Bert Transmission Fluid Performance Test Bert Blue Magic vs. Competition Aeromotive Research and Development Group / SynMax University Presentation for: Bert Blue Magic Products www.bertbluemagic.com
Product Evaluation Test was performed on a standard Bert 2 speed Transmission 2009 Race Season 35 40 Competition Races Transmission (A) Bert Blue Magic 2 Speed Fluid Transmission (B) National Brand: Royal Purple ATF
Left - Bert Blue Magic Center - New Bert Clutches Right Royal Purple ATF Observation: Bert Blue Magic OEM Fluid Clutch & Pressure Plate Surfaces slight wear close to new could be re-used Royal Purple ATF Clutch & Pressure Plate Surfaces very worn, dark & burned due to slippage, friction, fretting, heat & lack of fluid grip lubrication Clutches need replacement
Left - Bert Blue Magic Center - New Bert Clutches Right Royal Purple ATF Observation: Bert Blue Magic OEM Fluid Clutches showed little amount of paint worn from the OEM Bert Transmission original Sonnax Clutches ( this is from premium clutch fluid bite & protection) Pressure Plate Surfaces slight to little wear close to new All components could be re-used
REASON FOR PERFORMANCE SUCCESS Observation: It was further discovered that Bert Blue Magic OEM Fluid chemical engineering ACTUALLY SOAKS INTO THE CLUTCHES This allows the clutches to continually create a natural high performance BITE within a hydrodynamic barrier WITHOUT TEARING, BURNING OR DISTROYING CLUTCH SURFACE MATERIAL OR PRESSURE PLATES
Center (Left) - New Bert Clutches Right Royal Purple ATF Observation: Royal Purple ATF Clutch & Surfaces very worn, dark & burned ( due to fluid slippage and low grip which causes clutches to break and burn causing particles to float within trans) Pressure Plate burned due to slippage, friction, fretting, heat & lack of lubrication fluid grip NEED REPLACEMENT
Bert Transmission 2 Speed Fluid Test Conclusion: Test results & evidence over one year of racing (as shown within the attached pictures) it is clear the Bert Blue Magic fluid product (specifically designed for the Bert 2 Speed Transmission) was successful, performed well & exceeded all factory expectations. Bert Blue Magic OEM Fluid held up & did not break down under high performance ( 9,000 RPM) & extreme duty (850 HP to 900 HP+) conditions - extending service cycles of the Bert Transmission, Clutches & Pressure Plates. Discovery was that Bert Blue Magic Special Designed 2 Speed Fluid had premium performance for stay-ability to GRIP / BITE upon the clutch / pressure plate areas without slipping (which happens with Standard / Commercial Automatic Transmission Fluids ).
Bert Transmission 2 Speed Fluid Test Conclusion: Clutch & Pressure Plate surfaces DID NOT experience fatigue or fretting (small pieces of surface breaking off creating pits due to heat & friction ) as compared to other product used. Bert Blue Magic Fluid with Poly-X Viscosity formulation provided consistent clutch engagement & shifting stability. Bert Blue Magic Fluid anti wear formulation kept the gears, slide areas and rear needle bearings cool, lubricated & protected. Bert Blue Magic Fluid - Clutch & Pressure Plate surface area inspections indicated wear pattern & specifications were within 80% of original factory tolerances, acceptable & safe for reuse. NOTE: testing was not against any company or product used. It just happened that the performance ATF used by Transmission (B) was the Royal Purple MAX ATF.
Bert Blue Magic Products are Performance Tested and OEM Approved by Bert himself
Bert Blue Magic Grease is personally approved by Bert..
Bert Transmission Fluid Performance Test PRESENTATION - END Aeromotive Research and Development Group / SynMax University Presentation for: Bert Blue Magic Products www.bertbluemagic.com
For Technical, Test and Brochure information on how The Aerospace Advantage for Motorsports can work for your race team or commercial needs go to:. www.synmaxperformancelubricants.com