Ransomes Marquis, Super Certes and Super Bowl WARNING

25066G (Rev.0) Parts Manual Ransomes Marquis, Super Certes and Super Bowl 51 Marquis Product Code: LDAA504 Series: EF4 61 Marquis Product Code: LDCB604 Series: EG4 51 Super Certes Product Code: LDFC504 Series: EC4 61 Super Certes Product Code: LDFC604 Series: JG4 51 Super Bowl Product Code: LDFD504 Series: JF4 WARNING WARNING: If incorrectly used this machine can cause injury. Those who use and maintain this machine should be trained in its proper use, warned of its dangers and should read the entire manual before attempting to set up, operate, adjust or service the machine. RJL 100 January 2015

1 CONTENTS SECTION PAGE SECTION PAGE Introduction Important... 3 Product Identification... 4 Guidelines For The Disposal Of Scrap Products... 5 Key Numbers... 6 Service Parts... 6 Parts Main Frame... 8 Engine... 10 Throttle Linkage... 12 Cylinder Drive... 14 Cylinder Drive... 16 Handles... 18 Brakes... 20 Brakes And Scraper Super Certes... 22 Front Roll Marquis 51cm... 24 Front Roll Marquis 61cm... 26 Landroll Super Certes 51cm And 61cm... 28 Landroll Marquis 51cm And 61cm And Super Bowl 51cm... 30 Kickstand... 32 Drive Assembly... 34 Drive Assembly... 36 Decals... 40 Transport Wheels Super Certes Only... 42 Plain Steel Front Roll... 44 Grooved Front Roll... 46 Verti-groom Kit... 48 Verti-groom Kit... 50 Tow Bar Marquis 61cm Only... 52 Trailing Seat Marquis 61cm Only... 54 2015, Ransomes Jacobsen Limited. All Rights Reserved

INTRODUCTION 2 2.1 IMPORTANT The Super Bowl, Super Certes and Marquis with petrol engine are walk behind cylinder mowers. With chain traction and cylinder drives IMPORTANT: Do the maintenance indicated in this manual to make sure that the quality of cut is kept at a high level. This Manual is part of the machine and must stay with the machine always. The suppliers of new, or used, machines need to keep this documentation and supply the owners with a copy. You must use the machine to cut the grass only and not for any other purpose. The Compliance with these conditions of The operation, service and repair specified by the manufacturer, are understood to be part of the correct use. ALL operators MUST read through this manual and understand the Safety Instructions, controls, lubrication and maintenance procedures. Make sure that you obey all safety and road traffic regulations. You must not make any changes to the machine that are not approved by the manufacturer. This type of change can release the manufacturer from the liability for any damage or injury. Discard of worn parts in alignment with all local environment protection regulations. Use the local systems available in the country where the machine is used, for these recycled materials. When the machine is at its end of life, there are guidelines in this manual for the removal of the machine from use. Use only Ransomes Jacobsen Genuine spare parts to meet the machine type approval regulations specified by the European Union. 2006/42/EC These instructions are the Original instructions confirmed by Ransomes Jacobsen Limited en-3

Kg Kg Kg Kw West Road Ransomes Europark Ipswich IP3 9TT England 2 INTRODUCTION 2.2 PRODUCT IDENTIFICATION A B C D E F G H J Maximum front axle load in Kg (for all machines being driven on the highway) Weight-Mass in Kg Maximum rear axle load in Kg (for all machines being driven on the highway) Power Rating in Kw Date code Machine type (Name) Product code Product name Serial number West Road Ransomes Europark Ipswich IP3 9TT England A B C D E Kg Kg Kg Kw F G H J Location of Serial number plate The serial plate and guaranteed sound power decal A is located on the right hand side of the chassis. Chassis Stamp The Serial number and date code (C) are shown on the chassis between the serial plate and engine data decals (D). A A C en-4

INTRODUCTION 2 2.3GUIDELINES FOR THE DISPOSAL OF SCRAP PRODUCTS 2.3.1 DURING SERVICE LIFE All the used fluids and parts must be controlled as hazardous materials material. Recommended procedures must be followed for their safe removal. If a fluid leak occurs, contain the spill to make sure that the leak does not flow into the ground or drainage system. Follow the regulations in force to make sure that leaks are controlled. The maintenance procedures in this manual make sure that the damage that the machine can cause in the local environment is controlled. When the machine completes its full service life, the following actions must be taken. 2.3.2 END OF SERVICE LIFE These guidelines must be used with applicable Health, Safety and Environmental laws. Always use the approved local waste disposal and agencies for recycled materials. Park the machine in an applicable area to use all of the necessary lifting equipment. Use correct tools and Personal Protective Equipment (PPE) and take instruction from the technical manuals applicable to the machine. Remove and store correctly 1. Batteries 2. Fuel 3. Engine coolant 4. Oils Read the Technical Manual before you begin to disassemble the machine. Plan the disassembly, give attention to parts that are in a state of mechanical pressure or contain stored energy e.g springs. Items that continue to have a service life must be separated and returned to the local dealer. Items that are worn must be separated into the material groups and removed according to the agencies for the recycled materials that are available. Common examples. Steel Non ferrous metals Aluminium Brass Copper Plastic materials Identified Can be recycled Can not be recycled Not identified Rubber Electrical and Electronic Components Some parts are not easily separated e.g Hydraulic Hose. These materials must be added to the General discarded materials area. Do not burn discarded materials. Change the machinery records to show that the machine is not in operation and is discarded. Supply this serial number to The Ransomes Jacobsen Warranty Department to close their records. en-5

2 INTRODUCTION 2.4 KEY NUMBERS Record the key numbers Starter Switch:- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - Record the machine and the engine numbers. The machine serial number is found on the registration plate and the engine serial number is on the rocker cover. Machine Number:-- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - Engine Number:-- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - 2.5 SERVICE PARTS SERVICE PARTS Part No. Description Part No. Description MBC3140E Cylinder 10k X 61 cm S/C 009151220 Brake Band Marquis S/B MBF2159 Cylinder 6k X 51 cm Marquis MBG6396 Brake Drum Marquis S/B MBC4518E Cylinder 5k X 61 cm Marquis 9151210 Brake Band S/C MBC3139E Cylinder 10k X 51 cm S/B S/C 4246272 Primary Chain 4299354 Handles 51cm 008111210 Clutch Cable 4299351 Handles 61cm 009067800 Brake Cable 221505110 Bottom Blade S/C S/B 51 001190026 Blade Screws S/C S/B 51 en-6

INTRODUCTION 2 en-7

MAIN FRAME 4246970_S-Ped_M-Frame.eps Parts- 8

ITEM PART NO. QTY DESCRIPTION Notes/Serial Numbers 1 1191357 2 Screw Pan M4 x 8 2 2090580 1 Bearing 17 x 47 x 22.2 3 009133066 1 Grass Box Marquis 51 & S/Bowl 51 4 009133074 1 Grass Box Marquis 61 5 009133414 1 Grass Box S/Certes 51 6 009133422 1 Grass Box S/Certes 61 7 MBG6386 1 Pinion-11T x 3/8 Pitch 8 4139972 1 Main Frame S/Bowl & S/Certes 51 9 4139973 1 Main Frame Super Certes 61 10 4139974 1 Main Frame Marquis 51 11 4139975 1 Main Frame Marquis 61 12 450190 1 Screw Hex M8 x 16 13 450191 2 Screw Hex M8 x 20 14 450378 12 Nut Hex M8 Nyloc 15 450389 2 Washer M6 x 12.5 x 1.8 16 450390 13 Washer M8 x 17 x 1.8 17 450411 1 Lock Washer M8 x 12.75 x 2 18 450473 2 Screw Hex M8 x 30 19 450552 8 Screw Pan M8 x 20 20 452174 1 Key - 6 x 6 x 18 21 452694 2 Screw Hex M6 x 16 22 MBA5024 1 51 cm Concave Marquis 23 MBB0204 1 51 cm Concave S/ Bowl & S/ Certes 24 MBC3478 1 61 cm Concave S/Certes 25 MBC4526 1 61 cm Concave Marquis 26 MBC7064 2 Plate Marquis 27 MBC8847 1 Grass Box Bracket RH Marquis 51/61 28 MBC8850 1 Grass Box Bracket LH Marquis 51/61 29 MBC9892 1 Grass Box Bracket RH S/Bowl & S/Certes 51/61 30 MBC9893 1 Grass Box Bracket LH S/Bowl & S/Certes 51/61 31 MBC9657 1 Cover Plate 32 MBC9900 2 Plate For S/Bowl & S/Certes 33 MBG6358 1 Housing-Bearing 34 4298051 1 Shaft - 61cm 35 4298391 1 Shaft - 51cm 36 1290337 2 Screw Button M8 x 20 37 2920501 2 Spring Disc 8.2 x 16 x 0.9 38 450474 2 Screw Hex M8 x 40 Parts- 9

Engine 4288491_Group_Engine.eps Parts- 10

ITEM PART NO. QTY DESCRIPTION Notes/Serial Numbers 1 4246270 1 Engine - Honda GX120-QX9 3 670000116 1 Washer, Fibre 25/64 X 5/8 X 1/16 4 MBG6288 1 Drain Plug Extension 5 450474 2 Screw Hex M8-1.25 X 40 6 450390 2 Washer M8 X 17 X 1.8 7 450378 2 Nut Hex M8-1.25 8 450473 2 Screw Hex M8-1.25 X 30 9 4135990 1 Torque, Clutch 10 4298051 1 Shaft 61cm 10 4298391 1 Shaft 51cm 11 452200029 3 Lock Washer 1/4 X 425 X 072 12 434029 3 Screw 1/4-20 X 1 Cap 13 456010200 2 Screw Hex 5/16-24 X 3/4 14 450171 8 Screw Hex M6-1.0 X 20 15 450377 8 Nut Hex M6-1.0 16 4300366 2 Half-Clutch Cover 61cm Models 16 4136632 2 Half-Cover, Clutch 51cm Models Parts- 11

THROTTLE LINKAGE 4300812-A_Throttle_Linkage.eps Parts- 12

ITEM PART NO. QTY DESCRIPTION Notes/Serial Numbers 1 4108643 1 Spring, Throttle Plate 2 4310867 1 Cable Guide 3 804100288 1 Solder Less Nipple 4 4137299 1 Screw, # 6-32.1875 5 4299989 1 Spacer, Cable Guide 6 4299987 1 Spring, Engine Throttle 7 450528 1 Screw Pan M5-0.8 X 16 8 450322 1 Nut Hex M5-0.8 9 4301754 1 Cable Guide Parts- 13

CYLINDER DRIVE 4246978_Group_Cyl_and_Drive.eps Parts- 14

ITEM PART NO. QTY DESCRIPTION Notes/Serial Numbers 1 001090731 2 Bolt Hex M10-1.5 X 140, 2 001290094 2 Screw Button3/8-24 X 3/4 3 002036031 2 Bearing 17 X 40 X 12 4 002299358 2 Seal 5 002910760 1 Spring Comp 43 I/d X 092" X 20 6 002920501 3 Spring Disc 8.2 X 16 X 0.9 7 002920836 1 Spring Disc 10.2 X 23 X 1 9 008111210 1 Clutch Cable 10 LMSE122 1 Pinion & Sleeve, Reel Drive 11 MBC5294 1 Sliding Clutch 12 MBC5093 1 Bracket 13 MBC4686A 1 Cover Plate 14 450190 1 Screw Hex M8-1.25 X 16 8.8 15 001290337 1 Screw Button M8 X 20 16 450378 2 Nut Hex M8-1.25 8, Nyloc 17 450379 2 Nut Hex M10-1.5 8, Nyloc 18 450411 1 Lock Washer M8 X 12.75 X 2 19 450412 2 Lock Washer M10 X 15.9 X 2.5 20 451153 2 Screw Pan # 12-1.8 X 13, Self Tapping 21 451970 2 Circlip Internal 40 X 1.75 22 452042 1 Circlip External 17 X 1 23 452694 2 Screw Hex M6-1.0 X 16 24 456010331 2 Screw Hex 3/8-24 X 3/4 25 461003665 2 Spring 26 804100288 1 Solderless Nipple Bottom Block and Blades 27 LMAY588A 1 Block & Blade 51 S/B & S/C * N/A 1 Bottom Block * 221505110 1 Bottom Blade * 001190026 8 Countersunk Screws 28 LMAA786A 1 Block & Blade 61 S/C * N/A 1 Bottom Block * MBA7083 1 Bottom Blade * 001190026 8 Countersunk Screws 29 LMAY590A 1 Block & Blade 51 Marquis * N/A 1 Bottom Block * MBA7017 1 Bottom Blade * 001190026 8 Countersunk Screws 30 LMAA787A 1 Block & Blade 61 Marquis * N/A 1 Bottom Block * MBA7050 1 Bottom Blade * 001190026 8 Countersunk Screws All Models 31 LOY0013 2 Dust Cover Cutting Cylinders 32 MBC3139E 1 Cylinder 10k X 51 cm 51 S/B & S/C 33 MBC3140E 1 Cylinder 10k X 61 cm 61 Super Certes 34 MBF2159 1 Cylinder 6k X 51 cm 51 Marquis 35 MBC4518E 1 Cylinder 5k X 61 cm 61 Marquis Parts- 15

CYLINDER DRIVE 4246978_Group_Cyl_and_Drive.eps Parts- 16

ITEM PART NO. QTY DESCRIPTION Notes/Serial Numbers 36 MBC3183 1 Distance Piece 37 MBC3962B 1 Clutch Lever 38 MBC3979 1 Bearing Housing RH 39 MBC3980 1 Bearing Housing LH 40 MBC5316 1 Retaining Plate 41 MBC5915 2 Grease Ring 42 MBC7028 2 Locknut Hex M10 X 95 43 450390 3 Washer M8 X 17 X 1.8 45 450323 1 Nut Hex M6-1.0 8 46 450171 1 Screw Hex M6-1.0 X 20 47 450634 1 Screw M8-1.25 X 25 48 002993013 2 Lubricator M6 Straight Parts- 17

HANDLES 42922757_Handles_51cm.eps Parts- 18

ITEM PART NO. QTY DESCRIPTION Notes/Serial Numbers 1 002193350 2 Bearing Nyliner 12 X 13.6 X 12 2 002953390 1 Grommet 3 002990800 1 Tee Handle 4 006500400 1 Recoil Rope Guide 5 008111210 1 Clutch Cable 6 4311006 1 Throttle Control 7 008111400 2 Lever Landroll Clutch 8 009067800 1 Cable Brake 9 009067810 1 Cable Brake 10 009067820 1 Cable Brake 11 4312167 1 Landroll Clutch Cable 12 4130979 1 Handle Bracket 13 4130982 1 Spring Spigot 14 4130983 1 Special Cap Screw 15 4130984 2 Handle Grip 16 4130985 1 Conical Spring 17 4131063 1 Knurled Knob 18 4139803 1 Landroll Clutch Cable 19 MBG6219 1 Handle Bracket LH 20 450177 1 Screw Hex M6-1.0 X 50 21 450191 1 Screw Hex M8-1.25 X 20 22 452568 2 Bolt M8-1.25 X 45 23 450324 3 Nut Hex M8-1.25 24 450377 2 Nut Hex M6-1.0, 25 450378 5 Nut Hex M8-1.25 26 450389 5 Washer M6 X 12.5 X 1.8 27 450390 9 Washer M8 X 17 X 1.8 28 450545 4 Screw Pan M6-1.0 X 35 29 450726 2 Cap Screw Hex M8-1.25 X 35 30 451617 2 Pin tension 4 X 20 31 MBF2097 1 Brake Lever 32 4299354 1 Handles 51cm 32 4299351 1 Handles 61cm 33 MBG5994 1 Lever Brake 34 MBG6191 1 Pivot Shaft 35 MBG6428 4 Spacer-6.3 X 10 X 21.5 36 002990293 2 Plastic Star Knob M8 X 40 37 450018 4 Bolt Hex M8-1.25 X 50 38 MBC9297 4 Washer 8.5 X 26.5 X 1.6 39 4298191 2 Handlebar Support 40 4301072 4 Isolation Mount + Tube Parts- 19

BRAKES 4246982_Mrq_Sb_Brakes_Landroll.eps Parts- 20

ITEM PART NO. QTY DESCRIPTION Notes/Serial Numbers 2 009067150 1 Scraper 3 009067810 1 Cable Brake 4 009151220 1 Brake Band 5 MBF2157 1 Brake Bracket 6 450149 1 Screw Hex M5-0.8 X 12 7 450191 6 Screw Hex M8-1.25 X 20 8 450378 6 Nut Hex M8-1.25 9 450390 8 Washer M8 X 17 X 1.8 10 450411 2 Lock Washer M8 X 12.75 X 2 11 MBG1335 2 Scraper Bracket 12 MBG6091 1 Cable Clamp 13 MBG6396 1 Brake Drum 14 009072070 2 Washer M8 X 22 X 3 Parts- 21

BRAKES AND SCRAPER SUPER CERTES 2970004-2.eps Parts- 22

ITEM PART NO. QTY DESCRIPTION Notes/Serial Numbers 1 9067130 1 Scraper Super Certes 61 2 9167150 1 Scraper Super Certes 51 3 9067800 1 Cable Brake 4 9067820 1 Cable Brake 5 9151210 2 Brake Band 7 450149 1 Screw Hex M5 x 12 8 450191 6 Screw Hex M8 x 20 9 450378 6 Nut Hex M8 Nyloc 10 450390 8 Washer M8 x 17 x 1.8 11 450411 2 Lock Washer M8 x 12.75 x 2 12 450865 2 Screw M8 x 20 13 450949 1 Screw Set M5 x 5 14 MBF2025 1 Brake Plate LH 15 MBF2028 1 Brake Plate RH 16 MBG1335 2 Scraper Bracket 17 MBG6091 2 Cable Clamp Parts- 23

FRONT ROLL MARQUIS 51cm 2990005_Group_Front_Roll.eps Parts- 24

ITEM PART NO. QTY DESCRIPTION Notes/Serial Numbers 3 002921222 2 Spring Disc 16.3 X 34 X 1.5 4 002990293 1 Plastic Star Knob M8 X 40 5 009070107 1 Adjuster 6 4143028 1 Main Frame 7 450191 2 Screw Hex M8-1.25 X 20 8 450241 1 Screw Hex M12-1.75 X 30 9 450378 1 Nut Hex M8-1.25 10 450390 2 Washer M8 X 17 X 1.8 11 450411 2 Lock Washer M8 X 12.75 X 2 12 450413 1 Lock Washer M12 X 17.9 X 2.5 13 451581 1 Pin Tension 3 X 20 14 452000473 5 Washer 9/16 X 1-1/8 X 104 16 603000700 2 Wood Roll 17 603000742 2 Wood Roll 18 MBC3953a 1 Roll Carriage 19 MBC5201 1 Spindle 20 MBC5328A 1 Trunnion 21 MBC5330A 1 Adjusting Lever 22 MBC9862 1 Pivot LH 23 MBE3426 1 Carriage 24 MBF340 1 Inner Carriage Parts- 25

FRONT ROLL MARQUIS 61cm 301R0005-2.eps Parts- 26

ITEM PART NO. QTY DESCRIPTION Notes/Serial Numbers 1 2193295 1 Bush-Nylon 10.4 x 18 x 50 2 2910794 1 Spring Comp 15.88 x 1.83 x 63.5 3 2990552 1 M10 Hand Wheel 4 9071030 1 Adjusting Screw 5 4143029 1 Main Frame 61 Marquis 6 450191 5 Screw Hex M8 x 20 7 450241 2 Screw Hex M12 x 30 8 450324 2 Nut Hex M8 9 450325 1 Nut Hex M10 10 450378 1 Nut Hex M8 Nyloc 11 450389 4 Washer M6 x 12.5 x 1.8 12 450390 1 Washer M8 x 17 x 1.8 13 450391 3 Washer M10 x 21 x 2.2 14 450411 5 Lock Washer M8 x 12.75 x 2 15 450413 2 Lock Washer M12 x 17.9 x 2.5 16 451488 2 Pin Spirol 8 x 20 17 451581 1 Pin Tension 3 x 20 18 452000473 6 Washer 9/16 x 1-1/8 x.104 19 452692 2 Screw Hex M6 x 12 20 452695 2 Screw Hex M6 x 20 21 603000734 3 Wood Roll 22 603000742 2 Wood Roll 23 LMSD971 1 Ferrule 24 MBC4544A 1 Roll Carriage 25 MBC4548A 1 Spindle 26 MBC5383 1 Bearing Bracket 27 MBC5384 1 Bearing Plate 28 MBC5385 1 Link 29 MBC5387 1 Support Bracket 30 MBC5389 2 Packer 31 MBE3426 1 Collar 32 MBE3426 1 Carriage 33 MBF2176 1 Cross Shaft 34 450410 2 Washer - M6 * LMSE153 1 Steel Front Roll, 61 Marquis See Accessories Parts- 27

LANDROLL SUPER CERTES 51cm AND 61cm 4246991-2.eps Parts- 28

ITEM PART NO. QTY DESCRIPTION Notes/Serial Numbers 1 1191331 1 Screw Pan M5 x 16 2 1490658 1 Cotter Pin 3 2036049 2 Bearing 20 x 47 x 14 4 2193106 4 Bush-Devol 25 x 30 x 30 5 2300580 6 Sealing Ring 6 2920501 6 Spring Disc 8.2 x 16 x 0.9 7 MBF2030 1 Chain Wheel 8 450020087 1 Nut Hex 3/8-24 9 450172 2 Screw Hex M6 x 25 10 450190 6 Screw Hex M8 x 16 11 450388 1 Washer M5 x 10 x 1.1 12 450391 1 Washer M10 x 21 x 2.2 13 450410 2 Lock Washer M6 x 9.6 x 1.5 14 450412 1 Lock Washer M10 x 15.9 x 2.5 15 450433 6 Lock Washer M8 x 15 x 0.8 16 450727 7 Cap Screw M8 x 40 17 450968 2 Screw Set M8 x 10 18 451977 2 Circlip Internal 47 x 1.75 19 452045 1 Circlip External 20 x 1.2 20 452145 4 Key - 4 x 4 x 12 21 452176 1 Key - 6 x 6 x 22 22 456090042 6 Cap Head Screw 23 690040344 2 Bevel Gear 24 690040352 2 Bevel Gear 25 MBA5284A 2 Dust Shield 26 MBA5347A 2 Distance Collar 27 MBC4559 2 Adjusting Collar 28 MBC4955 1 Cover Plate 29 MBC5191A 1 Cover Plate 30 MBC5464 1 Nut Hex M20-1.0 31 MBC7008A 2 Washer 25.4 x 45 x 1 32 MBF1370 1 Gear Carrier 33 MBG0106A 2 Gear Flange 34 MBG5819 2 Housing 35 MBG5837 1 Landroll Shaft Super Certes 51 36 MBG5848 1 Landroll Shaft Super Certes 61 37 MBG6102 2 Landroll Super Certes 51 38 MBG6255 2 Landroll Super Certes 61 Parts- 29

LANDROLL MARQUIS 51cm AND 61cm AND SUPER BOWL 51cm 4246986-2.eps Parts- 30

ITEM PART NO. QTY DESCRIPTION Notes/Serial Numbers 1 1191331 1 Screw Pan M5 x 16, 2 1490658 1 Cotter Pin 3 2036049 2 Bearing 20 x 47 x 14 4 2920501 6 Spring Disc 8.2 x 16 x 0.9 5 MBF2030 1 Chain Wheel 6 450020087 1 Nut Hex 3/8-24 7 450172 2 Screw Hex M6 x 25 8 450190 6 Screw Hex M8 x 16 9 450388 1 Washer M5 x 10 x 1.1 10 450391 1 Washer M10 x 21 x 2.2 11 450410 2 Lock Washer M6 x 9.6 x 1.5 12 450412 1 Lock Washer M10 x 15.9 x 2.5 13 450968 2 Screw-Set M8 x 10 14 451977 2 Circlip Internal 47 x 1.75 T 15 452045 1 Circlip External 20 x 1.2 T 16 452176 1 Key - 6 x 6 x 22 17 456090042 6 Cap Head Screw 18 690040344 2 Bevel Gear 19 690040352 2 Bevel Gear 20 840000270 4 Lubricator-1/8 BSP Straight 21 MBA5284A 2 Dust Shield 22 MBA5347A 2 Distance Collar 23 MBC3307 4 Grease Tube 24 MBC4559 2 Adjusting Collar 25 MBC4954 1 Cover Plate 26 MBC5191A 1 Cover Plate 27 MBC5464 1 Nut Hex M20 x1.0 28 MBC7008A 2 Collar 29 MBF1370 1 Gear Carrier 30 MBF2037A 2 Landroll, Plain Super Bowl 51 31 MBF2036 2 Landroll, Ribbed Marquis 51 32 MBC3308 2 Landroll, Ribbed Marquis 61 33 MBG5797 1 Landroll Shaft Marquis & Super Bowl 51 34 MBG5867 1 Landroll Shaft Marquis 61 35 MBG5819 2 Housing Parts- 31

KICKSTAND kickstand.eps Parts- 32

ITEM PART NO. QTY DESCRIPTION Notes/Serial Numbers MBC4150C 1 Kickstand 51cm For Super Certes 51 only MBC4151C 1 Kickstand 61cm For Super Certes 61 only 1 454400245 2 Clevis Pin, 5/16" x 5/8" 2 450390 2 Washer M8 x 17 x 1.8 3 451208 2 Split Pin 2 x 14 4 MBC4158 1 Anchor Bracket 5 MBC4157 1 Anchor Bracket 6 450190 4 Screw Hex M8 x 16 8 450411 4 Lock Washer M8 x 12.75 x 2 9 2900950 2 Spring 18 x 2.5 x 85.8 11 MBC5703A 2 Plate 12 450192 4 Screw Hex M8 x 25 13 450191 2 Screw Hex M8 x 20 14 450390 6 Washer M8 x 17 x 1.8 15 450378 6 Nut Hex M8 Nyloc Parts- 33

DRIVE ASSEMBLY 4246984-2_Group_Drive.eps Parts- 34

ITEM PART NO. QTY DESCRIPTION Notes/Serial Numbers 1 002952227 1 Plastic Plug 2 009125100 1 Seal Grommet 3 MBE3667A 2 Cover Nut 4 MBG6240 1 Side Cover 6 450323 1 Nut Hex M6-1.0 8 7 4139803 1 Landroll Clutch Cable 8 MBC5918 1 Shoulder Bolt 9 002920852 1 Spring Disc 12.2 X 25 X 0.7 10 MBC4430 1 Clutch Lever 11 001434086 2 Pin 12 002992017 1 Steel Ball 13 001393361 1 Nut Hex M12-1.75 14 002192037 1 Thrust Collar 15 450382 1 Nut Hex M16-2.0 8 Nyloc 16 450324 2 Nut Hex M8-1.25 8 17 MBC7111 1 Stud Cover 18 001092262 1 Stud M8 x 40 19 002911017 5 Spring Comp 17.5 X 2.75 X 35 20 MBG6396 1 Brake Drum 21 MBC5916 5 Spring Bolt 22 MBC4704 1 Outer Clutch Plate 23 001191315 4 Screw M5 X 16, 24 002106246 2 Bush Oilite 18 X 22 X 12 26 LMSE155 1 Clutch Body 28 002900686 2 Spring 7/16 X 0.056 X 3 30 4246731 6 O Ring 14 Id X 2.5 31 4246733 3 Chain Tensioner 33 450390 5 Washer M8 X 17 X 1.8 * 002920501 3 Spring Disc 8.2 X 16 X 0.9 * MBG5251 1 Plate 39 MBF1890 1 Cam Plate 40 MBC5095 2 Plate * MBG5269 1 Spacer Block 42 009131925 2 Chain Tensioner * MBC3171 1 Bush-steel 8.5 X 14 X 15 * MBC5094 1 Plate * MBG1887 1 Clamp * MBG5429 1 Bracket * MBG6265 2 Side Plate LH * 4246734 1 Group-chain Tensioner 50 690403314 18 Friction Pad 51 539000836 1 Bush * LCG1451a 1 Chain Wheel * LMAY408 1 Chain Wheel 55 4246272 1 Primary Chain 56 MBE1141B 1 Sprocket * MBG5812 1 Boss 58 MBF2030 1 Chain Wheel * MBG6453 1 Boss 60 4139980 1 Bracket * MBE0899 1 Side Plate RH Parts- 35

DRIVE ASSEMBLY 4246984-2_Group_Drive.eps Parts- 36

ITEM PART NO. QTY DESCRIPTION Notes/Serial Numbers * 4143031 1 Top Deck * 4139972 1 Main Frame 67 4246274 1 Final Chain-1/2 Pitch X 42 Links 68 MBC5118ZA 1 Shaft 69 MBG6386 1 Pinion-11t X 3/8 Pitch 70 LCG1474B 1 Inner Clutch Plate * 002106424 1 Bush Oilite 22 X 27 X 25 72 LMSE122 1 Pinion & Sleeve, Reel Drive 73 MBC4641 1 Collar 74 4246273 1 Intermediate Chain-1/2 Pitch X 66 Links 75 MBG6878 1 Oil Tube 76 MBC9758 1 Stud 77 450194 1 Screw Hex M8-1.25 X 35 78 002993013 1 Lubricator M6 Straight Parts- 37

4246734_Group_Chain_Tensioner.eps Parts- 38

ITEM PART NO. QTY DESCRIPTION Notes/Serial Numbers 1 002900686 1 Spring 7/16 X 0.056 X 3 2 002920501 2 Spring Disc 8.2 X 16 X 0.9 3 009131925 1 Chain Tensioner 4 4246731 2 O Ring 14 Id X 2.5 5 4246732 1 Bolt Shoulder M8-1.25 X 44 6 4246733 1 Chain Tensioner 7 450377 1 Nut Hex M6-1.0 8 450378 3 Nut Hex M8-1.25 9 450390 4 Washer M8 X 17 X 1.8 10 450530 1 Screw Pan M5-0.8 X 25 4.8 11 452701 2 Screw Hex M8-1.25 X 16 12 MBC3171 1 Bush-steel 8.5 X 14 X 15 13 MBC5095 1 Plate 14 MBF1890 1 Cam Plate 15 MBG1887 1 Clamp 16 MBG5269 1 Spacer Block 17 MBG5429 1 Bracket Parts- 39

DECALS 000_619_decals.eps 10 11 12 13 14 10 Parts- 40

ITEM PART NO. QTY DESCRIPTION Notes/Serial Numbers 1 009034620 1 Decal-height Of Cut Marquis 61 Only 2 009034890 1 Decal-bystander Warning 3 009034900 1 Decal-belt 4 009034910 1 Decal-instruction 5 009034920 1 Decal-hot 6 009034940 1 Decal-cylinder Hazard 7 009034970 1 Decal-spark Plug 8 009114240 1 Decal-petrol Hazard 9 4124185 1 Decal-Ransomes Emblem 10 4311746 1 Decal, Ransomes Marquis 51 * 4311752 1 Decal, Jacobsen Marquis 51 11 4311747 1 Decal, Ransomes Marquis 61 * 4311753 1 Decal, Jacobsen Marquis 61 12 4311748 1 Decal, Ransomes Super Bowl 51 * 4311754 1 Decal, Jacobsen Super Bowl 51 13 4311749 1 Decal, Ransomes Super Certes 51 * 4311755 1 Decal, Jacobsen Super Certes 51 14 4311750 1 Decal, Ransomes Super Certes 61 * 4311756 1 Decal, Jacobsen Super Certes 61 15 4130883 1 Decal- OPC / Brakes 16 4131813 1 Decal-grass Box For 51 Cm Machines 17 4131814 1 Decal-grass Box For 61 Cm Machines 18 4142985 1 Decal-98db Noise Parts- 41

TRANSPORT WHEELS SUPER CERTES ONLY 2970009 transport wheels.eps Parts- 42

ITEM PART NO. QTY DESCRIPTION Notes/Serial Numbers 2 4228300 2 Wheel Complete 3 MBF0278A 2 Lever 4 9063060 2 Spring 5 MBF0277 8 Spacer-6.2 x 8.9 x 3.6 6 450719 6 Cap Screw M6 x 55 7 450171 2 Screw Hex M6 x 20 8 450377 6 Nut Hex M6 Nyloc 9 450389 7 Washer M6 x 12.5 x 1.8 10 MBG3688 1 Wheel Spacer 11 452000237 1 Washer 1/4 x 3/4 x 064 12 450172 1 Screw Hex M6 x 25 13 MBG6741 2 Wheel Lock Spacer 14 MBG6742 2 Wheel Spacer 80 MBG6026 1 Hub Spacer 81 MBG6021 1 Brake Hub RH 82 MBF0140 1 Spacer, Wheel Hub 83 MBG6017 1 Brake Hub LH 84 2300590 4 Sealing Ring 85 2075320 2 30 mm Roller Clutch 86 MBF0132 2 Clutch Sleeve 88 MBF0136 2 Washer Thrust 30 x 45 x 3 89 MBF0137 2 Land Wheel Collar 90 450393 1 Washer M16 x 30 x 3.3 91 450382 2 Nut Hex M16 Nyloc 92 MBC4664 1 Spacer-19 x 30 x 17 * 1190636 1 Screw M6 x 16 93 MBB2245A 1 Thrust Washer Parts- 43

PLAIN STEEL FRONT ROLL lmse152.eps Parts- 44

ITEM PART NO. QTY DESCRIPTION Notes/Serial Numbers LMSE152 1 Steel Front Roll 51cm 1 1799230 2 Circlip External 15 x 1 2 2036023 2 Bearing 15 x 35 x 11 3 2219120 2 Quad Ring 13.95 ID x 2.62 4 451965 2 Circlip Internal35 x 1.5 5 640001084 2 O Ring 2.109 ID x 139 6 MBE1471C 2 Roll End 7 MBG6504 1 Roll Tube-63.5 x 494.4 8 MBG6506 1 Shaft-51 Marquis Steel Roll LMSE153 1 Steel Front Roll 61cm 1 1799230 2 Circlip External 15 x 1 2 2036023 2 Bearing 15 x 35 x 11 3 2219120 2 Quad Ring 13.95 ID x 2.62 4 451965 2 Circlip Internal 35 x 1.5 5 640001084 2 O Ring 2.109 ID x.139 6 MBE1471C 2 Roll End 7 MBG6505 1 Roll Tube-63.5 x 596.4 8 MBG6507 1 Shaft-61 Marquis Steel Roll Parts- 45

GROOVED FRONT ROLL lmse149.eps Parts- 46

ITEM PART NO. QTY DESCRIPTION Notes/Serial Numbers LMSE149 1 Grooved Front Roll, 51cm Super Bowl/Certes 51 1 2036023 2 Bearing 15 x 35 x 11 2 2036031 2 Bearing 17 x 40 x 12 3 450959 2 Screw Set M6 x 8 4 451970 1 Circlip Internal 40 x 1.75 5 452040 2 Circlip External 15 x 1 6 452041 1 Circlip External 16 x 1 7 MBF1294 2 End Cap-Front Roll 8 MBG6454 1 Roll Tube-51cm Grooved 9 MBG6463 2 Shaft-Front Roll 10 MBG6474 1 Spacer-29 x 35 x 5 LMSE150 1 Grooved Front Roll, 61cm Super Certes 61 1 2036023 2 Bearing 15 x 35 x 11 2 2036031 2 Bearing 17 x 40 x 12 3 450959 2 Screw-Set M6 x 8 4 451970 1 Circlip Internal 40 x 1.75 5 452040 2 Circlip External 15 x 1 6 452041 1 Circlip External 16 x 1 7 MBF1294 2 End Cap-Front Roll 8 MBG6455 1 Roll Tube-61cm Grooved 9 MBG6463 2 Shaft-Front Roll 10 MBG6474 1 Spacer-29 x 35 x 5 Parts- 47

VERTI-GROOM KIT Vertigroom.eps Parts- 48

ITEM PART NO. QTY DESCRIPTION Notes/Serial Numbers LMAA937A Verti-Groom Kit 51cm LMAA937B Verti-Groom Kit 61cm 7 MBC9568 1 Bearing Housing 8 2039291 1 Bearing 17 x 35 x 10 9 MBC9569 1 Pivot Bolt 14 MBE1137 1 Screw 15 MBC9527 1 Drive Belt Housing 16 2039291 1 Bearing 17 x 35 x 10 17 2925022 1 Tolerance Ring 18 MBE1120 1 Drive Disc 19 2039267 1 Bearing 15 x 32 x 9 20 9175109 1 Pulley 22 MBC9262A 1 Clutch Hand Wheel 23 MBE0992 3 Dowel Pin 24 459000014 2 Steel Balls 25 2911059 1 Spring, 3.83 O/D x 7.8 Lg 26 MBC9297 1 Washer 8.5 x 26.5 x 1.6 27 2952586 1 Cover Plug 28 2993013 2 Lubricator-M6 Straight 29 2039275 2 Bearing 12 x 28 x 8 30 2960066 1 Spacer 31 2925006 1 Tolerance Ring 32 9133105 1 Wheel 33 MBE0456 1 Stop 34 2911114 1 Spring Comp 3.83 x 0.63 x 5.5 41 9202869 31 Groomer Blade 51cm 41 9202869 38 Groomer Blade 61cm 42 MBC9552 29 Spacer 51cm 42 MBC9552 36 Spacer 61cm 43 MBC9611A 1 Shaft 51cm 43 MBC9530 1 Shaft 61cm 45 MBC9346A 1 Collar 46 9042655 3 Spacer 52 2289185 1 Nilos Ring 53 MBE3474 1 Pulley 54 4921120 1 Drive Belt 61 MBC9627 1 Collar 62 MBC9695 1 Tensioner 63 824100472 1 Bearing 10 x 26 x 8 69 MBC9528 1 Lid 70 2953273 1 Grommet 71 9034646 1 Label 77 MBC9577 1 Groomer Link 78 MBE1484 1 Pivot Pin 79 2993013 2 Lubricator-M6 Straight 80 2039275 1 Bearing 12 x 28 x 8 81 9133105 1 Wheel 82 MBC9544 1 Plug 83 MBE0455 1 Locking Pin 84 2922935 3 Spring Disc 17.3 x 27.7 x 0.4 89 MBC9555 1 Groomer Bracket RH Parts- 49

VERTI-GROOM KIT Vertigroom.eps Parts- 50

ITEM PART NO. QTY DESCRIPTION Notes/Serial Numbers 90 MBC9556 1 Groomer Bracket LH 96 1949047 2 Clevis, M8 98 MBC9613A 2 Stud Adapter 99 2990293 2 Plastic Star Knob-M8 x 40 * LMSE149 1 Grooved Roller (51cm) * LMSE150 1 Grooved Roller (61cm) 1100 450172 1 Screw Hex M6 x 25 1148 450541 4 Screw Pan M6 x 16 1150 450543 3 Screw Pan M6 x 25 1230 450950 1 Screw-Set M5 x 6 1305 450324 2 Nut Hex M8 1310 450327 1 Nut Hex M16 1315 450377 5 Nut Hex M6 Nyloc 1320 450378 2 Nut Hex M8 Nyloc 1325 450382 1 Nut Hex M16 Nyloc 1490 1490666 2 Spring Clip 1504 450389 9 Washer M6 x 12.5 x 1.8 1505 450389 0 Washer M6 x 12.5 x 1.8 1507 450390 3 Washer M8 x 17 x 1.8 1520 450411 1 Lock Washer M8 x 12.75 x 2 1610 452145 1 Key-4 x 4 x 12 1750 452050 2 Circlip External 25 x 1.2 Parts- 51

TOW BAR MARQUIS 61cm ONLY Tow-Bar.eps Parts- 52

ITEM PART NO. QTY DESCRIPTION Notes/Serial Numbers 1 MBF2274 1 Tow Bar Bracket-Marquis 61 2 450191 4 Screw Hex M8 x 20 3 450411 4 Lock Washer M8 x 12.75 x 2 4 450324 2 Nut Hex M8 5 MBC8043 1 Ball Joint 6 450412 1 Lock Washer M10 x 15.9 x 2.5 7 450020087 1 Nut Hex 3/8-24 8 450390 6 Washer M8 x 17 x 1.8 Parts- 53

TRAILING SEAT MARQUIS 61cm ONLY LMAA628.eps Parts- 54

ITEM PART NO. QTY DESCRIPTION Notes/Serial Numbers 1 MBC5881C 1 Seat Frame 2 699524927 1 Seat 3 MBA5360 2 Land Roll 4 MBA5364 1 Spindle 5 452200087 4 Lock Washer 3/8 x.590 x.092 6 456110066 4 Screw Hex 3/8-16 x 1 7 456010789 2 Screw Hex 1/2-20 x 7/8 8 452200168 2 Lock Washer 1/2 x 763 x 116 9 452100823 3 Washer 15/16 x 1-3/4 x.104 10 590002752 4 Bush Oilite 7/8 x 1-1/8 x 1-1/2 11 MBC5869 1 Pin Fabrication 12 450391 1 Washer M10 x 21 x 2.2 13 450379 1 Nut Hex M10 Nyloc 14 452000326 4 Washer 3/8 x 3/4 x.072 15 MBG5007 1 Name Plate 16 001496052 2 Rivet-Pop 1/8 x 5/16 17 451144 4 Screw Pan # 10 x 13 18 MBC5887A 1 Guard 19 MBC7776 1 Anti-Slip Strip 20 MBC7777 1 Anti-Slip Strip Parts- 55

Europe & Rest of The World Except North & South America Ransomes Jacobsen Limited West Road, Ransomes Europark, Ipswich, IP3 9TT English Company Registration No. 1070731 www.ransomesjacobsen.com North & South America Jacobsen, A Textron Company 11108 Quality Drive, Charlotte, NC 28273, USA www.jacobsen.com