RYOBI Digital Inverter Generator Item No. RYi00BT/RYi00BTA Mfg. No. 0909009/090900 Replacement Parts List 990095-1-1 (Rev:01) TECHTRONIC INDUSTRIES POWER EQUIPMENT, INC. 18 Pearman Dairy Road, Anderson, SC 95 Phone 1-800-80-050 www.ryobitools.com
DIGITAL INVERTER GENERATOR MODEL NUMBER RYi00BT/RYi00BTA Figure A 0 1 9 Add Loctite or equivalent 18 19 1 1 8 1 1 0 5 9 Add Loctite or equivalent SEE FIG. E 1 SEE FIG. B 1 0 SEE FIG. B SEE FIG. D 1 5 1 1 9 SEE FIG. C SEE FIG. B 8 Add Loctite or equivalent 5 1 8
DIGITAL INVERTER GENERATOR MODEL NUMBER RYi00BT/RYi00BTA The model number will be found on a label attached to the back cover. Always mention the model number in all correspondence regarding your DIGITAL INVERTER GENERATOR or when ordering parts. PARTS LIST FIGURE A 1 8000 Internal tooth washer (5 mm ID)... 00 Screw (M5 x 0 mm, Button Soc. Hd.)... 81801 Washer (M5.)... 8 008 Wheel... 5 059901 Axle... 1 8001 Lock Washer... 09500 Bolt (M x 1 mm, Hex Hd.)... 8 8019 Lock Nut (M)... 9 05009 Screw w/washer (M x mm, T0 Torx Hd.)... 00 Screw (M5 x 5 mm, Button Soc. Hd.)... 1 001 Screw (M5 x 1 mm, Flat Hd.)... 1 90001 Ground Wire... 1 1 050 Screw (M x 1 mm, T Torx Hd.)... 1 1801 Screw (M x 1 mm, Flat Hd.)... 890001 U-Clip (M5)... 0 1 5508 Control Knob... 1 1 1001 Screw (M x mm)... 1 18 000 Screw (M5 x 1 mm, Button Soc. Hd.)... 19 05018 Screw (M5 x 0 mm, T5 Torx Pan Hd.)... 0 500 Left Housing Assembly (Incl. Key No. )... 1 1 00 Engine Start/Stop Mechanism Assembly (Inc. One of Key and Key )... 1 809008 Fuel Hose Clamp (/8 in.)... 5058 Fuel Hose (.5 mm and mm)... 1 880 Fuel Hose Clamp (9.5 mm)... 5 55900 Starter Cover Assembly... 1 0 Fuel System Assembly (Incl. Key Nos. -8)... 1 880 Clamp ( mm)... 1 8 5058 Fuel Hose (mm and.5 mm)... 1 9 5050 Fuel Tank Support... 1 0 5190900 Vented Fuel Cap... 1 1 50818005 Overspill Guard... 1 50 Upper Exhaust Panel Assembly (Incl. Key No. )... 1 501 Lower Exhaust Panel Assembly (Inc. Key No. 1)... 1 9900 Engine Isolator (5 Degree)... 5 5000 Right Housing Assembly (Incl. Key No. )... 1 500 Maintenance Cover Assembly (Incl. Key Nos. -8)... 1 8008 E-Clip (5 mm Shaft)... 1 8 5509 Lock Knob... 1 9 08008 Fuel Filter... 1 0 5000 Recoil Handle... 1 1 500 Grommet... 508800 Rubber Pad... 1 Not Shown: 9001 Accessory Kit 99009 Operator's Manual NOTE A: OWT Industries, Inc., will not provide engines as replacement parts. Engines are covered through the engine manufacturer s warranty. Consult the accompanying engine manual or contact our service department for assistance.
Figure B DIGITAL INVERTER GENERATOR MODEL NUMBER RYi00BT/RYi00BTA 1 1 18 0 1 0 19 5 1 1 ARROW TO THE FRONT 1 1 Add Loctite or equivalent 9 8 9 8
DIGITAL INVERTER GENERATOR MODEL NUMBER RYi00BT/RYi00BTA The model number will be found on a label attached to the back cover. Always mention the model number in all correspondence regarding your DIGITAL INVERTER GENERATOR or when ordering parts. PARTS LIST FIGURE B 1 518800 Front Cover...1 805 Handle Tube... 55 Handle Cap (Right)... 55 Handle Cap (Left)... 5 500 Back Cover...1 81801 Washer (M5.)... 00 Screw (M5 x 0 mm, Button Soc. Hd.)... 8 09500 Bolt (M x 1 mm, Hex Hd.)... 9 8001 Lock Washer... 500 Isolator Foot... 001 Screw (M5 x 1 mm, Flat Hd.)... 1 089008 Handle Assembly...1 1 5009 Handle Bumper...1 1 55900 Bottom Base...1 90009 Regulator (AC to DC)...1 1 08001 Flange Washer...1 1 500 Engine Support Isolator (Front)...1 18 5008 Engine Support Isolator (Back)...1 19 5198 Oil Drain Door...1 0 890001 U-Clip (M5)... 1 001 Screw (M5 x 1 mm, Phillips Hd.)... 5
Figure C DIGITAL INVERTER GENERATOR MODEL NUMBER RYi00BT/RYi00BTA 1 1 1 0 1 8 1 5 9 0 0 5 1 9 0 1 8 18 19 19 19
DIGITAL INVERTER GENERATOR MODEL NUMBER RYi00BT/RYi00BTA The model number will be found on a label attached to the back cover. Always mention the model number in all correspondence regarding your DIGITAL INVERTER GENERATOR or when ordering parts. PARTS LIST FIGURE C 1 80009 Faceplate...1 9001 GENControl Display Assembly...1 09500 Overload Reset Button...1 09500 Auto Idle Button...1 5 80900 Connector (Black)... 805000 Circuit Breaker (0A)...1 905101 Wire Harness (GENControl Display)...1 8 900001 Volt Duplex Receptacle (0 Amp)...1 9 501 Movable Outlet Cover...1 50 Fixed Outlet Cover...1 501 Clip...1 1 99001 Compression Spring...1 1 519001 Electrical Panel Housing...1 1 5800 Dual USB Cover...1 88001 Nut (M)... 1 01 Screw (M)... 1 001 Spacer (1. mm)... 18 801009 Wing Nut (M5)...1 19 8005 Washer (ID5. x OD x 0.5t)... 0 800 Lock Washer (ID5 x OD9 x 1.t)...1 1 801008 Hex Nut (M5)...1 0900 Bolt (M5 x 1 mm, Pan Hd.)...1 0505 Bolt (M x mm, T Torx Drive Hd.)... 909900 Flat Washer (ID. x OD)... 5 100 Hex Nut (M)... 0900 Screw (#-0 x /8 in., T Torx Pan Hd.)... 9050 Regulator Wire Harness w/ USB Ports...1 8 905101 Internal Wire Assembly...1 9 9000 Ground Wire...1 0 09501 Screw (M.1 x mm, Torx Hd.)...
Figure D DIGITAL INVERTER GENERATOR MODEL NUMBER RYi00BT/RYi00BTA 5 1 8
DIGITAL INVERTER GENERATOR MODEL NUMBER RYi00BT/RYi00BTA The model number will be found on a label attached to the back cover. Always mention the model number in all correspondence regarding your DIGITAL INVERTER GENERATOR or when ordering parts. PARTS LIST FIGURE D 1 5081800 Rubber Trim...1 09500 Bolt (M x 1 mm, Hex Hd.)... 901009 Baffle (Engine Intake)...1 9010 Bracket...1 5 05009 Screw w/washer (M x mm, T0 Torx Hd.)... 500005 Rubber Pad...1 9099 Inverter Module...1 9
DIGITAL INVERTER GENERATOR MODEL NUMBER RYi00BT/RYi00BTA Figure E 1 0 5 1 18 1 19 1 0 1 5 1 0 9 8 1 9 8 9 1 8 5 1 Not all parts shown on the exploded view are available. Some parts are shown to identify position and location of parts that are available.
DIGITAL INVERTER GENERATOR MODEL NUMBER RYi00BT/RYi00BTA The model number will be found on a label attached to the back cover. Always mention the model number in all correspondence regarding your DIGITAL INVERTER GENERATOR or when ordering parts. PARTS LIST FIGURE E 1 0005 Oil Dipstick...1 500 Fan...1 9 Bolt (M x 1 mm)...5 051 Low Oil Sensor...1 5 5 Rotor...1 05 Stator...1 88901 Alternator Cover...1 8 890 Muffler Heat Shield...1 9 8101 Spark Arrestor...1 08990055 Muffler...1 919 Bolt (M x 1 mm)...1 1 05901 Exhaust Valve...1 1 0001 Valve Spring... 1 01801 Plate... 00801 Valve Lock Clamp... 1 900 Gasket (Over Head Cover)...1 1 001 Over Head Cover...1 18 0180 Inlet Valve Spring Seat...1 19 01 Inlet Valve...1 0 91 * Spark Plug...1 1 05000 RPM Sensor...1 5005 Governor Motor Housing...1 9900 Compression Spring...1 001 Thermal Insulation Seat (Carburator)...1 5 911 Paper Gasket...1 9009 Air Box Gasket...1 5188005 Air Filter Assembly...1 8 50581 Fuel Hose ( mm)...1 9 80900 Fuel Line Clamp (/1 in.)...1 0 951 Breather...1 1 900 Gasket (Connection Block)...1 08051 Carburetor...1 8500005 Ignition Coil...1 9900 Engine Recoil...1 5 0000 Stepper Motor...1 08051 Carburetor Assembly (Incl. Key Nos., and 5)...1 0901 Engine Cover...1 8 91 Bolt (M x 0 mm)...5 9 01 Lifter Valve... 0 01901 Pushing Rod... 1 9008 Gasket (Muffler)...1 * STANDARD HARDWARE ITEM MAY BE PURCHASED LOCALLY
Figure F 5 DIGITAL INVERTER GENERATOR MODEL NUMBER RYi00BT/RYi00BTA 8 9 1 19 1 18 1 1 1 1 1
DIGITAL INVERTER GENERATOR MODEL NUMBER RYi00BT/RYi00BTA The model number will be found on a label attached to the back cover. Always mention the model number in all correspondence regarding your DIGITAL INVERTER GENERATOR or when ordering parts. PARTS LIST FIGURE F 1 905801 Handle Release Label...1 9005 Logo Label...1 90800 Fuel Stabilizer Label...1 90501 CPSC Label...1 5 905 Danger Label...1 9050 Ground Warning Label (En/Fr)...1 90900 Fire Distance Label...1 8 90918 Performance Label (Maintenance Door)...1 9 918008 Inquiries Label...1 900808 Lubricant Label...1 90918 Maintenance Door Label...1 1 90900 Maintenance Label...1 1 90905 Combustion Label...1 1 908008 Hot Surface Label...1 908 Start Label...1 1 90801 Gen Control/Bluetooth Label...1 1 90058 Easy Start Logo Label...1 18 9019 Choke Label...1 19 90918 Performance Label...1 1
DIGITAL INVERTER GENERATOR MODEL NUMBER RYi00BT/RYi00BTA Control Panel Block Parallel Connectors Main Winding Sub Winding DC Winding Generator Block WIRES COLOR CODES G Green O Orange W White BI Black B Blue Lb Light Blue Y Yellow Br Brown R Red Gr Gray P Pink G / Y Green / Yellow Pl Purple R/W Red/White Main Input power Stepper Motor Control Control and Indicator Signal UART Communication Port Inverter Block Noise Filter (AC) Inverter Module Ground Terminal O BL R W B BL R W V / 0 A Duplex Receptacle Ground Terminal O BL Reset push button (Normally Open) Press to remove overload condition USB Ports Auto Idele ON/OFF Momentary Switch Gencontrol Display B/W G BL O O BL AC to DC Regulator B/W Fuel Tank O BL Fuel Level Sensor Engine ON/OFF Switch G Spark Plug Ignition Coil Exciter Winding Ignition Pulse Generator Oil Level Switch Throttle Control Motor Engine Ground Engine Block G/Y Frame Block Wiring Diagram