASHER 4 154501 ~ 27 0-3220-05971 COTTER PIN (0 5.9x71) 4 154501 ~ 1-85

FIG.611 DUMP BODY RELATED PARTS (EARTH-MOVING TYPE) 17 20 A i f Sffl DetaiI A PV92368 1-86

FIG.611 INDEX PART NO. DESCRIPTION Q TY SERIAL NO. 1 1-55710-1210 DUMP BODY 1 154501 ~ 2 1-17710-1231 HINGE PIN BRACKET (WELDED) 2 154501 ~ 3 1-55710-1220 REAR SIDE DOOR 1 154501 ~ 4 1-11710-1150 REFLECTOR 2 154501 ~ 5 1-23710-1160 PIN 2 154501 ~ 6 0-3400-00100 GREASE NIPPLE 2 154501 ~ 7 0-3230-00640 SPRING PIN (Ф 6x40) 2 154501 ~ 8 1-16710-1310 HINGE PIN 2 154501 ~ 9 1-16710-1360 BUSHING 2 154501 ~ 10 0-3400-00100 GREASE NIPPLE 2 154501 ~ 11 0-1001-31200 BOLT (M12X100) 2 154501 ~ 12 0-1200-31210 NUT (M12) 2 154501 ~ 13 0-1100-01230 SPRING WASHER (M12) 2 154501 ~ 1-17710-1400 L.H. SIDE CUSHION ASS Y 1 154501 ~ 1-17710-1500 R.H. SIDE CUSHION ASS Y 1 154501 ~ 14 1-17710-1440 SPRING CASE ASS Y 1 154501 ~ 15 1-17710-1410 HOOK 1 154501 ~ 16 1-17710-1460 L.H. SIDE ARM ASS Y 1 154501 ~ 1-17710-1480 R.H. SIDE ARM ASS Y 1 154501 ~ 17 1-17710-1420 PIN ASS'Y 2 154501 ~ 18 1-17710-1430 SPRING 1 154501 ~ 19 1-17640-0011 DUMP CYLINDER ASS Y 2 154501 ~ 20 1-17710-1320 CYLINDER PIN 4 154501 ~ 21 1-16710-1330 WASHER 4 154501 ~ 22 0-3220-05971 COTTER PIN (Ф 5.9x71) 4 154501 ~ 1-87

FIG.711 ELECTRICAL SYSTEM (1/4) (CHASSIS WIRING HARNESS AND LAMPS) 1-88

FIG. 711 INDEX PART NO. DESCRIPTION Q TY SERIAL NO. 1 1-46210-1000 L.H. SIDE HALOGEN HEAD LAMP ASS Y 1 154501 ~ 2 1-46210-1250 OUTER HALOGEN HEAD LAMP 1 154501 ~ 3 1-25210-1490 OUTER HALOGEN BULB (75/70W) 1 154501 ~ 4 1-46210-1260 INNER HALOGEN HEAD LAMP 1 154501 ~ 5 1-46210-4250 - INNER HALOGEN BULB (70W) 1 154501 ~ 6 1-46210-1100 R.H. SIDE HALOGEN HEAD LAMP ASS Y 1 154501 ~ 7 1-46210-1250 OUTER HALOGEN HEAD LAMP 1 154501 ~ 8 1-25210-1490 - OUTER HALOGEN BULB (75/70W) 1 154501 ~ 9 1-46210-1260 INNER HALOGEN HEAD LAMP 1 154501 ~ 10 1-46210-4250 - INNER HALOGEN BULB (70W) 1 154501 ~ 11 0-5120-02400 TURN SIGNAL LAMP ASS Y 154501 ~ 12 0-5600-02401 HORN 1 154501 ~ 13 0-1260-00808 FLANGE NUT (M8) 1 154501 ~ 14 0-1200-00806 NUT (M8) 1 154501 ~ 15 C125-1302 HEATER RELAY 1 154501 ~ 16 1-55210-4510 BRACKET 1 154501 ~ 17 0-1260-00606 FLANGE NUT (M6) 154501 ~ 18 1-32210-1560 BACK-UP BUZZER SWITCH 1 154501 ~ 19 1-12210-1480 PLATE 1 154501 ~ 20 0-1000-00430 BOLT (M4X30) 2 154501 ~ 21 0-1200-00403 NUT (M4) 2 154501 ~ 22 0-1130-00408 PLANE WASHER (M4) 2 154501 ~ 23 1-46210-1510 BACK-UP BUZZER 1 154501 ~ 24 0-1300-00620 SCREW (M6X20) 2 154501 ~ 25 0-1260-00606 FLANGE NUT (M6) 2 154501 ~ 26 1-46210-1420 WIRING HARNESS 1 154501 ~ 27 1-12210-1430 GROUND CONNECTION WIRE (D409R038) 1 154501 ~ 28 0-1200-01008 NUT (M10) 1 154501 ~ 29 0-1100-01025 SPRING WASHER (M10) 1 154501 ~ 30 0-1120-01020 PLANE WASHER (M10) 1 154501 ~ 31 8-11210-4120 32 8-11210-4100 HST OIL PRESSURE SENSOR (SD10105364) HST OIL TEMPERATURE SENSOR (SD1090173) 1 154501 ~ 1 154501 ~ 33 1-32210-1180 FUEL LEVEL SENSOR 1 154501 ~ 34 C239-9957 RADIATOR WATER LEVEL SENSOR 1 154501 ~ 35 0-2720-02506 CLIP (LARGE) AR 154501 ~ 0-2720-01206 CLIP (SMALL) AR 154501 ~ 1-89

FIG.711 ELECTRICAL SYSTEM (1/4) (CHASSIS WIRING HARNESS AND LAMPS) 1-88

FIG.711 INDEX PART NO. DESCRIPTION Q TY SERIAL NO. 36 0-1200-00605 NUT (M6) AR 154501 ~ 37 0-1100-00615 SPRING WASHER (M6) AR 154501 ~ 38 0-2800-00202 STRAP BAND AR 154501 ~ 0-2800-00383 STRAP BAND AR 154501 ~ 1-90

FIG.712 ELECTRICAL SYSTEM (2/4) (CHASSIS WIRING DIAGRAM) 10 8 11 1 9 10 1-92

FIG.712 INDEX PART NO. DESCRIPTION Q'TY SERIAL NO. 1 1-55210-4110 MAIN WIRING HARNESS (D209R036) 1 154501 ~ 2 1-55210-4120 WIRING HARNESS (D409R037) 1 154501 ~ 3 1-46210-1420 BACK-UP BUZZER WIRING HARNESS 1 154501 ~ 4 1-55210-4130 GROUND CONNECTION WIRE (D409R038) 1 154501 ~ 5 1-55210-4210 WIRING HARNESS (D309R045) 1 154501 ~ 6 1-55210-4190 WIRING HARNESS (D409R044) 1 154501 ~ 7 1-55210-4170 WIRING HARNESS (D409R042) 1 154501 ~ 8 1-46210-1000 9 1-46210-1100 L.H. SIDE HALOGEN HEAD LAMP ASS Y R.H. SIDE HALOGEN HEAD LAMP ASS Y 1 154501 ~ 1 154501 ~ 10 0-5120-02400 TURN SIGNAL LAMP ASS Y 154501 ~ 11 0-5600-02401 HORN 1 154501 ~ 12 C239-9957 RADIATOR WATER LEVEL SENSOR 1 154501 ~ 13 C125-1302 HEATER RELAY 1 154501 ~ 14 1-46620-0010 SOLENOID VALVE ASS'Y (FOR PARKING BRAKE AND H /L SPEED) 1 154501 ~ 15 1-32210-1560 BACK-UP BUZZER SWITCH 1 154501 ~ 16 1-46210-1510 BACK-UP BUZZER 1 154501 ~ 17 8-11210-4100 18 8-11210-4120 HST OIL TEMPERATURE SENSOR (SD1090173) HST OIL PRESSURE SENSOR (SD 10105364) 1 154501 ~ 1 154501 ~ 19 1-32210-1180 FUEL LEVEL SENSOR 1 154501 ~ 20 MA87053122000 A/С WIRING HARNESS 1 154501 ~ 1-93

FIG.715 ELECTRICAL SYSTEM (3/4) (BATTERY AND BATTERY RELAY ) 1-94

FIG.715 INDEX PART NO. DESCRIPTION Q TY SERIAL NO. 1 0-5000-01300 BATTERY (130F51) (12V.120AH) 2 154501 ~ 2 0-5010-00000 TERMINAL (+) 2 154501 ~ 3 0-5011-00000 TERMINAL (-) 2 154501 ~ 4 1-17210-1310 BOARD 2 154501 ~ 5 1-46210-1340 HOLDER 1 154501 ~ 6 1-46210-1350 ROD 2 154501 ~ 7 0-1120-01020 PLANE WASHER (M10) 2 154501 ~ 8 0-1220-01006 NUT (M10) 4 154501 ~ 9 0-1100-01025 SPRING WASHER (M10) 2 154501 ~ 10 1-55210-4810 BRACKET 1 154501 ~ 11 0-1000-01030 BOLT (M10X30) 2 154501 ~ 12 0-1160-01032 PLANE WASHER (M10) 2 154501 ~ 13 0-1200-01008 NUT (M10) 2 154501 ~ 14 0-1100-01025 SPRING WASHER (M10) 2 154501 ~ 15 1-41210-1510 BATTERY RELAY 1 154501 ~ 16 0-1000-00820 BOLT (M8X20) 2 154501 ~ 17 0-1100-00820 SPRING WASHER (M8) 2 154501 ~ 18 0-1160-00823 PLANE WASHER (M8) 2 154501 ~ 19 C125-1302 STARTER RELAY 1 154501 ~ 20 1-55210-4820 SPACER (L=5) 2 154501 ~ 21 0-1000-00615 BOLT (M6X15) 4 154501 ~ 22 0-1100-00615 SPRING WASHER (M6) 4 154501 ~ 23 0-1120-00616 PLANE WASHER (M6) 4 154501 ~ 24 C171-2210 BREAKER (80A) 1 154501 ~ 25 0-1700-N1010 SCREW (UNF-NO.10X10) 2 154501 ~ 26 0-1120-00616 PLANE WASHER (M6) 2 154501 ~ 27 0-1260-01010 FLANGE NUT (M10) 1 154501 ~ 28 0-5070-00020 MINI BLADE FUSE (20A) 1 154501 ~ 29 1-55210-3920 SLOW BLOW FUSE (65A) 1 154501 ~ 30 1-55210-4930 SLOW BLOW FUSE (75A) 1 154501 ~ 1-95

FIG.716 ELECTRICAL SYSTEM (4/4) (BATTERY WIRING DIAGRAM) To s ta r te r and a lte rn a to r 2 PV93254 1-96

FIG.716 INDEX PART NO. DESCRIPTION Q TY SERIAL NO. 1 1-55210-4140 BATTERY CABLE (D409R039) 1 154501 ~ 2 1-55210-4130 BATTERY CABLE (D409R038) 1 154501 ~ 3 1-55210-4150 BATTERY CABLE (D409R040) 1 154501 ~ 4 1-55210-4180 WIRING HARNESS (D409R043) 1 154501 ~ 5 1-55210-4160 WIRING HARNESS (D409R041) 1 154501 ~ 6 1-55210-4210 WIRING HARNESS (D309R045) 1 154501 ~ 7 1-55210-4220 WIRING HARNESS (D410R193) 1 154501 ~ 8 1-55210-4110 MAIN WIRING HARNESS (D209R036) 1 154501 ~ 9 0-5070-00020 MINI BLADE FUSE (20A) 1 154501 ~ 10 1-55210-3920 SLOW BLOW FUSE (65A) 1 154501 ~ 11 1-55210-4930 SLOW BLOW FUSE (75A) 1 154501 ~ 12 1-55210-4940 DIODE 1 154501 ~ 13 0-5000-01300 BATTERY (130F51) (12V.120AH) 154501 ~ 14 1-41210-1510 BATTERY RELAY 1 154501 ~ 15 C125-1302 STARTER RELAY 1 154501 ~ 16 C171 2210 BREAKER (80A) 1 154501 ~ 1-97