Parts Manual CVT Lawn Tractor SERIES 000 Model LT00 PRINTED IN U.S.A. CUB CADET LLC, P.O. BOX CLEVELAND, OHIO -00 FORM -00C.fm (//00)
SERIES 000 CVT LAWN TRACTORS TABLE OF CONTENTS DESCRIPTION PAGE Axle, Front... Battery... 0 Brake Pedal... Deck, -inch... 0 Dash Panel... Drive System... Electrical Schematic... 0 Engine Air Intake/Filtration... Blower Housing... Crankcase... Cylinder Head... Engine Controls... Fuel System... Ignition / Electrical... Oil Pan / Lubrication... Starting System... DESCRIPTION PAGE Engine Accessories... Fender... Frame... 0 Fuel Tank... Head Lamp... Hood... Lift Linkage... Muffler... PTO... Seat... Steering... Transmission... Wheels, Front & Rear... NOTE, For painted parts, please refer to the list of color codes below. Please add the applicable color code, wherever needed, to the part number to order a replacement part. For instance, if a part, numbered 00-xxxx, is painted Cub Yellow, the part number to order would be 00-xxxx-0. Cub Yellow: 0 Cub Beige: 0 Powder Black: 0
WHEELS - Tire, Turf, 0 x 0 x -0A Rim Assembly,.0 x. (-Lug) -00 Lug Nut, /- - Tire, Turf, x x -00 Rim Assembly, x. (Includes Flange Bearings and Valve) -0 Hub Cap -0 Valve, Tubeless Air
B B A A C D E G G F F E D C Left Hand Transmission Bolt Mounting 0 0 0 0 0 0 0 0 0 0 0 DRIVE SYSTEM
DRIVE SYSTEM DESCRIPTION 0 Mounting Bracket, Transaxle -00 Switch, Interlock Plate, Switch -000 Lever Assembly, Shift 0-00 Screw, /-, 0.00 0-0 Screw, /-, 0.0 0-00 Screw, /-0,.0 0-00 Screw, Sems, /-,.00 0- Screw, /-,.0, Gr 0 0- Screw, /-,.00, Gr -0 Adjustment Ferrule /-0 x. -0 Nut, Hex, /-, Gr -00 Nut, Flange Lock, /-, GrF, Nylon -00 Nut, Flange Lock, /-, GrF, Nylon -000 Nut, Flange, /-, Gr -00 Pin, Cotter,.0 Dia. x. -0 Pin, Cotter, /,.0-00 Cotter Pin, Internal,. Dia. -00 Pin, Cotter, / x. 0-0A Pulley Hub, / Spline 0-00 Knob, Shift -0 Ball Joint -0 Sleeve,. x. x. -00 Sleeve,. x. x. -00A Spring, Extension,. Dia x. -0 Spring Clip, Shifter -0C Spring, Extension,. OD x.00-0 Spring, Extension,.0 Dia x. -0 Washer, Lock, / 0 0-0 Screw, #0-,.0-0B Spacer, Shoulder,.00 x. x. -0C Rod, Shift -0 Rod, Brake - Idler Rod, Adjustable, / -0 Spacer,. 0-0A Spacer,.0 x. x.00-0 Belt, V-Type -0 Belt, V-Type -000 Pulley, V-Type,. Dia. 0-0B Idler Pulley, Flat. OD -0 Bracket, Shift -00 Bracket, Shift, F-N-R -0 Idler Bracket, Center Double -000 Control Assembly, Brake -00A Control Assembly, Speed -0 Pedal Assembly DESCRIPTION 0-0 Screw, M x. x 0 mm 0-0A Screw,/-, 0.0 0-B Screw, /-, 0.0 0-0B Pin, /- x. -00A Nut, Flange Lock, /-, Gr -0 Spring, Compression,.0 x. -0 Spring, Extension,.0 OD x. -0 Spring, Extension,.0 OD x. -0 Pad -0 Pad, Brake -0 Washer, Flat,. x. x.0-0 Washer, Flat,. x.0 x.0-000 Washer, Flat,.0 x. x.0 0-0 Washer, Lock, / -0 Screw, Shoulder. Dia x. -00 Screw, Shoulder,.0 x. Lg, /- -0 Bearing, Hex Flange -0B Split Bearing, Hex Flange -00A Rod, Brake Lock -00 Rod, Cruise Control -00C Latch, Cruise Control -0 Bracket, Lockout -0 Pedal, Brake 0-00B Bracket, Neutral Return -00 Transmission, Single Speed -0 Bracket Assembly, Torque -0 Bracket, Idler 0-0 Screw, #- x.0-0 Hub Assembly, Wheel 0-00A Screw, /-,. 0-0 Screw, /-,. -0A Screw, Shoulder,. x. - Switch Spring, Short 0-00 Plate, Insulator 0-0 Spacer, Shoulder -0A Pulley, V-Type,.0-00 Pulley Assembly, Variable Speed -0 Bracket, Pulley 0-0 Screw, /-,.0 0-0 Screw, /-0,.0-0 Cup, Bearing -0 Washer, Flat -0 Ball Bearing 0-00 Washer, Flat,.0 x. x -0 Washer, Bell,.0 x. x.00-0 Washer, Flat,.0 x.0 x.0
CONTINUOUSLY VARIABLE TRANSMISSION 0 0
CONTINUOUSLY VARIABLE TRANSMISSION -0 Ring, Wire -0 Ring, E Type,.0-0 Flat Washer, / x.0 x.00* * -0 Flat Washer, / x.0 x.00* * -0 Flat Washer, / x.0 x.00* * -0 Washer, Thrust. x. x.0 0- Self-tapping Screw, /-0 x. -0 Upper Housing -0 Input Shaft -0 Needle Bearing,. x. x. - -tooth Bevel Pinion 0-00 Retaining Ring,. -00 Sleeve Bearing,. x..0 x.0-0 Seal,. x.0 x. -00A Differential Assembly -0 Flange Bearing, / x / x / -00 -tooth Bevel Gear -000 Brake Assembly -00 Clutch Collar -0 Flat Washer,.0 x. x.0-0 Drive Shaft 0-0 Thrust Washer,.0 x. x.0-0 Flange Bearing, / x / x / -00 Detent Shaft Assembly -0 Detent Ball -0 Compression Spring -00 Lower Housing -0 Brake Puck -00 Brake Disc 0-0 Self-tapping Screw, /-0 x. -0 Grease oz *Use applicable flat washer (a, b or c) in this application allowing.000/.00 in. end-play NOTE: If rebuilding the upper housing, include two ounces ( oz.) of Unirex N grease (Part No. -0) in the input shaft cavity.
STEERING 0 0
STEERING 0-0 Hex Cap Screw, /-,.00, Gr, Std -0 Link, Drag, RH -0A Link, Drag, LH 0-0 Self-tapping Screw, /- x. -00 Nut, Jam, /-0, Gr -0 Nut, Hex, /-, Gr -00 Nut, Nylon Lock, /- -0 Nut, Flange Lock, /-0-00A Nut, Flange Lock, /- 0-0E Gear, Steering, /0 Ratio - Gear, Pinion, Steering -0A Ball Joint, /-0 0-00 Hex Cap Screw, /-,.00-00 Washer, Flat,.0 x. x.0-0 Washer, Flat,.0 x.0 x.00-0a Cover, Steering Wheel -0 Spacer, Shoulder,.00 x. x. -00 Shaft, Steering,. OD x.00 Lg -0 Bushing, Plastic,.0 ID 0-0A Bearing, Hex Flange, / -000 Axle Ass y, LH.0 Dia -000 Axle Ass y, RH.0 Dia -0 Push Cap,. -00 Pin, Cotter, /,. -00 Axle, Pivot, Cast.0 Dia -0 Washer, Flat, Special. x. -0A Screw, Shoulder,.00 x.0, /- -000A Wheel, Steering, Three Spoke
FRAME 0 0 0 0
FRAME Plate, Switch -0B Frame Assembly, Lower -0 Bumper Assembly 0-0 Screw, Hex Washer, 0- x. 0-00A Screw, Self-tapping, /-, 0. 0-0A Screw, Self-tapping, /-, 0. 0- Screw, Hex Washer, /-0 x 0. -0 Pin, Clevis,.0 Dia x. Lg -00 Nut, Nylon Lock, /- 0 0-00 Screw, Hex Wash. Tapp, /- x. -00 Pin, Internal Cotter -00 Switch, Interlock -00 Spring, Compression,. OD x. -0 Washer, Lock, Ext / -00 Shoulder Spacer -0 Shoulder Screw, /- 0-00 Hex Screw /- x. -0E Bracket, Pivot, Support RH 0-0D Bracket, Pivot, Support LH -0B Bracket, Pivot, Bar -00D Frame, Upper -0 Bracket, Frame, Seat -00 Nut, Nylon Lock, /-0 0-0 Screw, Self-tapping, /-0, 0.00 -A Solenoid, V, 00 Amp -0 Washer, External Lock, / 0-0 Screw, Hex. /-0 x. -A Battery, 0 CCA 0-0 Nut, Sems, /-0 0-00 Screw, Carriage, /-0,., -0A Hold-down Rod, Battery -0 Tray, Battery
FENDER 0 0-0 Screw, /- x. 0-00A Screw, /-, 0. 0-0 Screw, /-, 0.0-00 Nut, Nylon Lock, /- -0 Cover, Lift Lever -0C Cover, Cup Holder -0 Washer, Flat,. x.00 x.0-0b Bracket, Lift, Adjustment -C Bracket, Seat, Mount 0-0A Fender -0 Clip, Ratchet,.0 Dia -0A Pad, Foot, LH -0B Pad, Foot, RH -00 Grommet 0-0 Flange Spacer,. x. x. 0-0 Screw, Self-tapping, /-0, 0.00-00 Washer, Lock, / External Tooth
LIFT ASSEMBLY 0 0 0 0-0 Shaft Assembly, Lift - Pulley, Roller -00 Shoulder Screw, /- -00 Nut, Nylon Lock, /- -00 Nut, Nylon Lock, /-, Gr -0 Nut, Hex Lock, /-, Gr, Nylon -00 Pin, Cotter,.0 Dia. x. Lg -0 Pin, Cotter, /,.0-00 Pin, Click,.0 x. Lg 0-00A E-ring,. Dia. Shaft 0-0 Grip, Handle -0 Spring, Torsion -00 Pivot Cup -0 Hanger Bracket, Deck -0A Rod, Deck,." Dia. -0 LH Arm, Lift -0 RH Arm, Lift -0A Screw, Hex Cap, /-x.0 Gr -0 Shoulder Screw, /- 0-0 Bearing, Hex Flange -0 Cable, Lift,. Lg -0 Handle, Lift -00 Nut, Hex, /-
ADJUSTABLE SEAT 0 0-0A Lever, Seat, Adjustment 0- Screw, #0-, 0. -00 Nut, Nylon Lock, /-, Gr -00 Nut, Nylon Lock, /-0 GrF 0-0 Grip, Seat, Adjustment (Yellow) -00 Nut, Speed,. ID -00 Spacer, Seat, Adjustment -0 Spring, Compression. x.0 - Spring, Extension,.0 Dia x. 0-0D Bracket, Seat Pivot -00 Seat, Cub Cadet, Medium Back -0 Selector, Seat, Adjustment -00 Washer, Flat,. x..0 x.0-0 Washer, Flat,. x.0 x. -0A Screw, Shlder,.0 x., /-0-0 Shoulder, Screw. x. Lg -0A Screw, Shoulder,.0 x., /- -00D LH Bracket, Seat Lift -0 Stop, Seat, Adjustment 0 0-0 Screw, #- x.0-0 Plate, Insulator -0 Spring Switch, Outer - Spring Switch, Inner -0 Plate, Insulator Boss
ENGINE ACCESSORIES 0 0 0-0 Screw, #-, 0.00 0-0 Screw, Hex, /-0, 0.00 0-0 Screw, Hex, /- x. 0-0A Screw, Hex, /- x.00-0a Muffler, Single Inlet -0 Cable, Tie, / x.0 x. 0-A Screw, /-, 0. -0 Extension, Deflector 0-0 Screw, Hex, /-0, 0.0 0-0A Deflector, Muffler -0 Muffler Bracket, LH -0 Muffler Bracket, RH -00 Pipe, Exhaust -0 Drain, Oil - Extension Hose, Oil Drain -00 Heat Shield, Lower -0 Shield, Muffler -0000 Rivet, Pop,. x. -00 Fuel Clamp 0-0 Fuel Line, Low Permeation -0 Clamp, /
DASH PANEL 0 0 0
DASH PANEL 0-0 Screw, #0- x.0 0-0 Screw, #0- x. 0-0 Screw, Self-tapping, /-0, 0. 0-0 Screw, Hex. /-0 x. 0-00 Screw, Hex, /-,.0-0 Switch, PTO 0-0 Screw, Hex, /- x. 0-0 Screw, /-, 0.0 0-B Screw, Torx Hd., /- x. 0 0- Screw, Machine, #-, 0., -0 Nut, #- -0B Switch Module, Ignition -0E Fuel Tank, Gal -0 Control, Throttle,. -00 Internal Cotter Pin,.0 x. -00 Cap, Fuel -000 Dash -0A Lever, Dash, Cruise -0A Lever, Dash, Brake 0 -A Knob, Throttle Control -0E Dash Support, RH -0 Ignition Key, Plastic - Ignition Key, Metal -0D Dash Support, LH -0 Control, Choke,.0 -A Rod,.0 Dia x. Lg. -000 Bracket, Steering Support - Bracket, Dash Rod -0 Steering Colume Bearing 0-00B Monitor, Systems Indicator / Hour -00 Wire Harness
HOOD & GRILLE 0-0A Hood -0A Hood Plenum 0-0 Self-tapping Screw, /- x. 0-0 Screw, /- x. -0 Cable Tie -00 Pivot Bracket, Hood, RH -0 Pivot Bracket, Hood, LH -00 Shoulder Screw,. x. x /- -00B Pivot Bracket 0-0 Miniature Lamp, V - Lamp Socket -0 Headlight Lens X Headlight Lens Reflector, RH X Headlight Lens Reflector, LH -00A Headlight Harness
POWER TAKE-OFF (PTO) SYSTEM 0 0-0 Screw, /- x. GR -0B Spacer, / x. 0-0A Screw, /-,. 0-A Screw, Hex Cap, /-0 x. GR -0 Clutch, PTO -0 Cable Tie -00 Nut, Hex. Nylon Lock, /- -0 Washer, Lock, /, Regular Duty -00 Rod, Belt Keeper 0-0 Washer, Flat,.0 x. x.0
0 -INCH MOWER DECK 0 0 0 0 A 0 0 A B B 0 0
-INCH MOWER DECK -0 Spindle Assembly -0 Deck Weldment, inch -0B Bracket, Deck Hanger LH 0-0 Screw, Hex Cap, /-0,.0, Gr 0-0A Screw, Self-tapping, /- x.0 0-0 Screw, Self-tapping, /- x. 0-0 Screw, Self-tapping, /- x. 0-0 Screw, Self-tapping, /-0 x.0-0 Screw, Shoulder,. x., /- 0-0 Washer, Flat,.0 x. x. -00 Nut, Hex, /-0, Gr -0 Washer, Flat,. x. x.0-00 Nut, Hx. Nylon Lock, /-0-00 Nut, Hx. Nylon Lock, /- -0 Nut, Hex, M-. -0B Chute Assembly, Side Discharge 0-0 Carriage Screw, /-0,. -00 Pin, Cotter, / x. -00 Adjustment Gear, Deck 0-00 Coupler, Hose -0 Nut, Push,. ID x.0 OD -00A Spring, Extension,. x. -0 Spring, Extension. x. -0 Wheel Deck.0 x. -0 Wheel Deck.0-0 Washer, Lock, /, Regular Duty -00 Washer, Belleville,. x. x.0-000 Washer, Flat,.0 x. x.0-0 Washer, Lock, Internal Tooth 0 0-0A Spacer,.0 x. x.00-000c Port, Water 0-00 Screw, Hex Cap, /-0,.0-0A Spacer, Shoulder,.0 x.0-0 Blade,.0 Lg, -in- - Rod, Handle, Deck Release. -0 Wing Nut, /-0 - Baffle, Mulch -00 Belt, V-Type -0 Pulley, Idler,. Dia. 0 -A Skirt, Deck -0B Cover, Belt -0D Idler Bracket, Pivot -0 Shaft, Spindle,. 0- Screw, /-,.0-0 Screw, Shoulder,. x.0, /- -000 Lube Fitting, / -0A Nut, Flange, /- 0-000 Spacer,. - Pulley,. Dia. 0-0 Ball Bearing,. x. x. -0 Spacer,.0 x. x.0-00 Support Bracket, Pivot 0-0 Screw, /-,. -00 Keeper Rod, Belt 0-00 Screw, /-,. 0-0A Spacer,. x. x. -0 Idler Bracket, Cast 0-0 Screw, Self-tapping, /-0 x.0-0a Bumper, Rubber 0-0 Nut, Flange Lock, /-0 0-0 Screw, Self-tapping, /- x. -0 Screw, Shoulder,. x. -0C Spring, Extension. x.
ENGINE CRANKCASE 0 0 0
ENGINE CRANKCASE Crankcase (Use: Short Block 0 0) -S Plug, sq. hd. pipe /" 0 0 0-S Seal, oil 0 0 0-S Rod, connecting 0 0-S Piston w/ Ring Set (Includes,) 0 0 0-S Ring Set ( mm) 0 0 0-S Retainer, piston pin 0 0-S Tube, drainback 0 0-S Kit, balance weight (Includes 0,) 0 0 0 -S Kit, screw/guide pin 0 0-S Shoe, guide 0-S Clip, hitch pin M-0-S Washer, plain X--0-S Washer, plain 0 0-S Shaft, governor cross 0 0-S Pump assembly, oil (Includes -) 0 0-S Spacer, oil pump screw 0 0 -S Screw, oil pump 0 0-S Shaft center, cam Exhaust 0 0 0-S Washer, thrust 0 00 0-S Lever assembly, cam () (Includes ) 0 0 0-S Screw, shoulder 0 00 0-S Gear assembly, cam Exhaust (Includes -) 0 0 0-S Spring, ACR 0 0 -S Weight, ACR 0 0-S Washer, thrust ACR 0 00 0-S Gear assembly, cam Intake 0 0 0-S Crankshaft (Includes ) X---S Key /" 0 0 0 -S Gear, crankshaft NOTE: Include a KH- prefix when ordering replacement engine parts (i.e. KH- -S).
ENGINE AIR INTAKE / FILTRATION 0 0 0-S Cover, air cleaner 0-S Knob, cover 0 0 0-S Element, precleaner 0 0 0-S Element, air cleaner 0 0 0-S Kit, air cleaner base (Includes ) 0 0-S Gasket, air cleaner base NOTE: Include a KH- prefix when ordering replacement engine parts (i.e. KH- -S).
ENGINE CYLINDER HEAD 0 0 0 0 0 0-S Kit, valve cover (Includes ) 0 0 0-S Gasket, valve cover M-00-S Screw, hex. flange Mx.0x0 0 0-S Hose, breather 0 0 0-S Screw, set 0 0-S Pivot, rocker arm 0 0-S Arm, rocker 0 0 0-S Stud, rocker 0 0-S Plate, push rod guide 0 0 0 0-S Lock, retainer 0 0-S Cap, valve spring 0 0 0-S Spring, valve 0 0 0-S Screw, hex. flange M0x.x 0-S Washer, flat /" 0 0-S Head, cylinder 0 0 0-S Valve, exhaust 0 0 0-S Valve, intake 0 0-S Kit, head gasket (Includes,, 0 0-S, 0 0-S & 0 0 0-S) 0 0-S Rod, push 0 0 0-S Stud, exhaust 0 0 -S Gasket M-00-S Nut, hex flange Mx. NOTE: Include a KH- prefix when ordering replacement engine parts (i.e. KH- -S).
ENGINE ENGINE CONTROLS 0 0 0-S Control assembly, speed (Includes 0-S Clamp, cable M-0-S Screw, hex flange thread forming M-00-S Screw, lobed socket thread forming 0 0 0-S Linkage, choke single wire 0 -S Spring, speed control 0 0 0-S Screw, thread forming Mx0.x 0 00 0-S Lever, governor 0-S Bolt, round head square neck /-0x" 0 X---S Washer, internal tooth lock /" 00 0-S Nut, hex. flange /-0" 0 0 -S Spring, governor 0 0 0-S Spring, linkage -S Bushing, throttle linkage 0 0 0-S Linkage, throttle 0-S Bushing, linkage retaining NOTE: Include a KH- prefix when ordering replacement engine parts (i.e. KH- -S).
ENGINE FUEL SYSTEM 0 0 0 0-S Gasket, heat deflector 0 0-S Deflector, heat M-00-S Screw, hex. flange Mx.0x0 0 -S Carburetor w/gaskets (Includes,) 0 0-S Gasket, carburetor 0 0-S Gasket, air cleaner 0 0 0-S Stud, carburetor mounting M-00-S Nut, hex. flange Mx.0 0 0-S Bracket, fuel pump mounting 0 -S Pump, fuel M-00-S Screw, hex. flange -S Clamp, hose 00 -S Filter, fuel 0 0-S Line, fuel -/" (pump to filter) -S Line, fuel " (pump to carb) 0-S Line, fuel 0" (pump to fitting) NOT ILLUSTRATED 0 0-S Sleeve, fuel line X---S Washer, lock /" (ground) 0-S Kit, choke shaft 0-S Kit, float 0-S Kit, carburetor repair -S Kit, solenoid repair -S Kit, bowl replacement w/gaskets 0-S Tie, wire NOTE: Include a KH- prefix when ordering replacement engine parts (i.e. KH- -S).
ENGINE IGNITION / ELECTRICAL & BLOWER HOUSING 0 0 NOT ILLUSTRATED 0 0-S Clamp, wire (clamps harness to blower housing) 0 0-S Harness, wiring 0 0-S Screen, grass 0 -S Screw, hex. flange M0 x. x 0-S Washer, flat 0 0-S Plate, fan mounting 0 0-S Fan X---S Key, woodruff 0 0 0-S Flywheel 0 0 -S Screw, hex. socket M x 0. x 0 0-S Clip, wire 0 -S Kit, stator 0-S Connector, body ( contact) M-00-S Screw, hex. flange M x 0. x 0 0 0-S Rectifier-regulator 0-S Plug, spark -S Clip, cable 0 0-S Module, ignition M-0-S Screw, hex. socket M x 0. x 0 0 0-S Starter assembly, inertia drive 00 -S Nut, hex. serrated flange #0-0 00 0-S Nut, hex. flange /-0 0 0 0-S Housing, blower 0 0 0-S Screw, shoulder M x 0. x NOTE: Include a KH- prefix when ordering replacement engine parts (i.e. KH- -S).
ENGINE OIL PAN / LUBRICATION 0 0 00 0-S Kit, dipstick assembly (Includes ) 0 0-S O-Ring, dipstick 0 00 0-S Plate assembly, closure (Includes,0,) 0-S Plug, pipe 00 0-S Filter, oil 0 0 0-S Gasket, closure plate 0 0 0-S Kit, oil passage cover (Includes ) 0 0 0-S Gasket, oil passage 0 0-S Shaft, governor gear 0 0 0 0-S Kit, gear and weight assembly (Includes ) 0 0-S Pin, governor regulating M-0-S Screw, hex. flange Mx0.x M-00-S Screw, hex. flange Mx.x0 0 0 0-S Seal, oil 0 -S Switch, pressure 0 -S Elbow, street -S Clip, cable 0-S Connector, 0 NOTE: Include a KH- prefix when ordering replacement engine parts (i.e. KH- -S).
ELECTRICAL SCHEMATIC 0
NOTES
CUB CADET LLC, P.O. BOX CLEVELAND, OHIO -00