Rheem Commercial Value Series Package Gas Electric Unit

Package Gas Electric Rheem Commercial Value Series Package Gas Electric Unit RKKL-B Standard Efficiency Series Nominal Sizes 6 Ton [2. kw] ASHRAE 90.-200 Compliant Models Proper sizing and installation of equipment is critical to achieve optimal performance. Ask your Contractor for details or visit www.energystar.gov. FORM NO. R-857 REV.

Table of Contents TABLE OF CONTENTS Unit Features & Benefits...3-4 Model Number Identification...5 Selection Procedure...6 Options...7 General Data...8-0 General Data Notes... Gross Systems Performance Data...2 Indoor Airflow Performance...3 Electrical Data...4 Dimensional Data...5-7 Accessories...8-25 Mechanical Specifications...26 Wiring Diagrams...27-29 Limited Warranty...30 2

Unit Features & Benefits RKKL - B072 STANDARD FEATURES INCLUDE: R-40A HFC refrigerant. Complete factory charged, wired and run tested. Scroll compressors with internal line break overload and high-pressure protection. Single stage compressor on all models. Convertible airflow. TXV refrigerant metering system. High Pressure and Low Pressure/Loss of charge protection standard on all models. Solid Core liquid line filter drier. Single slab evaporator coil facilitate easy cleaning for maintained high efficiencies. Cooling operation up to 25 degree F ambient. Easily removable filter, blower, gas heat, and compressor/ control access panels permits prompt service. Powder Paint Finish meets ASTMB7 steel coated on each side for maximum protection. G90 galvanized. One piece top cover and one piece base pan with drawn supply and return opening for superior water management. Externally mounted refrigerant gauge ports for easy service diagnostics. Easy to install plug-in; slip in, 00% fully modulating economizer. Forkable base rails for easy handling and lifting. Single point electrical and gas connections. High performance belt drive motor with variable pitch pulleys and quick adjust belt system. Permanently lubricated evaporator, condenser and gas heat inducer motors. Condenser motor is internally protected, totally enclosed with shaft down design. inch filter standard with slide out design. Single stage gas valve, direct spark ignition, and induced draft for efficiency and reliability. Tubular heat exchange for long life and induced draft for efficiency and reliability. Solid state furnace control with on board diagnostics. Colored and labeled wiring. Copper tube/aluminum Fin coils. Molded compressor plug. 3

Unit Features & Benefits Evaporator Coil/Filter Access Return air filters, normally provided, are removed in this photo. Tubular Heat Exchanger Aluminized steel (viewed from supply air side panel.) Stainless steel available Non-corrosive plastic condensate pan Control Box Access Heating Compartment Access Compressor Access (3 to 5 Ton [0.6 to 7.6 kw] Models) Blower Access Belt drive model shown. (Available on 3-phase models only.) 4

Model Number Identification R K K L B 072 C L 08 E X X X Economizer Option (See Next Page) Factory Installed Options (See Next Page) Ignition System E = Electric Ignition, Stage Gas Valve X = Electric Ignition, Stage Gas Valve, NOx Heating Capacity (MBH) 0 = 00,000 [29.3] 3 = 35,000 [39.6] Drive Package L = Belt Drive M= Belt Drive High Static Electrical Designation C = 208-230 V, 3 PH, 60 Hz D = 460 V, 3 PH, 60 Hz Y = 575 V, 3 PH, 60 Hz Cooling Capacity (BTUH) [kw] 072 = 72,000 [2.0] Future Technical Variations Design Series (R-40A) Efficiency Designation K =.2 EER Product Classification K = Rooftop Commercial Tradebrand R = Rheem Package Gas Electric 5

Selection Procedure. Determine cooling and heating requirements at design conditions. Example: Power Supply...208/230-3 Phase Total cooling capacity...66,000 BTUH [9.34 kw] Sensible cooling capacity...6,000 BTUH [7.88 kw] Heating capacity...96,000 BTUH [28.3 kw] Condenser entering air...95 F [35 C] Evaporator entering air...63 F [7 C] wb/76 F [24 C] db Indoor air flow...2460 CFM [6 L/s] External static pressure... in wg Required efficiency...2 EER 2. Select unit to meet cooling requirements. Since total cooling is within the range of 6 ton [2.0 kw] unit and requires.2 EER efficiency level, enter cooling performance from the RKKL-B072 at 95 F [35 C] outdoor temperature, 63 F [7 C] wb entering indoor air, and 2460 CFM [6 L/s]: Total capacity...7,700 BTUH [2.0 kw] Sensible capacity...67,500 BTUH [9.78 kw] Power input...5.0 kw And also, at 76 F [24 C] db indoor entering air, and using the formula at the bottom of the table: Sensible capacity...56,676 BTUH [6.6 kw] 3. Select heating capacity of the unit. In the general data tables, note that the heating capacity of the 6 ton [2.0 kw] model with the 35,000 input heater can deliver 09,400 BTUH [32.03 kw], which is suitable for this application. 4. Determine blower speed and power to meet the system requirements. At the given external static pressure of. in wg, the belt model must be selected. Enter the belt drive blower performance data at 2460 CFM [6 L/s] and. in wg ESP: RPM...97 Watts...392 Drive...M 5. Calculate indoor blower BTUH heat effect. BTUH = Watts x 3.43 = 475 6. Calculate net cooling capacities. Net total cooling = 7,700 475 = 66,949 BTUH [9.62 kw] Net sensible cooling = 67,900 475 = 62,749 BTUH [8.39 kw] 7. Select model RKKL-B072CM3E 6

Options FACTORY INSTALLED OPTION CODES FOR RKKL-B (6 TON) [2. kw] (B072) Option Code Hail Guard Stainless Steel Heat Exchanger Non-Powered Convenience Outlet/Unfused Service Disconnect Low Ambient/ Freeze Stat AD x AJ x AH x AP x BF x x BG x x BY x x JB x x CR x x x DN x x x x Economizer Codes A = No Economizer B = Economizer with Single Enthalpy Example: RKKL-B072CL3EXXX (where XX is factory installed option) Example: No Options RKKL-B072CL3E Example: No option with factory installed economizer RKKL-B072CL3EAAB Example: Options with stainless steel heat exchanger and no factory installed economizer RKKL-B072CL3EAJA Example: Options same as above with factory installed economizer RKKL-B072CL3EAJB ECONOMIZER SELECTION FOR RKKL-B (6 TON) [2. kw] A F x indicates factory installed option. No Economizer x Single Enthalpy Economizer With Barometric Relief x 7

General Data NOM. SIZES 6 TONS [2. kw] Model RKKL- Series B072CL0E B072CL3E B072CM0E B072CM3E Cooling Performance Gross Cooling Capacity Btu [kw] 73,000 [2.39] 73,000 [2.39] 73,000 [2.39] CONTINUED 73,000 [2.39] EER/SEER 2.2/NA.2/NA.2/NA.2/NA Nominal CFM/AHRI Rated CFM [L/s] 2400/2050 [33/967] 2400/2050 [33/967] 2400/2050 [33/967] 2400/2050 [33/967] AHRI Net Cooling Capacity Btu [kw] 70,000 [20.5] 70,000 [20.5] 70,000 [20.5] 70,000 [20.5] Net Sensible Capacity Btu [kw] 49,700 [4.56] 49,700 [4.56] 49,700 [4.56] 49,700 [4.56] Net Latent Capacity Btu [kw] 20,300 [5.95] 20,300 [5.95] 20,300 [5.95] 20,300 [5.95] Integrated Part Load Value N/A N/A N/A N/A Net System Power kw 6.2 6.2 6.2 6.2 Heating Performance (Gas) 3 Heating Performance (Gas) [kw] 00,000 [29.3] 35,000 [39.55] 00,000 [29.3] 35,000 [39.55] Heating Performance (Gas) [kw] 8,000 [23.73] 09,400 [32.05] 8,000 [23.73] 09,400 [32.05] Temperature Rise Range F [ C] 20-50 [./27.8] 30-60 [6.7/33.3] 20-50 [./27.8] 30-60 [6.7/33.3] Steady State Efficiency (%) 8 8 8 8 No. Burners 5 6 5 6 No. Stages Gas Connection Pipe Size in. [mm] 0.5 [2.7] 0.5 [2.7] 0.5 [2.7] 0.5 [2.7] Compressor No./Type /Scroll /Scroll /Scroll /Scroll Outdoor Sound Rating (db) 4 83 83 83 83 Outdoor Coil Fin Type Louvered Louvered Louvered Louvered Tube Type Rifled Rifled Rifled Rifled Tube Size in. [mm] OD 0.375 [9.5] 0.375 [9.5] 0.375 [9.5] 0.375 [9.5] Face Area sq. ft. [sq. m] 6.56 [.54] 6.56 [.54] 6.56 [.54] 6.56 [.54] Rows / FPI [FPcm] 2 / 22 [9] 2 / 22 [9] 2 / 22 [9] 2 / 22 [9] Indoor Coil Fin Type Corrugated Corrugated Corrugated Corrugated Tube Type Rifled Rifled Rifled Rifled Tube Size in. [mm] 0.375 [9.5] 0.375 [9.5] 0.375 [9.5] 0.375 [9.5] Face Area sq. ft. [sq. m] 6.5 [0.6] 6.5 [0.6] 6.5 [0.6] 6.5 [0.6] Rows / FPI [FPcm] 4 / 2 [5] 4 / 2 [5] 4 / 2 [5] 4 / 2 [5] Refrigerant Control TX Valves TX Valves TX Valves TX Valves Drain Connection No./Size in. [mm] / [25.4] / [25.4] / [25.4] / [25.4] Outdoor Fan Type Propeller Propeller Propeller Propeller No. Used/Diameter in. [mm] /24 [609.6] /24 [609.6] /24 [609.6] /24 [609.6] Drive Type/No. Speeds Direct/ Direct/ Direct/ Direct/ CFM [L/s] 4000 [888] 4000 [888] 4000 [888] 4000 [888] No. Motors/HP at /3 HP at /3 HP at /3 HP at /3 HP Motor RPM 075 075 075 075 Indoor Fan Type FC Centrifugal FC Centrifugal FC Centrifugal FC Centrifugal No. Used/Diameter in. [mm] /x0 [279x254] /x0 [279x254] /x0 [279x254] /x0 [279x254] Drive Type/No. Speeds Belt/Variable Belt/Variable Belt/Variable Belt/Variable No. Motors Motor HP /2 /2 /2 /2 Motor RPM 725 725 725 725 Motor Frame Size 0 0 0 0 Filter Type Disposable Disposable Disposable Disposable Furnished Yes Yes Yes Yes (No.) Size Recommended in. [mm] (4)2x6x6 [5x406x406] (4)2x6x6 [5x406x406] (4)2x6x6 [5x406x406] (4)2x6x6 [5x406x406] Refrigerant Charge Oz. [g] 9 [545] 9 [545] 9 [545] 9 [545] Weights Net Weight lbs. [kg] 689 [33] 689 [33] 689 [33] 689 [33] Ship Weight lbs. [kg] 696 [36] 696 [36] 696 [36] 696 [36] See Page for Notes. 8

General Data NOM. SIZES 6 TONS [2. kw] Model RKKL- Series B072DL0E B072DL3E B072DM0E B072DM3E Cooling Performance Gross Cooling Capacity Btu [kw] 73,000 [2.39] 73,000 [2.39] 73,000 [2.39] CONTINUED 73,000 [2.39] EER/SEER 2.2/NA.2/NA.2/NA.2/NA Nominal CFM/AHRI Rated CFM [L/s] 2400/2050 [33/967] 2400/2050 [33/967] 2400/2050 [33/967] 2400/2050 [33/967] AHRI Net Cooling Capacity Btu [kw] 70,000 [20.5] 70,000 [20.5] 70,000 [20.5] 70,000 [20.5] Net Sensible Capacity Btu [kw] 49,700 [4.56] 49,700 [4.56] 49,700 [4.56] 49,700 [4.56] Net Latent Capacity Btu [kw] 20,300 [5.95] 20,300 [5.95] 20,300 [5.95] 20,300 [5.95] Integrated Part Load Value N/A N/A N/A N/A Net System Power kw 6.2 6.2 6.2 6.2 Heating Performance (Gas) 3 Heating Performance (Gas) [kw] 00,000 [29.3] 35,000 [39.55] 00,000 [29.3] 35,000 [39.55] Heating Performance (Gas) [kw] 8,000 [23.73] 09,400 [32.05] 8,000 [23.73] 09,400 [32.05] Temperature Rise Range F [ C] 20-50 [./27.8] 30-60 [6.7/33.3] 20-50 [./27.8] 30-60 [6.7/33.3] Steady State Efficiency (%) 8 8 8 8 No. Burners 5 6 5 6 No. Stages Gas Connection Pipe Size in. [mm] 0.5 [2.7] 0.5 [2.7] 0.5 [2.7] 0.5 [2.7] Compressor No./Type /Scroll /Scroll /Scroll /Scroll Outdoor Sound Rating (db) 4 83 83 83 83 Outdoor Coil Fin Type Louvered Louvered Louvered Louvered Tube Type Rifled Rifled Rifled Rifled Tube Size in. [mm] OD 0.375 [9.5] 0.375 [9.5] 0.375 [9.5] 0.375 [9.5] Face Area sq. ft. [sq. m] 6.56 [.54] 6.56 [.54] 6.56 [.54] 6.56 [.54] Rows / FPI [FPcm] 2 / 22 [9] 2 / 22 [9] 2 / 22 [9] 2 / 22 [9] Indoor Coil Fin Type Corrugated Corrugated Corrugated Corrugated Tube Type Rifled Rifled Rifled Rifled Tube Size in. [mm] 0.375 [9.5] 0.375 [9.5] 0.375 [9.5] 0.375 [9.5] Face Area sq. ft. [sq. m] 6.5 [0.6] 6.5 [0.6] 6.5 [0.6] 6.5 [0.6] Rows / FPI [FPcm] 4 / 2 [5] 4 / 2 [5] 4 / 2 [5] 4 / 2 [5] Refrigerant Control TX Valves TX Valves TX Valves TX Valves Drain Connection No./Size in. [mm] / [25.4] / [25.4] / [25.4] / [25.4] Outdoor Fan Type Propeller Propeller Propeller Propeller No. Used/Diameter in. [mm] /24 [609.6] /24 [609.6] /24 [609.6] /24 [609.6] Drive Type/No. Speeds Direct/ Direct/ Direct/ Direct/ CFM [L/s] 4000 [888] 4000 [888] 4000 [888] 4000 [888] No. Motors/HP at /3 HP at /3 HP at /3 HP at /3 HP Motor RPM 075 075 075 075 Indoor Fan Type FC Centrifugal FC Centrifugal FC Centrifugal FC Centrifugal No. Used/Diameter in. [mm] /x0 [279x254] /x0 [279x254] /x0 [279x254] /x0 [279x254] Drive Type/No. Speeds Belt/Variable Belt/Variable Belt/Variable Belt/Variable No. Motors Motor HP /2 /2 /2 /2 Motor RPM 725 725 725 725 Motor Frame Size 0 0 0 0 Filter Type Disposable Disposable Disposable Disposable Furnished Yes Yes Yes Yes (No.) Size Recommended in. [mm] (4)2x6x6 [5x406x406] (4)2x6x6 [5x406x406] (4)2x6x6 [5x406x406] (4)2x6x6 [5x406x406] Refrigerant Charge Oz. [g] 9 [545] 9 [545] 9 [545] 9 [545] Weights Net Weight lbs. [kg] 689 [33] 689 [33] 689 [33] 689 [33] Ship Weight lbs. [kg] 696 [36] 696 [36] 696 [36] 696 [36] See Page for Notes. 9

General Data NOM. SIZES 6 TONS [2. kw] Model RKKL- Series B072YL3E B072YM3E Cooling Performance Gross Cooling Capacity Btu [kw] 73,000 [2.39] 73,000 [2.3 73,000 [2.39] 9] EER/SEER 2.2/NA.2.2/NA Nominal CFM/AHRI Rated CFM [L/s] 2400/2050 [33/967] /NA 2400/2050 [33/967] AHRI Net Cooling Capacity Btu [kw] 70,000 [20.5] 2400/2050 [33/ 70,000 [20.5] 967] Net Sensible Capacity Btu [kw] 49,700 [4.56] 70,000 [2 49,700 [4.56] Net Latent Capacity Btu [kw] 20,300 [5.95] 0.5] 20,300 [5.95] Integrated Part Load Value N/A 49,700 [ N/A 4.56] Net System Power kw 6.2 20,300 6.2 Heating Performance (Gas) 3 Heating Performance (Gas) [kw] Heating Performance (Gas) [kw] 00,000 [29.3] 8,000 [23.73] [5.95] 35,000 [39.55] 09,400 [32.05] Temperature Rise Range F [ C] 20-50 [./27.8] N/A30-60 [6.7/33.3] Steady State Efficiency (%) No. Burners No. Stages 8 5 6.2 35,000 [39.55] 8 6 Gas Connection Pipe Size in. [mm] 0.5 [2.7] 0.5 [2.7] 09,400 [32.05] Compressor 30 No./Type Outdoor Sound Rating (db) 4 /Scroll 83-6 0 /Scroll 83 Outdoor Coil Fin Type Louvered [6.7/33.3 Louvered Tube Type Rifled Rifled Tube Size in. [mm] OD 0.375 [9.5] ] 0.375 [9.5] 8 Face Area sq. ft. [sq. m] 6.56 [.54] 6 6.56 [.54] Rows / FPI [FPcm] 2 / 22 [9] 2 / 22 [9] Indoor Coil Fin Type Corrugated Corrugated 0 Tube Type Rifled.5 [2.7 Rifled Tube Size in. [mm] 0.375 [9.5] ] 0.375 [9.5] Face Area sq. ft. [sq. m] 6.5 [0.6] 6.5 [0.6] /S Rows / FPI [FPcm] 4 / 2 [5] croll 4 / 2 [5] Refrigerant Control TX Valves 83 TX Valves Drain Connection No./Size in. [mm] / [25.4] Lo / [25.4] uvered Outdoor Fan Type Propeller Rifle Propeller No. Used/Diameter in. [mm] /24 [609.6] d /24 [609.6] Drive Type/No. Speeds Direct/ 0.375 [9 Direct/.5] CFM [L/s] 4000 [888] 6.56 4000 [888] No. Motors/HP at /3 HP [.54] at /3 HP Motor RPM 075 075 2 / 22 [9] Indoor Fan Type FC Centrifugal FC Centrifugal No. Used/Diameter in. [mm] /x0 [279x254] Corrugat /x0 [279x254] Drive Type/No. Speeds Belt/Variable ed Belt/Variable Rifled No. Motors Motor HP /2 0.375 [9. /2 Motor RPM 725 5] 725 6.5 [0. Motor Frame Size 0 6] 0 Filter Type Disposable 4 / 2 Disposable Furnished Yes [5] Yes TX Valv (No.) Size Recommended in. [mm] (4)2x6x6 [5x406x406] (4)2x6x6 es [5x406x406] Refrigerant Charge Oz. [g] 9 [545] / [ 9 [545] Weights 25.4] Prope Net Weight lbs. [kg] 689 [33] ller 689 [33] Ship Weight lbs. [kg] 696 [36] /24 [ 696 [36] See Page for Notes. 0

General Data Notes NOTES:. Cooling Performance is rated at 95 F ambient, 80 F entering dry bulb, 67 F entering wet bulb. Gross capacity does not include the effect of fan motor heat. AHRI capacity is net and includes the effect of fan motor heat. Units are suitable for operation to 20% of nominal cfm. Units are certified in accordance with the Unitary Air Conditioner Equipment certification program, which is based on AHRI Standard 340/360. 2. EER and/or SEER are rated at AHRI conditions and in accordance with DOE test procedures. 3. IEER is rated in accordance with AHRI Standard 340/360. 4. Heating Performance limit settings and rating data were established and approved under laboratory test conditions using American National Standard Institute standards. Ratings shown are for elevations up to 2000 feet. For elevations above 2000 feet, ratings should be reduced at the rate of 4% for each 000 feet above sea level. 5. Outdoor Sound Rating shown is tested in accordance with AHRI Standard 270.

Gross Systems Performance Data GROSS SYSTEMS PERFORMANCE DATA RKKL-B072 O UT D O O R D R Y B U LB T E M PE R AT U R E F [ C] 75 [23.9] 80 [26.7] 85 [29.4] 90 [32.2] 95 [35] 00 [37.8] 05 [40.6] 0 [43.3] 5 [46.] ENTERING INDOOR AIR @ 80 F [26.7 C] dbe ➀ wbe 7 F [2.7 C] 67 F [9.4 C] 63 F [7.2 C] CFM [L/s] 2460 [60.9] 2050 [967.4] 660 [783.4] 2460 [60.9] 2050 [967.4] 660 [783.4] 2460 [60.9] 2050 [967.4] 660 [783.4] DR ➀ 0.06.2 0.06.2 0.06.2 Total BTUH [kw] Sens BTUH [kw] Power Total BTUH [kw] Sens BTUH [kw] Power Total BTUH [kw] Sens BTUH [kw] Power Total BTUH [kw] Sens BTUH [kw] Power Total BTUH [kw] Sens BTUH [kw] Power Total BTUH [kw] Sens BTUH [kw] Power Total BTUH [kw] Sens BTUH [kw] Power Total BTUH [kw] Sens BTUH [kw] Power Total BTUH [kw] Sens BTUH [kw] Power DR Depression ratio dbe Entering air dry bulb wbe Entering air wet bulb 87.3 [25.6] 55.7 [6.3] 4.7 85.5 [25.] 54.8 [6.] 4.9 83.6 [24.5] 53.7 [5.7] 5.2 8.6 [23.9] 52.5 [5.4] 5.4 79.5 [23.3] 5.3 [5.0] 5.6 77.3 [22.7] 49.9 [4.6] 5.9 75.0 [22.0] 48.4 [4.2] 6.2 72.6 [2.3] 46.8 [3.7] 6.5 70. [20.5] 45.2 [3.3] 6.8 84.2 [24.7] 47.8 [4.0] 4.6 82.5 [24.2] 47. [3.8] 4.8 80.7 [23.7] 46.2 [3.5] 5. 78.7 [23.] 45. [3.2] 5.3 76.7 [22.5] 44. [2.9] 5.5 74.6 [2.9] 42.9 [2.6] 5.8 72.4 [2.2] 4.7 [2.2] 6. 70. [20.5] 40.3 [.8] 6.4 67.7 [9.8] 38.9 [.4] 6.7 8.3 [23.8] 40.9 [2.0] 4.6 79.6 [23.3] 40.3 [.8] 4.8 77.9 [22.8] 39.5 [.6] 5.0 76.0 [22.3] 38.6 [.3] 5.2 74.0 [2.7] 37.7 [.] 5.5 72.0 [2.] 36.7 [0.8] 5.7 69.9 [20.5] 35.7 [0.5] 6.0 67.6 [9.8] 34.4 [0.] 6.3 65.3 [9.] 33.3 [9.8] 6.6 Total Total capacity x 000 BTUH Sens Sensible capacity x 000 BTUH Power KW input 83.8 [24.6] 65.3 [9.] 4.4 82.0 [24.0] 64.4 [8.9] 4.6 80.0 [23.4] 63.2 [8.5] 4.9 78.0 [22.9] 62. [8.2] 5. 75.9 [22.2] 60.8 [7.8] 5.3 73.7 [2.6] 59.4 [7.4] 5.6 7.5 [2.0] 58. [7.0] 5.9 69. [20.3] 56.4 [6.5] 6.2 66.6 [9.5] 54.8 [6.] 6.5 80.8 [23.7] 56.7 [6.6] 4.3 79. [23.2] 56.0 [6.4] 4.5 77.2 [22.6] 55.0 [6.] 4.8 75.3 [22.] 54. [5.9] 5.0 73.3 [2.5] 53.0 [5.5] 5.2 7.2 [20.9] 5.8 [5.2] 5.5 68.9 [20.2] 50.5 [4.8] 5.8 66.6 [9.5] 49. [4.4] 6. 64.2 [8.8] 47.7 [4.0] 6.4 78.0 [22.9] 49. [4.4] 4.3 76.3 [22.4] 48.5 [4.2] 4.5 74.6 [2.9] 47.7 [4.0] 4.7 72.7 [2.3] 46.9 [3.8] 4.9 70.7 [20.7] 45.9 [3.5] 5.2 68.7 [20.] 44.9 [3.2] 5.4 66.6 [9.5] 43.9 [2.9] 5.7 64.3 [8.8] 42.6 [2.5] 6.0 62.0 [8.2] 4.5 [2.2] 6.3 79.6 [23.3] 7.9 [2.] 4. 77.7 [22.8] 7.0 [20.8] 4.3 75.8 [22.2] 69.9 [20.5] 4.5 73.8 [2.6] 68.8 [20.2] 4.8 7.7 [2.0] 67.5 [9.8] 5.0 69.5 [20.4] 66.0 [9.4] 5.3 67.2 [9.7] 64.6 [8.9] 5.6 64.9 [9.0] 63. [8.5] 5.9 62.4 [8.3] 6.4 [8.0] 6.2 76.8 [22.5] 63.0 [8.5] 4.0 75.0 [22.0] 62.2 [8.2] 4.2 73.2 [2.5] 6.3 [8.0] 4.5 7.2 [20.9] 60.3 [7.7] 4.7 69.2 [20.3] 59.2 [7.4] 4.9 67. [9.7] 58.0 [7.0] 5.2 64.9 [9.0] 56.8 [6.7] 5.5 62.6 [8.3] 55.4 [6.2] 5.8 60.2 [7.6] 54.0 [5.8] 6. 74. [2.7] 54.9 [6.] 4.0 72.4 [2.2] 54.3 [5.9] 4.2 70.6 [20.7] 53.5 [5.7] 4.4 68.8 [20.2] 52.8 [5.5] 4.6 66.8 [9.6] 5.8 [5.2] 4.9 64.8 [9.0] 50.8 [4.9] 5. 62.6 [8.3] 49.7 [4.6] 5.4 60.4 [7.7] 48.5 [4.2] 5.7 58. [7.0] 47.3 [3.9] 6.0 NOTES: ➀ When the entering air dry bulb is other than 80 F [27 C], adjust the sensible capacity from the table by adding [.0 x CFM x ( DR) x (dbe 80)]. 2

Indoor Airflow Performance AIRFLOW PERFORMANCE 6 TON [2.0 kw] THREE PHASE BELT DRIVE Air Flow CFM [L/s] Capacity 6 Ton [2.0 kw] Voltage 208/230-460 & 575 3 Phase 0. [.02] 0.2 [.05] 0.3 [.07] 0.4 [.0] 0.5 [.2] 0.6 [.5] External Static Pressure Inches of Water [kpa] 0.7 [.7] 0.8 [.20] 0.9 [.22] RPM W RPM W RPM W RPM W RPM W RPM W RPM W RPM W RPM W RPM W RPM W RPM W RPM W RPM W RPM W 800 [850] 785 560 850 605 895 650 930 670 975 720 00 760 050 800 090 850 20 890 50 940 80 980 20 05 900 [897] 785 580 830 65 875 660 95 700 955 740 990 770 020 85 070 855 05 925 35 960 65 05 95 075 220 5 2000 [944] 775 600 85 625 860 675 895 720 930 750 975 800 05 840 050 900 085 940 20 000 45 035 75 090 205 50 230 205 200 [99] 80 650 840 680 880 740 920 780 955 820 995 880 030 920 065 960 00 025 30 060 60 30 90 80 220 250 240 295 2200 [038] 780 660 825 700 865 750 90 80 945 850 980 880 05 930 050 000 080 045 20 00 45 60 80 220 205 260 230 330 255 380 2300 [085] 85 720 855 760 890 830 930 870 960 90 000 960 035 005 065 060 00 30 35 80 60 250 200 325 220 370 240 425 2400 [33] 845 780 880 835 920 900 950 945 990 990 025 050 055 0 085 55 20 25 50 335 85 355 220 430 235 470 255 525 2500 [80] 870 855 90 95 945 975 980 020 020 085 045 40 080 200 0 260 35 300 75 390 205 450 230 530 250 580 295 630 2600 [227] 900 945 940 005 975 060 005 05 040 75 065 225 00 295 35 350 65 425 200 505 225 580 240 635 270 665 2700 [274] 930 075 970 00 000 45 030 200 060 260 090 335 25 395 55 470 85 540 220 65 235 675 255 730 2800 [32] 960 50 000 95 025 240 055 305 085 350 5 440 45 50 80 560 20 620 235 740 250 775 295 NOTE: L-Drive left of bold line, M-Drive right of bold line..0 [.25]. [.27].2 [.30].3 [.32].4 [.35].5 [.37] Drive Package L M Motor H.P. [W] /2 [9] /2 [9] Blower Sheave 6.4" Pitch Diameter 6.4" Pitch Diameter Motor Sheave 2.8"-3.8" Pitch Diameter Adj. 3.4"-4.4" Pitch Diameter Adj. Turns Open 0 2 3 4 5 6 0 2 3 4 5 6 RPM 00 050 000 945 895 845 780 295 230 95 45 00 050 000 NOTE: Factory sheave settings are shown in bold print. 3

Electrical Data ELECTRICAL DATA RKKL SERIES Unit Operating Voltage Range B072CL B072CM B072DL B072DM B072YL B072YM 87-253 87-253 44-506 44-506 58-632 58-632 Evaporator Fan Condenser Motor Compressor Motor Unit Information Volts 208/230 208/230 460 460 575 575 Minimum Circuit Ampacity 33/33 33/33 Minimum Overcurrent Protection Device Size 40/40 40/40 20 20 5 5 Maximum Overcurrent Protection Device Size 50/50 50/50 20 20 5 5 No. Volts 208/230 208/230 460 460 575 575 Phase 3 3 3 3 3 3 RPM 3450 3450 3450 3450 3450 3450 HP, Compressor 5 5 5 5 5 5 Amps (RLA), Comp. 9./0 9./0 9.8 9.8 7.5 7.5 Amps (LRA), Comp. 23/0 23/0 62 62 50 50 No. Volts 208/230 208/230 460 460 575 575 Phase HP /3 /3 /3 /3 /3 /3 Amps (FLA, each) 2.6/2.6 2.6/2.6.25.25 0.9 0.9 Amps (LRA, each) 4.7/4.7 4.7/4.7 2.4 2.4.5.5 No. Volts 208/230 208/230 460 460 575 575 Phase 3 3 3 3 3 3 HP /2 /2 /2 /2 /2 /2 Amps (FLA, each) 5.8/5.8 5.8/5.8 2.8 2.8 2. 2. Amps (LRA, each) 34/34 34/34 7 7 3. 3. 7 7 3 3 4

Dimensional Data GAS HEAT / ELECTRIC COOLING PACKAGE BOTTOM VIEW 5

Dimensional Data GAS HEAT / ELECTRIC COOLING PACKAGE BACK VIEW SIDE VIEW FRONT VIEW 6

Dimensional Data WEIGHTS 6 Ton [2. kw] Accessory Shipping Operating lbs [kg] lbs [kg] Economizer with Single Enthalapy 70 [32] 60 [27] Power Exhaust 9 [9] 6 [7] Fresh Air Damper (Manual) [5] 9 [4] Fresh Air Damper (Motorized) 3 [6] [5] Roof Curb 4" 92 [42] 88 [40] Roof Curb 24" 08 [49] 04 [47] Concentric Diffuser 8" Flush 37 [7] 26 [2] Concentric Diffuser 20" Flush 54 [24] 42 [9] Side Discharge Concentric Diffuser RXRN-FA60 35 [6] 20 [9] Side Discharge Concentric Diffuser RXRN-FA65 55 [25] 40 [8] CENTER OF GRAVITY (C.G.) Capacity Tons [kw] A in. [mm] B in. [mm] 6 [2.] 38 /4 [972] 25 3 /4 [654] Capacity Tons [kw] Corner Weights by Percentage A B C D 6 [2.] 22% 27% 23% 28% CLEARANCES (6 Ton [2. kw] Models) The following minimum clearances are recommended for proper unit performance and serviceability. Recommended Clearance in. [mm] Location 48 [29] A - Front 8 [457] B - Condenser Coil 2 [305] C - Duct Side 36 [94] D - Evaporator End 60 [524] E - Above *Without Economizer. 57" [448 mm] With Economizer NOTE: Supply duct may be installed with 0 inch clearance to combustible materials, provided " [25.4 mm] minimum Fiberglass insulation is applied either inside or on the outside of the duct. 7

Accessories ACCESSORY EQUIPMENT Accessory Description Model Application Accessory Model No. Factory Installed Thermostats RKKL-B072 See Thermostat Specification Sheet (T-00) No Roofcurb, 4" RKKL-B072 RXKG-CAD4 No Roofcurb, 24" RKKL-B072 RXKG-CAD24 No Roofcurb adapters RKKL-B072 RXRX-CCCE50 No Economizer, downflow/horizontal, single enthalpy RKKL-B072 AXRD-MCCM3 Yes Dual enthalpy kit for economizer RKKL-B072 RXRX-AV02 No CO2 sensor RKKL-B072 RXRX-AR02 No Power exhaust (C, D, Y voltages) RKKL-B072 AXRX-BGF03 No Fresh air damper, manual RKKL-B072 AXRF-FCA No Fresh air damper, motorized RKKL-B072 AXRF-JHB No Rectangular-to-round 20" duct adapters for concentric diffuser RKKL-B072 RXMC-CC04 No Concentric diffuser 20", step type RKKL-B072 RXRN-FA65 No Concentric diffuser 20", flush type RKKL-B072 RXRN-FA75 No Louver kit, 3-sided RKKL-B072 AXRX-AAD0B Yes Compressor time delay RKKL-B072 RXMD-B04 No Low ambient control RKKL-B072 RXRZ-A85 Yes Convenience outlet (requires separate power supply) RKKL-B072 RXRX-AN02 Yes Service disconnect switch RKKL-B072 RXRX-AP02 Yes LP conversion kit for White Rodgers gas valve (see note ) RKKL-B072 RXGJ-EP84W No LP conversion kit for Honeywell gas valve (see note ) RKKL-B072 RXGJ-EP85H No Freeze stat control RKKL-B072 RXRX-AM0 Yes Canadian high-altitude kit for natural gas only (see note ) RKKL-B072 RXRX-AH0 No *Voltage C = 208/230 VAC-3PH-60HZ D = 460 VAC-3PH-60HZ Y = 575 VAC-3PH-60HZ NOTES:. If a unit is to be converted to operate on LP gas above 2000 ft. in Canada, the conversion kits contain the necessary orifices and instructions to de-rate the input for 2000-4500 ft. 8

Accessories THERMOSTATS 200-Series * Programmable 300-Series * Deluxe Programmable 400-Series * Special Applications/ Programmable 500-Series * Communicating/ Programmable * Photos are representative. Actual models may vary. For detailed thermostat match-up information, see specification sheet form number T-00. Roofcurb Adapters Old Models OLD CURB MODEL ROOFCURB ADAPTER NEW MODEL COMMERCIAL PACKAGE UNIT (6.5 & 7.5 TON [23-26 kw]) RXRK-E50 RXRX-CCCE50 RKKL-B072 (-)RCF, (-)REF, (-)RGF3 & 20, RGF50 () SLOPE TYPE (2) FULL PERIMETER TYPE 9

Accessories ECONOMIZERS AXRD-TCCM3 RKKL-B 6 Ton [2. kw] Models Single Enthalpy (with Barometric Relief) RXRX-AV02 6 Ton [2. kw] Models Dual Enthalpy Kit RXRX-AR02 6 Ton [2. kw] Models Optional CO 2 Sensor Features Honeywell Analog Controls Available factory installed or field accessory Gear Driven Direct Drive Actuator Fully Modulating (0-00%) Low Leakage Dampers Horizontal or Downflow Applications Slip-In Design for Easy Installations Plug-In Polarized Electrical Connections Pre-configuring No Field Adjustments Necessary Standard Barometric Relief Damper Provided Single Enthalpy with Dual Enthalpy upgrade kit CO2 Input Sensor Available (field installed) Economizer slips in complete for downflow or horizontal duct applications Field assembled hood ships with Economizer Optional Remote minimum position (Honeywell #S963B28) is available from ProStock. Field installed power exhaust available. 20

Accessories INTEGRAL POWER EXHAUST FOR ECONOMIZER (FIELD INSTALLED ONLY) AXRX-BGF03C RKKL-B 6 Ton [2. kw] Models 208-230 V, PH, 60 Hz AXRX-BGF03D RKKL-B 6 Ton [2. kw] Models 460 V, 3 PH, 60 Hz AXRX-BGF03Y RKKL-B 6 Ton [2. kw] Models 575 V, 3 PH, 60 Hz For Honeywell economizer. Downflow or horizontal applications. Requires separate 208-230 volt PH power supply with disconnect or requires separate 460V 3 PH power supply with disconnect. Adjustable switch on economizer, factory preset to energize power exhaust at 95% outside air position. Polarized plug connects power exhaust relay to economizer. POWER EXHAUST KIT FOR RXRD-MCCM(-), RXRD-MECM(-) ECONOMIZERS Model No. No. of Fans Volts AXRX-BGF03C 208/230 Phase AXRX-BGF03Y ➁ 575 Watts (ea.) 000 800 CFM ➀ 2500 2370 High Speed 725 620 FLA (ea.) AXRX-BGF03D 460 800 2370 620.8 4. ➀ CFM is at 0" W.C. external static pressure. ➁ Unit includes 575 to 460 Volt step-down transformer. RPM 4.4.5 LRA (ea.) 23.7 3.3 FRESH AIR DAMPER RKKL-B 6 Ton [2. kw] Models AXRF-FCA (Manual) AXRF-FCB (Motorized) I39.DGN FRESH AIR DAMPER 2

Accessories DUCT ADAPTERS (RKKL-B 6 Ton [2. kw] Models) Rectangular to Round Transitions (Downflow) RXMC-CC04 20" [508 mm] Round Accessory Model No. RXMC-CB03 RXMC-CC04 Model Application Tons [kw] 3-5 [0.6-7.6] 6 [2.] Size in. [mm] 8 [457] Round 20 [508] Round 22

Accessories SIDE DISCHARGE CONCENTRIC DIFFUSER RXRN-FA65 (6 Ton [2. kw] Model) For Use With Duct Adapter (RXMC) DIMENSIONAL DATA Model No. A B C D E F G H I J K RXRN-FA65 47 5 /8" [20 mm] 29 5 /8" [752 mm] 4 3 /8" [365 mm] 27 /2" [699 mm] 45 /2" [56 mm] 22 /2" [572 mm] /2" [292 mm] 3 3 /4" [349 mm] 45 /2" [56 mm] 27 /2" [699 mm] 8 /8" [206 mm] Duct Size 20RD ENGINEERING DATA Model No. RXRN-FA65 CFM [L/s] Static Pressure Throw Feet 2600 [227].7 24-29 669 669 20 2800 [32].20 25-30 720 720 25 3000 [46].25 27-33 772 772 25 3200 [50].3 28-35 823 823 25 3400 [605].37 30-37 874 874 30 Neck Vel. Jet Vel. Noise Level 23

Accessories FLUSH MOUNT CONCENTRIC DIFFUSER RXRN-FA75 (6 Ton [2. kw] Model) For Use With Duct Adapter (RXMC) DIMENSIONAL DATA Model No. A B C D E F G H RXRN-FA75 47 5 /8" [20 mm] 29 5 /8" [752 mm] 6 5 /8" [422 mm] 27" [686 mm] 45" [43 mm] 22 /2" [572 mm] /4" [286 mm] 3 /2" [343 mm] Duct Size 20RD ENGINEERING DATA Model No. RXRN-FA75 CFM [L/s] Static Pressure Throw Feet 2600 [227].7 9-24 663 294 30 2800 [32].20 20-28 74 393 35 3000 [46].25 2-29 765 492 35 3200 [50].3 22-29 86 592 40 3400 [605].37 22-30 867 692 40 Neck Vel. Jet Vel. Noise Level 24

Accessories ROOFCURBS (Full Perimeter) n Rheem s new roofcurb design can be utilized on 3 through 7.5 ton [2. kw] models. n Two available heights (4" [356 mm] and 24" [60 mm]) for ALL models. n Quick assembly corners for simple and fast assembly. TYPICAL INSTALLATION n Opening provided in bottom pan to match the Thru the Curb electrical connection opening provided on the unit base pan. n 2" [5 mm] x 4" [02 mm] Nailer provided. n Insulating panels provided. n Sealing gasket (28" [7 mm]) provided with Roofcurb. n Packaged for easy field assembly. Roofcurb Model RXKG-CAD4 RXKG-CAD24 Height of Curb 4" [356 mm] 24" [60 mm] 25

Mechanical Specifications SAMPLE SPECIFICATIONS Unit shall be completely factory assembled and performance tested to provide the required cooling and heating functions suitable for outdoor installations. Unit shall be UL/cUL listed and rated in accordance to AHRI Standard 20. Cabinet Unit casing, base pan and framework shall be manufactured of galvanized sheet metal primed and finished with powder paint capable of withstanding a 000-hour salt spray test per ASTM B 7. Unit interior cabinet surfaces shall be insulated with a minimum /2-inch thick foil faced insulation. Access panels shall be easily removable providing access to the blower, filter, heating compartment, and compressor/ control box. Unit base rails shall be provided with fork insertion slots and rigging holes. Condensate drain pan shall be of sloped design to conform to ASHRAE 62. Unit shall be supplied ready for vertical airflow and be easily convertible to horizontal airflow at or before installation. Compressor(s) Unit shall be provided with fully hermetic scroll compressor(s) with internally protected safety controls. Coils The evaporator and condenser coils shall be fabricated of copper tubes with mechanically bonded aluminum plate fins. They shall be pressure tested prior to assembly into the unit, and electronically leak tested after assembly. Condenser Fan A single direct drive propeller fan shall discharge air vertically upward. The fan motor shall be permanently lubricated and have built-in overload protection. Evaporator Blower A single, double inlet, centrifugal wheel shall rotate in permanently lubricated ball bearings. The wheel shall be made from steel with corrosion resistant finish and shall be statically and dynamically balanced. ACCESSORIES ROOF CURB Curb shall be full perimeter type, complying with the standards of the National Roofing Contractors Association. Design shall provide for drop-in of supply and return ducts prior to setting unit, and include an insulating panel for the rest of the curb area. Economizer Economizer shall be completely assembled for field installation. Unit shall include all controls and dampers including the baro metric relief damper. Manual Fresh Air Damper Damper shall consist of damper and rainhood which is manually preset to admit up to 35% of outside air for field installation. Motorized Fresh Air Damper Damper shall consist of motor, damper, and rainhood which can admit up to 35% of outside air for field installation. Electric Heat Kits Electric heat kits shall be available in a wide range of capacity with branch circuit fusing allowing single point wiring. Kits shall be UL/cUL approved. Each kit shall be offered as a field or factory installed option. Pressure Controls High and low pressure controls shall be included for field or factory installation. Low Ambient Control Low ambient control shall be provided to cycle the condenser fan in response to condensing pressure and allow operation to 0 degrees F. The option shall be field or factory installed. Louver Panel Kits Field or factory installed louver kits shall be provided for condenser coil protection against hail or flying debris. 26

Wiring Diagrams 27

Wiring Diagrams 28

Wiring Diagrams 29

Limited Warranty BEFORE PURCHASING THIS APPLIANCE, READ IMPORTANT ENERGY COST AND EFFICIENCY INFORMATION AVAILABLE FROM YOUR RETAILER. GENERAL TERMS OF LIMITED WARRANTY* Rheem will furnish a replacement for any part of this product which fails in normal use and service within the applicable periods stated, in accordance with the terms of the limited warranty. Heat Exchanger...Ten (0) Years *For complete details of the Limited and Conditional Warranties, including applicable terms and conditions, contact your local contractor or the Manufacturer for a copy of the product warranty certificate. Compressor 3 Phase, Commercial Applications...Five (5) Years Parts 3 Phase, Commercial Applications...One () Year Factory Standard Heat Exchanger 3 Phase, Commercial Applications...Ten (0) Years 30

Notes 3

The new degree of comfort. In keeping with its policy of continuous progress and product improvement, Rheem reserves the right to make changes without notice. Rheem Heating, Cooling & Water Heating P.O. Box 700 Fort Smith, Arkansas 7297 www.rheem.com Rheem Canada Ltd./Ltée 25 Edgeware Road, Unit Brampton, Ontario L6Y 0P5 PRINTED IN U.S.A 7/3 QG FORM NO. R-857 REV.