DATE Place Kilometers Cost Description of Repairs FY 2009-2010 24-May-2010 ACT Truck Repairs $302.50 A Service 15-June-2010 Gipps Truck Centre 31592 $1,423.95 Service at CMV Hallam 17-July-2010 ACT Truck Repairs $825.00 B Service 26-August-2010 Cummins South Pacific 69780 $800.00 B Service 24-September-2010 ACT Truck Repairs $825.00 B Service 04-October-2010 Gipps Truck Centre 69703 $123.30 Repairs 23-November-2010 Truckair $99.00 Ice pack service 25-November-2010 Cummins South Pacific 130000 $800.00 B Service 31-December-2010 Cummins South Pacific 155032 $654.50 B Service 27-January-2011 Truckair $216.00 Ice pack service 03-February-2011 Cummins South Pacific $785.13 B Service 03-March-2011 Cummins South Pacific $655.66 B Service 01-April-2011 Gipps Truck Centre 212039 $1,682.80 Roadworthy on Truck & trailers, B Service 27-May-2011 Cummins South Pacific 228738 $744.32 Oil Consuption rebuild, note Cylinder head, pistons,liners,piston rings, & turbo charger replaced and cover by Cummins Warranty 03-June-2011 Cummins South Pacific 247431 $883.30 B Service FY 2011-2012 06-July-2011 Cummins South Pacific 266266 $881.30 B Service 10-August-2011 Gipps Truck Centre 282644 $213.70 A Service 15-August-2011 Cummins South Pacific 286044 $654.50 B Service 01-September-2011 Gipps Truck Centre 297697 $445.95 Coolant leaking from Radiator core remove and sent to Tralagon, refit in Bairnsdale (Warranty) 01-September-2011 East Gippsland Auto Elec $1,243.55 New Alternator & 4 new Batteries 19-September-2011 Cummins South Pacific 306070 $654.50 B Service 07-October-2011 Gipps Truck Centre 310172 $636.10 Repairs to Truck & Trailer 21-October-2011 Weller Mechanical Repairs 326387 $762.87 B Service 18-November-2011 Gipps Truck Centre 346917 $924.35 Hotset & B Service 23-November-2011 Gipps Truck Centre 335623 $279.00 Repairs 01-December-2011 Gipps Truck Centre 357270 $197.95 Repair & New Starter Motor (Warranty) 21-December-2011 D & L Laser Alignment 370691 $385.00 Truck Alignment 22-December-2011 Gipps Truck Centre 370955 $935.05 B Service 06-January-2012 Ride & Shine $4,411.00 Bling 09-February-2012 Gipps Truck Centre 393220 $1,296.70 Repairs & B service 10-March-2012 Gipps Truck Centre 417652 $811.75 B Service 16-March-2012 Gipps Truck Centre 417652 $378.95 FIT new Bush & pin kit in Gearlever 12-April-2012 Gipps Truck Centre 434118 $2,185.60 Road Worthy on Truck & trailers, B Service, remove Front Diff & reseal to stop Oil Leak (warranty) 13-April-2012 Bairnsdale Windscreens $260.00 Front Lefthand Screen 19-May-2012 Gipps Truck Centre 456244 $765.70 B Service 21-June-2012 Cummins South Pacific 478900 $818.31 B Service 23-June-2012 Cummins South Pacific 479003 $1,425.50 New EGR Valve 28-June-2012 Gipps Truck Centre 483300 $196.05 A Service FY 2012-2013 28-July-2012 Gipps Truck Centre 502682 $686.55 B Service
25-August-2012 Gipps Truck Centre 502682 $253.55 Coolant System leaks 31-August-2012 Gipps Truck Centre 525140 $814.55 B Service 22-September-2012 Gipps Truck Centre 538825 $328.15 Coolant System faults 01-October-2012 Gipps Truck Centre 543064 $749.25 B Service 02-October-2012 D & L Laser Alignment 543317 $440.00 Truck Alignment 15-October-2012 Gipps Truck Centre 551490 $5,945.75 New Turbo, Airdryer Kit 15-October-2012 Cowra Auto Electrical $1,243.00 New Starter Motor 29-October-2012 Cummins South Pacific 561000 $580.23 Tune up 30-October-2012 Cummins South Pacific 561000 $500.68 Exhaust Manifold Leaks 30-October-2012 Cummins South Pacific 561000 $745.80 B Service 09-November-2012 Gipps Truck Centre 570468 $2,371.05 Replace CAC (CHARGE AIR COOLER) 07-December-2012 Gipps Truck Centre 583747 $758.75 B Service 31-December-2012 East Gippsland Auto Elec $764.30 New Batteries 17-January-2013 Gipps Truck Centre 605500 $1,385.45 Replace Front Drive Shockers, Diff Oils & filter, Heater tap, Horton Fan US & B Service 18-January-2013 Paccar Trucks Melb 605500 $3,307.50 Repair Horton Fan 25-January-2013 Paccar Trucks Melb $1,012.65 Repair heater & Airconditioner 22-February-2013 Gipps Truck Centre 626049 $1,827.65 Replaced wear plates on Trailers & B Service 06-March-2013 Cummins South Pacific 632510 $1,719.89 replace EGR cooler 08-March-2013 Cummins South Pacific 632510 $125.35???? 22-March-2013 Truckair $276.00 Ice pack service 22-March-2013 Cummins South Pacific 643200 $802.41 Blocked CAC & Radiator 28-March-2013 Gipps Truck Centre 647784 $702.10 B Service 05-April-2013 Gipps Truck Centre 650322 $279.10 Check Radiator for leaks & coolant in EGR & EGR Value nothing Found 18-April-2013 Gipps Truck Centre 650322 $2,193.70 Roadworthy on Truck & trailers, remove & refit Radiator & fit Phone Kit 18-April-2013 Gipps Truck Centre 650322 $6,947.35 rebuild ENGINE 03-May-2013 Gipps Truck Centre 650322 $398.40 Remove & replace fuel line from tank to fuel cooler & to fuel rail 15-May-2013 Gipps Truck Centre 667718 $721.75 B Service 28-June-2013 Cummins South Pacific 694390 $752.73 B Service FY 2013-2014 25-July-2013 Gipps Truck Centre 711467 $991.95 B Service & Etc 24-August-2013 Lawrence Bassett 729842 $869.00 Call out to Tap hill, repair damaged relay value 26-August-2013 Gipps Truck Centre 730888 $1,038.20 repair heater & B Service 27-August-2013 Camel's Truck Repair $172.97 supply SRI Value & breakdown 09-September-2013 Cummins South Pacific $676.50 B Service 27-September-2013 Gipps Truck Centre 753336 $1,602.75 Fix Air leak at back of Gearbox, & B Service 05-October-2013 Gipps Truck Centre 757534 $593.85 replace Speedo 06-November-2013 Gipps Truck Centre 19763 $3,851.55 New Batteries, replace Alternator, Change Diff Oil, New heater core & B Service 15-November-2013 Gipps Truck Centre 25268 $379.50 new loom from speedo head to speed senser 03-December-2013 Ken Landt Diesel Repair 36296 $1,632.70 Found VG Turbo Actuator Failed replaced Turbo Actuator in Bundaberg 11-December-2013 Gipps Truck Centre 42406 $3,421.70 New Clutch & machine Flywheel & B Service 17-January-2014 Truckair $340.50 Ice pack service 24-January-2014 East Gippsland Auto Elec $1,943.00 Fix & repair A/Conditioner 31-January-2014 Gipps Truck Centre 66101 $720.10 top up Diff Oil & B Service 06-March-2014 Gipps Truck Centre 86669 $748.75 B Service 27-March-2014 Gipps Truck Centre 87245 $450.90 repairs 14-April-2014 Cummins South Pacific 111650 $918.56 B Service
29-April-2014 Gipps Truck Centre 120643 $1,416.30 Replace & Fix Oil leak on Drive new Brakes on 1 Wheel righthand side front Axle, 4 new Shockers on Drive 16-May-2014 Gipps Truck Centre 133922 $3,699.75 Remove & replace KINGPINS & remove front Diff repair Oil leak & B Service 17-June-2014 AB Auto Electrics $89.10 Check & repair Driving Lights FY 2014-2015 Cummins Sth Pacific $918.56 B - Service 01-July-2014 Cummins Sth Pacific 117428 $2,415.20 VGT Actuator internal short, engine wiring harness broken 01-July-2014 Cummins Sth Pacific $918.56 B - Service 08-July-2014 Gippsland Truck Centre 160214 $225.00 Change boost sensor & diff pressure tubes - one tube broken 28-July-2014 Cummins Sth Pacific 120686 $755.70 B - Service 28-July-2014 Cummins Sth Pacific 1174282 $2,415.20 VGT Actuator internal short - engine wiring harness broken wires 04-August-2014 Bridgestone 178681 $62.00 Rotate tyres x 2 & puncture repair 25-August-2014 Kenworth $818.05 Repairs to Horton; horton locked on 26-August-2014 Gippsland Truck Centre 186986 $1,343.59 B - Service & inspect oil leaks 26-August-2014 Gippsland Truck Centre 186986 $1,620.00 Repair oil leak front of engine; remove radiator & repair leaks around cam cover & front cover; remove & replace broken bolts found; repair diff oil leak; weld cracks in diff housing 22-September-2014 Cummins Sth Pacific 123948 $1,599.58 EGR Value stuck closed, remove and replaced 22-September-2014 Cummins Sth Pacific 1206860 $755.70 Engine service 10-October-2014 Gippsland Truck Centre 220969 $161.70 A- service; Grease & adjust clutch; clean boost sensor 18-October-2014 Kenworth 191631 $310.20 Trottle issue rectified 21-October-2014 Gippsland Truck Centre 225546 $246.05 Inspect fault codes; found throttle sensor code; inspect & replace throttle sensor 23-October-2014 A1 Trailers $66.00 Repairs to gates 11-November-2014 Gippsland Truck Centre 230352 $993.25 B - Service, remove intercooler & clean radiator and charge air cooler. Replace sensor and run new wires to gauge 13-November-2014 Brown & Hurley $64.86 Coolant 20-November-2014 Bridgestone 239000 $4,378.00 Fit tyre x 8 24-November-2014 Cummins Sth Pacific 1239487 $1,599.58 EGR valve stuck open 25-November-2014 Gippsland Truck Centre 239154 $2,674.05 Remove Turbo and EGR cooler, replace EGR cooler; inspect vehicle for coolant loss 08-December-2014 Bridgestone 248493 $1,791.20 Fit & balance tyres x 2 12-December-2014 Gippsland Truck Centre 248099 $1,045.85 B - Service to truck & trailer 06-January-2015 East Gippsland Auto Elec $282.80 Call out, truck won't start, isolate and replace 2 worst batteries. Supply Exide power breed PBN70MF x 2 24-January-2015 East Gippsland Auto Elec $365.20 Exide battery N70ZZMF x 2 28-January-2015 Gippsland Truck Centre 270076 $1,880.35 B - Service & service trailer. Fit new torgue rod bushes to front drive, change frontdiff oil filer and screen. Fit new airbag to (R) centre axle of trailer, replace 2 batteries in top carrier of truck 02-February-2015 East Gippsland Auto Elec $75.00 12V 60/55W H4 100% twin pack 09-March-2015 Briskair $364.78 Icepack bad terminal contacts at compressor 11-March-2015 Gippsland Truck Centre 291640 $890.10 A - Service 13-March-2015 Bridgestone 300464 $160.00 Fit & rotate tyres 18-March-2015 Gippsland Truck Centre 300151 $411.90 Check engine light on. Inspect & replace coolant level 13-April-2015 Cummins Sth Pacific $988.65 B - Service 13-May-2015 Cummins Sth Pacific $988.85 B - Service 15-May-2015 Gippland Truck Centre 339456 $1,157.65 B - Service on truck and service trailer 15-June-2015 AB Auto Electrics $863.50 Check starting and charging. Fit 12V 39MT Delco starter 06-July-2015 Bridgestone 369794 $170.00 rotate Tyres & check pressure 19-June-2015 Gippsland Truck Centre 360741 $1,349.25 B - Service on truck and service trailer
FY 2015-2016 30-January-2015 East Gippsland Auto Elec $825.30 A/C not working 27-July-2015 Cummins Sth Pacific $822.00 B - Service 08-August-2015 East Gippsland Auto Elec $392.00 Replace stereo with Clarion CD/MP3 player 17-August-2015 Bridgestone 396063 $40.00 Puncture repair 03-September-2015 Gippland Truck Centre 407509 $934.60 Remove chasis cover & inspect oil leaks; remove turntable & steam clean; remove front torque rods & rear tailshft; remove rear diff yoke' clean & replace seal; clean cracked aread on front diff housing' gring out and weld crack; weld banana enforcement ring around diff housing 10-September-2015 A1 Trailers $165.00 Repairs to 4 gates 10-September-2015 Bairnsdale Suspension $1,815.00 Reset pair front springs and add extra leaf, pins & bushes 11-September-2015 D & L Laser Alignment 412497 $462.00 Align truck 28-September-2015 AB Auto Electrics $223.30 Check (L) mirror and lights; repair open circuit wiring to door; check radio reception; repair aerial lead 09-October-2015 Cummins Sth Pacific $3,725.00 B - Service; blow out radiator in chasis - running hot 12-October-2015 Bridgestone 429098 $1,800.00 Supply & fit tyre x 2 15-October-2015 Bridgestone 431831 $40.00 Puncture repair 05-November-2015 Brown & Hurley 445561 $92.50 Supply & fit new Pitman arm from steering box 05-November-2015 Briskair $221.98 Icepack system fault; replace faulty relay & repair wiring; replace broken steering bolt 09-November-2015 Camel's Truck Repair 447109 $1,356.20 Rear engine mounts; check intercooler hose; one @ turbo has hole 20-November-2015 Brown & Hurley 456023 $2,950.96 B - Service; A/C fans not working; Replace front drive axle (L) brakes & drum; replace rear drive brake linings and leaking seal 11-December-2015 Sullivan Horan $610.50 R & R rear engine mounts; R & R jack hose; repaired globe in clock 14-December-2015 Brown & Hurley $284.79 Sensor ABS & Pyro sensor VDO 24-December-2015 Kenworth 478321 $161.70 Check & rectify engine warning light on dash & loss of power 06-January-2016 Sullivan Horan 476932 $121.00 Coolant leak; replace O rings; fit Pgro sensor 07-January-2016 Cummins Sth Pacific $11,320.24 B - Service & Fit new rear main crank seal; replace flywheel housing gasket; fit new bottom radiator hose 20-January-2016 Gippsland Truck Centre 487449 $126.50 Diff gauge not working 21-January-2016 Bridgestone 487770 $4,567.20 Supply & fit tyres x 8 28-January-2016 A1 Trailers $670.00 Repair & modify 8 gates; fabricate lifting stick 28-January-2016 Gippsland Truck Centre 491440 $81.00 Sppedo not working 15-February-2016 AB Auto Electrics $734.80 Supply & fit Batteries MF95 x 4 16-February-2016 Bridgestone 502495 $22.00 Rotate tyre Pos 12 25-February-2016 Brown & Hurley 508076 $1,663.99 B Service 31-March-2016 Gippsland Truck Centre $116.05 Fuel gauge not working 11-April-2016 Kenworth 537820 $166.45 Fuel gauge repair 11-April-2016 Cummins Sth Pacific $927.89 B Service 26-May-2016 Camel's Truck Repair 553935 $6,118.93 Compressor replaced 09-June-2016 Gippsland Truck Centre 561818 $1,218.85 Service 21-June-2016 Lawty Auto Electrics & Air 568410 $342.90 Jump start vehicle and located, removed & replaced faulty cable from alternator to battery box 29-June-2016 Sullivan Horan 573204 $181.50 Repaired coolant leak; new flange fitting is on order 01-July-2016 Gippsland Truck Centre 575486 $354.95 Circuit breaker fault. Numerous faults behind dash soldered 18-July-2016 Cummins South Pacific 582749 $822.00 B Service 16-August-2016 Bridgestone 595547 $235.40 Rotate drive tyres, flip inner drives 07-September-2016 Cummins South Pacific $21,481.32 Cam shaft failure 26-September-2016 Gippland Truck Centre 613718 $951.40 Faulty speedo, inspect speed sensor, found harness damaged. Repair harness and test/
03-October-2016 Bridgestone 618523 $1,889.80 Supply, fit and balance tyre Pos 1 & 2