Automatic Transmission Service power www.bluechemgroup.com
Automatic Transmission Cleaning Why? How? Modern automatic transmission fluids should be replaced at least every 50-60,000 km according to the manufacturers specifications. Some manufacturers even do not instruct change intervals. This is a so-called lifetime filling. However, even in compliance with the oil change intervals, damages or defects can occur. In contrast to manual transmissions, automatic transmission wear out considerably faster. By increasing wear and soiling of clutch plates and solenoid valves, the function of the transmission deteriorates gradually without the motorist being aware of this. Only when the performance of the transmission is significantly impaired, the costly damage is perceived. To avoid that, a cleaning of the automatic transmission system is recommended by more and more manufacturers. This service prevents costly repairs, helps with loss of power and restores a smooth/quiet gear operation. With a conventional oil change, not all contaminants can be removed from automatic transmissions. Approx. 60% of the waste oil remain in the gearbox. About 90% of all installed automatic transmission are concerned by this, because only the part of waste oil is removed, which is located in the oil pan. All other components such as heat exchangers and pipes, but especially the converter cannot be emptied. If the electrical and mechanical problems have caused no damage, the ATF EVOLUTION PREMIUM in combination with our products helps usually immediately. This automatic transmission service allows a complete replacement of the transmission fluid and a thorough cleaning of the transmission system in simple steps. The oil change for transmission, torque converter, exchangers and pipes is carried out within a short time. The exchange rate is almost 100%. The success of cleaning is immediately evident: the running is quieter, any bucking disappears and the gears are switching smooth and soft again. We recommend the preventive use, to avoid damage.
The Automatic Transmission Cleaning results in: Complete removal of contaminants in the entire transmission system Noise reduction Safe and smooth gear running Optimized gear changing behavior Avoidance of costly repairs www.bluechemgroup.com
ATF EVOLUTION PREMIUM Cleaning and service device for Automatic Transmissions Cleaning and maintenance of the entire transmission system: easily and quickly with just one device. The ATF EVOLUTION PREMIUM offers a range of automatic functions that supply the transmission expert with a simple tool to exchange the transmission fluid. The ATF EVOLUTION PREMIUM may be used in a manual operation as well. DSG ALSO WORKS WITH AUCH FÜR
Functions Flushing the AT systems (automatic transmission, torque converter, cooler and pipes) Oil exchange and level adjustment Print out the procedure and the vehicle data Monitoring temperature Monitoring oil pressure Customizable database www.bluechemgroup.com
ATF EVOLUTION PREMIUM Cleaning and service device for Automatic Transmissions Characteristics LCD display and compact design makes operation easy Automatic filling of automatic transmission fluid Automatic identification of the power polarity Automatic and intelligent switching of the fluid flow in and out Automatically circulated cleaning function for automatic transmissions Automatic exchange of new and used fluid Visual display the fluid pressure of A/F radiator and the fluid outlet pressure of the unit Intelligent electronic control of the full automatic amount of liquid exchanged of new and used fluid It improves the performance of the transmission, and it prolongs the working life of the AT system. Because of the compact design, the device is flexible and perfectly suited to the needs of any workshop Warranty 12 months Accessoiries The standard adapter set for automatic transmissions of various vehicle manufacturers is included in the delivery contents. The optional adapter set contains additional adapters for the brands Audi, BMW, Chrysler, Fiat, Ford, GM, Honda, Hummer, Lexus, Mercedes, Mitsubishi, Opel, Toyota, Volkswagen and Volvo. Device ATF EVOLUTION PREMIUM PU 1 pc. Art.-No. 34090-1 Optional accessories available on request.
Specifications Power Supply: AC 220V/50Hz or AC 110/60Hz Maximum Power: 150W Pressure gauge: 0 200psi Fluid outlet hose: 2.5m Fluid return hose: 2,5m Fluid draining hose: 1,2m Filtration: 5μm Fluid tank: 2 x 20 ltr Equivalent exchange error: +/- 100ml Noise: <70db Weight: 78kg www.bluechemgroup.com
ATF EVOLUTION PREMIUM Adapter / Accessoiries A list of available adapters incl. vehicle types is available on request.
STANDARD KIT (inclusive) Contains adapter for: Toyota, Mitsubishi, Lexus, Honda, Nissan, Cadillac, BMW, general european vehicles, Chrysler, Ford, General Motors, Volvo, Daimler Benz and universal adapter ADAPTER KIT I Contains adapter for: Dodge, AISIN, Peugeot, Renault, Citroen, Fiat, Opel, VAG, Audi, VW, Seat, Skoda, BMW, Mercedes Benz, Hummer, Saab and Porsche ADAPTER KIT II Contains adapter for: Chrysler, Dodge, Ford, Toyota, Honda, Nissan, Mitsubishi, Lexus, special adapter and adapter for hoses ADAPTER KIT III Contains adapter for: Alfa Romeo, Fiat, GM, Buick, Chevrolet, Cadillac, Saab, Chrysler, Volvo, Lincoln, Mazda, Ford and universal adapter www.bluechemgroup.com
Clean and maintain the automatic transmission effectively, rapidly and cheaply. Cleaning and Care Products
Automatic Transmission Flush Reliably dissolves and removes contaminants, such as oxidised oil residues and other deposits from the entire transmission oil system. Smooth and powerful gear changing will be the result. For all cars with automatic transmission. Application: Add the product to the oil system before exchanging the transmission oil. Run the system for approx. 10-15 minutes under frequent load change. Afterwards carry out the exchange of the transmission oil according to the manufacturer s instructions. Content 375 ml 1 ltr 5 ltr 10 ltr 20 ltr 200 ltr PU 28 pc. 12 pc. 4 pc. 1 pc. 1 pc. 1 pc. PRO-TEC Art.-No. P1701 P1709 P1702 P1708 P1707 P1705 bluechem Art.-No. 33179 33175 33174 33173 33172 Automatic Transmission Conditioner For the preservation of seals and o-rings. Reduces formation of foam and oxidation. Automatic Transmission Conditioner extends durability and delays the buildup of new residues of resin and similar contaminants. For all cars with automatic transmission. Application: Add to the gear oil system. Content 375 ml 1 ltr 5 ltr 10 ltr 20 ltr 200 ltr PU 28 pc. 12 pc. 4 pc. 1pc. 1 pc. 1 pc. PRO-TEC Art.-No. P1801 P1809 P1802 P1808 P1807 P1805 bluechem Art.-No. 33178 33176 33177 33171 33170
power Automatic Transmission Fluids maxxpower premium ATF 3 ATF 3 is used in automatic transmissions, power steering systems, fluid couplings, hydrodynamic converters and hydraulics in cars, trucks, buses and construction vehicles, if the manufacturer s specifications requires an ATF Type Dexron III H. Recommended for vehicles that require an oil to the following classifications / specifications: Allison C-4 Allison TES, 389 DEXRON III H DEXRON III G Ford M2C138-CJ, M2C 166-H Ford Mercon MAN 339 Typ Z1 & V1, Z2 & V2 MB 236.1, 236.5, 236.6 & 236.7 Voith 55.6335 & 55.6336 Volvo 97340, 97341 ZF TE-ML 02F, 04D, 09,11A, 14A & 17C Content 1 ltr 5 ltr 20 ltr PU 12 pc. 3 pc. 1 pc. Art.-No. 36900 36901 36902 www.maxxpower.info Ready for use,
maxxpower premium ATF 4 ATF 4 is used in automatic transmissions, power steering systems, fluid couplings, hydrodynamic converters and hydraulics, if the manufacturer s specifications requires an ATF Type 4. Exceeds all Dexron III-requirements an is easily miscible with all Dexron II D- and Dexron III ATFs. Recommended for vehicles that require an oil to the following classifications / specifications: DEXRON III Voith Turbo according to H55.6336.35 for extended oil change intervals (120.000 km) ZF TE-ML 11B Content 1 ltr 5 ltr 20 ltr PU 12 pc. 3 pc. 1 pc. Art.-No. 36910 36911 36912 maxxpower premium ATF 6 ATF 6 is a synthetic high-performance automatic transmission fluid which consists of versatile components of the especially for vehicles optimized anti-shudder additive technology. Characterized by low foaming tendencies and exceptionally stable oxidation behavior. Recommended for vehicles that require an oil to the following classifications / specifications: Allison C-4/ TES-295 Ford Mercon -V GM Type A Suffix A GM Dexron -IID/-IIE/-IIIG/-IIIH GM Dexron -VI (does not meet the level of viscosity) JASO 1-A MAN 339 Type V-1&2/Z-1&2 Volvo 97340 + 97341 MB 236.1, 236.2, 236.5, 236.6, 236.7, 236.9, 236.1 0, 236.11 Chrysler ATF +3/+4 ZF TE-ML 02F, 03D, 04D, 05L, 09, 11B, 14A, 14B, 16L, 17C Audi G 052 025, /G-052-162 BMW LA2634/ LT 71141/ 5 Series/ ETL-8072B/ BMW 7045E Daimler NAG 1 Volvo 4-6 Speed VW TL52162 ATF-MV Content 1 ltr 5 ltr 20 ltr PU 12 pc. 3 pc. 1 pc. Art.-No. 36920 36921 36922 around the globe.
power Automatic Transmission Fluids maxxpower premium DSG+ DSG+ is a synthetic high-performance automatic transmission fluid developed specifically for use in the latest generation of DSG gearboxes. Neutral to metals and sealing materials and offers excellent viscosity-temperature behavior. maxxpower premium CVT+ High-performance special transmission fluid designed for cartronic transmissions, such as used in Mercedes A and B Class and many other variable automatic transmission by various car manufacturers (e.g. Audi Multitronic). Recommended for vehicles that require an oil to the following classifications / specifications: Audi / VW / Seat / Skoda - DQ250 / DQ500 / DL501 (VW TL 052 182) BMW - 7DCI600 / DCI700 Citroen / Nissan / Peugeot - 6DCT451 (Peugot/Citroen 9734.52) Mitsubishi - 6DCT470 Ford / Getrag - 6DCT450 / 6DCT451 / 7DCT300 (Ford M2C936A) Volvo - 6DCT40 Mercedes Benz - F-DCT350 / F-DCT500 Porsche - ZF 7DT45HL / 7DT45HLA / 7DT45F / 7DFL / 7DT70HLA / 7DT75 / 7DT75A Recommended for vehicles that require an oil to the following classifications / specifications: Nissan NS-II Hyundai / Kia SP-III Mopar CVTF+4 Suzuki TC/NS-II Daihatsu TC Toyota GM / Saturn DEX-CVT Mitsubishi NS-II / SP-III/ CVT J-1 Honda ATF-Z1 Ford CVT 23 / WSS-M2C928-A BMW 8322 0 136 376 / 8322 0 429 159 Honda HMMF Subaru MB 236.20 MB A 001 989 46 03 VW G 052 180 JASO M358 Content 1 ltr 5 ltr 20 ltr PU 12 pc. 3 pc. 1 pc. Art.-No. 36930 36931 36932 Content 1 ltr 5 ltr 20 ltr PU 12 pc. 3 pc. 1 pc. Art.-No. 36940 36941 36942 Please refer to vehicle manufacturer recommended specifications prior to use. www.maxxpower.info
CTP GmbH Saalfelder Str. 35 h 07338 Leutenberg Germany Phone +49 (0)36734 230-0 Fax +49 (0)36734 230-22 info@bluechemgroup.com www.bluechemgroup.com Recommended by Art.-No.. 34109-2 03/2016 2016 bluechemgroup Subject to modifications and errors. Similar image. Picture material: Page 1 - fotolia_22431701 Page 2 - leonello calvetti-cutawaycar-91924364-shutterstock.com Page 2 - Automatic transmission popov48 #42106135-fotolia.com Page 8 - boite de vitesses d une automobile PackShot #34408763 - fotolia.com Page 11 - Motor oil poring Georgi Roshkov - Fotolia.com