PGB SERIES 0 SEER SelfContained Gas/Electric Packaged Air Conditioner 2 and 5 Ton Cooling Capacity: 2,600 to 58,000 BTUH Heating Input Rates: 6,000 to 0,000 BTUH The PGB outdoor package unit is a selfcontained heating and cooling unit that allows for ground or rooftop installation and sidebyside or downflow applications. Standard Features Twospeed evaporator blower motor Copper tube, aluminum fin coils Quiet operating top condenser discharge grille Totally enclosed, permanently lubricated condenser fan motor Hermetically sealed compressor with internal relief valve Fully charged R system Highefficiency performance Liquid line filter drier Powerassisted combustion requiring no vent cap Aluminized steel heat exchanger cells Watershed base All models meet Calif. NOX emissions standards Hot surface pilot ignition system Highefficiency copper tube/aluminum fin coil Cabinet Construction Powderpaint finish with 500hour salt spray approval Fully insulated with blankets of fiberglass Convenient access panels Bottom handling rails When properly anchored, meets the 0 Florida Building Code unit integrity requirements for hurricanetype winds Accessories L.P. Gas Conversion Kits Room thermostat High and Lowpressure Switch Kits Concentric converter Economizer (horizontal and vertical) Manual fresh air damper (025%) Motorized fresh air damper (025%) Rectangular to round converter Downflow filter rack Low Ambient Kit Roof curb SS90D www.goodmanmfg.com /0
Model Identification PGB 06 050 A ENGINEERING REVISION ELECTRIC DESIGNATOR = 8/2V, PH, 60Hz = 8/2V, PH, 60Hz = 60V, PH, 60Hz NOMINAL INPUT HEATING CAPACITY (BTUH) 050 = 6,000 075 = 69,000 00 = 92,000 25 = 5,000 50 = 0,000 NOMINAL COOLING CAPACITOR (BTUH) 02 = 2,000 0 =,000 06 = 6,000 02 = 2,000 08 = 8,000 060 = 60,000 UNIT TYPE PGB = PACKAGE GAS (ALL UNITS ARE DIRECT DRIVE) 2
Figure CHASSIS # CHASSIS #2 CHASSIS # ALL PGB MODELS LP Conversion Kit Honeywell HSP Room Thermostat High & Low Pressure Switch Kit Low Ambient Kit Figure 2 Accessory Model Numbers MODEL NUMBERS LPM0 CHT860 HLPK0 LA0 DIMENSIONS (INCHES) PGB050 PGB075 PGB0050 PGB0075 PGB06050 PGB06075 PGB000 PGB0600 PGB075 PGB00 PGB05 PGB08075 PGB0800 PGB0825 PGB0850 PGB06000 PGB06025 PGB06050 A 8 8 5 8 B 52 52 55 8 C 8 58 8 D 8 6 8 25 8 E 8 8 8 265 8 F 5 5 7 G 5 5 7 H 6 25 I 8 27 K 2 2 L 6 8 8 8 27 M 7 7 7 N 75 8 75 8 0 8 O 2 8 2 8 7 8
Specifications Total Cooling BTUH Sens. Cooling BTUH Cooling CFM Nominal SEER (2) EER a () Sound Rating (2) Heating Input Heating Capacity Output Capacity AFUE () Outdoor S. S. Eff. California SEER Temp. Rise Range Indoor Blower Type Size D x W Motor Horsepower. Evaporator Coil Face (ft 2 ) Fin / In Outdoor Fan Fan Dia. (in.) Condenser Coil Face Area (ft 2 ) Fin / In. Electrical Ph Volts Compr. RLA Compr. LRA Indoor Blw FLA. Outdoor Blw FLA. Min. Circuit Amp Max. Fuse Size Max HACR Breaker Net Weight Shipping Weight PGB050A PGB075A PGB0050B PGB0075B PGB000B PGB06050B 2,600 7,600 900 0.0 6,000 7,700 7.8 60 9 x 6 / 5 2. 2,600 7,600 900 0.0 69,000 56,600 76. 5080 9 x 6 / 5 2. 28,0 2,0,050 0.0 6,000 7,700 7.8 2555 9 x 6 / 2. 28,0 2,0,050 0.0 69,000 56,600 76.0 070 9 x 6 / 2.,000,500,050 0.0 92,000 75,00 76.5 5585 0 x 6 / 2.86,0 2,600,0 0.0 6,000 7,700 7.8 50 0 x 6 / 8 8 8 8 8 / 6 / 6 / 6 / 6 / 6 / 6 0.05 9 8/2 9.8 56.0.7. 5.0 60 70 0.05 9 8/2 9.8 56.0.7. 5.0 70 80 0.05 9 8/2.7 75.0..9 60 70 0.05 9 8/2.7 75.0..9 70 80. 9 8/2.7 75.0..9 85 95 2. 0.05 9 8/2.9 96.0.8 2.0 65 65 PGB models meet California NOX Requirements () In accordance with D.O.E. Test Procedures (2) Certified per ARI and 270 () BTU / Watt @ 80/67 F inside 95 F outside air
Specifications (cont.) Total Cooling BTUH Sens. Cooling BTUH Cooling CFM Nominal SEER (2) EER a () Sound Rating (2) Heating Input Heating Capacity Output Capacity AFUE () Outdoor S. S. Eff. California SEER Temp. Rise Range Indoor Blower Type Size D x W Evaporator Coil Face (ft 2 ) Fin / In Outdoor Fan Fan Dia. (in.) Condenser Coil Face Area (ft 2 ) Fin / In. Electrical Ph Volts Compr. RLA Compr. LRA Indoor Blower FLA. Outdoor Blower FLA. Min. Circuit Amp Max. Fuse Size Max HACR Breaker Net Weight Shipping Weight PGB06075B PGB06075B PGB0600B PGB075B PGB00B PGB05B,0 2,600,0 0.0 69,000 56,600 75.2 565 0 x 6 / 2. 8 /6 0.05 9 8/2.9 96.0.8 2.0 75 85,0 2,600,0 0.0 69,000 56,600 75.2 565 0 x 6 / 2. 8 /6 0.05 9 8/2 0. 75.0.8 7. 25 75 85 5,000 25,0,0 0.0 92,000 75,00 75.2 5585 0 x 6 / 2.86 0,000,00,50 0.0 8. 69,000 56,600 7. 60 0 x 8 / 2 2.86 0,000,00,50 0.0 8. 92,000 75,00 75.5 575 0 x 8 / 2 2.86 0,800,0,500 0.0 8. 5,000 9,0 76.2 575 0 x 8 / 2. / / / /. 9 8/2.9 96.0.8 2.0 95 05. 9 8/2 8.6 27.0.6.8 28.7 0 0 05 5. 9 8/2 8.6 27.0.6.8 28.7 0 0 0.95 9 8/2 7. 05.0.6.8 26.8 0 0 65 75 PGB Models meet California NOX Requirements () In accordance with D.O.E. Test Procedures (2) Certified per ARI and 270 () BTU / Watt @ 80/67 F inside 95 F outside air 5
Specifications (cont.) Total Cooling BTUH Sens. Cooling BTUH Cooling CFM Nominal SEER (2) EER a () Sound Rating (2) Heating Input Heating Capacity Output Capacity AFUE () Outdoor S. S. Eff. California SEER Temp. Rise Range Indoor Blower Type Size D x W Evaporator Coil Face (ft 2 ) Fin / In Outdoor Fan Fan Dia. (in.) Condenser Coil Face Area (ft 2 ) Fin / In. Electrical Ph Volts Compr. RLA Compr. LRA Indoor Blower FLA Outdoor Blower FLA Min. Circuit Amp Max. Fuse Size Max HACR Breaker Net Weight Shipping Weight PGB08075B PGB0800B PGB0825B PGB0850B PGB0850B PGB06000 6,000 6,000 6,000 6,000 6,000 58,000 6,800 6,800 6,800 6,800 6,800,800,700,700,700,700,700,950 0.0 0.0 0.0 0.0 0.0 0.0 9. 9. 9. 8. 8. 8. 8. 8. 8. 69,000 92,000 5,000 0,000 0,000 92,000 56,600 9,0,800 75,00 75,00,800 7. 7.8 75.8 76.5 76.6 7.6 50 60 070 575 575 2555 0 x 0 0 x 0 0 x 0 0 x 0 0 x 0 0 x 0 /2 /2 /2 /2 /2 /...... / / / / / /.95.95.95.95.95.95 9 9 9 9 9 9 8/2 8/2 8/2 8/2 8/2 8/2 8. 8. 8. 2 02.0 9.0 02.0 02.0 9.0 5.0.6.6.6.6.6 6.0 2.5 2.5 2.5 2.5 2.5 2. 29.0 2.9 29.0 29.0 2.9.7 0 0 0 60 0 0 0 60 70 80 90 500 500 525 80 90 500 50 50 55 PGB Models meet California NOX Requirements () In accordance with D.O.E. Test Procedures (2) Certified per ARI and 270 () BTU / Watt @ 80/67 F inside 95 F outside air 6
Specifications (cont.) Total Cooling BTUH Sens. Cooling BTUH Cooling CFM Nominal SEER (2) EER a () Sound Rating (2) Heating Input Heating Capacity Output Capacity AFUE () Outdoor S. S. Eff. California SEER Temp. Rise Range Indoor Blower Type Size D x W Evaporator Coil Face (ft 2 ) Fin / In Outdoor Fan Fan Dia. (in.) Condenser Coil Face Area (ft 2 ) Fin / In. Electrical Ph Volts Compr. RLA Compr. LRA Indoor Blower FLA. Outdoor Blower FLA. Min. Circuit Amp Max. Fuse Size Max HACR Breaker Net Weight Shipping Weight PGB06000 PGB06025 PGB06025 PGB06050 PGB06050 PGB06050 58,000 58,000 58,000 58,000 58,000 58,000,800,800,800,800,800,800,950,950,950,950,950,950 0.0 0.0 0.0 0.0 0.0 0.0 9. 9. 9. 9. 8. 8. 8. 8. 8. 8. 92,000 5,000 5,000 0,000 0,000 0,000 9,0,800 75,00 9,0,800,800 80 7.6 7.8 7.8 75.6 75.6 75.0 2555 565 565 070 070 070 x0 x 0 x 0 x 0 x 0 x 0 / / / / / /...... / / / / / /.95.95.95.95.95.95 9 9 9 9 9 9 8/2 8/2 8/2 8/2 8/2 60 6.0 2 6.0 2 6.0 8.0 7.0 5.0 7.0 5.0 7.0 68.0 6.0 6.0 6.0 6.0 6.0 2.2 2. 2. 2. 2. 2..2 28..7 28..7 28.. 0 60 0 60 0 0 60 0 60 0 525 55 55 55 55 55 55 55 55 555 555 555 PGB Models meet California NOX Requirements () In accordance with D.O.E. Test Procedures (2) Certified per ARI and 270 () BTU / Watt @ 80/67 F inside 95 F outside air 7
Evaporator Blower Air Flow Data MODEL # PGB02 050/075A VOLTAGE 8 2 8 2 MOTOR SPEED LOW LOW HIGH HIGH E.S.P. CFM WATTS CFM WATTS CFM WATTS CFM WATTS.0...0.50.60 75 700 685 665 60 590 250 25 2 0 0 825 80 795 760 7 675 295 285 280 265 250 2 85 825 80 775 70 690 0 295 285 270 260 970 925 905 870 85 755 290 270 MODEL # PGB0 050/075A VOLTAGE 8 2 8 2 MOTOR SPEED LOW LOW HIGH HIGH E.S.P. CFM WATTS CFM WATTS CFM WATTS CFM WATTS.0...0.50.60,000 960 905 870 8 785 0 295 290 280 265 250,060,0 970 90 880 80 25 5 0 290 285 270,,080,0 975 925 865 60 55 5,0,090,05 990 95 990 85 75 60 50 MODEL # PGB000A & PGB06 050/075/00X VOLTAGE 8 2 8 2 MOTOR SPEED LOW LOW HIGH HIGH E.S.P. CFM WATTS CFM WATTS CFM WATTS CFM WATTS.0...0.50.60,5,00,070,00 995 960 50 25 0 75 60,265,25,0,50,095,025 80 60 50 95 80 60,00,25,5,50,00,050 90 70 50 0 95 70,65,,285,25,75,00 5 500 80 50 25 00 MODEL # PGB02 075/00/25X VOLTAGE 8 2 8 2 MOTOR SPEED LOW LOW HIGH HIGH E.S.P. CFM WATTS CFM WATTS CFM WATTS CFM WATTS.0...0.50.60.70.80 9 905 895 865 80 85 790 765 00 90 85 75 60 55 5,,00,075,060,0 970 9 875 75 65 5 5 25 05 85 65,0,290,275,25,80,0,060,0 580 550 5 50 90 65 0 5,555,55,55,95,,25,0,60 650 6 600 570 550 550 5 90 8
Evaporator Blower Air Flow Data MODEL # PGB08 075/00/25/50X VOLTAGE 8 2 8 2 MOTOR SPEED LOW LOW HIGH HIGH E.S.P. CFM WATTS CFM WATTS CFM WATTS CFM WATTS.0...0.50.60.70.80,00,85,55,5,295,25,0,60 650 60 585 570 5 505 80 55,680,65,605,50,70,0,60, 7 70 670 65 605 570 50 50,7,685,65,580,55,,90,50 75 7 695 660 625 595 565 55,970,905,8,725,6,50,90,0 80 790 750 70 670 65 600 570 MODEL # PGB060 00/25/50X VOLTAGE 8 2 8 2 MOTOR SPEED LOW LOW HIGH HIGH E.S.P. CFM WATTS CFM WATTS CFM WATTS CFM WATTS.0...0.50.60.70.80,60,585,570,55,505,50,00,50 85 780 775 760 7 75 700 680,870,8,805,770,70,670,60,560 90 95 890 870 80 80 780 750 2,025 2,005,955,925,870,805,750,700,00,0 990 960 90 895 855 85 2,285 2,265 2,95 2, 2,05,965,900,80,70,50,090,060,000 965 9 895 WET COIL PRESSURE DROP NOTE: MODEL IN. W.C. (H 2 O) MODEL IN. W.C. (H 2 O) PGB02 PGB0 PGB06.09.0.2.2.5 PGB02 PGB08 PGB060 ) ALL BLOWER DATA IS DRY COIL WITHOUT FILTER, A.08 FOR FILTER 2) WET COIL PRESSURE DROP RANGE FOR COOLING TONNAGE IN TWO DIFFERENT CABINETS, LARGER PRESSURE DROP CORRESPONDS TO THE SMALLER CABINET. EX: (SMALL CABINET) PGB0075.2 W.C., (MEDIUM CABINET) PGB000.0 W.C..09.2..5 9
Lifting Detail Figure Roof Curb Figure 5 Roof Curb Figure 7 0
Base Rail Detail Figure UNIT A B C D 2 Ton (Small) 52 9 2 /6 2 2 2 Ton (Medium) 52 9 2 /6 2 5 Ton (Large) 55 8 8 5 2 Outside Slab Installation Figure 6 Economizer & Fresh Air Damper (Optional) Figure 8 UNIT A B C 2 TON (Small) 7 /6 2 TON (Medium) 9 5 5 /6 /2 5 TON (Large) 2 7 /6
Accessory Model Identification SQRPG CHASSIS SIZE # SMALL CHASSIS #2 MEDIUM CHASSIS # LARGE CHASSIS Accessory Selection Table UNIT TYPE PGC Roof curb PGED Economizer, downflow PGEH Economizer, horizontal PGMD Manual damper PGMDM Motorized damper SQRPG Square to round converter CDK Concentric converter (flush mount) PGFR Filter rack, downflow MODEL DESCRIPTION CHASSIS # CHASSIS #2 CHASSIS # PGC Roof Curb PGC2 Roof Curb PGC Roof Curb PGED Downflow Economizer PGED2 Downflow Economizer PGED Downflow Economizer PGEH Horizontal Economizer PGEH2 Horizontal Economizer PGEH Horizontal Economizer PGMD Manual Fresh Air Damper PGMDM Motorized Fresh Air Damper SQRPG Square To Round Converter SQRPG2 Square To Round Converter SQRPG Square To Round Converter CDK2 Concentric Converter CDK Concentric Converter PGFR Downflow Filter Rack PGFR2 Downflow Filter Rack PGFR Downflow Filter Rack NOTES: ) SEE FIGURES 5, 7 and 8 (PAGE 0) FOR DETAILS. 2) SEE DIMENSIONS TABLE (PAGE ) FOR MODELS IS CHASSIS, 2 and. Goodman Manufacturing Company, L.P., reserves the right to discontinue, or change at any time, specifications or designs without notice or without incurring obligations. Copyright 0 Goodman Manufacturing Company, L.P. Houston, Texas Printed in the USA. Goodman products are made proudly in the USA. 2