Mobile, secure, and powered storage for up to 10, 18, 20, 24, 27, 30, 36, or 42 computing devices.

UCCSS Series UCCSM Series UCCSL Series ipad, Chromebook, Tablet, and Laptop Cart, Single Frame Mobile, secure, and powered storage for up to 10, 18, 20, 24, 27, 30, 36, or 42 computing devices. The perfect storage solution for tablets, notebooks, and laptops. Contact Information Order toll-free in the U.S. or for FREE 24/7 technical support: Call 877-877-BBOX (outside U.S. call 724-746-5500) www.blackbox.com info@blackbox.com

Important Safety Information/Electrical Precautions Important Safety Information WARNING! Death or serious injury may occur when children climb on the Cart. The cart can tip over onto the child. WARNING! Avoid uneven loading of equipment onto the cart. Uneven weight distribution could cause the cart to tip when the cart is moving. Ensure devices are distributed evenly within the cart. Excess weight on sides of cart could cause the cart to tip while in motion. Only adults should move the cart. Do not leave the cart unattended in areas where children have access. Do not block the air vent openings. The Cart can be very heavy when fully loaded with laptops and should be moved about by persons physically able to do so. The Cart should only be used for the storage and transport of tablets, laptops, and other similar devices. Misuse, incorrect operation, or inadequate repair of the Cart will void the warranty. Electrical Precautions DANGER! Failure to observe the following electrical safety precautions can result in fire or death by electric shock. The power switch must be in the OFF position before plugging the Cart into a wall receptacle. The Cart must ONLY be connected to a 110 120-volt AC, 15-amp power supply. The Cart must only be used by adults or with adult supervision. Never pull the Cart by the power cord. Do not plug the Cart in if the switch, receptacle(s), or power cord has been damaged. All electrical components on this product must be repaired by a qualified electrician. Do not use an extension cord in conjunction with the Cart. Page 2 877-877-2269 blackbox.com UCCSM20T

Electrical Precautions Do not use liquids in or around the Cart environment. Inadequate repair or modifications can create significant hazards to users and is not covered by warranty. For your safety, we recommend that a qualified electrician test the circuit you will be plugging the Cart into. The circuit should be checked for ground integrity and appropriate branch circuit protection. The Cart ground prong must be present for safe operation. If the plug is damaged or if the ground prong has been removed, it should be replaced by a qualified electrician. The use of the Cart, including plugging or unplugging laptops, plugging or unplugging the Cart, operating the control switch, and engaging or releasing the directional and locked casters, must be done with adult supervision. UCCSM20-T 877-877-2269 blackbox.com Page 3

FCC and IC RFI Statements/NOM Statement FEDERAL COMMUNICATIONS COMMISSION AND INDUSTRY CANADA RADIO FREQUENCY INTERFERENCE STATEMENTS This equipment generates, uses, and can radiate radio-frequency energy, and if not installed and used properly, that is, in strict accordance with the manufacturer s instructions, may cause inter ference to radio communication. It has been tested and found to comply with the limits for a Class A computing device in accordance with the specifications in Subpart B of Part 15 of FCC rules, which are designed to provide reasonable protection against such interference when the equipment is operated in a commercial environment. Operation of this equipment in a residential area is likely to cause interference, in which case the user at his own expense will be required to take whatever measures may be necessary to correct the interference. Changes or modifications not expressly approved by the party responsible for compliance could void the user s authority to operate the equipment. This digital apparatus does not exceed the Class A limits for radio noise emis sion from digital apparatus set out in the Radio Interference Regulation of Industry Canada. Le présent appareil numérique n émet pas de bruits radioélectriques dépassant les limites applicables aux appareils numériques de la classe A prescrites dans le Règlement sur le brouillage radioélectrique publié par Industrie Canada. Normas Oficiales Mexicanas (NOM) Electrical Safety Statement INSTRUCCIONES DE SEGURIDAD 1. Todas las instrucciones de seguridad y operación deberán ser leídas antes de que el aparato eléctrico sea operado. 2. Las instrucciones de seguridad y operación deberán ser guardadas para referencia futura. 3. Todas las advertencias en el aparato eléctrico y en sus instrucciones de operación deben ser respetadas. Page 4 877-877-2269 blackbox.com UCCSM20T

NOM Statement 4. Todas las instrucciones de operación y uso deben ser seguidas. 5. El aparato eléctrico no deberá ser usado cerca del agua por ejemplo, cerca de la tina de baño, lavabo, sótano mojado o cerca de una alberca, etc. 6. El aparato eléctrico debe ser usado únicamente con carritos o pedestales que sean recomendados por el fabricante. 7. El aparato eléctrico debe ser montado a la pared o al techo sólo como sea recomendado por el fabricante. 8. Servicio El usuario no debe intentar dar servicio al equipo eléctrico más allá lo descrito en las instrucciones de operación. Todo otro servicio deberá ser referido a personal de servicio calificado. 9. El aparato eléctrico debe ser situado de tal manera que su posición no interfiera su uso. La colocación del aparato eléctrico sobre una cama, sofá, alfombra o superficie similar puede bloquea la ventilación, no se debe colocar en libreros o gabinetes que impidan el flujo de aire por los orificios de ventilación. 10. El equipo eléctrico deber ser situado fuera del alcance de fuentes de calor como radiadores, registros de calor, estufas u otros aparatos (incluyendo amplificadores) que producen calor. 11. El aparato eléctrico deberá ser connectado a una fuente de poder sólo del tipo descrito en el instructivo de operación, o como se indique en el aparato. 12. Precaución debe ser tomada de tal manera que la tierra fisica y la polarización del equipo no sea eliminada. 13. Los cables de la fuente de poder deben ser guiados de tal manera que no sean pisados ni pellizcados por objetos colocados sobre o contra ellos, poniendo particular atención a los contactos y receptáculos donde salen del aparato. 14. El equipo eléctrico debe ser limpiado únicamente de acuerdo a las recomendaciones del fabricante. 15. En caso de existir, una antena externa deberá ser localizada lejos de las lineas de energia. UCCSM20-T 877-877-2269 blackbox.com Page 5

NOM Statement 16. El cable de corriente deberá ser desconectado del cuando el equipo no sea usado por un largo periodo de tiempo. 17. Cuidado debe ser tomado de tal manera que objectos liquidos no sean derramados sobre la cubierta u orificios de ventilación. 18. Servicio por personal calificado deberá ser provisto cuando: A: El cable de poder o el contacto ha sido dañado; u B: Objectos han caído o líquido ha sido derramado dentro del aparato; o C: El aparato ha sido expuesto a la lluvia; o D: El aparato parece no operar normalmente o muestra un cambio en su desempeño; o E: El aparato ha sido tirado o su cubierta ha sido dañada. Page 6 877-877-2269 blackbox.com UCCSM20T

Trademarks Used In This Manual Trademarks Used In This Manual Black Box and the Double Diamond logo are registered trademarks of BB Technologies, Inc. Any other trademarks mentioned in this manual are acknowledged to be the property of the trademark owners. UCCSM20-T 877-877-2269 blackbox.com Page 7

Table of Contents Table of Contents 1. Specifications... 9 2. Overview... 19 2.1 Introduction... 19 2.2 What s Included... 19 2.3 Hardware Description... 20 3. Configuration and Setup... 21 3.1 Installing the Handle... 21 3.2 Routing the Cable... 22 3.3 Fastening the Power Bricks and Routing the Cable... 23 3.4 Installing the Cambrionix PowerPad 15S Units and Power Supplies (UCCSS30H-S and UCCSS30T-S Only)... 25 3.5 HASP Option (UCCSM-10-30H-HASP and UCCSM-10-30T-HASP)... 26 3.6 Pop-Up Power Port Option (UCCSM-10-30TP or UCCSM-10-30HP)... 26 3.7 Stand-Off Brackets Option (UCCSM-10-30H-SO and UCCSM-12-36H-SO)... 26 3.8 Using the Intelligent Charging System (-ILC at end of product code)... 27 3.9 Basket Distribution System (-BIN1 in product code)... 31 4. Using Your ipad, Chromebook, Tablet, and Laptop Cart... 32 4.1 Charging Your Computers... 32 4.2 Moving Your ipad, Chromebook, Tablet, and Laptop Cart... 32 4.3 Timer Instructions... 34 Page 8 877-877-2269 blackbox.com UCCSM20T

Chapter 1: Specifications 1. Specifications Part Number UCCSS20T, UCCSS20H Table 1-1. Cart Specifications UCCSM18T, UCCSM18H, UCCSM18H-ILC, UCCSM18T-ILC Slot Dimensions UCCSL18T, UCCSL18H, UCCSL18H-ILC, UCCSL18T-ILC UCCSS30T, UCCSS30H Height (in.) 13" 13" 13" 8.75" 8.75" UCCSM27T, UCCSM27H UCCSM27T- ILC UCCSM27H- ILC Height (cm) 33.02 cm 33.02 cm 33.02 cm 22.22 cm 22.22 cm Width (in.) 1.36" 1.53" 1.53" 1.36" 1.53" Width (cm) 3.45 cm 3.89 cm 3.89 cm 3.45 cm 3.89 cm Depth (in.) 10" 15" 17" 10" 15" Depth (cm) 25.4 38.1 cm 43.2 cm 25.4 cm 38.1 cm Number of Devices Device Capacity 20 18 18 30 27 External Dimensions (Including Handle)* Height (in.) 44.3" 44.3" 44.3" 44.3" 44.3" Height (cm) 112.5 cm 112.5 cm 112.5 cm 112.5 cm 112.5 cm Width (in.) 33.1" 33.1" 33.1" 33.1" 33.1" Width (cm) 84 cm 84 cm 84 cm 84 cm 84 cm Depth (in.) 24.8" 24.8" 24.8" 24.8" 24.8" Depth (cm) 63 cm 63 cm 63 cm 63 cm 63 cm Weight (Cart with Sliding Door) UCCSS20T UCCSM18T UCCSL18T UCCSS30T UCCSM27T Weight (lb.) 134 lb. 140 lb. 146 lb. 146 lb. 155 lb. Weight (kg) 60.8 kg 63.5 kg 66.2 kg 66.2 kg 70.3 kg Weight (Cart with Solid Steel Door) UCCSS20H UCCSM18H UCCSL18H UCCSS30H UCCSM27H Weight (lb.) 144 lb. 150 lb. 156 lb. 156 lb. 165 lb. Weight (kg) 65.3 kg 68 kg 70.8 kg 70.8 kg 74.8 kg *External dimensions are the same for all single cart models. NOTE: Weight capacity for all single carts is 150 lb. (68.2 kg), stationary., UCCSM20-T 877-877-2269 blackbox.com Page 9

Chapter 1: Specifications Part Number Table 1-1 (continued). Cart Specifications UCCSS-12-36H, UCCSS-12-36T UCCSM-10-10H, UCCSM-10-10T UCCSM-10-20H, UCCSM-10-20T Slot Dimensions Height (in.) 8.75" 8.75" 13" Height (cm) 22.22 cm 22.22 cm 33.02 cm Width (in.) 1.12" 1.36" 1.36" Width (cm) 2.84 cm 3.45 cm 3.45 cm Depth (in.) 15" 13" 13" Depth (cm) 38.1 33.02 cm 33.02 cm Device Capacity Number of Devices 36 10 20 External Dimensions (Including Handle)* Height (in.) 44.27" 44.27" 44.27" Height (cm) 112.4 cm 112.4 cm 112.4 cm Width (in.) 33.07" 33.07" 33.07" Width (cm) 83.99 cm 83.99 cm 83.99 cm Depth (in.) 25.35" 25.35" 25.35" Depth (cm) 64.39 cm 64.39 cm 64.39 cm Weight (Cart with Sliding Door) UCCSS-12-36T UCCSM-10-10T UCCSM-10-20T Weight (lb.) 211.5 lb. 193.5 lb. 208.5 lb. Weight (kg) 95.9 kg 87.8 kg 94.6 kg Weight (Cart with Solid Steel Door) UCCSS-12-36H UCCSM-10-10H UCCSM-10-20H Weight (lb.) 211.5 lb. 193.5 lb. 208.5 lb. Weight (kg) 95.9 kg 87.8 kg 94.6 kg *External dimensions are the same for all single cart models. NOTE: Weight capacity for all single carts is 150 lb. (68.2 kg), stationary. Page 10 877-877-2269 blackbox.com UCCSM20T

Part Number Table 1-1 (continued). Cart Specifications UCCSM-10-30H, UCCSM-10-30T, UCCSM-10-30H-ILC, UCCSM-10-30T-ILC UCCSM-12-36H, UCCSM-12-36T, UCCSM-12-36H-ILC, UCCSM-12-36T-ILC Chapter 1: Specifications UCCSM-12-24H, UCCSM-12-24T, UCCSM-12-24H-ILC, UCCSM-12-24T-ILC Slot Dimensions Height (in.) 8.75" 8.75" 13" Height (cm) 22.22 cm 22.22 cm 33 cm Width (in.) 1.36" 1.1" 1.1" Width (cm) 3.45 cm 2.8 cm 2.8 cm Depth (in.) 13" 15" 15" Depth (cm) 33.02 cm 38.1 38.1 Device Capacity Number of Devices 30 36 24 External Dimensions (Including Handle)* Height (in.) 44.27" 44.27" 44.27" Height (cm) 112.4 cm 112.4 cm 112.4 cm Width (in.) 33.07" 33.07" 33.07" Width (cm) 83.99 cm 83.99 cm 83.99 cm Depth (in.) 25.35" 25.35" 25.35" Depth (cm) 64.39 cm 64.39 cm 64.39 cm Weight (Cart with Sliding Door) UCCSM-10-30T UCCSM-12-36T UCCSM-12-24T Weight (lb.) 223.5 lb. 236.5 lb. 221.1 lb. Weight (kg) 101.4 kg 107.3 kg 100.3 kg Weight (Cart with Solid Steel Door) UCCSM-10-30H UCCSM-12-36H UCCSM-12-24H Weight (lb.) 223.5 lb. 236.5 lb. 221.1 lb. Weight (kg) 101.4 kg 107.3 kg 100.3 kg *External dimensions are the same for all single cart models. NOTE: Weight capacity for all single carts is 150 lb. (68.2 kg), stationary. UCCSM20-T 877-877-2269 blackbox.com Page 11

Chapter 1: Specifications Part Number Table 1-1 (continued). Cart Specifications UCCSM-10-30TP, UCCSM-10-30HP Slot Dimensions Height (in.) 8.75" 8.75" Height (cm) 22.22 cm 22.22 cm Width (in.) 1.36" 1.36" Width (cm) 3.45 cm 3.45 cm Depth (in.) 13" 13" Depth (cm) 33.02 33.02 Number of Devices Device Capacity 30 30 UCCSM-10-30H-HASP, UCCSM-10-30T-HASP External Dimensions (Including Handle)* Height (in.) 44.27" 44.27" Height (cm) 112.4 cm 112.4 cm Width (in.) 33.07" 33.07" Width (cm) 83.99 cm 83.99 cm Depth (in.) 25.35" 25.35" Depth (cm) 64.39 cm 64.39 cm Weight (Cart with Sliding Door) UCCSM-10-30TP UCCSM-10-30T-HASP Weight (lb.) 225.5 lb. 224 lb. Weight (kg) 102.5 kg 101.8 kg Weight (Cart with Solid Steel Door) UCCSM-10-30HP UCCSM-10-30H-HASP Weight (lb.) 225.5 lb. 224 lb. Weight (kg) 102.5 kg 101.8 kg *External dimensions are the same for all single cart models. NOTE: Weight capacity for all single carts is 150 lb. (68.2 kg), stationary. Page 12 877-877-2269 blackbox.com UCCSM20T

Chapter 1: Specifications Table 1-1 (continued). Cart Specifications Part Number UCCSM-10-30H-SO UCCSM-12-36H-SO UCCSM-12-36H-14C Slot Dimensions Height (in.) 8.75" 8.75" 9.75" Height (cm) 22.22 cm 22.22 cm 24.7 Width (in.) 1.36" 1.12" 1.12" Width (cm) 3.45 cm 2.85 cm 2.85 cm Depth (in.) 13" 15" 15" Depth (cm) 33.02 38.1 38.1 Number of Devices Device Capacity 30 36 36 External Dimensions (Including Handle)* Height (in.) 44.27" 44.27" 44.27" Height (cm) 112.4 cm 112.4 cm 112.4 cm Width (in.) 33.07" 33.07" 33.07" Width (cm) 83.99 cm 83.99 cm 83.99 cm Depth (in.) 25.35" 25.35" 25.35" Depth (cm) 64.39 cm 64.39 cm 64.39 cm Weight (Cart with Solid Steel Door) UCCSM-10-30H-SO UCCSM-12-36H-SO UCCSM-12-36H-14C Weight (lb.) 225 lb. 238 lb. 234.5 lb. Weight (kg) 102.2 kg 108.2 kg 106.6 kg *External dimensions are the same for all single cart models. NOTE: Weight capacity for all single carts is 150 lb. (68.2 kg), stationary. UCCSM20-T 877-877-2269 blackbox.com Page 13

Chapter 1: Specifications Table 1-1 (continued). Cart Specifications Part Number UCCSM-12-36H-15C, UCCSM-12-36T-15C UCCSS30T-S, UCCSS30H-S Slot Dimensions Height (in.) 11.5" 10" 8.75" Height (cm) 29.21 cm 25.4 cm 22.22" Width (in.) 1.12" 1.36 0.87" Width (cm) 2.84 cm 3.45 cm 2.21 cm Depth (in.) 15" 10" 13" Depth (cm) 38.1 cm 25.4 cm 33.02 cm Number of Devices Device Capacity 36 30 42 External Dimensions (Including Handle)* Height (in.) 44.27" 44.27" 44.27" Height (cm) 112.4 cm 112.4 cm 112.4 cm Width (in.) 33.07" 33.07" 33.07" Width (cm) 83.99 cm 83.99 cm 83.99 cm Depth (in.) 25.35" 25.35" 25.35" Depth (cm) 64.39 cm 64.39 cm 64.39 cm Weight (Cart with Sliding Door) Weight (lb.) 232.5 lb. 216.5 lb. 236.5 lb. Weight (kg) 105.7 kg 98.4 kg. 107.5 lb. Weight (Cart with Solid Steel Door) Weight (lb.) 236.5 lb. 216.5 lb. 236.5 lb. Weight (kg) 107.5 kg 98.4 kg. 107.5 lb. UCCSM-14-42T, UCCSM-14-42H, UCCSM-14-42T-ILC, UCCSM-14-42H-ILC *External dimensions are the same for all single cart models. NOTE: Weight capacity for all single carts is 150 lb. (68.2 kg), stationary. Page 14 877-877-2269 blackbox.com UCCSM20T

Chapter 1: Specifications Part Number Table 1-1 (continued). Cart Specifications UCCSM-BIN1-36T, UCCSM-BIN1-36H UCCSM-BIN1-36H-FCM0, UCCSM-BIN1-36T-FCM0 UCCBIN1KIT Basket Dimensions Height (in.) 5" 5" 5" Height (cm) 12.7 cm 12.7 cm 12.7 cm Width (in.) 8.25" 8.25" 8.25" Width (cm) 20.9 cm 20.9 cm 20.9 cm Depth (in.) 10.875" 10.875" 10.875" Depth (cm) 27.6 cm 27.6 cm 27.6 cm Number of 6 6 1 Baskets Device Capacity Number of 36 36 6 Devices Maximum Device Size H x W x D 8"H x 1"W x 9"D (20.3 x 2.5 x 22.8 cm) 9"H x 1"W x 9"D (22.8 x 2.5 x 22.8 cm) External Dimensions (Including Handle)* 1"W x 9"D (2.5 x 22.8 cm) Height depends on cart Basket Dimensions Height (in.) 44.27" 44.27" 5" Height (cm) 112.4 cm 112.4 cm 12.7 Width (in.) 33.07" 33.07" 8.25" Width (cm) 83.99 cm 83.99 cm 20.9 Depth (in.) 25.35" 25.35" 10.875" Depth (cm) 64.39 cm 64.39 cm 27.6 Weight (Cart with Sliding Door) Max. Basket Weight Loaded Weight (lb.) 210 lb. 210 lb. 25 lb. Weight (kg) 95.4 kg 95.4 kg 11.4 kg Weight (Cart with Solid Steel Door) Weight (lb.) 210 lb. 210 lb. 25 lb. Weight (kg) 95.4 kg 95.4 kg 11.4 kg UCCSM20-T 877-877-2269 blackbox.com Page 15

Chapter 1: Specifications Part Number UCCSM18T, UCCSM18H UCCSL18T, UCCSL18H UCCSS20T, UCCSS20H UCCSS30T, UCCSS30H, UCCSM27T, UCCSM27H UCCSS-12-36T, UCCSS-12-36H UCCSM-10-10T UCCSM-10-10H UCCSM-10-20T, UCCSM-10-20H UCCSM-10-30T, UCCSM-10-30H, UCCSM-10-30TP, UCCSM-10-30HP, UCCSM-10-30H-HASP, UCCSM-10-30T-HASP, UCCSM-10-30H-SO UCCSM-12-36T, UCCSM-12-36H, UCCSM-12-36H-SO, UCCSM-12-36H-14C, UCCSM-12-36H-15C, UCCSM-12-36T-15C, UCCSM-BIN1-36T, UCCSM-BIN-36T-FCM0, UCCSM-BIN1-36H, UCCSM-BIN1-36H-FCM0 UCCSS30T-S, UCCSS30H-S Table 1-2. Power Strip Specifications Automated Power Included Power Strips Controller (1) 4-outlet, 4-bank (2) 12-outlet, 15 A max. automated power controller with alwayson outlet, 15-minute (2) 12-outlet, 15 A max. increments, 100 125 V, (2) 12-outlet, 15 A max. 50 60 Hz, 15 amp max. (3) 12-outlet, 15 A max. (3) 12-outlet, 15 A max. (3) 12-outlet, 15 A max. (1) 12-outlet, 15 A max. (2) 12-outlet, 15 A max. (3) 12-outlet, 15 A max. (3) 12-outlet, 15 A max. (2) Cambrionix Power Pad 15S units and power supplies Page 16 877-877-2269 blackbox.com UCCSM20T

Chapter 1: Specifications Part Number UCCSM-12-24T, UCCSM-12-24H UCCSM-14-42T, UCCSM-14-42H Table 1-2 (continued). Power Strip Specifications Automated Power Included Power Strips Controller (1) 4-outlet, 4-bank (2) 12-outlet, 15 A max. automated power controller with alwayson outlet, 15-minute (4) 12-outlet, 15 A max. increments, 100 125 V, 50 60 Hz, 15 amp max. Part Number UCCSM18T-ILC, UCCSM18H-ILC UCCSL18T-ILC, UCCSL18H-ILC UCCSM27T-ILC, UCCSM27H-ILC UCCSM-10-30T-ILC, UCCSM-10-30H-ILC UCCSM-12-36T-ILC, UCCSM-12-36H-ILC UCCSM-12-24T-ILC, UCCSM-12-24H-ILC UCCSM-14-42T-ILC, UCCSM-14-42H-ILC Table 1-3. Charging Units included with Carts. Intelligent Charging Included Power Strips System (1) Intelligent Charging (2) 12-outlet, 15 A max. System Unit (SDILCU4) (2) 12-outlet, 15 A max. (3) 12-outlet, 15 A max. (3) 12-outlet, 15 A max. (3) 12-outlet, 15 A max. (2) 12-outlet, 15 A max. (4) 12-outlet, 15 A max. UCCSM20-T 877-877-2269 blackbox.com Page 17

Chapter 1: Specifications Table 1-3. Accessories Specifications Part Number Accessory Specs UCCSHELFS Small device shelf Number of Slots: 10; Slot Dimensions: 1.32"W x 10"D UCCSHELFM Medium device shelf Number of Slots: 9; Slot Dimensions: 1.52"W x 15"D UCCSHELFL Large device shelf Number of Slots: 9; Slot Dimensions: 1.52"W x 17"D UCCSHELF Storage shelf Height: 2U UCC-PPM Pop-up power module Recesses into top laminate of cart, 2-outlet, 110 125 V UCCDRAWER-2U 2U Accessory Drawer Height: 3.5"H (2U); Cable Access: 1.75"D; Weight: 15 lb. (6.8 kg) UCCDRAWER-3U 3U Accessory Drawer Height: 5.25"H (3U); Cable Access: 1.75"D; Weight: 18 lb. (8.2 kg) UCCDIVIDER-S PVC-coated divider for small shelves UCCDIVIDER-ML PVC-coated divider for medium and large shelves UCCLINER-S-10 Shelf liner for UCC small 10-slot shelves UCCLINER-S-12 Shelf liner for UCC small 12-slot shelves UCCLINER-M Shelf liner for UCC medium 9-slot shelves UCCLINER-M-10 Shelf liner for UCC medium 10-slot shelves UCCLINER-M-12 Shelf liner for UCC medium 12-slot shelves UCCLINER-L Shelf liner for UCC large shelves UCCBIN1KIT 6-Device Charging Cart Basket Kit for Deluxe, Basic, and 30-Device Standard Carts Dimensions: 5"H x 8.25"W x 10.875"D (12.7 x 20.9 x 27.6 cm); Page 18 877-877-2269 blackbox.com UCCSM20T

Chapter 2: Overview 2. Overview 2.1 Introduction The ipad, Chromebook, Tablet, and Laptop Cart is designed to store, charge, and transport tablets, e-readers, laptops, netbooks, and other similar devices. Units are available with capacities for 10, 18, 20, 24, 27, 30, 36, or 42 separate storage slots. Each unit plugs into a typical 120-volt 15-amp outlet. Carts are available with sliding or solid-steel doors. Syncing and intelligent charging carts are also available. Please read these operating instructions carefully. They contain important advice concerning the use and safety of your cart. This Cart must only be used for its intended purpose in accordance with these operating instructions. 2.2 What s Included ipad, Chromebook, Tablet, and Laptop Cart with 10-, 18-, 20-, 24-, 27-, 30-, 36-, or 42-device capacity; assembled (4) casters (installed), including: (2) locking swivel casters and (2) non-locking fixed casters (1) Automated Power Controller or Intelligent Charging System Unit (installed) Power Strips (installed): See the power strips specifications in Table 1-2 on the previous page. Cart handle with mounting hardware (to be installed by user) (1) user s manual (2) sets of keys UCCSM20-T 877-877-2269 blackbox.com Page 19

Chapter 2: Overview 2.3 Hardware Description Cable Grommet or Pop-Up Power Module Ventilation Laminate Top Handle and Power Cord Wrap Removable Rear Door Sliding Door Non-Locking Casters Cable Access Locking Swivel- Casters Figure 2-1. Front and back of cart with sliding door. Cable Grommet or Pop-Up Power Module Ventilation Laminate Top Handle and Power Cord Wrap Removable Rear Door Solid Steel Door Non-Locking Casters Cable Access Locking Swivel- Casters Figure 2-2. Front and back of cart with solid steel door. Page 20 877-877-2269 blackbox.com UCCSM20T

Chapter 3: Configuration and Setup 3. Configuration and Setup Remove and discard all packaging materials and then lock the lockable casters. Open and inspect the Cart to verify all doors, locks, and casters are working properly. Do not plug the Cart into a wall outlet until all configurations and setup are complete. 3.1 Installing the Handle The handle/cord wrap installs on the side of the cart with the locking swivel casters. NOTE: The casters swivel on one side of the Cart and are fixed on the other. Consider maneuverability options before installing the handle. Step 1: Locate the side of the cart with the locking swivel casters. Step 2. Place the handle so that the holes in the brackets are aligned with the threaded holes in the side panels. Phillips-head screws Handle Phillips-head screws Figure 3-1. Handle assembly. Step 3. Using a Phillips-head screwdriver, tighten four of the Phillips-head screws into the threaded holes. UCCSM20-T 877-877-2269 blackbox.com Page 21

Chapter 3: Configuration and Setup 3.2 Routing the Cable (UCCSS20T, UCCSS20H, UCCSS30T, UCCSS30H) 1. At the back of the cart, loosen the two screws on the cable manager, pull up on the top section of the cable manager, and place the device side of the charging cable into one of the slots. (See Figure 3-2.) Cable manager Loosen screws on cable manager and pull up Route cable to the front of the cart Power Strip Wrap excess cable around cable wrap Charger Figure 3-2. Small shelf routing instructions. 2. Replace the top section of the cable manager and tighten the screws. 3. Route the device side of the charging cable to the front of the cart and repeat step 1 for the front cable manager. 4. Wrap any excess cable around the cable wrap on the back of the shelf. 5. Plug the charger power plug into the power strip located below the shelf. Page 22 877-877-2269 blackbox.com UCCSM20T

Chapter 3: Configuration and Setup Loosen screws on cable manager and pull up Cable manager Route cable to the front of the cart Figure 3-3. Routing the cable. 3.3 Fastening the Power Bricks and Routing the Cable (UCCSM18T, UCCSM18H, UCCSM27T, UCCSM27H, UCCSL18T, UCCSL18H) 1. Attach the wrapped cord and power brick to the back of the shelf using the hook and loop strap. Keep some extra cable unwrapped to plug into the power strip. (See Figure 3-4.) 2. Loosen the two screws on the cable manager, pull up on the top section of the cable manager, and place the device side of the charging cable into one of the slots. 3. Replace the top section of the cable manager and tighten the screws. 4. Route the device side of the charging cable to the front of the cart and repeat step 2 for the front cable manager (see Figure 3-3). UCCSM20-T 877-877-2269 blackbox.com Page 23

Chapter 3: Configuration and Setup 5. Plug the charger power plug into the power strip located below the shelf. Loosen screws on cable manager and pull up Route cable to the front of the cart Cable manager Power block and cord Power strip Figure 3-4. Fastening the power brick and routing the cable. Page 24 877-877-2269 blackbox.com UCCSM20T

Chapter 3: Configuration and Setup 3.4 Installing the Cambrionix PowerPad 15S Syncing Units (UCCSS30H-S and UCCSS30T-S Only) Charge and sync up to 10 devices per locker or 30 devices per cart at the same time. The USB charge and sync device works with nearly all e-learning devices including Chromebook computers, ipad devices, mobile phones, e-readers, 3D glasses, and other tablets. The synchronization is achieved through a terminal interface (in the 16 th USB port) which also allows you to control, monitor, and update the USB charge and sync device with the latest firmware. It is perfect for schools, businesses, and other organizations that require numerous devices to be charged and synced at the same time. Figure 3-5. USB charge and sync device installed in Syncing Cart (UCCSS30HS or UCCSS30T-S). UCCSM20-T 877-877-2269 blackbox.com Page 25

Chapter 3: Configuration and Setup 3.5 HASP Option (UCCSM-10-30H-HASP and UCCSM-10-30T-HASP) A HASP lock option is available on the UCCSM-10-30H-HASP and UCCSM-10-30T-HASP carts. Hasp for optional padlock Figure 3-6. HASP lock option on the UCCSM-10-30H-HASP. 3.6 Pop-Up Power Port Option (UCCSM-10---SM-10-30HP Only) A popup power port is available for maximum safety. Figure 3-7. Popup power port. 3.7 Standoff Brackets Option UCCSM-10-30H-SO and UCCSM-12-36H-SO carts use standoff brackets to create a shelf using the power strips in the back. This ensures that power adapters don't fall. Page 26 877-877-2269 blackbox.com UCCSM20T

Chapter 3: Configuration and Setup 3.8 Using the Intelligent Charging System (-ILC at end of product code) The Intelligent Charging System Module arrives installed in your cabinet. 3.8.1 Display Tour Power Icon Charge Button AUX Button Charging Port LEDs USB Port Manage Button LED Display Reset Button Figure 3-8. Front of SDILCU4. Back Power Connector Auxiliary Outlet Charging Ports Figure 3-9. Back of SDILCU4. UCCSM20-T 877-877-2269 blackbox.com Page 27

Chapter 3: Configuration and Setup 3.8.2 To Begin Charging Connect to Power Select Charging Mode (Choose from Charge Mode or Manage Mode.) CHARGE MODE: Best used if all devices are powered off and connected at the same time. Power is discontinued when batteries reach full charge to conserve energy. MANAGE MODE: Best used if all or some devices are left on or are returned at different times. Charging continues until it is manually stopped. NOTE: The charging system should always be in MANAGE mode in order to charge ipads and devices that remain in sleep mode. Page 28 877-877-2269 blackbox.com UCCSM20T

Chapter 3: Configuration and Setup 3.8.3 Basic Functions Charge Button Pressing the CHARGE button will start charge mode. This is best used when all devices are powered down and returned to the cart at the same time. Charging will automatically stop when all batteries are 100% charged. You can also stop charging at any time by pressing the CHARGE button a second time. Manage Button Pressing MANAGE button will start manage mode and turn on the auxiliary power. This mode will continuously monitor and distribute power until manually stopped. This mode is best used if some of the devices may be left on when connected or if devices are connected at different times. Press the button again to stop manage mode. Auxiliary Power Button Controls power to any peripherals that are plugged into the AUX power strip in the back of the cart. If the AUX devices must be operational during charging then the system must be in manage mode. Be aware that this may lengthen charging time. UCCSM20-T 877-877-2269 blackbox.com Page 29

Chapter 3: Configuration and Setup Charging Port LEDs Indicates which sections of the cart are active. The charging unit controls this automatically, ensuring that all devices inside are charged in the fastest, most efficient way possible. When all four quadrant LEDs are solid green, charging is complete. Power Icon Indicates when the cart is connected to power and is ready. Reset Button The Intelligent Charging System is protected with its own circuit breaker. If it encounters misuse such as plugging in unsupported devices or if there is a power surge, the circuit will trip and the reset button will pop out. To reset the cart simply press it back in. Please first ensure that everything is plugged in properly and that only supported devices are connected before resetting. Page 30 877-877-2269 blackbox.com UCCSM20T

Chapter 3: Configuration and Setup 3.9 Basket Distribution System UCC carts with baskets (UCCBIN1KIT) instead of slots include: UCCSM-BIN1-36T UCCSM-BIN1-36H UCCSM-BIN1-36T-FCM0 UCCSM-BIN1-36T-FCM0 The baskets can also be ordered separately: UCCBIN1KIT Figures 3-10 through 3-12 show the UCCBIN1KIT basket. Baskets installed in cart. Basket, side view. Basket, top view. UCCSM20-T 877-877-2269 blackbox.com Page 31

Chapter 4: Using Your ipad, Chromebook, Tablet, and Laptop Cart 4. Using Your ipad, Chromebook, Tablet, and Laptop Cart 4.1 Charging Your Computers After the devices have been loaded into the Cart, plug the power cord of the Cart into a suitable receptacle. Locate the internal power switches on the timer and power strips of the Cart and push the switches to the ON position. 4.2 Moving Your ipad, Chromebook, Tablet, and Laptop Cart Turn the timer power switch to the off position. Remove the Cart plug from the wall receptacle and wrap the cord around the cord wrap or handle. Close and secure sliding or solid-steel doors. Your Cart comes equipped with two fixed casters and two locking swivel casters. Unlock the casters before moving the Cart to a new location. When you reach your desired destination, lock the casters to prevent the cart from moving and plug the Cart into a wall receptacle. Page 32 877-877-2269 blackbox.com UCCSM20T

Chapter 4: Using Your ipad, Chromebook, Tablet, and Laptop Cart Timer Power cord Cable access ports To wall outlet Figure 4-1. Plug the cart into the wall. UCCSM20-T 877-877-2269 blackbox.com Page 33

Chapter 4: Using Your ipad, Chromebook, Tablet, and Laptop Cart 4.3 Timer Instructions Before using your timer: For your safety, we recommend that a qualified electrician test the circuit you will plug the cart into. The circuit should be checked for ground integrity and appropriate branch circuit protection. The cart s ground prong must be present for safe operation. If the plug is damaged or if the ground prong has been removed, it should be replaced by a qualified electrician. Using the cart, including plugging it in or unplugging it, plugging in or unplugging the laptop(s) or other electrical equipment, or operating the control switch must be done with adult supervision. The timer comes preset from the factory to alternate power between the power strips at 15-minute intervals. All power strips cannot charge simultaneously. By plugging the cart power cord into an approved outlet and flipping the red switches located on the timer and power strips, the cart will begin charging. To end power, turn the red switch on the timer off and unplug the cart from the wall outlet. Page 34 877-877-2269 blackbox.com UCCSM20T

NOTES UCCSM20-T 877-877-2269 blackbox.com Page 35

Black Box Tech Support: FREE! Live. 24/7. Tech support the way it should be. Great tech support is just 60 seconds away at 724-746-5500 or blackbox.com. About Black Box Black Box Network Services is your source for an extensive range of networking and infrastructure products. You ll find everything from cabinets and racks and power and surge protection products to media converters and Ethernet switches all supported by free, live 24/7 Tech support available in 60 seconds or less. Copyright 2016. Black Box Corporation. All rights reserved. UCCSM20T, version 6 877-877-2269 blackbox.com