Parts Manual Generator Set NHM (Spec A H) English Original Instructions 00 90 00 (Issue )
To avoid errors or delay in filling your parts order, always give the MODEL, SPEC NO. and SERIAL NO. from the Onan nameplate. For handy reference, insert your nameplate information in the spaces below. MODEL AND SPEC NO. SERIAL NO. DIGITAL CONTROL SOFTWARE VERSION AND DATE (IF APPLICABLE) The following symbols are used in Onan manuals to alert users to the potentially dangerous conditions relating to maintenance of equipment and replacement of parts. Please read and observe. This symbol warns of immediate hazards which will result in severe personal injury or death. This symbol refers to a hazard or unsafe practice which can result in severe personal injury or death. This symbol refers to a hazard or unsafe practice which can result in severe personal injury or product or property damage. Service and repair of Onan equipment must be performed by trained, experienced personnel only. Improper service or repair may result in property damage, severe personal injury or death. Do not use this catalog as a guide to servicing your equipment. Read and follow the IMPORTANT SAFETY INSTRUC- TIONS in the Service Manual appropriate for the equipment you are working on. Contact with USED ENGINE OILS has been identified by a United States federal agency and some USA state agencies as causing CANCER or REPRODUCTIVE TOXICITY. When checking or changing engine oils take all necessary precautions not to ingest, breathe the fumes or contact the used oil. Contact with ASBESTOS has been identified by a United States federal agency and some USA state agencies as causing CANCER or REPRODUCTIVE TOXICITY. When handling engine gaskets take all necessary precautions not to ingest, breathe or contact the dust from the gaskets! Use adequate ventilation and wear protective gloves, masks and clothing! Contact with BENZINE and LEAD, found in gasoline, fuel additives and solvents has been identified by a United States federal agency and some USA state agencies as causing CANCER or REPRODUC- TIVE TOXICITY. When checking, draining or adding gasoline and fuel additives or using solvents take all necessary precautions not to ingest, breathe the fumes or contact the liquids. Use adequate ventilation and wear protective gloves, masks and protective clothing! PSP-
Introduction This manual applies to the standard NHM Recreational Vehicle Generator Set as listed in the Generator Set Data Table. Parts are arranged in groups of related items and each illustrated part is identified by a reference number corresponding to the same reference number in the parts list. Parts illustrations are typical. Using the model and speci fication number from your generator set nameplate, select parts that apply to your set. Right and left sides are determined by facing the engine end (front) of the set. Generator Set Data Table ELECTRICAL DATA MODEL** WATTS VOLTS HERTZ WIRE PHASE.NHM FA/*,00 0 0 LP.0NHM FA/*,000 0 0 Gasoline * The diagonal line (/) in the model and specification number separates generator set characteristics from the specification number and letter. The specification number denotes customer requested options or deviations from a standard (A, B, etc.) model. The speci fication letter advances (A to B, B to C, etc.) with major manufacturing changes. ** See Back of Book for W/D Information.
Index Actuator, Governor, Adapter, Air Cleaner (Gasoline), 9, Adapter, Air Cleaner (LP), Adapter, Generator, Adapter, Oil Drain, Adapter, Oil Fill Tube, Adapter, Oil Filter, 9 Adapter, Pipe, Adapter, Preheater, 9, Backplate, Air Housing, 9 Baffle, Preheater, 9, Ball, Bearing, Ball, Governor, 0 Base, Oil, 0 Bearing, Ball, Bearing, Camshaft, 9 Bearing, Connecting Rod, 9 Bearing, Crankshaft, 9 Bearing, Needle, Bearing, Rear Crankshaft, Block, Brush, Block, Cylinder,, 9 Block, Generator Brush, Block, Terminal, Board, PC, Bracket, Cable Adjust, Bracket, Choke Mounting, 9 Bracket, Control Box Mounted Fuse Holder, Bracket, Diaphragm Mounting, 9 Bracket, Fuel Pump, Bracket, Governor Adjust, Bracket, Housing Mounting, Bracket, Ignition Coil, Bracket, Ignition Control, Bracket, Oil Fill Tube Support, Bracket, Relay, Bracket, Resistor Mounting, Bracket, Voltage Regulator, Bracket, Voltage Regulator Mounting, Breaker, Battery Charger Circuit, Breaker, Control Circuit, Brush, Generator, Bushing, Fuel Tank Reducer, Bushing, Isolator, Bushing, Piston Pin, 9 Cable, Governor Flexible Adjust, Cable, Spark Plug, Cable, Starter, Camshaft (Begin Spec B), Camshaft (Spec A), 0 Cap, Oil Fill, 0 Cap, Starter Drive, Cap, Vinyl, 9, Capacitor, Carburetor, Gasoline, 9, Carburetor, LP, Charger, Battery, Clip, Air Housing Moulding, 9 Clip, Choke Housing Tube Retaining, 9 Clip, Control Rod (Begin Spec B), Clip, Control Rod (Spec A), Clip, Diaphragm Mounting U, 9 Clip, Fuel Line Retainer, Clip, Fuse, Clip, Preheater Hose, 9 Clip, Spark Plug Wire, 9 Coil, Ignition, Components, Gasoline Carburetor, Connector, Fuel Tank Barbed Hose, Connector, Hose, Control, Control, Ignition, Controller, Governor, Coupling, Fuel Tank Hose, Cover, Air Housing Cylinder, 9 Cover, Air Housing Governor Access, 9 Cover, Air Housing Top, 9 Cover, Air Inlet, 9, Cover, Breaker Box Opening, Cover, Breather, Cover, Brush Block Access, Cover, Choke, 9 Cover, Choke Housing, 9 Cover, Control, Cover, Hard Plastic Switch, Cover, Rubber Switch, Cover, Tailpipe Access, Cover, Underfloor Housing Rear Panel, 0 Cover, Valve, Crankshaft, Cup, Governor, 0 Cup, Oil Pickup, 0 Diagram, Wiring, Diaphragm, Pulloff, 9 Diode, 9 Drain, Oil Filter, 9 Elbow, Hose, Elbow, Reducing, Elbow, Regulator Reducing, Elbow, Street, 9, Element, Air Cleaner (Gasoline), 9, Element, Air Cleaner (LP), Element, Choke, 9 Element, Fuel Filter (LP) (Begin Spec F), Element, Fuel Filter (LP) (Spec A E), Exhaust Options, Extension, Oil Drain, Fan, Generator, Filter, Breather, Filter, Fuel (Gasoine) (Begin Spec B), Filter, Fuel (Gasoline) (Begin Spec B), 9
Index Filter, Fuel (LP) (Begin Spec F), Filter, Fuel (LP) (Spec A E), Filter, Oil, 9 Fitting, Elbow Vacuum, 9 Flange, Exhaust Manifold, Fuse, Engine Harness, Fuse, PC Board, Gasket, Air Horn (Gasoline), 9, Gasket, Air Horn (LP), Gasket, Bearing Plate, Gasket, Breaker Box Opening, Gasket, Carburetor Mounting (Gasoline), 9, Gasket, Carburetor Mounting (LP), Gasket, Cylinder Head, Gasket, Exhaust Manifold, Gasket, Gearcase (Begin Spec B), Gasket, Gearcase (Spec A), Gasket, Intake Manifold (Gasoline), 9, Gasket, Intake Manifold (LP), Gasket, Muffler, Gasket, Oil Base, 0 Gasket, Oil Drain Adapter, Gasket, Oil Filter Adapter, 9 Gasket, Regulator Foam (Begin Spec F), Gasket, Regulator Foam (LP) (Spec C E), Gasket, Valve Cover, Gasket, Valve Guide, Gear, Camshaft (Begin Spec B), Gear, Camshaft (Spec A), 0 Gear, Crankshaft, Gearcase (Begin Spec B), Gearcase (Spec A), Generator, Governor (Begin Spec B), Governor (Spec A), Grommet, Control Housing Nylon, Grommet, Fuel Pump, Grommet, Underfloor Housing Rubber, 0 Guide, Valve, Hanger, Exhaust, Harness, AC Output, Harness, Adapter,, Harness, Adapter (Spec A F), 0 Harness, Battery Charger, Harness, Engine (Begin Spec B), Harness, Engine (Spec A), Harness, Fuel Pump, Harness, Generator, Harness, PCB, Harness, Receptacle (Spec A F), 0 Harness, Remote (Begin Spec G), Harness, Remote (Spec A F), 0 Harness, Remote Panel (Begin Spec G), Harness, Remote Panel (Switch Only) (Begin Spec G), Harness, Remote Panel (Switch/Hourmeter) (Begin Spec G), Harness, Remote Panel (Switch/Voltmeter) (Begin Spec G), Harness, Voltage Regulator, Head, Cylinder, Holder, Engine Harness Fuse, Holder, PC Board Fuse, Hose, Fuel,,, Hose, Oil Drain, Hose, Preheater, 9, Hose, Regulator Fuel, Hose, Vacuum, 9 Housing, Air, 9 Housing, Air Cleaner (Gasoline), 9, Housing, Air Cleaner (LP), Housing, Choke, 9 Housing, Generator Stator, Housing, Underfloor, 0 Hub, Governor Cup, 0 Indicator, Oil Fill Tube, Insulation, Exhaust Manifold, Insulation, Exhaust Tube, Isolator, Vibration, Jet, Idle, Jet, Power, Joint, Ball, Key, Blower Wheel, Key, Camshaft Woodruff (Begin Spec B), Key, Camshaft Woodruff (Spec A), 0 Key, Crankshaft Gear, Kit, Carburetor Repair, Kit, Choke Bimetal, Kit, Choke Breaker, Kit, Choke Shaft, Kit, Deluxe Remote Control (Spec A F), 9 Kit, Float, Kit, Gasket, Kit, LP Conversion, Kit, Oil Pump Gasket, Kit, Piston Ring, Kit, Remote Panel (Switch Only) (Begin Spec G), Kit, Remote Panel (Switch/Hourmeter) (Begin Spec G), Kit, Remote Panel (Switch/Voltmeter) (Begin Spec G), Kit, Standard Remote Control (Spec A F), 9 Kit, Starter Drive, Labels, Line, Flexible Fuel, 9, Line, Fuel, Line, LP Regulator Supply (Spec A E), Line, Regulator Supply (LP) (Begin Spec F), Line, Regulator Supply (LP) (Spec A E), Link, Governor Spring, Linkage, Choke, 9 Linkage, Diaphragm Pulloff, 9 Lock, Valve Spring,
Index Manifold, Exhaust, Manifold, Intake (Gasoline), 9, Manifold, Intake (LP), Meter, Battery Condition, 9 Meter, Hour, Meter, Time Totalizing, 9 Meter, Voltage, Muffler, Nipple, Fuel Valve Shutoff Close (Begin Spec F), Nipple, Fuel Valve Shutoff Close (Spec A E), Nipple, Regulator Half (Begin Spec F), Nipple, Regulator Half (Spec A E), O Ring, Generator, O Ring, Oil Drain Valve, 0 O Ring, Oil Fill Cap, 0 O Ring, Oil Fill Tube, O Ring, Oil Fill Tube Adapter, O Ring, Preheater Hose, 9, Paint, Pan, Breather, Pan, Drip,, Panel, Air Housing Front, 9 Panel, Remote, 9 Panel, Remote (Begin Spec G),,, Panel, Underfloor Housing, 0 Pin, Bearing Stop Drive, Pin, Camshaft Center, 0 Pin, Gearcase Alignment (Begin Spec B), Pin, Gearcase Alignment (Spec A), Pin, Piston, Piston, Plate, Bearing, Plug, Air Cleaner Housing Button, 9, Plug, Camshaft Opening Welch, Plug, Core Hole, 9 Plug, Gearcase, Plug, Gearcase Expansion, Plug, Governor Adjust Access, 9 Plug, Intake Manifold Hex Head Pipe, Plug, Spark, Plunger, Bypass Valve, Plunger, Camshaft, Pump, Fuel, 9, Pump, Oil, 9 Rectifier, Fuel Pump, Reed, Breather Valve, Regulator, LP (Begin Spec F), Regulator, LP (Spec A E), Regulator, Voltage, Relay, Engine Harness, Relay, Fuel Pump, Relay, Start Solenoid, Resistor, Battery Charge, Resistor, Fixed, Resistor, Fuel Pump, Resonator, Exhaust, Retainer, Governor Adjust Push On, Ring, Camshaft Retaining, 0 Ring, Choke Housing Retaining, 9 Ring, Collector, Ring, Crankshaft Retaining, Ring, Piston Pin Retaining, Ring, Tolerance, Rod, Air Inlet, 9, Rod, Connecting, 9 Rod, Governor Control, Rod, Throttle Control, Rotocap, Valve Exhaust, Rotor, Generator, Rotor, Ignition, Seal, Crankshaft Oil, Seal, Drip Pan Air Outlet, Seal, Gearcase Oil (Begin Spec B), Seal, Governor Shaft Oil (Spec A), Seal, Muffler Support, Seal, Oil Fill Tube, Seal, Rear Crankshaft Oil, Seal, Valve, Sealant, Thread, Seat, Valve,, 9 Shaft, Governor, Shield, Tube, 9, Shim, Crankshaft, Spring, Air Inlet Rod, 9, Spring, Breather Valve, Spring, Bypass Valve, Spring, Camshaft Plunger, Spring, Generator Brush, Spring, Governor (Spec A), Spring, Throttle Rod (Begin Spec B), Spring, Valve, Starter, Stator, Generator, Strap, Ground, Support, Muffler, Support, Regulator,, Switch, Low Oil Pressure, 9 Switch, On/Off, Switch, On/Off (Remote Panel), 9,,, System, Fuel (Gasoline) (Begin Spec D), System, Fuel (Gasoline) (Spec A C), 9 System, LP Fuel, System, Side or Bottom Exhaust, Tank, Fuel, Tappet, Valve, Tube, Breather (Gasoline), 9, Tube, Breather (LP), Tube, Choke Housing, 9 Tube, Cylinder Block Oil, 9
Index Tube, Extended Oil Fill, Tube, Oil Fill, Tube, Side or Bottom Exhaust, Tube, Straight Exhaust, Valve, Exhaust, 9 Valve, Fuel Shutoff (Begin Spec F), Valve, Fuel Shutoff (Spec A E), Valve, Fuel Solenoid, 9, Valve, Fuel Tank Shutoff, Valve, Intake, Valve, Oil Base Drain/Shutoff, 0 Wheel, Blower, Yoke, Governor Shaft,
NHM/90 00 Cylinder Block 0 9 0 9 0 9 9 0 9 0 9 9 0
Cylinder Block 00 00 Screw, Hex Head Cap (/ 0 x / ) 00 Washer, Copper Flat (/ ) Cover, Left Side Breather Filter, Breather 0 Gasket, Valve Cover Spring, Breather Valve 00 Washer, Flat (/ ) Reed, Breather Valve 9 Pan, Breather 0 Tappet, Valve 000 Standard 000 0.00 Oversize 000 0.00 Oversize 0 09 Lock, Valve Spring Rotocap, Exhaust Valve 0 090 Gasoline Units 0 090 LP Units 0 09 Plunger, Bypass Valve 0 00 Spring, Bypass Valve 00 Washer, Copper Flat (/ ) 0 000 Screw, Hex Head Cap (/ x / ) 0 09 Washer, Intake Valve Spring Retainer (Special) 0 09 Spring, Valve 9 0 0 Seal, Intake Valve Oil 0 Guide, Valve 0 Exhaust 0 Intake 0 Gasket, Intake Valve Guide 0 0 Cover, Right Side Valve 00 00 Screw, Hex Head Cap (/ 0 x ) 00 000 Screw, Hex Head Cap (/ 0 x / ) 0 00 Washer, Flat (M) 0 Cover, Breaker Box Opening 0 Gasket, Breaker Box Opening 09 00 Seal, Rear Oil 9 0 09 0 Plate, Rear Bearing 0 Shim, Crankshaft (Use as Required) 0 0.00 0 0 0.00 Bearing, Rear Crankshaft (Includes Thrust Washer) 0 00 Standard 0 00 0.00 Undersize 0 00 0.00 Undersize 0 00 0.00 Undersize 0 00 0.00 Undersize 0 0 Washer, Thrust (Special) 0 009 Gasket, Bearing Plate 00 Pin, Bearing Stop Drive 00 0 Plug, Camshaft Opening Welch ( / ) 0 00 Screw, Socket Set (/ x / ) 00 Washer, Flat (.9 ) 00 00 0 Screw, Hex Head Cap (/ x / ) 9 Stud, Cylinder Head Mounting Begin Spec C 0 099 / x 9/ (Install Bottom Holes RH, LH Heads) 0 0 / x / (Install Top Holes RH, LH Heads) 0 09 / x (Install Middle Holes RH, LH Heads) 0 Seat, Intake Valve 0 Standard 0 0.00 Oversize 0 0.00 Oversize 0 0.00 Oversize 0.0 Oversize 0 Valve, Intake 0 9 Gasket, Cylinder Head 0 9 Head, Cylinder 00 0 Washer, Flat (Special) 00 090 0 Screw, Hex Head Cap Spec A, B (Special) 0 009 0 Nut, Hex (Special) Begin Spec C 009 Washer, Compression Lock Begin Spec C (Special) Kit, Piston Ring Specs A,B 09 Standard 09 0.00 Oversize 09 0.00 Oversize 09 0.00 Oversize 09 0.00 Oversize Begin Spec C 0 Standard 0 0.00 Oversize 0 0.00 Oversize 0 0.00 Oversize 0 0.00 Oversize 9 Piston (Includes Pin and Retaining Rings) 0 Standard 0 0.00 Oversize 0 0.00 Oversize 0 0.00 Oversize 0 0.00 Oversize 0 Ring, Retaining 09 Specs A,B 0 Begin Spec C Pin, Piston 009 Specs A,B 0 Begin Spec C NHM/90 00
NHM/90 00 Cylinder Block 0 9 0 0 9 0 9 9 0 9 0 9 9
Cylinder Block Bearing, Connecting Rod Half 0 Standard 0 0.00 Undersize 0 0.00 Undersize 0 0.00 Undersize 0 0.00 Undersize 00 Rod, Connecting (Includes Bolt and Bushing) 0 000 Bolt, Connecting Rod Place (Special) 00 Bushing, Piston Pin Valve, Exhaust 0 9 LP Engines 0 Gasoline Engines Seat, Exhaust Valve 0 Standard 0 0.00 Oversize 0 0.00 Oversize 0 0.00 Oversize 0 0.0 Oversize 0 00 Tube, Cylinder Block Oil 9 Bearing, Front Crankshaft (Flanged) 0 00 Standard 0 00 0.00 Undersize 0 00 0.00 Undersize 0 00 0.00 Undersize 0 00 0.00 Undersize 0 0 09 Pump, Oil (Components Not Sold Separately) 0 00 Washer, Flat (M) 00 000 Screw, Hex Head Cap (/ 0 x ) 00 Plug, Core Hole 0 00 Bearing, Camshaft (Precision) Block, Cylinder (See Short Block Catalog #9 009) 9 NHM/90 00
Camshaft Spec A 9 0 00 Ring, Retaining 0 9 Hub, Governor Cup 0 0 Cup, Governor (Includes Bushing) 0 00 0 Ball, Governor 0 000 Gear, Camshaft (Includes Plate and Spacer) 0 0 Washer, Thrust 000 Key, Woodruff 0 0 Camshaft (Includes Center Pin) 9 0 00 Pin, Center 0 NHM/90 00
Camshaft Begin Spec B 0 0 Camshaft 0 000 Gear (Includes Spacer and Plate) 0 0 Washer, Thrust 000 Key, Woodruff 0 00 Plunger, Camshaft 0 009 Spring, Plunger NHM/90 00
Crankshaft 0 Crankshaft 000 Key, Gear 0 00 Gear, Crankshaft 0 00 Washer, Gear 00 Ring, Retaining NHM/90 00
Blower Wheel 0 Wheel, Blower 009 Key, Blower Wheel 00 Washer, Flat (/ x / Thk) 0 Washer, Flat (/ x / Thk) Special 0 00 Screw (Special) NHM/90 00
Gearcase Spec A 9 0 0 00 Gearcase Assy (Includes Parts Marked *) 00 *Screw, Pan Head Machine Cross Recessed (# x / ) 0 *Yoke 0 0 *Nut, Self Locking (#0 ) 00 *Washer, Conical Disc Spring 0 00 0 *Shaft, Governor 0 00 *Screw, Governor Adjust Guide (Special) 0 99 *Link, Governor Spring 9 09 000 *Seal, Oil 0 0 00 *Bearing, Needle 00 *Pin 0 00 *Ball, Bearing 09 000 *Seal, Crankshaft Oil (Front) 0 00 Gasket, Gearcase 00 Washer, Copper Flat (/ ) Screw, Hex Head Cap 00 / x / 00 09 / x / * Parts Included in Gearcase Assy. NHM/90 00
Gearcase Begin Spec B 9 0 0 Gearcase Assy (Includes Seal and Plugs) 09 000 Seal, Oil 00 Plug, Gearcase 09 Plug, Expansion 00 0 Screw, Hex Head Cap (/ x / ) 00 Washer, Flat 0 Pin, Alignment 0 00 Gasket, Gearcase 9 00 00 0 Screw, Hex Head Cap (/ x / ) NHM/90 00
Governor Spec A 0 9 00 Nut, ET Hex (#0 ) 0 009 Stud, Governor Adjusting 0 Spring, Governor 0 9 0 Bracket, Governor 000 Clip, Retaining 0 099 Joint, Ball Rod, Governor Control 0 Gasoline Units 0 9 LP Units 0 9 Cable, Flexible Adjust 9 0 9 0 Bracket, Cable Adjust 0 0 Retainer, Push On NHM/90 00
Electronic Governor Begin Spec B 0 Rod, Throttle Control 0 Clip, Throttle Control Rod 0 Spring, Throttle Rod 00 Actuator, Governor (K) 0 0 Screw, Pan Head (. Lg) 0 0 Screw, Pan Head (. Lg) NHM/90 00
NHM/90 00 Gasoline Fuel System Spec A C 0 9 0 9 9 0 9 0 0 9
Gasoline Fuel System Spec A C 0 Clamp, Hose Tube, Breather Baffle, Preheater 0 0 0 Black 0 0 0 Green Adapter, Preheater 0 0 Black 0 0 Green 0 0 Clamp, Hose 0 Hose, Preheater 09 Clip, Preheater Hose 0 Rod, Air Inlet 9 000 Washer, Flat (#) 0 0 00 Spring, Air Inlet Rod 0 Cap, Vinyl 00 00 Screw, Cap Hex Head (/ 0 x / ) 00 Washer, Flat (/ ) 0 9 Housing, Air Cleaner 0 9 Element, Air Cleaner 0 Bracket, Choke Mounting 0 Housing, Choke (Includes Choke Shaft, Insulating Washer and Retainer Ring) (H) 0 Ring, Retainer 9 0 Clip, Choke Housing Tube Retaining 0 0 Tube, Choke Housing 0 Element, Choke 0 Cover, Choke (Includes Hex Nuts, Washers, Heater Coil Spider and Choke Heater Element) 09 Cover, Choke Housing 0 0 Nut, Nylon Acorn Cap (# ) 09 Screw, Hex Washer Head Cap Thread Forming (# x / ) 0 0 Elbow, 90 Barbed (Inlet) 0 0 Nut, Hex (#0 ) 0 Shield, Tube 9 0 000 Elbow, 90 Street (Outlet) 0 Valve, Fuel Solenoid (E) 0 9 Spec A 0 Spec B,C 0 00 Elbow, 90 Street (Outlet) 9 Pump, Fuel (E) 0 00 Line, 0 Flexible Fuel 9 9 Filter, Fuel 0 Linkage, Choke 09 Screw, Hex Washer Head Cap Thread Forming (/ 0 x / ) 0 0 Elbow, 90 Street Carburetor (See Separate Page for Components) 0 Spec A 0 Spec B, C 9 090 Gasket, Carburetor Mounting 0 Manifold, Intake 9 Gasket, Intake Manifold 0 Washer, Flat (Special) 00 00 Screw, Hex Head Cap (/ x / ) 0 0 Clamp, Hose 0 0 Fitting, 90 Elbow Vacuum 0 Screw, Hex Flange Head Cap (/ x ) 0 Bracket, Diaphragm Mounting 0 0 Hose, Vacuum (/ ID x ) 9 0 Diaphragm, Pulloff 0 00 Clip, Diaphragm Mounting U 0 Linkage, Diaphragm Pulloff 0 0 Gasket, Air Horn 00 Nut, Hex (/ ) 0 9 Adapter, Air Cleaner 090 Screw, Hex Head Machine (#0 x / ) 0 Cover, Air Inlet 00 Plug, Button 09 0 O Ring 9 NHM/90 00
Gasoline Fuel System Begin Spec D 9 0 9 0 0 9 0 9 0 NHM/90 00
Gasoline Fuel System Begin Spec D Tube, Breather 0 Clamp, Hose 0 0 0 Baffle, Preheater 0 0 Adapter, Preheater 0 0 Clamp, Hose 0 Hose, Preheater 00 Rod, Air Inlet 000 Washer, Flat (#) 9 0 00 Spring, Air Inlet Rod 0 0 Cap, Vinyl 00 00 Screw, Hex Head Cap (/ 0 x / ) 00 Washer, Flat (/ ) 0 0 Housing, Air Cleaner 0 9 Element, Air Cleaner 09 0 O Ring 0 Cover, Air Inlet 00 Plug, Button 090 Screw, Hex Head Machine (#0 x / ) 9 0 09 Adapter, Air Cleaner 0 0 0 Gasket, Air Horn 00 Nut, Hex (/ ) 0 0 Elbow, 90 Street 0 Carburetor (Includes Mounting Gaskets) (See Separate Page for Components) 090 Gasket, Carburetor Mounting 0 Screw, Hex Flange Head Cap (/ x ) 0 00 Plug, Hex Head Pipe 00 00 0 Screw, Hex Head Cap (/ x / ) 0 Washer, Flat (Special) 9 9 Gasket, Intake Manifold 0 Manifold, Intake Spec D F (With Vacuum Hole) 0 Begin Spec G (W/O Vacuum Hole) Filter, Fuel 9 9 Spec D F 9 Begin Spec G 0 00 Line, 0 Flexible Fuel 0 Valve, Fuel Solenoid (E) 0 00 Elbow, 90 Street (Outlet) 9 Pump, Fuel (E) 0 0 Elbow, 90 Barbed (Inlet) 0 0 Nut, Hex (#0 ) 0 Shield, Tube 9 0 000 0 Elbow, 90 Street (Outlet) 0 0 0 Hose, Fuel (Begin Spec G) 0 0 Clamp, Hose (Begin Spec G) 0 09 Connector, Hose (Begin Spec G) 9 0 Pump, Fuel (E) (Begin Spec G) 0 0 Elbow, 90 Hose (Begin Spec G) NHM/90 00
Carburetor Components Gasoline,,, Begin Spec D Spec A C Carburetor, Complete (Includes Mounting Gaskets) 0 Spec A 0 Spec B,C 0 Begin Spec D 0 Kit, Float (Includes Float, Pin and Valve) 0 Kit, Repair (Includes Gasket Package, Float Valve, Idle Adjust Needle and Spring, Mounting Gaskets, Adjust Limit Caps, Throttle Stop Screw and Spring (Spec A C) 0 Kit, Choke Bimetal (Includes Compl. Bimetal Holder, Thermostat Cover Assembly, Bimetal Set Plate, Bimetal Case Set Screw) Jet, Idle 0 Spec A 09 Spec B C 0 Jet, Power (Spec A C) 09 Kit, Choke Shaft (Includes Choke Shaft Assembly, Choke Collar, Choke Arm Return Spring, Choke Valve, Valve Set Screw, Choke Lever Assy) 09 Kit, Choke Breaker (Includes Choke Piston Rod, Link Washer, Snap Pin, Choke Opener Assy) NHM/90 00
LP Fuel System 9 0 9 0 Manifold, Intake Spec A E 0 Begin Spec F 0 Screw, Hex Washer Head (Special) 0 0 Plug, Hex Pipe (/ ) 9 Gasket, Intake Manifold 0 Washer, Flat (/ Screw) 00 00 Screw, Hex Head Cap (/ x / ) 0 0 Clamp, Hose (9/ to / ) Tube, Breather 9 Gasket, Carburetor Mounting 090 Spec A E 09 Begin Spec F 0 00 Nut, Hex (/ ) 0 Bracket, Housing Mounting 0 0 Gasket, Air Horn Carburetor 09 Spec A E 09 Begin Spec F (Includes Mounting Gaskets) 0 Clamp, Breather Tube Hose (.900 Diameter) Adapter, Air Cleaner 0 9 Spec A C 0 Begin Spec D 090 Screw, Hex Head Cap (Special) 0 9 Element, Air Cleaner Housing, Air Cleaner 0 9 Spec A C 0 0 Begin Spec D 9 00 Washer, Flat (/ ) 0 00 00 Screw, Hex Head Cap (/ 0 x / ) NHM/90 00
Regulator LP Spec A E 9 0 09 Regulator, LP 090 Gasket, Foam (Spec C E) 0 0 Nipple, Half (/ x ) (Spec C E) 090 Support, Regulator 0 Washer, Regulator Flat 00 000 Screw, Hex Head Cap Regulator Support (/ 0 x / ) 0 09 Clamp, Hose (Spec C E) 0 09 0 Elbow, 90 Reducing Regulator (/ to / ) 9 0 Elbow, 90 Reducing (/ x / ) 0 9 Line, Supply (Spec C E) Line Assy, Carburetor 9 Spec B 9 0 Spec C E 0 0 Clamp, Hose 0 0 Hose, Fuel 0 0 Line Assy, LPG 0 0 Valve, Fuel Shutoff (Bottom Outlet, Exhaust Manifold) 0 099 0 Nipple, Close (Bottom Outlet, Exhaust Manifold) 090 Filter, Fuel (Includes Element and O Rings) 09 Element, Fuel Filter NHM/90 00
Regulator LP Begin Spec F 0 9 9 0 9 Regulator Assy (Includes Parts Marked *) 0 Spec F 0 Begin Spec G 00 *Regulator *Gasket, Foam 090 Spec F 09 Begin Spec G 0 0 *Nipple, Half (/ x ) 0 0 *Elbow, 90 Reducing 0 *Elbow, 90 Reducing 0 0 *Adapter, Pipe 00 Washer, Flat (/ ) 9 00 000 Screw, Hex Head Cap (/ 0 x / ) 0 Support, Regulator 0 Spec F 0 Begin Spec G 09 Element, Fuel Filter 090 Filter, Fuel (Includes Element and O Rings) 0 0 Line, Fuel 0 0 Valve, Fuel Shutoff 0 099 0 Nipple, Close 0 0 Hose, Fuel 0 0 Clamp, Hose 00 Line, Carburetor 9 0 09 Clamp, Hose 0 09 Line, Regulator Supply 0 Kit, LP Conversion (Includes Regulator Assy, Fuel Lines, Regulator Support, LH Cylinder Cover, Hose Clamp, Mounting Hardware.) * Parts Included in Regulator Assy. NHM/90 00
Starter 9 0 9 Starter (See Separate Page for Components) (B) 00 00 Screw, Cap (Hex Head) (/ x / ) Cable, Starter (Spec A) 0 000 Washer, Lock (/ ) 0 000 Washer, Spring Lock (/ ) 000 Nut, Hex (/ 0) 0 Lead, Starter (Includes Shield) 0 Shield 9 000 Nut, Hex Spring (/ ) 0 9 Cap, Drive 9 Kit, Drive (Includes Drive Clutch, Pinion Gear, Roll Pin, Cover, Spring, Retainers and Washer) NHM/90 00
Resistor Spec B F 9 0 09 Nut, Insulation (#) 0 00 Washer, Centering 0 0 Resistor, Fixed (. Ohms 0 Watts) 0 0 Bracket, Resistor Mounting 0 Screw, Hex Head Cap (Special) 00 Screw, Hex Washer Head Self Lock, Thread Form (#0 x / ) 0 0 Bracket, Resistor Mounting 0 Screw, Hex Washer Head Thread Cutting (/ 0 x / ) 9 0 0 Washer, Flat (. Screw) NHM/90 00
Battery Charger 0 9 0 0 0 Charger, Battery 9 00 0 Bracket, Voltage Regulator Mounting 0 Harness, Battery Charger (Includes Parts Marked *) 0 0 *Breaker, Circuit 9 *Connector, Tab 0 *Connector 00 Screw, lock Head Flange (/ 0 x / ) 00 Washer, IT Lock (/ ) 9 09 0 Screw, Pan (#0 x / ) 0 000 Washer, EIT Lock (#0) * Parts Included in Battery Charger Harness. NHM/90 00
Oil Filter 0 Adapter, Oil Filter (Includes Screws) 00 Screw, Hex Washer Head Cap Thread Forming (#0 x / ) 00 Drain, Oil Filter 000 Filter, Oil Switch, Low Oil Pressure (S) 09 0 Spec A 09 0 Begin Spec B 00 00 0 Screw, Hex Head Cap (/ x ) 00 Washer, Copper Flat (/ ) 0 Gasket, Oil Filter Adapter 9 NHM/90 00
Oil Base 9 0 0 Gasket, Oil Base Base, Oil 0 9 Spec A F 0 0 Begin Spec G Cup, Oil Pickup 09 Cap, Oil Fill Valve, Drain/Shutoff 0 0 Spec A F 0 00 Begin Spec G 09 0 O Ring ( / ID) 09 0 O Ring (/ ) (Spec A F) 0 Washer, Flat (/ ) 9 Screw, Hex Head Cap 00 00 Spec A F (/ x ) 00 00 0 Begin Spec G (/ x / ) 0 09 09 O Ring (/ ) (Spec A F) 0 NHM/90 00
Extended Oil Fill Tube 0 9 0 0 Tube, Oil Fill Clamp, Coated 09 Adapter Assy (Includes Adapter and O Ring) 09 0 O Ring, Adapter 09 09 Seal, Oil FIll Tube 0 Indicator Assy (Includes O Ring) 09 0 O Ring, Indicator 9 0 Bracket, Tube Support 9 000 Screw (/ 0 x / ) 0 0 0 Nut (/ x 0) 009 Washer, Flat (/ ) NHM/90 00
Oil Drain Extension 0 9 Adapter, Oil Drain 0 9 Hose,Oil Drain (/ ID x ) 0 0 Clamp, Hose 0 9 Gasket, Oil Drain Adapter 0 Screw, Hex Washer Head Cap Thread Forming (/ 0 x / ) NHM/90 00
Generator Adapter 0 9 Nut, Hex Flange 00 M Positive Terminal 0 M Negative Terminal 00 Screw, Self Locking Hex Washer Head Thread Forming (/ 0 x ) Coil, Ignition (T) 0 Spec A,B Spec C S/N G99 & Below 00 Begin Spec C, S/N G99 & Above Bracket, Ignition Coil 09 0 Spec A,B Spec C S/N G99 & Below 0 Begin Spec C S/N G99 & Above 090 Screw, Self Locking Hex Washer Head Thread Forming (/ 0 x / ) 00 Screw, Self Locking Hex Washer Head Thread Forming (#0 x / ) 9 Clamp, Hose 09 Bracket, Ignition Control 9 0 Control, Ignition (S) 0 0 0 Nut, Self Locking (#0 ) 0 Capacitor (C) Cable, Spark Plug 0 9 0 0 Plug, Spark (E, E) 0 Rotor, Ignition 00 0 0 Screw, Hex Flange Head Cap (/ x / ) 09 Adapter, Generator NHM/90 00
Exhaust System (Side or Bottom) 9 0 9 0 9 0 Insulation, Exhaust Tube Spec A Insulation, Exhaust Manifold 9 0 Begin Spec B LP Liquid 9 0 Begin Spec B Gasoline 0 00 Nut, Self Locking (/ ) 0 Washer, Flat (Special) 00 Bolt, Carriage (/ x / ) 00 Nut, Hex (/ ) Stainless Steel 0 00 Washer, Flat (M) Tube, Exhaust 9 Gasket, Muffler (LP Use ) 0 00 00 Screw, Hex Head Cap (/ x ) 0 Screw, Hex Washer Head Cap Thread Forming (/ 0 x / ) 00 Washer, Flat (/ ) Support, Muffler Seal, Muffler Support Screw, Self Locking Hex Flange Head 009 Spec A F (/ x / ) 090 0 Begin Spec G Gasket, Exhaust Manifold Muffler Insulation, Exhaust Manifold 9 0 Begin Spec B LP Liquid 9 0 Begin Spec B Gasoline 9 Manifold, Exhaust 9 0 Gasoline Units LP Units Spec B (Includes Fuel Line) 9 Spec C E (W/Regulator Bracket 9 0 Begin Spec F (W/O Regulator Bracket) 0 Screw, Socket Head 0 00 Gasoline Units (/ x ) 0 00 LP Units (/ x x. ) 0 Spacer, Washer NHM/90 00
Exhaust Options 9 Tube, Exhaust 0 09 Flange, Exhaust Manifold (/ Thk) (Steel Plate) 00 00 Screw, Hex Head Cap (/ x ) 0 Washer, Flat (/ ) 0 Cover, Tailpipe Access Hanger, Exhaust ( / ) 0 0 Cover, Tailpipe Access 9 Resonator, Exhaust 9 Clamp, Exhaust / / 0 / 9 / / NHM/90 00
Drip Pan 0 LIQUID WITHDRAWAL 9 9 GASOLINE 9 9 0 NHM/90 00
Drip Pan 0 9 0 Pan, Drip 0 09 Bushing, Isolator Screw, Self Locking Hex Flange Head (/ 0 x / ) 000 Spec A F 000 9 Begin Spec G 0 Screw, Hex Head Cap Thread Forming (/ x / ) 0 Washer, Flat (/ ID x 9/ OD x / Thk) 0 0 Isolator, Vibration 00 Screw, Hex Self Locking Flange Head (/ 0 x / ) (Gasoline Units Only) 0 Clip, Fuel Line Retainer (Gasoline Units Only) 9 0 0 Nut, Self Locking Hex (/ 0) 0 0 Controller, Governor (A) Begin Spec B 0 0 Screw, Pan Head Torx (0 x / ) Begin Spec B Washer, EIT Lock (/ ) 000 Gasoline Units (/ ) 000 LP Units (/ ) Strap, Ground Screw 00 Self Locking, Hex Flange Head (/ x / ) 0 Hex Head, Thread Cutting Bracket, Fuel Pump Gasoline Units 9 0 Spec A F 9 9 0 Begin Spec G 9 0 LP Units 0 00 Grommet, Fuel Pump (Spec A F) (Gasoline Units Only) 00 Washer, Flat (#0) (Spec A F) (Gasoline Units Only) 0 000 Washer, Locking Self (#0) 9 0 0 Nut, ET Hex (#0 ) (Spec A F) (Gasoline Only) 0 0 Screw, Thread Form (/ 0 x / ) LP Begin Spec B 00 Screw, Hex Head Cap Thread Forming (/ 0 x ) Seal, Air Outlet Washer, Flat (Special) (Gasoline Units Only) 0 Spec A 0 Begin Spec B (/ ) NHM/90 00
Air Housing 9 0 9 NHM/90 00
Air Housing 0 Cover, Governor Access 09 Screw, Torx Drive Cover, Top (Includes Indented Parts Listed Below) 0 0 Use W/Electronic Governor 0 0 Use W/Mechanical Governor 9 Insulation 0 Insulation, Right Hand 0 Insulation, Left Hand 0 Insulation, Front 0 Nut, Insulation Push On Cover, Left Side Cylinder (Includes Indented Parts Listed Below) 9 Gasoline Sets LP Sets 9 Spec A E 9 0 Begin Spec F 90 0 Cover, Inner Cylinder Head 0 Nut, Insulation Push On 0 Screw, Torx Drive (/ 0 x / ) 0 Clip, Access Cover (/ 0) 0 Cover, Tailpipe Access Insulation, Cylinder Head Insulation, Muffler Box 9 00 Gasoline Sets LP Sets 9 0 Spec A E 9 0 Begin Spec F 0 Clip, Spark Plug Wire 0 Screw, Hex Washer Head Cap Thread Forming (/ 0 x / ) Backplate 90 0 Spec A 00 0 Begin Spec B 00 Screw, Self Locking Hex Washer Head (/ x. ) 9-0 Screw, Torx Drive (/ 0 x / ) 0 9 Cover, Right Side Cylinder (Includes Indented Parts Listed Below) 9 0 Cover, Inner Cylinder Head Insulation, Cylinder Head Insulation, Muffler Box 0 Nut, Insulation Push On Panel, Front (Includes Indented Parts Listed Below) 99 Insulation 0 Cover,Tailpipe Access 0 Clip, Access Cover (/ 0) 0 Screw, Torx Drive Access Cover (/ 0 x / ) -0 Nut, Insulation Push On 00 9 Clip, Moulding 0 Plug, Governor Adjust Access 9 NHM/90 00
Underfloor Housing 0 9 0 S0 Panel, Rear (Includes Insulation) 0 0 Cover, Rear Panel 0 000 Washer, Spring Lock (#0) 009 Screw, Round Head Machine (#0 x / ) 00 00 Screw, Hex Head Cap (/ x / ) 0 Washer, Flat (/ ) 0 S0 Panel, Left Side (Includes Insulation) 000 Washer, EIT Lock (/ ) 9 0 Panel, Right Side (Includes Insulation) 0 0 00 Grommet, Rubber (/ Grommet ID) 0 00 Grommet, Rubber ( / ID) 0 NHM/90 00
Fuel Tank 0 Tank, Fuel ( Gallon) 0 000 Bushing, Reducer (/ x / ) 0 09 Valve, Shutoff (/ ) 0 09 Connector, Barbed Hose (/ ) 0 00 Hose, Fuel (/ ID x ) 0 0 Clamp, Hose 0 09 Coupling, Quick Disconnect Female 0 09 Coupling, Quick Disconnect Male NHM/90 00
Generator 9 0 9 0 NHM/90 00
Generator 0 0 Rotor, Generator (Includes Parts Marked *) 0 0099 *Bearing, Ball 0 0 *Ring, Collector 00 *Ring, Tolerance 0 0 *Fan, Generator 000 Nut, Hex (/ ) 0 0 Screw, Socket (/ x 0 / ) 0 0 Grommet, Nylon 9 Cover, Brush Block Access 0 Block, Generator Brush (Includes Parts Marked #) #Block, Brush 00 #Brush, Generator 0 #Spring, Generator Brush 0 Screw, Pan Head Torx (#0 x / ) 0 00 Resistor, Fuel Pump (R) Screw, Torx Drive Thread Forming 00 Hex Head (#0 x / ) Specs A,B 00 0 Pan head (#0 x / ) Begin Spec C 0 09 Washer, Centering Resistor, Battery Charge (R) 0 09 Specs A,B Spec C F 0 00 0 Watts, Ohms 0 0 0 Watts,. Ohms 9 000 Screw, Lock Head (/ x ) 0 000 Washer, EIT Lock (/ ) 0 0 Housing, Generator Stator 00 00 Screw, Hex Head Cap (/ x / ) 0 000 Washer, Spring Lock (/ ) 9 0 Clamp, Stator 090 Screw, Countersunk Torx Drive Thread Forming (/ 0 x / ) 0 0 Stator, Generator 09 09 O Ring 09 Housing, Push On Connector * Parts Included in Generator Rotor. # Parts Included in Generator Brush Block. NHM/90 00
Control 0 9 9 0 9, 9 0 0 9 NHM/90 00
Control 0 Screw, Torx Slotted Hex Washer Head (# x / ) 0 Clamp, Conduit 0 Screw, Pan Head Thread Forming (#0 x / ) Bracket, Fuse Holder 0 0 Spec A F 0 0 Begin Spec G Screw, Pan Head Machine 09 0 Spec A F (/ 0 x ) 09 Begin Spec G (/ 0 x.) 0 0 0 Bracket, Voltage Regulator 0 Screw, Torx Drive Thread Forming (/ 0 x / ) 0 0 Regulator, Voltage (Includes Cap and Pins) (VR) 9 99 Pin, Contact 0 Cap, Place Connector (P) 0 0 Screw, Torx Drive (/ 0 x / ) Harness, Voltage Regulator (Includes Socket and Plug) 00 Plug, Connector Plug, Place Connector (J) 09 Screw, ET Pan Head Cross Recessed (# x / ) Breaker, AC Output Circuit (CB,CB) Spec 0,, 0 0A 0 0A 0 Spec 9, 0,,, (0A) 0 Insulator, PC Board (Begin Spec B) 0 Screw, Pan Head Thread Forming (#0 x / ) 9 09 Holder, Fuse (For Spares) 0 0 099 Cover, Rubber Switch Cover, Control 9 0 Spec A Begin Spec B 9 0 Spec 0,, 9 0 Spec 9, 0,,, Board, PC (A) (Includes Clip, Switch, Hard Plastic Cover and Fuse) 00 90 Spec A 00 Spec B F 00 90 Begin Spec G 0 099 Cover, Hard Plastic Switch 0 099 Switch, On/Off (AS) 0 Clip, Fuse Fuse (F) 09 Amp Spec A 0 0 Amp Begin Spec B Insulator, Terminal 000 Nut, Hex Jam (/ ) 9 0 00 Washer, Spring Lock (/ ) 0 0 0 Relay, Start Solenoid (K) 0 Harness, AC Output 00 Screw, Torx Pan Head (#0 x ) 09 0 Screw, Pan Head Torx Drive Thread Forming (#0 x / ) 9 0 Block, Terminal (TB) 009 Screw, Round Head Machine (#0 x / ) 0 9 Bracket, Relay (Spec A) Harness, Generator (Includes Parts Marked +) 0 +Pin, Contact 9 0 0 Nut, Hex (.90 ) 0 0 +Relay, Fuel Pump Stop Latch (K, K) 0 0 +Rectifier, Fuel Pump Bridge Power (CR0) (Spec A F) 00 +Rectifier, Fuel Pump Stop Latch (CR, CR9) 00 Screw, Round Head Machine (#0 x / ) Harness, Fuel Pump (F, TB L0 to J, R) 09 Housing, Push On Connector + Parts Included in Generator Harness. NHM/90 00
Engine Harness Spec A REF PART QTY PART NO. NO. USED DESCRIPTION Harness, Wiring (PCB) Engine to Control (Includes Housing and Contact Pins) 9 Housing (J) 0 Pin, Contact NHM/90 00
Engine Harness Begin Spec B Harness, Engine Gasoline Units Spec B 0 Spec C Begin Spec D LP Units Spec B 0 Spec C E 0 Begin Spec F 0 Connector, Receptacle 0 Wedge, Receptacle Use with 0 Connector 0 0 Holder, Fuse 0 0 Fuse (0A) 0 Relay (K) 00 Wedge, Plug Use with 0 Connector 0 Connector, Plug Use with 0 Connector NHM/90 00
Wiring Harness PCB 9 0 Harness, Wiring Gasoline Sets Spec A 00 PCB # (Includes Parts Marked *) Spec B,C (Includes Parts Marked ) Spec D F (Includes Parts Marked ) 0 Begin Spec G (Includes Parts Marked ) LP Sets (Includes Parts Marked ) Spec C E 0 Spec F 0 Begin Spec G 0 Housing, Connector Connections 9 Connector, Receptacle Pin, Contact 0 Wedge, Receptacle Use with 9 Connector Pin 00 * Contact, Socket 0 +*Pin, Contact *Housing (J) 9 +Housing (J) 9 Connector, Plug ( Pin) 0 Lock, Housing 0 Seal, Cable Plug, Cavity 9 Pin, Terminal * Parts Included in Spec A Harness. Parts Included in Spec B F and LP Harnesses. Parts Included in Beginning Spec G Harness. NHM/90 00
Remote Panel (Spec A F) 0 9 00 Kit, Standard Remote Control (Includes Screws, Rocker Switch and Control Panel) (A) +Screw, Wood Oval Head Cross Recessed (# x / ) 00 Standard Control 00 Deluxe Control 0 0 +Switch, Rocker (S) +Panel, Control 0 Standard Control 0 0 Deluxe Control 00 Kit, Deluxe Remote Control (Includes Parts Marked +) (A) 0 0 +Meter, Time Totalizing (M) 0 0 +Meter, Battery Condition (M) 9 00 +Diode 9 0 +Screw, Round Head Machine (# x / ) 0 0 000 +Nut, Hex (# ) + Parts Included in Deluxe Remote Control Kit. 9 NHM/90 00
Remote Wiring Harness (Spec A F) 0 9 0 Harness, Receptacle Wiring (Includes Pins and Housing) 000 Pin, Contact 000 Housing, Connector ( Place) 0 Harness, Remote (Includes Housing and Pins) 0 Housing, Connector ( Place) 99 Pin, Contact Harness, Adapter Wiring (Includes Pins, Sockets and Housing) 0 Housing, Connector ( Place) 9 99 Pin, Contact 0 0 Socket, Connector 00 Housing, Connector ( Place) Harness, Wiring (Includes Pins and Housing) 0 0 Ten Foot 0 0 Thirty Foot 99 Pin, Contact 0 Housing, Connector ( Place) (J) 0 NHM/90 00
Remote Switch Panel Begin Spec G 00 9 Kit, Switch Only Remote Panel 090 Screw, Wood Mounting (# x ) 0 0 Switch, Rocker 0 Harness, Remote Panel (Includes Pins and Plug) 9 Plug (9 Pin) 99 Pin, Contact NHM/90 00
Remote Switch/Hourmeter Panel Begin Spec G 00 9 Kit, Switch/Hourmeter Remote Panel 090 Screw, Wood Mounting (# x ) 0 0 Switch, Rocker 0 00 Meter, Hour Harness, Remote Panel (Includes Pins and Plug) 0 Plug ( Pin) 99 Pin, Contact NHM/90 00
Remote Switch/Voltmeter Panel Begin Spec G,,, 9 0 00 9 Kit, Switch/Voltmeter 090 Screw, Wood Mounting (# x ) 0 0 Switch, Rocker 0 Meter, Voltage 009 Washer, Nylon 009 Washer, Flat 000 Nut, Hex Brass Machine (0 ) 0 000 Washer, Lock 0 Harness, Remote Panel (Includes Pins and Plug) 9 0 Plug ( Pin) 0 99 Pin, Contact NHM/90 00
Remote Harness Begin Spec G 9 0 00 9 Harness, Remote (Includes Parts Marked *) Harness, Remote Panel (Includes Parts Marked +) 9 0 0 9 0 0 Harness, Adapter (Includes Parts Marked #) +*Connector, Receptacle ( Pin) +*Plug, Cavity 0 +*Seal, Cable 0 *Pin, Contact +*Lock, Housing 9 00 +#Contact, Socket 0 +#Cap, Connector * Parts Included in Remote Harness + Parts Included in Remote Panel Harness # Parts Included in Adapter Harness NHM/90 00
Adapter Harness 9,, 0 Harness, Adapter Wiring New Set to Old Panel (Includes Parts Marked *) Harness, Adapter Wiring Old Set to New Panel (Includes Parts Marked +) *Connector, Receptacle ( Pin) 0 +*Seal, Cable 0 *Pin, Contact +*Plug, Cavity +*Lock, Housing *Cap, Connector ( Pl) 9 00 *Contact, Socket 0 +Connector, Plug ( Pin) 09 +Socket, Terminal 0 +Cap, Connector ( Pl) 99 +Pin, Contact * Parts Included in Remote Harness + Parts Included in Remote Panel Harness NHM/90 00
Labels, Paint, Thread Sealant, Kits 9 Label, Air Cleaner Begin Spec B 9 0 0 Label, Air Cleaner Begin Spec B 9 0 Label, Battery Negative 9 Label, Fuse 9 0 Label, Model Identification (Marquis 000) 9 0 Label, Model Identification (Marquis 00 LPG) 9 0 Label, Oil Capacity (White Background) 9 0 Label, Oil Fill (Black Background) 9 0 Label, Phone Info 9 0 Label, Stripe 9 0 0 Label, Warning (Provide Support) 9 0 0 Label, Warning (Service/ Maintenance) 9 0 Label, Warning (Fire or Fumes) 9 0 Label, Warning (Hazardous Voltage, Exhaust Gas) 0 Loctite, Bottle (0cc) 09 Paint, Enamel Touch Up Black (Flat) oz. Pressurized Can 0 Sealant, Thread (0cc Bottle) 0 0 Kit, Oil Pump Gasket Kit, Gasket 090 Valve Grind 09 Engine NHM/90 00
Wiring Diagram Information Spec Wiring Diagram Number Number A B/C D/E/F G 9................................................... 0................. 9....... 9....... 0 0........................... 9....... 9....... 0........................... 9....... 9....... 0........................... 9....... 9....... 0............................................ 0.........................................
Numerical Index Part No. Page Part No. Page Part No. Page Part No. Page 09, 0 00, 0 0,, 09 0, 0 0, 0 0,, 0 09 0 0, 0 0, 0 0,, 09 0, 0 0 0, 0 0,, 09 0 0, 0, 0,, 9,, 09 0, 0 00, 0,, 09 0 0, 0 009, 09, 09, 09, 0 0, 0, 09 0, 0 0, 09 0, 0 0, 0 09 0, 0, 09 0, 0 0, 09 0, 09, 0 09 0, 0 000, 0, 09 0,, 9 09 0, 0 09, 0, 0, 09 0, 0 09, 0 0,, 09 0, 0 09, 0 0, 0, 9 0 00, 9 0 090, 0 0,, 9 0 09 0, 0 0, 0 0,, 9 0 00, 0, 00,, 9 0 00 0, 0 9, 9 00, 9 9 00, 9 0 00 0, 0, 9 0, 9 9 0, 9 0 00 0, 0 9, 0 0, 9 9 0, 9 0 00 0, 0, 0 0, 9 0, 0 00, 9 0, 0 0, 9 0, 9 0 00 0, 9 0, 0 0, 9 90 0, 9 0 00 0, 9 0, 9 00, 9 9 0, 9 0 00 0, 9 0 0, 9 000, 0, 9 0 00 0, 9 0 0, 9 000 0, 0, 9 0 009, 0 0, 9 000 0, 0, 9 0 9, 0 0 0, 9 0 00,, 9, 9, 9 0, 0 0 9, 0 0, 9, 9 0 9, 0, 0 09, 9 0, 0 9, 0 0, 0 09, 9 9 0, 0 0, 0 0, 0 00, 9 9 0, 0 00, 0 0, 0, 9,, 9 0, 0 00,, 0 0, 00, 9 9, 9 0 0, 0 0, 0, 9 90 0, 9 0 00, 0, 000, 9 99, 9 0 00, 009, 0, 9 00 0, 9 0 009, 0,, 0 0, 9
Numerical Index Part No. Page Part No. Page Part No. Page Part No. Page 0 0, 9 0, 0, 9 0, 9, 9 0, 0, 9 0, 9 0, 9 09, 0, 9 0, 0 9, 00, 0, 9, 00, 0 9, 9, 0, 0, 9 0, 0 0 0, 9, 00, 0, 9 09 0, 0 0 0, 9 0, 0, 9 09, 0 0, 9,, 09, 0, 9 00, 0 0, 9, 9, 9, 09, 9 0, 0 0, 9 9 9, 9, 0, 9 0, 0 9, 9,, 9 0, 09, 0, 0, 9, 9, 9,, 0, 0 0,, 9 0,, 9,, 0, 0 9, 9 9 0,, 090, 0 09, 9,, 09, 090, 9,, 9,, 9, 09, 9 9 0, 9, 9, 0, 9, 0 00, 0 9 0, 9, 0, 9 0 00, 0 0, 0 0, 00, 0 009, 0,, 0 0, 09, 0 099, 0, 0 0, 0, 0,, 0, 0, 0 9, 0 9,, 0, 0 0, 0,, 0, 9, 0,,, 0, 0 99,, 00, 0, 9, 0 00 0,, 0 0, 0, 0 9, 0 0, 0 0, 09, 0 9 0, 0, 0, 09, 0 9 0,, 09, 09, 0 00,, 9 0, 0,, 0,, 0, 09, 0, 9, 00, 9 090,, 0,, 00, 9 09,, 0,, 00, 090, 0 9, 0, 00 90, 090,, 00, 9 0, 00 90, 09, 0, 0, 00 9, 9
Numerical Index Part No. Page Part No. Page Part No. Page Part No. Page 00 9, 9 0, 0, 0, 00 9, 9 0, 0,, 0, 00 9, 0, 0,,, 9 0, 0, 9 0, 09, 9 0, 0 0, 9 0 0,,,, 0, 0 0, 9 0,,,, 0, 0 0, 9 0,,,, 0, 09,,,, 0 00, 09, 0,, 0 00, 0 0, 09,, 00, 0 0, 0 0,, 9 00, 9 0 0, 0 0, 9 0, 0 0, 0 09, 0 0, 0, 0 09, 0 09, 000, 0 9, 0 9 0, 0 00, 00, 0, 0 S0, 0 0 0,, 0, 0, 0, 0 0 00, 000, 0, 0 S0, 0 0 0, 0 0, 0 0 0, 0 0, 0 9, 9 0,, 0 0,, 99,, 0,,,, 00,,,, 9, 9, 0, 0,,, 0, 0 00, 0, 0 0,, 0 0 0, 0 0 0, 0 0 0, 0 0, 0 0,, 0 00, 9, 0 000, 9 0 000 0, 0 00, 0 0,,, 0 00, 9, 0 9,,, 0 0,, 0, 9,, 0 0, 0, 9,,, 0 09,, 0 0, 9,,, 0 09, 0 099, 0,,, 0, 0 09, 0 099,,, 0 0, 0 099, 0, 0, 0 09 0, 0 0,,, 9, 0, 0 099 0,, 09 0, 9 9,, 0 0, 9 09 0, 9 00,, 0 0, 9, 0, 0, 0, 0 0, 9, 9 00 0, 0,, 0,, 9 0, 0,, 0 0, 0
Numerical Index Part No. Page Part No. Page Part No. Page Part No. Page 0 0, 9,,,,, 0 09,, 0 00, 0 0,, 0 0,, 0 0, 9 0, 9,, 0 9, 0 0, 9 0, 9, 0 0, 0 00, 0 0 0, 0 0 09, 0 000, 0 0, 0 00, 0 0 00, 0 0 0, 0 00, 0 0, 09 000, 09 000,, 09 00, 09 0, 09 09, 09 0, 0, 09 0, 0 09 09, 09 09, 0 09 0, 9, 0 00, 0 00, 0 00, 0 0 0099, 000, 0,, 009, 00, 00, 00, 0, 00 0, 00, 9 0, 9, 0, 9 09, 00, 9, 000, 00, 09, 0, 0, 9 00, 9 0, 09, 9 00, 0, 9 0, 00, 9 0, 9 0, 9 0, 0, 9 0 0, 0 09, 0 099, 09, 000, 9, 00, 00, 00,,, 00, 9,, 009, 009, 00, 00,,, 9 00, 0,, 0,, 0 0, 00, 0, 9,,, 0 0, 0, 0, 00, 009, 0,, 9, 9, 0,, 0, 0,,, 0 00,, 9 0 00, 00 000, 00 000, 00 000, 00 000, 9 00 00, 00 00, 00 00, 9,, 00 00, 0 00 00 0, 9 00 00 0, 00 00 0, 00 00,, 00 00 0, 0 00 00, 9, 00 00 0, 00 00, 0 00 0, 00 0 0, 00 090, 00 09, 00 00,, 0 000, 0 00, 0 00, 0 0, 0 00, 0 000, 9 009, 009, 0 00, 00, 0, 0,,,,, 9 090,, 00, 9 00, 9 0, 9 00, 9 0, 0, 9,, 090, 9,, 09, 9 09, 9 00, 00, 0, 00, 0, 0, 0, 09 0,, 09 0, 00,,
Numerical Index Part No. Page Part No. Page Part No. Page Part No. Page 0 0, 0 0, 0 0, 0 0, 0, 09, 00, 00 0, 0, 9 09, 9 090 0, 09, 090,,, 00, 000,, 00, 00, 00, 009, 000, 0 000,, 0, 0 000, 0 00, 0 000,, 009, 00, 00, 000, 000, 000,, 0 000, 0 000, 9 000, 000,, 00, 00, 9,, 00, 000, 0 00, 0 0, 9,,, 0 09, 0 0,, 0 0,, 0 0, 9 000,
Cummins Power Generation 00 rd Ave. NE Minneapolis, MN USA Phone 000 Toll-free 00 Fax 9 Email www.cumminsonan.com/contact www.cumminsonan.com Cummins, Onan, the C logo, and Performance you rely on. are trademarks of Cummins Inc. 00 Cummins Power Generation, Inc. All rights reserved.