Piston -1 HYPERDRYVE PISTONS

Piston -1 HYPERDRYVE PISTONS

Piston -2 SPI Pistons SPI Pistons are a high quality OEM replacement piston. Manufactured to OEM specifications, and made from the highest quality materials with all parts interchanging with original components. Piston kits include: piston, rings, wrist pin and circlips. "Moly" piston surface treatment The aluminum piston's surface is treated with a special coating that include flourine which increases surface hardness, reduces friction, and contributes to improved power output and durability. Piston and Ring Installation Guide for Snowmobile Note: This guide is for experienced mechanics and not complete for installing pistons. Trans Can Imports assumes no liability for any damage that may occur through following these instructions. Preparation - If the old piston has failed, determine the cause and remedy the problem before replacing the piston. Seizing on the exhaust side is caused by a too lean mixture ro air leak. A "four corner" style seizure is caused from insufficient warm-up or clearance. A hole in the piston is caused from detonation, a result of advanced timing or poor fuel quality. A broken piston skirt is caused from excess piston to cylinder clearance. To remove a piston, use a piston pin puller and heat piston if necessary. DO NOT HIT PIN WITH A HAMMER! Measure the cylinder for clearances and out of roundness, service limit is.003" out of round up to 65 mm/.004" out of round over 66 mm larger size. Cast iron cylinders - finish cylinders with a 220 or 300 grit stone. Nikasil or electrofusion clinders - if necessary can use a 500 grit hone to clean cylinder To prevent ring breakage, make sure all port edges are chamfered @ 30 angles with a radius of 0.9 to 1.4 mm. Tips If the cylinder is in good condition but has aluminum build-up from a seizure, muriatic acid can be used to soften and clean off aluminum during the cylinder preparation. Chrome plated rings can be used in cast or nikasil or electrofusion bore but CANNOT be used in chrome bore. Chrome was used in pre-1980's and early 1980 productions but seldom used after that. Always check that the ring end gap will not be in align with a port. By putting a mark on the top of the piston where the ring locating pin(s) are is a quick and easy way to check. Installation - Check piston to cylinder clearance before assembly. Typical clearance range for snowmobiles is as follows but always refer to manufacturers specifications: Bore Air Cooled Liquid Cooled 50-65 mm.003 -.004".004 -.005" 66-70 mm.0035 -.0045".005 -.006" 70 and up.005 -.006".0055 -.0065" Check ring end gap, single ring piston's range is from 0.010-0.025", while two ring piston's range is from 0.010 to 0.035". Install pistons with arrow facing exhaust or on some Polaris applications, the arrow will face the magneto side of the engine. If wrist pin has a tight interference - heat the piston + oil the pin for ease of assembly Put a rag under the piston and install the circlips without bending or distorting them. Be careful they are tight in the circlip groove. Remove rag and make sure gaskets's are clean, oil the cylinder and install. Most engine builders like to position pin circlips at 12:00 o'clock or 6"00 o'clock positions. Break-in Procedure For the 1st tank of fuel on oil injected machines use a 50:1 fuel to 2-stroke oil mixture On pre-mix applications use 20:1 fuel to 2-stroke oil mixture for the first tank Avoid prolonged high RPM operations for the first 5 hours of engine time. Piston oversize Cross-Reference Inches mm Inches mm 0.010" 0.25 mm 0.020" 0.50 mm 0.030" 0.75 mm 0.040" 1.00 mm 0.060" 1.50 mm 0.080" 2.00 mm

Piston -3 TRANS CAN IMPORTS Arctic Cat (Kawasaki) 340 El Tigre 340 F/A 73-76 09-606 Std 60 566-0525 16x20x21.7 340 Cheetah 340 72-75 09-685 std 60 60 562-6850 564-6850 564-9160 566-0525 16x20x21.7 EXT 340A, 340A Special 1971 09-685-01 0.010 562-6851 Jag 340 FA 1975 09-685-02 0.020 562-6852 Lynx II 340 1974 Panther 340A 71-75 Puma 340A 71-75 440 Cheetah 440 72-75 09-688 Std 68 60 562-6880 564-6880 564-9160 566-0525 16x20x21.7 EXT 440A, 440A Special 1971 09-688-01 0.010 562-6881 Lynx II 440 1974 09-688-02 0.020 562-6882 Pantera 440F/C 1975 09-688-04 0.040 562-6884 Panther 440A 71-75 Puma440A, 440AP 71-73 Puma Mod 440A 1971 VIP 440 1974 * Dome Top with 2 rectangular rings 440 El Tigre 440 73-75 09-689 Std. 68 60 562-6890 564-6880 564-9160 566-0522 16x20x22.5 El Tigre Z 440 1975 09-689-01 0.010 562-6891 EXT 440 1973 09-689-02 0.020 562-6892 * Flat top with 1-L Ring & 1-Rectangular Ring Arctic Cat (Suzuki) 250 Lynx 2000S (250cc) 77-80 09-693* Std 70 65 562-6930 564-6930 564-9180 566-0503 18x23x22 09-693-02* 0.020 562-6932 09-693-04* 0.040 562-6934 275 Jag 275 1976 09-690 Std 54 60 562-6900 564-6900 564-9160 566-0502 16x21x20 Jag 2000 F/A 78-80 09-690-02 0.020 562-6902 Lynx 2000 T F/A 77-80 09-690-04 0.040 562-6904 340 Bearcat 340 95-00 09-692 Std 60 60 562-6920 564-6920 564-9160 566-0502 16x21x20 Cheetah 340 1994 09-692-02 0.020 562-6922 Jag 340 FA 76-77 Jag 340, Deluxe 76-77/98-99 Jag 340 MC 90-91 Jag 3000 F/A, F/C 78-80 Lynx 340 Deluxe 91-93 Lynx 340 MC 92-93 Panther 340A 98-00 Puma 340 Deluxe 94-95 Trail Cat 3000 F/C 79-80 370 Pantera 370, R 01-08 09-603* Std 60 65 564-9180 566-0503 18x23x22 Z 370, ES, LX 99-07 440 Cheetah 440 1976 09-697 Std 65 65 562-6960 564-6970 564-9160 566-0502 16x21x20 431 El Tigre 4000 FA 1976 Panther 440 1976 431 El Tigre 4000 F/A 1977 09-698 Std 65 65 562-6980 564-8010 564-9180 566-0503 18x23x22 Panther 4000 F/C 77-78 440 Cheetah Touring 440 L/C 91-94 09-695* Std 68 60 562-6950 564-7040 564-9180 566-0503 18x23x22 Cougar 440 L/C 91-94 0.010 562-6951 El Tigre Cross Country 1979 09-695-02 0.020 562-6952 El Tigre 5000 L/C 1987 Jag 440 L/C 1996 Pantera 440 L/C 85-93 Panther 440 L/C 96-97 Prowler 440 90-94 Prowler 440 Special L/C 91-94 Z440 1993 ZL 440 97-00 ZR 440 1994

TRANS CAN IMPORTS Piston -4 Arctic Cat (Suzuki) 440 Bearcat 440 93-98 09-696* Std 65 65 562-6960 564-6710 564-9160 566-0502 16x21x20 Bearcat 440 I, II 99-00 09-696-01 0.010 Cheetah 440 1994 09-696-02 0.020 Jag 4000 F/C 81-85 Jag AFS, Dlx, 440 F/C 89-91 Jag AFS, LT 440 F/C 89-93 Jag 440 LT 1981 Jag 440 F/C 85-89 Jag, Deluxe 89-99 Jag 440 Special 91-93 Mountain Cat 440 91-92 Panther 440 F/C, Dlx 84-85/89-01 Panther 4000 F/C 80-81 Super Jag F/C 87-97 Trail Cat 4000 80-81 Z 440 (NOT Sno-Pro 440) 95-98 440 ZR 440 96-98 09-618* Std 66.5 63 564-9180 440 ZR 440 Sno Pro 98-01 09-619* Std 66.5 63 *** Can sub to 09-618 but the piston skirt is slightly different on the Sno Pro 500 Cheetah 500 F/C 86-90 09-691* Std 70 65 562-6930 564-6930 564-9180 566-0503 18x23x22 Cougar 500 86-90 09-691-02* 0.020 562-6932 500 Cougar 500 SE 76-78 09-693* Std 70 65 562-6930 564-6930 564-9180 566-0503 18x23x22 El Tigre 500 1976 09-693-02* 0.020 562-6932 El Tigre 5000 77-81 09-693-04* 0.040 562-6934 Pantera 500 1976 Pantera 5000 77-81 Pantera 500, (elec), (man) 1980 Panther 500 86-88 500 Crossfire5,EFI,T 07-09 09-608* Std 71 63 566-0552 22x27x23.7 F5 EFI, LXR, Sno-Pro 04-14 Firecat 500, F5, LXR, Sno-Pro 03-11 M5, EFI 05-06 Sabrecat 500 04-06 Sno-Pro 500 10-14 T500, Touring 08-09 500 El Tigre 6000 L/C 76-79 09-695 Std 68 60 562-6950 564-7040 564-9180 566-0503 18x23x22 0.010 562-6951 09-695-02 0.020 562-6952 500 El Tigre 6000 L/C 80-85 09-694* Std. 70 65 562-6930 564-7040 564-9180 566-0503 18x23x22 500 Mountain Cat 500 EFI 01-02 09-605* Std 71 62.7 566-0552 22x27x23.7 ZR 500 EFI 01-02 ZL 500 01-02 ZL 500 EFI 01-02 B-case series - 22 mm wrist pin 500 Powder Special 500 EFI 2000 09-679* Std 71 62.7 564-9200 566-0523 20x26x24 ZL 500 98-00 ZL 500 EFI 99-01 ZR 500 98-00 A-case - 20mm wrist pin 530 Cheetah 530 L/C 86-89 09-699 Std 72 65 562-6990 564-6930 564-9180 566-0503 18x23x22 El Tigre 6000 86-89 09-699-01 0.010 562-6991 El Tigre EXT 530 L/C 89-90 09-699-02 0.020 562-6992 El Tigre EXT MC 530 L/C 1990 550 Bearcat 550 L/C 95-02 09-687* Std 73.4 65 562-6830 564-9200 566-0523 20x26x24 Cheetah 550 L/C 95-98 EXT MC 550 L/C 91-92 EXT Special 550 L/C 91-92 EXT 550, EFI, WFI MC 93-94

Piston -5 TRANS CAN IMPORTS Arctic Cat (Suzuki) 550 Pantera 550 L/C, EFI 93-94/03-05 09-687* Std 73.4 65 562-6830 564-9200 566-0523 20x26x24 Panter 550, Deluxe 97-01 Powder Special 1996 Prowler 2-up 1995 ZL 550 esr 00-03 ZL 550 01-02 570 Bearcat 570 04-14 09-615* Std 73.7 566-0555 18x23x24 F570 08-14 Mountain Cat 570 03-04 Panther 570, ES 02-07 T570 09-14 Z 570, LX 04-07 580 EXT 580 EFI, MC 1993 09-681* Std 74.5 65 562-6810 564-9200 566-0523 20x26x24 EXT 580 Z, MC 93-97 09-681-04* 0.040 562-6814 EXT Deluxe, EFI 580 L/C 96-98 Pantera 580 95-98 Pantera 580 EFI 99-03 Prowler 580 Special 1996 ZR 580 94-97 ZR 580 EFI 1998 600 Crossfire 6, EFI 06-09/11 09-616* Std 73.8 70 566-0552 22x27x23.7 F6 / EFI (all) 06-09/11 Firecat 600 / EFI (all) 04-05 M6 / EFI (all) 05-09/11 Sabrecat 600 04-06 600 EXT 600 Triple Touring 96-97 09-601* Std 66.5 57 564-7040 566-0503 18x23x22 Triple Touring 600 99-00 ZRT 600 96-00 600 Mountain Cat 600 2001 09-609* Std 78 62.7 562-6090 564-6090 566-0552 22x27x23.7 Mountain Cat LE 01-04 Pantera 600 EFI 02-05 Powder Special 600 EFT 2000 ZL 600 EFI 00-03 ZL 600 EFI ESR 01-03 ZL 600 EFI SS 02-03 ZR 600 00-02 ZR 600 EFI (all) 01-02 B case series 22 mm pin 600 Powder Special 600 98-00 09-680* Std 78 62.7 564-9200 566-0523 20x26x24 Powder Special 600 EFI 98-99 ZL 600 98-99 ZL 600 EFI 98-00 ZR 600 98-99 ZR 600 EFI 98-00 A case series 20 mm pin 650 Mountain Cat 650 1990 09-684 Std 78 68 562-6840 564-6840 564-9200 566-0523 20x26x24 Wildcat 650 L/C 88-90 700 Crossfire 7 2006 09-607* Std 79.7 70 566-0552 22x27x23.7 Firecat 700, Sno-Pro 03-06 09-907* Std 79.7 M7 (all) 05-06 (Hyperdryve Piston) Sabrecat 700 04-06 700 Mountain Cat 700 91-93 09-682 Std 81 68 562-6820 564-6840 564-9200 566-0523 20x26x24 Mountain Cat 700 EFI 91-96 09-682-01 0.010 Wildcat 700 MC 91-96 09-682-02 0.020 ZL 700 2000 ZR 700 94-96/99-00 800 Crossfire 8 (all) 07-09 09-630* Std 85 566-0552 22x27x23.7 F8 (all) 07-09 09-931* Std 85 M8 (all) 07-09 (Hyperdryve Piston)

TRANS CAN IMPORTS Piston -6 Arctic Cat (Suzuki) 800 CF8, CF8 LE, CF8 Sno-Pro 10-11 09-633* Std 85 70 566-0552 22x27x23.7 F8 EFI 10-13 F8, XF800, LXR, Sno-Pro 10-13 M8 EFI, M800, Sno-Pro 10-13 M8000 2014 XF800 LXR, Sno-Pro Climb HC, LTD 12-13 XF8000 Sno-Pro, Cross, High Country 2014 ZR8000 Sno-Pro, LXR 2014 800 Mountain Cat 800, EFI, LE 01-04 09-611* Std 81 76 566-0536 24x29x24 Pantera 800 EFI 03-04 ZL 800 (all) 01-03 ZR 800 (all) 01-03 800 Pantera 800 98-99 09-602 Std 72 65 564-9200 566-0523 20x26x24 ZRT 800 95-00/02 800 EFI Triple 01-02 900 King Kat 900 04-06 09-614* Std 85 76 566-0536 24x29x24 Mountain Cat 900 03-04 ZR 900 (all) 03-06 900 Thundercat 900 93-97 09-686* Std 76.5 562-6860 564-9200 566-0523 20x26x24 1000 Crossfire 1000 (all) 07-10 09-631* Std 90.3 78 566-0536 24x29x24 F1000 (all) 07-09 M1000 (all) 07-10 1000 Mountain Cat 1000 98-02 09-612* Std 81 64.6 564-6090 566-0552 22x27x23.7 Pantera 1000 00-01 Thundercat 1000 98-01 John Deere (CCW / Kiortz) 400 400/2,3,4 75-77 09-665 Std. 65 60 562-6650 564-8000 564-9180 566-0505 18x22x22 09-665-01 0.010 562-6651 09-665-02 0.020 562-6652 440 Cyclone 440 76-78 09-666 Std.(left) 66 64 562-6660 564-7000 564-9180 566-0505 18x22x22 JDX-8 74-75 09-667 Std.(right) 562-6660 Liquifire 76-78 09-666-01 0.010 (left) 562-6661 (KEC 440/22, A) 09-667-01 0.010(right) 562-6661 09-666-02 0.020(left) 562-6662 09-667-02 0.020(right) 562-6662 John Deere (Kawasaki) Trailfire 79-83 09-606 Std. 60 566-0525 16x20x21.7 Spitfire 80-82 Snowfire 82-84 JLO / Cuyuna 340 LR 340/2-9 71-80 09-660 Std. 60 60 562-6600 564-6850 564-9160 566-0516 16x22x20 09-661 0.010 562-6601 09-662 0.020 562-6602 399 LR 399/2-9 09-661 Std. 65 60 562-6610 564-6850 564-9160 566-0516 16x22x20 400 Cuyuna 400 74-78 09-661-01 0.010 562-6611 09-661-02 0.020 562-6612 440 LR 440/2-9 all 09-662 Std. 67.5 60 562-6620 564-6710 564-9180 Cuyuna 440 74-80 09-661-01 0.010 562-6621 or 562-6711 Cuyuana 440 F/C, LR 440/2 all 09-661-02 0.020 562-6622 or 562-6712 R 650/2 F/C 72-73 09-661-04 Kawasaki 340 Drifter 340 F/A, F/C up to 79 09-685 Std. 60 60 562-6850 564-6850 564-9160 566-0501 16x20x22 09-685-01 0.010 562-6851 09-685-02 0.020 562-6852 340 Drifter 340 F/A, F/C 80 09-606 Std. 60 566-0525 16x20x21.7 Invader 34 L/C 78-80

Piston -7 TRANS CAN IMPORTS Kawasaki 440 Drifter 440 79-80 09-689 Std. 68 60 562-6890 564-6880 564-9160 566-0522 16x20x22.5 Intiguer 440 1978 09-689-01 0.010 562-6891 Intruder 440 78-80 09-689-02 0.020 562-6892 Invader 440 78-81 440 Ltd 440 81-82 09-8072 Std. 562-8720 Kohler 250 K250-RMS 69-93 09-672 Std. 60 564-9180 566-0505 18x22x22 340 K340-22AX 69-93 09-670 Std. 62 56 562-6700 564-9180 566-0505 18x22x22 09-670-01 0.010 562-6701 09-670-02 0.020 562-6702 340 K340-2 69-93 09-675-02 0.020 56 564-6750 564-9160 566-0513 16x20x20 340 K340-2AX, K340-2AS 69-93 09-676 Std. 60 562-6760 440 K440-2AS, K440-2AX 69-93 09-672 Std. 60 564-9180 566-0505 18x22x22 Moto-Ski (Rotax) 250 Spirit 250 76-78 09-740 Std. 69 66 562-7400 564-6930 564-9160 566-0505 18x22x22 Spirit 250 79-83 09-740-02 0.020 562-7402 09-740-04 0.040 562-7404 09-74006 0.060 09-740-08 0.080 562-7408 09-740-10 0.100 562-74010 268 Mirage 1 (268) 80-82 09-741* Std. 72 61 562-7410 564-6930 564-9180 566-0505 18x22x22 09-741-01* 0.010 562-7411 09-741-02* 0.020 562-7412 09-741-04* 09-741-06 0.040 562-7414 300 Mirage 300 1979 09-764 Std. 57 61 562-7640 564-7640 564-9150 566-0514 15x19x20 09-764-01 0.010 562-7641 09-764-02 0.020 562-7642 300 Nuvik 300 75-77 09-770 Std. (left) 55.5 562-7710 564-7700 564-9180 566-0505 18x22x22 09-771 Std. (right) 562-7710 09-770-01.010 (left) 562-7711 09-771-01.010 (right) 562-7711 09-770-02.020 (left) 562-7712 09-771-02.020 (right) 562-7712 340 Futura 340 1975 09-747 Std. (left) 59.5 61 562-7480 564-7470 564-9180 566-0505 18x22x22 Nuvik 340, E 76-79 09-748 Std. (right) 562-7480 09-747-01.010 (left) 562-7481 09-748-01.010 (right) 562-7481 09-747-02.020 (left) 562-7482 09-748-02.020 (right) 562-7482 09-747-04.040 (left) 562-7484 09-748-04.040 (right) 562-7484 340 Sonic 340 76-78 09-767 Std. 63 54 562-7670 564-7530 564-9180 566-0505 18x22x22 09-767-01 0.010 562-7671 09-767-02 0.020 562-7672 340 Super Sonic 340 L/C 79-81 09-750 Std. 59.5 61 562-7500 564-7500 564-9180 566-0505 18x22x22 09-750-01 0.010 562-7501 09-750-02 0.020 562-7502 09-750-04 0.040 562-7504 377 Mirage 377 80-85 09-751* Std. 62 61 562-7510 564-7500 564-9180 566-0505 18x22x22 09-751-01* 0.010 562-7511 09-751-02* 0.020 562-7512 09-751-04* 0.040 562-7514 400 Futura 400, E 77-79 09-768 Std. (left) 64.5 61 562-7690 564-7530 564-9180 566-0505 18x22x22 09-769 Std. (right) 562-7690 09-768-01.010 (left) 562-7541 09-769-01.010 (right) 562-7691 09-768-02.020 (left) 562-7542 09-769-02.020 (right) 562-7542 09-754-04.040 (right) 562-7544

TRANS CAN IMPORTS Piston -8 Moto-Ski (Rotax) 440 Futura 440 75-79 09-758 Std. (left) 67.5 61 564-7040 564-9180 566-0505 18x22x22 Nuvik 440 1977 09-759 Std. (right) 562-7590 564-7040 09-758-01.010 (left) 564-7000 09-759-01.010 (right) 562-7591 564-7000 09-758-02.020 (left) 564-7000 09-759-02.020 (right) 562-7592 564-7000 09-758-04.040 (left) 09-759-04.040 (right) 440 Ultra Sonic 440 80-82 09-760 Std. 67.5 61 562-7600 564-6930 564-9180 566-0505 18x22x22 09-760-01 0.010 562-7601 09-760-02 0-02 562-7602 09-760-04 0.040 752-7604 444 Futura 444-09-761* Std. 69.5 61 562-7610 564-6930 564-9180 566-0505 18x22x22 464 Futura 464 80-82 09-761-01* 0.010 562-7611 467 Sonic 467 L/C 1984 09-761-02* 0.020 562-7612 09-761-04* 0.040 562-7614 500 Futura 500, E 80-82 09-741* Std. 72 61 562-7410 564-6930 564-9180 566-0505 18x22x22 Grand Prix Special 79-81 09-741-01* 0.010 562-7411 503 Sonic 503 1982 09-741-02* 0.020 562-7412 09-741-04* 0.040 562-7414 09-741-06 0.060 562-7416 Polaris 244 Gemini 244 79-83 09-700 Std. 72 60 562-7000 564-7000 564-9180 566-0520 18x23x21 250 Colt 250 (single cylinder) 72-78 09-700-02 0.020 562-7002 Custom II 250 1971 09-700-04 0.040 562-7004 Electra 250 75-77 Star 250 83-90 Starlite 250 91-95 Starlite GT 250 93-95 Startrak 250 87-90 TC 250 74-75 250 Colt 250 (twin cylinder) 76-78 09-702 Std. 53.5 55.6 562-7020 564-6710 564-9160 566-0513 16x20x20 250 Starfire 250 1976 09-703 Std. 53.4 55.6 562-7030 564-7020 564-9160 566-0513 16x20x20 TX 250 76-79 335 TX 335 72-74 09-701 Std. 62 55.6 562-7010 564-6710 564-9160 566-0513 16x20x20 TX Racer 335 1972 340 Colt 340 75-76 Colt SS 340 74-76 TX 340 Racer 72-74 340 Apollo 340 79-80 09-708 Std. 61.78 55.6 562-7080 564-6710 564-9160 566-0513 16x20x20 Cobra 340 78-79 09-708-02 0.020 562-7082 Colt SS 340 77/79 Cutlass 340 1981 Galaxy 340 1980 340 EC 340 79-80 09-706-01 Std. 62 55.6 562-7061 564-6710 564-9160 566-0513 16x20x20 Starfire 340 1983 09-706-02 0.010 562-7062 TX 340, F/A 76-80 09-706-04 0.030 562-7064 TX-C 340 Superstar 77-82 340 Indy Cross Country 340 1983 09-706 Std. 61.78 55.6 562-7060 564-6710 564-9160 566-0513 16x20x20 TX-L 340 77-72 09-706-01 0.010 562-7061 09-706-02 0.020 562-7062 09-706-04 0.040 562-7064 340 EC 340 2PM02A 09-717 Std. 62.25 55.6 564-8020 564-9160 566-0525 16x20x21.7 (cylinder honing required for std. bore on 86-89 models) 09-717-01 0.010 IndyLteDeluxe340 91-98 09-717-02 0.020 Indy Lite, GT 340 91-98 09-717-03 0.030 Indy Lite Touring 340 1998 09-717-04 0.040 Indy Sport 340 87-89

Piston -9 TRANS CAN IMPORTS Polaris 340 Indy 340 99-00/04 09-717 Std. 62.25 55.6 564-8020 564-9160 566-0525 16x20x21.7 Indy 340 Classic 03-06 09-717-01 0.010 Indy 340 Deluxe 99-03 09-717-02 0.020 Indy 340 Edge 03-07 09-717-03 0.030 Indy Lite 91-98 09-717-04 0.040 Indy 340 Touring 99-07 340 Transport 2008 Indy Sport Touring (340) 99-00 Sprint 340, ES 86-89 Sport GT 340 89-90/95-96 400 Indy 400 84-91 09-707* Std. 65 60 562-7070 564-8010 564-9180 566-0503 18x23x22 09-707-01* 0.010 562-7071 09-707-02* 0-020 562-7072 09-707-04* 0.040 440 Cobra 440 78-79 09-704 Std. 67.72 60 562-7040 564-7040 564-9180 566-0520 18x23x21 Cutlas SS 440, 440E 81-82 09-704-02 0.020 562-7042 Electra 440 74-77 Galaxy 440 E 80-81 Lon tack 440 83-86 (skirt length 69.5 mm) Sport 440 1983 Super Sprot 440 1983 TX 440 1973 TX-C 440C 1981 440 Cross Country 440 95-96 09-713* Std. 67.75 60 562-7130 564-7040 564-9180 566-0503 18x23x22 Indy 440, LC, SKS 92-98 0.010 562-7131 Indy 440 XC (EC45-P1091) 1992 09-713-02* 0.020 562-7132 Indy 440 XCR 92-94 09-713-03* 0.030 562-7133 09-713-04* 0.040 440 Indy Sport 440 91-99 09-710 Std. 67.75 60 562-7100 564-7040 564-9180 566-0503 18x23x21 Indy Sport Touring (440) 95-99 09-710-01 0.010 Indy Trail 440 83-86/95 09-710-02 0.020 562-7102 Indy Transport 96-99 Indy XCF 97-98 Long Track 440 84-90 Super Sport 94-96 TX-C 440C 1982 XCF 440 (EC44-3PM024) 97-98 440 TX 440 F/A 76-80 09-705 Std. 67.75 60 562-7050 564-7040 564-9180 566-0520 18x23x21 488 Charger 488 1971 09-700 Std. 72 60 562-7000 564-7000 564-9180 566-0520 18x23x21 Mustang 488 1971 09-700-02 0.020 562-7002 Voyageur 88 1971 09-700-04 0.040 562-7004 488 488 F/C and 500 L/C Fuji Engine 09-712* Std. 72 60 562-7120 564-7000 566-0503 18x23x21 Indy Trail 488 86-98 09-712-01* 0.010 562-7121 Indy Trail Deluxe 488 88-96 09-712-02* 0.020 562-7122 Indy Trail Touring 95-99 09-712-03* 0.030 Indy Wide Track LX 488 90-99 09-712-04* 0.040 562-7124 Super Sport 488 97-98 09-712-06* 0.060 Super Track 488 91-94 Trail Touring 488 95-98 500 Classic Touring 500 L/C 98-01 09-712* Std. 72 60 562-7120 564-7000 566-0503 18x23x21 Indy 500 89-06 09-712-01* 0.010 562-7121 Indy 500 Classic 89-02/04-06 09-712-02* 0.020 562-7122 Indy 500 Classic Touring 99-03 09-712-03* 0.030 Indy 500 EFI 92-97 09-712-04* 0.040 562-7124 Indy 500 RMK 96-99 09-712-06* 0.060 Indy 500 SKS 91-97 Indy Classic Touring 500 1998

TRANS CAN IMPORTS Piston -10 Polaris 500 Centurion 500 79-82 09-706 Std. 61.78 55.6 562-7060 564-6710 564-9160 566-0513 16x20x20 Indy 500 L/C 81-82 09-706-01 0.010 562-7061 09-706-02 0.020 562-7062 09-706-04 0.040 562-7064 500 Indy 500 XC 99-02 09-720* Std. 70.5 64 566-0526 20x25x21.7 Indy 500 XC SP 99-06 Indy 500 Classic 2003 Indy RMK LC 500 00-02 500 TX500 72-73 09-701 Std. 62 55.6 562-7010 564-6710 564-9160 566-0513 16x20x20 500 500 XC SP Edge / M-10 04-05 09-728* Std 77.25 64 562-7280 564-7220 566-0531 20x25x22.8 550 Indy 550 Supersport 99-08 09-727* Std. 73 65 564-9180 566-0503 18x23x22 Indy 550 Sport Touring, ES 99-05 09-727-01* 0.010 562-7271 Indy 550 Trail, RMK 99-08 09-727-02* 0.020 Indy 550 Trail Touring 03-09 09-727-04* 0.040 Indy 550 Trail Touring Dlx 00-07 Indy 550 Classic 03-06 Indy 550 Pro X Fan 2004 550 Indy (all) 14-15 550 IQ LXT 11-13 550 IQ Shift 09-13 550 Shift 11-13 550 LX 07-08 Super Sport 550, Edge 06-07 Super Sport 550, M-10 06-07 Trail Touring Deluxe 500 05-06 580 Indy 580 XLT 93-94 09-714* Std. 64 60 562-7140 564-8020 564-9160 566-0525 16x20x21.7 Indy 580 SKS 93-94 09-714-01* 0.010 XLT, SP 580 93-94 09-714-02* 0.020 562-7142 (Monoblock) 09-714-04* 0.040 600 Indy 600 (3 cylinder) 84-87 09-707* Std. 65 60 562-7070 564-8010 564-9180 566-0503 18x23x22 09-707-01* 0.010 562-7071 09-707-02* 0.020 562-7072 09-707-04* 0.040 562-7074 600 Big Block US built 600 Indy 600 Classic 2001 09-721* Std. 74.5 64 562-7210 566-0526 20x25x21.7 Indy 600 RMK 98-01 Indy 600 XC 98-99 Indy 600 XC Deluxe 45th 2000 Indy XC SP 1999 600 Small Block US built 600 up to 07 Indy 600 Classic 02-06 09-728* Std 77.25 64 562-7280 564-7220 566-0531 20x25x22.8 Indy 600 Classic Touring 01-02 Indy 600 Edge Touring 04-06 09-928* Std 77.25 64 600 HO Fusion 06-07 (Hyperdryve Piston) Indy 600 Pro X, X2 2004 Indy 600 RMK 00-07 Indy 600 Switchback 04-07 Indy 600 Touring 00/05 Indy 600 VES XC/SP 00-05 600 600 Indy / SP (all) 13-15 09-736* Std. 77.1 600 RMK / Pro RMK 13-15 600Rush,Pro-Ride,ES,LX 10-15 600 Switchback, Adventure, Assualt 13-15 600 Voyager 2014 600 Widetrak IQ 10-15

Piston -11 TRANS CAN IMPORTS Polaris 600 600 HO IQ Touring, Cleanfire 07-13 09-737* Std. 77.25 64 566-0531 20x25x22.8 600 HO IQ, LX Cleanfire 07-14 09-937* Std. 77.25 64 600 Dragon, IQ Dragon 08-10 (Hyperdryve Piston) 600 IQ LXT 11-15 600 RR 08-09 600 RMK, Shift 08-11 600 Switchback 08-12 600 Monoblock 600 Piston Port XCR 600 (Not Special) 95-97 09-716* Std. 65 60 562-7160 564-8020 564-9160 566-0525 16x20x21.7 Indy Triumph 2000 09-716-01* 0.010 562-7161 XLT 600 (piston port) 95-97 09-716-02* 0.020 XLT Touring 96-99 09-716-04* 0.040 XLT Special 97-99 09-716-06* 0-060 XLT Classic 98-99 600 Non Monoblock 600 with Reed Valves XCR 600 Special 96-98 09-729* Std. 62.5 65 564-7530 564-9180 566-0503 18x23x21 XCR 600 SE 1997 650 Indy 650, RXL, SKS 90-97 09-713* Std. 67.75 60 562-7130 564-7040 564-9180 566-0503 18x23x22 Indy 650, SKS 88-96 09-713-02* 0.020 562-7132 09-713-03* 0.030 562-7133 09-713-04* 0.040 680 Ultra 680, SP, SPX, Ultra Touring 96-98 09-718 Std. 66.6 65 564-8000 564-9180 566-0503 18x23x22 700 XCR 700 1997 (without exhaust valves) 700 Indy 700 Classic 01-04 09-722* Std. 81 68 562-7220 566-0526 20x25x21.7 Indy 700 Classic Touring 03-04 09-922* Std. 81 68 Indy 700 Deluxe 45th Anniv. 2000 (Hyperdryve Piston) Indy 700 RMK 97-04 09-722-02* 0.020 Indy 700 SKS 97/99-03 Indy 700 XC 98-00 Indy 700 XC SP 99-05 Indy Pro-X 03-04 Indy Pro-X2 2004 Switchback 700 2004 700 700 CFI Dragon IQ 07-10 09-734* Std. 81 566-0531 20x25x22.8 700 Dragon Swtchback & RMK 08-10 800 Indy 800 Classic 2004 09-730* Std. 85 70 562-7300 564-9212 566-0529 22x27x24.8 Indy 800 Edge Touring 04-05 09-930* Std. 85 70 Indy 800 LE 2001 (Hyperdryve Piston) Indy 800 RMK 00/02-05 Indy 800 Snow Check Spec 2001 Indy 800 SKS 2003 Indy 800 XC SP 01-05 Indy 800 Pro X 03-04 Indy 800 Pro X2 2004 Indy 800 Pro XR 2004 Switchback 800 04-05 800 800 Dragon, RMK 08-10 09-738* Std. 85 70 564-9212 566-0529 22x27x24.8 800 IQ 08-10 09-938* Std. 85 70 800 Switchback 08-10 (Hyperdryve Piston) (single ring design, can be used from 08-16) 800 800 Dragon, RMK (** updated motor) 08-10 09-739* Std. 85 70 564-9212 566-0529 22x27x24.8 800 Indy SP / ES 14-15 09-939* Std. 85 70 800 IQ 08-10 (Hyperdryve Piston) 800 RMK, 155 08-13 800 RMK Assault (all options), RMK 155 14-15 800 PRO RMK (155/163 all options) 11-16 800 Rush Pro-R/ES 11-14 800 Switchback/Assault/Adventure, Pro/Pro-RS 10-16 800 Switchback ES 11-16 (**dual ring design - as per Polaris updated motors)

TRANS CAN IMPORTS Piston -12 Polaris 800 Axys Pro RMK /SKS 16 09-733* Std. 85 70 564-9212 566-0529 22x27x24.8 800 Indy SP / ES 14-15 09-933* Std. 85 70 800 RMK Assault (all options), RMK 155 14-15 (Hyperdryve Piston) 800 PRO RMK 11-16 800 Rush 11-16 800 Switchback 11-16 800 Indy Storm 800 94-98 09-719* Std. 72 65 564-7040 564-9180 566-0503 18x23x22 800 XCR 800 99-02 09-731* Std. 72 65 564-7040 564-9180 566-0503 18x23x22 900 900 Fusion 05-06 09-732* Std. 83 80 562-9165 564-9212 566-0529 22x27x24.8 900 RMK 05-06 900 Switchback 05-06 Sachs 280 280/290 09-1110 Std. 73 562-9110 290 09-1111 0.020 73.5 562-9111 SkiDoo 250 Elan 250, E 71-78 09-740 Std. 69.5 66 562-7400 564-9180 566-0505 18x22x22 Elan 250 79-96 09-740-02 0.020 562-7402 09-740-04 0.040 562-7404 09-740-06 0.060 09-740-08 0.080 562-7408 09-740-10 0.100 250 Elan 250 (SS / Twin) 73-79 09-745 Std. 54 564-7450 564-7450 564-9150 566-0514 15x19x20 09-745-02 0.020 562-7452 268 Type 253 269 Citation 3500 (268cc) 79-84 09-741* Std. 72 61 562-7410 564-6930 566-0505 18x22x22 277 Citation 268 LS, LSE 85-91 09-741-01* 0.010 562-7411 Tundra 269 LT 85-96 09-741-02* 0.020 562-7412 Skandic 277 1983 09-741-04* 0.040 562-7414 09-741-06* 0.060 562-7416 294 Elan 294 09-764 Std. 57 57.5 562-7640 564-7640 564-9150 566-0514 15x19x20 300 TNT 294 09-764-01 0.010 562-7641 Citation 300 78-79 09-764-02 0.020 562-7642 300 Olympique 300, S, M 71-77 09-742 Std. 76 66 562-7420 564-7420 564-9180 566-0505 18x22x22 320 Olympique 320, E 1969 09-742-02 0.020 562-7422 09-742-04 0.040 562-7424 300 Olympique 300 Twin, F/C 75-78 09-770 Std.(left) 55.5 564-7700 564-9180 566-0505 18x22x22 09-771 Std.(right) 562-7710 09-770-01 0.010(left) 09-771-01 0.010(right) 562-7711 09-770-02 0.020(left) 09-771-02 0.020(right) 562-7712 335 Olympique 335 69-72 09-746 Std. 78 70 562-7460 564-7420 564-9180 566-0505 18x22x22 Skandic 335 70-73 09-746-01 0.010 562-7461 09-746-02 0.020 562-7462 340 Blizzard X-Country 340 L/C 1979 09-750 Std. 59.5 61 562-7500 564-7500 564-9180 566-0505 18x22x22 Blizzard 6500 Plus (340cc) 1978 09-750-01 0.010 562-7501 Blizzard 7500 Plus (340cc) 79-81 09-750-02 0.020 562-7502 09-750-04 0.040 562-7504 340 Everest 340, E 77-79 09-747 Std.(left) 59.5 61 562-7480 564-7470 564-9180 566-0505 18x22x22 Olympique 340, E 75-79 09-748 Std.(right) 562-7480 TNT 340 72-76 09-747-01 0.010(left) 562-7481 09-748-01 0.010(right) 562-7481 09-747-02 0.020(left) 562-7482 09-748-02 0.020(right) 562-7482 09-747-04 0.040(left) 562-7484 09-748-04 0.040(right) 562-7484

Piston -13 TRANS CAN IMPORTS SkiDoo 340 TNT F/A 340 73-78 09-765 Std. 59.5 61 562-7650 566-0505 18x22x22 09-765-01 0.010 562-7651 09-765-02 0.020 562-7652 09-765-04 0.040 562-7654 340 TNT RV 340 76-80 09-767 Std. 63 54 562-7670 564-7530 564-9180 566-0505 18x22x22 09-767-01 0.010 562-7671 09-767-02 0.020 562-7672 377 Citation 4500 (377cc) 79-83 09-751* Std. 62 61 562-7510 564-7500 564-9180 566-0505 18x22x22 Formula Deluxe 377 99-02 09-751-01* 0.010 562-7511 Formula S 377 95-96/99-00 09-751-02* 0.020 562-7512 Legend 380 Fan 03-04 09-751-04* 0.040 562-7514 MX-Z 380 01-06 GSX Fan 377 05-06 GTX Fan 2006 Grand Touring 380F 01-04 Nordik 377 81-84 Safari 377 84-94 Safari 377 L-LE 90-94 Saga 377 1989 Scout 377 89-92 Skandic 377 82-87 Skandic 380 98-00 Skandic II 377, R 92-95 Touring 377 L, LT 95-00 Touring 377 LE 93-95 Touring 377 E 96-00 Touring 377 ELT 1997 399 Alpine 399 70-71 09-768 Std.(left) 64.5 61 562-7690 564-7530 564-9180 566-0505 18x22x22 Nordic 399 70-71 09-753 Kimpex Std.(left) 64.5 61 Olympique 399 69-73 09-769 Std.(right) 562-7690 Valemont 399 1971 09-768-01 0.010(left) 562-7541 09-754-01 0.010(right) 562-7541 09-768-02 0.020(left) 562-7542 09-753-02 Kimpex 0.020(left) 09-754-02 0.020(right) 562-7542 09-754-04 0.040(right) 438 Blizzard 438 F/A 09-766 Std. 67.5 61 562-7660 564-6930 564-9180 566-0505 18x22x22 TNT 440 F/A 74-77 09-766-01 0.010 562-7661 09-766-02 0.020 562-7662 09-766-04 0.040 562-7664 440 Alpine 440 72-74 09-758 Std.(left) 67.5 61 562-7590 564-7040 564-9180 566-0505 18x22x22 Everest 440 F/C 74-79 09-759 Std.(right) 562-7590 564-7040 Nordic 440 1972 09-758-01 0.010(left) 562-7591 564-7000 Olympique 440 73-76 09-759-01 0.010(right) 562-7591 564-7000 TNT 440 F/C 71-78 09-758-02 0.020(left) 562-7592 564-7000 Valemont 440 1973 09-759-02 0.020(right) 562-7591 564-7000 09-758-04 0.040(left) 564-7000 440 MX-Z 440 ZX L/C 99-06 09-786* Std 65 65.8 564-9180 MX ZX 440 Racing 04-07 440 MX-Z 440 F 97-98 09-752* Std. 67.5 61 562-7520 564-7530 564-9180 566-0505 18x22x22 447 Nordik 50 (440cc) 87-91 09-752-01* 0.010 562-7521 Safari 440 LX, LXE 90-92 09-752-02* 0.020 562-7522 Skandic 440 2001 Touring 440 LE F/C 97-98 Touring SLE 95-99 Safari 447 84-86

TRANS CAN IMPORTS Piston -14 SkiDoo 444 444, 452, 462, 464, 467 L/C 452 Elite 450 L/C 78-80 09-761* Std. 69.5 64 562-7610 564-6930 566-0505 18x22x22 462 SS-25 462 1984 09-761-01* 0.010 562-7611 464 Everest 444 L/C 78-79 09-761-02* 0.020 562-7612 467 Everest 464 L/C 80-83 09-761-04* 0.040 562-7614 Formula GLX 467 1990 Formula MX 467, LT, XTC 85-93 Formula MX 467, Z 93-94 467 Formula SP 467 85-86 09-761* Std. 69.5 64 562-7610 564-6930 566-0505 18x22x22 Formula SS 467 85-86 09-761-01* 0.010 562-7611 Formula ST 467 1994 09-761-02* 0.020 562-7612 Formula XT 467 1994 09-761-04* 0.040 562-7614 Safari GLX 467, LC, LCE 90-92 Grand Touring 470 1995 Summit 470 94-95 454 Blizzard 9500 Plus (454cc) 79-82 09-760 Std. 67.5 61 562-7600 564-6930 564-9180 566-0505 18x22x22 09-760-01 0.010 562-7601 09-760-02 0.020 562-7602 09-760-04 0.040 562-7604 500 500 L/C Rotary Valve Type 494 Formula 500 2000 09-780* Std. 69.5 65.8 562-7800 564-6930 566-0505 18x22x22 Formula Deluxe 500 L/C 97-00 09-780-01* 0.010 Formula Z 500 L/C 1999 09-780-02* 0.020 562-7802 Grand Touring 500 98-99 09-780-04* 0.040 MX-Z 500 98-99 Summit 500 96-00 Touring 500 L/C 2000 Skandic WT L/C 98-01 500 500 L/C Reed Valve Type 493 Formula Deluxe 500 L/C 2001 09-784* Std. 69.5 65.8 564-6930 Grand Touring 500 01-03 09-784-02* 0.020 Legend 500 02-03 MXZ 500, Sport, Trail 00-03 MX-Z Trail 500 2001 500 Alpine 500 83-95 09-741* Std. 72 61 562-7410 564-6930 566-0505 18x22x22 Everest 500 E, F/C 80-83 09-741-01* 0.010 562-7411 Formula Delxe 500 F/C 99-01 09-741-02* 0.020 562-7412 MX-Z 500 F/C 01-02 09-741-04* 0.040 562-7414 Skandic 500 F/C 98-02 Summit 500 F/C 01-02 Touring Fan 500 2001 503 Blizzard 5500, MX (503cc) 79-84 Cheyenne 503 88-91 Escapade 503 87-89 GrandTouringF(503cc) 01-02 GrandTouringCargoF 2001 Nordik 60 (503cc) 87-91 Safari 503 88-91 Safari Rally 503 93-94 Skandic II 503 86-94/97 Skandic WT, SWT F/C 98-03 Skandic Sport 503 F/C 2003 Stratos 503 87-88 Touring 503 SLE F/C 95-99 Voyager 503 1989 521 Safari Grand Luxe 521 L/C 1986 Safari 521 L/C 86-94 Blizzard 9700 (521cc) 83-84 Formula Plus 521 86-91 Formula SL, 521 95-99

Piston -15 TRANS CAN IMPORTS SkiDoo 550 Expedition 550 F, Sport 05-08/11-15 09-743* Std. 76 566-0524 20x24x22.7 Freestyle 550, Back Country, Park, Session 07-09 09-743-01* 0.010 Grand Touring Sport 550F 10-15 09-743-02* 0.020 GSX 550F 05-10 09-743-04* 0.040 GTX 550F 05-09 Legend 550 F 2004 550 MX-Z 550 Fan 03-14 09-743* Std. 76 566-0524 20x24x22.7 Renegade Sport 550F 10-14 09-743-01* 0.010 Skandic SWT (550 F) 04-08 09-743-02* 0.020 Skandic SUV (550F) 04-10 09-743-04* 0.040 Skandic Tundra LT (550F) 08-12 Skandic WT (550 F) 04-15 Summit Fan 550F 03-09 Tundra 550F 09-15 583 Formula 583 1997 09-772* Std. 76 64 562-7720 564-7530 566-0505 18x22x22 Formula Deluxe 583 98-99 09-772-01* 0.010 Formula Z 583 94-99 09-772-02* 0.020 562-7722 Grand Touring 583, XTC 93-99 09-772-04* 0.040 Mach 1 583, XTC 89-90 MX-z 583 96-98 Summit 583 94-98 Mach I 617 91-92 600 600 HO and E-Tec (all) 03-15 09-777* Std. 72 73 562-7770 564-7770 564-9183 566-0531 20x25x23 Expedition TUV 600, HO, SDI 05-10 (single ring design) GSX Limited SDI 600 04-09 09-877* Std. 72 73 GSX Sport 600 HO 04-07 (dual ring design) GTX Limited, Sport 600, SDI 06-09 09-977* Std. 72 73 Legend Grand Touring SE / SE600 2004 (Hyperdryve Piston) Legend Grand Touring Sport 2004 Legend Sport SDI 2004 MXZ 600 HO (all) 03-04 MX-Z REV X 2003 MX-ZX 600 04-06 MX-Z REV Sport 2003 MX-Z Adrenaline / Renegarde 600 HO E-Tec 03-09 MX-Z Renegade X 600 HO 05-06 MX-Z Blizzard 600 HO 2007 Skandic WT L/C 01-04 Skandic SUV 600 Adrenaline 08-09 Summit 600 Adrenaline 03-09 Summit 600 HO E-Tec 2009 500SS 600 L/C and 500SS non HO ONLY 600 Formula Deluxe 600 00-01 09-785* Std. 76 65.8 564-9183 566-0531 20x25x23 Formula Deluxe GSE 2001 09-785-01* 0.010 GSX Sport (500 SS) 05-10 09-785-02* 0.020 GTX Sport (500 SS) 06-09 Grand Touring 600 00-01 GrandTouringSE,GS 02-03 GrandTouringSport600 10-15 Legend Sport 600 RER 2003 MX-Z 600 99-01 MX-Z Adrenaline 600 2001 MX-Z Trail 600 01, 03-04 MX-ZZX 600 2001 MX-Z Adrenaline 500SS 05-06 MX-Z Sport 600 02, 10-15 MX-Z Trail 500SS 04-09 MX-Z TNT 500SS 08-10

TRANS CAN IMPORTS Piston -16 SkiDoo 600 Renegade 600 Sport 2015 09-785* Std. 76 65.8 564-9183 566-0531 20x25x23 Skandic WT LC 600 01-10 09-785-01* 0.010 Skandic SUV 03-07 09-785-02* 0.020 Sport 600 LC 2002 Summit 600, RER Sport 99-01/11-15 Summit Everest 500SS 2009 600 Formula III 600 95-99 09-774 Std. 64.5 61 562-7740 564-7530 564-9180 566-0503 18x23x22 617 Formula Plus 617, EFI, X 92-93 09-772* Std. 76.5 64 562-7720 564-7530 566-0505 18x22x22 Formula STX 617, Z 94-96 09-772-01* 0.010 09-772-02* 0.020 562-7722 09-772-04* 0.040 640 Alpine 640 09-762 Std.(left) 76 70 562-7620 564-7420 564-9180 566-0505 18x22x22 Nordic 640 70-74 09-763 Std.(right) 562-7642 TNT 640 71-72 09-762-01 0.010(left) 562-7621 Valmont 640 71-72 09-763-01 0.010(right) 562-7631 09-762-02 0.020(left) 562-7622 09-763-02 0.020(right) 562-7632 09-762-04 0.040(left) 562-7624 670 Formula Deluxe 670 1999 09-773* Std. 78 70 562-7730 564-7730 566-0524 20x24x22.7 Formula SS 670 95-97 09-773-01* 0.010 Formula Z 670 98-99 09-773-02* 0.020 562-7732 Grand Touring 670 SE 94-97 09-773-04* 0.040 Mach I 670 93-96 MX-Z 670 97-98 Summit 670 HO 95-99 (doesnotfitsummitx670ho) 670 MX-Z 670 HO 1999 09-779* Std. 78 70 562-1470 566-0526 20x25x21.8 Summit X 670 HO 98-99 09-779-02* 0-020 09-779-04* 0-040 700 Formula Deluxe GS, GSE 700 00-01 09-783* Std. 78 73 562-7830 564-9183 566-0531 20x25x23 Formula Z 700 2000 GrandTouringGS700 01-02 GrandTouringSport700 02-03 GrandTouringSETwin 2003 Legend SE 700 03-04 Legend Sport 700 RER 03-04 Legend Sport GT/GT SE 2004 MX-Z 700 00-02 MX-Z 700 RER 2002 MX-Z Adrenaline 700 01/03 MX-Z Renegade 700 2002 MX-Z Trail 700 2001 MX-ZX 700 2001 Summit 700 2000 Summit High Mark 00/03 Summit Sport 700 RER 2002 Summit X 700 01-03 Summit Adrenaline RER 700 2003 700 Formula III 700 98-00 09-781* Std. 69.75 61 562-7810 564-8000 566-0503 18x23x22 Grand Touring 700 Triple 98-00 GrandTouringSETriple 97-98 Mach 97-00 780 Mach Z 780, LT 93-96 09-780* Std. 69.5 65.8 562-7800 564-6930 564-9180 566-0505 18x22x22 09-780-01* 0.010 09-780-02* 0.020 562-7802 09-780-04* 0.040

Piston -17 TRANS CAN IMPORTS SkiDoo Type 793 800 Grand Touring SE 800 02-03 09-778* Std. 82 75.7 562-9145 564-9183 566-0531 20x25x21.8 GSX Limited 800 04-07 (Single Ring Design) GTX Limited 800 06-07 09-788* Std. 82 75.7 562-9145 Legend SE 800 02-04 (Double Ring Design) Legend GT SE 800 2004 09-978* Std. 82 75.7 MX-Z 800 01-02 (Hyperdryve Piston) Type 793 800 MX-Z Blizzard 2007 09-778* Std. 82 75.7 562-9145 MX-Z X 800 01-07 (Single Ring Design) MX-Z Renegade 800 03-07 09-788* Std. 82 75.7 562-9145 MX-Z Renegade X 05-06 (Double Ring Design) MX-Z Rev, RER 2003 09-978* Std. 82 75.7 MX-Z Adrenaline 800 01/03-07 (Hyperdryve Piston) Summit 800 Highmark 01-05 Summit Adrenaline 03-04 Summit Adrenaline 144 05-07 Summit X Sport 01-07 800 Grand Touring SE 800 Triple 99-03 09-782 Std. 70.5 68 564-6930 564-9180 566-0505 18x22x22 Mach Z, LT 800 97-01 Mach Z Tech Plus 800 01-03 Mach Z Sport 800 2002 800 800R* 07-10 09-749* Std. 82 75.7 564-9210 566-0551 21x27x24.7 Freeride 137, 146, 154 12-15 (Single Ring Design with 1.9mm ring) GSX Limited 800 2008 09-849* Std. 82 75.7 MX-Z Adrenaline 800, Power Tec 08-10 (Double Ring Design) MX-Z Renegade, X, Power Tec 08-10 09-949* Std. 82 75.7 MX-Z X800, P-Tec 08-10 (Hyperdryve Piston 1.9mm ring) MXZ TNT 800R ETEC 11-15 MXZ X 800R, XRS, 800RE, ETEC 10-15 Renegade, Adrenaline, Backcountry, X 10-15 Summit Everest 800R, Hillclimb 08-10 Summit Everest, Freeride ETEC 10-15 Summit SP 800RE XM 12-15 Summit Sport 800R 11-15 Summit X 800R* 07-09 Summit X 800R, RE, XM 12-15 * Note - will fit 2007 model only when using needle bearing 566-0551 800 Expedition TUV V-800 07-09 557-2600* Std. 90.96 Expedition Sport V-700 07-08 557-260002* 0.020 91.46 Legend Touring 2009 557-260004* 0.040 91.96 Legend Touring, Trail V-800 2007 557-260006* 0.060 92.46 Skandic SWT V-800 07-11 Skandic Tundra V-800 07-09 1000 Mach Z Adrenaline 1000 05-08 09-744* Std. 88 82 Mach ZX 1000 07-08 Mach Z LT 1000 2008 Mach Z Renegade 1000 2007 Summit Highmark Series 05-08 Yamaha 250 BR 250 82-95 09-800 Std. 70 64 562-8000 564-8000 564-9180 566-0505 18x22x22 BR 250T, TS 85-03 09-800-01 0.010 562-8001 BR 250TS 84-97 09-800-02 0.020 562-8002 09-800-04 0.040 250 Enticer ET 250 (all) 77-81 09-801 Std. 73 59 562-8010 564-8010 564-9180 566-0505 18x22x22 09-801-01 0.010 562-8011 09-801-02 0.020 562-8012 09-801-03 0.030 562-8013 09-801-04 0.040 562-8014

TRANS CAN IMPORTS Piston -18 Yamaha 292 GP 292 72-73 09-812 Std. 73 70 562-8120 564-810 564-9180 566-0505 18x22x22 SM 292 73-74 09-812-01 0.010 562-8121 09-812-02 0.020 562-8122 292 SL 292 71-72 09-810 Std. 73 70 562-8100 564-810 564-9180 566-0505 18x22x22 09-810-02 0.020 562-8102 300 Enticer ET 300 (all) 80-84 09-811 Std. 56 59.6 562-8110 564-8110 564-9180 566-0513 16x20x20 09-811-01 0.010 562-8111 09-811-02 0.020 562-8112 09-811-04 0.030 562-8114 338 GP 338 1973 09-803 Std. 60 59.6 562-8030 564-7470 564-9180 566-0505 18x22x22 340 GS 338, 340 76-79 09-803-01 0.010 562-8031 SL 338 1974 09-803-02 0.020 562-8032 09-803-03 0.030 562-8033 338 GPX 338 F/A 74-75 09-815 Std. 60 59.6 562-8150 564-7470 564-9180 566-0505 18x22x22 09-815-01 0.010 562-8151 09-815-02 0.020 562-8152 340 CS 340, E Ovation 78-88 09-802* Std. 60 59.6 562-8020 564-8020 564-9160 566-0522 16x20x22.5 CS 340, LE Ovation 81-88 09-802-01* 0.010 562-8021 Excel III EC 340 89-95 09-802-02* 0.020 562-8022 Enticer ET 340 97-98 09-802-03* 0.030 562-8023 09-802-04* 0.040 562-8024 09-802-06* 0.060 562-8026 340 Exciter EX 340 76-78 09-804 Std. 60 59.6 562-8040 564-7470 564-9180 566-0505 18x22x22 STX 340 76-77 09-804-01 0.010 562-8041 09-804-02 0.020 562-8042 09-804-03 0.030 562-8043 09-804-04 0.040 562-8044 400 Enticer ET 400 89-91 09-805 Std. 66 59.6 562-8070 564-6710 564-9160 410 Enticer Trapper ET 410 TR F/C 92-98 09-805-01 0.010 562-8071 09-805-02 0.020 562-8072 433 w/cutaway int. reed valve 400 STX 400 76-77 09-806 Std. 68 59.6 562-8060 564-8010 564-9180 566-0505 18x22x22 433 GP 433, 433 w/reed valves 1975 09-806-01 0.010 562-8061 TL 433 1975 09-806-02 0.020 562-8062 440 Exciter EX 440 76-81 09-806-04 0.040 562-8064 GP 440 76-78 09-806-06 0.060 562-8066 Prestige PR 440 76-77 433 no cutaway piston port 433 GP 433, 433 w/reed valves 72-73 09-827 Std. 68 59.6 562-8270 564-8000 564-9180 566-0505 18x22x22 S433 1971 09-827-01 0.010 562-8271 SL 433 1972 09-827-02 0.020 562-8272 SS 433 1974 09-827-04 0.040 562-8274 433 GPX 433 71-75 09-806 Std. 68 59.6 562-8140 564-9180 566-0505 18x22x22 SR 433 71-75 09-806-01 0.010 562-8141 09-806-02 0.020 562-8142 09-806-04 0.040 562-8144 440 SRX 440 78-80 09-818 Std. 68.5 59.6 562-8180 564-8080 564-9200 566-0521 20x25x24 (will not fit 81, don't try) 09-818-01 0.010 562-8181 09-818-02 0.020 562-8182 440 SS 440 80-83 09-807 Std. 66 64 562-8070 564-8070 564-9180 566-0505 18x22x22 09-807-01 0.010 562-8071 09-807-02 0.020 562-8072 480 Mountain Lite 480 97-98 09-813* Std. 72 59.6 562-8130 564-8010 564-9180 566-0505 18x22x22 Phazer 480, E 84-98 09-813-01* 0.010 562-8131 Phazer II 90-94 09-813-02* 0.020 562-8132 500 Phazer 500, Deluxe 99-01 09-813-04* 0.040 Phazer Mountain Lite 00-01 Venture 480 GT, TF, XL 91-98 Venture XL Touring 99-00

Piston -19 TRANS CAN IMPORTS Yamaha 500 SX 500R 00-01 09-825* Std. 68 68 564-8080 564-9200 566-0521 20x25x24 Venture 500 L/C 97-01 09-825-02 0.020 V-Max 500, DX, LE, ST, SX 94-01 V-Max 500 XT, XCT 1998 540 Excel IV EC 540 79-85 09-808* Std. 73 64 562-8170 564-8080 564-9200 566-0521 20x25x24 SRV 540 80-91 09-808-01* 0.010 562-8171 Viking VK 540 88-05 09-808-02* 0.020 562-8172 Excel V XL 540 85-90 09-808-04* 0.040 540 V-Max 540 83-91 09-816 Std. 73 64 562-8160 564-8080 564-9200 566-0521 20x25x24 570 Exciter 570 87-90 09-817 Std. 73 68 562-8170 564-8080 564-9200 566-0521 20x25x24 Exciter II 570 91-93 09-817-01 0.010 562-8171 09-817-02 0.020 562-8172 09-817-04 0.040 600 Mountain Max 600 98-99 09-826* Std. 74.8 68 562-8260 564-9200 566-0521 20x25x24 Venture 600 L/C 97-99 09-826-02* 0.020 V-Max600DX,LE,ST,SX,XT 94-99 XT 600, XCT 1998 600 Mountain Max 600 00-02 09-830* Std. 65 59 564-8080 564-9200 SX 600R 00-02 SX 600 Venom, Venom ER 04-06 Venture 600 99-06 V-Max 600 Deluxe, SX 00-01 V-Max 600 ER 2002 700 Mountain 700 L/C 98 09-831* Std. 69 62 564-9200 566-0526 20x25x21.7 SR X 700 98-02 SX 700 Viper (Series) 02-05 SX 700 Viper ER/Mountain 03-06 Venture 700 2004 700 Mountain Max 700 98-04 09-828* Std. 70.5 59.6 564-8080 564-9200 566-0526 20x25x21.7 SX 700R 00-01 Venture 700 98-03 V-Max 700 97-02 V-Max 700, Deluxe 99-01 V-Max 700 SX 97-99 V-Max XTC, DX 1998

TRANS CAN IMPORTS Piston -20 PISTON KIT PRICING Part # Retail Part # Retail Part # Retail Part # Retail Part # Retail Part # Retail 557-2600 $158.95-J 561-6884 $62.95-H 561-7160 $82.95-H 561-7511 $82.95-H 561-7702 $60.95-H 561-8081 $90.95-H 557-260002 $158.95-J 561-6890 $60.95-H 561-7161 $82.95-H 561-7512 $82.95-H 561-7710 $60.95-H 561-8082 $90.95-H 557-260004 $158.95-J 561-6891 $60.95-H 561-7162 $82.95-H 561-7514 $82.95-H 561-7711 $60.95-H 561-8084 $90.95-H 557-260006 $158.95-J 561-6892 $60.95-H 561-7164 $82.95-H 561-7520 $84.95-H 561-7712 $60.95-H 561-8100 $55.95-H 561-1410 $90.95-H 561-6900 $60.95-H 561-7166 $82.95-H 561-7521 $84.95-H 561-7720 $90.95-H 561-8102 $55.95-H 561-1460 $95.95-H 561-6902 $60.95-H 561-7170 $85.95-H 561-7522 $84.95-H 561-7721 $90.95-H 561-8110 $60.95-H 561-1470 $104.95-H 561-6904 $60.95-H 561-7171 $85.95-H 561-7532 $69.95-H 561-7722 $90.95-H 561-8111 $60.95-H 561-1472 $104.95-H 561-6910 $54.95-H 561-7172 $85.95-H 561-7541 $58.95-H 561-7724 $90.95-H 561-8112 $60.95-H 561-1474 $104.95-H 561-6912 $54.95-H 561-7173 $85.95-H 561-7544 $58.95-H 561-7730 $94.95-H 561-8114 $60.95-H 561-1480 $107.95-H 561-6920 $60.95-H 561-7174 $85.95-H 561-7560 $56.95-H 561-7731 $94.95-H 561-8120 $60.95-H 561-1480h $150.95-H 561-6922 $60.95-H 561-7176 $85.95-H 561-7561 $56.95-H 561-7732 $94.95-H 561-8121 $60.95-H 561-2230 $127.95-H 561-6930 $91.95-H 561-7180 $85.95-H 561-7562 $56.95-H 561-7734 $94.95-H 561-8122 $60.95-H 561-6010 $84.95-H 561-6932 $91.95-H 561-7190 $90.95-H 561-7570 $56.95-H 561-7740 $60.95-H 561-8130 $90.95-H 561-6020 $70.95-H 561-6934 $91.95-H 561-7200 $96.95-H 561-7571 $56.95-H 561-7800 $87.95-H 561-8131 $90.95-H 561-6030 $95.95-H 561-6940 $91.95-H 561-7210 $97.95-H 561-7572 $56.95-H 561-7801 $87.95-H 561-8132 $90.95-H 561-6050 $90.95-H 561-6950 $83.95-H 561-7220 $97.95-H 561-7580 $60.95-H 561-7802 $87.95-H 561-8134 $90.95-H 561-6060 $65.95-H 561-6952 $83.95-H 561-7220H $150.95-H 561-7580 $55.95-H 561-7804 $87.95-H 561-8150 $60.95-H 561-6090 $104.95-H 561-6960 $84.95-H 561-7222 $97.95-H 561-7581 $60.95-H 561-7810 $87.95-H 561-8151 $60.95-H 561-6110 $104.95-H 561-6961 $84.95-H 561-7230 $118.95-H 561-7582 $60.95-H 561-7820 $60.95-H 561-8152 $60.95-H 561-6120 $115.95-H 561-6962 $84.95-H 561-7240 $118.95-H 561-7584 $60.95-H 561-7830 $98.95-H 561-8160 $60.95-H 561-6150 $104.95-H 561-6970 $62.95-H 561-7270 $100.95-H 561-7590 $60.95-H 561-7840 $88.95-H 561-8170 $60.95-H 561-6600 $60.95-H 561-6980 $62.95-H 561-7271 $100.95-H 561-7591 $60.95-H 561-7842 $88.95-H 561-8171 $60.95-H 561-6601 $60.95-H 561-6990 $63.95-H 561-7272 $100.95-H 561-7592 $60.95-H 561-7850 $95.95-H 561-8172 $60.95-H 561-6602 $60.95-H 561-6991 $63.95-H 561-7274 $100.95-H 561-7594 $60.95-H 561-7851 $95.95-H 561-8174 $60.95-H 561-6610 $60.95-H 561-6992 $63.95-H 561-7290 $90.95-H 561-7600 $60.95-H 561-7852 $95.95-H 561-8180 $60.95-H 561-6611 $60.95-H 561-7000 $62.95-H 561-7300 $117.95-H 561-7601 $60.95-H 561-8000 $60.95-H 561-8181 $60.95-H 561-6612 $60.95-H 561-7002 $62.95-H 561-7300H $155.95-H 561-7602 $60.95-H 561-8001 $60.95-H 561-8182 $60.95-H 561-6620 $60.95-H 561-7004 $62.95-H 561-7310 $99.95-H 561-7604 $60.95-H 561-8002 $60.95-H 561-8250 $95.95-H 561-6621 $60.95-H 561-7010 $61.95-H 561-7400 $60.95-H 561-7610 $88.95-H 561-8004 $60.95-H 561-8252 $95.95-H 561-6622 $60.95-H 561-7020 $60.95-H 561-7402 $60.95-H 561-7611 $88.95-H 561-8010 $60.95-H 561-8260 $99.95-H 561-6624 $60.95-H 561-7030 $60.95-H 561-7404 $60.95-H 561-7612 $88.95-H 561-8011 $60.95-H 561-8262 $99.95-H 561-6650 $60.95-H 561-7040 $60.95-H 561-7406 $60.95-H 561-7614 $88.95-H 561-8012 $60.95-H 561-8270 $60.95-H 561-6651 $60.95-H 561-7042 $60.95-H 561-7408 $60.95-H 561-7620 $62.95-H 561-8013 $60.95-H 561-8271 $60.95-H 561-6652 $60.95-H 561-7050 $60.95-H 561-74099 $60.95-H 561-7621 $62.95-H 561-8014 $60.95-H 561-8272 $60.95-H 561-6660 $60.95-H 561-7060 $60.95-H 561-7410 $91.95-H 561-7622 $62.95-H 561-8020 $83.95-H 561-8274 $60.95-H 561-6661 $60.95-H 561-7061 $60.95-H 561-7411 $91.95-H 561-7624 $62.95-H 561-8021 $83.95-H 561-8280 $93.95-H 561-6662 $60.95-H 561-7062 $60.95-H 561-7412 $91.95-H 561-7630 $62.95-H 561-8022 $83.95-H 561-8300 $93.95-H 561-6670 $62.95-H 561-7064 $60.95-H 561-7414 $91.95-H 561-7631 $62.95-H 561-8023 $83.95-H 561-8310 $100.95-H 561-6671 $62.95-H 561-7070 $78.95-H 561-7416 $91.95-H 561-7632 $62.95-H 561-8024 $83.95-H 561-8380 $49.95-H 561-6672 $62.95-H 561-7071 $78.95-H 561-7420 $60.95-H 561-7640 $60.95-H 561-8026 $83.95-H 561-8390 $49.95-H 561-6700 $62.95-H 561-7072 $78.95-H 561-7422 $60.95-H 561-7641 $60.95-H 561-8030 $60.95-H 561-8420 $49.95-H 561-6701 $62.95-H 561-7074 $78.95-H 561-7424 $60.95-H 561-7642 $60.95-H 561-8031 $60.95-H 561-8430 $49.95-H 561-6702 $62.95-H 561-7080 $60.95-H 561-7440 $125.95-H 561-7650 $59.95-H 561-8032 $60.95-H 561-8720 $49.95-H 561-6720 $34.95-H 561-7082 $60.95-H 561-7450 $60.95-H 561-7651 $59.95-H 561-8033 $60.95-H 561-9081 $104.95-H 561-6760 $34.95-H 561-7100 $60.95-H 561-7452 $60.95-H 561-7652 $59.95-H 561-8040 $60.95-H 561-90811 $104.95-H 561-6770 $120.95-H 561-7102 $60.95-H 561-7460 $61.95-H 561-7654 $59.95-H 561-8041 $60.95-H 561-90812 $104.95-H 561-6790 $97.95-H 561-7120 $90.95-H 561-7461 $61.95-H 561-7660 $60.95-H 561-8042 $60.95-H 561-90814 $104.95-H 561-6800 $105.95-H 561-7121 $90.95-H 561-7462 $61.95-H 561-7661 $60.95-H 561-8043 $60.95-H 561-9082 $104.95-H 561-6810 $95.95-H 561-7122 $90.95-H 561-7470 $60.95-H 561-7662 $60.95-H 561-8044 $60.95-H 561-9082h $150.95-H 561-6814 $95.95-H 561-7123 $90.95-H 561-7471 $60.95-H 561-7664 $60.95-H 561-8050 $85.95-H 561-9110 $49.95-H 561-6820 $110.95-H 561-7124 $90.95-H 561-7472 $60.95-H 561-7670 $60.95-H 561-8051 $85.95-H 561-9111 $49.95-H 561-6821 $93.95-H 561-7126 $90.95-H 561-7474 $60.95-H 561-7671 $60.95-H 561-8052 $85.95-H 561-9144 $98.95-H 561-6822 $93.95-H 561-7130 $85.95-H 561-7480 $60.95-H 561-7672 $60.95-H 561-8060 $60.95-H 561-9144B $145.95-H 561-6840 $62.95-H 561-7132 $85.95-H 561-7481 $60.95-H 561-7680 $60.95-H 561-8061 $60.95-H 561-9144H $155.95-H 561-6850 $60.95-H 561-7133 $85.95-H 561-7482 $60.95-H 561-7681 $60.95-H 561-8062 $60.95-H 561-9145 $104.95-H 561-6851 $60.95-H 561-7134 $85.95-H 561-7484 $60.95-H 561-7682 $60.95-H 561-8064 $60.95-H 561-9145A $155.95-H 561-6852 $60.95-H 561-7140 $82.95-H 561-7500 $60.95-H 561-7690 $60.95-H 561-8066 $60.95-H 561-9145H $155.95-H 561-6860 $95.95-H 561-7141 $82.95-H 561-7501 $60.95-H 561-7691 $60.95-H 561-8070 $60.95-H 561-9163 $110.95-H 561-6870 $92.95-H 561-7142 $82.95-H 561-7502 $60.95-H 561-7692 $60.95-H 561-8071 $60.95-H 561-9164 $120.95-H 561-6880 $62.95-H 561-7144 $82.95-H 561-7504 $60.95-H 561-7700 $60.95-H 561-8072 $60.95-H 561-9165 $120.95-H 561-6882 $62.95-H 561-7150 $69.95-H 561-7510 $82.95-H 561-7701 $60.95-H 561-8080 $90.95-H 561-9168 $90.95-H