TERMINOLOGIES & EXPLANATIONS TJM XGS has introduced a selection of high quality leaf springs for a number of vehicles. These springs include clip liners, slipper pads, and are spear cut with tapered ends and full military wrap (where fitment permits) These springs have been researched, developed and undergone extensive testing. Note: Some vehicle application have a different drivers & passenger side spring, this is to compensate for uneven vehicle weight distribution, weight of the driver or to compensate for any manufacturers chassis issues. As a guide the drivers side spring will be taller in free camber. Always measure the vehicle vertically from the centre of wheel/hub to guard at ride height before removing old springs. GVM - Gross Mass This is set by the vehicle manufacturer, the GVM of a vehicle is determined by wheel, tyre, axle, differential, emissions and suspension specifications. Exceeding GVM ratings can have legal and safety implications and is not recommended unless an approved DOTARS GVM upgrade kit has been fitted. are sometimes labelled (DS) drivers side & (PS) passengers side. These springs are individually designed to counteract uneven weight distribution in certain vehicles. As a guide the drivers side spring will be taller in free camber although this is not always the case. Always measure vehicle before removing old springs. Castor Correction Castor correction kits are required to correct castor alignments to induce positive castor after a raised suspension kit has been installed. consist of 4 eccentric bushes to fit the front trailing arms in.5 degree & 3.5 degree. A wheel alignment is required whenever any adjustment has been done to a vehicles suspension. LBA - Load Bearing Accessories Load Bearing Accessories are "add ons" fitted to the vehicle that attract additional weight (ie bullbars, sidebars, winches tyre carriers, roof racks, additional fuel or water tanks etc). These accessories may affect a vehicles load carrying capacity, ride and handling and should be considered when deciding on the appropriate suspension package. OE - Original Equipment As supplied by the manufacturer of the vehicle. Trim Packers In both steel (for leaf springs) & polyurethane (for coil springs) are designed to alleviate vehicle lean and in most cases will raise the vehicle, with the exception of a underslung leaf spring design. Stone Guards, Dust Boots & Strengthening Brackets In certain applications these are a requirement, failure to do so may void warranty. Installation Forms It is a warranty requirement that a TJM XGS Installation Form (p/n 66INSTALL) be completed for every suspension installation. All areas pertaining to the vehicle and suspension products fitted are to be filled out correctly and relevant copies forwarded. Failure to do this may void warranty. Determining Specifications For Height & Load Carrying Capacity TERMINOLOGIES & EXPLANATIONS The most important things to remember when determining vehicle specific suspension is:
) The model of the vehicle. ) Load Bearing Accessories fitted to the vehicle. 3) Constant Load on the vehicle or will be carried by the vehicle. 4) The approximate ride height required by the customer. Spring Lowered Raised Raised Heavy Duty Extra Heavy Duty Spring Description Lowered approx 0 to 0mm from standard also has an increased spring rate, these will generally be sold in a complete SUV kit. Raised leaf springs are similar to OE spring rate. Raised coil springs have generally 0-30% more spring rate than OE. Raised height heavy duty spring with increased spring rate to handle an additional load (passenger load and luggage weight). Raised height heavy duty spring with an increased spring rate. Designed to maintain ride height with a constant load up to vehicle manufacturers GVM rating. Suggested Fitting Times Please find listed below suggested fitment times as a guide only. Additional time may be required due to existing modifications or accessories already fitted to the vehicle which may interfere with the fitment of new suspension. Fitment of 4 Fitment of 4 Leaf Springs Fitment of pr Fitment of pr Torsion Bars Fitment of pr Struts approx hours approx 3 hours approx hour approx.5 hours approx.5 hours Fitment of Castor Correction Kit Fitment of Steering Damper approx hours approx 0.5 hours Fitment of Polyair Spring System approx -.5 hours Fitment of Bellows System approx 3-3.5 hours Please Note: Loads as published are approximate only and do not constitute legal upgrading of the GVM carrying capacity of the vehicle. Please refer to individual load specifications. All suspension development has been carried out on Australian specifications models, some differences may exist with the same model in another country. Overseas customers will need to make allowances for these possible differences. 3
XGS APPLICATION GUIDE CONTENTS Page Application Page Application -3 Terminologies 45 Nissan Patrol GU Y6 LWB 4 Contents 46 Nissan Patrol GU Ute Coil Leaf 5 Ford Courier 4wd All 87-06 47 Suzuki Grand Vitara 98-05 6 Ford Ranger 4wd All 006-0/0 48 Suzuki Grand Vitara 05+ 7 Ford Ranger 4WD 0/0+ PX 49 Suzuki Jimny 98+ 8 Great Wall V40/V00 50 Toyota Surf/4Runner IFS Leaf 9 Holden Rodeo 4wd 88-03 5 Toyota Surf/4Runner IFS Coil 89-96 0 Holden Rodeo 4wd 03-08 5 Toyota Surf/4Runner Coil 996+ Holden Colorado RC 4wd 008-5/0 53 Toyota Hilux Leaf Leaf 979-997 Holden Colorado RG 4wd 0+ 54 Toyota Hilux IFS Leaf 985-005 3 Hyundai Terracan 55 Toyota Hilux 50 Series 005+ 4 Isuzu D Max 4wd 008-6/0 56 Toyota Land Cruiser 40 Series SWB 5 Isuzu D max 4wd 0+ 57 Toyota Land Cruiser 40 Series LWB 6 Jeep Cherokee XJ 4/994-9/00 58 Toyota Land Cruiser 60/6 Series 7 Jeep Cherokee KJ/KK 00 on 59 Toyota Bundera 8 Jeep Grand Cherokee 999 on 60 Toyota Land Cruiser 73/74 Series MWB 9 Jeep Wrangler TJ 96-07 6 Toyota Land Cruiser 75 Series LWB 0 Jeep Wrangler JK 007 on 6 Toyota Land Cruiser 76 Series Landrover Defender 90 series 63 Toyota Land Cruiser 78/79 Series Landrover Defender 0 84-9 64 Toyota Land Cruiser 80/05 Series 3 Landrover Defender 0 99 on 65 Toyota Land Cruiser 80/05 Series Hi 4 Landrover Defender 30 994 on 66 Toyota Land Cruiser 00 Series IFS 5 Landrover Discovery Ser & Range Rover 67 Toyota Land Cruiser 00 Series 6 Landrover Discovery Ser & 3 68 Toyota Prado 90 Series 7 Mazda B ser & Bravo 4wd 87-06 69 Toyota Prado 0 Series 8 Mazda BT50 4wd 006-0/0 70 Toyota Prado 50 Series 9 Mazda BT-50 4WD /0+ 7 Toyota FJ Cruiser 0+ 30 Mitsubishi Challenger 4wd 00-06 7 Volkswagen Amarok 4WD 3 Mitsubishi Challenger 00 on 73 Toyota Hilux WD 005-9/0 3 Mitsubishi Pajero 9-000 74-76 Coil Spring Specifications 33 Mitsubishi Pajero SWB 000 on 77 Leaf Spring Specifications 34 Mitsubishi Pajero LWB 000 on 78 Torsion Bar Specifications 35 Mitsubishi Triton 4wd 96-06 79 Shock Absorber Specifications 36 Mitsubishi Triton 4wd 06 on 80 U-Bolt & Steering Dampers Specifications 37 Nissan Navara 4wd D 97 on 8 Poly Bush Kit Listing & Kit Contents 38 Nissan Navara D40 005 on 8 Repalcement Poly Air Bags 39 Nissan Pathfinder R50 95-05 83-84 Poly Air Spare Parts 40 Nissan Pathfinder R5 005 on 85-86 Characteristics 4 Nissan Patrol GQ Y60 SWB 87-88 XGS Features 4 Nissan Patrol GQ Y60 LWB 89 How to Measure Springs/Shocks 43 Nissan Patrol GQ/GU Coil Cab Chassis 90 Warranty Statement 44 Nissan Patrol GQ/GU Off Road Hi 4
FORD Courier 4WD All 987-006 Part and Location Description Part # Qty Req Per Std + 40mm 650GE46ZD Shock Mount Reinforcing Bracket Kit 663SBP Std + 40mm 650GE46ZD Torsion Bar Size Heavy Duty (Supplied As A Pair) 7mm x 97mm 657008 Leaf Springs Raised - 00kg Heavy Duty Raised - 400kg 40mm 40mm 65345G 653RRHD45G Bush Complete Leaf Spring & Shackle Kit Poly 779507K Shackles & Pins Greasable Shackles Greasable Pin 656387G 6560GP U-Bolts 4mm x 83mm x 30mm (inc Deep Nuts) 77500 4 Polyair To Suit 000 On Std & Rsd 6575698 Kit Stage. & rear shocks, raised leaf springs, complete leaf spring bush kit, shackles, pins, U bolts and reinforcing bracket Stage. and rear shocks, torsion bars, heavy duty raised leaf springs, complete leaf spring bush kit, shackles, pins and U bolts 5
FORD Ranger 4WD All 006-0/0 Part and Location Description Part No Qty Req Per Std + 40mm 650GE46ZD Shock Mount Reinforcing Bracket Kit - Required 663SBP Std + 40mm 650GE46ZD Torsion Bar Leaf Springs Heavy Duty (Supplied As A Pair) 7mm x 04mm 65708 Size Raised - 00kg 40mm 65346Z Heavy Duty Raised - 300kg 40mm 653346Z Extra Heavy Duty Raised - 400kg 40mm 653446Z Bush Shackles & Pins Complete Leaf Spring and Shackle Kit (bolt type 4mm fixed pin) Poly 779546K U-Bolts 656387G 4mm x 88mm x 00mm (inc Deep Nuts) 77504 4 Greasable Shackles Greasable Pin (Bolt With 4mm Pin) 65600GP Polyair To Suit Standard Height 6575698 Kit Bellows To Suit Standard Height 65856 Kit Bellows To Suit Raised Height 65856R Kit This vehicle develops a driveline vibration upon acceleration up to approximately 5klm/h when raised more than 30mm. Lowering the centre bearing position can help reduce the vibration. Replacing the factory piece tailshaft with an aftermarket single piece tailshaft seems to cure this issue. Stage. & rear shocks, raised leaf springs, complete leaf spring bush kit, shackles, pins, U bolts and reinforcing bracket Stage. and rear shocks, torsion bars, heavy duty raised leaf springs, complete leaf spring bush kit, shackles, pins U bolts and reinforcing bracket 6
Ford Ranger PX 4WD 0/0+ Mounts Top Strut Mount TBA Qty Req Per Std + 40mm 659GETD Std + 40mm 650GE46ZD Coils Leaf Springs Raised 40mm 770FRT - 50kg - Heavy Duty Raised 40mm 770FRHDT 50kg + Raised - 50kg 40mm 653T Heavy Duty Raised - 300kg 40mm 6533T Extra Heavy Duty Raised - 400kg 40mm 6534T Bush Complete Leaf Spring & Shackle Kit Poly 779545K Shackles & Pins U-Bolts Greasable Shackles 656G Greasable Pins USE OE 4mm x 6mm x 80mm (inc Deep Nuts) 77504 4 Bellows To Suit Standard Height & Raised up to 65857 Kit 40mm Bellows To Suit 50mm + Raised 65857R Kit This vehicle develops a driveline vibration upon acceleration up to approximately 5klm/h when raised more than 30mm. Lowering the centre bearing position can help reduce the vibration. Replacing the factory piece tailshaft with an aftermarket single piece tailshaft seems to cure this issue. Stage. struts and rear shocks, raised coils and raised H/D leaf springs, complete leaf spring and shackle bush kit, shackles and U bolts Stage. struts and rear shocks, heavy duty raised coils and extra heavy duty leaf springs, complete leaf spring and shackle bush kit, shackles pins and u bolts 7
GREAT WALL V40/V00 4WD All 009 on Qty Req Per Std + 40mm 650GE7D Torsion Bars Std + 45mm 650GE3MD Size Heavy Duty (Supplied As A Pair) 30mm x 4mm 65707 Leaf Springs Raised - 50kg Heavy Duty Raised - 300kg 45mm 45mm 6533G 653RRHD3G Bush Complete Leaf Spring & Shackle Kit Poly 779509K Shackles & Pins Greasable Shackles Greasable Pins 656386G 65600GP U-Bolts 4mm x 88mm x 00mm (inc Deep Nuts) 77504 4 Polyair To Suit Standard Height 6578095 Kit Polyair To Suit Raised Height 657895 Kit Bellows To Suit Standard Height 658505 Kit Bellows To Suit Raised Height 658505R Kit Stage. & rear shocks, raised leaf springs, complete leaf spring bush kit, shackles, pins and U bolts Stage. and rear shocks, torsion bars, heavy duty raised leaf springs, complete leaf spring bush kit, shackles, pins and U bolts 8
HOLDEN Rodeo 4WD TFS / R7 / R9 988-003 Qty Req Per Std + 40mm 650GE3OD Torsion Bars Std + 45mm 650GE3MD Size Heavy Duty (Supplied As A Pair) 6mm x 00mm 65700 Leaf Springs Bush Raised - 50kg Heavy Duty Raised - 300kg 45mm 653BRR3L 45mm 653RRHD30S Complete Leaf Spring & Shackle Kit Poly 779509K Shackles & Pins Greasable Shackles Greasable Pins 656386G 65600GP U-Bolts 4mm x 83mm x 95mm (inc Deep Nuts) 77504 4 Model Polyair To Suit Standard Height R7 / R9 6575903 Kit Stage. & rear shocks, raised leaf springs, complete leaf spring bush kit, shackles, pins and U bolts Stage. and rear shocks, torsion bars, heavy duty raised leaf springs, complete leaf spring bush kit, shackles, pins and U bolts 9
HOLDEN Rodeo 4WD RA 003-008 Qty Req Per Std + 40mm 650GE3OD Std + 45mm 650GE3MD Torsion Bars Size Heavy Duty (Supplied As A Pair) 30mm x 4mm 65707 Leaf Springs Raised - 50kg Heavy Duty Raised - 300kg 35-50mm 35-50mm 6533G 653RRHD3G Bush Complete Leaf Spring & Shackle Kit Poly 779509K Shackles & Pins Greasable Shackles Greasable Pins 656386G 65600GP U-Bolts 4mm x 88mm x 00mm (inc Deep Nuts) 77504 4 Polyair To Suit Standard Height 6578095 Kit Polyair To Suit Raised Height 657895 Kit Bellows To Suit Standard Height 658505 Kit Bellows To Suit Raised Height 658505R Kit Stage. & rear shocks, raised leaf springs, complete leaf spring bush kit, shackles, pins and U bolts Stage. and rear shocks, torsion bars, heavy duty raised leaf springs, complete leaf spring bush kit, shackles, pins and U bolts 0
HOLDEN Colorado 4WD 008-05/0 Qty Req Per Std + 40mm 650GE3OD Torsion Bars Std + 45mm 650GE3MD Size Heavy Duty (Supplied As A Pair) 30mm x 4mm 65707 Leaf Springs Bush Raised - 50kg 35-50mm 6533G Heavy Duty Raised - 300kg 35-50mm 653RRHD3G Complete Leaf Spring & Shackle Kit Poly 779509K Shackles & Pins Greasable Shackles Greasable Pins 656386G 65600GP U-Bolts 4mm x 88mm x 00mm (inc Deep Nuts) 77504 4 Polyair To Suit Standard Height 6578095 Kit Polyair To Suit Raised Height 657895 Kit Bellows To Suit Standard Height 658505 Kit Bellows To Suit Raised Height 658505R Kit Stage. & rear shocks, raised leaf springs, complete leaf spring bush kit, shackles, pins and U bolts Stage. and rear shocks, torsion bars, heavy duty raised leaf springs, complete leaf spring bush kit, shackles, pins and U bolts
HOLDEN Colorado RG 4WD 0+ Qty Req Per TBA TBA Coil springs Size TBA Leaf Springs TBA TBA Bush Complete Leaf Spring & Shackle Kit Poly TBA Shackles & Pins Greasable Shackles TBA Greasable Pins TBA U-Bolts TBA 4 Polyair To Suit Standard Height Kit Polyair To Suit Raised Height Kit Bellows To Suit Standard Height Kit Bellows To Suit Raised Height Kit Stage. & rear shocks, raised leaf springs, complete leaf spring bush kit, shackles, pins and U bolts Stage. and rear shocks, torsion bars, heavy duty raised leaf springs, complete leaf spring bush kit, shackles, pins and U bolts
Hyundai Terracan 00-008 Qty Req Per Std + 40mm 650GE5AD Std + 40mm 650GE88AD Torsion Bars Length Heavy Duty (Supplied As A Pair) 6mm x 8mm 65709 Standard- 00kg 0mm 770RS5A Raised (Progressive) - 00kg 40mm 770RP5A Polyair To Suit Standard Height 655694 Kit Polyair To Suit Raised Height 655794 Kit Stage. and rear shocks, raised coil springs. Stage. and rear shocks, torsion bars, heavy duty raised coils. 3
ISUZU D Max 4WD All 008-6/0 Qty Req Per Std + 40mm 650GE3OD Std + 45mm 650GE3MD Torsion Bars Size Heavy Duty (Supplied As A Pair) 30mm x 4mm 65707 Leaf Springs Bush Raised - 50kg 35-50mm 6533G Heavy Duty Raised - 300kg 35-50mm 653RRHD3G Complete Leaf Spring & Shackle Kit Poly 779509K Shackles & Pins Greasable Shackles 656386G Greasable Pins 65600GP U-Bolts 4mm x 88mm x 00mm (inc Deep Nuts) 77504 4 Polyair To Suit Standard Height 6578095 Kit Polyair To Suit Raised Height 657895 Kit Bellows To Suit Standard Height 658505 Kit Bellows To Suit Raised Height 658505R Kit Stage. & rear shocks, raised leaf springs, complete leaf spring bush kit, shackles, pins and U bolts Stage. and rear shocks, torsion bars, heavy duty raised leaf springs, complete leaf spring bush kit, shackles, pins and U bolts 4
ISUZU D MAX 4WD 0+ Qty Req Per TBA TBA Coil springs Size TBA Leaf Springs TBA TBA Bush Complete Leaf Spring & Shackle Kit Poly TBA Shackles & Pins Greasable Shackles TBA Greasable Pins TBA U-Bolts TBA 4 Polyair To Suit Standard Height Kit Polyair To Suit Raised Height Kit Bellows To Suit Standard Height Kit Bellows To Suit Raised Height Kit Stage. & rear shocks, raised leaf springs, complete leaf spring bush kit, shackles, pins and U bolts Stage. and rear shocks, torsion bars, heavy duty raised leaf springs, complete leaf spring bush kit, shackles, pins and U bolts 5
JEEP XJ Cherokee 4WD 4/994-9/00 Part and Location Description Approx Part No Qty Req Per Std + 40mm 650GE36P Std + 40mm 650GE36P Steering Damper Heavy Duty Note: May Need To Use 4mm Packer Behind The Mount Ext / Com 500 / 30 65040 Raised - 50kg - 40mm 770FR36P Leaf Springs Bush Raised - Comfort NOTE: Gearbox Spacer Maybe Required 50mm 65336P Panhard Rod Poly 779703K Complete Leaf Spring & Shackle Kit Poly 77956K U-Bolts mm x 80mm x 70mm (inc Deep Nuts) 7750 4 Polyair To Suit Raised Height 6534007 Kit Minimum weight requirement for HD front coil spring part numbers is a steel bullbar and winch & Gold Edition Shocks,, Steering Damper, Leaf Springs, Leaf Spring Bush Kit & U-Bolts 6
JEEP Cherokee 4WD KJ Limited 00-007 Qty Req Per Std + 40mm 659GE37UD Std + 40mm 650GE37UD Raised - 50kg - Heavy Duty Raised - 50kg + 30mm 30mm 770FR37U 770FRHD37U Raised - 50kg 40mm 770RR37U Polyair To Suit Standard Height 655495 Kit Polyair To Suit Raised Height 655695 Kit and rear shocks, front and rear coils JEEP Cherokee 4wd KK Limited/Sport 008 on Qty Req Per Std + 30mm 659GE37UD Std + 30mm 650GE37UD Raised - 50kg - 30mm 770FR36K Raised - 50kg 30mm 770RR36K and rear shocks, front and rear coils 7
JEEP Grand Cherokee WG / WJ 999-005 Qty Req Per Std + 40mm 650GE37D Std + 40mm 650GE37D Raised - 50kg - 40mm 770FR37D Raised - 50kg 40mm 770RR37D Polyair To Suit Standard Height 659494 Kit and rear shocks, front and rear coils JEEP Grand Cherokee WH 005-0 Qty Req Per Std + 30mm 659GE37ID Std + 30mm 650GE37ID Raised - 50kg - Heavy Duty Raised - 50kg + 30mm 30mm 770FR37I 770FRHD37I Raised - 50kg - Heavy Duty Raised - 00kg + 30mm 30mm 770RR37I 770RRHD37I Polyair To Suit Standard Height 65549 Kit and rear shocks, front and rear coils 8
JEEP Wrangler TJ 996-007 Qty Req Per Std + 40mm 650GE36X Std + 40mm 650GE36X Steering Damper Steering Damper 65040 Raised - 50kg - 40mm 770FR36X Raised - 00kg 40mm 770RR36X P.N. Gear box spacers may be required when raising suspension height as it may cause a driveline vibration. Bush Panhard Rod Poly 779703K Kit Polyair To Suit Raised Height 40mm 65569 Kit and rear shocks, front and rear coils $,98.00 9
JEEP Wrangler JK (SWB & LWB) 007 on Ext / Com Qty Req Per Std + 40mm 650GE36Z Std + 40mm 650GE36Z Steering Damper Steering Damper 65040 (3 DOOR) SWB Raised - 40kg - 40mm 770FRSD36Z Raised - 00kg 40mm 770RRS36Z (5 DOOR) LWB Raised - 40kg - 40mm 770FRLD36Z Raised - 50kg 40mm 770RRL36Z Polyair To Suit Standard Height (OE Coil only) Polyair To Suit Raised Height (TJM Coil only) 50mm 65694 Kit 65894 Kit and rear shocks, front and rear coils. 0
LANDROVER Defender 90 Series Qty Req Per - Long Travel 50mm RSD 75-00mm 650GE38S 650GE80BD - Long Travel 50mm RSD 75-00mm 650GE38S 650GEL38S Steering Damper Ext / Com Steering Damper 680 / 440 6503 Raised - 60kg - Heavy Duty Raised - 60kg + 40mm 40mm 770FR53A 770RS53A Raised - 50kg 50mm 770RR53A Minimum weight requirement for HD front coil spring part numbers is a steel bullbar and winch Note: Due to different gearbox mounts on 998+ models lifting of these vehicles may cause a front driveline vibration. Fitment of double cardan joints will assist in rectifying this issue and rear shocks, front and rear coils and steering damper. $,346.00
LANDROVER Defender 0 County & T/Back 984-99 Qty Req Per - Long Travel 50mm RSD 75-00mm 650GE38S 650GE80BD Steering Damper 50mm RSD 650GE38S - Long Travel 75-00mm 650GEL38S Ext / Com Steering Damper 680 / 440 6503 Bush & Raised (Petrol) - 60kg 40mm 770RS53A Raised (Diesel) - 60kg 40mm 770FR38X Raised (Wagon) - 50kg 40mm 770RR38X Raised (T/Back) - 50kg 40mm 770RR38S Heavy Duty Raised - 300kg 40mm 770RRHD38S Caster Correction 84-93 with KA chassis prefix Panhard Rod Bushes 987 - /999 Poly 779707K Kit inc: Panhard Rod (F&R), Radius Rod To Chassis, Radius Rod to Diff, Upper & Lower Trailing Arm deg 66353 987 - /999 778KIT43A Polyair To Suit Standard Height 6595098 Kit Polyair To Suit Raised Height 6595095 Kit Kit Kit Stage. and rear shocks, front and rear raised coils, steering damper, caster correction bushes, Stage. and rear shocks, front and rear heavy duty raised coils, steering damper, caster correction bushes
LANDROVER Defender 0 / TD5 99 on Qty Req Per - Long Travel 50mm RSD 650GE38S 75-00mm 650GE80BD - Long Travel 50mm RSD 75-00mm 650GE38S 650GEL38S Steering Damper Ext / Com Steering Damper 680 / 440 6503 Polyurethane Bushes & Raised - 60kg 40mm 770FR38S Heavy Duty Raised - 60kg+ 40mm 770FRHD38S Raised - 50kg 40mm 770RR38S Heavy Duty Raised - 300kg 40mm 770RRHD38S Caster Correction 93 on with LA & YA chassis prefix Panhard Rod Bushes 987 - /999 Poly 779707K Kit inc: Panhard Rod (F&R), Radius Rod To Chassis, Radius Rod to Diff, Upper & Lower Trailing Arm deg 6635 Kit Poly 778KIT43A Polyair To Suit Standard Height 6595098 Kit Polyair To Suit Raised Height 6595095 Kit Kit Minimum weight requirement for HD front coil spring part numbers is a steel bullbar and winch Note: Due to different gearbox mounts on 998+ models lifting of these vehicles may cause a front driveline vibration. Fitment of double cardan joints will assist in rectifying this issue Stage. and rear shocks, front and rear raised coils, steering damper, caster correction bushes, Stage. and rear shocks, front and rear heavy duty raised coils, steering damper, caster correction bushes 3
LANDROVER Defender 30 (Dual Cab) Petrol & Diesel 994 on Qty Req Per 50mm RSD 650GE38S - Long Travel 75-00mm 650GE80BD - Long Travel 50mm RSD 75-00mm 650GE38S 650GEL38S Steering Damper Ext / Com Steering Damper 680 / 440 6503 Bush & Raised - 60kg - 40mm 770FR38S Raised Heavy Duty 60 kg + 40mm 770FRHD38S Raised - 00kg 45mm 770RRHD38S Raised Extra Heavy Duty - 400kg 45mm 770RREHD38S Caster Correction deg 6635 Kit Panhard Rod Bushes Poly 779707K Kit inc: Panhard Rod (F&R), Radius Rod To Chassis, Radius Rod to Diff, Upper & Lower Trailing Arm Poly 778KIT43A Kit Polyair To Suit Standard Height (with inner coil) Polyair To Suit Standard Height (with inner coil removed) Polyair To Suit Raised Height (with inner coil removed) 659409 Kit 6595098 Kit 6595095 Kit Note: Due to different gearbox mounts on 998+ models lifting of these vehicles may cause a front driveline vibration. Fitment of double cardan joints will assist in rectifying this issue Stage. and rear shocks, front and rear heavy duty raised coils, steering damper, caster correction bushes 4
LANDROVER Discovery & Range Rover Series Discovery 99-999 & Range Rover 7-95 Qty Req Per - Long Travel 50mm RSD 75-00mm 650GE38S 650GE80BD - Long Travel 50mm RSD 75-00mm 650GE38S 650GEL38S Steering Damper Ext / Com 35mm Heavy Duty Replacement 5 / 308 65B768 Raised (Progressive) - 50kg - 40mm 770FR53A Raised (Progressive) - 50kg 40mm 770RR39E Bush Caster Correction deg 6635 Kit Panhard Rod Bushes Poly 779707K Kit & inc: Panhard Rod (F&R), Radius Rod to Chassis, Radius Rod To Diff, Upper & Lower Trailing Arm Poly 778KIT43A Kit Polyair To Suit Standard Height 659099 Kit Polyair To Suit Raised Height 659096 Kit and rear shocks, front and rear coils and steering damper. $,364.00 5
LANDROVER Discovery Series 999-004 Qty Req Per 50mm RSD 650GE39T 50mm RSD 650GE39T Steering Damper Ext / Com Steering Damper 655 / 395 6550 Raised - 50kg - 40mm 770FR39T Raised (Progressive) - 00kg Heavy Duty Raised (Progressive) - 00kg 40mm 40mm 770RR39E 770RRHD39E Bush Caster Correction deg 66354 Kit Caster Correction 3 deg 66355 Kit Polyair To Suit Standard Height 659896 Kit Polyair To Suit Raised Height 659096 Kit and rear shocks, front and rear coils, castor bushes and steering damper. LANDROVER Discovery Series 3 005 on Qty Req Per Std + 50mm 659GE39V Std + 50mm 659GE39V Raised - 50kg - 40mm 770FR39V Heavy Duty Raised 50kg + 50mm 770FRHD39V Raised (Progressive) 00kg 40mm 770RR39V Heavy Duty Raised (Progressive) 00kg 50mm 770RRHD39V & rear struts, front and rear raised coils. 6
MAZDA B Series & Bravo All 987-006 Qty Req Per Std + 40mm 650GE46ZD Shock Mount Reinforcing Bracket Kit 663SBP Std + 40mm 650GE46ZD Torsion Bar Size Heavy Duty (Supplied As A Pair) 7mm x 97mm 657008 Leaf Springs Raised - 00kg Heavy Duty Raised - 400kg 40mm 40mm 65345G 653RRHD45G Bush Complete Leaf Spring & Shackle Kit Poly 779507K Shackles & Pins Greasable Shackles Greasable Pin 656387G 6560GP U-Bolts 4mm x 83mm x 30mm (inc Deep Nuts) 77500 4 Polyair To Suit 000 On Std & Rsd 6575698 Kit Stage. & rear shocks, raised leaf springs, complete leaf spring bush kit, shackles, pins, U bolts and reinforcing bracket Stage. and rear shocks, torsion bars, heavy duty raised leaf springs, complete leaf spring bush kit, shackles, pins U bolts and reinforcing bracket $,678.00 $,66.00 7
MAZDA BT50 4WD All 006-0/0 Qty Req Per Std + 40mm 650GE46ZD Shock Mount Reinforcing Bracket Kit 663SBP Std + 40mm 650GE46ZD Torsion Bar Size Heavy Duty (Supplied As A Pair) 7mm x 04mm 65708 Leaf Springs Raised 00kg 40mm 65346Z Heavy Duty Raised - 300kg 40mm 653346Z Extra Heavy Duty Raised - 400kg 40mm 653446Z Bush Shackles & Pins Complete Leaf Spring and Shackle Kit (bolt type 4mm fixed pin) Poly 779546K Greasable Shackles 656387G Greasable Pin (Bolt With 4mm Pin) 65600GP U-Bolts 4mm x 88mm x 00mm (inc Deep Nuts) 77504 4 Polyair To Suit Standard Height 6575698 Kit Bellows To Suit Standard Height (Spring Over Diff) 65856 Kit Bellows To Suit Raised Height (Spring Over Diff) 65856R Kit This vehicle develops a driveline vibration upon acceleration up to approximately 5klm/h when raised more than 30mm. Lowering the centre bearing position can help reduce the vibration. Replacing the factory piece tailshaft with an aftermarket single piece tailshaft seems to cure this issue. Stage. & rear shocks, raised leaf springs, complete leaf spring bush kit, shackles, pins, U bolts and reinforcing bracket kit Stage. and rear shocks, torsion bars, heavy duty raised leaf springs, complete leaf spring bush kit, shackles, pins, U bolts and reinforcing bracket kit (Add $0 for extra heavy duty) 8
Mazda BT-50 4WD Models 0/0+ Mounts Top Strut Mount TBA Qty Req Per Std + 40mm 659GETD Std + 40mm 650GE46ZD Coils Leaf Springs Raised 40mm 770FRT Heavy Duty Raised 40mm 770FRHDT Raised - 50kg 40mm 653T Heavy Duty Raised - 300KG 40mm 6533T Extra Heavy Duty Raised - 400kg 40mm 6534T Bush Complete Leaf Spring & Shackle Kit Poly 779545K Shackles & Pins U-Bolts Greasable Shackles 656G Greasable Pins Use OE 4mm x 6mm x 80mm (inc Deep Nuts) 77504 4 Bellows To Suit Standard Height & Raised up to 40mm 65857 Kit Bellows To Suit 50mm + Raised 65857R Kit This vehicle develops a driveline vibration upon acceleration up to approximately 5klm/h when raised more than 30mm. Lowering the centre bearing position can help reduce the vibration. Replacing the factory piece tailshaft with an aftermarket single piece tailshaft seems to cure this issue. Stage. struts and rear shocks, raised coils and raised leaf springs, complete leaf spring and shackle bush kit, shackles, pins and U bolts Stage. struts and rear shocks, heavy duty raised coils and extra heavy duty leaf srings, complete leaf spring and shackle bush kit, shackles pins and u bolts 9
MITSUBISHI Challenger 4WD All 000-006 with coil rear suspension Qty Req Per Std + 40mm 650GE5AD Std + 40mm 650GE5J Torsion Bar Size Heavy Duty (Supplied As A Pair) 307mm 65700 Raised - 50kg 30mm 770RR5J Heavy Duty Raised - 50 kg 30mm 770RRHD5J Polyair To Suit Standard Height 6595893 Kit Polyair To Suit Raised Height 6595093 Kit Stage. and rear shocks, raised coil springs. Stage. and rear shocks, torsion bars, heavy duty raised coils. 30
MITSUBISHI Challenger 4WD All 00 on Qty Req Per Std + 40mm 659GE50LD Std + 40mm 650GE5J Raised - 50kg - 35mm 770FR50L Heavy Duty Raised - 50kg+ 35mm 770FRHD50L Standard - 00kg 770RS5A Heavy Duty Raised - 50kg 40mm 770RP5A Extra Heavy Duty Raised - 00kg 40mm 770RPHD5A Polyair To Suit Standard Height 655694 Kit Polyair To Suit Raised Height 655794 Kit Stage. and rear shocks, raised coil springs. 3
MITSUBISHI Pajero 4WD LWB V6 & TDI Wagon 99-000 Product Description Approx Part No Qty Req Per Std + 40mm 650GE5AD Std + 40mm 650GE5A Torsion Bars Length Heavy Duty (Supplied As A Pair) 6mm x 8mm 6570 Bush Heavy Duty (Supplied As A Pair) 7.5mm x 307mm 65700 NOTE: Check OE Length Before Ordering Standard - 50kg 770RS5A Raised (Progressive) 50kg 40mm 770RP5A Heavy Duty Raised (Progressive) 00kg 40mm 770RPHD5A Panhard Rod 779704K Polyair To Suit Standard Height 6595893 Kit Polyair To Suit Raised Height 6595093 Kit Stage. and rear shocks, raised coil springs. Stage. and rear shocks, torsion bars, heavy duty raised coils. 3
MITSUBISHI Pajero 4WD NM, NP, NS, NT, NW SWB 000 on Mounts Qty Req Per Top Strut Mounts 659THB5S Std + 45mm 659GE5P Std + 45mm 650GE5PD Raised - 60kg- 35mm 770FR5PT Heavy Duty Raised 60kg+ 35mm 770FRHD5P Raised - 00kg Heavy Duty Raised - 00kg 40mm 40mm 770RS5PT 770RR5PT Polyair To Suit Standard Height 6599697 Kit Polyair To Suit Raised Height 6599897 Kit Stage &. struts, rear shocks, front and rear raised coil springs. 33
MITSUBISHI Pajero 4WD NM, NP, NS, NT, NW LWB 000 on Mounts Qty Req Per Top Strut Mounts 659THB5S Std + 45mm 659GE5P Std + 45mm 650GE5PD Raised - 50kg - Heavy Duty Raised 50kg+ 35mm 35mm 770FR5PT 770FRHD5P Standard - 50kg 770RS5PT Raised - 50kg 45mm 770RR5PT Heavy Duty Raised (Progressive) 00kg 45mm 770RRHD5P Polyair To Suit Standard Height 6599697 Kit Polyair To Suit Raised Height 6599897 Kit Stage &. struts, rear shocks, front and rear raised coil springs. 34
MITSUBISHI Triton 4WD MK, MY 996-006 Qty Req Per Std + 45mm 650GE5AD Std + 50mm 650GE87ZD Torsion Bars Size Heavy Duty (Supplied As A Pair) 7.5mm x 370mm 6570 Leaf Springs Raised - 50kg Heavy Duty Raised - 300kg 45mm 50mm 65349A 653RRHD49A Bush Shackles & Pins Spring / Shackle Kit ( TJM Springs) 30mm Spring Eyes Spring / Shackle Kit ( OE Springs) 4mm Spring Eyes Poly Poly 7795K 779540K Greasable Shackles Greasable Pins 656676G 65600GP U-Bolts mm x 77mm x 75mm (inc Deep Nuts) 775006 4 Polyair To Suit Standard Height 657098 Kit Polyair To Suit Raised Height 65798 Kit Stage. & rear shocks, raised leaf springs, complete leaf spring bush kit, shackles, pins and U bolts Stage. and rear shocks, torsion bars, heavy duty raised leaf springs, complete leaf spring bush kit, shackles, pins and U bolts 35
MITSUBISHI Triton 4WD ML, MN 006 on Product Description Approx Part No Mounts Qty Req Per Top Strut Mounts 659THB50L Std + 35mm 659GE50LD Std + 35mm 650GE50LD Coils Raised - 50kg - 30mm 770FR50L Heavy Duty Raised 50kg+ 30mm 770FRHD50L Leaf Springs Raised - 00kg 30mm 65350L Heavy Duty Raised - 300kg 30mm 653350N Bush Complete Leaf Spring & Shackle Kit Poly 779550K Shackles & Pins Greasable Shackles 656676G Greasable Pins Use OE U-bolts mm x 7mm x 70mm (inc Deep Nuts) 77503 4 Correction Components Tailshaft Spacer Kit ( x mm Spacer, x Spring Wedges, 4 x Bolts, Nuts, Spring Washers) 653TSK50L Polyair To Suit Raised Height 657798T Kit Bellows To Suit Standard Height 6585 Kit Bellows To Suit Raised Height 6585R Kit s fitted with a factory piece tailshaft seem to develop a driveline vibration upon acceleration up to approximately 5klm/h when raised more than 30mm. If the vehicle is fitted with a factory piece tailshaft, replacing it with an aftermarket single piece tailshaft seems to minimise this problem. When raising Triton models with a piece tailshaft, a tailshaft spacer needs to be installed between the diff flange & tailshaft flange to centralise the centre bearing. This will NOT fix any vibration issues. This prolongs the life of the centre bearing. Stage. struts and rear shocks, raised coils and raised leaf springs, complete leaf spring and shackle bush kit, shackles and U bolts Stage. struts and rear shocks, heavy duty raised coils and heavy duty leaf srings, complete leaf spring and shackle bush kit, shackles and u bolts 36
NISSAN Navara 4WD D 997 on Qty Req Per Std + 40mm 650GE08QD Std + 40mm 650GE50LD Torsion Bars Size Heavy Duty (Supplied As A Pair) 7mm x 89mm 65706 Leaf Springs Bush Raised - 50kg Heavy Duty Raised - 300kg 40mm 65308Q 40mm 653RRHD08Q Complete Leaf Spring & Shackle Kit Poly 77958K Shackles & Pins U-Bolts Greasable Shackles Greasable Pins 656678G 656679G mm x 63mm x 80mm (inc Deep Nuts) 77508 4 Polyair To Suit Standard Height 6575695 Kit Bellows To Suit Raised Height 65853 Kit Stage. and rear shocks, raised leaf springs, complete leaf spring and shackle bush kit, shackles, pins and U bolts Stage. and rear shocks, torsion bars, heavy duty leaf srings, complete leaf spring and shackle bush kit, shackles, pins and u bolts 37
Mounts NISSAN Navara 4WD D40 005 on Qty Req Per Top Strut Mount Insulator (Rubber Part Only) Top Strut Mount (Steel Part Only) 659THB0L 659THB0M Std + 40mm 659GE0LD Std + 40mm 650GE0MD Coils Raised - 50kg - 40mm 770FR0L Raised - 50kg - V6 Turbo Diesel Models Heavy Duty Raised - 50-80kg 40mm 770FR0P 40mm 770FRHD0L Heavy Duty Raised - 80kg+ 40mm 770FRXHD0L Correction Components Lower Control Arm Camber Kit (4 x Bushes & 4 x Tubes) For Use Where Factory Camber Specification Can Not Be Reached 663OCK0L Kit Leaf Springs Raised - 00kg 40mm 6530L Medium Duty Raised - 300kg Heavy Duty Raised - 400kg 40mm 40mm 65330L 65340L Extra Heavy Duty Raised 500kg 40mm 65350L Bush Complete Leaf Spring & Shackle Kit Poly 77954K Shackles & Pins Greasable Shackles Greasable Pins 65630G 65600GP U-Bolts 4mm x 6mm x 80mm (inc Deep Nuts) 77500 4 Polyair To Suit Standard Height 6578595 Kit Polyair To Suit Raised Height 6578795 Kit Bellows To Suit Standard Height 65854 Kit Bellows To Suit Raised Height 65854R Kit Stage. struts and rear shocks, raised coils and raised leaf springs, complete leaf spring and shackle bush kit, shackles, pins and U bolts. Stage. struts and rear shocks, heavy duty raised coils and heavy duty leaf srings, complete leaf spring and shackle bush kit, shackles pins and u bolts 38
Strut NISSAN Pathfinder 4WD R50 /995-6/005 Bilstein Mono Tube Insert (Cuting and welding OE strut housing required) /995 - /998 (Series ) Bilstein Mono Tube Insert (Cuting and welding OE strut housing required) /998-6/005 (Series ) Bilstein Mono Tube /995 - /998 (Series ) Bilstein Mono Tube /998-6/005 (Series ) 654RE35046S 654RE3-5046S 654B46-036 654BE5-D564 Qty Req Per Raised - 40kg - 35mm 770FR0A Raised - 00kg 35mm 770RR0A Polyair To Suit Standard Height 6569 Kit Polyair To Suit Raised Height USE 6569 kit + x 6509766 6509766 ea 39
NISSAN Pathfinder 4WD R5 7/005 on Mounts Qty Req Per Top Strut Mount Insulator (Rubber Part Only) Top Strut Mount (Steel Part Only) 659THB0L 659THB0M Std + 50mm 659GE0LD Std + 50mm 650GE0L Raised - 40kg - 40mm 770FR0L Heavy Duty Raised - 40-00kg 40mm 770FRHD0L Extra Heavy Duty Raised 00kg+ 40mm 770FRXHD0L Raised - 00kg Heavy Duty Raised - 00kg 40mm 40mm 770RR0L 770RRHD0L Polyair To Suit Standard Height 659898 Kit Polyair To Suit Raised Height 659998 Kit Stage. struts, rear shocks, front & rear raised coils Stage. struts, rear shocks, front & rear heavy duty raised coils 40
NISSAN Patrol / Maverick 4WD GQ / Y60 SHORT Wheel Base /988 - /997 Qty Req Per Std + 50mm 650GEED XGS Tiger Adjustable Std + 50mm 650ADJE (Extra Long Travel For 3-4 Inch Depending On Coil Free Height) 75-00mm 650GE38S Std + 50mm 650GE87ZD XGS Tiger Adjustable Std + 50mm 650ADJ87Z (Extra Long Travel For 3-4 Inch Depending On Coil Free Height) 75-00mm 650GEED Steering Damper Ext / Com / Heavy Duty Pre 8/989 575 / 350 65034 Check end type Check Mount ^/^ Heavy Duty 8/989 Onwards 485 / 95 65006 Raised - 40kg - 50mm 770FRT Heavy Duty Raised - 40-80kg 50mm 770FRS Extra Heavy Duty Raised - 80kg+ 50mm 770FHS 5mm Single Coil Spacer 5mm 6636 30mm Single Coil Spacer 30mm 6639 Standard - 50kg 770RST Raised - 50kg 50mm 770RRT Heavy Duty Raised - 00kg 50mm 770RRS 5mm Single Coil Spacer 5mm 6637 30mm Single Coil Spacer 30mm 66330 Correction Components Gearbox Spacer Kit May Be Required NOTE: 770GQGBS 658ADJPR004 Adjustable Panhard Rods 658ADJPR005 Adjustable Drag Link 658ADJDL00 658BLKIT0 Extended Brake Lines 658BLKIT03 Castor Correction Kit ( Up To 50mm ).5 deg Rubber 6630R Castor Correction Kit ( Up To 50mm ).5 deg Poly 6630 Castor Correction Kit ( 75mm + ) 3.5 deg Poly 6635 Extended Sway Bar Link Pin (ea) 50-00mm Adjustable 658SBL5 Extended Sway Bar Link Pin (ea) 50-00mm Adjustable 658SBL5 Bush 779700K Panhard Rod Kit Poly. OE Only 779700K & inc: Panhard Rod (F&R), Radius Rod To Chassis, Radius Rod To Diff, Lower Trailing Arm Poly. OE Only 778KIT60 Aftermarket Spring 65F5690 Kit Aftermarket Spring Standard Height 6595097 Kit Aftermarket Spring Raised Height 6595096 Kit 4
NISSAN / FORD Patrol / Maverick 4WD GQ / Y60LWB 4.L Wagon /988 - /997 Gold Edition Std - 50mm 650GEED XGS Tiger Adjustable Std + 50mm 650ADJE - Long Travel 75-00mm 650GELED Gold Edition Std - 50mm 650GEED XGS Tiger Adjustable Std + 50mm 650ADJE - Long Travel 75-00mm 650GELE Steering Damper Ext / Com / Heavy Duty Pre 8/989 575 / 350 65034 Check end type Check Mount ^/^ Heavy Duty 8/989 Onwards 485 / 95 65006 Correction Components Raised 50mm 770FRS Heavy Duty Raised - 50kg- 50mm 770FHS Extra Heavy Duty Raised - 50kg+ 50mm 770FHE 5mm Coil Spacer 5mm 6636 ea 30mm Coil Spacer 30mm 6639 ea Raised - 50kg 50mm 770RRS Heavy Duty Raised (Progressive) 50mm 770RHS Extra Heavy Duty Raised - 00kg 50mm 770RRE 5mm Coil Spacer 5mm 6637 ea 30mm Coil Spacer 30mm 66330 ea 658ADJPR004 Adjustable Panhard Rods 658ADJPR005 Qty Req Per Adjustable Drag Link 658ADJDL00 658BLKIT0 Extended Brake Lines Does NOT Suit ABS 658BLKIT03 Castor Correction Kit ( 50mm ).5 deg Rubber 6630R Castor Correction Kit ( 50mm ).5 deg Poly 6630 Castor Correction Kit ( 75mm + ) 3.5 deg Poly 6635 Extended Sway Bar Link Pin (ea) 50-00mm Adjustable 658SBL5 Extended Sway Bar Link Pin (ea) 50-00mm Adjustable 658SBL5 Bush 779700K Panhard Rod Poly. OE Only 779700K & inc: Panhard Rod (F&R), Radius Rod To Chassis, Radius Rod To Diff, Lower Trailing Arm Poly. OE Only 778KIT60 Aftermarket Spring 65F5690 Kit Aftermarket Spring Standard Height 6595097 Kit Aftermarket Spring Raised Height 6595096 Kit Stage. & rear Gold Edition shocks, front & rear raised coils, steering damper, caster correction kit (rubber) Stage. & rear Gold Edition shocks, front & rear heavy duty raised coils, steering damper, caster correction kit (poly) Stage 3. & rear Gold Edition shocks, front & rear extra heavy duty raised coils, steering damper, caster correction kit (poly) front & rear adjustable panhard rods, adjustable drag link, front & rear brake line kis front & rear sway bar links 4
Qty Req Std + 50mm 650GEED XGS Tiger Adjustable Std + 50mm 650ADJE - Long Travel 75-00mm 650GELED Std + 50mm 650GEED XGS Tiger Adjustable Std + 50mm 650ADJE - Long Travel 75-00mm 650GELE Steering Damper Ext / Com ^/^ Heavy Duty GQ / Y60 485 / 95 65006 ^/^ Heavy Duty GU / Y6 Onwards 5 / 308 65B768 Correction Components Standard - 40kg- 770FSS Raised - 50kg- 50mm 770FRS Heavy Duty Raised - 40-80kg 50mm 770FHS Extra Heavy Duty Raised - 80kg+ 50mm 770FHE 5mm Coil Spacer 5mm 6636 ea 30mm Coil Spacer 30mm 6639 ea Standard - 50kg 50mm 770RRS Raised - 00kg 50mm 770RRE Heavy Duty Raised - 300kg 50mm 770RHE 5mm Coil Spacer 5mm 6637 ea 30mm Coil Spacer 30mm 66330 ea Adjustable Panhard Rods 658ADJPR004 658ADJPR005 Adjustable Drag Link 658ADJDL00 Extended Brake Line Does NOT Suit ABS 658BLKIT0 658BLKIT03 Castor Correction Kit ( 50mm ).5 deg Rubber 6630R Castor Correction Kit ( 50mm ).5 deg Poly 6630 Castor Correction Kit ( 75mm + ) 3.5 deg Poly 6635 50-00mm 658SBL5 Extended Sway Bar Link Pins (ea) Adjustable Bush NISSAN Patrol 4WD GQ,GU / Y60,Y6 C/C COIL front & COIL rear 989 on Extra Heavy Duty Raised - 500kg NOTE: Must have spring seats reinforced. Extended Sway Bar Link Pin GQ Models (ea) 50-00mm 658SBL5 Adjustable Extended Sway Bar Link Pin GU Models(ea) 50-00mm Adjustable 770XHDE 658SBL5 658SBL6 Panhard Rod Poly. OE Only 779700K 779700K & inc: Panhard Rod (F&R), Radius Rod To Chassis, Radius Rod To Diff, Lower Trailing Arm Poly. OE Only 778KIT60 Aftermarket Spring 65F5690 Kit Aftermarket Spring Standard Height 6595097 Kit Aftermarket Spring Raised Height 6595096 Kit 60mm Per Stage. & rear Gold Edition shocks, front & rear raised coils, steering damper, caster correction kit (rubber) Stage. & rear Gold Edition shocks, front & rear heavy duty raised coils, steering damper, caster correction kit (poly) 43
NISSAN Patrol 4WD HI LIFT OFF ROAD ONLY KITS GQ, GU Wagon & Coil Ute Y60,Y6 Qty Req Per 75-5mm 650GELED 75-00mm 00-5mm 650GELE 650GEXLE Steering Damper Ext / Com / Heavy Duty Pre 8/989 575 / 350 65034 ^/^ GQ 8/89+ 485 / 95 65006 ^/^ Heavy Duty 5/99-4/000 Wagon & Ute 5/99+ 5 / 308 65B768 TP/TP Heavy Duty 4/000 Onwards Wagon 550 / 35 6550 Correction Components Raised (3 inch) 75mm 770FRC3S Raised (4 inch) 00mm 770FRC4S Raised (5 inch) 5mm 770FRC5S Raised (7 inch) 75mm 770FRC7S Raised (3 inch) 75mm 770RRC3S Raised (4 inch) 00mm 770RRC4S Raised (5 inch) 5mm 770RRC5S Raised (7 inch) 75mm 770RRC7S To Suit GQ & GU Series & (Bent Rod) To Suit GQ & GU Series & Adjustable Drag Link (GQ & GU Series ) 658ADJPR004 658ADJPR005 658ADJDL00 To Suit Series 3 & 4 To Suit Series 3 & 4 Adjustable Drag Link (GU Series +) 658ADJPR08 658ADJPR09 658ADJDL00 658BLKIT0 Extended Brake Line Does NOT Suit ABS 658BLKIT03 Castor Correction Kit ( 75mm + ) 3.5 deg Poly 6635 Suitable For 4 & 5" Castor Correction Drop Bracket Kit s 6634 658SBL5 GQ 658SBL5 Extended Sway Bar Link Pin (each) Adjustable 658SBL5 GU 658SBL6 Bush Panhard Rod To Suit Series & Poly. OE Only 779700K Panhard Rod To Suit Series 3+ Poly. OE Only 77976K Panhard Rod To Suit Series & Poly. OE Only 779700K Panhard Rod To Suit Series 3+ Poly. OE Only 77976K & Panhard Rod (F&R), Radius Rod To Chassis, Radius Rod To Diff, Lower Trailing Arm 778KIT60 NOTE: These Coil Spring part numbers are designed for extreme off road only conditions and will render the vehicle illegal for use on public roads. Please note that all off road springs come in a black powder coat finish. Modifications may be necessary to suspension, steering, brakes & drive line when fitting these coil spring part numbers. Due to the intended use of the products on this page NO warranty is offered. Springs are not designed for load carrying 44
NISSAN Patrol 4WD GU / Y6 LONG Wheel Base Wagon /997 on Std + 50mm 650GEED XGS Tiger Adjustable Std + 50mm 650ADJE - Long Travel 75-00mm 650GE38S Std + 50mm 650GEED XGS Tiger Adjustable Std + 50mm 650ADJE - Long Travel 75-00mm 650GELE Steering Damper Ext / Com ^/^ Heavy Duty /97-4/000 5 / 308 65B768 Check End Check Mount TP/TP Heavy Duty 4/000 Onwards 550 / 35 6550 Raised - 40kg- 50mm 770FRS Heavy Duty Raised - 40-80kg 50mm 770FHS Extra Heavy Duty Raised - 80kg+ 50mm 770FHE 5mm Coil Spacer 5mm 6636 ea 30mm Coil Spacer 30mm 6639 ea Raised (Progressive) - 50kg 50mm 770RPE Heavy Duty Raised - 00kg 50mm 770RRE Qty Req Per Correction Components Extra Heavy Duty Raised (Progressive) - 300kg 50mm 770RHE 5mm Coil Spacer 5mm 6637 ea 30mm Coil Spacer 30mm 66330 ea To Suit Series & (Bent Rod) RHD To Suit Series & (Straight Rod) RHD Before Ordering 658ADJPR004 658ADJPR005 To Suit Series 3 & 4 (Bent Rod) RHD To Suit Series 3 & 4 (Staight Rod) RHD Check OE Fittings 658ADJPR08 658ADJPR09 Adjustable Drag Link (GU Series ) 658ADJDL00 Adjustable Drag Link (GU Series +) 658ADJDL00 Extended Brake Line Does NOT Suit ABS 658BLKIT0 658BLKIT03 Castor Correction Kit ( 50mm ).5 deg Rubber 6630R Castor Correction Kit ( 50mm ).5 deg Poly 6630 Castor Correction Kit ( 75mm + ) 3.5 deg Poly 6635 Extended Sway Bar Link Pin 50-00mm Adjustable 658SBL5 Bush & Extended Sway Bar Link Pin 658SBL5 658SBL6 Panhard Rod To Suit Series & Poly. OE Only 779700K Panhard Rod To Suit Series 3+ Poly. OE Only 77976K Panhard Rod To Suit Series & Poly. OE Only 779700K Panhard Rod To Suit Series 3+ Poly. OE Only 77976K inc: Panhard Rod (F&R), Radius Rod To Chassis, Radius Rod To Diff, Lower Trailing Arm 50-00mm Adjustable Poly. OE Only 778KIT60 Aftermarket Spring 65F5690 Kit Aftermarket Spring Standard Height 6595097 Kit Aftermarket Spring Raised Height 6595096 Kit Heat Shield (MUST BE USED ON 4.8lt Petrol) 65HSHIELD Kit Stage. & rear Gold Edition shocks, front & rear raised coils, steering damper, caster correction kit (rubber) Stage. & rear Gold Edition shocks, front & rear heavy duty raised coils, steering damper, caster correction kit (poly) 45
NISSAN Patrol 4WD GU / Y6 C/C COIL front LEAF rear 5/999 on Qty Req Per Std + 50mm 650GEED Std + 50mm 650GEX Steering Damper Ext / Com ^/^ Heavy Duty 5 / 308 65B768 Leaf Springs Standard - 40kg- 770FSS Raised - 40kg- 50mm 770FRS Heavy Duty Raised 40kg+ 50mm 770FHS 5mm Coil Spacer 5mm 6636 ea 30mm Coil Spacer 30mm 6639 ea Heavy Duty Raised D/side (80mm Camber) - 400kg Heavy Duty Raised P/side (70mm Camber) - 400kg 50mm 653BRHDX 653BRHPX Extra Heavy Duty Raised - 600kg 653RRX Correction Components Bush Shackles & Pins Castor Correction Kit ( 50mm ).5 deg Rubber 6630R Castor Correction Kit ( 50mm ).5 deg Poly 6630 Adjustable Panhard Rod 658ADJPR004 Panhard Rod Kit (Poly) OE Only 779700K Complete Leaf Spring & Shackle Kit 77959K Greaseable Shackle Greaseable Pins 656666G 656667G U-Bolts 4mm X mm X 65mm (inc Deep Nuts) A 77503 4 Bellows To Suit Std & Raised Height 65853 Kit Stage. & rear shocks, steering damper, heavy duty raised coils, heavy duty leaf springs, caster correction kit, (rubber) complete leaf spring & shackle bush kit, greasable shackles, pins & u-bolts Stage. & rear shocks, steering damper, extra heavy duty raised coils, extra heavy duty raised leaf springs, caster correction kit, (poly) complete leaf spring & shackle bush kit, greasable shackles, pins & u-bolts 46
SUZUKI Grand Vitara 4/98-7/05 SWB, LWB & XL7 Models Qty Req Per Use OE N/A Use OE N/A Raised - SWB & LWB 4cyl Models 5mm 770FR58H Raised - LWB V6 Models 5mm 770FR58J Raised - XL7 Models 5mm 770FR58Q Raised - SWB Models 5mm 770RR58H Raised - LWB Models 5mm 770RR58J Raised - XL7 Models 5mm 770RR58Q Polyair To Suit Standard Height SWB & LWB Non IRS 6563790 Kit 47
SUZUKI Grand Vitara 8/005 + Qty Req. Per Use OE N/A Use OE N/A Raised - V6 & Diesel Models 5mm 770FR58M Raised - 4cyl Models 5mm 770FR58N Raised 5mm 770RR58M Polyair To Suit Standard Height 656489 Kit 48
SUZUKI Jimny 4WD JLX Hard Top 0/998 on Qty Req Per 50mm 650GE57V 50mm 650GE57V Raised - 50kg - 50mm 770FR58L Bush Raised - 50kg - 50mm 770RR58L Castor Correction Kit Poly 66340 Polyair To Suit Standard Height 6563593 Kit Kit Price includes and Gold Edition Shocks, and raised coil springs and Castor Correction kit 49
TOYOTA 4 Runner/Surf 4WD IFS/Leaf LN6,63, YN63, 8/985-989 Qty Req Per Std + 40mm 650GE87FD Std + 40mm 650GE3OD Steering Damper O/O Right Angled Pin (one end) Torsion Bars Heavy Duty (Supplied As A Pair) NOTE: This Steering Damper May Not Fit On All Factory Turbo Diesel Models Ext / Com 60 / 370 65033 Size Heavy Duty 6mm x 064mm 657004 Leaf Springs Bush Raised (5+ Leaf Pack) 00kg 50mm 65367M Heavy Duty Raised (6+ Leaf Pack) 300kg 50mm 6537667M Complete Leaf Spring & Shackle Kit Poly 77955K Shackles & Pins U-Bolts Greasable Shackles 656386G Greasable Pins 656385G 4mm x 6mm x 80mm (inc Deep Nuts) B 77500 4 Polyair To Suit Standard Height 6575698 Kit Polyair To Suit Raised Height 5mm 6575798 Kit Stage. & rear shocks, steering damper, raised leaf springs, complete leaf spring & shackle bush kit, shackles, pins & u-bolts Stage. & rear shocks, steering damper, torsion bars, heavy duty raised leaf springs, complete leaf spring & shackle bush kit, shackles, pins & u-bolts 50
TOYOTA 4 Runner 4wd IFS/Coil - LN, RN, YN, VZN 30 Chassis, inc Surf 0/989-6/996 Qty Req Per Std + 40mm 650GE87FD Std + 40mm 650GE88ID Steering Damper O/O Right Angled Pin (one end) Torsion Bars Heavy Duty NOTE: This Steering Damper May Not Fit On All Factory Turbo Diesel Models Ext / Com 60 / 370 65033 Size Heavy Duty (Supplied As A Pair) 6mm x 064mm 657004 Standard Height 770RS86M Raised - 00kg - 40mm 770RR86M Heavy Duty Raised - 00kg 40mm 770RRHD86M Bush Panhard Rod Bush Kit Poly OE Only 779709K Polyair To Suit Raised Height 655790 Kit Stage. & rear shocks, steering damper, raised coil springs. Stage. & rear shocks, steering damper, torsion bars & heavy duty raised coils, 5
TOYOTA Surf 4WD (Import with Prado chassis) 85 Chassis 4/996+ Top Strut Mounts Qty Req Per Top Strut Mounts 659THB88A Std + 50mm 659GE88A Std + 50mm 650GE88A Standard Height - 50kg - 770FS88A Raised - 50kg- 45mm 770FR88A Heavy Duty Raised - 50kg+ 45mm 770FH88A Standard Height - 00kg- 770RS88A Raised - 00kg- 40mm 770RR88A Heavy Duty Raised - 00kg 50mm 770RRHD88A Standard Height 65679 Kit Raised Height 65689 Kit Stage. struts, rear shocks, front & rear raised coils Stage. struts, rear shocks front & rear heavy duty raised coils 5
TOYOTA Hilux 4WD & 4 Runner (leaf/leaf) LN/RN36 /46/05 & LN / YN65 / 67 / 06, 979-9/997 Qty Req Per Std + 50mm 650GE67MD Std + 50mm 650GE87ZD Steering Damper ^/O Leaf Springs Ext / Com Heavy Duty 535 / 340 650 Raised (6 Leaf) D/Side 55mm Camber - 50kg+ 50mm Raised (6 Leaf) P/Side 35mm Camber 50kg+ 653FHD67M 653FHP67M Bush Raised (5+ Leaf Pack) 00kg 50mm 65367M Heavy Duty Raised (6+ Leaf Pack) 300kg 50mm 6537667M 77953K Complete Leaf Spring & Shackle Kit Poly 77955K & 7795K Shackles & Pins U-Bolts Greasable Shackles 656384G Greasable Pins 656385G Greasable Shackles 656386G Greasable Pins 656385G 4mm x 6mm x 0mm (D/Side) B (F) 775SP 4mm X 6mm X 80mm (P/Side) B 77500 4mm x 6mm x 80mm (inc Deep Nuts) B 77500 4 Bellows To Suit 50mm Raised Height 6585303 Kit Stage. & rear shocks, front & rear raised leaf springs, steering damper, complete front & rear leaf spring & shackle bush kit, front & rear shackles, pin & u-bolts. Stage. & rear shocks, raised front leaf springs, heavy duty raised rear leaf springs, steering damper, complete front & rear leaf spring & shackle bush kit, front & rear shackles, pin & u-bolts. 53
TOYOTA Hilux 4WD IFS/Leaf S/C, D/C, X/C 985-3/005 Qty Req Per Std + 40mm 650GE87FD Std + 50mm 650GE87ZD Steering Damper O/O Right Angled Pin (one end) Torsion Bars Heavy Duty (Supplied As A Pair) NOTE: This Steering Damper May Not Fit On All Factory Turbo Diesel Models Ext / Com 60 / 370 65033 Size Heavy Duty (Supplied As A Pair) 6mm x 064mm 657004 Leaf Springs Raised (4 + Leaf Pack) 00kg 50mm 65387F Heavy Duty Raised (5 + Leaf Pack) 400kg 50mm 653487F Bush Extra Heavy Duty (6 + Leaf Pack) 600kg 50mm 653887F Complete Leaf Spring & Shackle Kit Poly Shackles & Pins 77950K Greasable Shackles Greasable Pins 656387G 65600GP U-Bolts 4mm x 6mm x 80mm (inc Deep Nuts) B 77500 4 Polyair To Suit Standard Height 6575703 Kit Polyair To Suit Raised Height 6575903 Kit Bellows To Suit 50mm Raised Height 6585303 Kit Stage. & rear shocks, steering damper, raised leaf springs, complete leaf spring & shackle bush kit, shackles, pins & u-bolts Stage. & rear shocks, steering damper, torsion bars, heavy duty raised leaf springs, complete leaf spring & shackle bush kit, shackles, pins & u-bolts 54