DE165E0 Image shown may not reflect actual package Output Ratings Generator Set Model 3 Phase Prime* Standby* 400/230 V, 480V, * Refer to ratings definitions on page 4. Ratings at 0.8 power factor. Technical Data Engine Make & Model: C7.1 Generator Model: LC3114J Control Panel: EMCP 4.1 Base Frame Type: Heavy Duty Fabricated Steel Circuit Breaker Type: 3 Pole MCCB Frequency: Engine Speed: RPM Fuel Tank Capacity: litres (US gal) Fuel Consumption, Prime: l/hr (US gal/hr) Fuel Consumption, Standby : l/hr (US gal/hr) 1500 1800 349 (92.2) 32.4 (8.6) 37.5 (9.9) 35.1 (9.3) 41.1 (10.9)
Engine Technical Data Physical Data Manufacturer: Model: No. of Cylinders/Alignment: Cycle: Induction: Cooling Method: Governing Type: Governing Class: Compression Ratio: Displacement: l (cu.in) Bore/Stroke: Moment of Inertia: kg m² (lb. in²) Engine Electrical System: Air System Air Filter Type: Combustion Air Flow: m³/min (cfm) Standby: Prime: Max. Combustion Air Intake Restriction: kpa (in H 2 O) Radiator Cooling Air Flow: m³/min (cfm) Voltage/Ground: Battery Charger Amps: Weight: kg (lb) Dry: Wet: External Restriction to Cooling Air Flow: Pa (in H 2 O) Cooling System Cooling System Capacity: l (US gal) Water Pump Type: Heat Rejected to Water & Lube Oil: (Btu/min) Standby: Prime: Heat Radiation to Room: Heat radiated from engine and alternator (Btu/min) Standby: Radiator Fan : (hp) Prime: Paper Element 10.7 (377) 10.0 (354) 3.0 (12.0) 303.4 (10714) 239.4 (8454) 125 (0.5) Caterpillar C7.1 6 / In Line 4Stroke Turbocharged Air To Air Charge Cooled Water Mechanical ISO 8528 G2 16.0:1 7.0 (427.8) 105.0 (4.1)/ (5.3) 21.0 (5.5) 75.7 (4305) 69.1 (3930) 22.4 (1274) 19.9 (1132) 4.5 (6.0) 1.53 (5228) 12/Negative Cooling system designed to operate in ambient conditions up to 50 C (122 F). Contact your local Cat dealer for power ratings at specific site conditions. 85 788 (1737) 822 (1812) Centrifugal 15.0 (529) 14.4 (509) 3.0 (12.0) 125 (0.5) 21.0 (5.5) 80.1 (4555) 73.5 (4180) 23.4 (1331) 20.8 (1183) 8.0 (10.7) Lubrication System Oil Filter Type: Total Oil Capacity l (US gal): Oil Pan l (US gal): Oil Type: Cooling Method: Performance Engine Speed: RPM Gross Engine Power: (hp) BMEP: kpa (psi) Standby: Prime: Standby: Prime: Regenerative Power: Fuel System Fuel Filter Type: Recommended Fuel: Fuel Consumption: l/hr (US gal/hr) Prime Standby 110% 100% 50% (based on diesel fuel with a specific gravity of 0.85 and conforming to BS2869, Class A2) Exhaust System Silencer Type: Silencer Model & Quantity: Pressure Drop Across Silencer System: kpa (in Hg) Silencer Noise Reduction Level: db 35.1 (9.3) 41.1 (10.9) Max. Allowable Back Pressure: kpa (in. Hg) Exhaust Gas Flow: m³/min (cfm) Standby: Prime: Exhaust Gas Temperature: C ( F) Standby: Prime: 1500 136.0 (182.0) 1701.0 (246.7) 6.7 SpinOn, Full Flow Replaceable Element Class A2 Diesel or BSEN590 32.4 (8.6) 37.5 (9.9) 35.1 (9.3) 41.1 (10.9) 16.5 (4.4) 14.9 (3.9) API CH4 / CI4 15W40 Water 1800 149.1 (200.0) 171.8 (230.0) 155.4 (208.0) 1633.0 (236.8) 1551.0 (225.0) 1477.0 (214.2) 24.9 (6.6) 28.9 (7.6) 27.2 (7.2) 31.9 (8.4) 6.0 (1.8) 25.5 (902) 23.9 (843) 484 (903) 484 (903) EXSY1 () 7.7 16.6 (4.4) 19.7 (5.2) 18.3 (4.8) 21.8 (5.8) 6.0 (1.8) 32.2 (1137) 31.9 (1125) 407 (765) 407 (765)
Generator Performance Data Data Item 415/240V 400/230V 230/115V 200/115V 220/127V 480/277V 240/139V 240/120V 208/120V 440/254V 220/127V Motor Starting Capability* 414 390 358 455 452 307 358 393 Short Circuit Capacity** % 300 300 300 300 300 300 300 300 Reactances: Per Unit Xd X'd X''d 2.834 3.050 3.380 2.185 2.860 4.326 3.808 3.404 0.136 0.147 0.163 0.105 0.138 0.208 0.183 0.164 0.082 0.088 0.098 0.063 0.083 0.125 0.110 0.098 Reactances shown are applicable to prime ratings. *Based on 30% voltage dip at 0.6 power factor and SHUNT excitation system. ** With optional Permanent Magnet generator. Generator Technical Data Physical Data Operating Data Overspeed: RPM 2250 Model: LC3114J Voltage Regulation: (steady state) +/ 0.5% No. of Bearings: 1 Wave Form NEMA = TIF: 50 Insulation Class: H Wave Form IEC = THF: 2.0% Winding Pitch Code: 2/3 6 Total Harmonic Content LL/LN: 2.0% Wires: 12 Radio Interference: Suppression is in line with European Standard EN610006 Ingress Protection Rating: IP23 Radiant Heat: (Btu/min) Excitation System: SHUNT : 10.2 (580) AVR Model: R250 : 11.1 (631)
Technical Data Voltage Prime Standby Voltage Prime Standby 415/240V 480/277V 400/230V 220/127V 160.0 128.0 176.0 140.8 230/115V 240/120V 220/127V 130.0 104.0 143.0 114.4 440/254V 200/115V 160.0 128.0 176.0 140.8 208/120V 240/139V Weights & Dimensions Weights: kg (lb) Dimensions: Net (+ lube oil) 1610 (3549) Length 2500 (98.4) Wet (+ lube oil & coolant) 1631 (3596) Width 1120 (44.1) Fuel, lube oil & coolant 1927 (4247) Height 1528 (60.2) Note: General configuration not to be used for installation. See general dimension drawings for detail. Definitions Standby Rating Prime Rating Output available with varying load for an unlimited time. Average power output is 70% of the prime power rating. Typical peak demand is 100% of prime rated e with 10% overload capability for emergency use for a maximum of 1 hour in 12. Overload opeation cannot exceed 25 hours per year. General Data Documents A full set of operation and maintenance manuals and circuit wiring diagrams. Quality Standards The equipment meets the following standards: IEC600341, IEC6003422, ISO3046, ISO8528, NEMA MG 132, NEMA MG 133, 2004/108/EC, 2006/42/EC, 2006/95/EC. Ṡtandard Reference Conditions Note: Standard reference conditions 25 C (77 F) air inlet temp, 100m (328ft) A.S.L. 30% relative humidity. Fuel consumption data at full load with diesel fuel with specific gravity of 0.85 and conforming to BS2869: 1998, Class A2. Performance No.: Feature Code: Gen. Arr. Number: (0 / ) www.catelectricpower.com 2014 Caterpillar All rights reserved. Materials and specifications are subject to change without notice. The International System of Units (SI) is used in this publication. CAT, CATERPILLAR, their respective logos, "Caterpillar Yellow," the "Power Edge" trade dress, as well as corporate and product identity used herein, are trademarks of Caterpillar and may not be used without permission.
E N C L O S U R E S SOUND ATTENUATED LEVEL 1 ENCLOSURES 30 220 Features DURABLE AND ROBUST CONSTRUCTION Galvanised steel protected by powder coat paint Zinc plated / stainless steel fasteners SECURITY AND SAFETY lockable enclosure door exterior below control panel access doors safety TRANSPORTABILITY EXCELLENT SERVICE AND MAINTENANCE ACCESS Removable front and rear access panels Lube oil and coolant drain valves LEHE0XXX00 LEHE0078600
E N C L O S U R E S Sound Pressure Levels (dba) Generator Set Model Prime 61.0 62.4 67.0 68.4 77.7 79.1 62.2 63.1 68.2 69.1 79.4 80.8 Standby 61.4 63.1 67.4 69.1 78.1 79.8 62.4 63.6 68.4 69.6 79.8 81.4 Prime 56.1 57.0 62.1 63.0 73.7 74.8 59.5 61.2 65.5 67.2 78.2 80.2 Standby 56.4 57.5 62.4 63.5 74.0 75.3 60.1 62.1 66.1 68.1 78.9 81.4 Prime 56.4 57.5 62.4 63.5 74.0 75.3 60.1 62.1 66.1 68.1 78.9 81.4 Standby 56.7 58.1 62.7 64.1 74.4 76.0 60.7 63.1 66.7 69.1 79.7 82.6 Prime 57.0 58.7 63.0 64.7 74.8 76.7 61.4 64.2 67.4 70.2 80.5 84.0 Standby 57.3 59.4 63.3 65.4 75.2 77.5 62.1 65.4 68.1 71.4 81.4 85.5 Prime 59.2 61.0 65.2 67.0 77.4 79.5 60.6 62.5 66.6 68.5 79.4 81.1 Standby 59.7 61.8 65.7 67.8 78.0 80.5 61.1 63.4 67.1 69.4 79.8 81.9 Prime 65.3 66.0 71.3 72.0 81.8 82.4 65.7 66.7 71.7 72.7 81.9 82.4 Standby 65.5 66.3 71.5 72.3 82.0 82.7 66.0 67.2 72.0 73.2 82.1 82.7 Prime 62.2 62.5 68.2 68.5 80.6 80.8 64.9 65.1 70.9 71.1 84.2 84.4 Standby 62.3 62.6 68.3 68.6 80.6 80.8 65.0 65.1 71.0 71.1 84.3 84.4 Prime 66.0 66.2 72.0 72.2 85.3 85.5 Standby 66.0 66.4 72.0 72.4 85.4 85.6 Prime 66.0 66.4 72.0 72.4 85.4 85.6 Standby 66.1 66.6 72.1 72.6 85.4 85.7 Generator Set Model Prime 56.1 57.0 62.1 63.0 73.7 74.8 59.5 61.2 65.5 67.2 78.2 80.2 Standby 56.4 57.5 62.4 63.5 74.0 75.3 60.1 62.1 66.1 68.1 78.9 81.4 Prime 57.0 58.7 63.0 64.7 74.8 76.7 61.4 64.2 67.4 70.2 80.5 84.0 Standby 57.3 59.4 63.3 65.4 75.2 77.5 62.1 65.4 68.1 71.4 81.4 85.5 Prime 65.3 66.0 71.3 72.0 81.8 82.4 65.7 66.7 71.7 72.7 81.9 82.4 Standby 65.5 66.3 71.5 72.3 82.0 82.7 66.0 67.2 72.0 73.2 82.1 82.7 LEHE0XXX00 LEHE0078600
E N C L O S U R E S C D B A Generator Set Model Three Phase A: B: C: D*: Fuel Capacity: l (US gal) Weight: kg (lb) DE33E0 56.0 (14.8) DE50E0 145 (38.3) DE55E0 145 (38.3) DE65E0 145 (38.3) DE88E0 188 (49.6) DE110E2 212 (56.0) DE165E0 289 (76.3) DE200E0 384 (101.4) DE220E0 384 (101.4) Generator Set Model Single Phase A: B: C: D*: Fuel Capacity: l (US gal) Weight: kg (lb) 2291 (90.2) 1026 (40.4) 1426 (56.1) 145 (38.3) 2291 (90.2) 1026 (40.4) 1426 (56.1) 145 (38.3) 2761 (108.7) 1126 (44.3) 1535 (60.4) 212 (56.0) LEHE0XXX00 LEHE0078600 (10/14) (0714) CAT, CATERPILLAR, their respective logos, Caterpillar Yellow, the Power Edge trade dress, as well as corporate and product identity used herein, are trademarks