T ABLE OF C ONTENTS FRONT COLLISION 1 DOOR COLLISION 7 REAR COLLISION 9 TRUCK COLLISION PARTS 13 DRIVE & SUSPENSION 17
F RONT C OLLISION FRONT END ASSEMBLY Complete Front Bumper Header Panel Hood with Hinges All Lamps Including Mounting L & R Fenders Core Support Unibody Rails through Shock Towers Condenser Radiator and Bolt-In Cooling Fans GRILL Attaching brackets and fillers HOOD Insulators as optioned Latch catches Bolt-on hinges Front Suspension Cowl Vent Panels AC Lines and Hoses Air Cleaner Assembly Antenna Mouldings and Emblems HEADER PANEL Header Panel Grill L & R Headlamps Park & Side Marker Lamps (If Panel Mounted) All Mounting Brackets 1 2
F RONT C OLLISION LH AIRBAG Airbag Assembly Dash Covers Sensors Airbag computer RH AIRBAG Airbag Assembly FRONT BUMPER Guards Pads Fascia Cover Unbolt Reinforcement Absorbers Mounting Brackets Lamps (If Bumper Mounted) End Caps Applicable Fillers Dash Covers Sensors Airbag computer STEERING COLUMN All Levers and Switches Key Cylinder Column to First Disconnect at Steering Gear R FRONT FENDER Outer Skin and Inner Liner (If Applicable) Steering Wheel Steering Wheel Control Units Airbag and Clockspring 3 4
F RONT C OLLISION WINDSHIELD Glass Only RADIATOR Radiator Assembly ( Core and Tanks) Attached Mounting Radiator Cooling Fan External Engine and Transmission Coolers Surround Mouldings and Rear View Mirror Attachment COOLING FAN ASSEMBLY Fan Motor Shroud Blade and Attached Mounting Description is Applicable for Both Radiator and Condenser HEADLAMP Headlamp Capsule and Independent Mounting Panel with adjusting Screws (If Applicable) Adjacent Park, Marker and Fog Light CONDENSER Condenser Core Assembly and Attached Mounting Condenser Cooling Fan and AC Lines 5 6
D OOR C OLLISION DOOR ASSEMBLY Door Shell Door Latch Weather Strips Door Window(s) Window Channel Runs Door Window Regulator Motor and Lock Actuators (If Applicable) Outside Door Handle Upper and Lower Door Hinges Non-Welded Door Mirror Mouldings Interior Trim Panel Impact Airbag Power Switches and Controls DOOR MIRROR Mirror Housing and Glass Mirror Mounting Adapter Remote or Electrical Cabling (If Applicable) DOOR GLASS Glass and Permanently Attached Mounting Hardware CENTER POST & ROCKER Inner and Outer Pillar and Rocker Pillar Cut at Roofline Rocker Cut 2" Past Sectioning Seam and 12" in on Floor Custom Cut Available DOOR REGULATOR Regulator and Power Motor (If Applicable) 7 8
R EAR C OLLISION LID Lid Panel Latch Lock Cylinder Hinged (If Welded to Lid) Rear Finish Panel and Third Brake Lamp (If Applicable) Hinge Assembly Spoiler Luggage Rack Power Release Actuator Lift Props REAR CLIP ASSEMBLY Rear Bumper Deck Lid/Hatch Assembly Rear Finish Panel Left and Right Tail Lamps Left and Right Quarter Panels Trunk Floor Rear Unibody Frame Rails Back Glass (As Optioned) Roof Panel Inner and Outer Body Floor Pan to First Seam Rear Suspension Luggage and Roof Racks Sunroof Glass Quarter Window(s) Moulding Spare Tire Jack Assembly Interior Trim Fuel Tank REAR BUMPER Guards Pads Fascia Cover Unbolt Reinforcement Absorbers Mounting Brackets Lamps (If Bumper Mounted) End Caps Applicable Fillers 9 10
R EAR C OLLISION TAIL LIGHT Same as Supplied From an OEM Dealer Only Recycled OEM QUARTER PANEL Outer Quarter Skin Inner Quarter Structure Side Marker Light Inner Wheelhouse and Trunk Extensions Dogleg and Partial Rocker Applicable Side Unibody Frame Rail Fuel Door (As Optioned) Quarter Window Rear Suspension Tail Lamp Quarter and Tail Light Extensions Exterior Mouldings Interior Trim GLASS Same as Supplied From an OEM Dealer Only Recycled OEM Includes All Permanently Attached Mounting Hardware Please Order All Glass (As Optioned) Verifying Heat, Tint, Stationary or Moveable (When Applicable) REAR FINISH PANEL Same as Supplied From an OEM Dealer Only Recycled OEM LIFT GATE Liftgate Shell Spoiler Back Window (As Optioned) Hatch Props Latch Exterior Mouldings and Emblems Bolt-On Hinges Interior Trim Panel Rear Wiper (If Optioned) Attached Weather Strips Rear Finish Panel and Third Brake Lamp (If Applicable) 11 12
T RUCK C OLLISION P ARTS TRUCK CAB Cab Shell Consisting of Complete Cowl Section Windshield Posts Roof Assembly Rear Cab Panel Both Rockers and Floor Pan Door Assemblies Windshield Back Glass/Quarter Glass Heater/AC Housing Complete Interior Dash Assembly and Steering Column TRUCK BED/BOX FRAME Right and Left Frame Rails All Crossmembers Suspension Mounting Brackets Front and Rear Axle Assemblies Springs Unbolt Front Suspension LIFT OFF ASSEMBLY Bedsides Floor Pan Front Bed Panel Tailgate Both Tail Lamps Fuel Door(s) Rear Bumper Assembly Moulding and Emblems 13 14
D RIVE & SUSPENSION TRANSMISSION Transmission Case All Internally Lubricated Parts Extension and Tail Housings and Transmission Pan(s) AUTOMATICS INCLUDE: Torque Converters Mounts Flywheel Transmission Cooler IMPORTANT NOTE!!! All fluid, filters, and retention seals must be replaced and all transmission cooling lines must be flushed to assure warranty. ENGINE Engine Block All Internally Lubricated Parts Cylinder Head(s) Valve Cover(s) Oil Pan Intake Manifold and Timing Cover(s) Distributor Coil Pack(s) Exhaust Manifold(s) Throttle Body Starter Alternator A/C Compressor Engine Wiring Harness and Mounting Brackets TRANSFER CASE Casing and All Internally Lubricated Parts Extension and Tail Housings Input and Output Shafts Mounting Hardware Manual Shift Linkage Electric Shift Motors Front and Rear Drive Shaft IMPORTANT NOTE!!! Many items are left on engine assemblies free of charge for exchange convenience. When these items differ from the original, they must be replaced with the original. All fluid and filters must be changed and external oil coolers and lines must be flushed to assure warranty. IMPORTANT NOTE!!! All fluid and retention seals must be replaced to assure warranty. 15 16
D RIVE & SUSPENSION 4X4 FRONT AXLE ASSEMBLY FWD VEHICLES Differential housing, all internally lubricated parts, axle and axle tubes, spindle and knuckle assemblies, control arms, sway bar. Spring Assemblies Brake Caliper Other Brake Parts CARRIER TYPE Carrier case, all internally lubricated parts, CV or U-Joint type axle shafts, attached sway bars, steering knuckle, hub and bearing assemblies, control arms. Spring Assemblies Brake Caliper Other Brake Parts REAR AXLE ASSEMBLY REAR AXLE ASSEMBLY Differential housing, all internally lubricated parts, axle and axle tubes, attached sway bar(s), brake-backing plates. Spring Assemblies (Shock or Strut) Absorbers Brake Caliper Other Brake Parts FRONT KNEE ASSEMBLY FWD VEHICLES Strut Coil Spring Strut Mounting Steering Knuckle Hub and Bearing Assembly RWD VEHICLES Upper and Lower Control Arms Spindle Spindle Mounted Speed Sensors Wheel ENGINE CROSSMEMBER Same as Supplied from an OEM Dealer Only Recycled OEM Attachable Control Arms Sway Bar(s) Complete Knee Assemblies Strut Assembly Spindle Lower Control Arms Spindle Mounted Speed Sensors 17 18 Wheel
D RIVE & SUSPENSION REAR KNEE ASSEMBLY Strut Coil Spring Strut Mounting Spindle Hub and Bearing Assembly Control Arms Speed Sensors Wheel WHEEL Same as Supplied From an OEM Dealer Only Recycled OEM COMPLETE REAR SUSPENSION INDEPENDENT SUSPENSION TYPE Right and Left Rear Knee Assemblies and Crossmember (If Applicable) Speed Sensors Wheel WHEEL COVER Same as Supplied From an OEM Dealer Only Recycled OEM 19 20
Team PRP Regions Quality Parts Nationwide Locations of PRP Members REGIONS PAR (Preferred Auto Recyclers) AA-Row Auto Wrecking A-Partsmart Albuquerque Foreign Arizona Auto Parts Capo s Auto Parts, Inc. Central Foreign Crabtree Auto Company Fair Auto & Truck Parts G & R Auto Parts G & R Foreign Auto Parts Hanser s Automotive Kelty s Auto Parts Mazda-Toyota Auto Recycling New Way Auto Parts Precision Auto Parts Riteway Auto Parts Shaw Auto Parts Smith Auto Wrecking Stadium Auto Parts Stadium Foreign Auto Parts Absolute Premium Parts Albert Lea Auto Parts Bionic Auto Parts Denton Auto Salvage Grand Valley Auto Knox Auto Parts Midway Auto Parts Preferred Auto & Truck Premium Recycled Parts of Louisiana Weaver Automotive PST (Parts Store of Texas) American Auto Salvage Bingle Auto Parts Don s Auto Parts Hi-Way Auto Parts Johnny Franks Auto Parts RCS Auto Recyclers Snyder Salvage Williams Auto Salvage Mid Atlantic Northeast AACE Auto Salvage Action Auto Parts All Foreign Used Auto Parts Auto Parts of Shelby Bill s Used Parts, Inc. Bridgeville Auto Center Brooks Auto Sales Bruce Auto Parts Cosner Brothers Auto Parts Cunningham Brothers Auto Parts Eagle Auto Salvage, Inc. Foss Auto Parts & Salvage Foss Auto Salvage, Inc. Foss Auto Salvage of Jacksonville, Inc. Foss Auto Parts & Salvage, Inc. Greensboro Auto Parts Johnson Auto Recycling, Inc. Lacy Auto Parts M & M Auto Parts Old Dominion Auto Salvage Ripple's Service, Inc. Woodfin Honda A & P Auto Parts, Inc. Benwood Auto Parts Inc. C & H Salvage Corp. Chuck's Auto Salvage Don's Automotive Mall E L & M Auto Parts Eiss Brothers Auto Parts Jerry Brown's Used Auto Parts Leesville Auto Wreckers, Inc. Ocean County Auto Parts Tolpa's Auto Parts Wilbert's Inc. B=Burn D=Dent L=Lip H=Hail 000 = No Damage (all zero) C=Crease E=Bent K = Buckle J = Rip or Crack Damage Locations always follow the same pattern: Front to back, top to bottom, left to right (as seen from driver's seat), in an ìsî pattern, with locations for door handles and mirrors. Codes are location, damage, and hours. Example: ì2d1î is a one hour dent in location 2. There may be a primary and secondary code per part, as in ì2d1,4s2î. If there is no damage on a part the code is 000 (as three zeros). Zero as a location indicates the entire panel, as in 0H4 (all over hail damage, 4 hours).