Bladder-type accumulator HAB

Similar documents
Bladder-type accumulator. Type HAB. Features. Contents. RE Edition: Replaces: 50170

Bladder-type accumulators

Accumulator shut-off block. Type ABZSS. Contents. RE Edition: Replaces: 05.13

Motor-pump group. Features. Table of contents RE 51171/ Type ABAPG and ABHPG

Proportional directional valve, pilot-operated, with integrated electronics (OBE)

Throttle and throttle check valve

Hydraulic inch power brake valve LT 31

Bladder-type accumulator

Accumulator shut-off block. Type 0532VAW. Contents. Features. RE Edition: Replaces: 07.10

Radial piston pump PR4 series 1X

Pressure reducing valve, pilot-operated. Type Z3DR. Contents. Features. RE Edition:

Supply pressure compensator, direct operated

Radial piston pump PR4 Series 1X

Throttle check valve. Type Z2FS. Contents. Features. RE Edition: Replaces: 10.07

Pressure relief valve, direct operated. Type ZDBY D, Z2DBY D. Features. Contents. RE Edition: Replaces: 01.09

6/2 ways/positions flow diverters L (VS151-VS152-VS155)

3/2 ways/positions flow diverters L (VS91-VS92-VS95)

Check valve. Type S. Contents. Features. RE Edition: Replaces:

6/2 ways/positions flow diverters L (VS120-VS125-VS129)

Gerotor pump, fixed displacement volume

Central Hydraulics Valve for Tractors with Priority Function for Steering, Trailer Brake and Pilot Oil Valve

Check valve. RE 21536/07.05 Replaces: Type Z1S. Size10 Component series 3X Maximum operating pressure 315 bar Maximum flow 100 l/min 1/6

4/3-4/2 Directional valve elements B8_0A with or without (EDB-A) secondary relief valves, with or without LS connections B8_0A (EDB-A)

迅捷 PDF 编辑器. Supply pressure compensator, direct operated RE 29231/ Type ZDC

Pressure reducing valve, direct operated. Type ZDR. Contents. Features. RE Edition: Replaces:

Flow sharing control block in mono block / sandwich plate design M6-22

4/3 Proportional directional valve elements L85P5 with proportional (EDC-IP) hydraulic control and flow sharing control (LUDV concept) PATENT PENDING

Variable Vane Pump, Direct Controlled PV7...A Series 1X / 2X

Pressure relief valve, pilot operated

Check valve. Type S. Contents. Features. RE Edition: Replaces:

6/2 ways/positions flow diverters

6 to14/2 ways/positions bankable flow diverters flangeable

Pressure relief valve, direct operated. Type DBD..K. Contents. Features. RE Edition:

Block mounting filter, lateral flange-mounting possible

6 to 12/2 ways/positions bankable flow diverters flangeable

Pressure reducing valve, direct operated

Axial Piston Fixed Pump A2FO

3/2 ways/positions flow diverters

Proportional cartridge throttle valve, with inductive position transducer, pilot operated

Pressure reducing valve, direct operated

Pressure reducing valve, pilot operated

Axial Piston Fixed Motor A2FNM for Fan Drives and Flywheel Mass

Axial Piston Fixed Pump A17FNO Series 10

Flow sharing control block in mono block / sandwich plate design M6-15

LUDV control block of sandwich plate design

Axial piston fixed motor A2FM series 70. Americas. RE-A Edition:

Inline filter with filter element according to DIN 24550

Pressure relief valve, pilot-operated. Type ZDB and Z2DB. Contents. Features. RE Edition: Replaces: 05.11

Pipe burst safety valve

4/3 and 4/2 Proportional directional valve elements L8580 with flow (EDC-P) sharing control (LUDV concept) PATENT PENDING

Electronic pressure switch. Type HEDE 10. Contents. Features. RE Edition: Replaces:

Axial piston fixed motor A2FM Series 70 A2FE Series 70

LUDV control block of sandwich plate design

2-way flow control valve. Type 2FRM, 2FRH, 2FRW. Contents. Features. RE Edition: Replaces: 07.04

Pressure relief valve, pilot-operated. Type ZDB and Z2DB. Contents. Features. RE Edition: Replaces: 10.05

4/3 4/2 Directional valve elements with or without secondary relief valves, and with or without LS connections

Stand alone 4/3, 4/2 direct acting directional valve LF2_1 (LC2F-DZ)

Stand alone 4/3, 4/2 solenoid operated directional valve

Filling valve sandwich plate

Spin-on filter according to Bosch Rexroth standard: Type 50 SL 30 to 80D. Features. Contents. RE Edition:

4/3 directional control valve, pilot operated, with electric position feedback and integrated electronics (OBE)

Block mounting filter, for sandwich plate mounting

6/2 ways/positions flow diverters

BODAS Pressure sensor PR3 series 10

Pressure relief valve, direct operated, with DC motor actuation. Type DBGT. Features. Contents. RE Edition:

Pressure reducing valve, direct operated

Proportional pressure reducing valve, pilot operated

Throttle check valve. RE 27526/04.08 Replaces: Type Z2FS

2-way flow control valve

6 to14/2 ways/positions bankable flow diverters flangeable

4/3 and 4/2 Proportional directional valve elements L8581 with flow (EDC-P1) sharing control (LUDV concept) PATENT PENDING

Dual-circuit power brake valve LT 07

6/2 ways/positions flow diverters

Single-circuit power brake valve LT 05

Directional valve elements L808103P (ED4-PT1) of Tank unloaded excess flow. RE Edition: Replaces:

6 to14/2 ways/positions bankable flow diverters flangeable

Directional spool valves, direct operated, smoothly switching, with solenoid actuation

Pressure relief valve, pilot operated

Servo solenoid valves with on-board electronics (OBE)

Check valve, pilot operated

Inline filter with filter element according to DIN 24550

Check valve, pilot operated

Servo solenoid valves with on-board electronics (OBE)

Servo solenoid valves with on-board electronics (OBE)

Servo solenoid valves with positive overlap Position feedback (Lvdt DC/DC ±10 V)

LUDV control block in mono block/sandwich plate design M7-20

Radial piston motor for compact drives MCR-C

Proportional pressure relief valve, directly operated, rising characteristic curve

Proportional cartridge throttle valve, with on-board electronics (OBE) and inductive position transducer, pilot operated

6 to 12/2 ways/positions bankable flow diverters flangeable

Contamination switch VS

4/4 directional control valves, direct operated, with electrical position feedback and integrated electronics (OBE)

Pressure relief valve, pilot operated

Radial piston pump, fixed displacement

Twin throttle check valve

Type 245LEN0040 to 0400; 245LE0130, 0150

Inline filter with filter element according to DIN 24550

Servo solenoid valves with on-board electronics (OBE)

Proportional pressure reducing valve, pilot operated

Throttle check valve. Type Z2FS. Features. Content. RE Edition: Replaces: 04.08

Transcription:

Bladder-type accumulator HAB RE 0170 Edition: 03.14 Replaces: 02.12 Component series 4X Nominal volume 1 to 0 liters Maimum operating pressure 30 bar Features Hydraulic accumulator as per Pressure Equipment Directive 97/23/EC Bladder material for different application Use: Energy storage for systems with intermittent operation Energy reserve for emergencies Compensation for leakage Shock and vibration damping Volume compensation for pressure and temperature changes Certifications CE label (as per Pressure Equipment Directive 97/23/EC) CE + GOST label ASME label (as per data sheet 130) For information on available spare parts: visit www.boschreroth.com/spc Contents Ordering code 2 Instruction manuals and declarations of conformity 3 Functional description 4 Technical data Application, mode of operation 6 Calculation 6 Dimensions Spare parts and accessories 11 Intended use 19 Safety instructions on hydraulic accumulators 19 Legal regulations 19 Safety devices RE 0170/03.14, Bosch Reroth AG

2 HAB Bladder-type accumulator Ordering code Ordering code 01 02 03 04 0 06 07 08 09 11 12 13 14 HAB 4 / 2 G 2 1 1 1 Type 01 Bladder-type accumulator HAB Nominal volume 02 1 liters 1 2. liters 2, 4 liters 4 6 liters 6 liters liters 3 liters 3 0 liters 0 Maimum permissible operating pressure 03 30 bar (1 to 6 liters) 30 330 bar ( to 0 liters) 330 Series 04 Series 40 to 49 (unchanged installation and connection dimensions) 4X Gas filling pressure 0 < 2 bar 2 Port size for hydraulic fluid 1) 1 2, 4 6 3 0 06 G3/4 G0 G1 1/4 G07 G2 G09 Type of mounting (oil connection form) 07 Thread with inner radial sealing surface G Gas connection form 08 Gas valve for charging and testing device (see page 13) 2 Bladder material 1) 09 NBR N ECO E Container material 1) Steel 1 Surface of container inner 1) 11 Steel 1 Surface of port side 1) 12 Steel 1 Certification (acceptance) 13 Acceptance according to 97/23/EC CE Instructions for use BA Acceptance in accordance with Gosudarstwenny Standard GOST 14 State other details in plain language, e.g. special versions Ordering eample HAB-330-4X/2G09G-2N111-CE = not available, = available 1) Other variants on request. Bosch Reroth AG, RE 0170/03.14

Bladder-type accumulator HAB Instruction manuals and declarations of conformity 3 Instruction manuals and declarations of conformity Instruction manuals valid for HAB1 to HAB0 Language Instruction manual Material number Document number German R9092 RA08194 English R90926 RA08721 French R90927 RA0821267 Spanish R90928 RA0821286 Italian R90929 RA0821301 Chinese R90930 RA0821308 Russian R90931 RA0821321 Norwegian R90932 RA0821347 Polish R901278729 RA082134 Czech R901278730 RA08770 Romanian R901289016 RA082136 Hungarian R90130167 RA0821372 Portuguese R901338309 RA0821427 CE declarations of conformity In the languages German, English, French Bladder material NBR Bladder material ECO Nominal volume [l] Material number Document number Material number Document number 1 2, R90940 RA0840060 R90942 RA0840138 4 6 R90941 RA08404 R90943 RA084013 3 0 CE + GOST declarations of conformity In the languages German, English, Russian Bladder material NBR Nominal volume [l] Material number Document number 1 2, RA0767138 4 6 RA0767883 3 0 RE 0170/03.14, Bosch Reroth AG

4 HAB Bladder-type accumulator Functional description Functional description X 4 7 If a certain volume of pressurized gas is charged with a higher fluid pressure, the gas volume will reduce as fluid pressure increases; the gas pressure increases with the fluid pressure. If the fluid pressure drops, the gas will epand, pressing the fluid back into the hydraulic system until the pressure is equalized again. 8 6 Detail X 1 2 3 4.1 4.2 4 4.3 1 Reservoir 2 Bladder 3 Oil valve 4 Gas valve Gas valve support 6 Nut 7 Type cap 8 Cover cap Bladder-type accumulator Bladder-type accumulators consist of a seamless cylindrical pressure reservoir (1) made of high-strength steel. Inside the container is an elastic bladder (2) which divides the accumulator into a gas section and a fluid section. The bladder is filled with nitrogen via the gas valve (4). to the specified gas pressure p 0. The oil valve (3) is located in the oil port of the bladdertype accumulator. It closes when the pressure is higher on the gas side than on the fluid side. This prevents the bladder from eiting into the oil duct, which would destroy the bladder. When the minimum operating pressure is reached, there should be a small volume of fluid between the bladder and the oil valve (appro. % of the nominal volume of the hydraulic accumulator). This prevents the bladder from coming into contact with the valve every time it epands. The gas valve (4) consists of a sealing cap (4.1), gas valve insert (4.2) and gas charging valve body (4.3). These parts can be echanged individually. The type cap (7) contains the technical data and features of the hydraulic accumulator. Symbol General Hydraulic accumulators are hydrostatic devices which are used to store a certain amount of energy, which they dispense as necessary to the hydraulic system. Fluids are only compressible to a small etent, while gases are highly compressible. This difference is the basis for the operating principle of all gas-charged hydraulic accumulators. Depending on the design of the separating element, a distinction is made between bladder-type and diaphragmtype accumulators. Hydraulic accumulators essentially consist of a fluid section and a gas section with a gas-proof separator element. The fluid section is connected to the hydraulic circuit. Bosch Reroth AG, RE 0170/03.14

Bladder-type accumulator HAB Technical data Technical data General Weight See table on page Design Bladder-type accumulator Installation position Fluid connection socket at bottom, others on request Mounting style With clamps and console Ambient temperature range 1 C to +6 C Line connection Screw-in thread Hydraulic Nominal volume V nom l 1 2. 4 6 3 0 Effective gas volume V eff l 2.4 3.7.9 9.2 18.1 33.4 48.7 Maimum permissible flow q ma l/min 240 600 600 600 900 900 900 900 Maimum permissible operating pressure p ma bar 30 30 30 30 330 330 330 330 Maimum permissible pressure fluctuation range Δp dyn bar 0 0 0 0 0 0 0 0 Operating pressure and effective volume See calculation on pages 6 to 9 Hydraulic fluid Hydraulic fluid according to DIN 124; other fluids on request! Hydraulic fluids temperature range (others on request) Pneumatic Filling gas 1 C to +80 C (NBR) 3 C to +80 C (ECO) Nitrogen, cleanliness level, N 2 = 99.99% by volume Gas filling pressure p 0 < 2 bar Hydraulic fluids Temperature range Material Mineral oils 1 C to +80 C 3 C to +80 C NBR 1) ECO 2) HFC C to +60 C NBR 1) Please consult us with respect to other hydraulic fluids and temperatures. 1) Acrylonitrile butadiene rubber (Perbunan) 2) Epichlorhydrin rubber RE 0170/03.14, Bosch Reroth AG

6 HAB Bladder-type accumulator Application, mode of operation Application, mode of operation Calculation Applications Hydro-pneumatic accumulators have many different possible applications: Energy storage to eliminate the need for pump drive power on systems with intermittent operation. Energy reserve for emergencies, e.g. if the hydraulic pump fails. Compensation for leakage. Shock and vibration damping for periodic vibrations. Volume compensation for pressure and temperature changes. charge charge Pressures The following pressures are key factors in calculating an accumulator: p 0 p 0 (t) p 0 (t ma ) p 1 p 2 Gas filling pressure at room temperature and empty fluid space Gas charge pressure at operating temperature Gas charge pressure at ma. operating temperature Minimum positive operating pressure Maimum positive operating pressure The following values are recommended to achieve optimum utilization of the accumulator volume and a long service life: p 0 (t ma ) ~ 0.9 p 1 (1) V 0 V 1 V 2 p 0 p 1 p 2 discharge discharge Mode of operation Fluids are practically incompressible and are therefore unable to store pressure energy. Reroth hydro-pneumatic accumulators use the compressibility of a gas for fluid storage. Only nitrogen of cleanliness level may be used! N 2 = 99.99 % by volume The top hydraulic pressure should not eceed four times the filling pressure as otherwise bladder elasticity is overstressed, leading to ecessive compression changes and strong gas heating: p 2 4 p 0 (2) The service life of the accumulator bladder increases as the difference between p 1 and p 2 decreases. Correspondingly the degree of utilization of the maimum storage capacity is however also reduced. Bosch Reroth AG, RE 0170/03.14

Bladder-type accumulator HAB Calculation 7 Oil volumes The pressures p 0 to p 2 result in the gas volumes V 0 to V 2. Here, V 0 is at also the nominal volume of the accumulator. The available oil volume ΔV is equal to the difference in gas volume V 1 and V 2 : ΔV V 1 V 2 (3) The gas volume that can be changed within one pressure difference is determined by the following equations: a) To isothermal changes of condition of gases, i.e. if the gas cushion changes so slowly that there is enough time for the complete heat echange between the nitrogen and its environment and the temperature therefore remains constant, the following applies p 0 V 0 = p 1 V 1 = p 2 V 2 (4.1) Application of calculation diagrams (see pages 8 to 9) Available oil volume ΔV V [l] V 2 V 1 Isothermal ΔV real = ΔV ideal K i p 0 s 1 Gas filling pressure p 1 p 2 s 2 Δp p [bar] Operating pressure range b) In the case of adiabatic transformation, i.e. a rapid change in the gas cushion entailing a change in the temperature of the nitrogen, the following applies: p 0 V χ 0 = p 1 V χ 1 = p 2 s V χ 2 (4.2) 0.9 p 2 = 0 bar p 2 = 300 bar p2 = 400 bar χ = Ratio of the specific heat of the gas Ki 0.8 (adiabatic eponent), in the case of nitrogen = 1.4 In practice, transformation tends to follow adiabatic rules. Charging is frequently isothermal, discharging adiabatic. Taking into account the equations (1) and (2) ΔV is 0 % to 70 % of the accumulator nominal volume. As reference: V 0 = 1. bis 3 ΔV () Calculation diagram For the purpose of graphic determination, the formulas (4.1) and (4.2) are implemented in the diagrams on pages 8 to 9. Depending on the purpose, the available oil volume, accumulator size or pressures can be ascertained. 0.7 0.6 0.1 0.2 0.3 0.4 0. 0.6 0.7 0.8 0.9 Adiabatic ΔV real = ΔV ideal K a p 1 /p 2 Correction factor K i and K a Equations (4.1) and (4.2) only apply for ideal gases. In the behavior of real gases, however, considerable deviations occur at operating pressures over 0 bar that must be taken into account by correction factors. These can be found in the following diagrams. The correction factors by which the ideal discharge volume V should be multiplied are in a range from 0.6 to 1. Ka 0.9 0.8 0.7 p 2 = 0 bar p2 = 300 bar 0.6 0.1 0.2 0.3 0.4 0. 0.6 0.7 0.8 0.9 p 1 /p 2 RE 0170/03.14, Bosch Reroth AG

8 HAB Bladder-type accumulator Calculation Isothermal state changes p 0 = 1 to 90 bar 1.0 0.8 V [l] 3 30 2 2 1 1.0 8.0 7.0 6.0.0 3.0 2. 1. 1. 0.7 0.6 0. 0.4 p 0 [bar] 1 2 3 4 6 7 89 12 14 16 18 2 30 40 0 60 70 80 90 1 6.0 3.0 0.3 0. 0. 0.2 0.1 0 3 6 4 2. 1 1 2 3 4 30 40 0 0 0 400 Nominal accumulator size [l] p 1, p 2 [bar] 300 p 0 = 0 to 300 bar 1.0 0.8 3 30 2 1.0 7.0 6.0 2. 1. 0.7 0.6 V [l] 2 1 8.0.0 3.0 1. 0. 0.4 p 0 [bar] 0 1 6.0 3.0 0.3 0. 0. 0.2 0.1 0 300 0 3 6 4 2. Nominal accumulator size [l] 1 0 0 300 400 p 1, p 2 [bar] Bosch Reroth AG, RE 0170/03.14

Bladder-type accumulator HAB Calculation 9 Adiabatic state changes p 0 = 1 to 90 bar 1.0 0.8 V [l] 3 30 2 2 1 1.0 8.0 7.0 6.0.0 3.0 2. 1. 1. 0.7 0.6 0. 0.4 p 0 [bar] 1 2 3 4 6 78 9 12 14 16 18 2 30 40 1 6.0 3.0 0.3 0 60 70 80 90 0. 0. 0.2 0.1 0 3 6 4 2. 1 1 2 3 4 30 40 0 0 0 400 Nominal accumulator size [l] p 1, p 2 [bar] 300 p 0 = 0 to 300 bar 1.0 0.8 3 30 2 1.0 7.0 6.0 2. 1. 0.7 0.6 V [l] 2 1 1 8.0 6.0.0 3.0 3.0 1. 0. 0. 0. 0.4 0.3 0.2 0.1 p 0 [bar] 0 0 300 0 3 6 4 2. Nominal accumulator size [l] 1 0 0 300 400 p 1, p 2 [bar] RE 0170/03.14, Bosch Reroth AG

HAB Bladder-type accumulator Dimensions Dimensions [mm] Dimensions hma a b ød ma SW øe øf Nominal volume [l] Order data / type Material number h ma ød ma a b øe øf SW Weight [kg] 1 HAB1-30-4X/2G0G-2N111-BA R90119131 333. 11. 6 70 G3/4" 36 32 HAB1-30-4X/2G0G-2N111-GOST R90132608 2, HAB2.-30-4X/2G07G-2N111-CE R90119133 4 11. 69 70 G1/14" 3 0 HAB2.-30-4X/2G07G-2N111-GOST R90132609 4 HAB4-30-4X/2G07G-2N111-CE R9011913 438. 170 67 70 G1/14" 3 0 16 HAB4-30-4X/2G07G-2E111-CE R90119136 HAB4-30-4X/2G07G-2N111-GOST R901326060 6 HAB6-30-4X/2G07G-2N111-CE R90119137 64. 170 67 70 G1/14" 3 0 HAB6-30-4X/2G07G-2N111-GOST R901326061 HAB-330-4X/2G09G-2N111-CE R90119139 90. 22. 4 70 G2" 76 70 32 HAB-330-4X/2G09G-2E111-CE R90119140 HAB-330-4X/2G09G-2N111-GOST R901326062 HAB-330-4X/2G09G-2N111-CE R90119141 900. 22. 4 70 G2" 76 70 3 HAB-330-4X/2G09G-2N111-GOST R901326063 3 HAB3-330-4X/2G09G-2N111-CE R90119143 1424 22. 4 70 G2" 76 70 8 HAB3-330-4X/2G09G-2N111-GOST R901326064 0 HAB0-330-4X/2G09G-2N111-CE R9011914 1940 22. 4 70 G2" 76 70 123 HAB0-330-4X/2G09G-2N111-GOST R90132606 Bosch Reroth AG, RE 0170/03.14

Bladder-type accumulator HAB Spare parts and accessories 11 Spare parts and accessories HAB mounting elements Console and rubber support ring Console Material number 131334008 3000 Nm 3 1 7 0 ø14 0 260 3 Rubber support ring Material number 1302242 2 1 Clamp 2 Console 3 Rubber support ring Clamp type Material Nominal accumulator size number 1 4 2, 6 3 0 Clamp 1-1 131316021 1 Clamp 160-170 131316022 2 Clamp 218-228 131316026 1 2 Clamp 224-230 13131600 2 Console 131334008 1 1 1 Rubber support ring 1302242 1 1 1 123 ø170 22 RE 0170/03.14, Bosch Reroth AG

E S H C E 9 S H C M 12 HAB Bladder-type accumulator Spare parts and accessories Securing clamps Type F1 F ry F a F r D A L B Type F2 D M A K B L 9 Clamp type Dimensions A B C D E H K L M S Material number Clamp 1-1 F1 13 96 1-1 0 64-69 6 M8 3 131316021 Clamp 160-170 F1 237 147 0 160-170 0 90-9 3 M8 4 131316022 Clamp 218-228 F1 237 147 28 218-228 0 1-12 3 M8 4 131316026 Clamp 224-230 F2 24 212 244 224-230 30 1-123 29 4 M12 3 13131600 Bosch Reroth AG, RE 0170/03.14

Bladder-type accumulator HAB Spare parts and accessories 13 Filling and testing device Additional parts to be ordered separately Material number Pressure gauge (0 to 2 bar) R9000339 Pressure gauge (0 to 60 bar) 1372302 Pressure gauge (0 to 400 bar) 137230 Connection fittings F 13339 GB 1333911 USA 1333912 Measurement set Material number KR 1333913 Measurement set, complete (for bladder-type accumulator HAB) 0383011 J 1333914 Consists of Case (without contents) R9070141 RUS 133391 Filling and testing valve 038300 Pressure gauge (0 to bar) 1372301 Hose l = m with connection fittings D 13076 Hose l = 2. m with connection fittings D 1307 Dimensions of filling and testing valve 1 Valve body with check valve, release valve, pressure gauge port and gas hose port. D 1 2 M14 1. W 24.32 1 1/4 in 0 0 0 00 0 00 3000 00 psi 300 bar 0 1372301 Reroth 0 l = 2. m SAE 7/8 in -14 UNF 1 Spare part, material number 137406 2 Adapter, see pages 14/1 RE 0170/03.14, Bosch Reroth AG

14 HAB Bladder-type accumulator Spare parts and accessories Dimensions [mm] Adapter for nitrogen bottle to union nut 13339 1333913 R900034782 W 21.8 1/14 in 37 SW32 W 24.32 1/14 in W 23 1/14 in 2 SW32 W 24.32 1/14 in M22 1.7 60 SW32 W24.32 1/14 in 1333911 1333914 R9007088 G /8-ISO 228 81 SW32 W 24.32 1/14 in W 22 1/14 in 68 SW32 W 24.32 1/14 in W21.8 1/14 in 79 SW32 W24.32 1/14 in 1333912 133391 R9070776 W 24.1 1/14 in 81 SW32 W 24.32 1/14 in G 3/4-ISO 228 4 SW36 W 24.32 1/14 in G/8-ISO228 61 SW32 W 24.32 1/14 in Bosch Reroth AG, RE 0170/03.14

Bladder-type accumulator HAB Spare parts and accessories 1 Country Brazil Bulgaria China France Greece United Kingdom India Italy Japan Canada North Korea South Korea Malaysia Meico Romania Russia Spain Saudi Arabia Singapore Taiwan Turkey USA 13339 1333911 1333912 1333913 1333914 133391 R900034782 R9007088 R9070776 Other countries on request Accumulator adapter for accumulator shut-off blocks type ABZSS Please select the type required in accordance with data sheet 0131. Connection fitting for accumulator shut-off blocks NG/DN type 032VAW in accordance with data sheet 0128 ød±0.3 D2 ød4 R2 L2 SW L 18 R1 D1 ø46±0.3 ød3 Safety block acc. to ISO 228 Dimensions [mm] Material number D1 M socket piece A [Nm] D2 M A [Nm] L L2 ød3 ød4 ød SW Part number complete with seals R1 and R2 M33 2 3 +30 G3/4 180 +18 64 28 3 12 42 46 13339038 R9012287 G1/14 40 +4 74 37 63 13339039 R9012289 G2 00 +0 8 44 90 30 7 80 13339040 R90122860 RE 0170/03.14, Bosch Reroth AG

16 HAB Bladder-type accumulator Spare parts and accessories Connection fitting, inch to metric thread HAB.. 1X to HAB.. 4X D2 ød4 R2 L2 H SW D1 ød3 Nominal volume [l] acc. to ISO 228 acc. to ISO 228 Dimensions [mm] Material number D2 M socket piece A [Nm] D1 M A [Nm] H L2 ød3 ød4 SW Part number complete with seal R2 1 G3/4 180 +18 M30 1. 180 +18 32 28 46 12 41 13334047 R90122863 2, to 6 G1/14 40 +4 M40 1. 400 +40 43 37 60 13334048 R90122864 to 0 G2 00 +0 M0 1. 40 +4 41 44 78 32 70 13334049 R9012286 Reducing nipple for pipe connection ød2 D4 R2 H L2 SW D1 ød3 Nominal volume [l] acc. to ISO 228 acc. to ISO 228 Dimensions [mm] Material number D2 M socket piece A [Nm] D1 M A [Nm] H L2 ød3 ød4 SW Part number complete with seal R2 1 G3/4 180 +18 G3/8 70 +7 8 28 38 12 32 13334039 R90122880 2, to 6 G1/14 40 +4 G1/2 11 +12 8 37 60 24 13334043 R90122884 G1/14 40 +4 G3/4 180 +18 8 37 60 24 13334040 R90122881 to 0 G2 00 +0 G1/2 11 +12 44 7 30 6 13334044 R9012288 G2 00 +0 G3/4 180 +18 44 7 30 6 13334041 R90122882 G2 00 +0 G1 3 +31 44 7 30 6 1333404 1333404 G2 00 +0 G1 1/2 40 +4 40 44 7 32 6 13334042 R90122883 Bosch Reroth AG, RE 0170/03.14

Bladder-type accumulator HAB Spare parts and accessories 17 Pressure safeguarding Pressure protection kit R90134660 Consists of Quantity 1 Bursting disk, 360 bar 1 2 Adapter 1 3 Protection cap 1 4 O-ring 2 Adapter nut (1 to 32 l) 1 ø4 Gas valves Gas valve spare parts kit R901337986 Consists of Quantity 1 Protection cap 1 2.1 Sealing cap, series 40 1 3.1 Valve insert, series 40 1 4.1 Gas valve, series 40 1 2.2 Sealing cap, series 41 1 3.2 Valve insert, series 41 1 4.2 Gas valve, series 41 1 Nut 1 3 4 1 7/8-14UNF 1 1 G1/4 2 Series 40 Series 41 2.1 2.2 M0 1. 6 3.1 3.2 7/8-14UNF 4.1 4.2 RE 0170/03.14, Bosch Reroth AG

18 HAB Bladder-type accumulator Spare parts and accessories Spare parts 30 40 Spare bladder with gas valve 41 and seal set Oil valve kit consisting of Retaining ring Accumulator size NBR ECO retaining ring and oil valve 1 liter R90124264 R90127463 2. liters R901242646 R90127464 4 liters R901242647 R901212 R90127440 R9012746 6 liters R901242648 R90127440 R9012746 liters R901242649 R901214 R90127441 R90127466 liters R90124260 R90127441 R90127466 3 liters R90124261 R90127441 R90127466 0 liters R90124262 R90127441 R90127466 Series 41 Series 40 ø7.8 VG8 1 2 4 a 3 Gas valve 1/2 in UNF Gas valve M 1. Accumulator frame size Item 1 O-ring Item 2 Support ring Item 3 O-ring Item 4 O-ring Item ED12 Item a O-ring 1 liter ø36.1 3. ø16.9 2.7 ø7 2. ED12 1. ø.82 1.78 2. to liters ø 3. ø30 3 ø7 2. ED12 1. ø.82 1.78 4 to liters ø 3. ø 61 1.4 ø30 3 ø7 2. ED12 1. ø.82 1.78 to 0 liters ø78.74.33 ø80 89 1.7 ø48 3 ø7 2. ED12 1. ø.82 1.78 40 30 Bosch Reroth AG, RE 0170/03.14

Bladder-type accumulator HAB Intended use 19 Intended use Legal regulations Reroth bladder-type accumulators HAB..-4X are designed for installation in hydraulic drive systems in stationary machines and systems. In mobile application or application in which acceleration forces act on the bladder-type accumulator during intended operation, use is only permitted with the prior approval of the responsible Bosch Reroth product manager. Please contact the Technical Sales department. Reroth bladder-type accumulators HAB..-4X are not intended for private use. Note! They must not be used in eplosive environments in accordance with directive 94/9/EC (ATEX). Hydraulic accumulators are pressure vessels and are subject to the national specifications and regulations applicable at the place of installation. In Germany the Ordinance on Industrial Safety and Health (BetrSichV) applies. Special stipulations are to be observed in shipbuilding, aircraft construction, mining, etc. Equipment is designed, manufactured and tested in accordance with the appendices of EN 1439. Installation, fitting and operation are governed by the "Technical Regulations for Pressure Vessels". Note! All vessel classes shall be protected by a pressure-relief valve according to directive 97/23/EG. Safety instructions on hydraulic accumulators For hydraulic accumulators, compliance with the specifications valid at the place of installation must be ensured before commissioning and during operation. The operator bears the sole responsibility for compliance with all applicable specifications. General instructions for hydraulic accumulators in hydraulic systems are provided by DIN EN ISO 4413. Qualified persons In accordance with the German Ordinance on Industrial Safety and Health (BetrSichV), eaminations may only be performed by qualified persons. Qualified persons are persons who have acquired the necessary specialist knowledge on account of their vocational training, professional eperience and recent professional activities. Documents provided must be kept in a safe place. They will be needed by eperts conducting regular eaminations. Warning! Do not perform any welding, soldering or mechanical work on the accumulator vessel. Risk of eplosion during welding or soldering work! Risk of bursting and loss of operating license in the event of mechanical processing! Do not charge the hydraulic accumulator with oygen or air. Risk of eplosion! Depressurize prior to working on hydraulic systems and protect against switching back on. Serious accidents may be caused by incorrect installation. Commissioning may only be performed by qualified specialist personnel. RE 0170/03.14, Bosch Reroth AG

HAB Bladder-type accumulator Safety devices Safety devices In accordance with the Technical Regulations for Pressure Accumulators (TRB), additional safety equipment is necessary. The safety devices are summarized in the compact Bosch Reroth accumulator safety block: Type ABZSS in accordance with data sheet 0131 Type 032VAW in accordance with data sheet 0128 6 S M 1 M 2 a 1 P T 3 2 4 1 System shut-off cock 2 Pressure relief valve 3 Manual unloading 4 Electro-magnetic unloading, optional Pressure measurement device 6 Safety device against ecessive temperatures M 1 ; M 2 P S T Measuring port Pump connection Accumulator port Tank port Bosch Reroth AG Hydraulics Zum Eisengießer 1 97816 Lohr am Main, Germany Phone +49 (0) 93 2 / 18-0 Fa +49 (0) 93 2 / 18-23 8 documentation@boschreroth.de www.boschreroth.de This document, as well as the data, specifications and other information set forth in it, are the eclusive property of Bosch Reroth AG. It may not be reproduced or given to third parties without its consent. The data specified above only serve to describe the product. No statements concerning a certain condition or suitability for a certain application can be derived from our information. The information given does not release the user from the obligation of own judgment and verification. It must be remembered that our products are subject to a natural process of wear and aging. Bosch Reroth AG, RE 0170/03.14