G300G Industrial Gaseous Generator Set EPA Certified Stationary Emergency G300G 300k 1 of 5 Standby Power Rating 375kVA 300k 60 z Generator image used for illustration purposes only features benefits Generator Set = PROTOTYPE & TORSIONAY TESTED 4 PROVIDES A PROVEN UNIT = U2200 TESTED 4 ENSURES A QUAITY PRODUCT = RINOCOAT PAINT SYSTEM 4 IMPROVES RESISTANCE TO EEMENTS = IDE RANGE OF ENCOSURES 4 PROVIDES A SINGE SOURCE SOUTION Engine = EPA COMPIANT 4 ENVIRONMENTAY FRIENDY = INDUSTRIA TESTED, GENERAC APPROVED 4 ENSURES INDUSTRIA STANDARDS = POER-MATCED OUTPUT 4 ENGINEERED FOR PERFORMANCE = INDUSTRIA GRADE 4 IMPROVES ONGEVITY AND REIABIITY Alternator = TO-TIRDS PITC 4 EIMINATES ARMFU 3RD ARMONIC = AYER OUND ROTOR & STATOR 4 IMPROVES COOING = CASS MATERIAS 4 EAT TOERANT DESIGN = DIGITA 3-PASE VOTAGE CONTRO 4 FAST AND ACCURATE RESPONSE Controls = ENCAPSUATED BOARD / SEAED ARNESS 4 EASY, AFFORDABE REPACEMENT = 4-20mA VOTAGE-TO-CURRENT SENSORS 4 NOISE RESISTANT 24/7 MONITORING = SURFACE-MOUNT TECNOOGY 4 PROVIDES VIBRATION RESISTANCE = ADVANCED DIAGNOSTICS & COMMUNICATIONS 4 ARDENED REIABIITY primary codes and standards
G300G 300k 2 of 5 G300G ENGINE SPECIFICATIONS application and engineering data General Cooling System Make Generac Cooling System Type Pressurized, Closed Recovery EPA Emissions Compliance Stationary Emergency ater Pump Flow 54 gal/min EPA Emissions Reference See Emissions Data Sheet Fan Type Puller Cylinder # 6 Fan Speed (rpm) 1632 Type Inline Fan Diameter mm (in.) 990 (39) Displacement - 13.3 Coolant eater attage 2000 Bore - mm (in.) 136.91 (5.39) Coolant eater Standard Voltage 240VAC Stroke - mm (in.) 150.11 (5.91) Compression Ratio 10.5:1 Fuel System Intake Air Method Turbocharged/Aftercooled Fuel Type Natural Gas Number of Main Bearings 7 Carburetor Down Draft Connecting Rods Carbon Steel Secondary Fuel Regulator Standard Cylinder ead Cast Iron, Overhead Valve Fuel Shut Off Solenoid Standard Cylinder iners et, Replaceable Operating Fuel Pressure 11" - 15" 2 O Ignition Altronic CD1 Pistons eat Resistant Alloy Engine Electrical System Crankshaft Die-Forged Carbon Steel System Voltage 24VDC ifter Type Solid Battery Charging Alternator Std Intake Valve Material Special eat-resistant Steel Battery Size (at 0ºC) 1155 CCA Exhaust Valve Material Iconel Alloy, igh Temp Battery Group 8D ardened Valve Seats igh Temp Alloy Stellite Faced Battery Voltage (2) 12VDC Ground Polarity Negative ubrication System Oil Pump Type Gear Oil Filter Type Full-Flow, Cartridge Crankcase Capacity - (qts) 27 (28.5) ATERNATOR SPECIFICATIONS Standard Model 520mm Voltage Regulator Type Full Digital Poles 4 Number of Sensed Phases 3 Field Type Revolving Regulation Accuracy (Steady State) ± 0.25% Insulation Class - Rotor Insulation Class - Stator Engine Governing Total armonic Distortion < 5% Governor Electronic Telephone Interference Factor (TIF) < 50 Frequency Regulation (Steady State) ± 0.25% Standard Excitation Permanent Magnent Bearings Sealed Ball Coupling Gear Drive oad Capacity - Standby 100% Prototype Short Circuit Test Yes CODES AND STANDARDS COMPIANCE (ERE APPICABE) NFPA 99 BS5514 NFPA 110 SAE J1349 ISO 8528-5 DIN6271 ISO 1708A.5 IEEE C62.41 TESTING ISO 3046 NEMA ICS 1 Rating Definitions: Standby Applicable for a varying emergency load for the duration of a utility power outage with no overload capability. (Max. load factor = 70%) Prime Applicable for supplying power to a varying load in lieu of utility for an unlimited amount of running time. (Max. load factor = 80%) A 10% overload capacity is available for 1 out of every 12 hours.
G300G operating data (60z) POER RATINGS (k) Natural Gas Three-Phase 120/208VAC @0.8pf 300 k Amps: 1041 Three-Phase 120/240VAC @0.8pf 300 k Amps: 902 Three-Phase 277/480VAC @0.8pf 300 k Amps: 451 Three-Phase 346/600VAC @0.8pf 300 k Amps: 361 G300G 300k 3 of 5 STARTING CAPABIITIES (skva) skva vs. Voltage Dip 480VAC 208/240VAC Alternator k 10% 15% 20% 25% 30% 35% 10% 15% 20% 25% 30% 35% Standard 300 303 454 605 757 908 1059 227 341 454 568 681 794 Upsize 1 FUE Fuel Consumption Rates* Natural Gas Percent oad ft 3 /hr m 3 /hr 25% 1671 47.3 50% 2162 61.2 75% 3048 86.3 100% 3939 111.5 * Refer to "Emissions Data Sheet" for maximum fuel flow for EPA and SCAQMD permitting purposes. COOING Air Flow (inlet air combustion and radiator) ft 3 /min (m 3 /min) 20,400 (577.7) System Coolant Capacity Gal (iters) 15 (56.8) eat Rejection to Coolant BTU/hr 1,024,140 Max. Operating Air Temp on Radiator ºF (ºC) 122 (50) Max. Ambient Temperature ºF (ºC) 104 (40) Maximum Radiator Backpressure " 2 O 1.50 COMBUSTION AIR REQUIREMENTS Flow at Rated Power cfm 1200 ENGINE Rated Engine Speed rpm 2300 orsepower at Rated k** hp 454 Piston Speed ft/min 2262 BMEP psi 203.5 ** Refer to Emissions Data Sheet for maximum bp for EPA and SCAQMD permitting purposes. EXAUST Exhaust Flow (Rated Output) cfm (m 3 /min) 4335 (122.8) Max. Backpressure (Post Silencer) ing 1.5 Exhaust Temp (Rated Output) ºF (ºC) 1490 (810) Exhaust Outlet Size (Open Set) in 5.0" Deration Operational characteristics consider maximum ambient conditions. Derate factors may apply under atypical site conditions. All performance ratings in accordance with ISO3046, BS5514, ISO8528 and DIN6271 standards.
G300G 300k 4 of 5 G300G GENERATOR SET Genset Vibration Isolation Std IBC Seismic Certified/Seismic Rated Vibration Isolators Opt Steel Enclosure Opt Aluminum Enclosure Opt Enclosure ighting Kits Opt ENGINE SYSTEM General Oil Drain Extension Std Oil eater Opt Critical Exhaust Silencer (Enclosed Sets) Opt Stainless steel flexible exhaust connection Std Air cleaner Std Fan guard Std Radiator duct adapter Std Fuel System Fuel lockoff solenoid Std Secondary Fuel Regulator Std Flexible fuel lines Opt Automatic Gaseous Dual Fuel Opt Cooling System 120VAC Coolant eater Opt 208VAC Coolant eater Opt 240VAC Coolant eater Opt Std Other Coolant eater Opt Closed Coolant Recovery System Std UV/Ozone resistant hoses Std Factory-Installed Radiator Std Radiator Drain Extension Std Engine Electrical System Battery charging alternator Std Battery cables Std Battery tray Std Battery box Opt Battery heater Opt Solenoid activated starter motor Std 2.5A U battery charger Opt 10A U float/equalize battery charger Opt Rubber-booted engine electrical connections Std ATERNATOR SYSTEM U2200 GENprotect Std Main ine Circuit Breaker Opt 2nd Circuit Breaker Opt 3rd Circuit Breaker Opt Alternator Upsizing Opt Anti-Condensation eater Opt Tropical coating Opt Permanent Magnet Generator Std CONTRO SYSTEM standard features and options Control Panel Digital -Panel Controller Std Programmable Crank imiter Std Programmable Crank imiter Std 21-ight Remote Annunciator Opt Remote Relay Panel (8 or 16) Opt 7-Day Programmable Exerciser Std Special Applications Programmable PC Std RS-485 Communications Std All-Phase Sensing DVR Std Full System Status Std 2-ire Start Compatible Std Power Output (k) Std Power Factor Std Reactive Power Std All phase AC Voltage Std All phase Currents Std Oil Pressure Std Coolant Temperature Std Coolant evel Std Oil Temperature Opt ow Fuel Pressure Std Engine Speed Std Battery Voltage Std Frequency Std Date/Time Fault istory (Event og) Std ow-speed Exercise -Opt Isochronous Governor Control Std -40deg C - 70deg C Operation Std aterproof Plug-In Connectors Std Audible Alarms and Shutdowns Std Not in Auto (Flashing ight) Std Auto/Off/Manual Switch Std E-Stop (Red Mushroom-Type) Std Remote E-Stop (Break Glass-Type, Surface Mount) Opt Remote E-Stop (Red Mushroom-Type, Surface Mount) Opt Remote E-Stop (Red Mushroom-Type, Flush Mount) Opt NFPA 110 evel I and II (Programmable) Std Remote Communication - RS232 Std Remote Communication - Modem -Opt Remote Communication - Ethernet -Opt 10A Run Relay -Opt Alarms (Programmable Tolerances, Pre-Alarms and Shutdowns) ow Fuel Oil Pressure (Pre-programmed ow Pressure Shutdown) Std Coolant Temperature (Pre-programmed igh Temp Shutdown) Std Coolant evel (Pre-programmed ow evel Shutdown) Std Oil Temperature Opt Engine Speed (Pre-programmed Overspeed Shutdown) Std Voltage (Pre-programmed Overvoltage Shutdown) Std Battery Voltage Std
G300G dimensions, weights and sound levels G300G 300k OPEN SET T dba* 145 58 69 7278 91 5 of 5 STANDARD ENCOSURE T dba* 175 58 78 8578 89 EVE 1 ACOUSTIC ENCOSURE T dba* 200 58 77 8770 82 EVE 2 ACOUSTIC ENCOSURE T dba* 181 58 107 9728 76 *All measurements are approximate and for estimation purposes only. Sound levels measured at 23ft (7m) and does not account for ambient site conditions. Specification characteristics may change without notice. Dimensions and weights are for preliminary purposes only. Please consult a Cat Dealer for detailed installation drawings. Information contained in this publication may be considered confidential. Discretion is recommended when distributing. Materials and specifications are subject to change without notice. CAT, CATERPIAR, their respective logos, OYMPIAN, Caterpillar Yellow, the Power Edge trade dress as well as corporate and product identity used herein, are trademarks of Caterpillar and may not be used without permission. www.olympianpower.com 2012 Caterpillar All rights reserved. Printed in U.S.A.