FBA-C, FBA-C CHAPTER 77 ENGINE INDICATING 77-00 Page July 4, 0
FBA-C, FBA-C List of Effective Pages Chapter / Section Page No. Date Chapter / Section Page No. Date 77-00 Jul 4, 0 Jul 4, 0 77-05 Jul 4, 0 Jul 4, 0 3 Jul 4, 0 4 Jul 4, 0 77-3 Jul 4, 0 Jul 4, 0 77-4 Jul 4, 0 Jul 4, 0 77-40 Jul 4, 0 Jul 4, 0 3 Jul 4, 0 4 Jul 4, 0 5 Jul 4, 0 6 Jul 4, 0 7 Jul 4, 0 8 Jul 4, 0 9 Jul 4, 0 0 Jul 4, 0 Jul 4, 0 Jul 4, 0 77-00 Page July 4, 0
FBA-C, FBA-C Figure GROUP Engine Indicating And MAJOR ASSEMBLY Engine Instrument Cluster (C/C) Index Number PART No. DESCRIPTION Effect. Vendor Ident. Units Per Assy - - - -3-4 -5-6 -7-8 -9-0 - - -3 No Number 7740-00478 MS306R-S-3S MS330-5 MS454-3 U645-00 05839-3 8655 MS448-4PC50G MS8034- No Number 34-04 AGC No Number 34-04 AGC -370-70 Engine Instrument Cluster & Transducers Fuel Sender Cannon Connector Circuit Breaker DPDT Switch Engine Instrument Cluster Circular Connector EGT Probe CHT Probe Oil Pressure Sender Oil Temperature Sender Fuse Assembly Fuse Holder Fuse, Ampere Fuse Assembly Fuse Holder Fuse, Ampere Shunt, 50mV @ 70 Amps ROG TIN SIG AMP ALC HON LTF LTF SIG 77-05 Page July 4, 0
MASTER ON ALT. ENABLE VOLTAGE OVER UNDER STALL WARNING Normal Category: No acrobatic maneuvers including spins, approved. Flight into known icing conditions prohibited. This airplane is certified for the following flight operations: DAY-NIGHT-VFR-IFR (With required equipment) MANEUVER SPEED = 4 KIAS The markings and placards installed in this airplane contain operating limitations which must be complied with when operating this airplane in the Normal Category. Other operating limitations which must be complied with when operating this airplane in this category are contained in the Airplane Flight Manual. To apply parking brake depress brake pedals and pull parking brake handle To release parking brake depress brake pedals and push parking brake handle Parking Brake Handle AUX. AVIONICS FUEL MASTER NAV. LTS TAXI LIGHT 0 0 LAND. LTS 0 30 STROBE LIGHT FLAPS UP DOWN PITOT HEAT BACKUP INTERIOR POWER LIGHT DIMMER CONTROLS ZONE ZONE ZONE3 AUX. STALL GEAR GEAR GEAR ALT VOLT. IGN FUEL WARN MOTOR CNTRL ADV. FLD REG. SW PITOT FLAP FLAP INSTR. TURN MAN TACH FUEL HEAT MOTOR IND CLUSTER CO-OR PRESS FLOW NAV. STROBE TAXI LAND INTER PULSE PULSE PANEL LTS LTS LTS LTS LTS CNTRL LT LTS COMM NAV COMM NAV HOBBS Vdc ENG AUDIO GPS GPS METER AUX. MONITOR INT XPNDR ADF DME AUTO A P HSI AVN BLIND PILOT ALERT FAN ENC. NO SMOKING FASTEN SEATBELTS DO NOT RELY ON FUEL FLOW INSTRUMENT TO DETERMINE FUEL LEVEL IN TANKS 3.75 V.D.C. 4 AMP CONT. 5 AMP MAX. FIRE EXTINGUISHER LOCATED UNDER PILOT SEAT Illustrated Parts Catalog FBA-C, FBA-C 3 4 9,0 8 6,,3 7 XP 5 Figure (Sheet ) Engine Instrument Cluster & Transducers (C/C) 77-05 Page July 4, 0
FBA-C, FBA-C 3 4 5 0 9 8 7 6 3 Figure (Sheet ) Engine Instrument Cluster & Transducers (C/C) 77-05 Page 3 July 4, 0
FBA-C, FBA-C INTENTIONALLY LEFT BLANK 77-05 Page 4 July 4, 0
FBA-C, FBA-C Figure GROUP And Index MAJOR ASSEMBLY Number PART No. Engine Indicating Manifold Pressure (C/C) DESCRIPTION Effect. Vendor Ident. Units Per Assy - - - -3-4 -5-6 -7-8 No Number X3-4 AN94-4D AN960-86 X3-3 AN85-4D X3- M- MS330- Manifold Pressure System Tube, Gauge to Fire Wall Bulk Head Fitting Washer Hose, Fire Wall to Engine Baffle Union Tube, Engine Baffle to Engine Fitting Manifold Pressure Gauge Circuit Breaker Ampere 77-3 Page July 4, 0
MASTER ON OVER VOLTAGE STALL WARNING ALT. ENABLE UNDER Normal Category: No acrobatic maneuvers including spins, approved. Flight into known icing conditions prohibited. This airplane is certified for the following flight operations: DAY-NIGHT-VFR-IFR (With required equipment) MANEUVER SPEED = 4 KIAS To apply parking brake depress brake pedals and pull parking brake handle To release parking brake depress brake pedals and push parking brake handle Parking Brake Handle AUX. FUEL The markings and placards installed in this airplane contain operating limitations which must be complied with when operating this airplane in the Normal Category. Other operating limitations which must be complied with when operating this airplane in this category are contained in the Airplane Flight Manual. AVIONICS MASTER NAV. LTS TAXI LIGHT 0 0 LAND. LTS 0 30 STROBE LIGHT PITOT HEAT BACKUP POWER INTERIOR LIGHT DIMMER CONTROLS ZONE ZONE ZONE3 AUX. FUEL PITOT FLAP HEAT MOTOR COMM NAV COMM NAV HOBBS Vdc ENG AUDIO GPS GPS METER AUX. MONITOR INT XPNDR STALL GEAR GEAR GEAR WARN MOTOR CNTRL ADV. NAV. STROBE TAXI LTS LTS LTS ADF DO NOT RELY ON FUEL FLOW INSTRUMENT TO DETERMINE FUEL LEVEL IN TANKS FLAP INSTR. TURN MAN TACH IND CLUSTER CO-OR PRESS DME LAND LTS AUTO A P PILOT ALERT ALT FLD INTER PULSE PULSE PANEL LTS CNTRL LT LTS HSI VOLT. REG. AVN FAN IGN SW FUEL FLOW BLIND ENC. 3.75 V.D.C. 4 AMP CONT. 5 AMP MAX. Illustrated Parts Catalog FBA-C, FBA-C 8 7 4 3 3 5 7 6 XP FLAPS UP DOWN NO SMOKING FASTEN SEATBELTS FIRE EXTINGUISHER LOCATED UNDER PILOT SEAT 8 Figure Manifold Pressure System (C/C) 77-3 Page July 4, 0
FBA-C, FBA-C Figure GROUP And Index MAJOR ASSEMBLY Number PART No. Engine Indicating Electric Tachometer (C/C) DESCRIPTION Effect. Vendor Ident. Units Per Assy - - - No Number MS330- R--6 Electric Tachometer Circuit Circuit Breaker Ampere Electric Tachometer EIT 77-4 Page July 4, 0
MASTER ON OVER VOLTAGE STALL WARNING ALT. ENABLE UNDER Normal Category: No acrobatic maneuvers including spins, approved. Flight into known icing conditions prohibited. This airplane is certified for the following flight operations: DAY-NIGHT-VFR-IFR (With required equipment) MANEUVER SPEED = 4 KIAS To apply parking brake depress brake pedals and pull parking brake handle To release parking brake depress brake pedals and push parking brake handle Parking Brake Handle AUX. FUEL The markings and placards installed in this airplane contain operating limitations which must be complied with when operating this airplane in the Normal Category. Other operating limitations which must be complied with when operating this airplane in this category are contained in the Airplane Flight Manual. AVIONICS MASTER NAV. LTS TAXI LIGHT 0 0 LAND. LTS 0 30 STROBE LIGHT PITOT HEAT BACKUP POWER INTERIOR LIGHT DIMMER CONTROLS ZONE ZONE ZONE3 AUX. STALL GEAR GEAR GEAR FUEL WARN MOTOR CNTRL ADV. PITOT FLAP FLAP INSTR. TURN MAN TACH FUEL HEAT MOTOR IND CLUSTER CO-OR PRESS FLOW NAV. STROBE TAXI LTS LTS LTS COMM NAV COMM NAV HOBBS Vdc ENG AUDIO GPS GPS METER AUX. MONITOR INT XPNDR ADF DO NOT RELY ON FUEL FLOW INSTRUMENT TO DETERMINE FUEL LEVEL IN TANKS DME AUTO PILOT A P ALERT ALT FLD LAND INTER PULSE PULSE PANEL LTS LTS CNTRL LT LTS HSI VOLT. REG. IGN SW AVN BLIND FAN ENC. 3.75 V.D.C. 4 AMP CONT. 5 AMP MAX. Illustrated Parts Catalog FBA-C, FBA-C XP FLAPS UP DOWN NO SMOKING FASTEN SEATBELTS FIRE EXTINGUISHER LOCATED UNDER PILOT SEAT Figure Electric Tachometer Circuit (C/C) 77-4 Page July 4, 0
FBA-C, FBA-C Figure And Index Number GROUP Engine Indicating MAJOR ASSEMBLY Engine Integrated Instrument System (C3 & C4) PART No. DESCRIPTION Effect. Vendor Ident. Units Per Assy - - - No Number MVP 50P-6 MS354-3 Engine Monitor Display Head MVP 50-P Display Head Screws 4 77-40 Page July 4, 0
FBA-C, FBA-C Figure Engine Monitor Display Head Installation (C3/C4) 77-40 Page July 4, 0
FBA-C, FBA-C Figure And Index Number - - - -3-4 -5-6 -7-8 GROUP Engine Indicating MAJOR ASSEMBLY Engine Integrated Instrument System (C3 & C4) PART No. DESCRIPTION No Number PT-30ALT PT-05DIFF PT-30ABS RFLM-4-4 EDC-33P 3060- MS3506-8 MS4693S50 EDC Panel Assembly Altitude Pressure Transducer Differential Pressure Transducer Absolute Pressure Transducer Resistive Level Fuel Module Electronic Data Converter /4 x /8 Straight Reduction Connector Screw Screw Effect. Vendor Ident. Units Per Assy 4 8 77-40 Page 3 July 4, 0
FBA-C, FBA-C 4 PLACES 6 7 8 PLACES 4 3 5 8 PLACES Figure EDC Panel Assembly (C3/C4) 77-40 Page 4 July 4, 0
FBA-C, FBA-C FBA C3 Models Figure And Index Number GROUP Engine Indicating MAJOR ASSEMBLY Engine Integrated Instrument System (C3 & C4) PART No. DESCRIPTION Effect. Vendor Ident. Units Per Assy 3- - - -3-4 -5-6 -7-8 -9 No Number AN94-4 AN960-76L AE3660000E034 AN86-4D AN837-4 X095 AN90-D 860-05-00659 Manifold Pressure System Nut Washer Flex Line Fitting Bulkhead Fitting Rigid Line Coupling Fitting Hose 77-40 Page 5 July 4, 0
FBA-C, FBA-C 9 8 7 4 6 5, FIREWALL Manifold Pressure System EDC Panel to Firewall, 3 Manifold Pressure System Firewall To Engine 4 Figure 3 Manifold Pressure System (C3/C4) 77-40 Page 6 July 4, 0
FBA-C, FBA-C Figure And Index Number 4- - - -3-4 -5-6 -7 GROUP Engine Indicating MAJOR ASSEMBLY Engine Integrated Instrument System (C3 & C4) PART No. DESCRIPTION No Number AN94-4 P-0 Hose Clamp, Type K P-00 3/8-4, Type K FT-90 P-0 PT-00GA P-8 3/8x8, Type K Engine Sensor Locations Fuel Sender EGT Probe CHT Probe Fuel Flow Transducer Oil Temp Probe Oil Pressure Transducer OAT Probe Effect. Vendor Ident. Units Per Assy 6 6 77-40 Page 7 July 4, 0
FBA-C, FBA-C 7 6 5 4 3 Figure 4 Engine Sensor Locations (C3/C4) 77-40 Page 8 July 4, 0
FBA-C, FBA-C Figure And Index Number 5- - - -3-4 -5-6 GROUP Engine Indicating MAJOR ASSEMBLY Engine Integrated Instrument System (C3 & C4) PART No. DESCRIPTION No Number MS3506-8 PT-05Diff 4060- X093 MS047L06 QS00M-60H Vacuum Pressure Transducer Screw Transducer Fitting Mounting Bracket Nutplate Hose Clamp Effect. Vendor Ident. Units Per Assy 77-40 Page 9 July 4, 0
FBA-C, FBA-C Attitude Gyro (U49-00-5) 5 6 4 3 Figure 5 Vacuum Pressure Transducer Installation (C3/C4) 5 77-40 Page 0 July 4, 0
FBA-C, FBA-C Figure And Index Number 6- - - -3-4 -5 GROUP Engine Indicating MAJOR ASSEMBLY Engine Integrated Instrument System (C3 & C4) PART No. DESCRIPTION No Number Engine Monitor Switch Panel AL-R Check Engine Light X59 Placard AV-7CP Voice Alarm Switch L933 Attenuated Post Light 70SYZQE Switch Effect. Vendor Ident. Units Per Assy 77-40 Page July 4, 0
FBA-C, FBA-C (Flight Panel) 3 4 5 Figure 6 Engine Monitor Switch Panel (C3/C4) 77-40 Page July 4, 0