Parts Catalog Marine Generator Set MDKBT (Spec A) MDKBU (Spec A) English 00 0 (Issue )
To avoid errors or delay in filling your parts order, always give the MODEL, SPEC NO. and SERIAL NO. from the Onan nameplate. For handy reference, insert your nameplate information in the spaces below. MODEL AND SPEC NO. SERIAL NO. DIGITAL CONTROL SOFTWARE VERSION AND DATE (IF APPLICABLE) The following symbols are used in Onan manuals to alert users to the potentially dangerous conditions relating to maintenance of equipment and replacement of parts. Please read and observe. This symbol warns of immediate hazards which will result in severe personal injury or death. This symbol refers to a hazard or unsafe practice which can result in severe personal injury or death. This symbol refers to a hazard or unsafe practice which can result in severe personal injury or product or property damage. Service and repair of Onan equipment must be performed by trained, experienced personnel only. Improper service or repair may result in property damage, severe personal injury or death. Do not use this catalog as a guide to servicing your equipment. Read and follow the IMPORTANT SAFETY IN- STRUCTIONS in the Service Manual appropriate for the equipment you are working on. Contact with USED ENGINE OILS has been identified by a United States federal agency and some USA state agencies as causing CANCER or REPRODUCTIVE TOXICITY. When checking or changing engine oils take all necessary precautions not to ingest, breathe the fumes or contact the used oil. Contact with ASBESTOS has been identified by a United States federal agency and some USA state agencies as causing CANCER or REPRODUCTIVE TOXICITY. When handling engine gaskets take all necessary precautions not to ingest, breathe or contact the dust from the gaskets! Use adequate ventilation and wear protective gloves, masks and clothing! Contact with BENZINE and LEAD, found in gasoline, fuel additives and solvents has been identified by a United States federal agency and some USA state agencies as causing CANCER or REPRODUC- TIVE TOXICITY. When checking, draining or adding gasoline and fuel additives or using solvents take all necessary precautions not to ingest, breathe the fumes or contact the liquids. Use adequate ventilation and wear protective gloves, masks and protective clothing! Servicing and replacement of MARINE CRITICAL PARTS must be carried out by persons trained and experienced with marine gasoline engine generator safety requirements! PSP-
Introduction This catalog applies to the standard marine generator sets listed below. Parts are arranged in groups of related items and each illustrated part is identified by a reference number corresponding to the same reference number in the parts list. Parts illustrations are typical. Unless otherwise mentioned in the description or page heading, parts are interchangeable between models. Throughout this catalog left and right sides are determined by facing the engine end (front) of the set. MODEL HERTZ MDKBT/* 0/0 MDKBU/* 0/0 * The diagonal line (/) in the model and specification number separates generator set characteristics from the specification number and letter. The specification number denotes customer requested options or deviations from the standard model. The specification letter advances (A to B, B to C, etc.) with major manufacturing changes. WIRING DIAGRAM 0 DC
Index Actuator, 0 Actuator, Electronic Governor, 0 Adapter, Coupling, 0 Adapter, Pipe, 0 Alternator, Alternator ( Neg Gnd), Alternator (ISO Ground), Alternator (Isolated Ground), Alternator, ISO Ground, Assy,Cylinder Head, Assy Bracket, Front, Assy Bracket, Rear, Assy Cover, Bearing Case, Assy Fork, Lever, Assy Holder, Nozzle,, Assy Lever, Engine Stop, Assy Lever, Governor, Assy Manifold, Intake, Assy Pipe, Over Flow, Assy Plug, Oil Filler, Assy Rectifier, Assy Rocker Arm Internal, 0 Assy Rocker Arm, Exhaust, 0 Assy Rotor, Assy Rotor, Oil Pump, Assy Shaft, Balancer, Assy. Arm, Valve, 0 Assy. Shaft, Rocker Arm, 0 Assy., Starter, Assy, Blank Panel, Assy, Connecting Rod, Assy, Control (esdd), Assy, Drip Pan, Assy, Engine Mount, Assy, Engine Panel,, 0 Assy, Flywheel, Assy, Generator Rotor, Assy, NIM PCB, Assy, Rocker Arm, 0 Assy, Water Separator Drain, Assy, Water Separator Pump, Assy, Water Separator Replacement Head, Balancer, Base, Injection Pump, Base, Mounting, Belt Guard, Block, Cylinder, Bolt, Flange, Bolt, Flywheel, Bolts, Mechanical Governor Adjusting, Box, Control, Bracket, Air Silencer, 0 Bracket, Alternator, Bracket, Clutch, 0 Bracket, Engine (Lifting), Bracket, Fan Guard,, Bracket, Fuel Pump, Bracket, Heat Exchanger, Bracket, Isolated Ground, Bracket, Mounting Pad, 0 Bracket, Oil Drain, Bracket, PTO (Left), 0 Bracket, PTO (Right), 0 Bracket, Remote Separator Mounting, Bracket, Rocker Arm, 0 Breaker, Circuit ( Amp), 0 Breaker, Circuit (0 Amp), 0 Bulkhead, Connector, Bush, Idle Gear, Bushing (Nylon), 0 Bushing, Connecting Rod, Camshaft, Camshaft, Fuel, Cap, Coolant Recovery Tank, Cap, Cylinder Block Sealing, Cap, Radiator, Cap, Valve, 0 Catch, Door, Circuit, Breaker, Circular Clip, External, 0 Clamp, Hose, 0 Clamp, Pipe, Clutch, 0 Collar, Idle Gear, Collet, Valve Spring, 0 Comp. Flange, Water, Comp. Gear, Idle, Comp., Valve Breather, Comp, Oil Pan, Components, Alternator, Components, Control Panel (Breaker Switch), 0 Components, Control Panel (NIM), Components, Starter, Components, Water Pump,
Index Components, Water Separator, Connector, Hose, Connector, Hose (Rear), Control Harness, Control, Box, Cooler, Oil, Cooling, Keel, Cord, Glow Plug, Coupling, Flexible, 0 Cover, Cover, Access, Cover, Access (Housed Only),, 0 Cover, Bearing Case, Cover, Box, Cover, Breather, Cover, Cylinder Head, Cover, Enclosure (Rear), Cover, Flywheel, Cover, Flywheel Housing, Cover, Fuel Camshaft, Cover, Gear Case, Cover, Governor Rod, Cover, Hydraulic Pump, Cover, Injection Pump, Cover, Oil Pump, Cover, Thermostat, Gasket, Exhaust Manifold, Gasket, Governor Housing, Gasket, Head Cover, Gasket, Injection Pump, Gasket, Injection Pump Base, Gasket, Injection Pump Cover, Gasket, Shaft Cover, Gasket, Water Pump, Gauge, Oil, Gear, Camshaft, Gear, Crankshaft, Gear, Injection Pump, Gear, Ring, Gearcase Assy, Generator, Governor, Mechanical, Ground, Isolated, Guard, Belt, Guard, Belt W/O PTO, Guard, Coupling, Guard, Coupling (PTO), Guard, PTO (Front), Guide, Card, Guide, Exhaust Valve, 0 Guide, Inlet Valve, 0 Guide, Oil Gauge, Door, Drive, Auxiliary (Sea Water Pump), Elbow, Exhaust (Wet), Elbow, Street Pipe, Element, Breather, Element, Water Separator, Endbell, Engine, Replacement, Exchanger, Heat, Exhaust, Bulkhead, Filter, Fuel,, Filter, Oil, Flange, Water Outlet, Flywheel, Gasket,,, Gasket, Crankcase, Gasket, Cylinder Head, Gasket, Enclosure, Hanger, Coolant Recovery Tank, Harness, Accessory, Harness, Battery,, 0 Harness, Battery (Front Bulkhead), Harness, Battery (Rear Bulkhead), 0 Harness, Control, Harness, Ground, Harness, Junction, Harness, Remote Control Panel, Harness, Remote Extension, Harnesses, Head, Cylinder, Holder, Nozzle, Hose, Fuel,, 0 Hose, Intake, 0 Housing Assy, Injection Pump, Housing, Flywheel, Housing, Generator, Housing, Governor, Housing, Injection Pump, Housing, Main Bearing,
Index Impeller, Water Pump, Injection, Fuel, Instalation Roof (End), Insulation, Cover, Insulation, Duct,, Insulation, Panel, Insulation, Roof, Insulation, Sound,, Intake, 0 Isolation, Vibration, Isolator, Mounting, Joint, Breaher, Joint, Breather Pip, Joint, Breather Pipe, Joint, Water Pipe, Kit Holder, Nozzle, Kit, Adapter Fuel (/ ID Hose), Kit, Control Panel, Kit, Coolant Recovery, Kit, Cruise, Kit, Exhaust (Adapter w/ Elbow), Kit, Exhaust (Adapter,No Elbow), Kit, Exhaust (Water Seperator), Kit, Exhaust (Wet, Front Out), Kit, Exhaust (Wet, Rear Out), Kit, Fitting Adapter, Kit, Fuel Adapter, Kit, Fuel Filter, Kit, Generator Heater, Kit, Holder Nozzle, Kit, Hose (Raw Water Front), Kit, Hose (Raw Water Rear), Kit, Impeller Service, Kit, Muffler/Water Separator, Kit, PCB (J No Cover), Kit, PCB (SmartCraft No Cover), Kit, PTO, 0 Kit, Pump Repair, Kit, Remote Control Panel, Kit, Remote Control Panel Switch Harness, Kit, Remote Fuel/Water Separator, Kit, Siphon Break, Kit, Sound Shield (Full), Kit, Sound Shield (PTO), Kit, Terminal Boot, Kit, Water Separator Metal Bowl Replacement, Kit, Water Separator O Ring, Kits, Label, Control, 0 Labels, Latch, Door, Lever, Engine Stop, Lever, Speed Control, Lever, Stop, Lever,Mechanical Governor Fork, Lines, Fuel Transfer (Front), Lines, Fuel Transfer (Rear), 0 Manifold Assy. (Exhaust), Manifold, Exhaust, Manifold, Intake, Meter, Hour, 0 Mounting, Governor, Muffler, Pan, Oil, Panel, Access,, Panel, Air Baffle, Panel, Control, 0 Panel, Control(Gnd), 0 Panel, Duct,, Panel, Enclosure,, Panel, Enclosure (Front), Panel, Housing, Panel, Remote Control,, Panel, Roof, Panel, Roof (End), PCB Assy, Control, Pickup, Oil, Piece, Nozzle, Pin, Cylinder Block Straight, Pin, Piston, Pin, Spring, 0 Pipe, Injection, Pipe, Water Return, Piston, Plug, Cylinder Block, Plug, Hole, Plug, Oil Filler, Plug, Water Outlet Flange, Plug, Water Separator, PTO, 0 PTO Belt Guard,
Index Pulley, Alternator, Pump Assy., Water, Pump, Comp. Base Hydraulic, Pump, Electric Fuel, Pump, Injection, Pump, Injection, Pump, Sea Water, Relay, Isolated Ground Solenoid, Relay, SPDT (V), Relay, SPDT (V), Resonator, Air Intake, 0 Retainer, Spring, 0 Retainer, Valve Spring, 0 Ring, Retaining, Rivet, Drive Plastic, Rod, Push, Rotor, Exciter, Screw, Adjusting, 0 Seal, Heat, Seal, Oil, Seal, Shaft, Seal, Valve Stem, 0 Seal, Weather, Separator, Fuel/Water, Separator, Remote Fuel/Water, Separator, Remote Fuel/Water Separator, Separator, Water, Set, Regulator, Set, Ring, Shaft, Fork Lever, Shaft, Idle Gear, Shaft, Valve, 0 Shield, Breather, Shield, Engine Panel Sound, Shield, Panel Engine Sound (Front and Rear), Shield, Panel Engine Sound (Front w/pto), Shield, Sound, Shim, Injection Pump Mounting, Siphon, Break, Slinger, Water Pump, Socket, Relay, Spacer, Alternator, Spacer, Guard,, Spacer, Water Pump, Spring, 0 Spring, Governor, Spring, Nozzle, Spring, Return, Spring, Stop Lever, Spring, Valve, 0 Spring, Valve Seat, Standoff, Insulation, Starter, Starter Assy, Stator, Generator, Stopper, Camshaft, Stopper, Fuel Camshaft, Strap, Bond, Supply, Fuel, Switch, Pressure,, Switch, Remote Control Panel Rocker (S), Switch, Rocker, SPDT, 0 Switch, Temperature (Wet), Tank, Coolant Recovery, Tappet, Tube, Breather, Valve, Check, Valve, Exhaust, 0 Valve, Inlet, 0 Valve, Relief, Water Inlet, Weight, Governor,
Cylinder Block 0 0 0 Engine, Replacement 00 0 V 00 0 V 0 Block Assy, Cylinder (Includes Parts Marked #) #Plug 0 #Plug #Plug #Cap, Sealing 0 #Cap, Sealing #Cap, Sealing 00 #Plug, Expansion #Pin, Straight 0 #Pin, Straight #Pin, Pipe #Pin, Gear Case 00 0 0 #Bolt, Bearing Case 0 #Cap, Sealing Plug Gasket 0 0 Joint, Water Pipe 0 00 Valve, Ball 0 0 Crankcase 0 00 Bolt, Flange Pin, Gear Case Nut, Flanged Cover 0 Gasket, Fuel Pump 0 Plug # Parts included in Cylinder Block Assy. * Parts Included in Keel Cooling Kit Listed on Keel Cooling Dry Exhaust Page.
Cylinder Head 0 0 #Stud 0 Assy,Cylinder Head (Includes Parts Marked #) #Cap, Sealing #Cap, Sealing #Plug #Plug Gasket, Cylinder Head 0 0.0mm 0.00mm 0.0mm 0 Plug 00 0 Bolt, Cylinder Head 0 0 #Head, Cylinder * Parts Included in Cylinder Head Assy.
Piston 0 Piston 0 Standard 00 0. mm Oversize Set, Ring 0 Standard 0 0. mm Oversize 0 Pin, Piston 0 Circle Clip, Internal 0 Rod Assy, Connecting (Includes Bushing, Bearing and Bolts) 0 0 Bushing 00 0 Bolt, Connecting Rod Bushing 0 Standard 0 0.0 mm Oversize 0 0.0 mm Oversize 0 Standard 0 0 Comp., Crankshaft 0 0 0 Sleeve, Crankshaft 0 00 Gear, Crankshaft Key, Feather 0 000 Gear, Oil Pump Drive Bushing, Crankshaft 0 0 Standard 0 0 0.0 mm Oversize 0 0 0.0 mm Oversize Bushing 0 0 Standard 0 00 0.0 mm Oversize 0 0 0.0 mm Oversize Bushing 0 0 Standard 0 0 0.0 mm Oversize 0 0 0.0 mm Oversize
Camshaft 0 0 00 Tappet 0 Rod, Push 0 0 Camshaft Assy (Includes Parts Marked *) 0 0 *Ball 0 00 *Gear, Camshaft *Key, Feather 0 *Stopper, Camshaft *Bolt, Flange 0 *Shaft, Idle Gear 0 Pin, Gear Idle 0 0 Collar, Idle Gear 0 Collar, Idle Gear 00 Bolt, Flange 0 00 Comp. Gear, Idle 0 0 Bush, Idle Gear 0 00 Comp. Gear, Idle 0 0 Bush, Idle Gear * Parts Included in Camshaft Assy
Rocker Arm 0 0 0 0 0 0 0 0 0 0 Guide, Inlet Valve Guide, Exhaust Valve 0 Valve, Inlet 0 Valve, Exhaust 0 Spring, Valve 0 Spring, Valve 0 Retainer, Spring 0 Retainer, Valve Spring 0 Collet, Valve Spring 0 0 Collet, Valve Spring 00 Seal, Valve Stem 0 Seal, Valve Stem 0 Shaft, Valve 0 Assy. Shaft, Rocker Arm 0 0 Screw, Set 0 Bracket, Rocker Arm Pin, Spring Washer 0 Circular Clip, External 0 0 00 Spring 00 Assy Rocker Arm Internal 0 Screw, Adjusting 00 Nut 0 Assy Rocker Arm, Exhaust 00 0 Bolt, Flange 0 Assy. Arm, Valve 00 Screw, Adjustment Nut 00 Pad 0 0 Cap, Valve 0
Balancer 0 00 Assy Shaft, Balancer Ball 0 Key, Feather 0 0 Assy Shaft, Balancer 0 Key, Feather Bolt, Flanged 0 0 Metal, Balancer 0 0 Metal, Balancer
Flywheel 0 0 0 Flywheel Assy (Includes Ring Gear) 0 00 Gear, Ring 00 Bolt, Flywheel 0 0 0 Bracket, Engine (Lifting) 0 0 Housing, Flywheel 0 0 Cover, Flywheel 00 0 Bolt, Flange 0 0 Cover, Flywheel Housing 00 Bolt, Flange 0 0 Washer, Flat (M) 00 Screw, Hex Head (M x. x 0mm) * Engine Bracket Mounted with embossed M faces flywheel.
Starter Starter Assy V V 00 Bolt, Flange 0 Stud 0 0 Nut, Flanged
Starter Components (V and V) A B A 0 0 0 B Assy., Starter V V Bracket Assy., Front V V 0 0 Set, Bearing Shaft Assy., Clutch 0 V V Shaft Assy., Gear Set, Washer Set, Internal Gear 0 00 V 0 00 V 0 0 Clutch, Over Running 0 00 Assy. Gear 0 Assy Lever, Set Set, Pinion 00 Set, Stopper Switch Assy., Magnetic 0 V 0 V 0 0 Set, Screw Ball Packing, Set Assy. Armature V V 0 0 Bearing Assy Yoke V V 0 Holder Assy., Brush V V 0 00 Brush, Spring Brush V 0 V Bracket Assy., Rear 00 Set, Bolt
Main Bearing Housing 0 0 Assy Cover, Bearing Case 0 00 Seal, Oil 00 Bolt, Flange 0 0 Cover, Bearing Case
Oil Gauge Gauge, Oil Guide, Oil Gauge 0 O Ring Guide, Oil Gauge 0 Plug, Oil Gauge
Oil Cooler 0 Plug Assy., Oil Filler (Includes Parts Marked #) #Plug, Oil Filler 0 0 #O Ring 0 Cooler Assy., Oil (Includes Housing and Gasket) 0 0 Gasket, Oil Cooler 00 Joint 0 0 Pipe, Oil Cooler Clamp, Hose 0 Pipe, Oil Cooler 0 0 0 Pipe, Oil Cooler Clamp, Hose 0 0 Pipe, Oil Cooler Clamp, Hose Bolt, Flange 00 Filter, Oil # Parts included in Plug Assy.
Oil Pan 0 0 Comp, Oil Pan 0 Plug 00 0 Bolt, Oil Pan 00 Bolt, Flange 0 Pickup, Oil 0 0 O Ring Bolt 0 00 Hose Assy 0 Cap, Pipe 0 0 0 Bracket, Oil Drain
Governor Mounting 0 0 Joint, Union Assy Pipe I P Oil 0 0 Bolt, Eye Joint 0 0 Gasket 0 Bracket, Pump Bolt, Flange Nut, Flange
Electronic Governor Actuator Actuator 0 0 V 0 0 V 0 Bolt, Hex Socket Head (M x x 0mm) 0 Gasket 00 Washer,Flat (/ ) 0
Mechanical Governor 0 0 0 Cover, Governor Rod 0 0 Weight, Governor 0 0 Nut, Flange 0 0 Sleeve, Governor 0 0 Housing, Governor 0 0 Assy Lever, Governor 00 O Ring 0 Lever, Stop 0 Circular Clip, Ex 0 0 Washer, Rocker Arm Shaft 0 0 Assy Lever, Engine Stop 00 O Ring 0 00 Spring, Return 0 0 Lever, Engine Stop 0 Pin, Spring Pin, Start Spring Pin, Straight 0 00 Spring 0 Lever, Speed Control
Mechanical Governor Fork Lever 0 0 00 Assy Fork, Lever (Includes Parts Marked*) *Washer, Plain 0 *Circular Clip Ex *Circular Clip Ex 00 *Circular Clip Ex 0 0 Shaft, Fork Lever 0 00 Spring, Governor 0 00 Spring, Start 0 00 Spring, Stop Lever 0 Stud 0 0 Gasket, Governor Housing 00 0 Bolt, Flange 0 0 Nut, Lock 0 Bolt 0 Nut * All parts marked included in Assembly.
Mechanical Governor Adjusting Bolt 0 0 0 Bolt Adjusting Nut, Locking 0 0 Bolt, Adjusting Nut 0 0 Bolt, Adjusting Nut, Locking 0 0 Nut Gasket 00 0 Bolt Assy, Adjustment 0 0 Nut Gasket 0 0 Nut Gasket Nut Gasket 0 Cap Cap
Injection Pump 00 Pump, Injection 00 Shim 00 0 Bolt, Flange Bolt 0 Joint, Eye 0 Pipe, Adapter 0 0 Screw, Hollow Gasket
Fuel Injection 0 0 0 0 Assy Pipe, Over Flow 00 Kit, Holder Nozzle 00 Assy Holder, Nozzle Gasket Seal, Heat 0 0 Pipe, Injection 0 0 Pipe, Injection 0 0 Pipe, Injection 0 0 Pipe, Injection 0 Clamp, Pipe Clamp, Pipe Screw, with Washer Plug, Glow 0 V 0 V Cord, Glow Plug Nut, Flange
Nozzle Holder 0 00 Kit Holder, Nozzle (Includes Assembly, Gasket and Heat Seal) 00 Assy Holder, Nozzle Nut Washer, Adjusting 0 00 Spring, Nozzle Piece, Distance Push, Rod Nut, Nozzle Washer 0 Piece, Nozzle 0 Assy Washer, Adjust Washer, Adjusting 0.00mm 0.mm 0.0mm 0.mm.000mm.0mm 0.00mm.0mm.00mm.mm.0mm.mm.00mm.mm.0mm.mm 0.00mm.mm.0mm.mm.00mm.mm.0mm.mm.00mm.mm 0.0mm.mm.00mm.mm.0mm.mm.00mm.mm.0mm.mm 00.00mm 0.mm 0.0mm 0.mm 0.00mm 0.mm 0.0mm Gasket Seal, Heat
Injection Pump Housing 0 0 0 0 Base, Injection Pump 0 Stud 0 0 Gasket, Injection Pump Base 0 Pin, Straight Bolt, Flanged 00 0 Bolt, Flanged 00 Bolt, Flanged 00 0 Bolt, Flanged 0 0 Cover, Injection Pump 0 0 0 Gasket, Injection Pump Cover 0 Housing Assy, Injection Pump (Includes Part Marked *) *Stud 0 *Stud 0 *Pin, Straight 00 *Plug, Injection Pump Housing *Pin, Straight 0 0 Camshaft, Fuel 0 00 Bearing, Ball 0 Bearing, Ball 0 0 Circular Clip, External Key, Woodruff 0 0 Stopper, Fuel Camshaft Screw, Counter Sunk Cover, Fuel Camshaft 0 Gasket, Shaft Cover 0 Bolt 00 Gasket, Injection Pump 0 00 Gear, Injection Pump 0 0 Nut, UBS 0 Nut, Flanged Bolt, Flanged Gasket * All Parts Included in Injection Pump Housing Assembly.
Gearcase 0 0 0 0 0 0 Assy Case, Gear 0 00 Spring 0 00 *Valve, Relief *Gasket 0 *Plug 0 *Assy Rotor, Oil Pump 0 *Cover, Oil Pump *Screw, Countersunk 0 0 *Plug 0 0 Plug 0 0 Seal, Oil 0 0 O Ring 0 0 O Ring 0 0 Gasket, Crankcase Plate, Gear Case 00 Bolt, Flange 00 Bolt, Flange Cover, Gear Case Sender, Oil Pressure 0 Neg Gnd 00 0 ISO Gnd 0 0 00 0 Bushing, Reducer * Parts Included in Gearcase Assy
Cylinder Head Cover 0 0 Cover, Cylinder Head Element, Breather Shield, Breather Plate, Breather Element Plate, Breather Element 0 Screw, Pan Head Joint, Breather Pipe 0 Gasket, Head Cover Comp., Valve Breather 0 Cover, Breather Screw, Pan Head 00 Cap, Sealing Assy Plug, Oil Filler Plug, Oil Filler 0 0 O Ring 00 0 0 Bolt Tube, Breather 0 0 Band, Pipe
Intake 0 0 0 Hose, Intake 0 Resonator, Air Intake 0 Clamp, Hose 0 Clamp, Hose 0 0 Hose, Intake 0 Bushing (Nylon) 0 Clamp, Hose 0 0 0 Bracket, Air Silencer 00 00 0 Screw, Hex Head Cap (/ NC x.mm) 0 Washer, Flat (M) 0 MDKBT and MDKBU 0 MDKBT and MDKBU W/PTO 0 Washer, Flat DAC 00 0 Screw, Hex Head Cap (M x. x mm) 00 0 Screw, Hex Head SEMS (M x.0 x mm) 00 Clamp, Loop (/ ) 00 0 0 Screw, Hex Head Cap (M x. x 0mm) 0 Clamp, Hose 0
Intake Manifold Assy Manifold, Intake Joint, Breather Gasket 00 Bolt, Flange 00 Bolt, Flange 0 Clamp, Cord
Water Outlet Flange 0 0 0 0 Pipe, Water Return Clamp, Hose 0 Cover, Thermostat 0 Gasket 00 Bolt, Flange 0 Comp. Flange, Water 0 0 Joint, Water Pipe 0 Plug Plug 0 Plug 0 Plug 0 Plug, Drain Gasket 0 Bolt, Flange 00 0 Bolt, Flange 0 Gasket, Water Flange 0 Assy Thermostat
Water Pump Components 0 Pump Assy., Water (Includes Cover, Seal and Impeller) 0 Gasket, Water Pump 0 Support Assy., Water Pump (Includes Parts Marked*) 0 0 *Joint, Water Pipe *Joint, Breather Pipe *Plug 0 0 *O Ring 00 Bolt, Flange 00 Bolt, Flange
Alternator 0 Alternator, Complete 0 V V Bracket, Alternator Washer, Plain 00 0 Bolt, Flange 00 Bolt, Flange 0 0 Nut, Flange 0 Pulley, Fan Drive 00 0 Bolt 0 Belt, V 0 0 Pulley, Fan Bolt, Flange
Alternator Components 0 Alternator, Complete (No Components Available) 0 V V 0 0 Nut 00 Set, Bolt Assy Bracket, Front 0 V 0 V 00 Set, Bolt 0 0 Bearing Assy Rotor 0 V 0 V 0 0 Bearing Assy Stator V V 0 Assy Bracket, Rear V V Assy Rectifier 0 V 0 V 0 0 Set, Nut Set, Regulator 0 00 V 0 0 V Set, Brush 0 Assy Pulley
Alternator (ISO Ground) 0 0 0 Spacer, Alternator 0 0 Bracket, Alternator Alternator, ISO Ground 0 V ISO Ground 0 V ISO Ground Spacer, Alternator 0 Pulley, Alternator 00 Washer, (/0 ) 0 00 Washer Split Locking (/ ) 00 00 Screw, Hex Head Cap (/ x.mm) 0 Washer, Flat (/ ) 0 00 0 Screw, Hex Head Cap (M0 x. x mm) 0 Belt, V
Fuel Filter 0 0 0 0 Joint, Pipe Gasket Assy Filter, Fuel (Includes Parts Marked*) *Cover 0 0 *Bolt, Joint 0 *Connector 0 *Connector 0 *Element, Fuel Filter 0 0 *Gasket 0 0 0 *Gasket 00 Bolt, Flanged 0 Joint, Eye 0 0 Bolt, Joint 0 0 Gasket * All parts included in Fuel Filter Assembly.
Fuel Supply 0 Kit, Adapter Fuel (/ ID Hose) Kit, Fuel Adapter (/ ID Hose) Kit, Fuel Adapter (/ ID Hose) Kit, Fitting Adapter 0 Kit, Fuel Filter 0 Bracket, Fuel Pump Pump, Electric Fuel 0 V 0 V 00 0 Screw, Hex Head Sems (M x 0. x 0mm) 0 00 Elbow, Street Pipe 00 Clamp, Loop 00 0 0 Screw, Hex Head Cap (M x. x 0mm) 0 0 Hose, Fuel 0 0 Hose, Fuel 0 0 Clamp, Hose 0 0 0 Hose, Fuel Connector, Hose 0 Washer, Flat (M)
Fuel Transfer Lines (Front) 0 REF PART QTY. PART REF PART QTY. PART 0 Coupling, Anchor 0 Connector, Hose 0 0 Hose, Fuel 0 0 Clamp, Hose 0 Connector, Hose (/ NPT x / Hose) 0 0 Hose, Fuel (Return) 0 0 Plug, Hole 0 Clip, Retainer 0 0 Washer, Flat 0 00 0 Screw, Hex Head Cap (M x. x mm)
Fuel Transfer Lines (Rear) 0 REF PART QTY. PART REF PART QTY. PART 0 Coupling, Anchor 0 Connector, Hose 0 0 Hose, Fuel 0 0 Clamp, Hose 0 Connector, Hose (/ NPT x / Hose) 0 0 Hose, Fuel (Return) 0 0 Plug, Bulkhead Hole 0 Clip, Retainer 0 0 Washer, Flat 0 00 0 Screw, HEx Head Cap (M x. x mm) 0
Remote Water Separator REF PART QTY. PART REF PART QTY. PART 0 Kit, Remote Fuel/Water Separator 0 0 Separator, Fuel/Water (See Separate Page for Components) 0 0 Bracket, Separator Mounting 0 000 Elbow, Street 0Degrees 0 00 Bushing, Pipe * All Parts Included In Kit.
Water Separator Components 0 0 Kit Separator, Water 0 Kit, Metal Bowl Replacement (Includes Plug, O Rings and Drain Assy) Drain Assy (Includes Knob and Seal) 0 Element (Includes Seals) 0 0 Plug, Hex (/ ) Head Assy, Replacement (Includes Vent Plug, O Rings, Seal, Cap, Tube and Pump Assy) Plug, Vent (Includes O Ring) 0 Pump Assy (Includes Plunger, Retainer, Shaft, Check Ball, Knob and Screw) 0 O Ring Kit (Includes Seal and Plunger) * All Parts Included In Separator Kit.
Break Siphon MDKBT, MDKBU 0 0 Kit, Siphon Break 0 0 Hose, Coolant 0 0 Valve, Check 0 0 Cap, Tube 0 0 Clamp, Hose 0 0 Connector, Hose 0 Clamp, Hose 0 0 Edging 0 0 Grommet (Boot) * All Parts Included In Kit But Not All Shown.
Heat Exchanger 0 0 0 00 Kit, Low Coolant Sender 0 0 Exchanger, Heat 0 Hose, Coolant (Wet and Dry) 0 Hose, Water 0 Hose, Water 0 Hose, Coolant 0 Hose, Coolant 0 Clamp, Hose 0 Clamp, Hose 0 Pump, Water 0 0 00 O Ring, Seal 0 0 0 Bracket, Heat Exchanger 0 0 Clamp, Hose 00 0 Hex, Head Cap (M x. x 0mm) 0 Flat, Washer (M) 0 Clamp, Loop Heat Exchange 00 0 Screw, Hex Head Sims (M x. x mm) 0 0 Clamp, Hose (Cover) Clamp, Hose (Cover, Not Shown) 0 0 Wet 0 Dry 0 0 Switch, Pressure 0 00 0 0 Screw, Hex Head Cap (M x. x 0mm) Washer, Flat (M)
Keel Cooling (Wet Exhaust) 0 0 Hose, Water 0 Hose, Water 0 Hose, Coolant 0 Clamp, Hose 0 Clamp, Hose 0 Pump, Water 0 00 O Ring, Seal 000 Screw, Hex Head Cap (M0 x. x mm) 0 0 Clamp, Hose(Wet and Dry) 0 0 0 Tube, Low Pressure Clamp, Hose 0 Wet 0 Dry 0 Elbow, Hose 0 0 0 Tube, Water 0 Clamp, Hose 00 0 Screw, Hex Head (M x x mm) 0 0 0 Nut, HEx Flanged (M) Sender, Water Temperature 0 Neg Gnd 0 0 ISO Gnd 0 0 Switch, Pressure
Sea Water Pump 0 Kit, Pump Repair (Minor, Includes Parts Marked *) 0 Kit, Impeller Service (Includes Parts Marked +) Kit, Pump Repair (Major Includes All Parts Below) 0 0 +Seal, Shaft 0 Wear, Sleeve 0 0 Washer, Spring Locking Screw, Round Head Slotted 0 00 Bearing, Ball 0 Ring, Retaining 0 0 Seal, Shaft 0 Washer 00 Screw, Hex Head 0 0 Key 0 Ring, Retaining 0 Spacer, Water Pump 00 Slinger, Water Pump 0 Spacer, Water Pump 0 Ring, Retaining 0 +*Impeller, Water Pump 0 +*Gasket, Water Pump 0 +*Gasket, Water Pump All parts included in Major Repair Kit only. * Pump Repair Kit Includes Impeller and Gaskets. + Impeller Service Kit Includes Impeller Gaskets and Shaft Seal.
Auxiliary Drive (Sea Water Pump) 0 00 Pump, Comp. Base Hydraulic 0 00 Gear, Hydraulic Pump Drive 0 Ball, Bearing 0 Circular Clip, Internal 0 Circular Clip, External 0 0 O Ring 00 Bolt, Flange 0 Cover, Hydraulic Pump 0 00 O Ring (Dry Exhaust) 0 00 0 Bolt, Flange(Dry Exhaust) 0 00 Cover, Hydraulic Pump (Dry Exhaust)
Water Inlet Front 0 Rear 0 Kit, Hose (Includes Instruction and Water Hose, Front) 0 Kit, Hose (Includes Parts Mark*) 0 0 Plug, Hole (Front and Rear Housed,.0 ) 0 Bulkhead, Connector 0 Hose, Water (Front) 00 0 Screw, Hex Head Sems (M x.0 x mm) Clamp, Hose 0 Front 0 Rear 0 Clamp, Loop 0 0 0 Nut, Hex Head Flange (M x.mm) 0 *Hose, Water (Rear) 0 *Hose, Water (Rear) 0 0 *Connector, Hose (Rear) Clamp, Hose (Cover Not Shown) 0 Front 0 Rear 0 0 Washer, Flat (M) 0 0 Plug, Hole * Includes Hoses Connector and Clamps.
Coolant Recovery 0 Kit, Coolant Recovery (Instructions Included) 0 0 Tank, Coolant Recovery 0 Hanger, Tank 0 Hose (/ I.D. x 0 Lg.) 0 Cap, Tank 0 Hardware Package (Includes Mounting Hardware) * All Parts Included In Kit.
PTO 0 0 0 0 0 Kit, PTO (V) 0 Kit, PTO (V) 0 0 0 Bracket, PTO (Right) 0 0 0 Bracket, PTO (Left) 0 0 0 Bracket, Clutch Clutch 0 0 0 V 0 0 0 V 0 0 0 Adapter, Coupling 0 0 Coupling, Flexible 0 0 0 Adapter, Coupling 0 0 0 Bracket, Mounting Pad Shim, PTO 0 0 0 AR GA 0 0 0 AR GA 0 0 0 AR 0GA 0 0 Washer, Flat 00 0 Screw, Hex Head Cap (M x. x 0mm)) 0 Screw, Socket Head 0 Screw, Locking Flange (M x. x 0mm)) 0 Washer, Flat (M) 00 0 Screw, Hex Head Cap (M x. x 0mm) 00 000 Screw, Hex Head (/ x.00) 0 Washer, Flat (. 0GA) 0 00 Screw, Hex Head (/ NC x.00) 0 Screw, Socket Head Cap (M x. x 0mm) 0 00 Nut, Hex (M x.mm) 00 0 Screw, Hex Head Cap (M x. x 0mm) 0 0 Adapter, Pipe * Kits Include all parts noted. 0
Exhaust Manifold Kit, Exhaust (Parts Marked*) Kit, Exhaust (Parts Marked+) 0 Kit, Exhaust (Parts Marked^) 0 Kit, Exhaust (Includes Gasket Hole Plug, Adapter) Manifold Assy. (Exhaust) Gasket, Exhaust 0 Elbow, Exhaust (Wet) 0 0 0 Switch, Temperature (Wet) 0 0 0 Nut, Hex W/ET (# ) Gasket, Exhaust 0 0 0 Nut, Hex Flanged (M) 0 Cap, Radiator 0 ^Elbow, Exhaust (Dry) 0 Terminal, Tab Adapter 0 Sleeving, Insulation(.0 ) 00 0 Screw, Hex Head Cap (M x. x mm) 0 Stud 0 Sender, Low Coolant 0 Adapter * Includes Rear Exhaust Hose + Includes Front Exhaust Hose ^ Includes Exhaust Elbow. Kit 0 Includes Hole Plug, Gasket and Adapter 0.
Bulkhead Exhaust 0 Bulkhead Assy. 0 Hose, Exhaust (Rear) 0 0 Clamp, Hose 00 0 Screw, Hex Head 0 Hose, Exhaust (Front) 0 Plug, Hole Housed 0 0 Plug, Hole Housed
Water Separator, Muffler 0 Kit, Muffler, Separator (Includes Parts Marked *) Kit, Exhaust (Water Separator) (Includes Parts Marked +) *Muffler, Marine Clamp, Hose 0 0 + Muffler Kit 0 0 * Separator Kit 0 +Separator, Water 0 0 +Clamp, Hose
Isolated Ground 0 REF PART QTY. PART REF PART QTY. PART 0 0 Bracket, Solenoid *Relay, Solenoid 0 V 0 V 0 Washer, Flat (M) 0 0 Washer, Split Lock (M) 00 Nut, Hex (M) 00 0 0 Screw, Hex Head Cap (M x. x 0) 0 0 0 Nut, ET Hex (#0 ) (V) 00 Washer, ET Lock (/ ) 00 0 Nut, Hex (/ ) 0 00 0 Harness, Ground 00 Washer (/) Cable, Jumper * Relay Solenoid ties to B and K Isolated Ground Harness ( 00 0)
Mounting Base 0 0 0 0 Assy, Drip Pan Isolator, Mounting 0 0 0 MDKBT 0 0 0 MDKBT and MDKBU w/ PTO MDKBU w/o PTO 0 MDKBT and MDKBU w/ PTO MDKBU w/o PTO 0 0 Plug, Hole 0 Washer, Flat Washer, Flat (M) 0 Without PTO 0 With PTO 0 00 Nut, Hex (M x.mm) 00 0 Screw, Hex Head Sems (M x. x mm) 00 0 Screw, Hex Head Cap (M x. x mm) 00 Screw, Hex Head Cap (Mx. x 0mm) 0 0 0 0 Mount, Engine
Belt Guard 0 0 Kit Guard, Belt (Includes Parts Marked *) 0 0 *Guard, Belt 0 0 0 *Bracket, Fan Guard 0 *Spacer, Guard 00 0 *Screw, Hex Head Sems (M x. x mm) 00 0 0 *Screw, Hex Head Sems (M x x mm) 00 0 0 *Screw, Hex Head Cap (M0 x. x 0mm) 0 0 *Washer, Flat 0 *Washer, Flat 0 *Label, Warning All parts are for Unhoused Units Only.
PTO Belt Guard 0 0 0 Kit Guard, Belt (Includes Parts Marked *) 00 0 0 *Screw, Hex Head Cap (M0 x. x 0mm) 0 0 0 *Bracket, Fan Guard 0 *Spacer, Guard 00 0 *Screw, Hex Head (M x. x mm) 00 0 0 *Screw, Hex Head Sems (M x.00 x mm) 0 0 0 *Guard, Coupling 00 0 *Screw, Hex Head Sems Stainless (M x.00 x mm) 0 0 0 *Guard, Coupling 0 0 *Guard, Belt 0 0 0 *Washer, Flat 0 *Washer, Flat All Parts are for Unhoused Units Only
Generator Housing 0 0 0 0 Panel, Housing 0 0 0 Panel, Air Baffle 0 0 0 Panel, Air Baffle 0 0 0 Panel, Access 0 0 0 Panel, Enclosure 0 00 0 Panel, Enclosure 0 0 0 Cover, Enclosure (Rear) 0 Insulation, Panel 0 Insulation, Cover 0 0 PCB Assy, Control 0 Insulation, Panel 0 Insulation, Panel 0 0 Seal, Brush 0 Bracket, Fan HSG 0 0 Rivet, Pop 0 Insulation, Panel 0 Insulation, Panel 0 Seal, Weather 0 Insulation, Panel 0 00 Washer, Flat (M) 00 0 Screw, Hex Head Sems (M x 0. x 0mm) 00 0 Screw, Hex Head Sems (M x x mm) 0 Grommet, Rubber 0 0 Plug, Hole
Battery Harness (Front Bulkhead) Front Bulkhead 0 REF PART QTY. PART REF PART QTY. PART Kit, Terminal Boot (Includes Insulated Terminal Black and Red) 0 Harness, Battery 00 Washer, Flat (/ ) 000 Nut, Hex Head Hvy (/ UNC) Washer, ET Locking (M) 0 Neg 0 ISO 0 0 Cover, Access (Housed Only) 0 Bar Assy, Bus (Neg Gnd) Strap, Bond 0 Washer, Flat (M) 00 0 Screw, Hex Head Cap (M x. x 0mm) 0 0 Clamp, Hose 00 0 0 Screw, Hex Head Cap (M x. x 0mm) Washer, ET Lock (/ ) 000 Neg 000 ISO Washer, Flat (M) 0 0 Neg 0 0 ISO 00 Nut, HB Full (/ ) (Neg Ground) 0 0 0 Nut, Hex Head Flanged (M x.) 0 Clamp, Hose 00 0 Screw, Pan Head Mach Torx (M x.00 x 0mm)
Battery Harness (Rear Bulkhead) 0 Front Bulkhead REF PART QTY. PART REF PART QTY. PART 0 Harness, Battery 00 Washer, Flat (/ ) 000 Nut, Hex Head Hvy (/ UNC) Washer, ET Locking (M) 0 Neg 0 ISO 0 0 Cover, Access (Housed Only) 0 Bar Assy, Bus (Neg Gnd) Strap, Bond 0 Washer, Flat (M) 00 0 Screw, Hex Head Cap (M x. x 0mm) 0 0 Clamp, Hose 00 0 0 Screw, Hex Head Cap (M x. x 0mm) Washer, ET Lock (/ ) 000 Neg 000 ISO Washer, Flat (M) 0 0 Neg 0 0 ISO 00 Nut, HB Full (/ ) (Neg Ground) 0 0 0 Nut, Hex Head Flanged (M x.) 0 Clamp, Hose 00 0 Screw, Pan Head Mach Torx (M x.00 x 0mm) 0
Engine Sound Shield REF PART QTY. PART REF PART QTY. PART Kit, Sound Shield (Includes Complete Sound Shield Enclosure for Engine) 0 0 Panel, Roof 0 Cover, Access 0 Plug, Hole 00 0 Screw, Hex Head Sems Stainless (M x.0 x mm) 0 0 Gasket, Enclosure 0 Insulation, Roof 0 Insulation, Roof * Kit Includes Insulated Roof, Doors, Sides and Ends.
Engine Panel Sound Shield 0 0 REF PART QTY. PART REF PART QTY. PART 0 0 Panel, Access 0 Insulation, Door 0 0 Insulation, Sound 0. Seal, Weather 0. Seal, Weather 0 0 Door 0 0 Rivet, Pop 0 0 Catch, Door 0 0 Latch, Door 0 00 0 Screw, Hex Head Sems (M x x mm) 0 0 Insulation, Sound
Engine Panel Sound Shield (Front and Rear without PTO) 0 REF PART QTY. PART REF PART QTY. PART 0 0 Panel, Roof (End) 0 Installation Roof (End) 0 0 Panel, Duct 0 Insulation, Duct 0 0 Panel, Enclosure (Front) 00 0 Screw, Hex Head Cap Stainless (M x.0 x mm) 0 00 Grommet, Rubber 0 0 Plug, Hole 0 0 Rivet, Pop 0 0 0 Catch, Door
Engine Panel Sound Shield (Front w/pto) 0 REF PART QTY. PART REF PART QTY. PART Kit, Sound Shield (Includes PTO End Parts) 0 0 0 Panel, Duct 0 Insulation, Duct 0 0 Panel, Enclosure 00 0 Screw, Hex Head Sems Stainless (M x x mm) 0 0 0 Guard, Coupling (PTO) 0 Insulation, Sound 0 0 0 Guard, PTO 0 Insulation, Sound 0 0 0 Guard, PTO 0 0 Insulation, Sound 0 Insulation, Sound 0 00 Grommet, Rubber 0 0 Plug, Hole * All Parts On This Page Included In Kit.
Generator 0 0, Kit, Generator Heater 00 V 00 V Stator, Generator (Includes Grommet) Single, Phase 0 0 MDKBT 0 0 MDKBU Three Phase 0 0 MDKBT 0 0 MDKBU Rotor Assy, Generator (Includes Parts Marked *) 0 0 MDKBT 0 0 MDKBU 0 0 Endbell 0 0 Retainer, Endbell 00 00 Screw, Hex Head Cap (. x.0 ) 00 00 Screw, Hex Head Cap (. x.00 ) 0 0 0 Washer, Locking (. ) 0 Washer, Flat (. ) Connector, Plug 0 0 0 Bearing, Ball 0 0 Rotor, Wound (Excitor) 0 0 0 Generator, Fan 0 Spacer Drive, Disk 0 Screw, Hex Flanged (.0 ) 00 Washer, Locking ET (.0 ) 00 0 *Screw, Hex Head Cap (M x. x 0mm)) 000 Screw, Hex Head Cap (. x.00 ) 0 Washer, Flat (M0) 0 0 Washer, (M) Label, Certification (UL) 0 Hub, Drive * Parts Included in Generator Rotor Assy. + Heater Clamp Cover and Hardware Included In Heater Kits.
Control Box 0 0,, 0
Control Box REF PART QTY. PART REF PART QTY. PART 0 Kit, PCB (J No Cover) 0 Kit, PCB (SmartCraft No Cover) 0 Control, Box 0 0 0 Isolation, Vibration 0 0 Rivet, Pop 0 Cover, Box 0 Cover 0 Guide, Card 0 0 Grommet, Remote 0 Plug, Hole 00 0 Screw, Hex Head Cap (M x x mm) 0 00 Washer, Flat (M) Standoff, Insulation 0 Single Phase Neg V V 0 Three Phase Neg/ISO V V 0 Three Phase ISO V V Washer, Flat (. ID) 00 Single Phase Neg V V 00 Three Phase Neg V V 00 Single Phase ISO V V 00 Three Phase ISO V V Screw, Hex Flange (/ 0 x / ) 000 Single Phase Neg V V 000 Three Phase Neg V V 000 Three Phase ISO V V 000 Washer, ETIT Locking (/) 00 Nut, Hex (. 0UNC) 0 0 Screw, Round, Head (. 0UNC. ) Strap, Bond 00 Washer, ET Lock (/ ) 00 0 Screw, Hex Head Cap (M x. x mm) 0 00 0 Screw, Hex Head Cap (M x. x mm) Screw, XREC Pan Head ( x. ) 00 0 Single Phase 00 0 Three Phase Assy, NIM PCB 0 NIM /J 0 NIM /Smartcraft 00 00 Screw, Hex Head Sems (M x. x 0mm) J /Smartcraft Harness, Accessory J/Smartcraft Nut, Nylon Locking (M) 0 0 Neg/Iso Gnd Phase and v 0 0 J /Smartcraft 0 Relay, SPDT (V) 0 Relay, SPDT (V) 0 0 Plug, Hole 0 0 Plug, Hole 0 Circuit, Breaker MDKBT 0 00 Amps Pole 0 0 Amps Pole 0 0 0 Amps Pole 0 0 Amps Pole 0 Amps Pole 0 0 Amps Pole 0 Amps Pole 0 0 Amps Pole 0 Amps Pole 0 00 Amps Pole MDKBU 0 00 Amps Pole 0 0 0 Amps Pole 0 Amps Pole 0 0 Amps Pole 0 0 Amps Pole 0 Amps Pole 0 0 Amps Pole 0 Amps Pole 0 00 Amps Pole 0 0 Amps Pole * Included In PCB Kits, PCB Assembly, Accessory Harness Instructions and Hardware. SmartCraft is a trademark of the Brunswick Corporation.
Control Panel Components REF PART QTY PART NO. NO. USED DESCRIPTION Assy Panel, Engine 00 0 V 00 0 V 00 Assy Panel, Blank (Std) Rivet, Drive Plastic (Std) 0 0 Standard 0 0 esdd 00 0 Assy Control (esdd) (See NIM Option Page)
Control Panel Kit 0 Kit, Control (Includes Instruction Sheet Control and Screws) 0 Panel, Display Label, Information (Display) 00 0 Assy, Control 0 0 Washer, Flat DAC (#) 00 00 0 Screw, Hex Head Mach (# UNC x.0lg) 0 Screw, Flat Head XREC (M. x.mm) 0 0 Rivet, Driver 000 Washer, ETITE Locking (#0) 0 0 Nut, Sems ET (#0 ) * Also includes Instruction sheet 000C 0.
Control Panel Components (Breaker Switch Option) 0 REF PART QTY. PART REF PART QTY. PART Assy, Engine Panel (All Parts Included) 00 0 V 00 0 V 0 Panel, Control Label, Control 0 Breaker, Circuit ( Amp) 0 Breaker, Circuit (0 Amp) 0 0 Meter, Hour Switch, Rocker SPDT 0 VDC 0 VDC 0 Harness, Control 00 00 0 Screw, Hex Head ( x / ) 0 0 Washer, Flat (#) 0 0 Panel, Control (Ground) 000 Washer, EIT Lock (#0) 0 0 Nut, Sems EIT * See Control Box for Location. 0
Remote Control Panel P S 0 REF PART QTY. PART REF PART QTY. PART Kit, Remote Switch Harness (Includes Parts Marked +) 0 0 V 0 0 V Kit, Panel Remote (Includes Parts Marked #) 00 0 V 00 0 V #+Switch, Rocker (S) 0 0 V 0 0 V #Panel, Remote (Includes Printing) #+Harness, Remote Panel (Includes Parts Marked *) 0 0 *Connector, Switch (S) 0 *Terminal, Receptacle (. ) *Terminal, Socket *Plug, ( Pin) *Plug, Seal *Wedge, Plug ( Pin) 0 00 #Screw, Wood (# x ) 0 +Label, Instructions 0 #+Label, Warning # Parts Included in Remote Panel. + Parts Included in Remote Switch Harness. Instructions included in Kits only
Blank Sheet
Control Harness J 0 J S S P P P REF PART QTY. PART REF PART QTY. PART 0 Harness, Control 0 0 Plug ( Pin, Black P) 0 Plug ( Pin, Gray P) 0 Plug ( Pin, Green P) AR Plug (P) 0 AR Seal,Cable(S) 0 0 Switch, Connector (S) Connector, Housing Pin (S) Socket, Relay Plug, Wedge Pin, P, P, P 0 Connector, Receptacle Pin (J, J) Receptacle, Wedge(J, J) Label, Information (Relay)
Wiring Harnesses 0 0 P J J
Wiring Harnesses REF PART QTY. PART REF PART QTY. PART Harness, Remote Extension (Includes Parts Marked #) feet feet feet 0 feet 0 00 feet 0 0 feet #Plug ( Pin) #Terminal, Socket #Wedge, Plug ( Pin) #Receptacle, ( Pin) #Terminal, Pin #Wedge, Receptacle ( Pin) Harness, Remote Panel Plug ( Pin) 0 Wedge, Plug (Pin) AR Terminal, Socket AR Plug, Seal 0 Harness, Pigtail (Includes Parts Marked @) @Connector, Receptacle ( Pin) AR +Terminal, Pin @Wedge, Lock ( Pin) 0 Harness, Junction (Includes Parts Marked +) ± Plug, Connector ( Pin) AR ± Terminal, Socket 0 ± Wedge, Plug ( Pin) +Connector, Receptacle ( Pin) AR @Terminal, Pin +Wedge, Lock, Receptacle ( Pin) # Parts Included in Remote Extension Harness. * Parts Included in Custom Pigtail Harness. Parts Included in Adapter Harness..+ Parts Included in Junction Harness..@ Parts Included in Pigtail Harness.
Labels, Kits 0 Label, Information (Housed Includes Parts Marked *) Label, Information Includes Parts Marked +) +Label, Information Ground +Label, Warning (Unhoused) 0 +Label, Information 0 +Label, Danger +Label, Warning 0 +Label, Information (Service) +Label, Warning 0 Label, Onan E QD (Housed) 00 *Label, Information (Oil Fill Housed) *Label, Warning (Housed) *Label, Information (Lifting) (Housed) *Label, Information (Coolant) (Housed) Label, Information (No Step) + Housed * Unhoused Label, Warning (Coolant) + Housed * Unhoused 0 Label, Information (Housed w/ PTO, Includes Parts Marked ^) Label, Information Label, Information (Housed) 0 ^Label, Information (Housed w/ PTO) 0 ^Label, Information (Housed w/ PTO) 00 0 Kit, Cruise Includes All of The Following Items: 0 Filter, Fuel 00 Filter, Oil Kit Pump, Service 0 Belt 0 Pencil, Zinc 0 Box, Cruise Kits 00 0 Kit, Remote Panel 00 0 Kit, Remote Panel Kit, Terminal Boot 0 0 Kit, Remote Switch 0 0 Kit, Remote Switch
Numerical Index Part No. Page Part No. Page Part No. Page Part No. Page 0 0, 0 0, 0, 0 0, 0, 0 0 0, 00, 0, 0 0, 0 00, 0, 0, 0, 0 0, 0, 0, 0, 0 00, 0, 0, 0 0, 0 0, 0, 0, 0 0, 0 0, 0, 0, 0, 0 0, 0, 0 0 0, 0, 0 0, 0, 0 0, 0, 0 0, 0, 0 0 0, 0 0, 0 0, 00, 0 0 0, 0 0, 0 0, 0, 0 0 0 0,, 0, 0 0, 0, 0 0 0 0, 0, 0 0, 0, 0,, 0 0, 0 00, 0, 0 0, 0, 0 0, 0, 0, 0, 0 0, 0, 0 0, 0, 0 0, 0, 0, 0, 0 0, 0 0, 0, 0, 0 0, 0, 0, 0, 0 0, 0, 0, 0, 0 0, 0, 0, 0, 0 0, 0, 0, 0 00, 0 0, 00,, 0, 0 0, 0, 00, 0, 0 0, 0, 0,, 0, 0 0, 0, 0, 0, 0 0, 0 0, 0, 0,, 00 0, 0, 0, 0, 00 0, 0,,, 00, 00 0, 0,, 0, 0 0, 0,, 0, 0 0, 0,, 0, 0 0, 0 0,, 0, 0, 0, 0, 0, 0, 0, 0, 0, 0 0, 0, 0, 0, 0 0, 0,, 00,
Numerical Index Part No. Page Part No. Page Part No. Page Part No. Page 0, 0 0,,, 0, 0 0 0 0, 0 00,, 00, 00, 00,, 00, 0, 0, 0, 0, 0 0,, 0,,,, 0 0, 0, 0, 0, 0,,,,,, 0, 0, 0, 0,,,,, 0, 0 0, 0 00, 0 0, 0 0, 0 0, 0 0, 0 0, 0 0, 0 0, 0 0, 0, 0 0,,,,, 0, 0, 0,,, 0, 0, 0, 0, 00, 0, 0, 0 0,,,,,,,,,, 0,,, 0,,,,,,,,,, 0, 0,, 0,,,,,,,,,,, 0,,,,,,,,,, 0,,,,,,,,,, 0,,,,,,,,, 00, 0, 0, 0, 0, 0, 0,, 0,,,,,,,,,,,,, 0,,,,,, 0 00,, 0,,,,
Numerical Index Part No. Page Part No. Page Part No. Page Part No. Page 0, 0 0 0 0, 0, 0 0, 0, 0 0 0 0,, 0 0, 0, 0 0 0 0,, 0, 0, 0 0 0, 0, 0 0, 0 0, 0 0 0 0, 0, 0 0, 0 00, 0 0 0 0, 00 0, 0, 0, 0 0, 0 0, 0, 0, 0, 0, 0,, 0, 0 0, 0,,, 0, 0 0, 0,, 0, 0 0, 0,,,, 0, 0, 0 0,, 0, 0 0, 0, 0 0,, 0 0 0, 0 0 0, 0 0,,,, 0 0, 0, 0, 0 0,,, 0, 0,,,, 0 0 0,,,, 0 0, 0 0,,,,, 0 0, 0, 0 0,, 0 0, 0,,, 0 0, 0, 0 00,,,,,,,, 0 0, 0,,, 0, 0,, 0, 0, 0, 00, 0,,,,, 00, 0 0, 0 0 0, 0, 00, 0, 0 0 0, 0, 00, 0, 0 0 0, 0, 00, 0, 0 0 0, 0, 00 0,, 0 0, 0 0, 0, 00 0,, 0 0, 0 0 0, 0, 00 0,, 0, 0 0 0, 0 0, 00 0,, 0, 0 0 0, 0, 00 0, 0, 0 0 0, 0, 00 0, 0, 0 0 0, 0, 0 0, 0 0 0, 0 0 0, 0, 0 00, 0,
Numerical Index Part No. Page Part No. Page Part No. Page Part No. Page 0 0, 0, 0, 0 0, 0 0,, 0, 0, 0, 0 0, 0, 0,, 0 0, 0 0, 0, 0,,, 00 0, 0 0, 0 0,,,, 0, 0 0,,,, 0, 0 0,,,,, 0,, 0 0, 0 0,,, 0, 0, 0, 0 0,,, 0, 0, 0 0,, 0, 0, 0, 0, 0 0 0, 0 0 0, 0, 0, 0 0 0, 0, 0,,,,, 0, 0, 0, 0,,, 0 0 0, 0 0, 0 0,,, 0 0 0, 0 0, 0, 0 0, 0 0 0, 0 0,, 0 0, 0, 0, 0, 0, 0, 0 0, 0 0, 0 0, 0, 0 0, 0 0,, 0 0, 0, 0, 0 0, 0 0,,, 0 0, 0, 0 0,,, 0, 0, 0 00 0, 0, 0, 0, 0 0 0, 0 00, 0,, 0, 0 0 0, 0 0, 0,,,, 0 0 0, 0 0, 0 0, 0 0, 0 0, 0 0, 0, 0, 0 0, 0 0, 0, 0, 0 0, 0 0, 0, 0 0,, 0 0 0, 0 000, 0 0,,, 0 0, 0 00, 0 0,, 0, 0 00 0, 0 0,, 0 0 0, 0 00, 0 0,, 0, 0 0 0, 0 0, 0,, 0 0, 0, 0,, 0, 0,, 0 0, 0, 0, 0,, 0 0,,, 0, 0, 0 0, 0 0,, 0 0
Numerical Index Part No. Page Part No. Page Part No. Page Part No. Page 0,, 0 000, 0 0, 0, 0 0, 0 0 00, 0,,, 0, 0 0,, 0 0 00, 0, 0, 0, 0 00, 0, 0, 0, 0 00,, 0, 0, 0 0, 0 0, 0, 00, 0 0, 0 0,, 0, 0 0, 0,,, 0 0, 0 0,, 0, 0 0, 0, 0, 0, 0 0, 0 0,, 0, 0 00, 0 0,, 0, 0, 0 00, 0 0,, 00,, 0 0 0, 0 0 00,,,, 00, 0, 0 0,, 00, 0, 0 00, 0 0,, 00, 0 0, 0 0, 0, 0, 0, 0 0, 0, 0, 0, 0 00, 0 00, 0 0 00, 0 00, 0 00, 0 00, 0 00, 0 00, 0 00, 0 00, 0 00, 0 00, 0 00, 0 00, 0 00, 0 00, 0 0, 0 0, 0 0, 0 0, 0 0, 0 0, 0 0, 0 0, 0 0, 0 0, 0 00, 0 0, 0 0, 0 0, 0 0, 0 0, 0 0, 0 00, 0 0, 0 0, 0 0, 0 0,, 0,,, 0 0, 0 0, 0 0, 0 0, 0, 0, 0, 00, 00, 00, 00, 0 0, 0 0,, 0 0, 00, 0, 0, 0, 0,, 0 0, 0, 0,, 0 0 0, 0 0,, 0 0, 0 0, 0,,, 0 0, 0,,,,, 0 0, 0, 0,,, 0,,, 0 0,, 0, 0 00, 00,, 0,, 0 0, 0 0,, 0 0,, 0,
Numerical Index Part No. Page Part No. Page Part No. Page Part No. Page 0, 00 0, 0 00, 0 0,,, 0, 00 0, 0,, 0 00, 0 0, 0, 00 0, 00, 0 0 0, 0, 00 0, 00 0, 0 0, 0, 00 00, 0 00, 0 000,, 0, 00 0, 0 0, 0 00 0, 0, 0 00 0,, 0 0, 00, 0, 0 00 0, 0 0, 00, 0, 00,, 0 0,, 0 0 0, 00,, 0, 0 0 0, 0 0, 00,,,, 0 0 0,, 00, 00 0, 0 0,, 00, 000,, 0 0 0,,,, 0, 0,, 0, 0, 0, 0 0, 0 00 00, 00 000, 0 00 00 0, 0 00 00 0,, 0 00 00, 00 00, 00 0, 00, 00 0 0,, 00 0, 0,, 0,, 00 0, 00 0, 0 00 0 0,, 00 0, 00 0 0, 0,,,,, 0 00 0, 0,,,,,,,,, 00 0, 00 0, 00 0, 00 0, 00 0, 00 0, 00 0, 00 0,, 00 0,,,, 00, 00, 00, 00,,, 00, 00, 00,, 00, 00 0, 0 00, 00, 00, 00, 00, 00, 0, 0 0, 0 0,,,, 0 0,, 0,, 000, 0, 0 00 0, 00 0,,, 00 0,, 0 0 00, 0 0 0, 0 0, 0 0, 00, 00,, 0,, 0 000,, 0 000, 000,, 0 0 00, 0 0, 0 0, 0 0 0,,,, 0 00, 00,, 0 0,, 0, 0,
Cummins Power Generation 00 rd Ave. NE Minneapolis, MN USA Phone 000 Toll-free 00 Fax Email www.cumminsonan.com/contact www.cumminsonan.com Cummins, Onan, the C logo, and Performance you rely on. are trademarks of Cummins Inc. 00 Cummins Power Generation, Inc. All rights reserved.