Spare Parts Manual Raptor+ Thermal 6/5
Spare Parts Manual Raptor+ Thermal 6/5 Edition CA, November 2012 This book has part No. 1006135
0-2 General information This manual Part 0: General information This manual Products covered This manual is valid for: Raptor + Thermal 6 from serial no 10061-0001. Raptor + Thermal 5 from serial no 100610-00. The serial number is specified on the processor name plate located on the rear end of the tank on the left side (when standing behind the processor). This manual is for Service Technicians only. The directions given must not be followed by unauthorized personnel. Always read the Safety Instruction Manual part No 211 before installing or operating the equipment. This manual is published by: GLUNZ & JENSEN A/S Selandia Park 1 DK-100 Ringsted Denmark Phone:+5 5 6 1 1 E-mail: gjhq@glunz-jensen.com Internet: www.glunz-jensen.com Copyright 20 by GLUNZ & JENSEN A/S. Spare Parts Manual - Raptor+ Thermal 6/5 12
0-3 Reservations This manual was written and illustrated using the best possible information available at the time of publication. Any differences between this manual and the equipment reflect improvements introduced after the publication of the manual. Changes, technical inaccuracies and typographic errors will be corrected in subsequent editions. As a part of our policy of continuous improvement, we reserve the right to alter design and specifications without further notice. 12 Spare Parts Manual - Raptor+ Thermal 6/5
0- Table of contents Part 0: General information... 0- This manual....0- Products covered...0- Reservations...0-3 Table of contents...0- Part 1: Spare parts... 1-1 Spare parts kit...1-1 Ordering spare parts...1-1 Finding a spare part...1-1 Software...1-1 Preventive Maintenance Kit Program....1-2 Panels...1-3 Stand...1-5 Stand, closed... 1- Exit, table...1- Feed table....1- Handshower...1-13 Pump / circulation... 1-15 Hoses and clamps...1-1 Drive...1-21 Developer...1- Wash...1-2 Gum...1-2 Dryer...1-31 Electrical....1-33 Additional spare parts :...2-1 Spare Parts Manual - Raptor+ Thermal 6/5 12
Spare parts 1-1 Part 1: Spare parts Spare parts kit A small kit consisting of the most needed spare parts is delivered with the processor. For further need of spare parts please refer to the spare part lists in this chapter with iso-metric drawings, descriptions and part numbers. Ordering spare parts When ordering spare parts please state carefully the spare part number, the part specification and the number of items wanted and send the order to your spare parts dealer. The cable spare part numbers can be found in the electrical diagram which is placed in Appendix A in the processor's Service Manual. Finding a spare part 1 2 3 Spare parts Drive plate Spare parts Drive plate 5 10 13 Gum Pos. No 6 5 1 1 3600 3600 BEARING, ROLLER, SNAP, BLACK 2 3262 3262 GEAR, Z1, M2, D12, B15 10 3 03 321 03 321 GUIDE, PLATE, GEAR CLIPS, R-SHAPE, D2.5X20 1 2 12 13 5 6 1000515 100013 1000515 BEARING, ROLLER, DISTR., GUM 100013 BEARING, ROLLER, WHITE, 13 KG, COMPLETE 3 1 10005 226 1000335 10005 BUSHING, SPRING 226 SPRING, D12.5, T1.6, L1, K12.3 1000335 SPRING, SILICONE, SPRAY 10 5 3 ROLLER, SH30, STRAIGHT, WITH GEAR 6 5 5 6 12 13 1 15 60 226 226 226 ROLLER, SH0, 65 100563 ROLLER, SH0, 50, BULGED 1001 TUBE, GUM 10002 ROLLER, PUR, D30 10003 GUIDE, GUM 16 1 1 1 20 21 22 2 25 T6 26 2 GUM 2 3 Spare Parts Manual - Plate Processor 6/5 22 22 Spare Parts Manual - Plate Processor 6/5 T31 1. Find the pages covering the section where the part is located. 2. Find the specific part and the part s Pos. No. on the drawing. 3. Refer to the list on the opposite page to find the spare part s number and specification. Software All spare part PCB's with software proms will be delivered without software installed. The Service Technician must download the software and the upgrade instruction from the manufacturers web site www.glunz-jensen.com/support. 12 Spare Parts Manual - Raptor+ Thermal 6/5
1-2 Spare parts Preventive Maintenance Kit Program Preventive Maintenance Kit Program To ensure continues high quality and maximize productivity and processor up-time, it is recommended to carry out preventive maintenance at regular intervals. To facilitate this a Preventive Maintenance Program has been developed, consisting of a number of relevant service-parts to be replaced at specific service intervals. It is recommended that the following Preventive Maintenance Kits are implemented, at the mentioned intervals, at which point the cycle will start over. Minor Preventive Maintenance 1006213 at 500 production hours or every year what comes first. Medium Preventive Maintenance 100621 at 1000 production hours or every year what comes first. Minor Preventive Maintenance 1006213 at 1500 production hours or every year what comes first. Major Preventive Maintenance 1006215 at 2000 production hours or every year what comes first. Read more about our Preventive Maintenance Kits onwww.glunz-jensen.com and see the content of the Preventive Maintenance Kits - or contact us at order-department@glunz-jensen.com. Spare Parts Manual - Raptor+ Thermal 6/5 12
Spare parts Preventive Maintenance Kit Program 1-3 12 Spare Parts Manual - Raptor+ Thermal 6/5
1-2 Spare parts 5 6 3 13 3 10 1 12 2 T5 PANELS Spare Parts Manual - Raptor+ Thermal 6/5 12
Spare parts Panels 1-3 Panels Pos. No 6 5 Specification 1 SEE APPENDIX 2 SEE APPENDIX 3 35362 35362 HANDLE, SOUTHCO TP. P2- SEE APPENDIX 5 526 526 HINGE, SOUTHCO, 6-50-510-50 6 52 52 HINGE, SOUTHCO, 6-50-520-50 1000 SPRING, GAS, 200N, 265,5/100, 321PI,DAMPED 1000120 SPRING, GAS, 250N, 265.5/100, 26TP,DAMPED 25 25 CIRCLIP DX0. RA---ME DIN 6 SEE APPENDIX 10 51 51 ROLLER, W/HOLDER 15262 15262 NUT M6/D10X1 12 1001206 1000 GUIDE, EXIT, ROLLER 13 51 51 ACTUATOR, SAFETY, SWITCH 1 15 16 1 1 1 20 21 22 2 25 26 2 2 2 12 Spare Parts Manual - Raptor+ Thermal 6/5
1- Spare parts 5 6 3 2 5 1 3 2 12 10 T5 STAND Spare Parts Manual - Raptor+ Thermal 6/5 12
Spare parts Stand 1-5 Stand Pos. No 6 5 Specification 1 SEE APPENDIX 2 006366 006366 BUSHING 25-66 3 SEE APPENDIX 1000161 1000161 BRACKET,ATTACHMENT,STAND 5 565 565 BUSHING, 25-6, D5/50X1.6 6 SEE APPENDIX 13 13 STOPPER D120X10 1000615 1000615 GASKET, D1/33/2 3535 3535 BUSHING, TRAPEZOID, D0X2 10 35360 35360 NUT, LEG, ADJ.TRAPEZOID 36-KM 1 3535 3535 LEG, TRAPEZOID, D0, METAL 12 513 513 LEG, TRAPEZOID 13 1 15 16 1 1 1 20 21 22 2 25 26 2 2 2 30 12 Spare Parts Manual - Raptor+ Thermal 6/5
1-6 Spare parts 1 2 1 3 T5 STAND CLOSED Spare Parts Manual - Raptor+ Thermal 6/5 12
Spare parts Stand, closed 1- Stand, closed Pos. No 6 5 Specification 1 352 352 LATCH, SWELL FOR PANEL, SIDE, STAND 2 506 506 BRACKET, LATCH 3 SEE APPENDIX SEE APPENDIX 5 6 10 12 13 1 15 16 1 1 1 20 21 22 2 25 26 2 2 2 30 12 Spare Parts Manual - Raptor+ Thermal 6/5
1- Spare parts 1 2 6 3 5 T52 EXIT TABLE Spare Parts Manual - Raptor+ Thermal 6/5 12
Spare parts Exit, table 1- Exit, table Pos. No 6 5 Specification 1 1000521 1000233 EXTENSION, TABLE, EXIT 2 100051 1000232 TABLE, EXIT 3 100022 100022 BRACKET, TABLE, EXIT 601 601 SUPPORT, TABLE, EXIT 5 50 50 LINCH PIN D1X.5, PLATED YELLOW 6 616 616 EDGE, PROFILE, TABLE, EXIT 10 12 13 1 15 16 1 1 1 20 21 22 2 25 26 2 2 2 30 12 Spare Parts Manual - Raptor+ Thermal 6/5
1-10 Spare parts 10 5 6 3 1 2 T53 FEED TABLE Spare Parts Manual - Raptor+ Thermal 6/5 12
Spare parts Feed table 1- Feed table Pos. No 6 5 Specification 1 100005 10000 TABLE, FEED 2 1000056 100002 SUPPORT, TABLE, FEED 3 531 531 PIN, GUIDE, TABLE, FEED 15262 15262 NUT M6/D10X1 5 10060310 100601 PANEL, FRONT, COMMON 6 521 6 GUIDE, ENT, UP 51 51 ROLLER, W/HOLDER 026 026 STOP, EMERGENCY 522 0 BRACKET, SENSOR, INPUT 10 16 16 SWITCH, ASSY 10-5220-010 15263 15263 SCR M6X30 HE ELZ 12 13 1 15 16 1 1 1 20 21 22 2 25 26 2 2 2 30 12 Spare Parts Manual - Raptor+ Thermal 6/5
1-12 Spare parts 1 2 3 5 6 T5 HANDSHOWER AND CONTAINER LEVEL SENSORS Spare Parts Manual - Raptor+ Thermal 6/5 12
Spare parts Handshower 1-13 Handshower Pos. No 6 5 Specification 1 35315 35315 HOLDER, PIPE D20 2 3 3 GASKET, EPDM, SHORE0, 2X1X2 3 10006 10006 FITTING, HANDSHOWER 10003060 10003060 HOSE, 1/2"X3/"RGX2.5M 5 5 5 GASKET, FIBER, ½", D1X12.5X2 6 00361 00361 FIT. VALVE, BALL ½" MA/FE 1000302 1000302 CHECKVALVE, DW1/DN10GF 301 301 JET, SHOWER, RAPTOR 532 532 HOLDER, PIPE, D16, W.LOCK 10 12 13 1 15 16 1 1 1 20 21 22 2 25 26 2 2 2 30 12 Spare Parts Manual - Raptor+ Thermal 6/5
1-1 Spare parts 6 3 1 3 2 5 50 51 2 B 52 51 50 3 5 6 A 1 0 2 10 36 35 3 3 25 33 C 3 5 3 30 32 31 26 2 2 2 2 22 1 1 20 21 20 22 15 1 12 1 13 16 A C B 53 53 5 5 5 55 56 T61 PUMP/CIRCULATION Spare Parts Manual - Raptor+ Thermal 6/5 12
Spare parts Pump / circulation 1-15 Pump / circulation Pos. No 6 5 Specification 1 2 2 STANDPIPE 2 616 616 O-RING D20X2 3 15 15 SPRING, STANDPIPE D30X25 3016 3016 BRACKET, DRAIN, OVERFLOW 5 500 500 STANDPIPE, DEV 6 10005 10005 BUSHING, SPRING 226 226 SPRING, D12.5, T1.6, L1, K12.3 1000335 1000335 SPRING, SILICONE, SPRAY 100006 100006 SWITHC, FLOAT, SENSOR, 15KOhm Res. 10 21060 10060 HOSE Y 3/" 135 135 CLAMP, CABLE 1" TP.330 WH PL 12 532 532 HOLDER, PIPE, D16, W.LOCK 13 1000303 1000303 VALVE, SOLENOID, D13.5, 15L FOR TAP WATER 1 1000552 1000552 VALVE,SOLENOID, D13.5, 3,3L RECIRCULATION 15 10003506 10003506 HOSE, PUMP, MD-15, CIRC. WASH 16 0 0 DRAIN VALVE ½" 1 35 35 FILTER, BOTTOM. 1 SEE APPENDIX 1 0012153 0012153 O-RING FOR FILTER CARTRIDGE 20 2530 2530 O-RING D2.X3.53 21 35 35 FILTER, TOP 22 100010 100010 FITTING, ELBOW, SWIVEL, ¾" 2 2 NUT, UNION, MALE, 3/"RG X 16.3 2 X00000 X00000 O-RING, 15. X 2.62 25 5 5 CARTRIDGE, HEATER, 1000W, W CABLE 26 1001251 1001251 FIT.HOSE 16X16 GS16 2 100052 100052 TUBE, CIRCULATION, MODIFIED 2 1000531 1000531 TUBE, CIRCULATION, MODIFIED 2 356 356 FITTING, Y, 16-16-16 30 35355 35355 O-RING D5.0X2.5 EPDM 12 Spare Parts Manual - Raptor+ Thermal 6/5
1-16 Spare parts 6 3 1 3 2 5 50 51 2 B 52 51 50 3 5 6 A 1 0 2 10 36 35 3 3 25 33 C 3 5 3 30 32 31 26 2 2 2 2 22 1 1 20 21 20 22 15 1 12 1 13 16 A C B 53 53 5 5 5 55 56 T61 PUMP/CIRCULATION Spare Parts Manual - Raptor+ Thermal 6/5 12
Spare parts Pump / circulation 1-1 Pump / circulation Pos. No 6 5 Specification 31 00 00 FITTING, BUSHING, 3/"RGXD6 32 32 32 SENSOR, TEMP NTC (0mm CABLE) 33 1000622 1000622 HOSE, ELBOW 0, MODIFIED 3 1006031 1006031 PUMP, CIRCULATION, MEDIUM 35 10053 10053 HOSE, ELBOW, 0, MODIFIED 36 1006215 1006215 PUMP, CIRCULATION, LOW 3 100151 100151 NUT, M16, SWITCH, FLOAT 3 3536 3536 O-RING D16.3X2. FPM 3 10061566 10061566 PUMP, BELLOW, KBR-3X, W.PLUG 0 10003 10003 TUBE, CIRCULATION, MODIFIED 1 22006 22006 FITTING, TEE, HOSE, D12, ACETAL 2 1000525 1000525 TUBE, CIRCULATION, MODIFIED 3 250 250 FITTING, REDUCTION, HOSE, D12XD10, GRS12-10 2552 2552 FIT.TEE, HOSE D10X0' TS10 5 100621 100621 PUMP, OSCILLATION, 26W 6 10003122 10003122 BRACKET, PUMP, REPL./OSC. 1006156 1006156 PUMP, BELLOW, KBR-2XAU3M, WITH PLUG 3631 3631 FITTING, INLET, PUMP 3632 3632 FITTING, OUTLET, PUMP 50 3633 3633 FITTING, NUT, PUMP 51 100031 100031 VALVE, POPPET, ASSEMBLY, PUMP, BELLOW 52 100002 100002 O-RING, ASSEMBLY, PUMP, BELLOW 53 1000522 1000522 TUBE, SUCTION, DEV/GUM 5 100022 100022 SENSOR, LEVEL, 2-PIN, REPLENISH/WASTE 55 1000561 1000561 TUBE, SUCTION, D/DL0 56 152 152 VALVE, CHECK 1/" 5 263 263 CONN. RECEPT. MINIFIT 5 5 60 12 Spare Parts Manual - Raptor+ Thermal 6/5
CLEAR PVC BLUE PVC CLEAR PVC 1-1 Spare parts 1 2 3 5 6 BLACK EPDM BLACK EPDM CLEAR PVC RED PVC Ø20 Ø2 Ø2 Ø Ø1 Ø1 Ø1 10 10 12 T55 HOSES AND CLAMPS Spare Parts Manual - Raptor+ Thermal 6/5 12
Spare parts Hoses and clamps 1-1 Hoses and clamps Pos. No 6 5 Specification 1 600 600 HOSE 1/2", REINFORCED (PER M) 2 100050 100050 HOSE, RUBBER, 1X.5MM, EPDM, BLACK 3 100560 100560 HOSE, RUBBER, D16XMM, EPDM, BLACK 25 25 HOSE, D16 MM, REINF. (PER M 5 10001636 10001636 HOSE, PVC, X13, BLUE 6 10001635 10001635 HOSE, PVC, X13, RED 601 601 HOSE,D10/1MM,PVC,CLEAR (PER M) 601 601 CLAMP, HOSE, D-22 602 602 CLAMP, HOSE, D20-32 10 63 63 CLAMP, HOSE D13-2 6332 6332 CLAMP, HOSE D-1mm 12 15510 15510 CLAMP, HOSE D-1mm 13 1 15 16 1 1 1 20 21 22 2 25 26 2 2 2 30 12 Spare Parts Manual - Raptor+ Thermal 6/5
1-20 Spare parts 1 16 1 1 2 3 5 6 10 1 22 1 30 20 21 22 20 2122 2 2 25 1 13 12 12 1 15 15 15 2 15 26 T60 DRIVE Spare Parts Manual - Raptor+ Thermal 6/5 12
Spare parts Drive 1-21 Drive Pos. No 6 5 Specification 1 320 320 GEAR, Z22, M2, LEFT 2 1000210 1000210 BEARING, DRIVE 3 10002 10002 O-RING D21X1.5 EPDM 321 321 CLIPS, R-SHAPE, D2.5X20 5 10002653 10002653 GEAR, CONICAL, Z20,M1.5,D12 6 10002651 10002651 SHAFT, DRIVE, BRUSH,WASH 100210 100210 BEARING, DRIVE, BRUSH 616 616 O-RING D20.2X2.62 EPDM 631 631 GEAR, CONICAL, Z30(20), M1.5 10 1000163 100163 GEAR, Z26, M2, D12 1000262 1000262 GEAR, Z16, M2, D12 12 10013531 10013531 MOTOR, AF 103.606 2V W. SENSOR 13 326 326 GEAR, Z1, M2 1 1000203 1000203 SHAFT, DRIVE, BRUSH, DEV 15 102 102 BRACKET, BEARING 16 322 322 SHAFT, GEAR 1 6520 6520 GROMMET, V-SEAL 1 320 320 GEAR, Z16, M2 1 3250 3250 WORM, LEFT, Z2, M2, D12 20 1001622 1001622 GROMMET, V-SEAL VA 12 (FPM) 21 6302 6302 O-RING, D1.1x1.6 22 1001530 1001530 SUPPORT, SEAL, BEARING, BRUSH 100163 100163 GEAR, Z26, M2, D12 2 326 326 SHAFT, DRIVE, MAIN 25 10005522 10005522 SHAFT,INTERMEDIATE WHEEL 26 100625 100625 DRIVE, MAIN, COMPLETE 2 3262 3262 GEAR, Z1, M2, D12 2 10052622 10052622 SHAFT, GEAR, W. O-RING 2 100526 100526 SHAFT, GEAR, BRUSH, W. O-RING 30 1005200 1005200 GEAR Z13 D10/2X6 M=2 12 Spare Parts Manual - Raptor+ Thermal 6/5
1-22 Spare parts 1 2 1 2 1 3 5 6 10 12 1 1 3 2 22 3 0 22 2 26 2 2 25 10 12 12 1 1 22 25 2 26 2 1 22 3 33 21 21 13 2 30 31 32 3 15 1 32 33 32 16 20 35 3 32 36 20 32 16 3 35 36 32 1 T62 3 15 DEVELOPER Spare Parts Manual - Raptor+ Thermal 6/5 12
Spare parts Developer 1- Developer Pos. No 6 5 Specification 1 1001520 1001520 BRACKET, ROLLER 2 006132 006132 CIRCLIP, A12-, DIN1 A2 3 1000 10002 ROLLER, PUR, D30, HEAVY, ST 100025 1000255 SHAFT, ROLLER, D12 5 100001 1000220 LID, CONDENSATION, DEV 6 6 6 HANDLE, BLACK 5 3 ROLLER, SH30, STRAIGHT, WITH GEAR 60 ROLLER, SH0, 65 100563 ROLLER, SH 0, 50, BULGED 100000 1000 TUBE, SPRAY, DEV, REAR 10 1000 1000 GUIDE, DEV, REAR SEE APPENDIX 12 321 6351 ROLLER, PUR, D0 13 1000 1000 BEARING, ROLLER, RIGHT 1 1001 1001 BEARING, ROLLER, LEFT 15 10006 10006 BEARING, BRUSH, LEFT 16 253 253 O-RING D22.1X1.6 1 5 15 TUBE, SPRAY, DEV, FRONT 1 10003 100063 GUIDE, DEV, FRONT 1 100025 100022 ROLLER, RUBBER, D25 20 313 313 BUSHING, SUPPORT, TUBE 21 100013 100013 BEARING, BRUSH, RIGHT 22 3600 3600 BEARING, ROLLER, SNAP, BLACK 3262 3262 GEAR, Z1, M2, D12, B15 2 03 03 GUIDE, PLATE, GEAR 25 1000666 1000666 NUT, M22 26 1000660 1000660 VALVE, TUBE, SPRAY 2 353 353 O-RING 13.3x2. EPDM 2 321 321 CLIPS, R-SHAPE, D2.5X20 2 100026 100026 TUBE, COOLING 12 Spare Parts Manual - Raptor+ Thermal 6/5
1-2 Spare parts 1 2 1 2 1 3 5 6 10 12 1 1 3 2 22 3 0 22 2 26 2 2 25 10 12 12 1 1 22 25 2 26 2 1 22 3 33 21 21 13 2 30 31 32 3 15 1 32 33 32 16 20 35 3 32 36 20 32 16 3 35 36 32 1 T62 3 15 DEVELOPER Spare Parts Manual - Raptor+ Thermal 6/5 12
Spare parts Developer 1-25 Developer Pos. No 6 5 Specification 30 30 30 NUT, COOLING, D12 31 X000600 X000600 O-RING 12 x 3 32 10005 10005 BEARING, ROLLER, GUIDE 33 100013 100013 BEARING, ROLLER, WHITE, 13 Kg 3 226 226 SPRING, D12.5, T1.6, L1, K12.3 35 1000335 1000335 SPRING, SILICONE, SPRAY 36 10005 10005 BUSHING, SPRING 3 1000621 1000621 SHELL, BEARING 3 530 530 BEARING, ROLLER, LOWER SPRINGLOAD 3 100066 100066 GUIDE, SILICONE 0 315FJ0055 315FJ0055 CIRCLIP, STAINLESS 1 100006 100006 BEARING, ROLLER, DARK GREY, 6 Kg 2 SEE APPENDIX 3 SEE APPENDIX 5 6 50 51 52 53 5 55 56 5 5 5 12 Spare Parts Manual - Raptor+ Thermal 6/5
1-26 Spare parts 13 10 12 1 1 2 10 12 3 13 1 5 6 6 5 1 2 21 20 3 22 21 21 1 1 21 1 15 16 20 1 16 T63 WASH Spare Parts Manual - Raptor+ Thermal 6/5 12
Spare parts Wash 1-2 Wash Pos. No 6 5 Specification 1 3600 3600 BEARING, ROLLER, SNAP, BLACK 2 3262 3262 GEAR, Z1, M2, D12, B15 3 03 03 GUIDE, PLATE, GEAR 353 353 O-RING 13.3x2. EPDM 5 1000660 1000660 VALVE, TUBE, SPRAY 6 1000666 1000666 NUT, M22 321 321 CLIPS, R-SHAPE, D2.5X20 5 3 ROLLER, SH30, STRAIGHT, WITH GEAR 60 ROLLER, SH0, 65 100563 ROLLER, SH 0, 50, BULGED 10 100063 1000626 TUBE, SPRAY, WASH, REAR, COMPLETE 100013 100012 BRUSH, D0, WITH GEAR ( BLACK BRUSH ) 12 321 6351 ROLLER, PUR, TUBE, D0 13 10063 1005533 TUBE, SPRAY, WASH, FRONT, DB. ROW 1 226 226 SPRING, D12.5, T1.6, L1, K12.3 15 1000335 1000335 SPRING, SILICONE, SPRAY 16 10005 10005 BEARING, ROLLER, GUIDE 1 253 253 O-RING D22.1X1.6 1 313 313 BUSHING, SUPPORT, TUBE 1 10005 10005 BUSHING, SPRING 20 100013 100013 BEARING, BRUSH, RIGHT 21 100013 100013 BEARING, ROLLER, WHITE, 13 Kg 22 530 530 BEARING, ROLLER, LOWER, SPRINGLOAD 1000621 1000621 SHELL, BEARING 2 25 26 2 2 2 12 Spare Parts Manual - Raptor+ Thermal 6/5
1-2 Spare parts 10 13 1 10 1 2 12 13 3 1 15 6 6 5 5 T6 GUM Spare Parts Manual - Raptor+ Thermal 6/5 12
Spare parts Gum 1-2 Gum Pos. No 6 5 Specification 1 3600 3600 BEARING, ROLLER, SNAP, BLACK 2 3262 3262 GEAR, Z1, M2, D12,B15 3 03 03 GUIDE, PLATE, GEAR 321 321 CLIPS, R-SHAPE, D2.5X20 5 1000515 1000515 BEARING, ROLLER, DISTR., GUM 6 100013 100013 BEARING, ROLLER, WHITE, 13 KG, COMPLETE 10005 10005 BUSHING, SPRING 226 226 SPRING, D12.5, T1.6, L1, K12.3 1000335 1000335 SPRING, SILICONE, SPRAY 10 5 3 ROLLER, SH30, STRAIGHT, WITH GEAR 60 ROLLER, SH0, 65 100563 ROLLER, SH 0, 50, BULGED 12 10016 1001 TUBE, GUM 13 1000 10002 ROLLER, PUR, D30 1 000 10003 GUIDE, GUM 15 530 530 BEARING, ROLLER, LOWER, SPRINGLOAD 16 1 1 1 20 21 22 2 25 26 2 2 2 12 Spare Parts Manual - Raptor+ Thermal 6/5
1-30 Spare parts 10 12 13 5 6 6 1 10 20 3 2 16 1 1 1 21 22 1 15 21 T65 DRYER Spare Parts Manual - Raptor+ Thermal 6/5 12
Spare parts Dryer 1-31 Dryer Pos. No 6 5 Specification 1 100025 100025 HOUSING, FAN/HEATER 2 5563 5563 CAPACITOR, 2uF 3 32 32 FAN, 2TRE15 W PLUG 6303 6303 HEATER 2x50W W.PLUG 5 1000331 1000331 COVER, FAN, HEATER 6 3262 3262 GEAR, Z1, M2, D12, B15 603 602 COVER, DRYER, COMPLETE 321 321 CLIPS, R-SHAPE, D2.5X20 10013520 10013520 BEARING, ROLLER, SNAP 10 1000226 1000226 WHEEL, RUBBER, D0 10003013 10003010 GUIDE, ROLLER, D0 12 1000301 100030 GUIDE, ROLLER, D0 13 1000065 10006012 AIRDUCT, UPPER 1 100000 100060 AIRDUCT, LOWER 15 015103 015103 GRID, FAN INCL.TAP 16 155 125 BRACKET, GUIDE, HEATER 1 332 332 GUIDE, DRYER 1 2635 2635 SENSOR, TEMP THERMISTOR,PLASTIC 1 16 16 SWITCH, ASSY 10-5220-010 20 500 500 BRUSH, ANTISTATIC 21 100013 100013 BEARING, ROLLER, WHITE, 13 KG, COMPLETE 22 530 530 BEARING, ROLLER, LOWER, SPRINGLOAD 2 25 26 2 2 2 30 12 Spare Parts Manual - Raptor+ Thermal 6/5
1-32 Spare parts 5 1 3 6 2 22 21 10 12 16 20 1 1 13 1 1 2 25 31 20 26 15 30 2 2 2 T66 ELECTRICAL Spare Parts Manual - Raptor+ Thermal 6/5 12
Spare parts Electrical 1-33 Electrical Pos. No 6 5 Specification Cable spare part numbers can be found in the electrical diagram which is placed in Appendix A in the processor's Service Manual. 1 1006136 1006136 SWITCH, INTERLOCK 2 10062 10062 COOLING, FAN 3 10 10 BAR, PVC, D30X22 6 6 BRACKET, CABINET, EL 5 2636 2636 PLUG, FEMALE, -POL. 6 1006005 1006005 BRACKET, MMI PANEL 10066 10066 KIT, SPARES, MMI, TFT 100532 100532 BOTTOM, BOX, FWB 5512 5512 SPACER, M6X35+10, TP.DI65 10 1006350 1006350 BLOCK, TERMINAL, W. BRACKET 10022 10022 FUSE F, 6.3A 12 161 161 RELAY, HPFI 0A/30mA 00V -POL 13 100531 100531 BOX, TOP 1 1005362 1005362 SWITCH, DISCONNECT, -CIRCUIT, 32A 15 1005566 1005566 FUSE F10, 2A 16 36500 36500 GLAND, CABLE, ST-M 32x1.5 1 6002 6002 PLATE, END, ELBOX RIGHT MPU 1 100555 100555 PSU, AC>DC, 0-2, 225, SEALED 1 100531 100531 SPACER, M3x5+35, BN 331.136 20 2501 2501 SPACER MX+10 TP.DI65 21 6001 6001 PLATE, END, ELBOX RIGHT HPU/HCU 22 50632 5032 TOP, BOX EL 3622 3622 PROFILE, EDGE TP.DX 2P 2 1006130 1006130 PLATE, END, ELBOX, LEFT 25 1005606 1005606 PCB, PCU, SPAREPART 26 1005316 1005316 PCB, FUP3 2 100133 100133 PCB, SYSTEM-ON-MODULE, LINUX 2 1006636 1006636 PCB, GNUC-II, MIO, SPARES 2 100551 100551 PLATE, END, ELBOX, GNUC I 30 2650 2650 FUSE F1-F6, 15A 12 Spare Parts Manual - Raptor+ Thermal 6/5
1-3 Spare parts 5 1 3 6 2 22 21 10 12 16 20 1 1 13 1 1 2 25 31 20 26 15 30 2 2 2 T66 ELECTRICAL Spare Parts Manual - Raptor+ Thermal 6/5 12
Spare parts Electrical 1-35 Electrical Pos. No 6 5 Specification Cable spare part numbers can be found in the electrical diagram which is placed in Appendix A in the processor's Service Manual. 31 1002 1002 FUSE F6-F, 1AT 32 33 3 3 35 36 3 3 3 0 1 2 3 5 6 50 51 52 53 5 55 56 5 5 5 60 12 Spare Parts Manual - Raptor+ Thermal 6/5
1-36 Spare parts Spare Parts Manual - Raptor+ Thermal 6/5 12
Appendix A: Additional spare parts 2-1 Appendix A: Additional spare parts Some of the spareparts shown on the ISO-metric drawings in Part 1 have no sparepart number and specification. The sparepart numbers and specification for those parts are listed below. The page and position numbers refer to the page and position numbers used in Part 1. When ordering spare parts please state carefully the spare part number, the specification and the number of items wanted before you send your order. Pos.No 6 5 Specification Page 1-2 (Panels): 1 10061213 10061213 PANEL, FENDER, RIGHT, POLYMER 2 02 02 FENDER, LEFT 0302 025 PANEL, TOP, HINGED 1001203 10056 COVER, DRYER Page 1- (Stand): 1 1000130 03 PANEL, FRONT, STAND 3 032 032 RAIL, STAND 6 10001312 032 PANEL, REAR, STAND Page 1-6 (Stand, closed): 3 0325 0325 PANEL, SIDE, LEFT, STAND 0326 0326 PANEL, RIGHT, STAND Page 1-1 (Pump / circulation): 1 150 150 INSERT, FILTER 50MY Page 1-32 (Developer) 55 526 BRUSH, D0, WITH GEAR, PP 0.10 (WHITE BRUSH) 100013 100012 BRUSH, D0, WITH GEAR, PP 0.05 (BLACK BRUSH) 12 Spare Parts Manual - Raptor+ Thermal 6/5
2-2 Appendix A: Additional spare parts Pos.No 6 5 Specification Page 1-3 (Developer) 2 5 3 ROLLER, EPDM RUBBER, SH30, GREY, WITH GEAR 1001321 100132 ROLLER, SILICONE, SH0, BLACK, WITH GEAR 3 5 3 ROLLER, EPDM RUBBER, SH30, GREY, WITH GEAR 1001320 10013 ROLLER, SILICONE, SH0, BLACK, WITH GEAR Spare Parts Manual - Raptor+ Thermal 6/5 12