SOLID QUALITY & PROVEN DURABILITY
SEPARATOR CURB L62 Female End 18 inch length Each pallet holds 211 lf of Separator. Each Separator Unit weighs over 34 lbs. A conveyor can be hooked to a truck for long lengths of Separator. Using our Hook & Bolt System you can install nearly 1000 ft. per hour at temporary installations. L60 Separator Unit 40 length 10 5/8 inch width 3 1/2 inch height To depict profile of curb SNAP IN A L65 REFLECTIVE ARC FS 50 Bolt, Molly & Washer for on Asphalt Flex with Stabilizing Bar Q 640 Marker Puller FS 51 Anchor Wedge Concrete L61 Male End 18 inch length Securing Arcs For panel stability For permanent installations a hole is drilled into the road surface and the Separator is secured to the road using a bolt and molly. Tighten to the road until the washer begins to bend. Our curb doesn t crack or shatter. Reboundable markers slide into place quickly with the panel puller. Spacing of markers is as close as every meter. THE ONE AND ONLY WITH OVER 20 YEARS ROAD EXPERIENCE
BIG BOLLARD TM High Target Value + Clear Visibility = Motorist Respect L125 BIG BOLLARD 40 inch height mounted in QWICK KURB(R) The BIG BOLLARD TM is the largest reboundable bollard on the market with a 15" circumference. The rubber flex allows the BIG BOLLARD to rebound on impact. BIG BOLLARD achieves the traffic engineer's requirement for motorist compliance when narrow posts won t. THEIRS THEIRS OURS OURS Also available in 36 height. NARROW FEEBLE POST DON T WORK! - use BIG BOLLARD TM
L104 MEGA MARKER TM L 50 11 7/8 x 10 L 54 39 3/8 x 10 5/8 The Air Marker offers high target value both day and night. Each side of the Air Marker has 232 square inches of Hi-Intensity retro-reflective sheeting. GET THE MESSAGE ACROSS WITH MEGA MARKERS
RAILROAD SAFETY Proclaimed the least expensive safety measure to significantly improve grade crossing safety. QWICK KURB is the only median separator system that has been involved in a FRA sponsored test. Proven to reduce motorist drive arounds over 75%. Combination of formidable markers and raised mountable separator deters drive-arounds, and still allows emergency vehicles a way out. Average installation time per crossing is just three hours. The raised separator is the most cost efficient Supplemental Safety Measure available for proposed Quiet Zones. THE ONLY SYSTEM SPONSORED FOR TEST BY STATE & FRA
Median Edgeline
Interstate Roundabout
THE ONE AND ONLY LANE SHIFTING CONVEYOR Nightly lane closures, daily shifts of HOV lanes. The conveyor picks up the curb and transfers it up to 20 feet laterally. Conveyor attaches to a standard one ton Truck. Separator is moved at up to 4 miles per hour with a two-man crew. Separator system gives superior visual guidance in comparison to barrier wall. THE ONLY AUTOMATED LANE SHIFT SYSTEM
WORK ZONE AHEAD SUPERIOR WET NIGHT REFLECTIVITY Each piece of separator securely joins to the next using a metal hook and tongue system. It is not necessary to fasten the system to the road way. It is quick to install and relocate and it is easy to store for the next job. Curb weights about 10 lb per foot. Bright profile reflective arcs significantly reduce the need for any temporary traffic markings. Markers clearly guide motorist through work zones. Markers rebound on impact without dislodging separator. INSTALL UP TO 1000 LF PER HOUR WITH A 4 MAN CREW
Install Replacement Marker On Existing Rubber Flex in a Minute! SAVE MAINTENANCE MONEY WITH OUR 2 PART MARKER
Some claim they are Equal. They are not! Roadway Traffic Hazard Warranty - 5 Years Separator, Reflective Arcs and Asphalt Mollies For fixed installations of products at specified areas, QWICK KURB, INC. (hereinafter QWICK KURB ) provides a comprehensive Warranty for Product Performance (that is, the covered products will maintain their functionality) to the original purchaser for a period of five (5) years. Subject to limitations stated herein, the Warranty covers listed products rendered non-functional even if caused by normal vehicular roadway traffic. A separate Warranty may cover damage from snowplows. This Warranty does not apply to a competitive bid project unless the conditions of the bid require the Warranty of all bidders. SPECIFIED LOCATION This Warranty applies to units on fixed installations, and is effective provided that QWICK KURB gives specific written coverage identifying the installation by location. To avail itself of this Warranty, the purchaser must, before purchase is made, supply QWICK KURB with a detailed drawing of the traffic design and specific location of the intended installation, and receive this Warranty with that location identified below and with the specific signature from QWICK KURB that the Warranty is approved. The Warranty in no way implies approval or an opinion of the suitability or configuration of the installation or behavior of traffic at the location; the Warranty is confined strictly to covered products. Units at the installation identified below are approved under this Warranty. NOTE: it is not necessary for experienced users under annual contracts to identify projects. In the lines above, describe the location and installation in detail (state, county, city, road name, and position on the road),. COVERED PRODUCTS: The products covered by this Performance Warranty are new QWICK KURB units as follows: L60 KURB; L61 and L62 END KURB; L65 Reflective Arc ; S65 Securing Arc and FS50 Cloverleaf Molly for asphalt. TERM: The five (5) year term of this Warranty extends from the date product was shipped to the initially registered purchaser including such purchaser whose purchase is made through an authorized QWICK KURB dealer or distributor. REPLACEMENT OR REPAIR During the Warranty period, the obligation of QWICK KURB is limited to repairing or replacing, as QWICK KURB shall elect, any covered unit. Purchaser shall give QWICK KURB reasonable opportunity to examine the installed, non-functional units on site, unless Purchaser determines that non-functional units need to be removed immediately for safety reasons. In this exception Purchaser shall document promptly in written form a description of the product failure to include if possible photographs of the nonfunctional units while still installed, and Purchaser will store such products for examination by QWICK KURB. REPLACEMENT SCHEDULE QWICK KURB will replace or repair non-functional units by granting price credits against current prices as follows: through first two years 100%, i. e., free of charge; third year through fifth year 60%. WHAT IS NOT COVERED This Warranty does not cover units moved to a location different than the original installation; storage, shipment, removal, maintenance or installation done in a manner inconsistent with the instructions in the QWICK KURB Installation Manual(s), including use of achoring devices other than those QWICK KURB supplies unless pre-approved in writing by QWICK KURB ; color fading; modifications to the units not performed by authorized QWICK KURB technical personnel; damage from but not limited to metal-tracked equipment, chemical or other spills, vandalism, acts of God, etc.; units where QWICK KURB vertical markers are used at intervals greater than seven meters; vertical markers and flexes. Except as described herein, QWICK KURB makes no express or implied Warranty whatsoever with respect to product maintenance or suitability of installation. QWICK KURB disclaims any liability for incidental, or consequential damages to the extent permitted by law. The customer remedies described herein shall be exclusive of any other remedies. The Warranties described herein are for the exclusive benefit of the initially registered purchaser, and are not assignable except as provided otherwise (sales through dealers may be assignable at locations specified above). Warranty approved by, 200 President or Plant Manager Workmanship and Materials Warranty - 2 Years All units QWICK KURB, INC. ( QWICK KURB ) warrants each new unit to be free from defects in workmanship and material for a period of two (2) years for fixed installations from the date of shipment to the initially registered purchaser. During this warranty period, the obligation of QWICK KURB is limited to repairing or replacing, as QWICK KURB may elect, any part or parts of such product determined to be defective in material and/or workmanship. This warranty does not extend to any unit which has been relocated to an installation away from its original installation, which has been subjected to abuse, misuse, improper installation, which has been inadequately maintained or stored, or which has been modified by anyone other than QWICK KURB factory or authorized warranty service personnel. This warranty does not cover travel expenses, the cost of specialized equipment for gaining access to the product, or labor charges for removal, handling or re-installation of the product. THERE ARE NO OTHER WARRANTEES, EXPRESS OR IMPLIED, INCLUDING BUT NOT LIMITED TO, ANY IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE. IN NO EVENT, SHALL QWICK KURB BE LIABLE FOR ANY LOSS OF PROFITS OR ANY INDIRECT OR CONSEQUENTIAL DAMAGES ARISING OUT OF ANY SUCH DEFECT IN MATERIAL OR WORKMANSHIP. AS SEEN IN THE 2007 NATIONAL ROADWAY SAFETY AWARDS BEST PRACTICES SPONSORED STUDIES 1994 BAST Report on Lateral impact 1997 Railroad Sealed Corridor 1998 Median Barriers Evaluation 2000 Driver Behavior Study 2000 Northeast Grade Crossing 2000 Merging in Construction Zone 2001 Dynamic Test Lane Separator 2003 Railroad Traffic Separators 2005 Use report of Separator System 2005 Low Cost Safety Improvements 2006 Northeast Expressway Project 2007 National Roadway Award DETAILS AVAILABLE UPON REQUEST OUR PROMISE TO YOU WITH 20 YEARS OF EXPERIENCE
Solving your Delineator Maintenance Problems BEFORE JUST SO YOU KNOW! The original German version of the system, Klemmfix, has been used on the Autobahn since the mid-1980s. In 1995 QWICK KURB began operating in the United States. These raised separator systems are installed worldwide, making them subject to countless vehicle impacts in all weather conditions and climates, from the frigid winter winds in Michigan and Canada to the hot summer desert air of New Mexico. So we know that our product holds up, and we know that it holds up well. AFTER 6 MONTHS LATER (WITH NO MAINTENANCE) QWICK KURB, INC. 1916 US 41 South Ruskin, FL 33570 (813) 645-5072 www.qwickkurb.com U. S. Distributor and Licensee for horizont klemmfix Note: All measurements in this folder are approximate as plastic expands and contracts slightly with temperature variations.