REPLACEMENT PART MANUAL WALL MOUNTED PACKAGE AIR CONDITIONER Models: WA WA44D WA4 WA4D WA44 WA49 WA0 WA0 WA0D General Notes Contents Revised and/or additional pages may be issued from time to time. A complete and current manual consists of pages shown in the following contents section. Cabinet Components Page Exploded View... Usage List... Usage List... 4 Important Functional Components Exploded View... Usage List... Usage List... Contact the installing and/or local Bard distributor for all parts requirements. Make sure you have the complete model and serial number available from the unit rating plates. Control Panel Exploded View... Usage List... 9 Usage List... 0 Blank Page... Exploded View... Usage List... Exploded View... 4 Usage List... 4 Bard Manufacturing Company, Inc. Bryan, Ohio 40 ince 94...Moving ahead, just as planned. Manual: 0-49 upersedes: NEW File: Tab Date: 0--0 Copyright 00 Manual 0-49 Page of 4
CABINET COMPONENT This drawing is referenced in Tables on Pages and 4 Manual 0-49 Page of 4
CABINET COMPONENT Dwg. Part Number WA-A, B WA-C WA4-A,B,E WA4-C,F WA44DA, B WA44DC WA44-A,B,E WA44-C, F WA4DA,B WA4DC 4 Lower Base 00--* Left ide 00--* Right ide 4 0-09 Back 0-4-* To p 4-0-* Upper Front -4-* ervice Door -04-* Condenser Grille 0-0 Condenser Partition Drain Pan Blower Partition 4 4 Control Panel Assembly -4 - ee Control Parts List Panel Assembly Drawing Control Panel Cover (Inner) Control Panel Cover (Inner) and -04 Fan hroud -40 Bottom Mounting Bracket 9-09 Fill Fresh Air Damper Assembly 099 Filter Tra y 0 Left ide upport 4 4-04 Left Evaporator upport - Raceway 04 Outlet Air Frame Assembly 9-0-* ide Grille --* Control Panel Cover (Outer ) --* Disconnect Access Door 0 BFAD- 0 Right ide upport 4-04-* Right ide Cover Plate (Outer ) 9-9 Heat hield 0-0-* Top Rain Flashing - Cond. Partition Block Off Plate Eterior cabinet parts are manufactured with various paint color options. To insure that you receive the proper paint color, you must include the complete model and serial number of the unit for which cabinet parts are being ordered. This Table is references drawing on Page Manual 0-49 Page of 4
CABINET COMPONENT Dwg. Part Number WA49-A, B WA49-C WA0-A,B WA0-C WA0DA, B WA0DC WA0-E WA0-F 4 Lower Base 00--* Left ide 00--* Right ide 4 0-09 Back 0-4-* To p 4-0-* Upper Front -4-* ervice Door -04-* Condenser Grille 0-0 Condenser Partition Drain Pan Blower Partition 4 4 Control Panel Assembly -4 - ee Control Panel Assembly Drawing and Parts List Control Panel Cover (Inner) Control Panel Cover (Inner) -04 Fan hroud -40 Bottom Mounting Bracket 9-09 Fill Fresh Air Damper Assembly 099 Filter Tra y 0 Left ide upport 4 4-04 Left Evaporator upport - Raceway 04 Outlet Air Frame Assembly 0 Right ide upport 9-9 Heat hield 9-0-* ide Grille --* Control Panel Cover (Outer ) --* Disconnect Access Door 0 BFAD- 4-04-* Right ide Cover Plate (Outer ) 0-0-* Top Rain Flashing - Manual 0-49 Page 4 of 4 Cond. Partition Block Off Plate Eterior cabinet parts are manufactured with various paint color options. To insure that you receive the proper paint color, you must include the complete model and serial number of the unit for which cabinet parts are being ordered. This Table is references drawing on Page
FUNCTIONAL COMPONENT This Exploded View references Tables on Page and Manual 0-49 Page of 4
FUNCTIONAL COMPONENT Dwg. Part Number 000-000-0 000-0 000-000- 000-4 000-000-9 000-0 900-900-4 900-4 900-4 WA-A WA-B WA-C WA4-A WA4-B, E WA4-C WA4-F WA44DA WA44DB WA44DC WA49-A WA49-B WA49-C 00-004 Fan Motor Mount 4-0 Fan Blade 9 9 9 0 0-00 0-09 0-0B 0-04B -0 00-09 00-0 00-04 00-00B 9-00B 00-0B 00-B 004-0 00-00 004-0 Condenser Motor Condenser Motor Condenser Coil Condenser Coil Expansion Valve Cooling Capillary Assembly Distributor Assembly Distributor Assembly Air Filter " Throw-Away Air Filter " Washable Air Filter " Pleated -0 /4 Turn Fastener -04 /4 Turn Retainer -0 /4 Receptacle 04-00 High Pressure witch (Flare) 0-04 0-04 0-04 R ev. Valve olenoid, Black Casing (Wilspec) Rev. Valve olenoid, Red Casing (Ranco) Rev. Valve olenoid, Black Casing (an Hua) N 0-04 Three-Way Valve with 4V olenoid Coil N 00-0 Drain Back Capillary N 04-00 Low Pressure witch (Flare) N C MA- Low Ambient Control (Flare) Not hown Optional on these models This Table references Exploded View on Page Manual 0-49 Page of 4
FUNCTIONAL COMPONENT Dwg. Part Number 000-0 000-4 000-000- 000-000- 000-000-4 900-900-4 900-900- WA44-A WA44-B,E WA44-C WA44-F WA4DA WA4DB WA4DC WA0-E WA0-F WA0-A WA0-B WA0-C WA0DA WA0DB WA0DC 00-004 Fan Motor Mount 4-0 Fan Blade 0-00 0-09 0-0 0-00 Condenser Motor Condenser Motor Condenser Motor Condenser Motor 0-04B Condenser Coil 9 9 9 0 00-004 00-04 00-09 -0-09 00-00B 00-0B 9-004B 9-0044B 004-0 00-00 004-0 Cooling Capillary Assembly Distributor Assembly Distributor Assembly Expansion Valve Expansion Valve Air Filter " Throw-Away Air Filter " Washable Air Filter " Pleated -0 /4 Turn Fastener -04 /4 Turn Retainer 04-00 High Pressure witch (Flare) 0-04 0-04 0-04 Rev. Valve olenoid, Black Casing (Wilspec) Rev. Valve olenoid, Red Casing (Ranco) Rev. Valve olenoid, Black Casing (an Hua) N 0-04 Three-Way Valve with 4V olenoid Coil N 00-0 Drain Back Capillary N C MA- Low Ambient Control (Flare) N 04-00 Low Pressure witch (Flare) Not hown Optional on these models This Table references Exploded View on Page Manual 0-49 Page of 4
CONTROL PANEL This drawing is referenced in Tables on Pages 9 and 0 Manual 0-49 Page of 4
CONTROL PANEL WA-A WA-B WA-C WA4-A WA4-B WA4-C WA4-E WA4-F WA44-A WA44-B WA44-C WA44-E WA44-F D rawing Part 0-00 Low Voltage Terminal trip 0-0 Terminal Block Pole 0-04 Terminal Block Pole 0-0 Phenolic Insulator 0-0 Blower Control 0-0 Blower Relay 4 40-04 Transformer 4 40-04 Transformer 40-00 Contactor 40-0 Contactor -00-0 -0-0 Outdoor Motor Capacitor Outdoor Motor Capacitor Capacitor Capacitor -0 Wire hield -00 Ground Termina l 9 000-0 Pin Connecto r 0 0-0 Phase Monitor 0-0 Alarm Relay -004 tart Device 0-0 Control Module 4 9 Low Voltage Box 4 Control Panel 0-0 Terminal Block -0 Breaker A Pole -040 Breaker 0A Pole -04 Breaker A Pole -0 Breaker 0A Pole WMPD-0C Pull Disconnect 409- Wiring Diagram 409- Wiring Diagram 409-4 Wiring Diagram 409- Wiring Diagram 409-9 Wiring Diagram 409- Wiring Diagram 409- Wiring Diagram 409- Wiring Diagram 409- Wiring Diagram 409- Wiring Diagram Optional on these models. breakers listed are for units without electric heat "0Z" models. Hot gas bypass models not available without electric heat. ee Heater Replacement Parts Manual for units with electric heat. = Not shown This Table is references drawing on Page Manual 0-49 Page 9 of 4
CONTROL PANEL WA49-A WA49-B WA49-C WA0-A WA0-B WA0-C WA0-E WA0-F D rawing Part 0-00 Low Voltage Terminal trip 4 4 0-0 0-04 0-0 0-0 0-0 40-04 40-04 40-00 40-0 -004-00 -0-09 -0 Terminal Block Pole Terminal Block Pole Phenolic Insulator Blower Control Blower Relay Transformer Transformer Contactor Contactor Outdoor Motor Capacitor Outdoor Motor Capacitor Outdoor Motor Capacitor Capacitor Capacitor -0 Wire hield -00 Ground Termina l 9 000-0 Pin Connecto r 0 0-0 Phase Monitor 0-0 Alarm Relay -004 tart Device (PTCR) 0-0 Control Module 4 9 Low Voltage Box 4 Control Panel 0-0 Terminal Block -040-04 WMPD-0C -04-044 409-409- 409-9 409-409- Breaker 0A Pole Breaker 40A Pole Pull Disconnect Breaker 0A Pole Breaker 4A Pole Wiring Diagram Wiring Diagram Wiring Diagram Wiring Diagram Wiring Diagram breakers listed are for units without electric heat "0Z" models. Hot gas bypass models not available without electric heat. ee Heater Replacement Parts Manual for units with electric heat. = Not shown This Table is references drawing on Page Manual 0-49 Page 0 of 4
This page left blank intentionally. Manual 0-49 Page of 4
CONTROL PANEL 9 0 4 4 EP-4 Manual 0-49 Page of 4
CONTROL PANEL Dwg. Part Number WA44DA WA44DB WA44DC WA4DA WA4DB WA4DC WA0DA WA0DB WA0DC 0-04 Low Voltage Terminal trip 4 4 0-0 0-04 0-0 0-0 0-0 40-0 40-04 40-00 40-0 -004-00 -0-0 -0-0 Terminal Block Pole Terminal Block Pole Phenolic Insulator Blower Control Blower Relay Transformer Transformer Contactor Contactor Outdoor Motor Capacitor. MFD-0V Outdoor Motor Capacitor 0 MFD-0V Outdoor Motor Capacitor MFD-0V Capacitor 0/0 MFD-0V Capacitor 40/0 MFD-0V Capacitor 0/. MFD-0V -0 Wire hield -00 Ground Termina l 9 000-0 Pin Connecto r 0 0-0 Relay 0-09 Logic Board 4 9 Low Voltage Box 4 Control Panel 0-0 Terminal Block (Optional ) 0-0 Control Module -040 Breaker 0A Pole -04 Breaker A Pole WMPD-0C Pull Disconnect N -04 Breaker 0A Pole N -044 Breaker 4A Pole N 409- Wiring Diagram N 409- Wiring Diagram N 409-0 Wiring Diagram N 409- Wiring Diagram breakers listed are for units without electric heat "0Z" models. Hot gas bypass models not available without electric heat. ee Heater Replacement Parts Manual for units with electric heat. = Not shown Manual 0-49 Page of 4
BLOWER AEMBLY Drawing N o. Part -0-0 -0-0 0-00 0-0 04-0 04-04 900-900-4 0 Inch Wheel (CW) 9 Inch Wheel (CW) 0 Inch Wheel (CCW) 9 Inch Wheel (CCW) Blower Motor (0/0) Blower Motor (40) Blower Motor (0/0) Blower Motor (40) 900-900- 900-4 900-4 4-00 Capacitor 00-040 Motor Mount 4-0 Grommets 0- Back Brace 0-0 ide Angle 4 4 4 4 4 4 9 0-9 Front Brace 0-0 Housing 44- Diffuser Manual 0-49 Page 4 of 4