SC500 Parts List /0 revised 4/08 REV M Form no. 560459 Models: 560400(SC500-5D) Obsolete Models: 5604003(SC500-5D EcoFlex)
PARTS LIST revised 6/03 GENERAL VIEW 3 4 6 7 5 Item Ref. No. Qty Description Chassis System Control System 3 Electrical System 4 Recovery System Item Ref. No. Qty Description 5 Scrub System-0D 6 Solution System 7 Squeegee Assy ii SC500-560459 /0
revised 6/07 PARTS LIST TABLE OF CONTENTS DESCRIPTION PAGE Chassis System... -3 Drive Wheel Assembly... 4-5 Platform Assembly... 6-7 Control System... 8-9 Decal System... 0- Electrical System... -3 Recovery System... 4-5 Scrub System-0D... 6-7 Solution System... 8-9 Squeegee System... 0- Ladder Diagram- Before July 04... -3 Ladder Diagram- Before July 04... 4-5 Ladder Diagram- After June 04... 6-7 Ladder Diagram- After June 04... 8-9 Optional Kits and Accessories... 30 Recommended Spare Parts... 3-3 Brush Selector Guide-Disk... 33 Squeegee Blade Selector Guide... 34 WHEN ORDERING PARTS * Use the part numbers from the Ref. No. columns in this parts list. If the Ref. No. column is blank; look under the Kit column to identify which kit contains the part in question, then use the kit callout, for example K, to find the Ref. No. for that kit. Kit Item Ref. No. Qty Description K 6 Washer Flat 3/6 Zinc Plat K Screw-BHS-Brass-0-3x3/8-MS K 3 3 Washer EPDM 7/3 X /8 4 805 Chain-Cover 5 905 Caster Swivel 4 Gray Non MA K 6 Nut, Hex Nyl Loc 0-4 K 7 3 Scr- Hex SS /4-0 X.75 K 8 6 Scr, Hex Hd Loc /4-0 x.50 K 9 3 Wsh, Flt SS.60 X.000 X.074 0 5630 Solution Tank 563034 Hinge Plate K 56303 Kit-Hardware Solution Tank * Specify the model number and serial number of the machine. * Use the space below to record the model number and serial number for future reference. Model No. Serial No. /0 560459 - SC500
PARTS LIST revised 4/08 CHASSIS SYSTEM 9 6 48 43 3 6 3 5 39 6 5 9 30 5 5 9 8 9 0 33 4 44 47 50 5 39 3 49 33 4 56 6 8 6 0 37 35 34 38 8 3 7 7 46 40 4 4 8 4 46 45 36 7 59 53 43 54 39 6 4 39 58 57 SC500-560459 /0
revised 4/08 PARTS LIST CHASSIS SYSTEM Kit Item Ref. No. Qty Description K,K4 # Washer Flat Xl 9.0 x 3.0 x.5 K4 4 Screw, Hex Hd M8 x 45- K,K4 3 Screw, Hex Thd To Hd M8 x 0 SS K4 4 8 Nut, Hex Nyl Loc Thin M0 5 Intentionally Omitted K4 6 7 Washer, Flat 6,4 X,5 K4 7 4 Washer, Flat 8.4 X 6 X.6 K4 8 4 Scr-Hex Hd Loc 3/8-6 x.6 K4 9 4 Scr-Hex M8-.5 X 6MM K3 0 Nut, Hex Nyl Loc-Thin -4 K4 Key-Wdf 5MMX6.5MMX6MM K4 8 Scr-Soc Shd Mx6mmx M0-.50 K4 4 Wsh, Int Shprf #0 K 5 Wheel 6 560409 Mounting Tab 7 Drive Wheel Assembly 8 5604094 Bar Linkage 9 560405 Battery Tray 0 560430 Steering Shaft 560435 Link Bar 560448 Steering Shaft Weldt 3 56045 Spindle Mount Weldment 4 560457 Collar 5 5604448 Chassis Weldment K4 6 6 Bushing Link Arm K5 7 Harness-Drive Motor Kit Kit Item Ref. No. Qty Description 8 560469 Sprocket- Tooth K 9 Universal Joint 30 Platform Assembly 3 560439 Tube-Steering Assembly TSB-FC-04-00 K4 3 Screw Cap 33 560467 Bearing Flange K3 34 Bearing Cup K3 35 Bearing Cone K3 36 Seal, Shaft 37 563403 Block, Bearing K3 38 Bearing Ball K4 39# Clamp Black K4 40 Chain - Ball K4 4 Screw Grub M5 x 0 Uni599 K4 43 4 Scr, Pan Phil M5 x 6 K4 44 3 Screw, Hex Thd To Hd M6 x 4 K4 45 5 Flat Tie Holder K4 46 5 Thread Rolling Scr 5 X 6 K4 47 3 Washer, Flat Xl K4 48 3 Scr, Pan Phil M6 x 6 K4 49 4 Washer, Flat Xl 9.5 X 7 X.5 50 909 556 000 Clamp 8 K4 5 4 Washer Flat Xl Uni-6593 8 x 4 5 33005604 Nut Hex Nyl Loc Thin M6 53 909996000 Spacer 5.5 X 8 X 3 K4 54 Scr 4.8 X 6 UNI6954 Thd Form 55# DELETED K5 56 Scr Pan Phil 0-4 X.50 K5 57 Nut-Hex Nyl Loc SS.5-0 K5 58# Wsh-Ext-Ser-SS-.5 K5 59# Scr-Carr-SS-/4-0X.675 K5 [60] 5.35 in Cable Tie Black Nylon SERVICE KITS K 560438 Universal Joint Kit K 560433 Rear Wheel Kit K3 560433 Bearing Block Kit K4 5604333 Chassis Hardware Kit K5 5638536 Harness-Drive Motor Kit [ ] = Not Shown # = Revised or new since last update /0 560459 - SC500 3
PARTS LIST DRIVE WHEEL ASSEMBLY revised 9/03 6 0 4 4 30 3 0 3 5 7 7 6 7 8 6 34 5 3 9 3 4 7 8 5 9 33 7 5 5 3 8 9 7 4 SC500-560459 /0
revised /07 PARTS LIST DRIVE WHEEL ASSEMBLY Kit Item Ref. No. Qty Description Drive Wheel Assembly K7 Sprocket Assy TSB-FC-03-3 K7,K8 Bushing, Flanged K5,K8 3 4 Viti Tcei/Scr, Soc Hd K8 4 Scr-Soc Hd 5/6-8 X.50 K8 5 Nut, Hex Nyl Loc-Thin 5/6-8 K7,K8 6 Wsh-Flt Sae Ss 5/6 K5,K6,K7 7 Key-Wdf 5mmx6.5mmx6mm K6,K8,K9 8 4 Scr-Carriage Ss M8-.5 X 0mm K6 9 Drive Wheel 0 5604793 Drive Wheel Frame Weldment (used after September 03) NOTE 5604498 Drive Weldment Kit (used before October 03) K6 Axle TSB-FC-04-00 K6,K9 Axle Bearing K5 3 Drive Wheel Motor (M) TSB-FC-05-0 * 5638400 Electromagnetic Brake Kit NOTE 4 5604077 Spindle Weldt K5 5 Spacer 6 56045 Steering Plate K5,K6,K8,K9 7 8 Washer, Flat 8x7x.6 Ss K7 8 Sprocket-5 Tooth TSB-FC-03-3 K7 9 Sprocket- Tooth TSB-FC-03-3 0 560470 Chain-Roller K7 Chain-Roller K7 Weld t-idler Adjust K6 3 Key, 6mm Sq K7,K8 4 Screw, Hex Thd To Hd M6x35 Ss K5,K6,K8,K9 5 5 Nut, Hex Nyl Loc Thin M8 Ss K5,K6,K8 6 4 Screw, Hex Thd To Hd M6x5 Ss K8 7 4 Screw, Hex Thd To Hd M8x30 Ss K7,K8 8 Nut, Hex M6 Ss K7,K8 9 Screw, Hex Thd To Hd M8x55 Ss K8 30 4 Spacer K8 3 Spacer K6 3 33006059 Ring D 0 UNI7435 TSB-FC-04-00 K6 33 56003959 Wsh-Flt A DIN90 0.5X30X.5 TSB-FC-04-00 K6 34 56003533 Scr Hex SS M0-.50X0MM TSB-FC-04-00 SERVICE KITS K5 5604336 Drive Wheel Motor Kit K6 5604338 Wheel And Bearing Kit K7 5604435 Sprocket And Chain Kit (used with 560443) K7 5604339 Sprocket And Chain Kit (used with 5604498) K8 5604340 Drive Wheel Hardware Kit K9 5604384 Front Wheel Bearings Kit * = Optional, Not Included NOTE : Electromagnetic Brake Kit 5638400 can be used to replace Brake-Electromagnetic 56384098 as a separate repair part for the Drive Wheel Motor. NOTE : 5604793 replaces 560443. /0 560459 - SC500 5
PARTS LIST revised /06 PLATFORM ASSEMBLY 6 4 4 7 4 0 5 4 9 3 8 9 3 6 SC500-560459 /0
revised /06 PARTS LIST PLATFORM ASSEMBLY Kit Item Ref. No. Qty Description Platform Assembly K 6 Washer TSB-FC-04-043 NOTE K 6 Scr-Pan Phil Plast M6x.5x6mm K 3 Scr-Pan Phil Plast M6x.5x0mm K 4 4 Scr-Pan Phil Plast M5x.3x0mm 5 560405 Platform-Upper 6 560485 Pedal-Safety 7 56384567 Pedal-Foot TSB-FC-06-65 8 560487 Platform-Bottom 9 56384579 Spring-Compression-M/W-.480 OD NOTE 0 5604406 Switch Harness (S, S5) 5658690 Grommet 5633006 Grommet 3 56384568 Spring-Compression-SS-.480 OD NOTE K 4 Washer SERVICE KITS K 560447 Platform Hardware Kit NOTE : TSB-FC-04-043 All machines built prior to SN3504470663 order and install Neoprene Washer PN 56096. Note that the Neoprene Washer has been replaced by Washer, part number 456000. NOTE : To replace a spring on machines built before July 05, order () of 56384579 and () of 56384568. All three springs should be replaced at the same time for these machines. /0 560459 - SC500 7
PARTS LIST CONTROL SYSTEM revised 6/03 5 4 3 5 0 3 3 7 4 6 8 4 8 SC500-560459 /0
revised 9/03 PARTS LIST Kit Item Ref. No. Qty Description K3 Washer, Flat 3X4 K3 Key-Wdf 5mmX6.5mmX6mm 3 5604053 Control Panel K3 4 Collar 5 560496 Shaft Steering 6 560465 Shaft Hex K 7 Universal Joint K 8 Hook Latch K3 0 Bearing-Flange 560440 Bracket-Prop Rod 5660060 Steering Wheel K3 3 Nut, Hex Nyl Loc Thin M K,K3 4 4 Scr, Pan Phil M5x0 Ss K3 5 Screw Grub M5x0 Uni599 SERVICE KITS K 560438 Universal Joint Kit K 560435 Draw Latch Kit K3 5604365 Control Hardware Kit CONT ROL SYSTEM /0 560459 - SC500 9
PARTS LIST revised 7/04 DECAL SYSTEM 4 4 3 5 6 0 SC500-560459 /0
revised 0/04 PARTS LIST Kit Item Ref. No. Qty Description K,K Decal, Caution K,K Decal-Chemical Ratio K,K 3 Decal, Nilfisk K 4 Decal-Nilfisk SC500 K 4 Decal-Nilfisk SC500 Ecoflex K,K 5 Decal-Error Codes K,K 6 Decal-SC500 QR Code SERVICE KITS K 5604335 SC500 EU Decal Kit K 560448 SC500 EU Ecoflex Decal Kit DECAL SYSTEM /0 560459 - SC500
PARTS LIST ELECTRICAL SYSTEM revised 4/08 35 4 9 43 30 8 8 3 5 7 0 7 8 0 7 9 4 3 5 3 36 6 3 40 39 SC500-560459 /0 6
revised 4/08 PARTS LIST ELECTRICAL SYSTEM Kit Item Ref. No. Qty Description 560443 Circuit Breaker 50 Amp (CB) # DELETED 3# DELETED 4# DELETED 5# 4 Washer, Flat 6,4x,5 K 6 3 Scr-Pan Phil /4-0 X.38 K 7 5 Nut, Hex W/ Shprf /4-0 K 8 3 Stud [9] 5604444 Harness-Main K 0 Interface Panel Assembly (A) K3 * Interface Panel Kit 560476 Solid State Relay (K) 560493 Electrical Panel 3 560443 Speed Controller (E) 4 560447 Disconnect-Emergency 5# DELETED 6# DELETED 7 563555 Circuit Breaker, 5 Amp (CB) 8 Potentiometer, 00k (R / part of Main harness) 9 5604438 3 Cable-Battery Assy 0 564089 Fuse, 50 Amp (F) 56438 Circuit Breaker, 0 Amp (CB3) 56469858 3 Electrical Mount 3 5650963 Circuit Breaker-5 Amp (CB4) 4# DELETED 5 566083 Contactor 4v, 00 Amp (K) K 6 Washer, Flat Xl 5,5x5x, Ss K 7 Viti Tcei/Scr, Soc Hd K 8 4 Scr, Pan Phil M5x6 9 46 888 000 Switch, Key With Water Proof Cup (S) * 46 887 000 Key PCS K 30 4 Cover For Screw Tcb 4.8mm K 3 Scr, Pan Phil M6x K 3 Scr, Pan Phil M4x0 33 Intentionally Omitted 34 Intentionally Omitted 35 5096A Knob, Speed Control K 36 Screw M5x Hex Hd F/Thd IS0407 37 Intentionally Omitted 38 Intentionally Omitted 39 566503 Rectifier 35 Amp (D) 40 460497000 Screw Hex HD M4X6 SS 4 5638965 Rectifier Assy. (D) 4# DELETED 43# 56385490 Batt Panel Harness Assy Kit [ ] 560445 Wire Assy White [ ] 560444 Wire Assy Black SERVICE KITS K 560434 Electrical Hardware Kit K 5638404 Control Board Kit K3 560437 Interface Panel Kit [ ] = Not Shown * = Optional, Not Included # = Revised or new since last update /0 560459 - SC500 3
PARTS LIST RECOVERY SYSTEM revised 4/08 6 36 37 8 7 0 9 8 5 3 4 30 0 4 6 35 8 6 34 33 4 5 7 5 9 7 3 9 3 3 4 4 SC500-560459 /0
revised 4/08 PARTS LIST Kit Item Ref. No. Qty Description K Latch, Draw K7 # 3 Screw M6x0 Wn45 Black Zn K7 3 3 Washer, Flat 6,4x,5 S.S. K,K5,K7 4 3 Washer, Flat 4,3x9 K7 5 3 Rivet, Nylon Tree Push-In (.5) 6# 56394039 Recovery Tank NOTE K4 7 Debris Cage K4 8 Debris Tray Cover 9 560458 Back Panel 0 560464 Gasket-Recovery Tank 560458 Vac Hose Assy 560485 Drain Hose [3] 5604306 Jumper Harness TSB-FC-06-66 4 5604443 Guard-Splash-4X-Poly K8 5 Vacuum Motor Support Gasket K6 6 Gasket, Vacuum Motor 7 450543000 Hose Clamp 4/3-5 K3,K7 8# 4 Washer, Flat Xl 5,5x5x, SS 9 9000046 Cover Vacuum Motor K,K5,K7 0 3 Viti Tcei/Scr, Soc Hd K8 Insulation Tube K8 Panel, Acoustic Insulation K7 3 3 Plate Cover 4# 5634468 Filter K6 5 Vacuum Motor 3 Stage 4v (M4) K3 6 Gasket Float Support K3 7 Float Cage-Complete K,K5,K7 8 3 Nut, Hex Nyl Loc Thin M4 Ss K3,K7 9# 4 Scr,Pan Phil M5x6 SS K5 30 Clamp, Hose D.50 3# Intentionally Omitted 3# L088587 Tie Cable 4.8x430 White 33# 9096595000 Flat Tie Holder 34# 909799000 Screw Cyl Hd 5X6 Self L. Plas 35# 56385083 Tank Support Assembly 36# 56003975 Nut Hex Nyl Loc SS M5-0.8 37# 5600933 Wsh-Flt SS.0 X.56 X.040 SERVICE KITS K 560435 Draw Latch Kit K3 5604389 Float Cage EU Kit K4 5604360 Debris Cage Kit K5 560436 Hose Clamp Kit K6 5604363 Vacuum Motor Kit K7 5604364 Recovery Hardware Kit K8 5604383 Vacuum Motor Insulation Kit [ ] = Not Shown # = Revised or new since last update RECOVERY SYSTEM NOTE : To replace an old style recovery tank (PN 560405) order 56394063 Recovery Tank Kit. /0 560459 - SC500 5
PARTS LIST SCRUB SYSTEM-0D revised /07 6 43 3 5 5 38 3 5 4 5 8 4 4 36 8 7 3 40 4 7 40 8 4 34 0 34 35 3 9 6 3 30 33g 6 7 39 9 37 9 33 33c 33f 33d 33b 0 33e 33a 33h 6 SC500-560459 /0
revised /07 PARTS LIST Kit Item Ref. No. Qty Description K Washer 8x3x.5uni6593 0 Pcs K Screw, Hex Thd To Hd M6x50 K 3 4 Screw, Flat Socket Head K 4 Nut, Hex Nyl Loc Thin M5 K 5 Nut, Hex Nyl Loc Thin M8 K 6 3 Washer M8 Uni75b 0 Pcs Set K 7 3 Washer, Flat 8.4X6X.6 K 8 Rivet, Nylon Tree Push-In (.5) K 9 Key, Square.5 X.44 K 0 Scr-Soc Hd 5/6-8 X.5 Zinc K Scr-Hex Thd Form M6 X 0mm K Scr-Soc Shd M6xmm X M5-0.8 K 3 Scr-Soc Shd M8x6mm X M6-.00 K 4 Scr-Hex Plastic M8-.5 X 6MM K 5 Wsh, Bowed.66X.500X.060 6 560407 Disc Brush Motor (A-F) (M5) 7 5604095 Shaft Disc Brush Motor 8 56047 Deck Lift Plate Weldment 9 56040 Lower Deck Plate 0 5604 Brush Housing 56046 Squeegee Link Weldment K Squeegee Pivot Block K 3 Bearing Flange K 4 Squeegee Pivot Washer 5 560437 Spacer Motor 6 560469 Solenoid Valve Assy (L) 7 560440 Skirt Brush 8 56044 Double Scrub Brkt 9 5634983 Tee Assembly 30 5638683 Barbed Elbow 90 3 56384076 Hose-Pvc-.50x3.50 3 563977 Hose, Pvc Clear SCRUB SYSTEM-0D Kit Item Ref. No. Qty Description 33 5660733 Brush Plate Assy Rt 33a 56366455 Plate, Stop K 33b Wsh, Flt Std #0 K 33c Wsh, Flt.66 X.906 X.060 K 33d 4 Scr, Pan Phil Plastite 0-4 X.38 33e 5609653 Spring Retainer 33f 565 Gimbal-Collar Assembly 33g 5660056 Spring, Brush Holder 33h 56608 Brush Plate K 34 Scr, Pan Hd Thd Form K 35 Washer, Flat Xl 5,5X5X, Ss K 36 Key 37 909 5483 000 Hose Holder K 38 Screw, Hex Thd To Hd M8x6 Loctite K 39 3 Screw, Hex Thd To Hd M8x30 Ss K 40 3 Nut, Hex Nyl Loc Thin M6 Ss K 4 Washer, Flat Xl Ss K 4 Screw Cyl Hd M5x K 43 45054000 Tie, Cable 4.8 X 00 Black Kit Item Ref. No. Qty Description A 560497 Motovario Gearbox 5/ B 560498 Motor C 5604300 Brush Housing Assembly D 5660588 Cover And Screws E 5660508 Plastic Cover F 5660534 Carbon Brushes () SERVICE KITS K 5604344 Squeegee Pivot Kit K 5604346 Disc Deck Hardware Kit 6 F F E A Key C B Cover and Screws D /0 560459 - SC500 7
PARTS LIST SOLUTION SYSTEM revised 9/04 c b 5 43 4 33 4 a d 3 5 3 5 9 3 30 0 9 7 4 37 3 9 8 7 3 3 40 3 35 39 34 3 36 7 4 0 38 45 46 6 3 5 6 5 8 44 7 6 3 4 8 SC500-560459 /0
revised /06 PARTS LIST SOLUTION SYSTEM Kit Item Ref. No. Qty Description K5,K7 Screw, Hex Thd To Hd M0x50 K5,K7 Nut, Hex Nyl Loc Thin M8 K6,K7 3 8 Washer, Flat 8.4x6x.6 K7 4 Nut, Hex Nyl Loc-Thin Ss 3/8-6 K7 5 0 Scr-Hex M8-.5 X 6mm K5,K7 6 Scr-Soc Shd M0x50mm X M8-.5 K7 7 3 Wsh, Flt.66 X.906 X.060 8 5604050 Solution Tank K6 9 Tip Pad 0 560465 Filter Bracket 5604445 Bracket-Tank Support Hinge Assembly a 560406 Hinge Pin b 560407 Hinge Weldment c 560408 Hinge Bracket d 560449 Bearing Flange 3 56049 Grommet 4 556A Hosebarb 3/8 X 90 Deg 5 560434 Actuator Brkt K5 6 Actuator Assembly (M3) TSB-FC-06-7 7 5604308 Pivot Block K5 8 Spacer Actuator K4 9 Rubber Solution Cap 0 5604390 Insert-Brass M8 560439 Adjustment Pad 5604409 Prop Rod K8 3 Fill Hose Support K4 4 Clip, Panel K7 5 Bushing 6 5639338 Hose-Pvc Clear Kit Item Ref. No. Qty Description K,K 7 Hose, Spiral.500 9 565044 Cap-Extra Vent K7 30 3 Washer, Flat Xl 5,5x5x, Ss K,K 3 4 Clamp, Hose 8/9-6clamp, Hose B3hs K7 3 6 Scr, Pan Phil M5x Ss K7 33 Screw K,K 34 Gasket 35 909 66 000 Buzzer 5-3v (H) K 36 Ball Valve 90 K8 37 Filling Hose K3 38 Filter, Water TSB-FC-03-7 K 39 Ball Valve K6,K7 40 8 Screw, Hex Thd To Hd M8x30 Ss K7 4 Nut, Hex Nyl Loc Thin M6 Ss K3,K7 4 Scr, Pan Phil M4x0 Ss K7 43 Washer, Flat Xl Ss K7 44 Scr,Pan Phil M5x6 Ss K 45 Hose, Solution K 46 Clamps F Solution System Kit SERVICE KITS K 5604349 Solution Drain Kit K 5604350 Solution Hose Kit K3 560435 Solution Filter Kit K4 5604354 Solution Cap Kit K5 5604356 Actuator Kit K6 5604357 Tip Pad Kit K7 5604358 Solution Hardware Kit K8 56355 Kit-Refilling Hose /0 560459 - SC500 9
PARTS LIST SQUEEGEE SYSTEM revised /05 4 9 6 3 7 8 8 9 3 5 0 3 7 7 4 9 3 6 4 5 5 9 6 30 3 9 0 9 4 5 8 9 3 8 3 0 SC500-560459 /0
revised /07 PARTS LIST Kit Item Ref. No. Qty Description K3,K4,K6 7 Washer, Flat 6,4X,5 S.S. K4,K6 Pin-Bow-Tie SS /4-3/8 X.7 K4,K6 3 Nut-Hex Jam Ss 3/8-6 K4,K5 4 4 Wsh-Flt.38 X.563 X.03 K4 5 56044 Squeegee Casting NOTE K4 6 56044 Squeegee Cover NOTE K4 7 Squeegee Lift Bracket K4,K8 8 Squeegee Bracket Weldment K4 9 Squeegee Plate K,K4 0 Blade-Squeegee Linatex Front NOTE K * Blade-Squeegee Pu Front NOTE K,K4 Blade-Squeegee Linatex Rear NOTE K * Blade-Squeegee Pu Rear NOTE K4,K6 56043 Caster Wheel TSB-FC-05-04 K4,K6 3 Roller Wheel K4,K8 4 Squeegee Mount Brkt K4,K8 5 Pivot Pin K4,K5 6 4 Retaining Ring K4,K7 7 Strap-Squeegee Rear K4,K5 8 4 Knob K4,K7 9 Latch-T Tab Assy K4,K6 0 Wheel K4,K6 Pin-Clevis.3 X.78 K4,K8 Pin Cover-6mm K4,K7 3 Nut, Hex Nyl Loc Thin M4 Ss K4,K6 4 3 Washer 8x4x Uni 6593 Ss K3,K4 5 6 Screw, Hex Thd To Hd M6x6 Ss K4,K8 6 Spring Acc. Lid Lh K4,K6 7 Screw Soc. Hd M6X45 K3,K4 8 Washer, Flat 5.3X0X Ss K3,K4,K6 9 7 Nut, Hex Nyl Loc Thin M6 Ss K4,K7 30 Scr, Pan Phil M4x0 Ss K3,K4 3 Screw, Hex Thd To Hd M5x0 SS K4,K5 3 L08603689 4 Flat Washer M6 X 8 SS SQUEEGEE SYSTEM SERVICE KITS K 560435 Squeegee Kit - Blade PU K 5604483 Squeegee Kit - Blade Linatex K3 560437 Squeegee Hardware Kit K4 5604378 Squeegee Assy Kit K5 560449 Squeegee Knobs Kit K6 5604385 Squeegee Wheels Kit TSB-FC-07-05 K7 5604386 Squeegee Strap Kit K8 5604387 Squeegee Mount Brkt Kit TSB-FC-06-68 * = Optional, Not Included NOTE : All squeegee blade kits include both front and rear squeegee blades. NOTE : The squeegee casting and cover are available for sale separately. If you need to replace the whole assembly, please order the Squeegee Assy Kit 5604378. /0 560459 - SC500
PARTS LIST PIN 4 - BRAKE + PIN 5 - KSI B+ RED RED 3 WHT/BRN BLU WHEN CHARGER IS NOT UNSTALLED THERE NEEDS TO BE A JUMPER BETWEEN PINS AND ON CONNECTOR X6 ON MAIN HARNESS YEL/ORN RED BRN/VIO J3- B+ J3-8 B+ WHT/RED RED VIO/ BRN/WHT ORN/RED GRN/ DEAD MAN SWITCH J3-4 J3-4 KEY SWITCH A (CONTROL BOARD) MAIN MACHINE CONTROLLER MOTION J3-6 J3-3 BRUSH CONTACTOR RED/YEL INHIBIT SPC J-7 RED/YEL BT BATTERY, 4 Vdc + - F FUSE, 50A. OPTIONAL DETERGENT PUMP BLU/GRY ORN/BLU BRN/ E CHARGER S.P.E. (OPTIONAL) BRN/ORN ORN ORN E CURTIS 0 SPEED CONTROLLER DEADMAN SWITCH S PIN 6 - BRAKE - PIN - INHIBIT PIN 9 - STATUS PIN 6 - REV. ALARM PIN 7 - DRIVE SWITCH PIN 3 - HIGH X6C PIN 8 - SPEED LIMIT PIN 3 - POT. LOW PIN 4 - GO SWITCH B- M M YEL/ RED/GRN Y BRAKE RED/WHT RED/WHT STATUS J3-7 BLU/ REV. ALARM J3-5 RED/BRN YEL J3- SOLUTION SOLENOID GRN/ORG VIO YEL BRN/VIO BRN BRN B- YEL/ RED/GRN RED/WHT J3-0 HORN + GRA X6A BLU X6B J3-9 HORN - J- + DETERGENT PUMP B- J-8 B- J-7 B- J- B- J- J-3 - DETERGENT PUMP YEL/ORN RED BRN B+ CB CIRCUIT BREAKER, 50A. A B ~ B+ B- GND 3 CIRCUIT BREAKER, 5 AMP CB K CONTACTOR, BRUSH L VALVE, SOLENOID H - + HORN M M + X6D X43B X43A X57B M M - LADDER DIAGRAM- BEFORE JULY 04 X6E revised /04 MOTOR, WHEEL DRIVE EMERGENCY STOP S4 X6D X6C X44A X6E X44B X6A SW, SPST KEY S X58B R 00K POT 3 S5 X58A X57A X6B GO SWITCH D SC500-560459 /0
revised 7/06 PARTS LIST Item Ref. No. Qty Description LADDER DIAGRAM- BEFORE JULY 04 A BT Control Board Battery CB 560443 Circuit Breaker 50A (Drive Wheel) CB 563555 Circuit Breaker 5 Amp (Control Circuit) CB3 56438 Circuit Breaker 0 Amp (Vacuum Motor) CB4 5650963 Circuit Breaker-5 Amp (Brush Motor) D 5638965 Rectifier Assy. D 566503 Rectifier 35 Amp E 560443 Speed Controller E 56544 Battery Charger 4v 5a F 564089 Fuse 50 Amp H 909 66 000 Buzzer 5-3v K 560476 Solid State Relay K 566083 Contactor 4v 00 Amp L 560469 Solenoid Valve Assembly M Drive Wheel Motor M 56354 Pump Chemical M3 5604356 Actuator Kit (Motor Brush Lift Actuator) M4 909 7556 000 Motor Vacuum 3st 4v 40w M5 560407 Disc Brush Motor (0D) R Potentiometer 00k (Speed Adjustment / part of Main harness) S 46 888 000 Switch Key with Cap * 46 887 000 Key PCS S Switch-Sealed (part of Switch Harness 5604406) S4 560447 Disconnect-Emergency S5 Switch-Sealed (part of Switch Harness 5604406) Y Electrical Brake (part of Drive Wheel Motor M) * = Optional, Not Included Color Codes BLU BRN GRA GRN ORN PINK RED TAN VIO WHT YEL Black Blue Brown Gray Green Orange Pink Red Tan Violet White Yellow /0 560459 - SC500 3
PARTS LIST LADDER DIAGRAM- BEFORE JULY 04 YEL/ORN SOLID STATE "RELAY" J-3 BAT CHARGER ON BOARD COMMUNICATION BRUSH ACT (-) J-9 A(CONTROL BOARD) MAIN MACHINE CONTROLLER B- J-8 ACT POSITION J- ACT POSITION J- J3- VACUUM MOTOR POWER MODULE BRUSH ACT (+) J-0 A D YEL/ POS M3 C RED/VIO F B RED B+ BRN GRA/ K BLU/ORN WHT BRN/YEL BLU TOP LIMIT POS + /WHT ORN/ BOTTOM LIMIT M4 M MOTOR, VAC M5 RED M + MOTOR, BRUSH B- - + - 3+ 4- M CIRCUIT BREAKER, 0 AMP CB3 CIRCUIT BREAKER, 5 AMP CB4 K 4 3 CONTACTOR, BRUSH MOTOR, BRUSH LIFT ACTUACTOR + ~ ~ - - revised /05 FLY-BACK DIODE D 4 SC500-560459 /0
revised 7/06 PARTS LIST Item Ref. No. Qty Description LADDER DIAGRAM- BEFORE JULY 04 A BT Control Board Battery CB 560443 Circuit Breaker 50A (Drive Wheel) CB 563555 Circuit Breaker 5 Amp (Control Circuit) CB3 56438 Circuit Breaker 0 Amp (Vacuum Motor) CB4 5650963 Circuit Breaker-5 Amp (Brush Motor) D 5638965 Rectifier Assy. D 566503 Rectifier 35 Amp E 560443 Speed Controller E 56544 Battery Charger 4v 5a F 564089 Fuse 50 Amp H 909 66 000 Buzzer 5-3v K 560476 Solid State Relay K 566083 Contactor 4v 00 Amp L 560469 Solenoid Valve Assembly M 5604074 Drive Wheel Motor M 56354 Pump Chemical M3 5604356 Actuator Kit (Motor Brush Lift Actuator) M4 909 7556 000 Motor Vacuum 3st 4v 40w M5 560407 Disc Brush Motor (0D) R Potentiometer 00k (Speed Adjustment / part of Main harness) S 46 888 000 Switch Key with Cap * 46 887 000 Key PCS S Switch-Sealed (part of Switch Harness 5604406) S4 560447 Disconnect-Emergency S5 Switch-Sealed (part of Switch Harness 5604406) Y Electrical Brake (part of Drive Wheel Motor M) * = Optional, Not Included Color Codes BLU BRN GRA GRN ORN PINK RED TAN VIO WHT YEL Black Blue Brown Gray Green Orange Pink Red Tan Violet White Yellow /0 560459 - SC500 5
PARTS LIST LADDER DIAGRAM- AFTER JUNE 04 revised /05 PIN 4 - BRAKE + PIN 5 - KSI B+ E CURTIS 0 SPEED CONTROLLER PIN 6 - BRAKE - PIN - INHIBIT BRN/ORN RED RED CIRCUIT BREAKER, 50A. X00 A B CHARGER OPTIONAL SEE PAGE 3 WHEN CHARGER IS NOT INSTALLED THERE NEEDS TO BE A JUMPER BETWEEN PINS AND ON CONNECTOR X6 ON MAIN HARNESS PIN 9 - STATUS PIN 6 - REV. ALARM PIN 7 - DRIVE SWITCH PIN 3 - HIGH 3 BRN/ ORN PIN 8 - SPEED LIMIT YEL/ORN PIN 3 - POT. LOW WHT/BRN BLU X6C X6C X004 PIN 4 - GO SWITCH X00 B- M M RED SW, SPST KEY BRN/VIO BRN/VIO TRACKCLEAN CONNECTIONS X00=B+(RED) X00=B-(BLU) X003=SCRUB(WHT) X004=KEY SW(BRN) X005=VACUUM(GRA) X006=DRIVE(PNK) X007=BYPASS(BRN) X008=MACHINE SUPPLY(ORN) TRACKCLEAN BYPASS: CONNECT BROWN WIRE FROM THE MACHINE TO BROWN WIRE (X007). ORN B- USE ADAPTER HARNESS FOR RETROFIT MACHINES. F FUSE, 50A. S KEY SWITCH DETAIL KEY SW BRN/VIO X004 BRN X008 BRN-MACHINE ORN TRACKCLEAN HARNESS YEL/ YEL/ RED/GRN RED/GRN RED J3- B+ J3-8 B+ BRN/WHT DEAD MAN SWITCH J3-4 J3-4 KEY SWITCH BRN RED/WHT D X58B A (CONTROL BOARD) MAIN MACHINE CONTROLLER X006 X003 RED/WHT RED/WHT MOTION J3-6 J3-3 BRUSH CONTACTOR WHT/RED BRN RED/YEL ORN/BLU BLU/ RED/BRN INHIBIT SPC J-7 STATUS J3-7 REV. ALARM J3-5 DRIVE SWITCH J3-3 YEL GRN/ORG VIO J3- SOLUTION SOLENOID VIO/ YEL J3-0 HORN + ORN/RED GRA BLU J3-9 HORN - GRN/ J- + DETERGENT PUMP RED/YEL B- J-8 B- J-7 B- J- B- J- J-3 - DETERGENT PUMP OPTIONAL DETERGENT PUMP BLU/GRY YEL/ORN RED BRN B+ X58A X43B X57B X43A X57A M M - MOTOR, WHEEL DRIVE BT BATTERY, 4 Vdc + - CB DEADMAN SWITCH S X6D EMERGENCY STOP S4 CIRCUIT BREAKER, 5 AMP CB X6D X44A Y BRAKE X6E X6E X44B K CONTACTOR, BRUSH VALVE, SOLENOID L R 00K POT H 3 - + GO SWITCH S5 HORN X6A X6B M X6B + M X6A 6 SC500-560459 /0
revised 7/06 PARTS LIST Item Ref. No. Qty Description LADDER DIAGRAM- AFTER JUNE 04 A BT Control Board Battery CB 560443 Circuit Breaker 50A (Drive Wheel) CB 563555 Circuit Breaker 5 Amp (Control Circuit) CB3 56438 Circuit Breaker 0 Amp (Vacuum Motor) CB4 5650963 Circuit Breaker-5 Amp (Brush Motor) D 5638965 Rectifier Assy. D 566503 Rectifier 35 Amp E 560443 Speed Controller E 56544 Battery Charger 4v 5a F 564089 Fuse 50 Amp H 909 66 000 Buzzer 5-3v K 560476 Solid State Relay K 566083 Contactor 4v 00 Amp L 560469 Solenoid Valve Assembly M Drive Wheel Motor M 56354 Pump Chemical M3 5604356 Actuator Kit (Motor Brush Lift Actuator) M4 909 7556 000 Motor Vacuum 3st 4v 40w M5 560407 Disc Brush Motor (0D) R Potentiometer 00k (Speed Adjustment / part of Main harness) S 46 888 000 Switch Key with Cap * 46 887 000 Key PCS S Switch-Sealed (part of Switch Harness 5604406) S4 560447 Disconnect-Emergency S5 Switch-Sealed (part of Switch Harness 5604406) Y Electrical Brake (part of Drive Wheel Motor M) * = Optional, Not Included Color Codes BLU BRN GRA GRN ORN PINK RED TAN VIO WHT YEL Black Blue Brown Gray Green Orange Pink Red Tan Violet White Yellow /0 560459 - SC500 7
PARTS LIST YEL/ORN SOLID STATE "RELAY" J-3 BAT CHARGER ON BOARD COMMUNICATION BRUSH ACT (-) J-9 A(CONTROL BOARD) MAIN MACHINE CONTROLLER B- J-8 ACT POSITION J- ACT POSITION J- J3- VACUUM MOTOR POWER MODULE BRUSH ACT (+) J-0 A D C RED/VIO B INLINE FUSE 3A P/N 56383587 3 RED B+ BRN GRA/ BLU/ORN WHT BRN/YEL MOTOR, BRUSH LIFT ACTUACTOR BLU YEL/ M3 + POS /WHT F ORN/ M4 M MOTOR, VAC RED B- - M CIRCUIT BREAKER, 0 AMP CB3 K CIRCUIT BREAKER, 5 AMP CB4 TOP LIMIT POS BOTTOM LIMIT FLY-BACK DIODE D + ~ ~ - M5 M + MOTOR, BRUSH E4 ~ GND B+ B- CHARGER DELTA Q - LADDER DIAGRAM- AFTER JUNE 04 revised /05 + - 3+ 4- K 4 3 CONTACTOR, BRUSH X005 A B ~ GND B+ B- 3 CHARGER S.P.E. 8 SC500-560459 /0
revised 7/06 PARTS LIST Item Ref. No. Qty Description LADDER DIAGRAM- AFTER JUNE 04 A BT Control Board Battery CB 560443 Circuit Breaker 50A (Drive Wheel) CB 563555 Circuit Breaker 5 Amp (Control Circuit) CB3 56438 Circuit Breaker 0 Amp (Vacuum Motor) CB4 5650963 Circuit Breaker-5 Amp (Brush Motor) D 5638965 Rectifier Assy. D 566503 Rectifier 35 Amp E 560443 Speed Controller E 56544 Battery Charger 4v 5a F 564089 Fuse 50 Amp H 909 66 000 Buzzer 5-3v K 560476 Solid State Relay K 566083 Contactor 4v 00 Amp L 560469 Solenoid Valve Assembly M 5604074 Drive Wheel Motor M 56354 Pump Chemical M3 5604356 Actuator Kit (Motor Brush Lift Actuator) M4 909 7556 000 Motor Vacuum 3st 4v 40w M5 560407 Disc Brush Motor (0D) R Potentiometer 00k (Speed Adjustment / part of Main harness) S 46 888 000 Switch Key with Cap * 46 887 000 Key PCS S Switch-Sealed (part of Switch Harness 5604406) S4 560447 Disconnect-Emergency S5 Switch-Sealed (part of Switch Harness 5604406) Y Electrical Brake (part of Drive Wheel Motor M) * = Optional, Not Included Color Codes BLU BRN GRA GRN ORN PINK RED TAN VIO WHT YEL Black Blue Brown Gray Green Orange Pink Red Tan Violet White Yellow /0 560459 - SC500 9
PARTS LIST revised 4/08 Item Ref. No. Qty Description Kits * 5604403 On Board Charger-EU Kit * 5604437 Shelf Charger Adapter Kit * 5638404 Control Board Kit * 560437 Interface Panel Kit * 5638505 Tank Support Kit *# 56394063 Recovery Tank Kit OPTIONAL KITS AND ACCESSORIES Squeegee Blade Kits (See Squeegee Blade Selector Guide) 560435 Squeegee Kit - Blade PU NOTE * 5604483 Squeegee Kit - Blade Linatex NOTE Accessories * 56397453 Indicator Battery Level * 5638357 Programmer-User * 5638357 Programmer Cable-Molex * 560490 Ecoflex Bottle Assy * 56049 EU Chemical Injection Kit * 5604469 Literature Pack 0 Disk Scrub Brushes (See Brush Selector Guide) * 56505790 Pad Holder-0 3 Lug * 5650579 Disc Brush-0 Magnagrit 3 Lug * 5650579 Disc Brush-0 Dyna Grit 3 Lug * 56505793 Disc Brush-0 Aglite 3 Lug * 56505794 Disc Brush-0 Prolene 3 Lug * 56505795 Disc Brush-0 Prolite 3 Lug * 56505796 Disc Brush-0 Union Mix 3 Lug * 56505797 Disc Brush-0 Midgrit 3 Lug * 56505798 Disc Brush-0 Midlite 3 Lug * 97670 Pads Cs 0 Black Thin (Qty 5) * 976070 Pads Cs 0 Brown 5 (Qty 5) * 976069 Pads Cs 0 Blue 5 (Qty 5) * = Optional, Not Included NOTE : All squeegee blade kits include both front and rear squeegee blades. 30 SC500-560459 /0
revised /07 PARTS LIST RECOMMENDED SPARE PARTS Item Ref. No. Qty Description CHASSIS SYSTEM Ordinary Maintenance O 5638536 Harness-Drive Motor Kit O 560469 Sprocket- Tooth O 5604407 Bearing-Flange O 560433 Rear Wheel Kit O 5604338 Wheel And Bearing Kit O 5604435 Sprocket And Chain Kit (used w/560443) O 5604339 Sprocket And Chain Kit (used w/5604058) Extra-Ordinary Maintenance E 560409 Mounting Tab E 5604094 Bar Linkage E 560405 Battery Tray E 560430 Steering Shaft E 560435 Link Bar E 560448 Steering Shaft Weldt E 56045 Spindle Mount Weldment E 560457 Collar E 5604448 Chassis Weldment E 563403 Block, Bearing E 560438 Universal Joint Kit E 560433 Bearing Block Kit E 5604333 Chassis Hardware Kit E 5604336 Drive Wheel Motor Kit E 5604340 Drive Wheel Hardware Kit E 5604384 Front Wheel Bearings Kit CONTROL SYSTEM Normal Wear W 560470 Chain-Roller Extra-Ordinary Maintenance E 5604053 Control Panel E 560496 Shaft Steering E 560465 Shaft Hex E 560440 Bracket-Prop Rod E 5660060 Steering Wheel E 5604058 Drive Wheel Frame Weldt E 5604077 Spindle Weldt E 56045 Steering Plate E 560438 Universal Joint Kit E 560435 Draw Latch Kit E 5604365 Control Hardware Kit ELECTRICAL SYSTEM Extra-Ordinary Maintenance E 560443 Circuit Breaker 50 Amp E 5604444 Harness-Main E 560476 Solid State Relay E 560493 Electrical Panel E 560443 Speed Controller E 560447 Disconnect-Emergency E 56048 Cable-Power E 56354 Handle E 563555 Circuit Breaker, 5 Amp E 5604438 Cable-Battery Assy E 564089 Fuse, 50 Amp E 56438 Circuit Breaker, 0 Amp E 56469858 Electrical Mount E 5650963 Circuit Breaker-5 Amp E 5604439 Cable-Connector Assy E 566083 Contactor 4v, 00 Amp E 46 888 000 Switch, Key With Water Proof Cup E 46 887 000 Key PCS E 5096A Knob, Speed Control Item Ref. No. Qty Description ELECTRICAL SYSTEM CONTINUED Extra-Ordinary Maintenance E 560434 Electrical Hardware Kit E 5638404 Control Board Kit E 560437 Interface Panel Kit PLATFORM ASSEMBLY Ordinary Maintenance O 5604406 Switch Harness Extra-Ordinary Maintenance E 560405 Platform-Upper E 560485 Pedal-Safety E 560486 Foot Pedal E 560487 Platform-Bottom E 560477 Compression Spring E 5658690 Grommet E 5633006 Grommet E 560447 Platform Hardware Kit RECOVERY SYSTEM Ordinary Maintenance O 560464 Gasket-Recovery Tank O 560458 Vac Hose Assy O 560485 Drain Hose O 909 667 000 Filter Extra-Ordinary Maintenance E 560405 Recovery Tank E 560458 Back Panel E 5604306 Jumper Harness E 5604443 Guard-Splash-4x-Poly E 45 0543 000 Hose Clamp 4/3-5 E 909 605 000 Cover, Vac E 560435 Draw Latch Kit E 5604389 Float Cage EU Kit E 5604360 Debris Cage Kit E 560436 Hose Clamp Kit E 5604363 Vacuum Motor Kit E 5604364 Recovery Hardware Kit E 5604383 Vacuum Motor Insulation Kit SCRUB SYSTEM-0D Ordinary Maintenance O 909 5483 000 Hose Holder Extra-Ordinary Maintenance E 560407 Disc Brush Motor E 5604095 Shaft Disc Brush Motor E 56047 Deck Lift Plate Weldment E 56040 Lower Deck Plate E 5604 Brush Housing E 56046 Squeegee Link Weldment E 560437 Spacer Motor E 560469 Solenoid Valve Assy E 560440 Skirt Brush E 56044 Double Scrub Brkt E 5634983 Tee Assembly E 5638683 Barbed Elbow 90 E 56384076 Hose-Pvc-.50x3.50 E 563977 Hose, Pvc Clear E 5660733 Brush Plate Assy Rt E 56366455 Plate, Stop E 5609653 Spring Retainer E 565 Gimbal-Collar Assembly E 5660056 Spring, Brush Holder E 56608 Brush Plate E 560497 Motovario Gearbox 5/ E 560498 Motor E 5604300 Brush Housing Assembly E 5660588 Cover And Screws /0 560459 - SC500 3
PARTS LIST RECOMMENDED SPARE PARTS CONTINUED revised 6/07 Item Ref. No. Qty Description SCRUB SYSTEM-0D CONTINUED Ordinary Maintenance O 5660534 Carbon Brushes () Extra-Ordinary Maintenance E 5660508 Plastic Cover E 5604344 Squeegee Pivot Kit E 5604346 Disc Deck Hardware Kit E 5604347 Disc Deck Assy 0 Kit SOLUTION SYSTEM Extra-Ordinary Maintenance E 5604050 Solution Tank E 560465 Filter Bracket E 560494 Support Brkt E 560409 Hinge Assembly E 560406 Hinge Pin E 560407 Hinge Weldment E 560408 Hinge Bracket E 560449 Bearing Flange E 56049 Grommet E 556A Hosebarb 3/8 X 90 Deg E 560434 Actuator Brkt E 5604308 Pivot Block E 5604390 Insert-Brass M8 E 560439 Adjustment Pad E 5604409 Prop Rod E 5639338 Hose-Pvc Clear E 5647763 Tie, Cable E 5660599 Cap - Raw With Tether E 909 66 000 Buzzer 5-3v E 560489 Insert-Dry Break E 5604408 Chemical Bottle Assembly E 563494 Hose, Chem Resistant E 563499 Hose, Chem Resistant 4 E 56354 Pump, Chemical E 900005 Cap, Plastic F Chemical Tank E 563553 Cap, Dry Break, /8 Barb, 90 E 909 549 000 Cable Support E 5604349 Solution Drain Kit E 5604350 Solution Hose Kit E 560435 Solution Filter Kit E 5604354 Solution Cap Kit E 5604356 Actuator Kit E 5604357 Tip Pad Kit E 5604358 Solution Hardware Kit SQUEEGEE SYSTEM Normal Wear W 560435 Squeegee Kit Blade PU W 5604483 Squeegee Kit - Blade Linatex W 5604385 Squeegee Wheels Kit Extra-Ordinary Maintenance E 560437 Squeegee Hardware Kit E 5604378 Squeegee Assy Kit E 560449 Squeegee Knobs Kit E 5604386 Squeegee Strap Kit E 5604387 Squeegee Mount Brkt Kit DECAL SYSTEM - SC500 Extra-Ordinary Maintenance E 5604335 SC500 EU Decal Kit E 560448 SC500 EU Ecoflex Decal Kit ACCESSORY / OPTIONS Extra-Ordinary Maintenance E 56049 EU Chemical Injection Kit E 5604403 On Board Charger EU Kit 3 SC500-560459 /0
PARTS LIST BRUSH SELECTOR GUIDE We provide brushes and pad holders that will give you the best possible performance between machine and floor. Following are descriptions of the materials and their applications. Soft Nylon: Bristles are made from light-duty polypropylene for general scrubbing when you do not want to scratch or remove finish from the floor. Recommended for use in place of red pads. Poly: Lite Grit: Medium Grit: Heavy Grit: Polypropylene material for medium-duty scrubbing on concrete, terrazzo and vinyl floor tile. Recommended for use in place of green or blue pads. For light scrubbing when used wet; buffing or polishing when used dry on urethane coated, sealed concrete or other resilient hard surface floors. Recommended for use in place of red or white pads. For general purpose scrubbing of sealed or unsealed concrete, stone, terrazzo, quarry tile and other resilient hard floor surfaces. Recommended for use in place of green or blue pads. For aggresive, heavy-duty scrubbing or stripping of floors. Recommended for use in place of brown pads. 0" Disk Scrub Brushes 56505790 - Pad Holder 5650579 - Magnagrit 5650579 - Dyna Grit 56505793 - Aglite 56505794 - Prolene 56505795 - Prolite 56505796 - Union Mix 56505797 - Midgrit 56505798 - Midlite 97670 - Pads Cs 0 Black Thin (Qty 5) 976070 - Pads Cs 0 Brown 5 (Qty 5) 976069 - Pads Cs 0 Blue 5 (Qty 5) DISC BRUSH APPLICATION GUIDE (SUGGESTION ONLY) Heavy Medium Lite Soft Application Grit Grit Grit Poly Nylon Stripping: Concrete X Terrazzo X Ceramic/Quarry tile X Vinyl tile X General Scrubbing: Concrete X X X X Terrazzo X X X Ceramic/Quarry tile X X X Marble X X X Vinyl tile X X X Raised-rubber tile X X X /0 560459 - SC500 33
PARTS LIST revised 9/04 SQUEEGEE BLADE SELECTOR GUIDE Red Gum Rubber: Polyurethane: Provides longest life on finished or unfinished concrete floors. Oil resistance provides superior life in applications with oily floors. Performance Traits Red Gum Rubber (Natural Rubber) Polyurethane/ Pentathane Tear Strength X X Abrasion Resistance X X Applications Oil Resistant Applications X Appearance Red Translucent 34 SC500-560459 /0
Nilfisk A/S Kornmarksvej DK-605 Brøndby Denmark Tel.: +45 43 3 8 00 Fax: +45 43 43 77 00 mail.com@nilfisk.com www.nilfisk.com