Page 1 of 11 Caterpillar Electronic Technician 2012C v1.0 Product Status Report 12-Mar-2013 1:40 PM Product Status Report Comments Monitor ECM Part Number 2395025-09 2897B667HL Software Group Part Number 3844011-00 AUG11 Software Group Msngr MG Logged Diagnostic s [Diagnostic Clock = 3014.2527 hours] - Monitor Occ. First Last No Logged Diagnostic s Logged Event s [Diagnostic Clock = 3014.2527 hours] - Monitor Occ. First Last No Logged Events Active Diagnostic s - Monitor No Active s
Page 2 of 11 Active Event s - Monitor No Active Events Current Totals - Monitor Unit Total Operating Hours 3014 hours Configuration - Monitor Unit All Wheel Drive System Installation Status C7 (KHX09207) Engine Serial Number KHX09207 29676333JL Software Group Part Number 3925431-00 DEC11 Software Group MG- Logged Diagnostic s [Diagnostic Clock = 3014.1694 hours] - C7 (KHX09207) Occ. First Last 42-5 Injector Actuation Valve : Current Below Normal 1 3012 3012 168-4 Electrical System Voltage : Voltage Below Normal 1 3008 3008 Logged Event s [Diagnostic Clock = 3014.1694 hours] - C7 (KHX09207) Occ. First Last E198 (2) Low Fuel Pressure 1 2969 2969
Page 3 of 11 Active Diagnostic s - C7 (KHX09207) No Active s Active Event s - C7 (KHX09207) No Active Events Current Totals - C7 (KHX09207) Unit Total Operating Hours 3014 hours Total Fuel 11647 gal Total Max Fuel 32235 gal Total Idle Time 1162:27 hours Total Idle Fuel 1288 gal Lifetime Total Engine Revolutions 258433932 rev Engine Starts 2735 Configuration - C7 (KHX09207) Unit Engine Serial Number KHX09207 29676333JL ECM Part Number 2622878-01 Software Group Part Number 3925431-00 DEC11 Software Group MG- Engine Cooling Fan Map Standard Ether Solenoid Configuration Continuous Flow Solenoid Number of Available Engine Power Levels 8 Security System Immobilizer Installation Status Engine Warmup Elevated Idle Feature Enable Status Enabled FLS 4
Page 4 of 11 FTS -7 Total Tattletale 1226 Injector Trim Calibration - C7 (KHX09207) Injector Serial Number File Version Tattletale Injector1 000000003B11965977F3 0 1 Injector2 000000003B119661678D 0 1 Injector3 000000003B119661769F 0 1 Injector4 000000003B11966113FA 0 1 Injector5 000000003B11966040D9 0 1 Injector6 000000003B11965806F4 0 1 Monitoring System - C7 (KHX09207) State Trip Point Delay Time Engine Overspeed Least Severe (1) Always On 2600 rpm 0 sec Moderate Severity (2) Always On 2800 rpm 0 sec High Air Filter Restriction Pressure Least Severe (1) Always On 2.0 " H2O 0 sec Moderate Severity (2) Always On 4.0 " H2O 0 sec High Engine Coolant Temperature Least Severe (1) Always On 226 Deg F 10 sec Moderate Severity (2) On 232 Deg F 10 sec Most Severe (3) Off 232 Deg F 10 sec High Engine Inlet Air Temperature Least Severe (1) Always On 194.0 Deg F 8 sec Moderate Severity (2) Always On 230.0 Deg F 8 sec High Fuel Filter Pressure Restriction Least Severe (1) On None 3600 sec Moderate Severity (2) On None 14400 sec High Fuel Pressure Least Severe (1) Always On 109.9 psi 8 sec High Fuel Temperature Least Severe (1) Always On 194.0 Deg F 30 sec Moderate Severity (2) On 195.8 Deg F 10 sec Low Engine Oil Pressure Least Severe (1) Always On None 8 sec
Page 5 of 11 Most Severe (3) Always On None 4 sec Trans/Chassis Transmission Serial Number CZM01278 ECM Part Number 2621408-02 24976962JT ECM Location 1 Software Group Part Number 3783741-00 SEP2011 Software Group 140 MG Chassis/Trans Logged Diagnostic s [Diagnostic Clock = 3014.1941 hours] - Trans/Chassis Occ. First Last 623-3 Directional Switch : Voltage Above Normal 1 2871 2871 Logged Event s [Diagnostic Clock = 3014.1941 hours] - Trans/Chassis Occ. First Last E627 (3) Parking Brake Applied with Machine in Motion 1 1656 1656 Active Diagnostic s - Trans/Chassis No Active s Active Event s - Trans/Chassis No Active Events Current Totals - Trans/Chassis
Page 6 of 11 Unit Total Operating Hours 3014 hours Total Hours Coasting In Neutral 7 hours Machine Idle Time 830.45 hours Configuration - Trans/Chassis Unit Transmission Serial Number CZM01278 Autoshift Feature Installation Status Installed Transmission Minimum Forward Autoshift Gear 3 Transmission Maximum Forward Autoshift Gear 8 Transmission Minimum Reverse Autoshift Gear 3 Transmission Maximum Reverse Autoshift Gear 6 Transmission Maximum Forward Gear 8 Transmission Maximum Reverse Gear 6 Transmission Initial Forward Gear 4 Transmission Initial Reverse Gear 3 Clutch #1 Hold Level Current Command Amps Clutch #2 Hold Level Current Command Amps Clutch #3 Hold Level Current Command Amps Machine Speed Limit 50 mph Machine Speed Correction Factor 0.0000 % Transmission Orifice Plate Installation Status Transmission Oil Type Configuration TDTO SAE 30 Air Conditioning System Installation Status Installed Battery Cable Shield Monitoring System Installation Cold Engine Parasitic Load Reduction Installation Automatic Differential Lock Feature Installation Status Security System Immobilizer Installation Status CAN Communication Protocol Write Security CAN Communication Protocol Read Security Total Tattletale 1 Shift Count Matrix - Trans/Chassis To N R1 R2 R3 R4 R5 R6 1 2 3 4 5 6 7 8 From N --- 1432 5612 8235 40 12 2 3614 10339 7490 2995 42 28 16 23
Page 7 of 11 R1 1151 --- 4154 2 0 0 2 3214 1 1 0 0 0 0 0 R2 4693 503 --- 6443 0 0 0 338 15699 0 0 0 0 0 0 R3 8037 46 753 --- 13719 1 1 190 1197 32341 137 0 0 0 0 R4 1910 4 2 178 --- 4762 0 11 271 6729 77 0 0 0 0 R5 800 1 1 6 184 --- 760 2 43 2917 99 0 0 0 0 R6 94 1 1 0 3 38 --- 1 15 599 12 0 0 0 0 1 2692 6493 237 286 0 0 0 --- 3081 55 45 0 1 0 2 2 6414 37 16603 721 0 0 0 5162 --- 10427 4 0 0 0 2 3 8224 11 230 31691 0 0 0 288 8639 --- 15630 1 0 0 14 4 3190 5 66 7408 0 0 0 86 89 4098 --- 7378 6 0 0 5 1316 1 20 1138 0 0 0 24 24 93 3272 --- 3985 50 107 6 546 0 10 218 0 0 0 6 4 20 45 2370 --- 2671 0 7 276 0 2 82 0 0 0 4 3 9 22 116 1843 --- 1664 8 253 0 4 76 0 0 0 4 5 8 4 129 30 1292 --- Counters - Trans/Chassis Parking Brake Pressure Switch Cycles 7893 Parking Brake Solenoid Cycles 7835 Starter Relay Cycles 3559 Service Brake Pedal Switch Cycles 60226 Number of Cold Temperature Transmission Filter Bypasses 620 Total Cold Temperature Transmission Oil Filter Bypass Hours 10 Implement ECM Part Number 2621408-02 29376732JT ECM Location 2 Software Group Part Number 3783743-00 SEP2011 Software Group 140 MG Master Impl Cntl Logged Diagnostic s [Diagnostic Clock = 3014.1774 hours] - Implement
Page 8 of 11 Occ. First Last 2210-3 Auxiliary Lever #7 Position Sensor : Voltage Above Normal 2 3006 3006 Logged Event s [Diagnostic Clock = 3014.1774 hours] - Implement Occ. First Last E258 (3) No steering detected with command given 1 1598 1598 Active Diagnostic s - Implement No Active s Active Event s - Implement No Active Events Current Totals - Implement Unit Total Operating Hours 3014 hours Configuration - Implement Unit Left Steering Cylinder Maximum Extension Length 930.7 mm Right Steering Cylinder Maximum Extension Length 930.8 mm Left Steering Cylinder Minimum Retraction Length 644.4 mm Right Steering Cylinder Minimum Retraction Length 645.2 mm Left Steering Cylinder Position Sensor Maximum Pulse Duration 128.8 usec Right Steering Cylinder Position Sensor Maximum Pulse Duration 128.7 usec Left Steering Cylinder Position Sensor Minimum Pulse Duration 24.6 usec Right Steering Cylinder Position Sensor Minimum Pulse Duration 24.6 usec Hydraulic Oil Viscosity Rating SAE 10W Machine Shipping Mode Enable Status Disabled Auxiliary Valve #1 Control Lever Configuration Auxiliary Valve #2 Control Lever Configuration Lever #7
Page 9 of 11 Auxiliary Valve #3 Control Lever Configuration Auxiliary Valve #4 Control Lever Configuration Auxiliary Valve #5 Control Lever Configuration Auxiliary Valve #6 Control Lever Configuration Auxiliary Valve #7 Control Lever Configuration Auxiliary Lever #1 Float Enable Status Auxiliary Lever #4 Float Enable Status Auxiliary Lever #6 Float Enable Status AccuGrade System Installation Status AccuGrade Enable Status AccuGrade Temporary Installation Status Auxiliary Control Pod Enable Status CAN Communication Protocol Write Security CAN Communication Protocol Read Security Disabled Disabled Disabled Installed Disabled Enabled Calibration Status - Implement Calibration Status Last Successful Completion Articulation Position Sensor Calibration Success 2.7 hours Auxiliary Valve #1 Port B Solenoid Never Calibrated Never Successfully Calibrated Auxiliary Valve #1 Port A Solenoid Never Calibrated Never Successfully Calibrated Auxiliary Valve #2 Port B Solenoid Success 2.8 hours Auxiliary Valve #2 Port A Solenoid Success 2.8 hours Auxiliary Valve #3 Port B Solenoid Never Calibrated Never Successfully Calibrated Auxiliary Valve #3 Port A Solenoid Never Calibrated Never Successfully Calibrated Auxiliary Valve #4 Port B Solenoid Never Calibrated Never Successfully Calibrated Auxiliary Valve #4 Port A Solenoid Never Calibrated Never Successfully Calibrated Auxiliary Valve #5 Port B Solenoid Never Calibrated Never Successfully Calibrated Auxiliary Valve #5 Port A Solenoid Never Calibrated Never Successfully Calibrated Auxiliary Valve #6 Port B Solenoid Never Calibrated Never Successfully Calibrated Auxiliary Valve #6 Port A Solenoid Never Calibrated Never Successfully Calibrated Blade Right Lower Solenoid Calibration Success 631.5 hours Blade Right Lower Float Solenoid Calibration Success 631.5 hours Blade Left Lower Solenoid Calibration Success 631.5 hours Blade Left Lower Float Solenoid Calibration Success 631.6 hours Circle Right Solenoid Calibration Success 631.6 hours Circle Left Solenoid Calibration Success 631.6 hours Blade Right Raise Solenoid Calibration Success 631.9 hours Blade Left Raise Solenoid Calibration Success 631.6 hours
Page 10 of 11 Blade Sideshift Right Solenoid Calibration Success 631.7 hours Blade Sideshift Left Solenoid Calibration Success 631.7 hours Blade Pitch Forward Solenoid Calibration Success 631.7 hours Blade Pitch Backward Solenoid Calibration Success 631.7 hours Circle Sideshift Right Solenoid Calibration Success 631.7 hours Circle Sideshift Left Solenoid Calibration Success 631.8 hours Articulate Right Solenoid Calibration Success 631.8 hours Articulate Left Solenoid Calibration Success 631.8 hours Wheel Lean Right Solenoid Calibration Success 631.8 hours Wheel Lean Left Solenoid Calibration Success 631.8 hours Steering Cylinder Position Sensors Calibration Success 2.9 hours Implement Control #2 ECM Part Number 2621408-02 29376355JT ECM Location 3 Software Group Part Number 3855563-00 SEP2011 Software Group Aux Implement Ctrl #1 Logged Diagnostic s [Diagnostic Clock = 3014.1607 hours] - Implement Control #2 Occ. First Last No Logged Diagnostic s Logged Event s [Diagnostic Clock = 3014.1607 hours] - Implement Control #2 Occ. First Last No Logged Events Active Diagnostic s - Implement Control #2
Page 11 of 11 No Active s Active Event s - Implement Control #2 No Active Events Configuration - Implement Control #2 Unit Advanced Machine Security System Installation Status Sunday Security System Bypass Start Time Sunday Security System Bypass Stop Time Monday Security System Bypass Start Time Monday Security System Bypass Stop Time Tuesday Security System Bypass Start Time Tuesday Security System Bypass Stop Time Wednesday Security System Bypass Start Time Wednesday Security System Bypass Stop Time Thursday Security System Bypass Start Time Thursday Security System Bypass Stop Time Friday Security System Bypass Start Time Friday Security System Bypass Stop Time Saturday Security System Bypass Start Time Saturday Security System Bypass Stop Time Total Tattletale 2