0300 LGT654 Illustrated Parts List / 9604500070
DECALS 3 6 5 7 6 4 4 4 9 8 6 5 53 4 9-38 Decal, Warning 4 53 9 5-54 Decal, Hood Cust Resp 5 53 7 84-55 Decal, Caution 6 53 4 99-35 Decal, Eng. HP 8 53 9 87-85 Decal, Mower Sch. 9 53 4 50-05 Decal, Battery Dnge/Poi 3 53 40 44-84 Decal, Steering Whl 4 53 4 0-09 Decal, Panel Side 5 53 8 09-4 Decal, Panel Side 6 53 4 68-38 Decal, Hood Logo 7 53 4 0-38 Decal, Replacement - - 53 6 69-60 Decal, Bypass - - 53 40 7-7 Pad, Footrest, LH - - 53 40 37-73 Pad, Footrest, RH WHEELS AND TIRES 3 7 6 4 0 5 9 8 53 05 9-9 Cap, Valve, Tire 53 06 5-39 Stem, Valve 3 53 4 45-09 Rim Assembly, Front 4 53 00 8-34 Tube, Front (Ser vice Item Only) 5 53 0 6-30 Tire, Front 6 53 49-57 Fitting, Grease (Front Wheel Only) 7 53 49-59 Bearing, Flange (Front Wheel Only) 8 53 7 50-39 Cap, Axle (Front Wheel Only) 9 53 8 47-08 Tire, Rear 0 53 00 7-54 Tube, Rear (Service Item Only) 53 40 7-8 Rim Assembly, Rear - - 53 4 43-34 Sealant, Tire (0 oz. Tube) inch = 5.4 mm wheel_art_-tex 30
SCHEMATIC SCH A AMMETER (OPTIONAL) RED FUSE BATTERY RED SOLENOID STARTER M WHITE PTO SWITCH (DISENGAGED) WHITE ELECTRIC CLUTCH S B M A G L A RED C A H D WHITE RED CLUTCH/BRAKE (PEDAL UP) GRAY B E REVERSE SWITCH (NOT IN REVERSE) 3 SEAT SWITCH (NOT OCCUPIED) 6 GRAY /WHITE JUNCTION CONNECTOR CHASSIS HARNESS SHORTING CONNECTOR C B A F E D H G BLUE IGNITION UNIT (OPTIONAL) HOUR METER SPARK PLUGS GAP ( PLUGS ON TWIN CYL. ENGINES) PTO SWITCH (MATING SIDE) BLUE FUEL LINE BLUE V POWER OUTLET (OPTIONAL) NOTES ORANGE FUEL SHUT-OFF SOLENOID (IF EQUIPPED) RED CHARGING SYSTEM OUTPUT 9-6AMPDC@3600 RPM REGULATOR STATOR 8 VOLTS AC @ 3600 RPM (REGULATOR DISCONNECTED) BROWN LIGHT SWITCH HEADLIGHTS IGNITION SWITCH POSITION CIRCUIT MAKE OFF RUN/OVERRIDE RUN M+G+A B+A B+A L+A START B+S+A 3 CHASSIS HARNESS CONNECTOR (MATING SIDE) 6 5 4 DASH HARNESS CONNECTOR 3 6 5 4 3 WIRING INSULATED CLIPS NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR SERVICING OF UNIT, THEY SHOULD BE RE-INSTALLED TO PROPERLY SECURE YOUR WIRING. NON-REMOVABLE CONNECTIONS REMOVABLE CONNECTIONS
ELECTRICAL TS 90 30 33 7 79 9 4 8 99 00 34 7 4 43 4 6 40 5 8 55 6 0 With V Outlet Option 03 7 59 0 9 With Service Minder Option 05 46 3
ELECTRICAL 53 4 49-7 Battery 874 76 04- Bolt Hex Hd /4-0 unc x 3/4 8 53 8 64-9 Battery Box 6 53 7 6-38 Switch Interlock 53 8 37-59 Harness Socket Light 53 00 4-5 Bulb, Light #56 4 53 40 0-53 Cable Battery 5 53 4 8-95 Cable Starter 6 53 7 5-58 Fuse 7 873 5 04-00 Nut Keps Hex /4-0 unc 8 53 4 54-9 Cable Ground " Blk 6 Ga. 9 53 40 5-45 Switch Seat 30 53 9 33-50 Switch Ign 33 53 4 9-33 Key/Chain 34 53 07- Switch Light/Reset 40 53 40-04 Harness Ign. Dash 4 87 7 04-08 Screw Thd Cut /4-0 x / 4 53 3 5-63 Cover Terminal Red 43 53 9 5-07 Solenoid 46 53 40 7-63 Gauge Hourmeter 50 53 9 6- Switch PTO 55 87 06 05- Screw Thdrol 5/6-8 x 3/4 59 53 40 03-03 Outlet -Volt 7 53 9 4-76 Harness Ign Chassis 79 53 7 5-4 Socket Asm Bulb 90 53 40 07-4 Cover Terminal Battery 9 53 9 0-70 Strap Battery 99 87 67 04- Screw Hexwsh Thdrol /4-0 x 3/4 00 89 09 4-6 Washer 9/3 x 7/8 x 6 Ga. 0 53 9 83-7 Pigtail 0 53 40 44-54 Harness Pigtail K46 03 53 40 79-6 Harness Pigtail V Outlet 05 53 40 75-68 TT Pedal Control inch = 5.4 mm 33
CHASSIS 04 0 08 8 5 99 98 96 03 06 34 4 4 30 07 5 76 5 37 8 30 09 0 37 34 76 77 75 05 50 78 96 76 76 6 6 36 37 94 36 94 68 8 30 36 35 34 30 3 3 99 80 8 65 68 68 6 8 83 68 89 94 5 7 58 8 89 chassis-tex_tex GT HUSQ_6_r 89 5 89 34
CHASSIS 5 53 40 87-0 Dash 4 53 4 0-46 Hood Asm. 5 53 9 89-07 Lens LH 8 53 40 86-07 Grille Asm. 5 53 9 89-06 Lens RH 34 53 9 6-5 Plate Engine 36 87 06 05- Screw 5/6-8 x 3/4 37 53 40 8-5 Fender 5 873 68 05-00 Nut Crown Lock 5/6-8 58 53 9 43-4 Bracket Fender 68 87 49 05-08 Screw 5/6-8 x / 30 53 4 63-58 Screw #0 x.750 BOS Thread 37 53 40 75-90 Bumper Dash 50 53 9 85- Duct Heat Hood 5 53 9 95-35 Shield Browning/Debris 6 53 40 8-6 Console Fuel Window 6 53 4 4-3 Screw Hex Wsh Hi-Lo /4 x / 65 53 9 68-6 Bracket Support Tank 75 53 9 63-04 Crossmember 76 53 40 07-76 Screw 0-4 x 5/8 77 53 9 5-7 Bushing Steering 78 53 9 97-8 Cargo Asm. Net 80 53 9 54-77 Chassis 8 53 40 30-5 Bushing Mtg. Fender Crgo. 8 53 40 68-59 Dash Lower 83 874 78 05-0 Bolt Fin Hex 5/6-8 unc x -/4 89 87 00 05- Screw 5/6-8 x 3/4 94 873 80 05-00 Nut Lock Hex Flange 5/6-8 96 53 40 0-99 Console Asm. Deck Lift 99 53 9 8-59 Plate Deck Lift 0 53 40 30-48 Vent Side Hood RH 03 53 40 30-76 Vent Side Hood LH 04 53 4 66-3 Vent Asm Hood Top 05 53 40 7-09 Skirt Hood Side RH 06 53 40 7- Skirt Hood Side LH 07 53 9 7-98 Bezel RH 08 53 9 7-99 Bezel LH 09 53 9 9-30 Insert Hex Top RH 0 53 9 9-3 Insert Hex Top LH 53 9 9-3 Insert Hex Bottom RH 53 9 9-33 Insert Hex Bottom LH 3 874 76 05- Bolt Hex Hd 5/6-8 unc x 3/4 4 53 9 9-45 Clip Retainer 7 53 40 9-67 Rod Pivot 8 53 9 63-95 Hood Stop 53 9 89-09 Reflector LH 8 53 9 5-6 Stud Fastener 34 53 40 47-4 Bumper Hood 35 53 40 6-9 Spacer Fender 36 873 93 05-00 Nut Center Lock 5/6-8 unc 96 53 40 86-06 Trim 98 53 04-5 Nut Push 99 53 40 50- Logo inch = 5.4 mm 35
DRIVE 0 74 70 3 07 9 06 5 6 74 56 43 09 6 7 60 6 97 96 4 84 35 5 5 5 64 59 67 60 70 6 59 5 7 9 49 88 85 86 89 87 5 6 5 53 08 63 5 4 0 80 90 50 5 5 66 05 9 5 5 6 53 5 33 83 6 6 5 7 05 30 6 6 30 83 9 73 Drive-tex_K46_pedal r 99 73 05 7 33 36
DRIVE 53 4 40-06 Transaxle, TUFFTORQ K46BN 53 8 6- Key /4 x.5 7 53 9 98-44 Hub Asm. Wheel 9 53 4 00-80 Bolt Hub Wheel 5 89 3 3-6 Washer 3/3 x 3/6 x 6 Ga. 7 53 4 36-78 Spring, Brake 6 53 9 96-79 Spring Return Cruise 9 53 40 38-06 Rod, Brake 33 8 00 00-0 Ring E 35 53 9 95-9 Rod, Brake, Park 4 53 48-7 Cover, Foot Pedal 49 87 06-4 Bolt 50 53 9 43-7 Pulley Idler Flat 5 873 90 06-00 Lock Nut 3/8-6 5 53 9 43-6 Idler V-Groove 90" Offset 56 53 3 09-69 V-Belt, Drive 64 53 9 78-65 Shaft Asm. Pedal Brake Control 70 53 40 05-30 Control Asm. 73 874 49 05-60 Bolt Hex Flghd 5/6-8 x 3.75 74 53 4 4-3 Screw /4 x / 80 53 4 33-05 Bracket Strap Torque 9 874 76 05-0 Bolt Fin Hex 5/6-8 unc x.5 99 53 4 57-43 Rod Spring Bypass 6 873 90 05-00 Nut Lock Hex Flange 5/6-8 5 87 00 05- Screw 5/6-8 x 3/4 43 87 49 05-08 Screw Thdrol 5/6-8 x / 53 53 47-88 Retainer Spring 59 876 0 04- Pin Cotter /8 x 3/4 60 53 6 94-84 Retainer Clip 6 53 0 57-09 Spring, Return, Clutch 6 53 9 57-85 Spacer Transaxle 63 53 40 0-34 Rod Pedal Control 66 53 9 7-90 Nut Push.65 67 53 40 5-57 Latch Brake Parking 70 53 9 43- Keeper Belt Centerspan 7 87 06-6 Bolt Rdhd Sqnk 3/8-6 unc x 83 53 40 04-4 Spacer Split 84 53 40 3-8 Handle Parking Brake 85 87 06-0 Bolt Rdhd Sqnk 3/8-6 x -/ 86 53 9 43- Spacer Retainer 87 89 3 3-0 Washer 88 53 9 43-3 Link Clutch Ground Drive 89 53 9 43-7 Bellcrank Ground Drive 90 53 9 43-8 Keeper Bellcrank Ground Drive 96 87 00 06-6 Screw 3/8-6 x 97 53 9 97-69 Bracket Clutch Anti-Rotation 05 53 7-48 Washer 06 53 9 78-67 Bracket Mount Latch Cruise 07 53 9 78-68 Latch Control Cruise 08 53 9 78-69 Gear Sector Control Cruise 09 53 9 95-9 Rod Control Cruise 0 53 9 78-60 Rocker Asm. Pedal Control 53 0-83 Bearing Nylon 3 53 40 3-9 Knob Control Cruise 4 53 40 7- Pedal Forward 5 53 40 7-3 Pedal Reverse 6 53 9 6-3 Bracket Pulley Idler 0 53 9 89-08 Reflector RH 53 40 3-87 Retainer Spring Clip Handle 89 0-0 Washer /3 x -/4 x 0 Ga. 5 53 40 33-9 Keeper Belt Trans. 6 53 40 08-3 Bracket Mount Touque 30 53 8 89-67 Washer Harden inch = 5.4 mm 37
ENGINE 87 8 0 8 45 69 6 7 5 9 84 79 70 8 37 3 4 4 85 8 90 9 37 9 SPARK ARRESTER KIT engine-tex_bs-cyl_9 38
ENGINE - - - - - - Engine Briggs Model No. 44P777 53 4 97-3 Muffler 9 53 9 43-0 Keeper Belt Engine 53 7 93-35 Clutch Electric 53 9 43-43 Pulley Engine 5 53 9 34-99 Tank Fuel 4.0 8 53 9 4-67 Cap Asm 0 53 7 83-85 Control Throttle 53 4 63-58 Screw #0 x.750 BOS Thread 53 9 5-96 Control Choke 8 53 40-35 Fuel Line 9 53 3 7-80 Spark Arrester Kit 3 53 4 50-06 Clip Push-In 37 53 34-87 Clamp Hose 4 53 6-97 Washer -/ OD x 5/3 ID x.50 4 80 04 07-00 Washer Lock 7/6 45 873 5 04-00 Nut Keps Hex /4-0 unc 6 53 4 66-9 Shield Heat Muffler 69 53 6 53-9 Gasket 70 53 5 99-55 Tube Exhaust LH 7 53 6 05-89 Tube Exhaust RH 79 53 8 39-06 Screw Socket Head 5/6-8 x 8 53 4 84-56 Tube Drain Oil Easy 8 53 8 6-54 Plug Drain Oil 84 87 06 06-0 Screw 3/8-6 x /4 85 53 7 99-53 Bolt Hex 7/6-0 x 3.75 Gr. 5 87 53 9 8-39 Bolt 5/6-8 unc x w/sems 90 87 00 06-6 Screw 3/8-6 x 9 53 8 74-95 Bushing inch = 5.4 mm For engine service and replacement parts, call the toll free number for your engine manufacturer listed below: Briggs & Stratton -800-33-373 Engine Power Rating Information The gross power rating for individual gas engine models is labeled in accordance with SAE (Society of Automotive Engineers) code J940 (Small Engine Power & Torque Rating Procedure), and rating performance has been obtained and corrected in accordance with SAE J995 (Revision 00-5). Actual gross engine power will be lower and is affected by, among other things, ambient operating conditions and engine-to-engine variability. Given both the wide array of products on which engines are placed and the variety of environmental issues applicable to operating the equipment, the gas engine will not develop the rated gross power when used in a given piece of power equipment (actual on-site or net horsepower). This difference is due to a variety of factors including, but not limited to, accessories (air cleaner, exhaust, charging, cooling, carburetor, fuel pump, etc.), application limitations, ambient operating conditions (temperature, humidity, altitude), and engine-to-engine variability. Due to manufacturing and capacity limitations, Briggs & Stratton may substitute an engine of higher rated power for this Series engine. 39
STEERING ASSEMBLY 53 9 39-43 Wheel, Steering 53 9 59-68 Axle Asm., Front 4 53 40 30-89 Spindle Asm., LH 5 53 40 30-90 Spindle Asm., RH 6 53 49-3 Bearing, Race Thrust Harden 7 53 7-48 Washer 5/3 x -5/8 x 6 Ga. 8 8 00 00-9 Ring, Clip #T5304-75 9 53-3 Cap, Spindle 3 53 7-49 Washer 5/3 x -/4 x 6 Ga. 4 80 04 06-00 Washer, Lock Hvy Hlcl Spr 3/8 5 873 54 06-00 Nut, Crown Lock 3/8-4 unf 6 53 40 8-9 Shaft Steering 9 53 9 47-9 Plate Steering 53 8 67-37 Adapter, Wheel Steering 53 9 48-45 Bushing, Strg. Blk 6 53 9 36-5 Insert, Wheel Steering 8 87 00 06- Screw 3/8-6 x 3/4 35 53 9 47-3 Gear, Sector Plate 45 89 8 38- Washer 9/6 x -3/8 x Ga. 5 873 94 08-00 Nut Hex Jam Toplock /-0 unf 53 53 8 89-67 Washer Hardened.793 x.637 x.060 57 53 9 7-46 Bracket Upstop 58 53 9 47-47 Bolt Shoulder Sector Pivot CFM 59 53 9 47-48 Washer Thrust Sector Steering 60 873 97 0-00 Nut Flange Lock 5/8-6 53 9 47-40 Draglink, LH 6 53 9 47-4 Draglink, RH 63 87 00 05- Screw 5/6-8 x 3/4 64 53 9 98-49 Retainer Clip Spring Steering 66 87 0 07-48 Bolt Hex Fghd 7/6-4 x 3 Serr 67 53 9 47-37 Bushing PM Front Axle 68 873 90 07-00 Nut Lock Flange 7/6-4 Gr. 5 69 53 9 9-6 Washer.5 x.505 x.8 70 53 9 6-97 Bracket Deck Susp. Front inch = 5.4 mm 40
SEAT ASSEMBLY 8 8 8 7 7 8 4 40 0 6 37 44 6 37 43 3 seat-tex_6.5sl_3 53 40 66- Seat 53 8 0-66 Bracket Pivot Fender 3 53 4 06-75 Strap, Asm Fender 6 873 80 06-00 Nut, Lock w/ins. 3/8-6 unc 7 53 4-8 Spring, Seat Cprsn 8 53 7 8-77 Bolt 5/6-8 unc x 3/4 w/sems 0 53 9 69-77 Pan, Seat 53 7 8-5 Bolt, Shoulder 5/6-8 37 873 80 05-00 Nut, Lock 5/6-8 unc 40 53 9 76-6 Handle Slide Seat 4 53 9 8-00 Spring Latch Seat 43 874 76 06- Bolt 3/8-6 x 3/4 44 89 3 38- Washer 3/3 x -3/8 x Ga. inch = 5.4 mm 4
MOWER DECK 46 46 47 6 4 85 39 34 9 49 43 5 7 46 98 3 33 97 08 96 5 49 33 3 3 33 3 30 6 7 0 49 3 94 59 6 9 50 60 9 5 6 4 7 8 8 5 90 89 4 58 87 90 3 88 8 87 8 mower_deck 54-tex_4_r 4
MOWER DECK 53 40 3-5 Deck Weldment Mower 6 53 9 60-66 Cover Mandrel LH 7 53 9 7-8 Cover Mandrel RH 8 53 7 43-65 Bolt 7/6 Asm. Blade 53 8 7-56 Blade Bagging - - 53 8 7-55 Blade Mulching 53 40 48-5 Rod Anti Sway 3 53 8 7-9 Shaft Asm. w/lower Bearing 4 53 8 7-8 Housing, Mandrel 6 89 3 3- Washer 3/8 5 53 04-85 Bearing, Ball, Mandrel 8 87 4 05-05 Bolt Carriage 5/6-8 x 5/8 9 53 9 4-08 Pin Cotter 5/6 Bowtie 873 68 05-00 Nut, Crownlock 5/6-8 unc 4 53 0 53-04 Cap Sleeve 5 53 7 8-0 Spring, Torsion 6 53 04-5 Nut, Push 7 53 8 89-38 Deflector Shield 9 53 3 4-9 Rod, Hinge 30 53 7 39-84 Screw, Thdroll Washer Head 3 53 8 76-90 Washer, Spacer Mower Vented 3 53 5 35-35 Pulley, Mandrel 33 53 40 0-34 Nut, Flg. Top Lock 34 873 68 06-00 Nut Crownlock 3/8-6 unc 39 53 9 73-80 Pulley, Idler, Stationary LH 43 53 9 60-65 Arm, Idler 46 53 3 77-9 Screw, Thdroll. /4-0 x 5/8 47 53 9 6-03 Belt Deck Drive 49 873 90 06-00 Nut, Lock Flg. 3/8-6 unc 50 87 06-6 Bolt Rdhd Sqnk 3/8-6 unc x 5 53 9 73-79 Pulley Idler 58 53 8 73-4 Baffle Right 59 53 8 73-44 Baffle Left 60 53 8 76-07 Baffle Center 97 53 7 85-5 Washer Hardened 98 53 9 6-05 Spring Drive 3 87 05-08 Bolt Rdhd Sqnk 5/6-8 x 3/4 4 53 8 75-56 Rod Tension Relief 6 53 9 34-06 Bolt, Shoulder 7 53 7 48-73 Gauge Wheel 0 89 3 0- Washer 3/3 x -/4 x Ga. 53 8 75-57 Bushing Tension Relief 85 873 90 07-00 Nut Lock Flange 7/6-4 Gr. 5 87 53 9 5-6 Stud Fastener w/"d" Anti-Rotation 88 873 90 05-00 Nut Lock Hex Flange 89 53 9 5-85 Arm Susp. Mower Rear 90 53 9 65-39 Bolt Shoulder 9 53 9 84-68 Keeper Belt Idler 94 87 4 07-6 Bolt Carr Sqnk 7/6-4 x 96 87 4 06-0 Bolt Rdhd 3/8-6 x -/ Gr. 5 08 87 67 06-08 Screw Thdrol 3/8-6 x / - - 53 8 7-9 Mandrel Asm. Service (Includes Key Nos. 3-5 and 33) - - 53 9 93-00 Replacement Mower, Complete inch = 5.4 mm 43
MOWER LIFT 7 87 87 90 98 3 0 88 97 89 97 9 87 89 lift-tex_3 89 87 53 9 5-3 Shaft Asm., Lift 3 53 9 5-30 Lever Asm., Lift RH 7 53 4 5-55 Grip, Lever 0 53 9 63-4 Spring Torsion 87 53 9 4-09 Pin Cotter 7/6 Bow Tie Lock 88 53 9 53-04 Spring Lift Assist 89 89 9 9- Washer Clear Zinc 90 53 9 4-08 Pin Cotter 5/6 Bow Tie Lock 9 53 40 34-07 Link Lift Susp Mower Rear 97 87 00 06- Screw 3/8-6 x 3/4 98 53 9 5-64 Link Lift Susp. Front Mower inch = 5.4 mm 44