EM readyapply BASIC W EM readyapply Product description LED emergency module suitable for direct installation in ceilings Complete set with integrated electronics, LED module, heat sink, optics and battery Includes click-in multi-lens option for anti-panic, escape route and spot illumination Emergency lighting function for manual testing Small size ceiling hole, 40 4 mm diameter, 80 mm height Properties Output power 0.75.50 W Very low stand-by power loss Maintained and non-maintained variants or h rated duration (separate variants) Plug-in Lithium Iron Phosphate battery with strain-relief 5 years guarantee electronic (LED Driver) years guarantee battery È Standards, page 4 Wiring diagrams and installation examples, page 4 Data sheet 05/8-EM06-9 www.tridonic.com
y Emergency lighting units EM readyapply BASIC W EM readyapply Technical data Rated supply voltage AC Input voltage range AC (tolerance for safety) Input voltage range AC (tolerance for performance) Mains frequency 0 40 V 98 64 V 98 54 V 50 / 60 Hz Overvoltage protection 0 V (for 48 h) Time to light (emergency operation) < 0.5 s from detection of emergency event THD normal operation 75 % (maintained operation, at 0 V, 50 Hz, charging) Output current tolerance ± 5 % LF current ripple ± 5 % Ambient temperature ta +5... +0 C (insulated ceilings) Ambient temperature ta +5... +40 C (non-insulated ceilings) Mains voltage changeover threshold According to EN 60598-- Type of protection IP0 Impact protection rating IK0 Protection class II Colour temperature 6,500 K Colour tolerance Mac Adams Colour rendering index CRI > 80 Nominal life-time 50,000 h EoF I Ø 40 4 9 5 79 > 80 0 5 5 Ordering data Type Article Operating Rated Number Packaging, Packaging, Weight number mode duration of cells carton pallet per pc. EM RA BASIC NM W 8980054 Non-maintained h pc(s). 80 pc(s). 0.8 kg EM RA BASIC M W 8980055 Maintained h pc(s). 80 pc(s). 0.9 kg EM RA BASIC NM W 898005 Non-maintained h pc(s). 80 pc(s). 0.8 kg EM RA BASIC NM W 8980056 Non-maintained h pc(s). 80 pc(s). 0. kg EM RA BASIC M W 8980057 Maintained h pc(s). 80 pc(s). 0. kg Specific technical data Type Number of battery cells Rated duration Mains current (0 V, 50 Hz), maintained Mains current (0 V, 50 Hz), non-maintained Mains power (0 V, 50 Hz), maintained Mains power (0 V, 50 Hz), non-maintained Typ. λ (at 0 V, 50 Hz, charging) Charging Charger off Charging Charger off Charging Charger off Charging Charger off Normal operation EM RA BASIC NM W h 0 ma 5 ma.5 W 0.6 W 0.6c EM RA BASIC M W h 5 ma 6 ma 4.5 W. W 0.58c 6 ma V.50 W EM RA BASIC NM W h 0 ma 5 ma.5 W 0.6 W 0.6c EM RA BASIC NM W h 6 ma 5 ma.5 W 0.6 W 0.6c EM RA BASIC M W h 40 ma 6 ma 5.5 W. W 0.58c 6 ma V.50 W Emergency operation EM RA BASIC NM W h 6 ma V.50 W EM RA BASIC M W h 6 ma V.50 W EM RA BASIC NM W h 64 ma. V 0.75 W EM RA BASIC NM W h 6 ma V.50 W EM RA BASIC M W h 6 ma V.50 W IK rating valid for lens EM = Emergency Typ. output current Typ. forward voltage Output power Data sheet 05/8-EM06-9 www.tridonic.com
ACCES- SORIES Lithium Iron Phosphate Battery pack.5.0 Ah Batteries Product description Lithium Iron Phosphate replacement battery pack for use with EM readyapply emergency lighting units 8-year design life (at up to 0 C ambient, insulated ceilings) 6-year design life (at up to 40 C ambient, non-insulated ceilings) -year guarantee Properties Certified quality manufacturer Casing material made of polycarbonate Charge efficiency > 90 % Low self discharge Compact micro USB type B connector providing polarity safe battery connection Protection and monitoring circuit built into battery enclosure Deep discharge protection Suitable for emergency lighting equipment as per IEC 60598-- 77,5±0,,5±0, 9±0, 7,5±0, 6,5±0, Ordering data Type Article number Packaging, carton Weight per pc. Battery pack.5 Ah PACK-LiFePO4,5Ah RA 89800555 75 pc(s). 0.064 kg Battery pack.0 Ah PACK-LiFePO4,0Ah RA 89800556 75 pc(s). 0.04 kg 4, 55 Data sheet 05/8-EM06-9 www.tridonic.com
. Standards acc. to EN 507 EN 5505 EN 60068--9 EN 60068--0 EN 60068--64 EN 60598- EN 60598-- EN 60598-- EN 6000-- EN 647- EN 647--7 EN 647-- EN 6547 EN 684 IEC 6 (related to Lithium Iron battery) UN 8. (related to Lithium Iron battery) EN 60 EN 647. Storage conditions Humidity 45 % up to max. 85 %, not condensed (max. 56 days/year at 85 %) Storage time / temperature: max. 6 months at -0 C up to +45 C (< months at +45 C) Note: The devices have to be within the specified temperature range (ta) before they are operated. Store batteries within the specified temperature range in low humidity conditions. Optimal storage conditions are: Temperature: -0... +5 C for up to months -0... +5 C for up to 6 months Relative humidity: 65 % ±5 % Avoid atmosphere with corrosive gas Disconnect batteries before store or delivery Avoid storage of discharged batteries. Glow-wire test according to EN 60598- with increased temperature of 850 C passed.. Thermal data. Temperature range According to the standard IEC 60598- a LED Driver for remote installation has a max. case temperature of 90 C. The ambient temperature range ta for the EM RA BASIC is defined to meet this requirement.. Expected life-time. Installation / Wiring. Lens assembly Wear gloves when mounting the lens Take care of the mounting direction of the escape route lens Use screwdriver for replacing/removing lens. +. Push lens clips with screwdriver via openings on both sides. Remove lens.. Electronics Average life-time 50,000 hours under rated conditions with a failure rate of less than 0 %. Average failure rate of 0. % per 000 operating hours. Expected life-time Type ta 5 C 0 C 40 C EM RA BASIC life-time > 50,000 h 50,000 h 50,000 h.. Life-time, lumen maintenance and failure rate for LED module The light output of an LED module decreases over the life-time, this is characterized with the L value. L70 means that the LED module will give 70 % of its initial luminous flux. This value is always related to the number of operation hours and therefore defines the life-time of an LED module. As the L value is a statistical value the lumen maintenance may vary over the delivered LED modules. The B value defines the amount of modules which are below the specific L value, e.g. L70B0 means 0 % of the LED modules are below 70 % of the inital luminous flux, respectivly 90 % will be above 70 % of the initial value. Life-time declarations are informative and represent no warranty claim. ta temperature L90 / B50 L80 / B50 L70 / B0 5 C 50,000 h 50,000 h 0 C 50,000 h 40 C 50,000 h Data sheet 05/8-EM06-9 www.tridonic.com 4
. Wiring diagrams 4. Mechanical data 0 40 V 50/60 Hz L N 4. Housing properties Polycarbonate white RAL 906 4. Battery connection Battery EM RA BASIC L N Battery pack end termination Compact micro USB type B connector providing safe battery connection Module end termination Battery strap with compact micro USB type B connector Strain relief at the module casing and locking clip for secure connection of the battery pack Battery strap: low smoke, halogen free Note: Strap not suitable for connection of any other micro USB device other than the readyapply battery pack 4. Fixing Note: Battery must be connected before mains connection.. Wiring type and cross-section Spring fixing through hole in ceiling Hole diameter: 40 4 mm Ceiling thickness: 5 mm Ceiling void height: > 80 mm Wiring Mains (N, L): brown, blue Cable length: 50mm with strain relief at the RA BASIC module Cable: low smoke, halogen free 0.75 mm² fine-stranded 8 ± mm 50 ± 9 ± 8 ± Blue Brown Ø 6.5 Recommended connector with strain-relief (plug and socket): to be defined Only a terminal complying with EN 60998-- or EN 60998-- shall be used Note: If mains cable or battery strap are damaged the luminaire must be disposed. 5. Electrical data 5. Maximum loading of automatic circuit breakers Automatic circuit breaker type C0 C C6 C0 B0 B B6 B0 Inrush current Installation Ø.5 mm.5 mm.5 mm 4 mm.5 mm.5 mm.5 mm 4 mm I max time EM RA BASIC 80 60 60 60 90 0 0 0 0 A 0 μs 5. Harmonic distortion in the mains supply (at 0 V / 50 Hz and -cell maintained charging) in % THD. 5. 7. 9.. EM RA BASIC < 75 < 6 < < 9 < 8 < Data sheet 05/8-EM06-9 www.tridonic.com 5
5. Battery charge regime / discharge EM RA BASIC W, / h Type EM RA BASIC W EM RA BASIC W EM RA BASIC W Article no. 8980054 / 8980055 8980056 / 8980057 898005 Cells cells cells cells Duration h h h Battery charge time Initial Recharge Trickle charge 0 h h continuously and battery voltage controlled Initial charge 40 ma 90 ma 40 ma Typ. charge current Recharge 40 ma 90 ma 40 ma Trickle charge 40 ma / 0 ma 90 ma / 0 ma 40 ma / 0 ma Mains power consumption Initial charge <.095 W <.095 W <.095 W Recharge <.095 W <.095 W <.095 W Trickle charge <.095 W / 0 W <.095 W / 0 W <.095 W / 0 W Discharge current at. V (nominal) 65 ma 65 ma 0 ma Automatic recharge when battery voltage falls below.4 V. Charger off (0 ma) when battery voltage exceeds.6 V. Note: Battery protected against operation at excessive temperatures (charging stopped when battery cell temperature < 0 C or > 60 C) 5.4 Battery selection for replacement EM RA BASIC W, / h Type EM RA BASIC W EM RA BASIC W EM RA BASIC W Technology and capacity Lithium Iron Phosphate.5 Ah Lithium Iron Phosphate Ah Design Number of cells Type Article no. 8980054 / 8980055 8980056 / 8980057 898005 Cells cells cells cells Duration h h h Article no. Assignable batteries single cell PACK-LiFePO4,5Ah RA 89800555 side by side + PACK-LiFePO4,0Ah RA 89800556 Note: If the rated duration of operation cannot be reached the battery must be replaced. Remove mains during battery replacement. Data sheet 05/8-EM06-9 www.tridonic.com 6
6. Functions 6. Status indication The indication LED is integrated in the bezel. A green LED indicates that charging current is flowing into the battery. The battery is protected against operation at excessive temperatures (charging stops and indication LED turns off when battery cell temperature < 0 C or > 60 C). 6. Test switch Test switch is integrated in the bezel. This can be used to to execute function test as long as the switch pressed > s To initiate a test use a suitable tool, refer to drawing below. Status LED 6. Technical data batteries,5 mm Test Switch Accu Lithium Iron Phosphate Case temperature range to ensure 8 years design life.5 /.0 Ah, insulated ceilings +5 C to +5 C Case temperature range to ensure 6 years design life.5 /.0 Ah, non-insulated ceilings +5 C to +45 C Battery voltage/cell. V Single cell dimensions Diameter 8 mm 65 mm Capacity one cell.5 Ah Capacity two cell pack.0 Ah Max. short term temperature (reduced life-time) 55 C Max. number discharge cycles 50 cycles total Packing quantity pc. per carton Comply with UN 8. and IEC 6 (safety testing) protected against over charge, over discharge, charging at excessive temperatures, short-circuit and over current. 7. Optical properties 7. Anti panic EM RA BASIC W Max. spacing for >0.5 lux Centre to end Centre to centre.5 m.85 m.80 m 9.40 m 9.40 m.0 m.75 m.80 m 0.40 m 0.40 m.5 m.70 m.70 m 0.95 m 0.95 m 4.0 m.50 m.50 m.0 m.5 m 5.0 m 0.40 m 0.40 m.5 m.5 m All values for ta = 0 C Luminous flux: lm EM RA BASIC W Max. spacing for >0.5 lux Centre to end Centre to centre.5 m.85 m.80 m 0.90 m 0.85 m.0 m.80 m.75 m.90 m.90 m.5 m.80 m.80 m.90 m.90 m 4.0 m.70 m.70 m.90 m.85 m 5.0 m.55 m.50 m 4.90 m 4.90 m 6.0 m.0 m.05 m 5.0 m 5.05 m All values for ta = 0 C Luminous flux: 00 lm Light distribution relative intensity Iv/Iv,max 0 00 90 80 70 60 50 40 0 0 0 0-60 -50-40 -0-0 0 0 0-0 0 90-00 -80-60 -40-0 0 0 40 60 80 00 C0 / C90 / C80 / 70 40 50 60 70 80 For battery data see separate data sheet. Data sheet 05/8-EM06-9 www.tridonic.com 7
7. Escape route EM RA BASIC W Max. spacing for >.0 lux Centre to end Centre to centre.5 m.70 m.0 m 9.95 m 5.70 m.0 m.90 m.0 m 0.0 m 4.85 m.5 m 4.05 m.0 m 0.55 m 4.80 m 4.0 m 4.0 m.40 m 0.95 m.40 m 5.0 m 4.0 m.45 m.60 m.80 m 6.0 m 4.5 m.40 m.05 m 4.00 m 7.0 m.95 m.0 m.0 m 4.0 m 8.0 m.0 m 0.90 m.5 m 4.05 m All values for ta = 0 C Luminous flux: 7 lm EM RA BASIC W Max. spacing for >.0 lux Centre to end Centre to centre.5 m 4.75 m.75 m.65 m 6.55 m.0 m 4.80 m.95 m.75 m 7.0 m.5 m 5.05 m.50 m.45 m 6.85 m 4.0 m 5.0 m.65 m.60 m 6.50 m 5.0 m 5.50 m.80 m 4.0 m 4.5 m 6.0 m 5.70 m.90 m 5.05 m 4.85 m 7.0 m 5.75 m.90 m 5.60 m 5.5 m 8.0 m 5.65 m.85 m 6.05 m 5.5 m All values for ta = 0 C Luminous flux: 00 lm Light distribution relative intensity Iv/Iv,max 0 00 90 80 70 60 50 40 0 0 0 0-60 -50-0 -0 0 0 0-0 0-40 40 50 60-00 -80-60 -40-0 0 0 40 60 80 00 70 80 90 C0 / C80 C90 / C 70 7. Spot EM RA BASIC W Max. spacing for >0.5 lux / > 5 lux Minimum Centre to end Centre to centre illuminance.5 m.05 m.90 m 4.50 m 4.0 m.0 m.0 m.5 m 5.5 m 5.0 m.5 m.50 m.45 m 6.5 m 6.05 m 0.5 4.0 m.60 m.60 m 6.85 m 6.05 m 5.0 m.80 m.80 m 6.00 m 5.95 m 6.0 m.00 m.95 m 5.85 m 5.80 m 7.0 m.0 m.05 m 6.00 m 6.00 m 8.0 m.5 m.0 m 6.40 m 6.5 m.5 m 0.70 m 0.65 m.00 m.00 m.0 m 0.70 m 0.65 m.0 m.0 m.5 m 0.70 m 0.70 m.40 m.5 m 5.0 4.0 m 0.70 m 0.70 m.50 m.50 m 5.0 m 0.70 m 0.65 m.65 m.65 m 6.0 m 0.60 m 0.55 m.70 m.65 m 7.0 m 0.5 m 0.0 m.75 m.70 m All values for ta = 0 C Luminous flux: 5 lm EM RA BASIC W Max. spacing for >0.5 lux / > 5 lux Minimum Centre to end Centre to centre illuminance.5 m.05 m.90 m 8.40 m 4.0 m.0 m.5 m.5 m 5.5 m 5.0 m.5 m.80 m.45 m 6.5 m 6.05 m 0.5 4.0 m.70 m.70 m 7.90 m 5.85 m 5.0 m.0 m.05 m 8.90 m 8.40 m 6.0 m.0 m.0 m 8.5 m 8.0 m 7.0 m.50 m.45 m 8.00 m 8.00 m 8.0 m.65 m.60 m 7.80 m 7.85 m.5 m 0.85 m 0.80 m.50 m.45 m.0 m 0.90 m 0.85 m.55 m.55 m.5 m 0.90 m 0.90 m.75 m.75 m 5.0 4.0 m 0.90 m 0.95 m.95 m.95 m 5.0 m 0.95 m 0.90 m.0 m.5 m 6.0 m 0.95 m 0.90 m.50 m.45 m 7.0 m 0.85 m 0.85 m.60 m.55 m 8.0 m 0.75 m 0.75 m.60 m.60 m All values for ta = 0 C Luminous flux: 00 lm Light distribution relative intensity Iv/Iv,max 0 00 90 80 70 60 50 40 0 0 0 0-60 -50-40 -0-0 0 0 0-0 0 90-00 -80-60 -40-0 0 0 40 60 80 00 C0 / C90 / C80 / 70 40 50 60 70 80 Data sheet 05/8-EM06-9 www.tridonic.com 8
8. Miscellaneous 8. Black Box data recording Recording of several parameters only accessable for Tridonic. 8. Additional information Additional technical information at www.tridonic.com Technical Data Guarantee conditions at www.tridonic.com Services The light source of this luminaire is not replaceable; when the light source reaches its end of life replace the whole luminaire. Life-time declarations are informative and represent no warranty claim. No warranty if device was opened. Data sheet 05/8-EM06-9 www.tridonic.com 9