PIPER AIRCRAFT CORPORATION PA.28RT-2OIT, TURBO ARROW IV 2.I GENERAL This section provides the "FAA Approved" operating limitations, instrument markings, oolor coding and basic placards necessary for operation of the airplane and its systems. Limitations associated with those optional systems and equipment which require handbook supplements can be found in Section 9 (Supplements). 2.3 AIRSPEED SPEED Never Exceed Speed (VN E) - Do not exceed this speed in any operation. Maximum Strrrctural Cruising Speed (VNO) - Do not exceed this speed except in smooth air and then only with caution. Design Maneuvering Speed (VA) - Do not make full or abrupt control movements above this speed. Ar 2900 lbs. G.w. At 1893 lbs. G.W. CAUTION KIAS 193 152 l1a KCAS t86 148 t2l vt Maneuvering speed decreases at lighter weight as the effects of aerodynamic forces become more pronounced. Linear interpolation may be used for intermediate gross weights. Maneuvering speed should not be exceeded while operating in rough air. ISSUED: NOVEMBER 30, 1978 REVISED: JULY 15. 1982 2_l
PIPER AIRCRAFT CORPORATION PA-2tRT-201T, TURBO ARROW IV SPEED Maximum Flaps Extended Speed (VFE) - Do not exceed this speed with the flaps extended. Maximum Landing Gear Extension Speed - Do not exceed this speed when extending the landing gear. Maximum Landing Gear Retraction Speed - Do not exceed this speed when retracting the landing gear. Maximum Landing Gear Extended Speed (VLE) - Do not exceed this speed with the landing gear extended. KIAS 108 133 lll 133 KCAS 104 130 109 130 2.5 AIRSPEED INDICATOR MARKINGS MARKING Red Radial Line (Never Exceed) Yellow Arc (Caution Range - Smooth Air Only) Green Arc (Normal Operating Range) White Arc (Flap Down) IAS I93 KTS 152 KTS to I93 KTS 66 KTS to I52 KTS 6l KTS to IO8 KTS 2-2 ISSUED: NOVEMBER 30. l9z8
PIPER AIRCRAFT CORPORATION PA.28RT-2OIT, TURBO ARROW IV I,IMITATIONS 2.7 POWER PLANT (a) Number of Engines (b) Engine Manulacturer (c) Engine Modcl No. (d) Engine Operating Limits (l) Maximum Horsepower (2) Maximum Rotation Speed (RPM) (3) Maximum Manifold Prcssure (ln. Mercury) (4) Maximum Oil Temperature (e) Oil Pressure Minirnum (red line) Maximum (red line) (f) Fuel Pressure Maximum (red line) (g) Fuel (AVGAS ONt-Y) (minimurn grade) (h) Number of Propelle rs (i) Propeller Manu{'acturer ü) Propeller Hub and Blade Model (l) Optional (Three Blade) (2) Standard (Two Blade) (k) Propeller Diameter (l) Optional (Three Blade) Minimum Maximum (2) Standard (Two Blade) Minimum Maximum (l) Blade Angle Limits (l) Optional (Three Blade) Low Pitch Stop High Pitch Stop (2) Standard (Two Blade) Low Pitch Stop High Pitch Stop I T-eledyne Continental TSrO-360-FB 200 2575 4l 240" F IO PSI r00 PSr I9 PSI 100 orl00l.l. Aviation Grade I Hartzell PHC-C3YF-r( )Fi F7663-2R BHC-C2YF-r( )F/ F84594-8 R 12 16 15 76 l\) + )o 33t l' 14.4!.2 29!1" ISSIIED: NOVEMBER 30, 1978 REVISED: JULY 16, 1984 2-3
PIPER AIRCRAFT CORPORATION PA-28RT-201T, TURBO ARROW IV (m) RPM Restrictions (Two Bladed Propeller Only) Avoid Continuous Ground Operation 1700-2100 RPM In Cross/Tail Wind Over IO KTS. Avoid Continuous Operation 2000-2200 RPM Above 32 Inches Manifold Pressure- 2.9 POWER PLANT INSTRUMENT MARKINGS (a) Tachometer Green Arc (Normal Operating Range) Red Line (Maximum Continuous Power) (b) Oil Temperature Green Arc (Normal Operating Range) Red Line (Maximum) (c) Oil Pressure Green Arc (Normal Operating Range.; Yellow Arc (Caution Range) (Idle) Yellow Arc (Caution Range) (Start and Warm-Up) Red Line (Minimum) Red Line (Maximum) (d) Fuel Pressure Green Arc (Normal Operating Range) Red Line (Maximum) (e) Exhaust Gas Temperature (EGT) Green Arc (Normal Operating Range) Red Line (Maximum) (0 Manifold Pressure Green Arc (Normal Operating Range) Red Line (Maximum) 500 to 2575 RPM 2575 RPM 100" to 2400F 240"F 30 PSI to 80 PSI l0 PSI to 30 PSI 80 PSI to IOO PSI IO PSI IOO PSI 3.5 PSI to 19 PSI I9 PSI 1200'F to l650of 1650.F l0in. to 4l IN. HG 4I IN. HG 2-4 ISSUED: NOVEMBER 30. 1978
PIPER AIRCRAFT CORPORATION PA-28RT-2OIT. TURBO ARROW IV 2.II WEIGHT LIMITS (a) Maximum Weight (b) Maximum Ramp Weight (c) Maximum Baggage 2900LBS. '2912 LBS. 200LBS. NOTE Refer to Scction 5 (Performance) for maximum weight as limited by performance. 2.I3 CENTER OF- GRAVIT'Y LIMITS Weight Pounds Forward Limit Inches Aft of Datum 89.0 85.0 Rearward Limit Inches Aft of Datum NOTES Straight line variation between points given. The datum used is 78.4 inches ahead of the wing leading edge at the intersection of the straight and tapered section. It is the responsibility of the airplane owner and the pilot to insure that the airplane is properly loaded. See Section 6 (Weight and Balance) for proper loading instructions. 2.15 MANEUVER LIMITS No acrobatic maneuvers including spins approved. ISSUED: NOVEMBER 30, 1978 REVISED: JULY 15. 1982 2-5
PIPER AIRCRAFT CORPORATION PA-28RT-2OIT, TURBO ARROW IV 2.I7 FLIGHT LOAD FACTORS (a) Positive Load Factor (Maximum) (b) Negative Load Factor (Maximum) 3.g G No inverted maneuvers approved 2.T9 TYPES OF OPERATIONS The airplane is approved for the following operations when equipped in accordance with FAR 9l or FAR 135. (a) Day V.F.R. (b) Nieht V.F.R. (c) Day I.F.R. (d) Night I.F.R. (e) Non Icing 2.21 FUEL (a) Total Capacity (b) Unusable Fuel The unusable fuel for this airplane has been determined as 2.5 gallons in each wing tank in critical flight attitudes. (c) Usable Fuel The usable fuel in this airplane has been determined as 36.0 gallons in each wing tank. (d) Fuel remaining when the quantity indicators read zero cannot be used safelv in flighr. 77 U.S. GAL. 5 U.S. GAL. 72 U.S. cal. 2.23 OPERATING ALTITUDE Flight above 20,000-feet is not approved. Flight up to and including 10:0])0 feet is approved if equipped with oxyg;n in accordance with FAR 23-1441 and avionics in accordance with FAR 9l or FeR i:s. 2-6 ISSUED: NOVEMBER 30. l97t
PIPER AIRCRAFT CORPORATION PA.28RT.2OIT. TURBO ARROW IV 2.25 NOISE LEVEL The noise level of this aircraft is 69.4 d B(A) for two bladed propeller installations and 72.8 d B(A) for three bladed propeller installations. No determination has been made by the Federal Aviation Administration that the noise levels of this airplane are or should be acceptable or unacceptable for operation at, into, or out of, any airport. The above statement not withstanding the noise level stated above has been verified by and approved by the Federal Aviation Administration in noise level test flights conducted in accordance with FAR 36, Noise Standards - Aircraft Type and Airworthiness Certification. This aircraft model is in compliance with all FAR 36 noise standards applicable to this type. ISSUED: NOVEMBER 30. 1978 2-7
PIPER AIRCRAFT CORPORATION PA-28RT-2OIT, TURBO ARROW IV 2.27 PLACARDS In full view of the oilot: THIS AIRCRAFT MUST BE OPERATED AS A NOR- MAL CATEGORY AIRPLANE IN COMPLIANCE WITH THE OPERATING STATED IN THE FORM OF PLACARDS, MARKINGS AND MANUALS. THIS AIRCRAFT APPROVED FOR NIGHT I.F.R. NON-ICING FLIGHT WHEN EQUIPPED IN ACCORDANCE WITH FAR 9I OR FAR I35. In full view of the pilot, the following Takeoff Check List and one of the following Landing Check Lists will be installed: TAKEOFF CHECK LIST Fuel on Proper Tank Auxiliary Fuel Pump Off Engine Gauges Checked Alternate Air Closed Seat Backs Erect Mixture Set Propeller Set Fasten Belts/ Harness Flaps Set Trim Tab Set Controls Free Doors Latched Air Conditioner Off LANDING CHECK LIST Fuel on Proper Tank Seat Backs Erect Fasten Belts/Harness Aux. Fuel Pump Off Mixture Rich Propeller Set Gear Down (133 KIAS Max.) Flaps Set (108 KIAS Max.) Air Conditioner Off REPORT: V8-940 z-8 ISSUED: NOVEMBER 30, l97e REVISED: SEPTEMBER 14. 1979
PIPER AIRCRAFT CORPORATION PA.2tRT.2OIT. TURBO ARROW IV LANDING CHECK LIST Fuel on Proper Tank Seat Backs Erect Fasten Belts/ Harness Aux. Fuel Pump Off Mixture Rich Propeller Set Gear Down Flaps Set (White Arc) Air Conditioner Off The "Air Conditioner Off item in the above Takeoff and Landing Check Lists is mandatory for air conditioned aircraft only. On the instrument panel in full view of the pilot: " ox?u,üfüils?j,tl liin5' o' va t24ar 2eoo i!t. tttu P.o.H.) On the instrument panel in full view of the pilot: DEMONSTRATED CROSSWIND COMPONENT I7 KTS or DEMO. X-WIND 17 KTS ln full view of the pilot: NO ACROBATIC MANEUVERS. INCLUDING SPINS. APPROVED On the instrument panel in full fiew of the pilot: GEAR DOWN 133 KrAS (MAX.) GEAR UP lll KrAS (MAX.) EXTENDED 133 KrAS (MAX.) or VLO I33 DN, I I I UP VLE I33 MAX. ISSUED: NOVEMBER 30, 197t REVISED: SEPTEMBER l.l, 1979 REPORT: YD9{0?F9
PIPER AIRCRAFT CORPORATION PA-28RT-201T, TURBO ARROW IV Near emergency gear lever: EMERGENCY DOWN Near emergency gear lever (aircraft equipped with backup gear extender): OVERRIDE ENGAGED AUTO-EXT-OFF LOCK PIN ON SIDE TO ENGAGE OVERRIDE: PULL LEVER FULL UP, PUSH LOCK PIN p u L JSEt?f L?i fjf ät?.', o., Near gear selector switch: GEAR UP DOWN II I KIAS MAX. I33 KIAS MAX. Adjacento upper door latch: ENGAGE LATCH BEFORE FLIGHT In full view of the pitot: WARNING TURN OFF STROBE LIGHTS WHEN IN CLOSE PROXIMITY TO GROUND OR DURING FLIGHT THROUGH CLOUD. FOG OR HAZE. In full view of the pilot, in the area of the air conditioner controls when the air conditioner is installed: WARNING AIR CONDITIONER MUST BE OFF TO INSURE NORMAL TAKEOFF CLIMB PERFORMANCE. 2-n ISSUED: NOVEMBER 30, l97t REVISED: AUGUST T5. 19t6
PIPER AIRCR AFT CORPORATION PA-28RT-2OIT, TTIRBO ARROW IV LIIVIITATIONS On insidc ol baggage compartmcnt doot BACJGAGE MAXIMUM zoo T-BS. SEE WEIGHI A\D BALANCE DATA FOR BAG(;ACE I-OADING I]E- T WEEN I50 I-BS. AND ]OO t-bs. ln iull ricu of the pilot: FL'E[- REMAINING WHEN QUANTI'IY I\DICAIOR READS ZERO CANNOT BE L]SED SAFE[.\' IN Fl.lciHl. On the instrument panel in iull riew o[ the pilot in aircral't rvith tuo bladcd propeller installations onll': AVOID CON TINUOUS GROUND OPERATION ITOO- 2IOO RPM IN CROSS I'AIL WIND OVER IO KTS. AVOID CONTINUOLIS OPERATION 2OOO-2200 RPM ABOVE 32" MANIFOLD PRESSURE. On the aft baggage closeout: MAXIMUM BAGGAGE 2OO LBS. NO HEAVY OBJECI'S ON HAT SHET-F. ISSUED: NOVEMBER 30, l97t REVISED: AUGUST t. 1983 2-tl
LII\{ITATIONS PIPER AIRCRAFT CORPORATION PA.28RT.2OIT, TURBO ARROU' IV Adjacento fuel tank filler caps(prior ro serial number2gr-g03 I03l): FLIEI- IOO I30 AVIATION GRADE - MIN. USABLE CAPACITY 36 GAL. USABLE CAPACITY TO BOTTOM OF FIL-LER NECK INDICAI'OR 25 GAL. Ad.iacent to fuel tank filler caps (Serial numbers 28R-s03103 I and unr: FTJEL. IOO OR IOOLL A\'IATION GRADE (Serial numbers 28R-83-l l0l5 and uo) AVGAS01{LY sgrade looll GRADE loo REPORT: vb-940 2-t2 ISSUED: AtrGUST 8. 1983