RYOBI Digital Inverter Generator Manufacturing No. 09090 Item No. RYi00GR Replacement Parts List 99500009 7-6-7 (Rev:0) TECHTRONIC INDUSTRIES POWER EQUIPMENT, INC. 8 Pearman Dairy Road, Anderson, SC 965 Phone -800-860-050 www.ryobitools.com
Figure A DIGITAL INVERTER GENERATOR ITEM NUMBER RYi00GR 5 5 50 58 5 7 8 Add Loctite or equivalent 6 9 0 6 7 6 8 8 6 5 0 7 8 SEE FIG. C 8 5 8 9 9 9 Add Loctite or equivalent 7 0 SEE FIG. B SEE FIG. E 5 57 6 5 56 5 SEE FIG. B 5 8 8 9 7 5 60 59 5 5 6 SEE FIG. D SEE FIG. B 0 Add Loctite or equivalent 9 7 55 5 6 5
DIGITAL INVERTER GENERATOR ITEM NUMBER RYi00GR The model number will be found on a label attached to the back cover. Always mention the model number in all correspondence regarding your DIGITAL INVERTER GENERATOR or when ordering parts. PARTS LIST FIGURE A 6607600 Screw (M5 x 0 mm, Button Soc. Hd.)...0 6880 Washer (M5.)...8 66600 Screw (M x 0 mm)... 556008 Control Knob... 5 50500 Recoil Handle... 6 66076007 Screw (M5 x mm, Button Soc. Hd.)... 7 5597005 Starter Cover Assembly... 8 660505 Screw (M x mm, T5 Torx Hd.)...6 9 660508 Screw (M5 x 0 mm, Phillips Hd.)... 0 66860 Screw (M x 6 mm, Flat Hd.)... 5000 Left Housing Assembly (Incl. Key No. )... 59709007 Vented Fuel Cap... 57088005 Overspill Guard... 5705600 Fuel Tank Support... 5 0796 Fuel System Assembly (Incl. Key Nos. and 6-8)... 6 5705870 Fuel Hose (6mm and.5 mm)... 7 6788505 Clamp (0 mm)... 8 67809008 Fuel Hose Clamp (/8 in.)... 9 6788500 Fuel Hose Clamp (9.5 mm)... 0 90080 Easy Start Logo Label... 087008 Fuel Filter... NOTE A Engine (Ducar) (See Figure E)... 66097500 Bolt (M6 x mm, Hex Hd.)...7 679900 Engine Isolator (5 Degree)... 5 678000 Lock Washer... 6 660760 Screw (M5 x 6 mm, Flat Hd.)... 7 0008 Wheel... 8 9000 Ground Wire... 9 986008 Inquiries Label... 0 605990 Axle... 909700 Fire Distance Label... 5008 Lower Exhaust Panel Assembly (Incl. Key No. )... 6870006 Washer (5 mm)...6 5006 Upper Exhaust Panel Assembly (Incl. Key No. 5)... 5 660760 Screw (M5 x 5 mm, Button Soc. Hd.)... 6 6605009 Screw w/washer (M x 0 mm, T0 Torx Hd.)...6 7 9065 Danger Label... NOTE A: Techtronic Industries, Inc., will not provide complete engines as replacement parts. Engines are covered through the engine manufacturer s warranty. Consult the accompanying engine manual or contact our service department for assistance.
DIGITAL INVERTER GENERATOR ITEM NUMBER RYi00GR The model number will be found on a label attached to the back cover. Always mention the model number in all correspondence regarding your DIGITAL INVERTER GENERATOR or when ordering parts. PARTS LIST FIGURE A 8 90679 Choke Label... 9 555900 Bottom Base Assembly (Incl. Key Nos. -, and 5; See Figure B)... 0 6787709 Lock Nut (M6)... 5000 Right Housing Assembly (Incl. Key Nos. -)... 6789000 U-Clip (M5)...0 56087800 Rubber Pad... 5707660 Grommet... 5 500 Maintenance Cover Assembly (Incl. Key Nos. 6-7)... 6 5560 Lock Knob... 7 686008 Retaining Ring... 8 0700 Engine Start/Stop Mechanism Assembly... 9 570587 Fuel Hose (.5 mm and 6 mm)... 50 909705 Combustion Label... 5 905507 CPSC Label... 5 9075806 Handle Release Label... 5 9070808 Lubricant Label... 5 9077900 Performance Label... 55 90900 Maintenance Label... 56 907800 Fuel Stabilizer Label... 57 90500 Ground Warning Label (English/French)... 58 90680086 Hot Surface Label... 59 907056 Logo Label... 60 9077999 Performance Label (Maintenance Door)... 6 906778 Start Label... 6 90506 Engine Wire Harnes... Not Shown: 06900 Accessory Kit 99500007 Operator's Manual
Figure B DIGITAL INVERTER GENERATOR ITEM NUMBER RYi00GR 0 5 6 6 5 5 6 8 ARROW TO THE FRONT 7 9 9 6 Add Loctite or equivalent 8 7 8 7 5
DIGITAL INVERTER GENERATOR ITEM NUMBER RYi00GR The model number will be found on a label attached to the back cover. Always mention the model number in all correspondence regarding your DIGITAL INVERTER GENERATOR or when ordering parts. PARTS LIST FIGURE B 587800 Front Cover... 687005 Handle Tube... 5560 Handle Cap (Left)... 5560 Handle Cap (Right)... 5 555900 Bottom Base... 6 5980 Oil Drain Door... 7 08790086 Handle Assembly... 8 5005 Back Cover... 9 565006 Isolator Foot... 0 5707008 Engine Support Isolator (Back)... 5707007 Engine Support Isolator (Front)... 5707009 Handle Bumper... 6600 Screw (M5 x mm, Pan Hd.)... 6789000 U-Clip (M5)... 6 5 6607600 Screw (M5 x 0 mm, Button Soc. Hd.)... 6 6880 Washer (M5.)... 6 7 66097500 Bolt (M6 x mm, Hex Hd.)... 8 678000 Lock Washer... 9 660760 Screw (M5 x 6 mm, Flat Hd.)... 6
Figure C DIGITAL INVERTER GENERATOR ITEM NUMBER RYi00GR 6 5 7 7
DIGITAL INVERTER GENERATOR ITEM NUMBER RYi00GR The model number will be found on a label attached to the back cover. Always mention the model number in all correspondence regarding your DIGITAL INVERTER GENERATOR or when ordering parts. PARTS LIST FIGURE C 57088006 Edge Trim Rubber... 9066009 Engine Intake Baffle... 66097500 Bolt (M6 x mm, Hex Hd.)... 90660 Inverter Module Bracket... 5 6605009 Screw (M x 0 mm, T0 Torx Hd.)... 6 909900 Inverter Module... 7 57060005 Rubber Pad... 8
Figure D DIGITAL INVERTER GENERATOR ITEM NUMBER RYi00GR 8 6 6 7 0 7 9 0 5 5 8 9 9
DIGITAL INVERTER GENERATOR ITEM NUMBER RYi00GR The model number will be found on a label attached to the back cover. Always mention the model number in all correspondence regarding your DIGITAL INVERTER GENERATOR or when ordering parts. PARTS LIST FIGURE D 687000 Front Cover... 76095005 Reset Button... 7605006 Auto Idle Switch... 870900 Connector (Black)... 5 78050007 Circuit Breaker (0A)... 6 900007 0 Volt Duplex Receptacle (0 Amp)... 7 5700 Receptacle Cover (Front)... 8 57005 Receptacle Cover... 9 5700 Clip... 0 679900 Spring... 686005 Flat Washer (OD0 x ID5. x 0.5t)... 67800 Lock Washer (OD9 x ID5 x.t)... 67806008 Hex Nut (M5)... 66097600 Bolt (M5 x 6 mm, Pan Hd.)... 5 660505 Bolt (M x 0 mm, T5 Torx Hd.)... 6 69096900 Washer (OD0 x. x t)... 7 66500 Hex Nut (M)... 8 90505 Internal Wire Assembly... 9 9000 Ground Wire... 0 6609000 Screw (M6-0 x 0.8 mm, T5 Torx Pan HD.)... 5970705 Electrical Panel Housing... 67806009 Wing Nut (M5)... 70900 Indicator (Red LED.V-mA)... 0
Figure E DIGITAL INVERTER GENERATOR ITEM NUMBER RYi00GR 5 0 7 6 5 8 9 0 5 6 7 0 9 8 0 6 9 8 9 6 7 8 5 7 Not all parts shown on the exploded view are available. Some parts are shown to identify position and location of parts that are available.
DIGITAL INVERTER GENERATOR ITEM NUMBER RYi00GR The model number will be found on a label attached to the back cover. Always mention the model number in all correspondence regarding your DIGITAL INVERTER GENERATOR or when ordering parts. PARTS LIST FIGURE E 00005 Oil Dipstick... 075700 Fan... 95 Bolt (M6 x mm)...5 050 Low Oil Sensor... 5 07705 Rotor... 6 07705 Stator... 7 678890 Alternator Cover... 8 689706 Muffler Heat Shield... 9 6870 Spark Arrestor... 0 08990055 Muffler... 99 Bolt (M6 x 6 mm)... 0590 Exhaust Valve... 0600 Valve Spring... 080 Plate... 5 0080 Valve Lock Clamp... 6 96006 Gasket (Over Head Cover)... 7 00 Over Head Cover... 8 080 Inlet Valve Spring Seat... 9 070 Inlet Valve... 0 970 * Spark Plug... 7605000 RPM Sensor... 50005 Governor Motor Housing... 679900 Compression Spring... 00 Thermal Insulation Seat (Carburator)... 5 96 Paper Gasket... 6 96009 Air Box Gasket... 7 588005 Air Filter Assembly... 8 570587 Fuel Hose (6 mm)... 9 6780900 Fuel Line Clamp (7/6 in.)... 0 956 Breather... 96007 Gasket (Connection Block)... 0805 Carburetor... 8500005 Ignition Coil... 6699600 Engine Recoil... 5 0000 Stepper Motor... 6 0805 Carburetor Assembly (Incl. Key Nos., & 5)... 7 090 Engine Cover... 8 9 Bolt (M6 x 0 mm)...5 9 060 Lifter Valve... 0 090 Pushing Rod... 96008 Gasket (Muffler)... * STANDARD HARDWARE ITEM MAY BE PURCHASED LOCALLY
DIGITAL INVERTER GENERATOR ITEM NUMBER RYi00GR Parallel Connectors Main Winding Sub Winding DC Winding Generator Block This connector doesn t need to be connected to anything on this model Main Input power Control and Indicator Signal Stepper Motor Control Inverter Block Noise Filter (AC) 0V / 0 A Duplex Receptacle Ground Terminal Reset push button Press to remove overload condition Overload Red LED Indicator Auto Idle On / Off Switch Inverter Module Ground Terminal G W B Y R P WIRES COLOR CODES Green White O BI Orange Black Blue Lb Light Blue Yellow Br Brown Red Gr Gray Pink G / Y Green / Yellow Control Panel Block Spark Plug Ignition Coil Exciter Winding Ignition Pulse Generator Oil Level Switch Throttle Control Motor Engine Ground Engine Block Frame Block Engine On / Off Switch Wiring Diagram