Parts Catalog MDKBP MDKBR MDKBS Printed U.S.A. 0 0
To avoid errors or delay in filling your parts order, always give the MODEL, SPEC NO. and SERIAL NO. from the Onan nameplate. For handy reference, insert your nameplate information in the spaces below. MODEL AND SPEC NO. SERIAL NO. DIGITAL CONTROL SOFTWARE VERSION AND DATE (IF APPLICABLE) The following symbols are used in Onan manuals to alert users to the potentially dangerous conditions relating to maintenance of equipment and replacement of parts. Please read and observe. This symbol warns of immediate hazards which will result in severe personal injury or death. This symbol refers to a hazard or unsafe practice which can result in severe personal injury or death. This symbol refers to a hazard or unsafe practice which can result in severe personal injury or product or property damage. Service and repair of Onan equipment must be performed by trained, experienced personnel only. Improper service or repair may result in property damage, severe personal injury or death. Do not use this catalog as a guide to servicing your equipment. Read and follow the IMPORTANT SAFETY IN- STRUCTIONS in the Service Manual appropriate for the equipment you are working on. Contact with USED ENGINE OILS has been identified by a United States federal agency and some USA state agencies as causing CANCER or REPRODUCTIVE TOXICITY. When checking or changing engine oils take all necessary precautions not to ingest, breathe the fumes or contact the used oil. Contact with ASBESTOS has been identified by a United States federal agency and some USA state agencies as causing CANCER or REPRODUCTIVE TOXICITY. When handling engine gaskets take all necessary precautions not to ingest, breathe or contact the dust from the gaskets! Use adequate ventilation and wear protective gloves, masks and clothing! Contact with BENZINE and LEAD, found in gasoline, fuel additives and solvents has been identified by a United States federal agency and some USA state agencies as causing CANCER or REPRODUC- TIVE TOXICITY. When checking, draining or adding gasoline and fuel additives or using solvents take all necessary precautions not to ingest, breathe the fumes or contact the liquids. Use adequate ventilation and wear protective gloves, masks and protective clothing! PSP-
Introduction This catalog applies to the standard marine generator sets listed below. Parts are arranged in groups of related items and each illustrated part is identified by a reference number corresponding to the same reference number in the parts list. Parts illustrations are typical. Unless otherwise mentioned in the description or page heading, parts are interchangeable between models. Throughout this catalog left and right sides are determined by facing the engine end (front) of the set. MODEL HERTZ MDKBP/* 0/0 MDKBR/* 0/0 MDKBS/* 0/0 * The diagonal line (/) in the model and specification number separates generator set characteristics from the specification number and letter. The specification number denotes customer requested options or deviations from the standard model. The specification letter advances (A to B, B to C, etc.) with major manufacturing changes. WIRING DIAGRAM 0 DC
Index Actuator, Governor, Adapter, Dry Exhaust, Adapter, Engine, Adapter, Fuel Return Pipe, Adapter, Hose (MDKBP, MDKBR), 0 Adapter, Keel Cooling, Adapter, Oil Drain (MDKBP, MDKBR), 0 Adapter, Oil Drain (MDKBS), Adapter, Pipe, Alternator (Isolated Ground), Alternator (MDKBP, MDKBR, Neg Gnd), Alternator (MDKBP, MDKBR, Negative Ground), Alternator (MDKBS), 0 Arm Assy, Rocker (MDKBP, MDKBR), 0 Arm Assy, Rocker (MDKBS), Armature, Starter (V), Armature, Starter (V), Assy Control (esdd), Assy Panel, Blank, Assy Panel, Engine, Assy, Glow Plug, Assy, PCB, Baffle, Air, Baffle, Generator, Ball, Crankshaft (MDKBP, MDKBR), 0 Ball, Crankshaft (MDKBS), Ball, Valve Seat, Band, Pipe, Bar, Bus, Barb, Keel Cooling (Dry Exhaust), Barb, Keel Cooling (Wet Exhaust), Base, Filter, Base, Generator Mounting, 0 Base, Mounting, 0 Bearing, Alternator (Negative Ground, V), Bearing, Alternator (Negative Ground, V), Bearing, Ball, Bearing, Connecting Rod, Bearing, Coolant Water Pump, Bearing, Crankshaft (MDKBP, MDKBR), 0 Bearing, Crankshaft (MDKBS), Bearing, Crankshaft Thrust (MDKBS), Bearing, Generator, Bearing, Main (MDKBS), Bearing, Starter (V), Bearing, Starter (V), Belt, Alternator (Isolated Ground), Block, Cylinder (MDKBP, MDKBR), Block, Cylinder (MDKBS), Box, Control, Bracket, Alternator (Isolated Ground), Bracket, Alternator (MDKBP, MDKBR, Neg Gnd), Bracket, Alternator Adjusting (MDKBS), 0 Bracket, Baffle, Bracket, Belt Guard, Bracket, Fuel Pump, Bracket, Heat Exchanger, Bracket, Isolated Ground, Bracket, Lifting (MDKBP, MDKBR), Bracket, Lifting (MDKBS), Bracket, Mounting Pad, Bracket, Oil Drain (MDKBP, MDKBR), 0 Bracket, PTO, Bracket, PTO (Right), Bracket, Remote Separator Mounting, Bracket, Rocker Arm (MDKBP, MDKBR), 0 Bracket, Rocker Arm (MDKBS), Bracket, Starter (V), Bracket, Starter (V), Break Siphon (MDKBP, MDKBR), 0 Breaker, Circuit, Breaker, Circuit ( Amp), Breaker, Circuit (0 Amp), Breather (MDKBP, MDKBR), Breather (MDKBS), Brush, Alternator (Negative Ground, V), Brush, Alternator (Negative Ground, V), Bulkhead, Exhaust Connector, Bushing, Connecting Rod, Bushing, Idle Gear, Bushing, Oil Drain Reducer (MDKBS), Cam, Water Pump, Camshaft, Camshaft, Fuel, Cap, Adjusting Bolt Assy (MDKBS), Cap, Coolant Recovery Tank, Cap, Coolant Tank, Cap, Cylinder Block Sealing (MDKBP, MDKBR), Cap, Cylinder Block Sealing (MDKBS), Cap, Cylinder Head Sealing (MDKBP, MDKBR), Cap, Cylinder Head Sealing (MDKBS), Cap, Oil Drain Line (MDKBP, MDKBR), 0 Cap, Stop Lever Adjusting Bolt (MDKBP, MDKBR), Cap, Valve (MDKBP, MDKBR), 0 Cap, Valve (MDKBS), Clamp, Fuel Pump Hose, Clamp, Fuel Return Hose, Clamp, Injection Pipe (MDKBP, MDKBR), Clamp, Nozzle Pipe (MDKBS), Cock, Cylinder Block Drain (MDKBP, MDKBR), Cock, Cylinder Block Drain (MDKBS), Collar, Alternator (MDKBS, Negative Ground), 0 Collar, Alternator (Negative Ground, V), Collar, Alternator (Negative Ground, V), Collar, Crankshaft (MDKBP, MDKBR), 0 Collar, Crankshaft (MDKBS), Collar, Idle Gear, Collet, Valve Spring (MDKBP, MDKBR), 0 Collet, Valve Spring (MDKBS), Components, Alternator (Negative Ground, V), Components, Alternator (Negative Ground, V), Components, Injection Pump (MDKBP, MDKBR), Components, Injection Pump (MDKBS), Components, Starter (V),
Index Components, Starter (V), Components, Water Pump, Components, Water Separator, Connector, Fuel Pump Male, Connector, Fuel Return Male, Connector, Heat Exchanger Bulkhead, Connector, Hose, Connector, Hose (MDKBS), Connector, Keel Cooling Bulkhead, Connector, Male, Control Harness, Control Panel Components (NIM), Control, Box, Cooling, Keel (Dry Exhaust), Cooling, Keel (Wet Exhaust), Cord, Glow Plug (MDKBP, MDKBR), Cord, Glow Plug (MDKBS), Coupling, Anchor, Coupling, Dry Exhaust Reducer, Coupling, PTO, Cover (MDKBS), Cover Assy, Starter (V), Cover Assy, Starter (V), Cover, Access, Cover, Alternator Bearing (Negative Ground, V), Cover, Alternator Bearing (Negative Ground, V), Cover, Alternator End (Negative Ground, V), Cover, Alternator End (Negative Ground, V), Cover, Bearing Housing (MDKBP, MDKBR), Cover, Bearing Housing (MDKBS), Cover, Control Box, Cover, Cylinder Head (MDKBP, MDKBR), Cover, Cylinder Head (MDKBS), Cover, Cylinder Head Oil Fill (MDKBS), Cover, Fuel Camshaft (MDKBP, MDKBR), Cover, Heat Exchanger, Cover, Hole (MDKBP, MDKBR), Cover, Hole (MDKBS), Cover, Injection Pump (MDKBP, MDKBR), Cover, Injection Pump (MDKBS), Cover, Mechanical Fuel Pump (MDKBS), Cover, Thermostat, Cover, Water Pump, Crankshaft, 0 Crankshaft (MDKBP, MDKBR), 0 Crankshaft (MDKBS), Cylinder Block (MDKBS), Disc, Generator Drive, Door, Sound Shield, Drain Assy, Water Separator, Drive Assy, Starter (V), Drive Assy, Starter (V), Elbow, Degree Street, Elbow, Degree Street Fuel, Elbow, Fuel Return, Elbow, Inverted Male, Elbow, Keel Cooling, Elbow, Keel Cooling (Dry Exhaust), Elbow, Keel Cooling (Wet Exhaust), Elbow, Oil Drain (MDKBP, MDKBR), 0 Elbow, Oil Drain Pipe (MDKBS), Elbow, Pipe, Elbow, Street Pipe, Element, Breather (MDKBP, MDKBR), Element, Breather (MDKBS), Element, Fuel Filter, Element, Water Separator, Endbell, Engine, Replacement (MDKBP, MDKBR), Engine, Replacement (MDKBS), Exchanger, Heat, Exhaust, Dry, Exhaust, Wet, Fan, Generator, Filter, Fuel,, Filter, Oil,, Fitting, Oil Drain Hose Barb (MDKBS), Flange, Coolant Water Pump, Flange, Dry Exhaust, Flange, Oil Fill, Flange, Water Outlet, Flange, Water Return, Flywheel Assy, Frame, Alternator Drive End (Negative Ground, V), Frame, Alternator End (Negative Ground, V), Frame, Alternator End (Negative Ground, V), Gasket, Adjusting Bolt (MDKBS), Gasket, Bearing Housing (MDKBP, MDKBR), Gasket, Bearing Housing (MDKBS), Gasket, Bearing Housing Cover (MDKBP, MDKBR), Gasket, Bearing Housing Cover (MDKBS), Gasket, Breather (MDKBP, MDKBR), Gasket, Breather (MDKBS), Gasket, Coolant Water Pump, Gasket, Cover (MDKBS), Gasket, Cylinder Block Plug (MDKBP, MDKBR), Gasket, Cylinder Block Plug (MDKBS), Gasket, Cylinder Head (MDKBP, MDKBR), Gasket, Cylinder Head (MDKBS), Gasket, Cylinder Head Cover (MDKBP, MDKBR), Gasket, Cylinder Head Cover (MDKBS), Gasket, Delivery Valve (MDKBP, MDKBR), Gasket, Delivery Valve (MDKBS), Gasket, Dry Exhaust, Gasket, Dry Exhaust Adapter, Gasket, Exhaust Manifold, Gasket, Fuel Camshaft Cover (MDKBP, MDKBR), Gasket, Fuel Nozzle (MDKBP, MDKBR), Gasket, Gearcase, Gasket, Heat Exchanger Cover, Gasket, Hole Cover (MDKBP, MDKBR), Gasket, Injection Pump (MDKBS), Gasket, Injection Pump Cover (MDKBP, MDKBR),
Index Gasket, Injection Pump Cover (MDKBS), Gasket, Injection Pump Eye Joint (MDKBP, MDKBR), Gasket, Injection Pump Hollow Screw (MDKBP, MDKBR), Gasket, Injection Pump Hollow Screw (MDKBS), Gasket, Mechanical Fuel Pump Cover (MDKBS), Gasket, Mixer, Gasket, Nozzle (MDKBS), Gasket, Oil Fill Flange, Gasket, Oil Pan (MDKBP, MDKBR), 0 Gasket, Oil Pan (MDKBS), Gasket, Oil Pan Plug (MDKBP, MDKBR), 0 Gasket, Oil Pump (MDKBP, MDKBR), Gasket, Oil Pump (MDKBS), Gasket, Raw Water Pump, Gasket, Riser/Adapter, Gasket, Speed Control Plate (MDKBS), 0 Gasket, Stop Lever Adjusting (MDKBP, MDKBR), Gasket, Thermostat Cover, Gasket, Water Outlet Flange, Gasket, Water Pump (Wet Exhaust), Gasket, Water Return Flange, Gear Assy, Idle, Gear, Camshaft, Gear, Crankshaft (MDKBP, MDKBR), 0 Gear, Crankshaft (MDKBS), Gear, Oil Drive (MDKBS), Gear, Oil Pump Drive (MDKBP, MDKBR), Gear, Oil Pump Drive (MDKBS), Gear, Starter (V), Gear, Starter (V), Gearcase Assy, Generator, Governor, Grommet, Generator, Grommet, Generator Housing, Grommet, Remote, Grommet, Vacuum Relief Valve, 0 Ground, Isolated, Guard Assy, Coupling, Guard, Belt, Guard, Belt and PTO Belt, Guard, Belt W/O PTO, Guide, Control Box Card, Guide, Valve (MDKBP, MDKBR), Guide, Valve (MDKBPD, MDKBR), Guide, Valve (MDKBS), Hanger, Coolant Recovery Tank, Harness, Battery, Harness, Control, Harness, Control, Harness, Ground, Harness, Isolated Ground, Harness, Junction, Harness, Remote Control Panel, 0 Harness, Remote Extension, Harness, Remote Panel w/ Hourmeter, Harnesses, Head Assy, Cylinder (MDKBS), Head Assy, Water Separator Replacement, Head, Cylinder (MDKBP, MDKBR), Head, Cylinder (MDKBS), Holder Assy, Alternator Brush (Negative Ground, V), Holder Assy, Alternator Brush (Negative Ground, V), Holder Assy, Nozzle (MDKBP, MDKBR), Holder Assy, Nozzle (MDKBS), Holder Assy, Starter Brush (V), Holder, Delivery Valve (MDKBP, MDKBR), Holder, Delivery Valve (MDKBS), Holder, Nozzle (MDKBP, MDKBR), Holder, Nozzle (MDKBS), Holder, Starter Brush (V), Hose, Coolant, Hose, Coolant Tank Upper, Hose, Engine Coolant, Hose, Exhaust Manifold, Hose, Fuel, Hose, Intake, Hose, Keel Cooling, Hose, Keel Cooling (Dry Exhaust), Hose, Keel Cooling (Wet Exhaust), Hose, Lower Coolant Tank, Hose, Mixer, Hose, Raw Water Pump, Hose, Wet Exhaust, Hourmeter (Control Panel), Hourmeter, Remote Control Panel, Housing, Generator, Housing, Main Bearing (MDKBP, MDKBR), Housing, Main Bearing (MDKBS), Hub, Drive, Impeller, Coolant Water Pump, Impeller, Water Pump, Indicator, Oil Level (MDKBP, MDKBR), 0 Indicator, Oil Level (MDKBS), Insulation, Access Panel Sound, Insulation, Alternator Brush (Negative Ground, V), Insulation, Alternator Brush (Negative Ground, V), Insulation, Door, Insulation, Duct (W/O PTO), Insulation, Generator Housing, Insulation, Panel (Side), Insulation, Panel (Top), Insulation, Roof, Insulation, Roof End, Isolation, Vibration, Isolator, Mounting, 0 Joint, Cylinder Block Drain Cock (MDKBP, MDKBR), Joint, Cylinder Block Drain Cock (MDKBS), Joint, Injection Pump (MDKBS), Joint, Injection Pump Eye (MDKBP, MDKBR), Joint, Intake Manifold Pipe, Joint, Oil Filter Pipe,
Index Jumper, Temp Switch, Key, Camshaft, Key, Crankshaft (MDKBP, MDKBR), 0 Key, Crankshaft (MDKBS), Key, Fan Drive Pulley (MDKBP, MDKBR), Key, Oil Pump (MDKBP, MDKBR), Key, Oil Pump (MDKBS), Key, Water Pump, Kit, Access Panel, Kit, Belt Guard (ISO Ground), Kit, Belt Guard (Neg Ground), Kit, Belt Guard (PTO), Kit, Coolant Recovery, Kit, Coupling Guard, Kit, Cruise, Kit, Door, Kit, Duct Panel, Kit, Enclosure Panel, Kit, Engine Roof Panel, Kit, Exhaust, Kit, Exhaust (Wet), Kit, Exhaust Adapter, Kit, Exhaust Flange, Kit, Fuel Adapter (/ Hose), Kit, Fuel Adapter (/ Hose), Kit, Heat Exchanger End Cap/Pencil, Kit, Heat Exchanger Zinc Pencil, Kit, Isolated Ground, Kit, Keel Cooling, Kit, Keel Cooling (Dry Exhaust), Kit, Keel Cooling (Wet Exhaust), Kit, Minor Service, Kit, Muffler, Kit, Muffler/Water Separator, Kit, Panel Enclosure, Kit, Panel, Remote, Kit, PTO, Kit, PTO Belt, Kit, Raw Water Pump Service, Kit, Remote Fuel/Water Separator, Kit, Remote Panel, 0 Kit, Remote Switch Harness, 0 Kit, Roof Panel, Kit, Sender, Kit, Siphon Break (MDKBP, MDKBR), 0 Kit, Siphon Break (MDKBS), Kit, Sound Shield, Kit, Water Separator, Kit, Water Separator Metal Bowl Replacement, Kits, Label, Control, Label, Indicator, 0 Labels, Latch, Door (/ Turn), Lever Assy, Engine Stop (MDKBS), Lever Assy, Fork, Lever Assy, Starter (V), Lever Assy, Starter (V), Lever Assy, Stop (MDKBS), Lever, Engine Stop (MDKBP, MDKBR), Lever, Engine Stop (MDKBP, MDKBR), Lever, Engine Stop (MDKBS), Lever, Governor, Line, Flex Oil (MDKBP, MDKBR), 0 Line, Fuel Return, Line, Oil, Lock Assy, Plate (MDKBP, MDKBR), Lug, Solderless, Manifold, Exhaust, Manifold, Intake, Manifold, Oil Pressure, Mixer, Mount Assy, Engine, 0 Mounting, Printed Circuit Board, Muffler, Muffler, Dry Exhaust, Nipple, Keel Cooling (Dry Exhaust), Nipple, Keel Cooling (Wet Exhaust), Nozzle (MDKBS), Nozzle, Fuel (MDKBP, MDKBR), O Ring Kit, Water Separator, O Ring, Crankshaft (MDKBP, MDKBR), 0 O Ring, Crankshaft (MDKBS), O Ring, Cylinder Block, O Ring, Cylinder Block Pipe Pin (MDKBS), O Ring, Cylinder Head (MDKBP, MDKBR), O Ring, Cylinder Head (MDKBS), O Ring, Delivery Valve Holder (MDKBS), O Ring, Gearcase, O Ring, Governor Lever (MDKBS), 0 O Ring, Oil Fill Cover (MDKBS), O Ring, Oil Fill Plug, O Ring, Oil Pickup Tube (MDKBS), O Ring, Pickup Tube (MDKBP, MDKBR), 0 O Ring, Valve Holder (MDKBP, MDKBR), O Ring, Water Pump, Pan, Oil (MDKBP, MDKBR), 0 Pan, Oil (MDKBS), Panel, Access, Panel, Control, Panel, Control (Gnd), Panel, Duct (W/O PTO), Panel, Enclosure, Panel, Enclosure (W/PTO), Panel, Generator Housing, Panel, Generator Housing Side, Panel, Remote Control, 0 Panel, Remote Control (w/ Hourmeter), Panel, Remote Printed (W/Hourmeter), Panel, Roof,
Index Panel, Roof End, Panel, UMC Mounting, PCB Assy, Control, Pencil, Zinc, Pin, Cylinder Block Pipe (MDKBP, MDKBR), Pin, Cylinder Block Pipe (MDKBS), Pin, Cylinder Block Straight (MDKBS), Pin, Cylinder Block Straight (MDKBP, MDKBR), Pin, Cylinder Block Straight (MDKBS), Pin, Flywheel Alignment, Pin, Gearcase, Pin, Piston, Pin, Rocker Arm Bracket Spring (MDKBP, MDKBR), 0 Pin, Rocker Arm Spring (MDKBS), Pin, Stop Lever Spring (MDKBP, MDKBR), Pin, Stop Lever Spring (MDKBS), Pin, Tappet Guide (MDKBP, MDKBR), Pin, Tappet Guide (MDKBS), Pinion Set, Starter (V), Pipe, Injection (MDKBP, MDKBR), Pipe, Injection (MDKBS), Pipe, Overflow (MDKBP, MDKBR), Pipe, Overflow (MDKBS), Pipe, Water Return, Piston, Plate Assy, Lock (MDKBS), Plate, Alternator Retainer (Negative Ground, V), Plate, Alternator Retainer (Negative Ground, V), Plate, Breather (MDKBP, MDKBR), Plate, Breather (MDKBS), Plate, Injection Pump (MDKBS), Plate, Injection Pump Mounting (MDKBP, MDKBR), Plate, Speed Control (MDKBS), 0 Plate, Water Pump Wear, Plug, Coolant Tank Hex Pipe, Plug, Cylinder Block (MDKBP, MDKBR), Plug, Cylinder Block (MDKBS), Plug, Cylinder Head (MDKBP, MDKBR), Plug, Cylinder Head (MDKBS), Plug, Fuel Filter Drain, Plug, Gearcase, Plug, Glow, Plug, Glow (MDKBS), Plug, Hex Head Pipe, Plug, Oil Fill, Plug, Oil Pan (MDKBP, MDKBR), 0 Plug, Oil Pan (MDKBS), Plug, Water Outlet Flange, Plug, Water Separator, Plunger, Pump (MDKBP, MDKBR), Plunger, Pump (MDKBS), PTO, Pulley, Alternator (Isolated Ground), Pulley, Alternator (MDKBS), 0 Pulley, Alternator (Negative Ground, V), Pulley, Alternator (Negative Ground, V), Pulley, Coolant Water Pump, Pulley, Fan Drive (MDKBP, MDKBR, Neg Gnd), Pump Assy, Coolant Water, Pump Assy, Injection (MDKBP, MDKBR), Pump Assy, Injection (MDKBS), Pump Assy, Water Separator, Pump, Electric Fuel, Pump, Fuel, Pump, Heat Exchanger Raw Water, Pump, Keel Cooling Raw Water (Wet Exhaust), Pump, Oil (MDKBP, MDKBR), Pump, Oil (MDKBS), Rack, Injection Pump Control (MDKBP, MDKBR), Rack, Injection Pump Control (MDKBS), Rectifier, Alternator (Negative Ground, V), Rectifier, Alternator (Negative Ground, V), Regulator, Alternator (Negative Ground, V), Regulator, Alternator (Negative Ground, V), Relay, Isolated Ground Solenoid, Remote Control Panel, 0 Resistor, Fuel Pump (V), Resonator, Intake, Retainer, Endbell, Retainer, Valve Spring (MDKBP, MDKBR), 0 Retainer, Valve Spring (MDKBS), Ring, Idle Gear Retaining, Ring, Piston Retaining, Ring, Rocker Arm (MDKBP, MDKBR), 0 Ring, Rocker Arm Retaining (MDKBS), Ring, Water Pump Retaining, Riser, Exhaust, Riser, Wet Exhaust, Rivet, Drive Plastic, Rod Assy, Connecting, Rod, Push, Rotor Assy, Generator, Rotor, Alternator (Negative Ground, V), Rotor, Alternator (Negative Ground, V), Rotor, Exciter, Screw, Follow, Seal, Bearing Housing Oil (MDKBS), Seal, Coolant Water Pump, Seal, Crankshaft Oil (MDKBP, MDKBR), 0 Seal, Heat (MDKBS), Seal, Main Bearing Housing Oil (MDKBP, MDKBR), Seal, Nozzle Heat (MDKBP, MDKBR), Seal, Oil (MDKBS), Seal, Stop Lever Oil (MDKBP, MDKBR), Seal, Stop Lever Oil (MDKBS), Seal, Valve Stem (MDKBP, MDKBR), 0 Seal, Valve Stem (MDKBS), Seal, Water Pump Lip, Seal, Water Pump Mechanical, Seal, Weather (. ), Seat, Spring (MDKBP, MDKBR), Seat, Spring (MDKBS),
Index Seat, Valve, Sender, Low Coolant, Sender, Oil, Sender, Oil Pressure, Sender, Water Temperature, Separator, Fuel/Water, Separator, Remote Fuel/Water, Separator, Remote Fuel/Water Separator, Separator, Water, Set, Ring, Shaft Assy, Rocker Arm (MDKBP, MDKBR), 0 Shaft Assy, Rocker Arm (MDKBS), Shaft, Engine Stop Lever (MDKBP, MDKBR), Shaft, Fork Level, Shaft, Idle Gear, Shaft, Stop Lever (MDKBS), Shield, Engine Panel Sound (Access), Shield, Engine Panel Sound (Doors), Shield, Panel Engine Sound (Front and Rear), Shield, Panel Engine Sound (Front w/pto), Shield, Sound, Engine (Cover), Shim, Injection Pump (MDKBS), Shim, Injection Pump Mounting (MDKBP, MDKBR), Shim, Injection Pump Mounting (MDKBS), Shim, PTO, Shim, Spring Seat (MDKBP, MDKBR), Siphon, Break (MDKBS), Sleeve, Air Intake, Sleeve, Crankshaft (MDKBP, MDKBR), 0 Sleeve, Crankshaft (MDKBS), Sleeve, Injection Pump Control (MDKBS), Sleeve, Injection Pump Upper Spring (MDKBP, MDKBR), Slinger, Crankshaft Oil (MDKBS), Slinger, Oil (MDKBP, MDKBR), 0 Socket, Relay, Spacer, Generator Fan, Spacer, Panel, Spring, Alternator Brush (Negative Ground, V), Spring, Alternator Brush (Negative Ground, V), Spring, Delivery Valve (MDKBP, MDKBR), Spring, Delivery Valve (MDKBS), Spring, Plunger (MDKBP, MDKBR), Spring, Plunger (MDKBS), Spring, Rocker Arm (MDKBP, MDKBR), 0 Spring, Rocker Arm (MDKBS), Spring, Starter (V), Spring, Starter (V), Spring, Valve (MDKBP, MDKBR), 0 Spring, Valve (MDKBS), Spring, Valve Seat, Standoff, Insulator, Stator, Generator, Stator, Wound, Stiffener, Enclosure, Stopper, Camshaft, Stopper, Starter Set (V), Stopper, Starter Set (V), Strainer, Water Pickup, Strap, Bond, Strap, Electrical, Support, Fuel Return, Switch, High Exhaust Temperature, Switch, Pressure, Switch, Rocker (S), 0 Switch, Rocker (S) (Remote Control Panel), Switch, Rocker SPDT (Control Panel), Switch, Starter Solenoid (V), Switch, Starter Solenoid (V), System, Grounding, Tank, Coolant, Tank, Coolant Recovery, Tappet, Tappet Assy (MDKBS), Tappet Assy, Injection Pump (MDKBP, MDKBR), Tee, Keel Cooling, Tee, Keel Cooling (Wet Exhaust), Tee, Street, Thermostat, Tube, Breather (MDKBP, MDKBR), Tube, Breather (MDKBS), Tube, Flexible Exhaust, Tube, Low Pressure Switch, Tube, Oil Pickup (MDKBP, MDKBR), 0 Tube, Oil Pickup (MDKBS), Valve (MDKBS), Valve, Check (MDKBP, MDKBR), 0 Valve, Check (MDKBS), Valve, Delivery (MDKBP, MDKBR), Valve, Delivery (MDKBS), Valve, Exhaust (MDKBP, MDKBR), 0 Valve, Inlet (MDKBP, MDKBR), 0 Valve, Oil Drain Shutoff (MDKBS), Yoke Assy, Starter (V), Yoke Assy, Starter (V),
Cylinder Block, MDKBP, MDKBR 0 0 0 0 Engine, Replacement MDKBP 00 0 V 00 0 V MDKBR 00 0 V 00 0 V Cap, Sealing Plug Plug 0 Cap, Sealing Pin, Straight Plug Plug Plug 0 Pin, Straight Pin, Straight 0 Pin, Straight *Gasket, Cover *Cover, Fuel Camshaft *Bolt 0 Pin, Pipe 0 O Ring 0 0 Bracket, Lifting 00 Washer (M) 0 00 0 Screw, Hex Head Cap (M x. x mm) 0 Washer, Flat (M) 00 0 Screw, Hex Head Cap (M x. x mm) Plug Gasket Washer, Spring 0 Bolt 0 Nut, Flange Gear, Oil Pump Drive Key 0 Pump, Oil Gasket, Oil Pump Gasket, Hole Cover Cover, Hole 0 00 Washer, Flat 00 0 Bolt Cock, Drain Joint, Drain Cock * Parts Included in Keel Cooling Kit Found on Keel Cooling Dry Exhaust Page).
Cylinder Block, MDKBS 0 0 0 Engine, Replacement (MDKBS) 00 0 V 00 0 V 0 Block Assy, Cylinder (Includes Parts Marked #) 0 #Plug 0 #Cap, Sealing #Pin, Straight 00 #Plug #Cap, Sealing #Plug #Plug 0 #Pin, Pipe 0 0 #Pin, Straight #Pin, Straight #Plug #Pin, Straight #Plug Joint, Drain Cock Cock, Drain 0 O Ring Plug Gasket 0 0 Pump, Oil Gasket, Oil Pump 0 Bolt Washer, Spring 0 Gear, Oil Pump Drive Key 0 Nut, Flange 0 0 Bracket, Lifting Washer, Flat (M) 00 0 Screw, Hex Head Cap (M x. x mm) 0 00 0 Screw, Hex Head Cap (M x. x mm) 00 Washer (M) *Screw, Hex Head Cap (M x 0mm) 00 Washer, Flat *Cover *Gasket Cover, Hole Gasket, Hole Cover 0 00 Washer, Flat 00 0 Bolt # Parts included in Cylinder Block Assy. * Parts Included in Keel Cooling Kit Listed on Keel Cooling Dry Exhaust Page.
Crankshaft MDKBP, MDKBR 0 Crankshaft (Includes Balls and Sleeve) Ball Sleeve Gear 0 Key Slinger, Oil Collar O Ring 0 Nut 0 Seal, Oil Bearing 0 Standard 0. mm Undersize 0. mm Undersize Bearing, Main 0 Standard 0. mm Undersize 0. mm Undersize Bearing, Thrust Standard 0. mm Oversize 0 0. mm Oversize Standard 0. mm Oversize 0. mm Oversize 0
Crankshaft MDKBS 0 0 Crankshaft (Includes Balls and Sleeve) Ball 0 Sleeve 00 Gear 0 Key 0 Gear, Oil Drive 0 Slinger, Oil 0 Collar O Ring 0 Bearing 0 Standard 0. mm Undersize 0. mm Undersize Bearing, Main 0 Standard 0. mm Undersize 0. mm Undersize Bearing, Thrust Standard 0. mm Oversize 0 0. mm Oversize Standard 0 0. mm Oversize 0 0. mm Oversize
Camshaft 0 0 Tappet 00 MDKBP, MDKBR 00 0 MDKBS Rod, Push 0 MDKBP, MDKBR 0 0 MDKBS Camshaft Assy (Includes Parts Marked *) 0 MDKBP, MDKBR 0 MDKBS *Camshaft 0 MDKBP, MDKBR 0 MDKBS *Screw, Set 0 *Screw, Set (MDKBS) 0 *Key 0 *Stopper, Camshaft *Gear, Camshaft 0 MDKBP, MDKBR 0 MDKBS 0 00 Bolt Gear Assy, Idle (Includes Bushing) 0 MDKBP, MDKBR 0 MDKBS Bushing, Idle Gear 0 MDKBP, MDKBR 0 MDKBS 0 Collar 0 Collar Ring, External Retaining Shaft, Idle Gear * Parts Included in Camshaft Assy
Piston Piston MDKBP Standard 0. mm Oversize MDKBR Standard 0 0. mm Oversize MDKBS Standard 0 0. mm Oversize Set, Ring MDKBP Standard 0 0. mm Oversize MDKBR Standard 0 0. mm Oversize MDKBS Standard 0 0. mm Oversize Pin, Piston MDKBP, MDKBR MDKBS Ring, Retaining MDKBP, MDKBR 0 MDKBS Rod Assy, Connecting (Includes Bushing, Bearing and Bolts) MDKBP, MDKBR MDKBS Bushing 0 MDKBP, MDKBR 0 MDKBS Bearing Standard 0 MDKBP, MDKBR 0 MDKBS 0. mm Undersize MDKBP, MDKBR MDKBS 0. mm Undersize MDKBP, MDKBR MDKBS Bolt MDKBP, MDKBR 0 MDKBS
Flywheel 0 Flywheel Assy (Includes Ring Gear) 0 MDKBP, MDKBR 0 MDKBS 0 0 Plug, Hole 0 0 Adapter, Engine 0 Washer, Flat (M) 00 0 Screw, Hex Head Cap (M x. x 0mm) 0 Washer, Flat (M0) 00 00 Screw, Hex Head Cap (M0 x. x 0mm) 00 Pin, Parallel Hard (MDKBP, MDKBR) Starter (See Separate Page For Components) V 0 V 0 0 Washer, Flat (M) 00 Screw, Hex Head Cap (M x. x mm)
Starter Components (V) 0 0 Starter 0 Set, Screw Bracket Assy, Front Gear Drive Assy Cover Assy Stopper, Set Lever Assy Spring, Set Bracket Assy, Center 0 Armature (Includes Bearings) Bearing, Center Bearing, Rear Yoke Assy Holder Assy, Brush Spring, Brush Bracket, Rear Bolt, Set Switch, Solenoid Gear, Set 0 Drive Assy
Starter Components (V) 0 0 0 Starter 0 Set, Screw Bracket Assy, Front (Includes Bearing) Gear Drive Cover Assy, Rear (Includes Cover Plate, Washers, Screws, and Snap Ring) 0 Pinion Set (Includes Pinion, Spring & Stopper Set) Stopper, Set (Includes Ring) Lever Assy 0 Spring Set 0 Bracket, Center 0 Armature (Includes Bearings) Bearing, Center Sleeve Bearing, Rear Sleeve 0 Yoke Assy (Includes Pole Shoes, Field Coil, Positive Brushes) 0 Holder, Brush (Includes Negative Brushes) Spring, Brush Bracket, Rear Bolt, Set 0 Switch, Solenoid (Includes Shims) 0 Gear, Set Drive Assy
Main Bearing Housing MDKBP, MDKBR 0 Housing, Main Bearing 0 Bolt, Bearing Housing Gasket, Bearing Housing Cover, Bearing Housing Gasket, Bearing Housing Cover 0 Bolt 0 Bolt Seal, Oil Housing, Main Bearing 0 Housing, Main Bearing Housing, Main Bearing Bolt, Bearing Housing
Main Bearing Housing MDKBS 0 Housing, Main Bearing 0 0 Bolt, Bearing Housing Gasket, Bearing Housing Gasket, Bearing Housing Cover 0 Bolt 0 Bolt 0 Seal, Oil Housing, Main Bearing Housing, Main Bearing 0 Housing, Main Bearing 0 Housing, Main Bearing Bolt, Bearing Housing Cover, Bearing Housing
Fuel Camshaft 0 0 0 Camshaft Assy, Fuel (Includes Parts Marked *) 0 0 *Camshaft, Fuel *Bearing, Ball 0 *Gear, Injection Pump *Key, Feather 0 *Clip, External Circular 0 *Sleeve, Governor 0 *Clip, Governor Sleeve 0 0 *Case, Governor Ball 0 0 00 *Ball 0 *Clip, Circular 0 0 *Ball Bearing, Ball 0 0 Stopper, Fuel Camshaft 00 Bolt Cover, Fuel Camshaft Gasket Clip, External Circular 00 0 Bolt * Parts Included in Fuel Camshaft Assy
Speed Control 0 00 0 Bolt, Adjusting Maximum Fuel 0 0 Nut Gasket Nut 00 Lever, Speed Control Key, Feather 0 0 O Ring 0 Washer, Plain 0 Nut 0 0 Collar 0 Plate, Speed Control 0 Gasket 0 Bolt 0 Stud 0 0 Washer, Spring Nut 0
Governor 0 0 0 Lever, Governor 0 0 Lever Assy, Fork (Includes Parts Marked *) 0 000 Spring, Governor 0 0 *Lever Assy, Fork (Includes Pin) 0 0 *Shaft, Fork Level *Bolt 00 0 *Bolt, Flange 0 0 *Washer, Spring 0 0 *Holder, Fork Lever 0 00 0 *Bolt Bolt Bolt 0 00 Washer, Plain Washer, Plain 0 000 Spring, Start * Parts Included in Fork Lever Assy.
Engine Stop Lever MDKBP, MDKBR 0 Lever Assy, Engine Stop (Includes Parts Marked #) #Lever, Engine Stop #Pin, Spring #Seal, Oil #Cover, Injection Pump #Shaft, Lever Bolt Gasket, Injection Pump Cover Bolt, Adjusting 0 Gasket Nut 0 Nut, Cap Cap # Parts Included in Engine Stop Lever Assy
Engine Stop Lever MDKBS 0 Cover 0 Gasket Bolt 0 Bolt Assy, Adjusting Governor Adjust (Includes Parts Marked *) *Bolt, Adjusting *Nut 0 *Nut, Cap *Gasket *Cap 0 Lever Assy, Engine Stop (Includes Parts Marked #) #Cover, Injection Pump #Shaft, Lever #Lever, Engine Stop #Seal, Oil #Pin, Spring #Bolt Gasket * Parts Included in Adjusting Bolt Assy. # Parts Included in Engine Stop Lever Assy.
Injection Pump MDKBP, MDKBR 0 0 Pump Assy, Injection (See Separate Page for Components) Shim Standard.0mm.mm Shim.mm.0mm 0 Bolt 0 Stud Nut Washer, Spring 0 Screw, Follow Joint, Eye 0 Gasket
Injection Pump MDKBS Pump Assy, Injection (See Separate Page for Components) Shim.0mm 0.mm.0mm 0 Bolt Stud Nut Washer, Spring 0 Screw, Follow Joint Gasket
Injection Pump Components MDKBP, MDKBR 0 Pump Assy, Injection Holder, Delivery Valve O Ring 0 Spring, Delivery Valve Gasket, Delivery Valve Valve, Delivery Plunger, Pump Plate Pin, Tappet Guide Sleeve, Control 0 Seat, Upper Spring Spring, Plunger Seat, Lower Spring Shim Tappet Assy 0 Rack, Control Gasket Screw, Hollow Lock Assy, Plate
Injection Pump Components MDKBS 0 0 Pump Assy, Injection Plunger, Pump Valve, Delivery Spring, Delivery Valve Gasket, Delivery Valve Holder, Delivery Valve O Ring Tappet Assy Pin, Tappet Guide 0 Spring, Plunger Seat, Upper Spring Seat, Lower Spring Shim Rack, Control Sleeve, Control Screw, Hollow Gasket Plate Plate 0 Plate Assy, Lock 0 Plate Assy, Lock
Cylinder Head MDKBP, MDKBR 0 Stud 0 MDKBP 0 MDKBR Head Assy, Cylinder (Includes Parts Marked *) MDKBP 0 MDKBR *Plug *Cap, Sealing *Cap, Sealing *Guide, Inlet Valve *Guide, Exhaust Valve Washer (With Rubber) Plug 0 Bolt, Cylinder Head Gasket, Cylinder Head MDKBP MDKBR 0 O Ring * Parts Included in Cylinder Head Assy.
Cylinder Head MDKBS 0 0 Head Assy, Cylinder (Includes Parts Marked #) #Cap, Sealing #Cap, Sealing #Plug #Guide, Inlet Valve #Guide, Exhaust Valve Bolt, Cylinder Head 00 Gasket, Cylinder Head Plug 0 Washer (with Rubber) 0 O Ring # Parts Included in Cylinder Head Assy.
Rocker Arm MDKBP, MDKBR 0 0 0 0 0 Valve, Inlet 0 Valve, Exhaust 0 Spring, Valve 0 Retainer, Valve Spring 0 Collet, Valve Spring 0 Seal, Valve Stem 0 Cap, Valve 00 Shaft Assy, Rocker Arm (Includes Set Screws) Screw, Set 0 0 Bracket, Rocker Arm 0 Stud Nut Washer, Spring 0 00 Washer, Flat Pin, Spring 0 Washer, Rocker Arm Shaft 0 Spring, Rocker Arm 0 Ring, External Retaining 0 Arm Assy, Rocker (Includes Screw and Nut) 0 0 Screw, Adjusting 00 Nut 0
Rocker Arm MDKBS 0 0 0 0 0 0 0 Valve, Inlet 0 Valve, Exhaust 0 0 Spring, Valve 0 0 Retainer, Valve Spring 0 0 Collet, Valve Spring 0 0 Seal, Valve Stem 0 0 Cap, Valve 0 Shaft Assy, Rocker Arm (Includes Set Screws) Screw, Set 0 0 Bracket, Rocker Arm 0 Stud Nut Washer, Spring 0 00 Washer, Flat Pin, Spring 0 Washer 0 Spring, Rocker Arm 0 Ring, External Retaining 0 0 Arm Assy, Rocker (Includes Screw and Nut) 0 0 0 Screw, Adjusting 00 0 Nut
Nozzle Holder MDKBP, MDKBR 0 Clamp, Pipe Screw (With Washer) Pipe, Injection Pipe, Injection Pipe, Injection Pipe, Injection Clamp, Pipe Cord, Glow Plug Assy, Glow Plug (Includes Nut and Washer) 0 V V 0 Pipe, Overflow 0 Holder Assy, Nozzle (Includes Nozzle) 0 Nozzle Gasket, Nozzle Seal, Heat
Nozzle Holder and Glow Plug MDKBS 0 00 Pipe, Overflow 0 Holder Assy, Nozzle (Includes Nozzle, Gasket and Heat Seal 0 Nozzle Gasket Seal, Heat 0 Pipe, Injection 0 Pipe, Injection 0 Pipe, Injection 0 Pipe, Injection 0 00 Pipe, Injection Clamp, Pipe Clamp, Pipe Screw (With Washer) Plug, Glow 0 V V Cord, Glow Plug Nut, Flange 00 Washer, Flat
Water Outlet Flange 0 Flange, Water Outlet (Includes Pipe) 0 Pipe, Water Return Gasket 0 Bolt Stud Bolt MDKBP, MDKBR 00 MDKBS Nut Washer, Spring 000 Pipe, Water Return 0 00 Band, Pipe Plug 00 Cover, Thermostat 00 Gasket, Thermostat Cover Bolt MDKBP, MDKBR MDKBS 00 Thermostat +Sender, Water Temperature (E) 0 Negative Ground 0 0 Isolated Ground 0 00 Plug, Square Head Pipe (/ ) MDKBP, MDKBR 0 Clip, Wire (MDKBS) *Kit, Sender (Includes Water Temperature Sender) 00 00 Negative Ground 00 0 Isolated Ground * Kit Also Includes Oil Pressure Sender Listed on Oil Pan Page. + Water Temperature Sender ties to E Iso Harness (See Isolated Ground 00 0)
Cylinder Head Cover MDKBP, MDKBR 0 Cover, Cylinder Head Gasket, Cover 0 Breather Gasket, Breather 00 Bolt Element, Breather Plate Tube, Breather Clamp, Hose 0 Nut, Cap Gasket
Cylinder Head Cover MDKBS 0 0 Cover, Cylinder Head 0 Gasket, Cover 0 Breather Gasket 00 Bolt Element, Breather Plate Nut, Cap Gasket 0 Tube, Breather Clamp 0 Cover, Oil Fill O Ring
Gearcase 0 0 0 0 Gearcase Assy (Includes Parts Marked *) MDKBP, MDKBR MDKBS 0 *Plug Bolt 0 Bolt Bolt 0 Washer, Spring 0 Seal, Oil (MDKBS) Bolt 0 Bolt 0 Washer, Flat Joint, Pipe Spring Ball Seat, Valve *Pin, Start Spring Bolt 0 00 Washer, Flat Stud (Bottom)(MDKBP, MDKBR) Washer, Spring(MDKBP, MDKBR) 0 Nut (MDKBP, MDKBR) Bolt (Bottom)(MDKBS) 00 Filter, Oil Bolt (Top)(MDKBS) 0 Plug, Oil Fill O Ring Flange, Oil Fill Stud (Top)(MDKBP, MDKBR) Gasket 0 Gasket 0 Flange, Water Return 0 Bolt 0 Gasket 0 *O Ring *Pin, Straight *O Ring (MDKBP, MDKBR) *O Ring (MDKBS) *O Ring (MDKBS) * Parts Included in Gearcase Assy
Water Pump 0 Pump Assy, Water (Includes Parts Marked *) 00 MDKBP, MDKBR 0 MDKBS 00 *Bearing, Ball 00 *Impeller 0 *Seal *Flange 00 MDKBP, MDKBR MDKBS 0 Gasket 0 Bolt Stud 0 MDKBP, MDKBR 0 MDKBS Washer, Spring 0 Nut Bolt Pulley 0 MDKBP, MDKBR 0 MDKBS 0 Bolt, Flange * Parts Included in Water Pump Assy
Alternator MDKBP, MDKBR (Negative Ground) 0 Alternator, Complete (See Separate Page for Components) V V Bracket, Adjusting 0 V V Bolt MDKBP MDKBR Washer, Spring Bolt Washer, Flat Nut 0 Washer, Spring 0 Pulley, Fan Drive 0 0 Key 0 Washer, Flat Nut
Alternator MDKBS (Negative Ground) Volt Volt 0 0 Alternator (See Separate Page for Components) V V 0 Bolt Washer, Spring 0 Washer, Flat Nut Bolt Washer, Flat Nut Washer, Spring 0 Bracket, Adjusting 0 V V Collar 0 Pulley 0 Bolt Coupler Assy 0 Connector Terminal 0
Alternator (Isolated Ground) (V/V) 0 Alternator, Complete (No Components Available) 0 V 0 V 0 Strap, Alternator 0 Bracket, Alternator 00 00 Screw, Hex Head Cap (/ x / 0 000 Washer, Lock (/ ) 00 Washer, Flat (/ ) 00 00 Screw, Hex Head Cap (/ x / ) 0 00 Washer, Lock (/ ) 0 Belt 0 0 Washer, Flat (/ ) 00 Nut (/ ) 0 Pulley, Alternator Screw, Hex Head Cap 00 0 (M x 0mm) (MDKBP, MDKBR) 00 0 (M x 0mm)(MDKBS) 00 00 Screw, Hex Head Cap (M0 x 00) 0 Washer, (M0) 0 00 Washer, Lock (M0) 0 00 Nut, Hex (M0) 0 Washer (MDKBS) * Alternator ties to G GND, Iso Ground Harness (See Isolated Ground 00 0)
Alternator Components (Negative Ground) (V) 0 0 Alternator (V) Pulley Nut Collar Frame, Drive End (Includes Parts Marked *) 0 *Bolt, Through Screw, Round Head *Bearing *Plate, Retainer *Screw, Round Head 0 0 Rotor (Includes Bearing and Cover) Bearing Cover, Bearing Insulation, Brush Nut Bolt Cover, End Screw, Round Head Holder Assy, Brush (Includes Brushes and Springs) Brush 0 Spring, Brush Screw, Round Head Regulator 0 Rectifier Nut 0 Bolt Frame, End Washer, Thrust * Parts Included in Drive End Frame
Alternator Components (Negative Ground) (V) 0 0 Alternator (V) 0 Pulley Nut Collar Frame, Drive End (Includes Parts Marked *) 0 *Bolt, Through Screw, Round Head *Bearing *Plate, Retainer *Screw, Round Head 0 0 Rotor (Includes Bearing and Cover) Bearing Cover, Bearing Insulation, Brush Nut Bolt Cover, End Screw, Round Head Holder Assy, Brush (Includes Brushes and Springs) Brush 0 Spring, Brush Screw, Round Head 0 Regulator Rectifier Nut 0 Bolt Frame, End * Parts Included in Drive End Frame
Governor Actuator REF PART QTY. PART NO. NO. USED DESCRIPTION Actuator, Governor 0 0 0 (V) 0 0 0 (V) 0 0 *Nut Stainless Steel (M x ) 0 0 *Washer, Spit Lock Stainless Steel (M) 00 Gasket, Solenoid Cover * Reuse existing Hardware.
Fuel Pump 0 0 0 0 Bracket, Fuel Pump 0 000 Elbow, Pipe 0 0 Connector, Male 0 0 Connector, Hose 0 Filter, Fuel (Includes Element, Plug and Filter Base) 0 Element 0 00 Plug, Drain Base, Filter 0 0 Washer, Centering (V) 0 0 Resistor (. ohms) (V) 000 Washer, EIT (#0) (V) 0 Screw, Round Head Machine (#0 x. ) (V) 00 0 Screw, Hex Flange (M x x ) 0 0 Connector, Hose 0 0 Clamp, Hose 0 00 0 Hose, Fuel Pump, Fuel 0 00 Elbow, Street Pipe 0 0 Elbow, Street 0 0 00 Washer, Lock Split (M) 00 0 Screw, Hex Head (M x. x 0) 0 00 0 Hose, Fuel (/ x.) 0 0 Adapter, Pipe (/ NPT)
Fuel Return, Oil Sender, 0 0 Kit, Fuel Adapter (/ Hose) Kit, Fuel Adapter (/ Hose) 0 Adapter, Pipe 0 00 Elbow, Inverted Female 0 0 Connector, Hose 0 0 Clamp, Hose 0 00 0 Hose, Fuel (/ x. ) 0 00 Elbow, Street 0 Tee, Street (/ NPT) 0 Support, Fuel Return 0 Washer, Fl (M) 0 00 0 Screw, Hex Head Cap (M x. x mm) 0 Coupling, Anchor 0 0 Connector, Male 0 00 0 Hose, Fuel (/ x 0 ) 0 0 Elbow, Inverted Male 0 Line, Oil 0 000 Connector, Male IN 0 Manifold, Oil Pressure Sender, Oil Pressure 0 Neg Ground with Gauges 00 0 Iso Ground with Gauges 0 00 Plug, Hex Head Pipe 0 0 Connector, Female Bulkhead 00 Washer, Flat (M) Line, Fuel 0 0 0 MDKBP, MDKBR 0 0 0 MDKBS Line, Fuel 0 0 0 MDKBP, MDKBR 0 0 0 MDKBS * Oil Sender ties to E, Iso Ground Harness (See Isolated Ground 00 0)
Remote Water Separator REF PART QTY. PART REF PART QTY. PART 0 Kit, Remote Fuel/Water Separator 0 0 Separator, Fuel/Water (See Separate Page for Components) 0 0 Bracket, Separator Mounting 0 000 Elbow, Street 0Degrees 0 00 Bushing, Pipe
Water Separator Components 0 0 Separator, Water 0 Kit, Metal Bowl Replacement (Includes Plug, O Rings and Drain Assy) Drain Assy (Includes Knob and Seal) 0 Element (Includes Seals) 0 0 Plug, Hex (/ ) Head Assy, Replacement (Includes Vent Plug, O Rings, Seal, Cap, Tube and Pump Assy) Plug, Vent (Includes O Ring) 0 Pump Assy (Includes Plunger, Retainer, Shaft, Check Ball, Knob and Screw) 0 O Ring Kit (Includes Seal and Plunger)
Blank Page
Break Siphon MDKBP, MDKBR 0 Kit, Siphon Break 0 Hose, Coolant 0 0 Valve, Check 0 0 Cap, Tube 0 0 Clamp, Hose 0 Connector, Hose 0 Hose, Water 0 0 0 Clamp, Hose 0 0 Adapter, Hose 0 0 *Grommet, Rubber * Parts not shown but included in kit. 0
Break Siphon MDKBS 0 0 Kit, Siphon Break 0 Hose, Coolant 0 0 Valve, Check 0 0 Cap, Tube 0 0 Clamp, Hose 0 Connector, Hose 0 0 *Clamp, Hose 0 0 *Grommet, Rubber * Parts not shown but included in kit.
Heat Exchanger 0 0 0
Heat Exchanger Exchanger, Heat 0 00 0 MDKBP, MDKBR 0 00 0 MDKBS 0 Pencil, Zinc (w/screw) Clamp, Hose 0 ( )MDKBP, MDKBR 0 (. )MDKBS 00 00 Screw, Hex Head Cap (M0 x. x 0mm) 0 Washer, Flat (M0) Bracket, Heat Exchanger 0 0 MDKBP, MDKBR 0 0 MDKBS 0 Clamp, Hose ( / ) 0 Clamp, Hose ( ) 0 Hose, Exhaust Manifold ( / ) (Includes Sleeving) 0 Hose, Engine Coolant ( / ) 0 MDKBP, MDKBR 0 MDKBS 0 00 Hose, Coolant Tank Lower ( x ) 0 0 Clamp, Hose Hose, Mixer 0 (/ x ) MDKBP, MDKBR 0 0 (/ x ) MDKBS Clamp, J 0 Pump, Raw Water (See Separate Page for Components) 00 0 Screw, Hex Head Cap (M x. x 0mm) 00 Washer, Flat (M) 0 Gasket, Water Pump Hose, Water Pump ( ) 0 MDKBP, MDKBR 0 MDKBS 0 0 0 Switch, Pressure 0 0 0 Hose, Coolant 0 0 Tube, Low Pressure Switch 0 Kit, Minor Service (Includes O Rings and Impeller) 0 O Ring 0 Impeller 0 Kit, Heat Exchanger Zinc Pencil (Includes Parts Marked +) (MDKBP, MDKBR) 0 0 +Kit, End Cover (Includes Parts Marked *) 00 0 +Screw, Hex Head (/ x / ) 0 0 +Washer, Lock (/ ) 0 *Cover, Heat Exchanger 0 W/O Zinc Pencil Boss) 0 0 W/Zinc Pencil Boss) *Gasket, Cover 0 W/O Zinc Pencil Hole 0 0 W/Zinc Pencil Hole 0 *Pencil, Zinc (w/o Screw) 0 Connector, Bulkhead Hose, Coolant 0 0 0.mm Length MDKBP, MDKBR 0 0 0.mm Length MDKBS 00 0 Screw, Hex Head Sems Stainless (M x x mm) + Parts Included in Heat Exchanger Zinc Pencil Kit. * Parts Included in End Cover Kit.
Keel Cooling (Wet Exhaust) 0 0
Keel Cooling (Wet Exhaust) 0 Gasket, Water Pump 00 Washer, Flat (M) 00 0 Screw, Hex Head Cap (M x 0mm) 0 Pump, Raw Water 0 0 Clamp, Hose Hose 0 MDKBP, MDKBR (/ x ) 0 0 MDKBS Clamp, J 0 *Clamp, Hose ( ) 0 0 0 Hose, Lower Coolant (Cut to Fit) 0 0 0 *Adapter (/ NPT x Barb) 0 0 *Elbow, 0 *Adapter (/ NPT) 0 0 / Barb (MDKBP, MDKBR) 0 0 / Barb (MDKBS) 0 0 *Hose, Coolant ( / x ) 0 0 0 *Nipple, Half 0 000 *Elbow 0 00 *Tee 0 0 *Barb, Hose 0 00 *Elbow 0 *Clamp, Hose ( / ) 0 0 0 0 Hose, Coolant ( x 0 ) 0 Kit, Keel Cooling (Includes Parts Marked *) 00 Kit, Water Pump Service (Includes Impeller and O Ring, Wear Plate, Cover, Lip Seal, Cam, Seal Washer, Cam Screw, and Key) (MDKBS) 0 0 Connector, Bulkhead * Parts Included in Keel Cooling Kit.
Water Pump Components, 0 0 Kit, Major Service 0 Cover 0 O Ring 00 Screw, Cam 0 Washer, Seal 0 Cam 0 Impeller 0 Plate, Wear 0 Seal, Seat Assy 0 Ring, Retaining 0 0 Seal, Lip 0 Key 0 Ring, Retaining 0 Kit, Minor Water Pump Service (Includes Impeller and O Ring)
Keel Cooling System (Dry Exhaust) 0 Kit, Exhaust 0 Clamp, Hose ( / ) 0 0 *Hose, Coolant ( / x ) 0 0 0 *Nipple, Half 0 000 *Elbow 0 00 Tee 0 0 *Barb, Hose 0 0 0 *Hose, Coolant ( x 0 ) 0 00 *Elbow 0 Clamp, Hose ( ) 0 0 Kit, Keel Cooling (Includes Parts Marked *) * Parts Included in Keel Cooling Kit. (Also Includes Cover, Gasket and Hardware Found on Cylinder Block Page.)
Coolant Tank 0 0 Tank, Coolant 0 Cap, Tank 0 Clamp, Hose ( / ) Hose, Upper Elbow 0 MDKBP, MDKBR 0 MDKBS 0 Hose, Upper S ( / ) 00 Washer, Flat (M) 00 0 Screw, Hex Head Cap (M x. x mm) 0 0 Plug, Hex Pipe (/) 0 Sender, Low Coolant
Coolant Recovery 0 Kit, Coolant Recovery 0 0 Tank, Coolant Recovery 0 Hanger, Tank 0 Hose (/ I.D. x 0 Lg.) 0 Cap, Tank 0 Hardware Package (Includes Mounting Hardware)
Oil Pan MDKBP, MDKBR 0 0 Pan, Oil Gasket Bolt, Flange 0 Plug Gasket 0 *Bolt *Gasket Tube, Oil Pickup Bolt 0 0 O Ring Indicator, Oil Level 0 0 Adapter, Oil Drain 0 0 Line, Flex Oil ( ) 0 0 Elbow, Pipe 0 0 Cap, Pipe 0 Washer, Oil Drain (.ID x.od x.0thk) 0 0 Bracket, Oil Drain 00 0 Screw, Hex Flanged (M x x mm) 00 0 Screw, Hex Head (M x x 0mm) 0 0 00 Washer, Lock Split (M) 0 Washer, Flat (M) * Bolt and Gasket Removed with Installation of Oil Drain. 0
Oil Pan MDKBS 0 Pan, Oil 0 Gasket 0 Bolt Bolt *Plug (Removed with Installation of Oil Drain) *Gasket (Removed with Installation of Oil Drain) 0 Tube, Oil Pickup Bolt 0 0 O Ring 0 0 Indicator, Oil Level 0 Washer, Oil Drain (/ ) 0 0 Adapter, Oil Drain 0 Elbow, Pipe 0 0 00 Valve, Shutoff 0 0 Bushing, Reducer 0 00 Fitting, Hose Barb * Circled Bolt and Gasket Removed with Installation of Oil Drain.
PTO 0 0 Kit, PTO (Includes Parts Marked *) MDKBP, MDKBR 0 0 0 V 0 0 0 V MDKBS 0 0 0 V 0 0 0 V 0 0 Kit, PTO Belt (Includes Tool Spacer and Belt) *Adapter, Coupling 0 0 0 MDKBP, MDKBR 0 0 0 MDKBS *Screw, Socket Head Cap 0 MDKBP, MDKBR (M x. x mm) 00 0 MDKBS(M0 x. x mm) 0 0 *Coupling, Flex 0 *Screw, Socket Head Cap (M x. x 0mm) 0 00 *Screw, Hex Head Cap (/ x ) 0 *Washer, Flat 0 0 0 *Adapter, Coupling *Clutch 0 0 0 V 0 0 0 V 0 0 0 *Bracket, PTO Clutch 0 00 000 *Screw, Hex Head Cap (/ x.00 ) 00 0 *Screw, Hex Head Cap 0 0 *Washer, Flat (M) 00 0 *Screw, Hex Head (M x. x 0mm)) 0 *Washer, Flat Stainless (M) 0 *Screw, Locking Flange (M x x mm) 0 0 0 *Bracket, Mounting Pad 00 *Nut, Hex (M) 0 *Screw, Socket Head (M x. x mm) 0 0 0 *Bracket, PTO (Left) 0 00 0 *Screw, Hex Head Cap (M x. x mm) *Shim, PTO 0 0 0 AR. GA 0 0 0 AR. GA 0 0 0 AR.0 GA 0 00 0 *Bracket, PTO (Right) * Parts Included in PTO Kit. (Also Includes Fuel Pump Mounting Hardware Found on Fuel Pump Page)
Intake Manifold 0 Manifold Assy, Intake MDKBP, MDKBR 0 MDKBS Joint, Breather Gasket 0 MDKBP, MDKBR 0 MDKBS Bolt 0 MDKBP, MDKBR 0 MDKBS Resonator, Intake 0 MDKBP, MDKBR 0 0 MDKBS 0 0 Sleeve, Air Intake *Clamp, Hose 0 MDKBP, MDKBR ( / ) 0 MDKBS ( ) 0 Clamp, Hose ( ) Hose, Intake 0 MDKBP, MDKBR ( / x ) 0 00 0 MDKBS ( / x ) 0 Cable, Tie
Exhaust Manifold *Gasket, Riser, Adapter Gasket, Exhaust Manifold Manifold, Exhaust MDKBP, MDKBR 00 MDKBS Stud 0 0 MDKBP, MDKBR 0 0 MDKBS Washer, Flat (M) 00 MDKBP, MDKBR 00 0 MDKBS Nut (M x.) 0 00 MDKBP, MDKBR 0 00 0 MDKBS * Part Included in Exhaust Adapter Kit Found on Dry Exhaust Page.
Wet Exhaust 0 Kit, Exhaust (Wet) 0 0 MDKBP, MDKBR (Rear Out) 0 0 MDKBP, MDKBR (Front Out) 0 0 MDKBS (Rear Out) 0 0 MDKBS (Front Out) Kit, Exhaust (Wet) 00 0 Screw, Hex Head Cap (M x. x 0mm) 00 Washer, Flat (M) 00 Screw, Hex Head Cap (M x. x 0mm) Riser, Exhaust 0 000 Nut, Hex ( ) 0 00 Washer, Lock (M) 0 Gasket, Mixer Mixer 0 00 Washer, Flat (M) 0 0 0 Screw, Socket Cap (M x x 0mm) 0 0 0 Switch, High Exhaust Temperature (S) Hose, Exhaust Front 0 MDKBP, MDKBR 0 MDKBS Rear 0 0 0 MDKBP, MDKBR 0 0 0 MDKBS 00 0 Screw, Hex Head Sems Stainless (M x x mm) 0 0 Bulkhead, Exhaust Connector 0 Clamp, Hose Exhaust
Dry Exhaust (Up or Down) 0 Riser, Exhaust 00 Screw, Hex Head Cap (M x. x 0mm) 00 0 Screw, Hex Head Cap (M x. x 0mm) 00 Washer, Flat (M) 0 Kit, Exhaust Adapter (Includes Parts Marked *) 0 *Adapter, Exhaust 0 00 *Washer, Lock (M) 0 *Screw, Hex Head Cap (M x. x mm) *Gasket, Exhaust Adapter 0 0 0 *Flange, Exhaust 0 0 0 *Coupling, Reducer ( x / ) 0 Kit, Exhaust Flange (Includes Parts Marked +) 0 +Gasket, Exhaust (Mixer) 0 0 +Flange, Exhaust 0 00 +Washer, Flat (M) 0 0 +Screw, Allen Socket Cap (M x x 0mm) Jumper, Temp Switch * Parts Included in Exhaust Adapter Kit.(Also Includes Gasket on Exhaust Manifold Page.) + Parts Included in Exhaust Flange Kit.
Muffler REF PART QTY PART NO. NO. USED DESCRIPTION 0 Tube, Flexible Exhaust ( ) Muffler, Dry Exhaust (Up) ( ) 0 0 Industrial 0 0 Critical
Water Separator, Muffler,, Kit, Muffler, Separator (Includes Parts Marked *) MDKBP, MDKBR MDKBS Kit, Muffler (Includes Parts Marked +) 00 MDKBP, MDKBR MDKBS Kit, Water Separator (Includes Parts Marked #) MDKBP, MDKBR MDKBS *+Muffler, Marine 0 MDKBP, MDKBR 0 MDKBS Clamp, Hose ( ) MDKBP, MDKBR 0 + Muffler Kit ( ) 0 # Separator Kit ( ) 0 0 * Muffler, Separator Kit ( ) MDKBS 0 + Muffler Kit ( / ) 0 # Separator Kit ( ) 0 0 * Muffler/Separator Kit ( ) 00 *+Strainer, Water Pickup *#Separator, Water ( )MDKBP, MDKBR ( / )MDKBS 0 *#Clamp, Hose ( / ) * Parts Included in Muffler/Separator Kit. + Parts Included in Muffler Kit. # Parts Included in Water Separator Kit.
Isolated Ground 0 REF PART QTY. PART REF PART QTY. PART Kit Isolated Ground (Includes Screws, Sending Units and Harness) 0 V 0 V 0 0 Bracket, Solenoid *Relay, Solenoid 0 V 0 V 0 Washer, Flat (M) 0 0 Washer, Split Lock (M) 00 Nut, Hex (M) 00 0 Screw, Hex Head Cap (M x. x 0) 0 0 0 Nut, ET Hex (#0 ) (V) 00 Washer, ET Lock (/ ) 00 0 Nut, Hex (/ ) 0 00 0 Harness, Isolated Ground 00 0 Harness, Ground * Relay Solenoid ties to B and K Isolated Ground Harness ( 00 0)
Mounting Base 0 Base, Generator Mounting 0 0 MDKBP, MDKBR 0 0 MDKBS Isolator, Mounting W/O PTO 0 MDKBP, MDKBR 0 MDKBS With PTO 0 MDKBP, MDKBR 0 MDKBP, MDKBR 0 MDKBS 0 0 MDKBS 0 Washer, Flat (M) 0 00 Nut, Hex Machine (M x.mm) Washer, Flat (M) 0 Without PTO 0 With PTO 00 0 Screw, Hex Head Cap (M x. x mm) 00 Screw, Hex Head Cap (M x. x 0mm) 0 Washer, Rocker Ball (MDKBS) 00 00 Screw, Hex Head Cap (MDKBS) (M0 x. x 0mm) 0 Mount, Engine 0 0 0 MDKBS 0 0 MDKBS 0 0 0 MDKBP, MDKBR Screw, Hex Head Cap (M x. x 0mm) 00 0 without PTO 00 0 with PTO 0 0 Edging 0
Grounding System 0 00 Washer, EIT Lock (/ ) Strap, Bond 0 Washer, Flat (M) 00 0 Screw, Hex Head Cap (M x. x 0mm) 00 0 Screw, Hex Head Cap (M x. x 0mm) 00 Washer, Flat (M) 000 Washer, EIT Locking (/ ) 0 00 Nut, Hex (M x.mm) 0 Bar, Bus 0 00 Nut, Hex Brass (/ ) 000 0 Strap, Electrical
Belt Guard and PTO Belt Guard 0 0 0 Kit, Belt Guard (Neg Ground) (Includes Parts Marked*) 0 0 Kit, Belt Guard (ISO Ground) (Includes Parts Marked+) 0 0 Kit, Belt Guard (PTO) (Includes Parts Marked~) Guard, Belt W/O PTO 0 0 Negative Ground 0 0 Isolated Ground 0 0 ~Guard, Belt W/PTO 0 0 0 ~Coupling Guard W/PTO Bracket, Guard 0 0 *~ Negative Ground/PTO 0 0 + Isolated Ground 0 0 *Bracket, Guard (Negative Ground) 0 0 *~Bracket, Guard (Negative Ground/PTO) 0 0 *+~Bracket, Guard *+~Screw, Hex Head Cap (M x ) 00 0 Negative Ground 00 0 Isolated Ground 00 0 PTO 0 *~Screw, Hex Head Cap (M x. x mm) Neg Ground and PTO 0 0 0 ~Coupling, Guard / PTO 0 *+~Label, Warning All Parts are for Unhoused Units Only * Parts Included in Negative Gnd Belt Guard Kit + Parts Included in ISO Gnd Belt Guard Kit ~ Parts Included in PTO Belt Guard Kit
Generator Housing 0 Panel, Housing 0 0 Single Phase 0 0 Three Phase 00 0 Screw, Hex Head Cap (M x x mm) 00 Washer Lock ET (M) 00 0 0 Screw, Hex Head Stainless (M x.0 x mm) Insulation, Panel (Side) 0 Single Phase 0 0 Three Phase 0 Insulation, Panel (Top) 00 Seal, Weather (. ) 0 Grommet, Rubber 0 0 0 Isolation, Vibration 0 0 0 Rivet, Pop 0 Insulation, Panel (Top) 0 Insulation, Panel (Rear) 0 0 0 Cover, Enclosure (Rear) 000 Screw, Slotted Round Head (#0 x.0) 000 Washer, EIT Lock (#0) 0 0 Nut, Sems
Generator Housing Panel 0 REF PART QTY. PART REF PART QTY. PART 00 Kit, Panel (Gen) 0 0 Panel, Housing 00 0 Screw, Hex Sems Stainless Steel (M x x mm) 0 0 Screw, Round Head Brass (/ 0 x /) 0 Lug, Solderless 00 Washer, ET (M) 0 Insulation, Sound 000 Washer, EIT (/ ) 0 Washer, Flat (M) 0 0 Nut, Hex (M) 0 0 Washer, Flat 0 Harness, Battery (Includes Parts Marked *) 00 *Washer, Flat Brass (/ ) *Cable, Welding 0 0. (MDKBP, MDKBR) 0 0 (MDKBS) 00 *Nut, (/ ) 0 0 Nut, Hex Acorn (/ 0 Nylon) 00 Nut, Hex Brass (/ 0) 00 Washer, Flat (/ ) 00 0 Screw, Hex Head Cap (M x x mm) * Parts Included in Battery Harness
Generator Baffle REF PART QTY. PART REF PART QTY. PART 0 0 0 Baffle, Generator 000 0 Screw, Torx Thread Form (M x 0. x mm) 0 00 Grommet, Rubber (MDKBP, MDKBR) 0 0 Bracket, Baffle 0 0 Seal, Brush 0 0 Plug, Hole 00 0 Screw, Hex Head Sems Stainless (M x.0 x mm) 0 0 Nut, Hex Head (M x mm) 00 Tape, Polyurethane (MDKBS)
Engine Sound Shield REF PART QTY. PART REF PART QTY. PART Kit, Sound Shield (Complete, Includes Roof, Doors, Ends And Insulation, Refer to Following Pages) 00 0 MDKBP, MDKBR 00 0 MDKBS Kit, Roof Panel (Includes Parts Marked *) 0 0 MDKBP, MDKBR 0 0 MDKBS *Panel, Roof 0 0 0 MDKBP, MDKBR 0 0 MDKBS *Insulation, Roof 0 0 MDKBP, MDKBR 0 MDKBS 0 0 *Cover, Access Screw, Hex Head Sems (M x x mm) 00 0 (MDKBP, MDKBR) 00 0 (MDKBS) 0 0 Rivet, Pop 0 0 *Stiffener, Enclosure (MDKBP, MDKBR) 0 0 *Gasket, Baffle * Parts Included in Roof Panel Kit.
Engine Panel Sound Shield REF PART QTY. PART REF PART QTY. PART 0 0 Kit, Door (Includes Parts Marked *) 0 0 *Door, Sound Shield 0 *Insulation, Door Seal, Weather 0 MDKBP, MDKBR 0. MDKBS 0 *Insulation, Door 0 0 *Latch, Door (/ Turn) *Seal, Weather 0. MDKBP, MDKBR 0. MDKBS * Parts Included in Door Kit.
Engine Panel Sound Shield REF PART QTY. PART REF PART QTY. PART Kit, Access Panel (Includes Parts Marked *) 0 0 MDKBP, MDKBR 0 0 MDKBS *Panel, Access 0 0 MDKBP, MDKBR 0 0 0 MDKBS *Insulation, Access Panel Sound Lower 0 0 MDKBP, MDKBR 0 0 MDKBS *Insulation, Access Panel Sound, Upper 0 0 MDKBP, MDKBR 0 0 MDKBS 0 0 0 Spacer, Panel 0 *Insulation 0 0 *Catch, Door 0 0 *Rivet 00 0 Screw, Hex Head Sems Stainless (M x x mm) *Seal, Weather 0 AR MDKBP, MDKBR ( ) 0 AR MDKBS (. ) * Parts Included in Access Panel Kit.