MAKING MODERN LIVING POSSIBLE Datasheets Danfoss scroll compressors SM / SY / SZ / SH / WSH FRCC.UD.130813.085054 www.danfoss.com/odsg
Datasheet, technical data Performer scroll compressor, SZ185W4 General Characteristics Model number (on compressor nameplate) SZ185W4YC SZ185W4XC Code number for Singlepack* SZ185-4YCI SZ185-4XCI Code number for Industrial pack** SZ185-4YCM SZ185-4XCM Drawing number 8551119b 8551056c Suction and discharge connections Rotolock Brazed Suction connection 2-1/4 " Rotolock 1-5/8 " ODF Discharge connection 1-3/4 " Rotolock 1-1/8 " ODF Suction connection with supplied sleeve 1-3/8 " ODF Discharge connection with supplied sleeve 7/8 " ODF Oil sight glass Threaded Threaded Oil equalisation connection 3/8'' flare SAE 3/8'' flare SAE Oil drain connection 1/4'' flare 1/4'' flare LP gauge port Schrader Schrader IPR valve None None Swept volume 249,9 cm3/rev Displacement @ Nominal speed 43.5 m3/h @ 2900 rpm - 52.5 m3/h @ 3500 rpm Net weight Oil charge Maximum system test pressure Low Side / High side Maximum differential test pressure 100 kg 6,2 litre, POE - 160SZ 25 bar(g) / 32 bar(g) 24 bar Maximum number of starts per hour 12 Refrigerant charge limit Approved refrigerants 13,5 kg R407C, R134a, R404A, R507A Electrical Characteristics Nominal voltage 380-400V/3/50Hz - 460V/3/60Hz Voltage range 360-440 V @ 50Hz - 414-506 V @ 60Hz Winding resistance (between phases) +/- 7% at 25ºC 0.94 # Rated Load Amps (RLA) 24 A Maximum Continuous Current (MCC) 34 A Locked Rotor Amps (LRA) 155 A Motor protection Electronic protection module, 230 V Dimensions D=317 mm H=678 mm H1=180 mm H2=643 mm Terminal box Recommended Installation torques Suction Rotolock nut or valve Discharge Rotolock nut or valve Oil sight glass Power connections / Earth connection Terminal box cover screws Mounting bolts Parts shipped with compressor Mounting kit with grommets, bolts, nuts, sleeves and washers Electronic protection module mounted in terminal box Initial oil charge Installation instructions Approvals : CE certified, UL certified (file SA6873), - *Singlepack: Compressor in cardboard box **Industrial pack: 6 Unboxed compressors on pallet (order per multiples of 6) 130 Nm 110 Nm 50 Nm 3 Nm / 2 Nm 2,3 Nm 21 Nm IP54 (with cable gland) 1: Power connection, 3 x 4.8 mm (3/16'') 2: Earth M5 3: Thermostat connector 4: Knock-out Ø 22 mm (7/8'') for 1/2'' conduit 5: Knock-out Ø 16.5 mm (0.65'') 6: Knock-out Ø 20.5 mm (0.81'') 7: Double knock-out Ø 32.1 mm (1.26'') & Ø 25.4 mm (1'') 8: Double knock-out Ø 44 mm (1-3/4'') for 1-1/4'' conduit & Ø 34 mm (1-3/8'') for 1'' conduit 9: Electronic protection module FRCC.ED.SZ185W4X.A6.02 / page technical data
Datasheet, accessories and spare parts Performer scroll compressor, SZ185W4 Rotolock accessories, suction side Solder sleeve, P08 (2-1/4" Rotolock, 1-3/8" ODF) 8153005 Solder sleeve, P03 (2-1/4" Rotolock, 1-5/8" ODF) 8153006 Rotolock valve, V08 (2-1/4" Rotolock, 1-3/8" ODF) 8168025 Rotolock valve, V03 (2-1/4" Rotolock, 1-5/8" ODF) 8168026 Gasket, 2-1/4" 8156133 Rotolock accessories, discharge side Solder sleeve, P07 (1-3/4" Rotolock, 7/8" ODF) 8153013 Solder sleeve, P02 (1-3/4" Rotolock, 1-1/8" ODF) 8153004 Angle adapter, C07 (1-3/4" Rotolock, 7/8" ODF) 8168008 Angle adapter, C02 (1-3/4" Rotolock, 1-1/8" ODF) 8168005 Rotolock valve, V07 (1-3/4" Rotolock, 7/8" ODF) 8168032 Rotolock valve, V02 (1-3/4" Rotolock, 1-1/8" ODF) 8168028 Gasket, 1-3/4" 8156132 Rotolock accessories, sets Solder sleeve adapter set, (2-1/4" Rotolock, 1-5/8" ODF), (1-3/4" Rotolock, 1"1/8 ODF) 7765028 Valve set, V08 (2-1/4"~1-3/8"), V07 (1-3/4"~7/8") 7703010 Gasket set, 1-1/4", 1-3/4", 2-1/4", OSG gaskets black & white 8156013 Gaskets, sleeves and nuts 1: Gasket 2: Solder sleeve 3: Rotolock nut Solder sleeve adapter set Oil / lubricants POE lubricant, 160SZ, 1 litre can 7754023 POE lubricant, 160SZ, 2 litre can 7754024 Crankcase heaters Surface sump heater + bottom insulation, 56 W, 24 V, CE mark, UL 120Z0360 Surface sump heater + bottom insulation, 56 W, 230 V, CE mark, UL 120Z0376 Surface sump heater + bottom insulation, 56 W, 400 V, CE mark, UL 120Z0377 Surface sump heater + bottom insulation, 56 W, 460 V, CE mark, UL 120Z0378 Belt type crankcase heater, 75 W, 230 V, CE mark, UL 7773108 Belt type crankcase heater, 75 W, 400 V, CE mark, UL 7773118 Belt type crankcase heater, 75 W, 460 V, CE mark, UL 120Z0464 1: Rotolock adapter (Suc & Dis) 2: Gasket (Suc & Dis) 3: Solder sleeve (Suc & Dis) 4: Rotolock nut (Suc & Dis) Mounting kit Miscellaneous accessories Electronic soft start kit, MCI 25 C 7705007 Acoustic hood for scroll compressor S175-S185 7755007 Acoustic bottom insulation for scroll compressor 120Z0353 Discharge thermostat kit 7750009 Spare parts Electronic motor protection module, 230 V 8169021 Mounting kit for 1 scroll compressor including 4 grommets, 4 sleeves, 4 bolts, 4 washers 8156138 Mounting kit for 1 scroll compressor including 4 grommets, 4 sleeves, 4 bolts, 4 washers, 2 8156147 rotolock nuts, 2 solder sleeves, 2 gaskets Oil sight glass with gaskets (black & white) 8156019 Gasket for oil sight glass (white teflon) 8156129 Terminal box 186 x 198 mm, incl cover 8156139 T block connector 60 x 75 mm 8173021 1: Bolt (4x) 2: Lock washer (4x) 3: Flat washer (4x) 4: Sleeve (4x) 5: Grommet (4x) 6: Nut (4x) FRCC.ED.SZ185W4X.A6.02 / page accessories
Datasheet, drawing Scroll compressor All trademarks in this material are property of the respective companies. Danfoss, the Danfoss logotype and Maneurop are trademarks of Danfoss A/S. All rights reserved. FRCC.PD.8551119b / page drawings
Datenblatt, Folleto Datasheet, Karta Scheda Fiche katalogowa, produit, técnico, tecnica, Zeichnung drawing schéma figuras schema rysunki Compressore Compresores Compresseur Sprężarki Scroll-Verdichter compressor Spiralne scroll Die La Danfoss in Katalogen, no n'assume can acepta non accept Prospekten si assume aucune ninguna no responsibility und responsabilité alcuna responsabilidad anderen schriftlichen responsabilità for possible quant por Unterlagen, aux posibles circa errors erreurs wie eventuali inerrores catalogues, z.b. qui Zeichnungen se errori que seraient pudieran nei brochures und cataloghi, glissées Vorschlägen aparecer and pubblicazioni dans other en enthaltenen les sus printed catalogues, catálogos, o altri material. Angaben documenti brochures folletos und Danfoss technischen o scritti. ou cualquier reserves autres Daten La Danfoss otro documentations the sind material right vom Käufer si reserva to alter impreso, vor écrites. il sübernahme diritto products reservándose Dans und di modificare without Anwendung souci el notice. i derecho constant zu prüfen. suoi prodotti de d'amélioration, alterar Der Käufer senza suskann previo aus diesen Unterlagen und zusätzlichen Diensten keinerlei Anspruch gegenüber Danfoss oder Danfoss-Mitarbeitern ableiten, es sei denn, dass diese vorsätzlich oder grob fahrlässig gehandelt haben. Danfoss behält sich das Recht vor, productos avviso, Danfoss This also anche se applies sin réserve previo per to i prodotti le products aviso, droit incluyéndose d'apporter già already ordine on sans sempre los order préavis que provided che estén toutes tali bajo that modifiche modifications pedido, such alternations si si possane estas à ses modificaciones produits, fare can be senza made y compris la necessità no without afectan ceux subsequential di a se cambiamenti las trouvant características changes déjà nelle en commande, specifiche being convenidas necessary che sous con sono el in réserve, cliente. specific già state toutefois, Todas ations concordate. las already que marcas ces agreed. modifications registradas son n'affectent ohne vorherige Bekanntmachung im Rahmen des Angemessenen und zumutbaren Änderungen an ihren Produkten - auch an bereits in Auftrag genommene - vorzunehmen. Alle in dieser Publikation enthaltenen Warenzeichen sind Eigentum propiedad Tutti pas All trademarks les i marchi caractéristiques der jeweiligen di las in fabbrica respectivas this Firmen. material déjà citati Danfoss arrêtées compañías. sono are und property di proprietà en das accord Danfoss Danfoss-Logo of the delle avec respective y el rispettive sind le logotipo client. Warenzeichen companies. società. Danfoss de Danfoss der Il et nome Danfoss, le son logotype Danfoss marcas A/S. thealle Danfoss registradas e Rechte il logotipo ainsi logotype vorbehalten. de Danfoss que Danfoss and Performer e Maneurop Performer A/S. sont Reservados are des sono trademarks marques marchi todos depositati los ofabrique Danfoss derechos. della A/S. Danfoss All rights A/S. reserved. Tous Tutti droits i diritti réservés. riservati. FRCC.PD.8551056c / / página Seite, pagina page page Zeichnung drawings de schema schéma figuras