Russian Motorcycle Schematics and Wiring Diagrams Part XII: Dnepr Schematics, Wiring Diagrams and Part Lists Ernie Franke eafranke@tampabay.rr.com 11 / 2017
Differing Electrical Schematics on the Same Model of a Russian Motorcycle Within the Same Model (such as within a M-72 or within a MT-12), There Can Be Several Different Schematics for the Same Model (Early/Later), depending on; Ignition System on Dnepr K-750 or on MT-12, Ural M-62 or on M-63 Manual Spark Advance on Early Version: PM-05/PM-11 Automatic Spark Advance on Later Versions: PM-302 Alternator Upgrade on a Ural 650 or 750 Series Hitachi 18-Amp ( 98) Russian Hand-Grenade (14.3771) 35-Amp ( 98-1/2) Nippon Denso 55-Amp ( 04) Voltage Regulator Mechanical-to-Later Mechanical on Dnepr MT-12, MT-16 or on Ural M-62 PP-31/PP-31A ( 50/ 56) PP-302/PP-302A ( 63) Mechanical-to-Solid-State on Dnepr MB-750M, MT-11, MT-16 or on Ural MT-63, 8.103 650 Series PP-330( 63) Mechanical 33.3702 ( 92) Solid-State Brake Lights Notes for Model and Component Numbers Model Designations: MV (cyrillic MB) = MB = CF (Example: MB-750 = MV-750, CF-650 = MB-650) Component Designations: No Brake Lights on Early Russian Bikes - Original M-72 s and early K-750 s Rear Foot-Pedal Brake- - Started in Late 1950 s with M-72M s and later K-750 s Directional Turn Signals Early M-61, M-62: No Directional Signals Later M-61, M-62: Directional Signals and PC419 Flasher Unit Ignition Coil Upgrade Improved Model on a Ural M-72: From a KM-01 to a B2B ВП = VP (Example: ВП48801 = VP48801) H = N (Example 72H05121 = 72N05121) 2
Ferreting Out Data on Old Russian Bikes It Takes a Bit of Courage to Post Information You Are Subject to Helpful Advice It Helps If Offered in the Right Spirit For Example: Received Some Good Advice about the M-72 Headlight Assembly. Not Being a M-72 kind of Guy, I Simply Looked at All the International Postings I Could Get, Sorted thru Them All and Came Up with a Few Rules Take Advise from the Old Farts: Been Around the Block a Few Times Trust the Old Manuals and Schematics First Trust the Illustrated Parts Diagrams Next Trust the Component Dealers Labels Next These Are Good for Commonality and Later Re-Fitting Trust the Bikes Ads Last Folks Have a Devil of a Time Figuring Model or Year of Bike They Own Folks Purchase Bikes Restored to Something Less than Original Reasons for Differing Views Ivan Took a Break for Some Refreshments Ran Out of One Particular Part and Had a Few Old Parts Lying Around Wanted to Get the Improved Parts into the Hands of the Customers Replica Parts Made for Maximum Replacement for Some Other Industry»Replaced an Electric Starter on My 2003 Patrol. Replacement Starter Fit Like a Glove. Life was Good, until I Noticed that the Starter Was about One Inch Longer than the Original. Starter Lever Couldn t Move More than ¼ Range, Due to Slicing the Starter. No Problem for the 3 Major Supply (i.e. Russian Outboard Motors)
Table I: KMZ (KMЗ) - Dnepr (Днепр) Model/Year vs. Electrical System Model Year Engine Size Voltage Chassis Polarity Generator/ Alternator Regulator Ignition Coil Breaker/ Distributor M-72 1952-56 750cc 6-Volt Pos G-11A (1952) PP-31 (1950) KM-01 PM-05 3MT-7 (7A-hr) or M-72N (H) 1956-59 750cc 6-Volt Pos G-11A (1952) PP-31A (1956) KM-01 PM-05 3MT-14 (14A-hr) K-750 Battery 1958-60 Pos G-11A (1952) PP-31A (1956) B2Б PM-05, PM-11A 3MT-6 750cc 6-Volt 1960-63 Neg G-414 (1957) PP-302 (1963) B201 PM-302 3MT-12 or 3MTS-14 K-750M 1963-77 750cc 6-Volt Neg G-414 (1957) PP-302 (1963) MT-12 (Dnepr-12) 1974-82 2WD 1982-85 1WD 750cc 6-Volt Neg G-414 (1957) PP-302 (1963), PP-302A MB-750 1964-73 750cc 6-Volt Neg G-414 (1957) PP-302 (1963) MB-750M 1973-77 750cc 6-Volt Neg G-414 (1957) PP-302 (1963), 33.3702 (1992) K-650/MT-8 1967-70 650cc 6-Volt Neg G-414 (1957) PP-302 (1963), PP-302A K-650/MT-9 1971-74 650cc 6-Volt Neg G-414 (1957) PP-302 (1963)/ PM-302A B2Б B201 B2Б B201 B2Б B201 B2Б B201 B2Б B201 B2Б B201A PM-05 PM-302 PM-05 PM-302 PM-05 PM-301/PM-302 PM-05 PM-301 PM-05, PM-11A PM-302/PM-302A PM-05 PM-302 MT-10 1973-76 650cc 12-Volt Neg G-424 (1974) PP-330 B204 PM-302/PM-302A MT-10.36 1975-87 650cc 12-Volt Neg G-424 (1974) PP-330 B204 PM-302A MB-650 1976-84 650cc 12-Volt Neg G-424 (1974) PP-330 33.3702 (1992) B204 PM-302A MB-650M 1985-91 650cc 12-Volt Neg G-424 (1974) PP-330 B204 PM-302/PM-302A MT-11 (Dnepr-11) 1985-1995 650cc 12-Volt Neg G-424 (1974) MT-16 (Dnepr-16) 1986-1995 650cc 12-Volt Neg G-424 (1974) PP-330, 33.3702 (1992) B204 PM-302A PP-30, PP-31, PP-330, 33.3702 (1992) B204 PM-302/302A 3MT-6 3MT-12 3MT-12 3MT-12 3MT-6 or 3MT-12 6MTS-9 or or 2X 3MT-6 (9A-hr) 1. MT-14 (1977) was a prototype. 2. MW-650 is military version of MT-16 and MW-750 is a military version of the MT-12 3. Alternators progress in output voltage and power from Г-11 (G-11) generator of 6-Volts/45-Watts in 1941, Г-11A of 6 V/45 W in 1952, Г-414 6V/65 W in 1957, Г-424 of 12V/150W in 1974, 14.3771 of 12V/350W in 1998.5, to the present-day Nippon-Denso alternator of 12V/770W. 4. MT-11 and MT-16 remained in production until 1991 when they were re-named the Dnipro-11 (Dnepr-11) and Dnipro-16 (Dnepr-16). 5. Model # s: H = N, MW = MB = MV 6. 33.3702 Solid-State Voltage Regulator replaced the PP-330 in 1992. 7. Г-424 alternator (150 Watts) has external relay/regulator (PP-302 or PP-330). 14.3771(350 Watts) alternator has internal regulator. 8. 12-Volt ignition coil B2Б (manual spark advance) paired with PM-05 distributor, B201/B201A (ignition coil for automatic spark advance) paired with PM-302/PM-302A. B2Б and B201 coils for 6-Volts and B204 for 12-Volts. 4
Table II: IMZ (ИМЗ) - Ural (Урал) and KMZ (KMЗ) - Dnepr (Днепр) Brake es Mfgr Model Year Engine Size ( cm 3 / inch 3 ) Hand (Front) Brake- Foot (Rear) Brake- Voltage Brake Lamp M-72 1941-56 746 / 45.3 SV - - Later: ВК854Б 6-Volt A6-15 M-72K 1954-60 746 / 45.3 SV - - Later: ВК854Б 6-Volt A6-15 M-72M 1956-60 746 / 45.3 SV - - Later: ВК854Б 6-Volt A6-15 M-61 1958-60 649 / 39.4 OHV - ВК854Б 6-Volt A6-15 M-62 1961-65 649 / 39.4 OHV - ВК854Б 6-Volt A6-15 Ural M-63 (Ural-2) 1965-68 649 / 39.4 OHV - Later: 8.102-17048 ВК854Б 6-Volt A6-15 M-66 (Ural-3) 1968-72 649 / 39.4 OHV - IMZ-8.102-17048 6-Volt A6-15 M-67 1973-75 649 / 39.4 OHV Later: IMZ-8.102-17048 ВК854Б 12-Volt A-12-21 M-67.36 1976-95 649 / 39.4 OHV Later: IMZ-8.102-17048 ВК854Б 12-Volt A-12-21 8.103, 8.107 Series 650 1994-2002 649 / 39.4 OHV IMZ-8.102-17048 IMZ-8.102-17048 12-Volt A-12-21 8.1037 750 Series 2003-present 745 / 45.2 OHV IMZ-8.102-17048 IMZ-8.102-17048 12-Volt A-12-21 M-72 1952-56 746 / 45.3 SV - - Later: ВК854Б 6-Volt A6-15 M-72N 1956-59 746 / 45.3 SV - - Later: ВК854Б 6-Volt A6-15 K-750 1959-63 746 / 45.3 SV - ВК854Б, Later: 65018950 6-Volt A6-15 K-750M 1963-77 746 / 45.3 SV - ВК854Б, Later: 65018950 6-Volt A6-15 MB-750 1964-73 746 / 45.3 SV ВК854Б, Later: 65018950 6-Volt A6-15 K-650/MT-8 1967-70 649 / 39.4 OHV - ВК854Б 6-Volt A6-15 K-650/MT-9 1971-74 649 / 39.4 OHV - ВК854Б 6-Volt A-6-21 MB-750M 1973-77 746 / 45.9 SV - ВК854Б 6-Volt A6-15 Dnepr MT-10 1973-76 649 / 39.4 OHV - ВК854Б 12-Volt A-12-21 MB-650 1976-84 649 / 39.4 OHV 13.3720 ВК854Б 12-Volt A-12-21 MB-650M 1985-91 649 / 39.4 OHV - ВК854Б 12-Volt A-12-21 MT-10.36 1975-87 649 / 39.4 OHV - ВК854Б 12-Volt A-12-21 MT-12 (Dnepr-12) 1974-85 746 / 45.3 SV - ВК854Б, Later: 65018950 6-Volt A6-15 MT-11 (Dnepr-11) 1985-1995 649 / 39.4 OHV 13.3720 ВК854Б 12-Volt A-12-21 MT-16 (Dnepr-16) 1986-1995 649 / 39.4 OHV 13.3720 ВК854Б 12-Volt 5 A-12-21
Table III: IMZ (ИМЗ) - Ural (Урал) and KMZ (KMЗ) - Dnepr (Днепр) Neutral-Gear Sensors Mfgr Model Year Engine Size ( cm 3 / inch 3 ) Ural Dnepr Neutral-Gear Sensor Voltage Signal Lamp M-72 1941-56 746 / 45.3 SV - 6-Volt - M-72K 1954-60 746 / 45.3 SV - 6-Volt - M-72M 1956-60 746 / 45.3 SV - 6-Volt - M-61 1958-60 649 / 39.4 OHV - 6-Volt - M-62 1961-65 649 / 39.4 OHV - 6-Volt - M-63 (Ural-2) 1965-68 649 / 39.4 OHV - 6-Volt - M-66 (Ural-3) 1968-72 649 / 39.4 OHV - 6-Volt - M-67 1973-75 649 / 39.4 OHV - 12-Volt - M-67.36 1976-95 649 / 39.4 OHV MT804517A 12-Volt A12-1 8.103, 8.107 Series 650 1994-2002 649 / 39.4 OHV IMZ-8.103-04055 12-Volt A12-1 8.1037 750 Series 2003-present 745 / 45.2 OHV IMZ-8.103-04055 12-Volt A12-1 M-72 1952-56 746 / 45.3 SV - 6-Volt - M-72N 1956-59 746 / 45.3 SV - 6-Volt - K-750 1959-63 746 / 45.3 SV MT804517A 6-Volt A6-1 K-750M 1963-77 746 / 45.3 SV MT804517A 6-Volt A6-1 MB-750 1964-73 746 / 45.3 SV MT804517A 6-Volt A6-1 K-650/MT-8 1967-70 649 / 39.4 OHV - 6-Volt - MB-650 1976-84 649 / 39.4 OHV MT804517A 12-Volt A12-1 K-650/MT-9 1971-74 649 / 39.4 OHV MT804517A (after adding PM-05) 6-Volt A6-1 MB-750M 1973-77 746 / 45.9 SV MT804517A 6-Volt A6-1 MT-10 1973-76 649 / 39.4 OHV MT804517A 12-Volt A12-1 MB-650M 1985-91 649 / 39.4 OHV MT804517A 12-Volt A12-1 MT-10.36 1975-87 649 / 39.4 OHV MT804517A 12-Volt A12-1 MT-12 (Dnepr-12) 1974-85 746 / 45.3 SV MT804517A 6-Volt A6-1 MB-650-M1 1985-2007 649 / 39.4 OHV 12-Volt MT-11 (Dnepr-11) 1985-1995 649 / 39.4 OHV MT804517A 12-Volt A12-1 MT-16 (Dnepr-16) 1986-1995 649 / 39.4 OHV MT804517A 12-Volt A12-1 6
Table IV: IMZ (ИМЗ) - Ural (Урал) and KMZ (KMЗ) - Dnepr (Днепр) Oil-Pressure Sensors Mfgr Model Year Engine Size ( cm 3 / inch 3 ) Ural Dnepr Oil-Pressure Sensor Voltage Signal Lamp M-72 1941-56 746 / 45.3 SV - 6-Volt - M-72K 1954-60 746 / 45.3 SV - 6-Volt - M-72M 1956-60 746 / 45.3 SV - 6-Volt - M-61 1958-60 649 / 39.4 OHV - 6-Volt - M-62 1961-65 649 / 39.4 OHV - 6-Volt - M-63 (Ural-2) 1965-68 649 / 39.4 OHV - 6-Volt - M-66 (Ural-3) 1968-72 649 / 39.4 OHV MM106A 6-Volt A6-1 M-67 1973-75 649 / 39.4 OHV - 12-Volt - M-67.36 1976-95 649 / 39.4 OHV - 12-Volt A12-1 8.103, 8.107 Series 650 1994-2002 649 / 39.4 OHV - 12-Volt A12-1 8.1037 750 Series 2003-present 745 / 45.2 OHV - 12-Volt A12-1 M-72 1952-56 746 / 45.3 SV - 6-Volt - M-72N 1956-59 746 / 45.3 SV - 6-Volt - K-750 1959-63 746 / 45.3 SV MM106A (later models) 6-Volt A6-1 K-750M 1963-77 746 / 45.3 SV MM106A (later models) 6-Volt A6-1 MB-750 1964-73 746 / 45.3 SV - 6-Volt - K-650/MT-8 1967-70 649 / 39.4 OHV MM106A (later models) 6-Volt A6-1 MB-650 1976-84 649 / 39.4 OHV MM106A 12-Volt A12-1 K-650/MT-9 1971-74 649 / 39.4 OHV MM106A 6-Volt A6-1 MB-750M 1973-77 746 / 45.9 SV MM106A, MM126 6-Volt A6-1 MT-10 1973-76 649 / 39.4 OHV MM106A, MM126 12-Volt A12-1 MB-650M 1985-91 649 / 39.4 OHV MM126 12-Volt A12-1 MT-10.36 1975-87 649 / 39.4 OHV MM126 12-Volt A12-1 MT-12 (Dnepr-12) 1974-85 746 / 45.3 SV MM126 6-Volt A6-1 MB-650-M1 1985-2007 649 / 39.4 OHV MM126 12-Volt A12-1 MT-11 (Dnepr-11) 1985-1995 649 / 39.4 OHV MM126 12-Volt A12-1 MT-16 (Dnepr-16) 1986-1995 649 / 39.4 OHV MM126 12-Volt A12-1 7
Table V: Ural (Урал) and Dnepr (Днепр) Master Battery es Mfgr Model Year Engine Size ( cm 3 / inch 3 ) Voltage Master Battery M-72 1941-56 746 / 45.3 SV 6-Volt Not Used M-72K 1954-60 746 / 45.3 SV 6-Volt Not Used M-72M 1956-60 746 / 45.3 SV 6-Volt Not Used M-61 1958-60 649 / 39.4 OHV 6-Volt Not Used M-62 1961-65 649 / 39.4 OHV 6-Volt Not Used M-63 (Ural-2) 1965-68 649 / 39.4 OHV 6-Volt Not Used Ural M-66 (Ural-3) 1968-72 649 / 39.4 OHV 6-Volt Not Used M-67 1973-75 649 / 39.4 OHV 12-Volt IMZ-8.101-1806-01 M-67.36 1976-95 649 / 39.4 OHV 12-Volt IMZ-8.101-1806-01 8.103, 8.107 Series 650 1994-2002 649 / 39.4 OHV 12-Volt IMZ-8.101-1806-01 8.1037 750 Series 2003-present 745 / 45.2 OHV 12-Volt Not Used (electric-start) M-72 1952-56 746 / 45.3 SV 6-Volt Not Used M-72N 1956-59 746 / 45.3 SV 6-Volt Not Used K-750 1959-63 746 / 45.3 SV 6-Volt Not Used K-750M 1963-77 746 / 45.3 SV 6-Volt Not Used MB-750 1964-73 746 / 45.3 SV 6-Volt Not Used K-650/MT-8 1967-70 649 / 39.4 OHV 6-Volt Used on Later K-650 s MB-650 1976-84 649 / 39.4 OHV 12-Volt 46.3710 K-650/MT-9 1971-74 649 / 39.4 OHV 6-Volt Not Used Dnepr MB-750M 1973-77 746 / 45.9 SV 6-Volt Not Used MT-10 1973-76 649 / 39.4 OHV 12-Volt 46.3710 MB-650M 1985-91 649 / 39.4 OHV 12-Volt Not Used MT-10.36 1975-87 649 / 39.4 OHV 12-Volt 46.3710 MT-12 (Dnepr-12) 1974-85 746 / 45.3 SV 6-Volt Not Used MT-11 (Dnepr-11) 1985-1995 649 / 39.4 OHV 12-Volt 46.3710 MT-16 (Dnepr-16) 1986-1995 649 / 39.4 OHV 12-Volt 46.3710 8
Table VI: IMZ (ИМЗ) - Ural (Урал) Electric s Model Year Engine Size Voltage Signal M-72 1942-56 750cc 6-Volt SM-01 or SM-02, C-35 (72186-A1) after 1950, C-37A (72186-A3) M-72K 1954-60 750cc 6-Volt C-37 M-72M 1956-60 750cc 6-Volt C-37 M-61 1958-60 650cc 6-Volt C-37A (72186-A3) M-62 1961-65 650cc 6-Volt C-37A (72186-A3) M-63 (Ural-2) 1965-68 650cc 6-Volt C-37A (72186-A3) M-66 (Ural-3) 1968-72 650cc 6-Volt C-37A (72186-A3) M-67 1973-75 650cc 12-Volt C-205B, C-38A M-67.36 1976-95 650cc 12-Volt C-205B 8.103 and 8.107 Series 650 1994-98 650cc 12-Volt C-205B (IMZ 8.101-186006-20, 3721000), C-304 8.103, 8.103X, 8.123, 8.123X, 650 & 750 Series 1999-2003 750cc 12-Volt C-205B, C-304 (20.3721000-09) 8.103,8.103X, 8.123,8.123X, 750 Series 2004-2006 750cc 12-Volt IMZ 8.101-18006-2, 8.101-18006-20 2007-present 750cc 12-Volt LEBK91- White Zinc or Black Table VII: KMZ (KMЗ) - Dnepr (Днепр) Electric s Model Year Engine Size Voltage Signal M-72 1952-56 750cc 6-Volt C-35A (72186-A1) M-72N (H) 1956-59 750cc 6-Volt C-35, C-35A K-750 Early 1956-60 Later 1960-63 750cc 6-Volt C-35A, C-37A (72186-A3) C-35, C-35A, C-37 (72186), C-37A K-750M 1963-77 750cc 6-Volt C-37A (72186-A3) MB-750 1964-73 750cc 6-Volt C-37A (72186-A3) MB-750M 1973-77 750cc 6-Volt C-37A (72186-A3) K-650/MT-8 1967-70 650cc 6-Volt C-37, C-37A (72186-A3) K-650/MT-9 1971-74 650cc 6-Volt C-37, C-37A (72186-A3) MB-650 1976-84 650cc 12-Volt C-205B (3721000) / C-304 (3721000) MB-650M 1985-91 650cc 12-Volt C-304 MT-10 1973-76 650cc 12-Volt C-38 MT-10.36 1975-87 650cc 12-Volt C-38 MT-12 (Dnepr-12) 1974-82 2WD, 1982-85 1WD 750cc 6-Volt C-204B MT-11 (Dnepr-11) 1985-1995 650cc 12-Volt C-205B (3721000) / C-304 (3721000) MT-16 (Dnepr-16) 1986-1995 650cc 12-Volt C-205B (3721000) / C-304 (3721000) 9
Motorcycle Figure 1A: 6-Volt Electrical Systems Generator Regulator Ignition Coil Breaker/Distributor Ural: M-72, M-72M, M-61 Dnepr: M-72, M-72N PP-1 (1941) KIM-01 Г-11/11A: 45 W (1941/1952) Ural: M-62, M-63, M-66 Dnepr: K-750, K-750M, MB-750, MB-750M, K-650, MT-9, MT-12 PP-30 PP-31/PP-31A (1950/1956) UG-4085B (1950) and B-11 B-2Б PM-05 (1954) (with manual spark advance) PM-11A or PM-301/PM-302/PM-302A (with automatic spark advance) Г-414: 65 W (1957) PP-302/302A (1963/197X) B-201/B-201A 10
Motorcycle Ural: M-67, M-67.36, IMZ 8.103 Series Dnepr: MB-650, MT-10, MT-10.36, MT-11, MT-16 Figure 1B: 12-Volt Electrical Systems Alternator Regulator Breaker - Ignition Coil (Relay-Regulator) PP-330 (1941) B-204A PM-302/PM-302A Г-424: 150 W (1974) Contact-less Type I Type III Ural: IMZ 8.103 Series (1999-2003) Dnepr: None 33.3702 (1992) Type II 14.3771: 500 W (1999) Ural: IMZ 8.1037 Series (2004-present) Dnepr: None Nippon Denso: 770 W (2004) Internal to Alternator (JYA212A11E) Internal to Alternator Ducati (2006) Type V Type IV Raceway Services Power Arc 11
Simplified Diagram of Early Wiring Turn Signal Ignition Hand Brake-Light Voltage Regulator Headlight Charge Indicator Neutral Sensor And Indicator Foot Brake-Light Brake Light Flasher Unit Generator Negative Ground Master Ground Ignition Turn Signal Button Ignition Coil Spark Plugs Battery Directional Turn- Breaker Points 12
Dnepr (Днепр) M-72 Button Light Generator (G-11A) Breaker/Distributor (PM-05) Я Ш Lights Ignition Coil (KM-01) Regulator (PP-31) Battery Positive Ground 13
Dnepr (Днепр) M-72 1 - Generator: Г-11A 2 - Voltage Regulator: PP-31 3 - Rechargeable battery 4 - Distributor 5 - Breaker: PM-05 6 - Ignition Coil: KM-01 or B-2B 7 - Spark plugs (candles) 8-9 - Lamp 10 - Driving Lamp and Low Beam 11 - Parking Light Bulb 12 - Tail Light 13 - Sidecar Tail Light 14 - Sidecar Front Light 15 - Control Lamp 16 - Central 17 - Key 18 - Safety 19 - Beam and Dipped Beam 20 - Lever Hi/Lo Beam 21 - Button 22 - Ignition Retard/Advance Lever 23 - Fuse Lamps 24, 25 and 26 - High-Voltage Wires 27, 28, 29 and 30 - Bundle of Low-Voltage Wires 31 and 32 Sidecar lamp Wires Manual Spark Advance Hi/Lo Beam Spark Plug (candle) Positive-Ground Battery Breaker/Distributor (PM-05) Generator (Г-11A) Spark Plug (candle) Ignition Coil Regulator (PP-31) 14
Dnepr М-72, М-16, К-750, К-750М, and МТ-12 1 - Turn signal switch P-201 (П-201) 2 - Right front turn indicator on Solo 3 - Breaker for turn indicator РС-419 4 - Headlight A6-32 + 21 or А6-32 + 32 5 - Parking lamp in headlight 6 - Left turn indicator 7 - Breaker PM-05 (ПМ-05) 8 - Light switch (in headlight cavity) 9 - Ignition timing cable 10 - Light switch 11 - Ignition timing 12 - Fuse 15A 13 - M-72 and K-750 has a slightly different designation of terminals) 14 - Lamp A6-2 illumination of the scale of the speedometer 15 - Generator 16 - Control lamp of generator A6-0.25 17 - Ignition coil KM-01 or B-2B (Б- 2б) 18 - Distributor 19 - Right sidecar turn indicator 20 - Sidecar front marker light 21 - Lamps A6-15 stop lamps (only in FP-230 or FP-246) 22 - Battery ЗМТ-6 or ЗМТ-7 (ZMT-6 or ZMT-7) 23 - Right rear turn indicator on Solo 24 - Relay-controller 25 - Stop-light switch 26 - Lamps for rear lights 27 - Signal horn C-35 28 - button 15
Dnepr (Днепр) M-72 (1955) (www.oldtimergarage.szn.pl) Speedometer Advance/Retard Lever Regulator (PP-31) Hi/Lo Beam Generator (Г-11A) (C-35A) Ignition Coil (KM-01) Breaker/Distributor (PM-05) Battery (3MT-7) 16 Spark Plug Spark Plug
17
Dnepr (Днепр) Early K-750 12. 10. Ignition Coil (B2Б) 23. Breaker/Distributor (PM-05) Generator (Г-11A) 16. Foot Brake-Light Hi/Lo Beam 25. Button 19. Battery 17. Voltage Regulator (PP-31A) 18
Dnepr (Днепр) K-750 Ignition Coil (KM-01 or B2Б) Breaker/Distributor (PM-05) Battery Hi/Lo Beam 19
Dnepr (Днепр) K-750 1. Turn Signal (П201) 4. Headlight (A6-32+21 or A6-32+32) 3. Flasher Unit (PC419) 12. Fuse (15A) 15. Generator (Г-414) 22. Battery (3MT-6 or 3MT-7) 25. Foot Brake-Light 24. Voltage Regulator (PP-302) 27. (C-35) 10. Hi/Lo Beam 17. Ignition Coil (KM-01 or B2Б) 11. Manual Spark Advance/Retard Button 7./16. Breaker/Distributor (PM-05) 20
Dnepr (Днепр) K-750 Wiring Diagram 21
1960? kmz k750 Rough Diagram 22
Dnepr (Днепр) Early K-750 with Manual (PM-05) Ignition Battery Generator (Г-414) Voltage Regulator (PM-302) Hi/Lo Beam Dimmer Button Breaker/Distributot (PM-05) Ignition Coil (B2Б) 23
Dnepr (Днепр) Early K-750 with PM-05 Breaker/Distributor and B2B Ignition Coil Turn Signal Battery 3T-6 or 3MT-7 Generator (Г-414) Ignition Coil (B2Б) Breaker/Distributor (PM-05) 1 - switch indicators P-201 11 - Shifters Ignition 21 - Lamp A6-15 stop-signals (only in the lamp, or OP-230 OP-246) 2 - The right front indicator lamp on a motorcycle-alone 12 - fuse 15A 22 - battery 3MT-6 or 3MT-7 3 - Flasher PC-419 13 - central switch (on M-72 & K-750 slightly different notation terminals) 23 - right rear indicator lamp on motorcycle-alone 4 - lamp head light headlamp A6-32, 21 or A6-32 +32 14 - bulb illumination A6-2 scale speedometer 24 - relay-regulator 5 - parking light bulb headlights 15 - generator 25 - stop light switch 6 - Left direction indicators 16 - control lamp of the generator A6-0.25 26 - headlight rear position lamps 7 - chopper PM-05 17 - ignition coil KM-01 or B-2B 27 - horn C-35 8 - light switch (located in the housing headlights) 18 - Splitter 28 - horn button 24 9 - cable Shifters Ignition 19 - Indices turning right (sidecar) 10 - lever light switch 20 - front position lamp sidecar
K-750 and MB-750 Headlight Cavity Ground masse Parking Light Fuse Ignition On/Off Contacts Hi/Lo Dual-Beam Lamp Ignition Key Generator Charge Lamp Hi/Lo Dimmer 25
26
Dual- Filament Headlight. Headlight Cavity Ignition Shown in Off Position. K-750 Headlight Cavity Fuse protects the Hi/Lo beam, parking and rear bike/sidecar lamps Ignition Fuse (8-Amp in Ural, 15-Amp in Dnepr). Б Master Run to Ignition Coil Terminal from Battery Terminal and Б Terminal of Voltage Regulator Master Shown in Off Position to Rear Bike and Sidecar Lights Speedometer Backlight Parking Lamp. CC Park Generator Charge (Red) to Rear Brake Light Foot (in later K-750 s) Ground Mass. Hi/Lo Beam Slider to Я Terminal of Г-11 Generator and PP-1 Voltage Regulator Mechanical Linkage (Bowden Cable) to Left Handlebar Lamp Ground Central ignition switch supplies 6-Volts to the bike/sidecar lamps and either the hi/lo beam lamp or the parking light. The ignition switch also supplies energy to the generator field coil, ignition coil 27 and voltage regulator.
K-750 and MB-750 Headlight Cavity Ground masse Parking Light Fuse Ignition On/Off Contacts Hi/Lo Dual-Beam Lamp Ignition Key Generator Charge Lamp Hi/Lo Dimmer 28
Dnepr (Днепр) Early K-750 (with Ignition Coil B2B and Distributor PM-05 for Manual Control of Firing Angle) Ignition Coil (B-2B) Breaker/Distributor (PM-05) Generator (Г-11A) Foot Brake-Light Button Battery Hi/Lo Beam Regulator (PP-31A) 1 - lamp beam and dipped beam, 2 - key 3 - safety 4 - lamp, 5 - central switch, 6 - wire ground", 7 - high voltage wire, 8 spark plugs, 9 - high voltage 10 - ignition coil, 11 - front light stroller, 12 horn, 13 - wire front canopy sidecar, 14 - tail light sidecar, 15 - tail lamp of motorcycle, 16 - gauge stoplight, 17 - Relay-regulator, 18 generator, 19 battery, 20 - Low voltage wiring loom, 21 - the wire "battery ground, 22 - breaker, 23 - valve, 24 - high voltage wire and 25 - button signal 26 - wire signal 27 - advance ignition; 28 - cord switch driving and parking light, 29 - switch to driving and parking light, 30 29- control lamp, 31 - the parking light bulb, 32 - lamp illuminated; 33 - Connecting Jack wires, 34 - cable sidecar lamps, 35 - wire from the sensor to Stop lamp, 36 - wire from the connector to the lamp lighting plate
Dnepr (Днепр) Early K-750 (with PP-31 Voltage Regulator, PM-05 Breaker/Distributor and B2B Ignition Coil) Speedometer Advance/Retard Lever Hi/Lo Beam Regulator (PP-31A) Ignition Coil (B2Б) Generator (Г-11A) (C-37) Breaker/Distributor (PM-05) Spark Plug Battery (3MT-7) 30 Spark Plug
Dnepr (Днепр) Early K-750 31
Dnepr (Днепр) Later K-750 (with Breaker PM-302, Voltage Regulator PP-31A and Ignition Coil B201 for Automatic Control of Firing Angle) Oil-Pressure Sensor (MM-106A) Breaker/Distributor (PM-302) Ignition Coil (B201) Generator (Г-414) Foot Brake-Light Battery Button Hi/Lo Beam Regulator (PP-31A) 32
Dnepr (Днепр) Later K-750 with PP-302 Regulator, PM-05 Breaker/Distributor and B2B Ignition Coil Trouble-Light Socket Speedometer Advance/Retard Lever Trouble-Light Hi/Lo Beam (C-37) Ignition Coil (B-2B) Generator (Г-414) Regulator (PP-302) Breaker/Distributor (PM-05) Spark Plug Alternate Rear Brake-Light (ВК-854Б) Spark Plug Battery Rear Brake-Light (65018950) 33
Dnepr (Днепр) Early K-750M (with Ignition Coil B2B and Distributor PM-05 for Manual Control of Firing Angle) Ignition Coil (B2Б) Button Breaker/Distributor (PM-05) Battery Generator (Г-11A) Foot Brake-Light Hi/Lo Beam Regulator (PP-31A) 1 - lamp beam and dipped beam, 2 - key 3 - safety 4 - lamp, 5 - central switch, 6 - wire ground", 7 - high voltage wire, 8 spark plugs, 9 - high voltage 10 - ignition coil, 11 - front light stroller, 12 horn, 13 - wire front canopy sidecar, 14 - tail light sidecar, 15 - tail lamp of motorcycle, 16 - gauge stoplight, 17 - Relay-regulator, 18 generator, 19 battery, 20 - Low voltage wiring loom, 21 - the wire "battery ground, 22 - breaker, 23 - valve, 24 - high voltage wire and 25 - button signal 26 - wire signal 27 - advance ignition; 28 - cord switch driving and parking light, 29 - switch to driving and parking light, 30 34- control lamp, 31 - the parking light bulb, 32 - lamp illuminated; 33 - Connecting Jack wires, 34 - cable sidecar lamps, 35 - wire from the sensor to Stop lamp, 36 - wire from the connector to the lamp lighting plate
Dnepr (Днепр) Early K-750M 1. Turn Signal (П201) 4. Headlight (A6-32+21 or A6-32+32) 3. Flasher Unit (PC419) 12. Fuse (15A) 15. Generator (Г-414) 22. Battery (3MT-6 or 3MT-7) 25. Foot Brake-Light 24. Voltage Regulator (PP-302) 27. (C-35) 10. Hi/Lo Beam 17. Ignition Coil (KM-01 or B2Б) 11. Manual Spark Advance/Retard Button 7./16. Breaker/Distributor (PM-05) 35
Dnepr (Днепр) Early K-750M (with PM-05 Breaker/Distributor and B2Б Ignition Coil) Turn Signal Battery 3T-6 or 3MT-7 Generator (Г-414) Ignition Coil (B2Б) Breaker/Distributor (PM-05) 1 - indicators P-201 11 - Shifters Ignition 21 - Lamp A6-15 stop-signals (only in the lamp, or OP-230 OP-246) 2 - Right front indicator lamp on a motorcycle-alone 12 - Fuse 15A 22 - Battery 3MT-6 or 3MT-7 3 - Flasher PC-419 13 - Central switch (on M-72 & K-750 slightly different notation terminals) 23 - Right rear indicator lamp on Bike-alone 4 - Lamp head light headlamp A6-32, 21 or A6-32 +32 14 - Bulb illumination A6-2 scale speedometer 24 - Relay-regulator 5 - Parking light bulb headlights 15 - Generator 25 - Stop light switch 6 - Left direction indicators 16 - Control lamp of the generator A6-0.25 26 - Headlight rear position lamps 7 - Chopper PM-05 17 - Ignition coil KM-01 or B-2B 27 - C-35 8 - Light switch (located in the housing headlights) 18 - Splitter 28 - button 36 9 - Cable Shifters Ignition 19 - Indices turning right (sidecar) 10 - Lever light switch 20 - Front position lamp sidecar
Dnepr (Днепр) Early K-750M (with PM-05 Breaker/Distributor and B2Б Ignition Coil) Breaker/Distributor (PM-05) Battery Hi/Lo Beam 37
Dnepr (Днепр) K-750M Speedometer Advance/Retard Lever Hi/Lo Beam (C-37) Ignition Coil (B-2Б) Generator (Г-414) Regulator (PP-302) Spark Plug Battery (3MT-6) Spark Plug Breaker/Distributor (PM-05) Rear Brake-Light (65018950) 38
K-750M with PM-05 Ignition and Handlebar Control 1. Hi/Lo Beam Lamp 6. Ground Wire 35. Parking Light Hi/Lo Dimmer in Headlight Cavity 28. Hi/Lo Beam Lever 26. Button to Signal 1. Light Beam and Low Beam, 2. Key, 3. Fuse, 4. Lamp, 5. Master, 6. Ground Wire, 26. Signal 39 Button, 27. Signal Wire, 28. Hi/Lo Beam Lever, 29. Cable for Hi/Lo Light, 30. Driving and Parking Light 31. Warning Light 32. Parking Light Bulb 33. Backlight Speedometer
Dnepr (Днепр) Early К-750М (with PM-05 Breaker/Distributor and B2Б Ignition Coil) 40
MB-750 (with PM-05 Breaker/Distributor and B2B Ignition Coil) (Note that turn indicators were not in use until MT-9/MT-10) 41
Dnepr (Днепр) Early MB-750 with Manual Ignition (with PM-05 Breaker/Distributor and B2Б Ignition Coil) Battery Generator (Г-414) Voltage Regulator (PM-302) Hi/Lo Beam Dimmer Button Breaker/Distributot (PM-05) Ignition Coil (B2Б) 42
Dnepr Early MB-750 (with PM-05 Breaker and B2Б Ignition Coil) 43
Dnepr Early MB-750 (with PM-05 Breaker and B2Б Ignition Coil) Part number Part name Part number Part name 019 205 Bolt to relay control 7218419 Bush mounting bolts lights 201 418 Bolt M6x16 fixing glass to the bar 7218469 Gasket bolt washers 7218469 Gasket bolt washers 7218471 Tube wiring lights 201 474 Bolt to the rear panel to the frame 7218478-A Ignition key 221 511 Screw mounting socket M3h25 72185 Combined coin ignition, signal and light switch 250 508 Screw nut bracket plate 72186-AZ Signal motorcycle-37 250 613 Axle nut rear brake lever 7218802 Tip cap wires 250 763 Nut screws tail light 7218806-A Cord bush 252 153 Spring washer screws tail light 7218812 High voltage to the spark plug cylinder 252 153 Spring washer screws tail light 7218812 High voltage to the spark plug cylinder 252 154 Spring washer bracket plate 7218815-B High voltage wire spool - distributor 252 155 Spring washer to rear panel frame 7218817-B High voltage wire spool - splitter assembly 366 301 Screw fixing the wires in tconnector 7218818 Lock wire holder 47K Socket 7218819 Ribbon Cable holder 5318715-A Gasket tail light 7218865 Insulating cap terminal signal 5318811 Spark with resistance 7218936 Warning lamp A6-0, 25 5318909-A Protective cap 72N173 Candle glow A8U 5318931 Lamp A6-6 750 179 Flexible shaft HS-127 5318933 Lamp A6-3 750 181 Generator G414 650 174 Speedometer SP102 750 182 Rechargeable battery ZMT12 65017401 Foot mount speedometer 750 183 Relay-regulator RR302 650180 Ignition coil B2B 750 183 Relay-regulator RR302 65018303 Laying relay control 75018446 Wire from the main switch to the light switch 650184-B Headlamp with speedometer & wires 75018447 Wire from the switch to the central lamp headlights (low beam) 650184-B Headlight assembly FG116 75018448 Wire from the switch to the central lamp lights (headlight) 650 188-13B Cross wire brake and tail lights 75018501 Outlet cap 65018810 A6-2 lamp with holder & wire asbly 75018502 Battery cable - socket 65018820 Connector wiring tail lights 75018505 Portable lamp PLTM 65018821 Connector body 75018708 Socket assembly 65018901 Lamp A6-32 +32 750 188 Rear motofonar FP220 65018950 Brake sensor 750188-1 Cross wire spool and signal 72172 Distributor PM05 750188-11 Wire spool - breaker 72177-B Lamp A6-2 750188-12 Wire battery - weight 7218302 Relay plate - weight 750188-14 Wire button - the signal 7218405-A Cable cover light switch 750188-2 Cross drives generator, brake, relay control, battery & rear light 7218414 O-ring speedometer 75018801 Bush lights 75018805 Coupling 75018814 Insulating cover terminals 44
Dnepr (Днепр) Early MB-750М (with PM-05 Breaker/Distributor and B2B Ignition Coil) 45
MB-750M (Note that turn indicators were not in use until MT-9/MT-10) 46
Dnepr (Днепр) Early K-650 (with PM-05 Breaker/Distributor and B2B Ignition Coil) Breaker/Distributor (PM-05) Ignition Coil (B-2Б) (C-37A) Oil-Pressure Sensor (MM-106A) Generator (Г-414) Voltage Regulator (PP-302) Battery Hi/Lo Beam Button 47
Dnepr (Днепр) Early K-650 (with PM-05 Breaker System and B2Б Single-Output Ignition Coil) 48
Dnepr (Днепр) Early K-650 (with PM-05 Breaker System and B2Б Single-Output Ignition Coil) 1. Headlight (A6-32+32) brn blk 8. Oil-Pressure Sensor (MM106A) Turn Signal vio yel grn blk vio 14. Spark Plug 16. Distributor/Breaker (PM-05) blk blk Generator (Г-414) 17. Ignition Coil (B2Б) blk gry blk blk vio blk gry 22. Foot Brake-Light wht Flasher blu red yel 32. Green Neutral Indicator blu 30. Neutral sensor wht 14. Spark Plug 25. Battery 23. Voltage Regulator (PP-302) wht grn blk blu wht gry 29. Advance/Retard Lever 49
Dnepr (Днепр) Later K-650 / MT-8 (with PP-302 Regulator, PM-302 Breaker and B201 Ignition Coil) Voltage Regulator (PP-302) Flasher Foot Brake-Light Battery (3MT-12) Generator (Г-414) Ignition Coil (B-201) Turn Signal Button Breaker (PM-302/PM-302A) 50
Dnepr (Днепр) Later K-650 / MT-8 (with PP-302 Regulator, PM-302 Breaker and B201 Ignition Coil) 51
Dnepr (Днепр) Later K-650 / MT-8 (with PP-302 Regulator PM-302 Breaker and B201 Ignition Coil) Turn Signal Oil Pressure Sensor Generator (Г-414) Battery (3MT-12) Voltage Regulator (PP-302) Flasher Foot Brake-Light Ignition Coil (B-201) Breaker (PM-302/PM-302A) 52
Dnepr (Днепр) Later K-650 (with PP-302 Regulator, PM-302 Automatic Breaker and B201 Ignition Coil) Voltage Regulator (PP-302) G-414 Generator PP-302 Regulator B201 Ignition Coil PM-302 Breaker 3MT-12 Battery Ignition Coil (B-201) Breaker (PM-302/PM-302AA) Generator (Г-414) Battery 53
Dnepr (Днепр) Early MT-9 (with PM-05 Breaker/Distributor and B2Б Ignition Coil) Breaker/Distributor (PM-05) Ignition Coil (B-2Б) (C-37A) Oil-Pressure Sensor (MM-106A) Generator (Г-414) Voltage Regulator (PP-302) Battery Hi/Lo Beam Button 54
Dnepr Early MT-9: Early Manual Control of Firing Angle (B2Б Ignition Coil and PM-05 Breaker/Distributor) 8. Oil-Pressure Sensor 6. Oil-Pressure Indicator (PD20) 1. Lamp (A6-32+32) 7. Lamp (A6-1) Turn Signal 16. Breaker/Distributor (PM-05) Ignition Coil (B-2B) Foot Brake-Light Flasher Battery Button Hi/Lo Beam 55
Early MT-9 with Manual (PM-05) Spark Advance (Dimmer in Headlight Cavity) 34. ПереключателЬ Света П45 (Handlebar Light Dimmer P-45) 18. 16. PM-05 Manual Spark Advance 27. Button 29. Hi/Lo Beam Lever 56
Early Dnepr MT-9 (with Manual Timing) Right Handlebar Control (П201) Oil-Pressure Sensor (MM-106A) Left Handlebar Control (П45) Neutral Sensor (MT804517) Generator (Г-414) Ignition Coil (B2Б) Breaker/Distributor (PM-05) Regulator (PP-302) Foot Brake-Light (ВК-854) 57
Dnepr (Днепр) Later MT-9 (with PP-302 Regulator, PM-302 Breaker, and B201 Ignition Coil) Turn Signal Oil Pressure Sensor Generator (Г-414) Battery (3MT-12) Voltage Regulator (PP-302) Flasher Foot Brake-Light Ignition Coil (B-201) Breaker (PM-302/PM-302A) 58
Dnepr (Днепр) MT-9: Later Automatic Control of Firing Angle (B-201A Ignition Coil and PM-302 Breaker) Oil-Pressure Sensor Turn Signal Breaker Points (PM-302/PM-302AA) Ignition Coil (B-201) Foot Brake-Light Flasher Battery Button 59
Dnepr Later MT-9 with Automatic Advance Timer 60
Later MT-9 with Automatic (PM-302) Spark Advance (Dimmer in Handlebar Control, No Spark Advance Lever) 30. Neutral Position Pick-Up (Contact Plug) Later MT-9 headlight assemblies contained a neutral sensor and indicator lamp. 61
Later MT-9 (with Automatic Timing) (B201 Ignition Coil and PM-302 Breaker/Distributor) Right Handlebar Control (П201) Oil-Pressure Sensor (MM-106A) Left Handlebar Control (П25A) Neutral Sensor (MT804517) (C-37A) Breaker/Distributor (PM-302) Generator (Г-414) Regulator (PP-302) Ignition Coil (B-201A) Foot Brake-Light (ВК-854) 62
Dnepr MT-9 Early Headlight Assembly ФГ-116 (with Manual Spark Advance PM-05 and Light ) Fuse Ignition Key Speedometer Dual-Filament Headlight Parking Light Bowden Cable from Spark Advance / Retard Handlebar Control Lever Flasher Unit The early MT-9 headlight assembly (ФГ116) contained a hi/lo beam switch. 63
Headlight Assembly Фара ФГ-116 (FG-116) in a Dnepr K-650 Central 1. Master 2. Speedometer / Odometer 3. Cavity Body 4. Lamp Holder and Hi/Lo Beam Lamp 5. Flexible Shaft Speedometer Cable 6. and 7. Bundles of Wires 8. Parking Light Bulb Socket 9. Lamp Holder 10. Lens 11. Dual Filament (Hi/Lo) Beam Lamp 12. Reflector 13. Ring (rim) of Lens and Reflector 64
Later K-650, with Hi/Lo Beam Dimmer in Handlebar, and not in Headlight Cavity 4. Oil-Pressure Alarm 7. Oil-Pressure Sensor 1. Hi/Lo Beam Lamp 26. Speedometer Lamp 28. Parking Light 27. Generator Alarm Light 25. Hi/Lo Beam Lever 24. Button 65
Dnepr MT-9 Later Headlight Assembly ФГ-116 Fuse Ignition Key Speedometer Dual-Filament Headlight Parking Light Flasher Unit The later MT-9 headlight assembly (ФГ-116), with the removal of the 66 spark advance / retard control, used an external hi/lo beam switch.
Dnepr MT-9 Master Schematic (IggyMo on Dneprheads) П (56) З/С (15) СС (55) Generator Charge Light ЛС Fuse Я (61) Ф (58) Б (30/51) 67
Dnepr (Днепр) MT-12 68
Dnepr (Днепр) MB-750 Speedometer Advance/Retard Lever Trouble-Light Socket Trouble-Light Hi/Lo Beam (C-37) Ignition Coil (B-2B) Generator (Г-414) Voltage Regulator (PP-302) Distributor/Breaker (PM-05) Spark Plug Battery (3MT-12) Alternate Rear Brake- Light (ВК-854Б) Spark Plug Rear Brake-Light (65018950) 69
Dnepr (Днепр) Later K-650 / MT-8 Speedometer Voltage Regulator (PP-302) Ignition Coil (B-201) Generator (Г-414) Battery (3MT-12) Rear Brake-Light (65018950) Breaker (PM-302/PM-302A) Spark Plug 70
Dnepr (Днепр) MT-9 with Manual Control of Firing Angle (B-2B Ignition Coil and PM-05 Breaker/Distributor) Speedometer Oil-Pressure Sensor (MM-106A) Regulator (PP-302) Generator (Г-414) (C-37) Ignition Coil (B-2B) Spark Plug Spark Plug Rear Brake-Light (ВК-854Б) 71
Dnep (Днепр) MT-9 with Automatic Control of Firing Angle (B-201A Ignition Coil and PM-302 Breaker) Speedometer Oil-Pressure Sensor (MM-106A) Generator (Г-414) (C-37) Breaker (PM-302) Voltage Regulator (PP-302) Ignition Coil (B-201) Rear Brake-Light (ВК-854Б) 72 Spark Plug Spark Plug
Dnepr (Днепр) MB-650 Oil-Pressure Sensor Turn Signal Breaker (PM-302/PM-302A) Ignition Coil (B-204) Alternator (Г-424) Foot Brake-Light Flasher Battery Button Voltage Regulator (PP-31A) 73
Dnepr Later МВ-650 27. Lamp (А12-21) 30. Lamp (А12-21+6) 9. Central (ВК-857) 7. Turn Light (УП-223) 13. Turn (П201) 15. Foot Brake-Light (ВК-854) 16. Tail Light (ФП-219) 27. Lamp (А12-21) 10. Flasher (РС427) 27. Lamp (А12-21) 5. Headlight (ФГ-137) 29. Lamp (А12-45+40) 32. Lamp (А12-1) 11. Oil Pressure Sensor (ММ125) 18. Battery (ЗМТ-6) 7. Turn Light (УП-223) 31. Lamp (А12-3) 27. Lamp (А12-21) 28. Lamp (А12-4) 17. Voltage Regulator (РР-330) 27. Lamp (А12-21) 7. Turn Light (УП-223) 5. (C-38) 21. Alternator Г-424 7. Turn Light (УП-223) 27. Lamp (А12-21) 4. Ignition Coil (Б-204) 14. Headlight (ПФ-232) 19. Fuse Block (ПР-118) 20. Rear Light Cluster (ФП-246) 3. Breaker (ПМ-302У or ПМ-304) 74
Dnepr (Днепр) Early MB-650 (with PP-330 (relay) Voltage Regulator) Oil-Pressure Sensor (MM-126) Neutral Sensor (MT804517A) Speedometer Front Brake-Light (13.3720) Alternator Г-424 Voltage Regulator (PP-330) Ignition Flasher (PC-427) Fuse Block (C-304) Spark Plug Trouble-Light Socket & Cover Rear Brake-Light (ВК-854Б) Trouble-Light Battery (6MTC-9) 75
Speedometer Dnepr (Днепр) Later MB-650 (with 33.3072 (solid-state) Voltage Regulator) Front Brake-Light (13.3720) Oil-Pressure Sensor (MM-126) Alternator Г-424 Voltage Regulator (33.3702) Rear Brake-Light (ВК-854Б) Ignition (141.3704) Flasher (PC-427) Fuse Block Ignition Coil B-204 Breaker (PM-302A) Spark Plug Trouble-Light Socket & Cover (C-205B/C-304) Turn Signal Headlight Assembly (ФГ=137) Trouble-Light Battery (3MTS-9) 76
Ignition Lock: ВК-857 Dnepr (Днепр) MB-650M Lamp A12-21 Lamp A12-8 Lamp A12-21 Lamp A12-21+6 Turn M-201 Foot Brake- BK-854 Oil Pressure Sensor MM-126 Neutral Regulator PP-330 Lamp A12-45+40 Lamp A12-4 Master BK-857 Lamp ПД20Д Lamp ПД20Е Flasher PC-427 Lamp ПД20Е Lamp A12-1 Lamp A12-1 Lamp A12-1 C-304 Spark Plug A14B Trouble-Lamp Socket Battery 3MT-6 Fuse Holder ПР-11B Lamp A12-21 Lamp A12-3 Lamp A12-21 Alternator Г-424 Lamp A12-21 Ignition M-25 Ignition Coil B-204 Breaker PM-302A Spark Plug A14B 77
Turn Signal Dnepr (Днепр) MT-10 Flasher Battery (2X 3MT-6) Oil-Pressure Sensor Master Foot Brake-Light Neutral Voltage Regulator (PP-330) Button Ignition Coil (B-204) Alternator (Г-424) Breaker (PM-302/PM-302A) 78
Dnepr (Днепр) Later MT-10 Right Turn 16. Turn Signal 17. Flasher Unit 21. Front Sidecar Light 7. Speedometer 9. Turn-Signal Indicator 10. Emergency Oil Pressure 11. High-Beam Headlight Indicator 23. Fuse Block 26. Voltage Regulator (PP- 330) 27. Foot Brake-Light 15. Central 13. Neutral Transmission Indicator 12. Generator 19. Oil-Pressure 24. Indicator Sensor Alternator 18. Neutral Sensor and Indicator 20. Light 28. Master Battery Ground 29. Battery (2X 3MT-6) 36. Brake Light Left Turn 25. 30. Breaker 31. Ignition Coil 1. Left Turn 79 34. Spark-Plug
7. Lamp (A12-21) 1. Turn Signal (П-201) 3. Lamp (A12-1) 4. Lamp (A12-45+40) 5. Lamp (A12-4) Dnepr (Днепр) Later MT-10 2. Flasher 19. Neutral (A12-1) Button 12. Fuse Battery (15A)(2X 3MT-6 or 6MTTS-9) 13. Turn (A12-1) 14. Oil (A12-1) 15. Hi/Lo (A12-1) 18. Neutral Sensor 20. (C-38) 9. Lamp (A12-21) 10. Lamp (A12-21) 16. Charge (A12-1) 17. Oil-Pressure Sensor 28. Master Battery Ground 31. Foot Brake-Light 22. Regulator (33.3702) 23. Alternator (Г-424) 26. Lamp (A12-21+5) 9. Lamp (A12-21) 29. Lamp (A12-21) Brake 30. Lamp (A12-5) 7. Lamp (A12-21) 8. Hi/Lo Beam (П-201) 21. Ignition Coil (B-204) 25. Breaker (PM-302A) 80
Dnepr (Днепр) Later МТ-10 (roker.kiev.ua) 1 - Left turn signal lamp 2 - Lamp A12-21 3 - Light 4 - Lamp A12-4 marker and parking light 5 - Lamp A12-45-40 and low beam 6 - Right turn signal lamp (on motorcycle and sidecar is not connected) 7 - Speedometer 8 - A12-1 lamp lighting speedometer 9 - Lantern warning lamp turn indicators 10 - Warning lamp lantern oil pressure 11 - Lamp driving lamp control 12 - Lamp warning lamp generator 13 - Lantern lamp control sensor neutral 14 Dash 15 - Central switch 16 - Turn signal switch 17 Flasher 18 - Plug contact 19 - Oil pressure sensor 20 - Light switch 21 - Front lantern carriages 22 - Lamp A12-21 marker light and sidecar brake; 23 - Fuse box, 24 - Generator, 25 Signal, 26 - Relay Controller, 27 - Brake light switch, 28 -, 29 Battery, 30 Breaker, 31 Ignition coil, 32 - High voltage wire, 33 Spark plug 81 tip, 34 - Spark plug, 35 Sidecar taillight, 36 Motorcycle lamp, 37-15 Signal Lamp A12 inhibition, 38 - Lamp A12-3 dimensional light license plate light
Dnepr (Днепр) Later MT-10 82
Dnepr (Днепр) Later МТ-10 27. Lamp (А12-21) 30. Lamp (А12-21+6) 9. Central (ВК-857) 7. Turn Light (УП-223) 13. Turn (П201) 15. Foot Brake-Light (ВК-854) 16. Tail Light (ФП-219) 27. Lamp (А12-21) 10. Flasher (РС427) 27. Lamp (А12-21) 5. Headlight (ФГ-137) 29. Lamp (А12-45+40) 32. Lamp (А12-1) 11. Oil Pressure Sensor (ММ125) 18. Battery (ЗМТ-6) 7. Turn Light (УП-223) 31. Lamp (А12-3) 27. Lamp (А12-21) 28. Lamp (А12-4) 17. Voltage Regulator (РР-330) 27. Lamp (А12-21) 7. Turn Light (УП-223) 5. (C-38) 21. Alternator Г-424 7. Turn Light (УП-223) 27. Lamp (А12-21) 4. Ignition Coil (Б-204) 14. Headlight (ПФ-232) 19. Fuse Block (ПР-118) 20. Rear Light Cluster (ФП-246) 3. Breaker (ПМ-302У or ПМ-304) 83
Dnepr (Днепр) Early MT-10 Oil-Pressure Sensor Turn Signal Breaker (PM-302/PM-302A) Ignition Coil (B-204) Alternator (Г-424) Foot Brake-Light Flasher Battery 31. Neutral Indicator Green 30. Neutral Gear 27. Button Voltage Regulator (PP-31A) 84
Dnepr (Днепр) Early MT-10 Speedometer Oil-Pressure Sensor (MM-106A) Alternator (Г-424) (C-38) Breaker (PM-302) Spark Plug Ignition Coil (B-204) Spark Plug Voltage Regulator (PP-330) Battery (2X 3MT-6) Rear Brake-Light (ВК-854Б) 85
Dnepr (Днепр) Later MT-10 86
Early Style Headlight Assembly Фара ФГ-116 (FG-116) on MT-10 Central 1. Master 2. Speedometer / Odometer 3. Cavity Body 4. Lamp Holder and Hi/Lo Beam Lamp 5. Flexible Shaft Speedometer Cable 6. and 7. Bundles of Wires 8. Parking Light Bulb Socket 9. Lamp Holder 10. Lens 11. Dual Filament (Hi/Lo) Beam Lamp 12. Reflector 13. Ring (rim) of Lens and Reflector 87
Dnepr MT-10 Master Schematic (IggyMo on Dneprheads) П (56) З/С (15) СС (55) Generator Charge Light ЛС Fuse Я (61) Ф (58) Б (30/51) 88
Dnepr (Днепр) MT-10 (1969) 89
Newer Style MT-10 Lamp (фара) ФГ-137 (FG-137) 2. Central Ignition Speedometer Separate from Headlight Cavity 90
1. Turn Signal (П-201) 3. Lamp (A12-1) 4. Lamp (A12-45+40) Dnepr (Днепр) Later MT-10.36 2. Flasher 12. Fuse Battery (15A) (2X 3MT-6 or 6MTTS-9) 13. Turn (A12-1) 14. Oil (A12-1) 15. Hi/Lo (A12-1) 9. Lamp (A12-21) 10. Lamp (A12-21) 28. Master Battery Ground 17. Oil-Pressure Sensor 31. Foot Brake-Light 22. Regulator (33.3702) 26. Lamp (A12-21+5) 9. Lamp (A12-21) 29. Lamp (A12-21) Brake 30. Lamp (A12-5) 7. Lamp (A12-21) 5. Lamp (A12-4) 19. Neutral (A12-1) Button 18. Neutral Sensor 16. Charge (A12-1) 20. (C-38) 23. Alternator (Г-424)) 7. Lamp (A12-21) 8. Hi/Lo Beam (П-201) 21. Ignition Coil (B-204) 25. Breaker (PM-302A) 91
Dnepr (Днепр) Later MT-10.36 Right Turn 16. Turn Signal 17. Flasher Unit 21. Front Sidecar Light 7. Speedometer 9. Turn-Signal Indicator 10. Emergency Oil Pressure 11. High-Beam Headlight Indicator 26. Voltage Regulator (PP- 330) 23. Fuse Block 28. Master Battery Ground 27. Foot Brake-Light 15. Central 13. Neutral Transmission Indicator 12. Generator 19. Oil-Pressure 24. Indicator Sensor Alternator 18. Neutral Sensor and Indicator 20. Light 29. Battery (2X 3MT-6) 36. Brake Light Left Turn 25. 30. Breaker 31. Ignition Coil 1. Left Turn 92 34. Spark-Plug
Turn Signal Dnepr (Днепр) Later MT-10.36 Neutral Oil-Pressure Foot Brake-Light Flasher Voltage Regulator (PP-330) Ignition Coil (B-204) Button Battery (6MTS-9 or 2X 3MT-6) Breaker (PM-302/PM-302A) Alternator (Г-424) 93
Dnepr (Днепр) Later MT-10.36 Headlight Cavity ФΓ-137 Headlight ММ 126 Emergency oil pressure sensor ПД20Е Generator alarm light and relay control (PD20E) ПД20Е Emergency oil-pressure alarm light (PD20E) ПД20Д Neutral position indicator light (PD20D) ПД20Д Hi/Lo beam indicator light (PD20D) ПД20Д Turn indicator light (PD20D) ФГ137 Headlight cavity (FG137) ФП246 Motorcycle taillight (FP246) ФП219Б Rear sidecar light (FP219B) ПФ232Б Front sidecar light (PF232B) ВК857 Central switch (VK857) ПР11В Fuse box (PR11V) 94
Dnepr (Днепр) Later MT-10.36 ФΓ-137 Headlight 95
Dnepr (Днепр) Early MT-12 1. Turn Signal (П201) 4. Headlight (A6-32+21 or A6-32+32) 3. Flasher Unit (PC419) 12. Fuse (15A) 15. Generator (Г-414) 22. Battery (3MT-6 or 3MT-7) 25. Foot Brake-Light 24. Voltage Regulator (PP-302) ФΓ-116 Headlight 27. (C-35) 10. Hi/Lo Beam 17. Ignition Coil (KM-01 or B2Б) 11. Manual Spark Advance/Retard Button 7./16. Breaker/Distributor (PM-05) 96
Dnepr (Днепр) Early MT-12 (with PM-05 Breaker/Distributor and B2B Ignition Coil) Turn Signal Battery 3T-6 or 3MT-7 Generator (Г-414) ФΓ-116 Headlight Ignition Coil (B2Б) Breaker/Distributor (PM-05) 1 - indicators P-201 11 - Shifters Ignition 21 - Lamp A6-15 stop-signals (only in the lamp, or OP-230 OP-246) 2 - Right front indicator lamp on a motorcycle-alone 12 - Fuse 15A 22 - Battery 3MT-6 or 3MT-7 3 - Flasher PC-419 13 - Central switch (on M-72 & K-750 slightly different notation terminals) 23 - right rear indicator lamp on motorcycle-alone 4 - Lamp head light headlamp A6-32, 21 or A6-32 +32 14 - Bulb illumination A6-2 speedometer 24 - Relay-regulator (RR) 5 - Parking light bulb headlights 15 - Generator 25 - Stop light switch 6 - Left direction indicators 16 - Control lamp of generator A6-0.25 26 - headlight rear position lamps 7 - Chopper PM-05 17 - ignition coil KM-01 or B-2B 27 - C-35 8 - Light switch (located in the housing headlights) 18 - Splitter 28 - button 97 9 - Cable Shifters Ignition 19 - Indices turning right (sidecar) 10 - Lever light switch 20 - Front position lamp sidecar
Dnepr (Днепр) Early MT-12 (with PM-05 Breaker/Distributor and B2Б Ignition Coil) 3. Oil Pressure Sensor 6. ФΓ-116 Headlight 17. Lamp (A6-32+32) 16. Lamp (A6-1) 18. Flasher Unit (PC-419) 20. Fuse (15A) 11. Lamp (A6-3) 23. Generator (Г-414) 24. Voltage Regulator (PP-302) 16. Lamp (A6-1) 22. Lamp (A6-0.25) 26. Rear Brake-Light 28. Button 31. Breaker/Distributor (PM-05) 29. Ignition Coil (B2Б) 98
Dnepr (Днепр) Early MT-12 (with PM-05 Breaker/Distributor and B2Б Ignition Coil) Breaker/Distributor (PM-05) Battery Hi/Lo Beam 99
Dnepr (Днепр) MT-12 Speedometer Advance/Retard Lever Trouble-Light Socket Trouble-Light Hi/Lo Beam (C-37) Ignition Coil (B-2B) Generator (Г-414) Voltage Regulator (PP-302) Distributor/Breaker (PM-05) Spark Plug Battery (3MT-12) Alternate Rear Brake- Light (ВК-854Б) Spark Plug Rear Brake-Light (65018950) 100
Dnepr (Днепр) Early MT-11 (with PP-330 Regulator, later replaced with solid-state Regulator 33.3072 in 1992) Oil-Pressure Sensor Neutral 24, Regulator (PP-330) Foot Brake Light Brake Master Flasher Turn Signal Ignition Coil Breaker Battery 101
Dnepr (Днепр) Early MT-11 (with PP-330 Voltage Regulator) Oil-Pressure Sensor (MM-126) Neutral Sensor (MT804517A) Speedometer Front Brake-Light (13.3720) Alternator Г-424 Voltage Regulator (PP-330) Ignition Flasher (PC-427) Fuse Block (C-304) Spark Plug Trouble-Light Socket & Cover Rear Brake-Light (ВК-854Б) Trouble-Light Battery (6MTC-9) 102
Dnepr (Днепр) Early MT-11 (with PP-330 Regulator, later replaced with solid-state Regulator 33.3072 in 1992) 103
Dnepr (Днепр) Later MT-11 (showing replacement of PP-330 Regulator with the Solid-State 33.3702) 6. Lamp (A21-1) 10. Headlight 7. Turn (A12-45+40) (A21-1) 8. Oil (A21-1) 9. Hi/Lo (A21-1) 11. Lamp (A12-4) 13. Lamp (A12-21) 14. Flasher Unit (PC-427) 12. Ignition (141.3704) 16. Turn Signal 17. Lamp (A12-21) 18. Lamp (A12-8) 5. Front Brake-Light (13.3720) 19. Oil-Pressure Sensor 22. Charge (A21-1) 23. Neutral (A21-1) IgnitionCoil (B-204) 20. Fuse Block 28. 27. Breaker points Button 21. Voltage Regulator (33.3702) 33. Master Battery Ground 24. Neutral Sensor 25. (C-205) 30. Rear Foot Brake-Light 36. Alternator (Г-424) 34. Battery (6mts-9 or 2HZMT-6) 29. Double Lamp (A12-2+6) 4. Lamp (A12-21) 31. Brake Lamp (A12-21) 32. Lamp (A12-5) 13. Lamp (A12-21) CMH-8.155: MT-11 CMH-8.922: MT-16 CMH-8.157: MT-14 Older Models: 37. PP-330 Voltage Regulator 35. Trouble-Light Socket (only in MT-16) 104
Dnepr (Днепр) Later MT-11 (solid-state Regulator 33.3072 in 1992) 2. Lamp (A12-21-3) 2. Lamp (A12-21-3) 7. Oil Pressure Sensor (MM126) 6. Neutral Sensor 8. Foot Brake Light (BK854B) 4. Lamp (A12-21+6) 27. Lamp (A12-45+40) 43. Lamp (A12-1) 16. Voltage Regulator (33.3702) 25. Lamp (A12-5) Brake 28. Lamp (A12-4) 2. Lamp (A12-21-3) 14. Flasher Unit (PC-427) Turn Signal 37. Breaker (PM-302A) Button 33. (C-205B) 35. Ignition Coil (B-204) 36. Spark plug (A14B) 21. Alternator: Г-424 (150W) 42. Master Battery Ground (46.3710) 2. Lamp (A12-21-3) 19. Battery: 6MTS-9 105 (12V/9A-hr) 2. Lamp (A12-21-3)
Dnepr (Днепр) Later MT-11 (with solid-state Regulator 33.3072, in 1992) 106
Speedometer Dnepr (Днепр) Later MT-11 (with solid-state Regulator 33.3072, in 1992) Front Brake-Light (13.3720) Oil-Pressure Sensor (MM-126) Alternator Г-424 Voltage Regulator (33.3702) Flasher (PC-427) Fuse Block (C-205B/C-304) Ignition Coil B-204 Breaker Spark Plug (PM-302A) Trouble-Light Socket & Cover Rear Brake-Light (ВК-854Б) Turn Signal Trouble-Light Battery (3MTS-9) 107
Dnepr (Днепр) Early MT-16 (with PP-330 Regulator, later replaced with 33.3072 (solid-state) Voltage Regulator) Oil-Pressure Sensor Neutral Regulator (PP-330) Foot Brake Light Brake Master Flasher Turn Signal Ignition Coil Breaker Battery 108
Dnepr (Днепр) Early MT-16 (with PP-330 Voltage Regulator) Oil-Pressure Sensor (MM-126) Neutral Sensor (MT804517A) Speedometer Front Brake-Light (13.3720) Alternator Г-424 Voltage Regulator (PP-330) Ignition Flasher (PC-427) Fuse Block (C-304) Spark Plug Trouble-Light Socket & Cover Rear Brake-Light (ВК-854Б) Trouble-Light Battery (6MTC-9) 109
Dnepr (Днепр) Later MT-16 (showing replacement of PP-330 Regulator with the Solid-State 33.3702 in 1992) 6. Lamp (A21-1) 10. Headlight 7. Turn (A12-45+40) (A21-1) 8. Oil (A21-1) 9. Hi/Lo (A21-1) 17. Lamp (A12-21) 18. Lamp (A12-8) 5. Front Brake-Light (13.3720) 19. Oil-Pressure Sensor 20. Fuse Block 30. Rear Foot Brake-Light 21. Voltage Regulator (33.3702) 29. Double Lamp (A12-2+6) 4. Lamp (A12-21) 31. Brake Lamp (A12-21) CMH-8.155: MT-11 CMH-8.922: MT-16 CMH-8.157: MT-14 Older Models: 37. PP-330 Voltage Regulator 11. Lamp (A12-4) 13. Lamp (A12-21) 14. Flasher Unit (PC-427) 12. Ignition (141.3704) 22. Charge (A21-1) 23. Neutral (A21-1) IgnitionCoil (B-204) 24. Neutral Sensor 25. (C-205) 36. Alternator (Г-424) 33. Master Battery Ground 34. Battery (6mts-9 or 2HZMT-6) 32. Lamp (A12-5) 13. Lamp (A12-21) 35. Trouble-Light Socket (only in MT-16) 16. Turn Signal 28. Button 27. Breaker points 110