SERVICE IPL, YTH00 Twin, 007-0, 53 4 60-9 9604006400 YTH00 Twin Spare parts Ersatzteile Pièces détachées Reserve onderdelen Repuestos Reservdelar 53 4 60-9
ILLUSTRATED PARTS LIST MODEL NO. 9604006400 CUSTOMER CATALOG NO. YTH00 TWIN PRODUCT NO. 960 4 00-64 47 53 4 60-9 Rev. 0 04..09 SR
DECALS 7 8 6 6 4 4 7 9 3 5 6 5 7 4 0 8 53 40 03-89 Decal, Warning Syms. CE 3 53 9 63-57 Decal, Warning Deflect Cutfinger 4 53 9 68-4 Decal, Warning Eng. Syms. 5 53 4 08-37 Decal, Saddle Brake Parking 6 53 7 83-0 Decal, Oper. Cruise Sym. 8 53 6 03-96 Decal, Mower Sch. 9 53 4 50-05 Decal, Battery Dan./Poi. 0 53 5 97-37 Decal, Brake/Clutch Sym. 53 5 97-36 Decal, Chassis Hot Muffler 53 8-66 Decal, Cutfinger CE 4 53 4 60-4 Decal, Panel Side 5 53 8 04-3 Decal, Fender DB/CE 6 53 40 8-3 Decal, Hood Logo 7 53 9 68-4 Decal, Cutfinger 8 53 4 57-47 Decal, Replacement - - 53 6 5-98 Decal, Drawbar Load Limit - - 53 6 69-60 Decal, Bypass - - 53 40 7-7 Pad, Footrest, LH - - 53 40 37-73 Pad, Footrest, RH - - 53 4 60-7 Manual,Operator's Euro WHEELS AND TIRES 3 7 6 4 0 5 9 8 53 05 9-9 Cap, Valve, Tire 53 06 5-39 Stem, Valve 3 53 3 83-36 Rim Assembly, Front 4 53 05 99-04 Tube, Front (Ser vice Item Only) 5 53 0 6- Tire, Front 6 53 49-57 Fitting, Grease (Front Wheel Only) 7 53 49-59 Bearing, Flange (Front Wheel Only) 8 53 7 50-39 Cap, Axle (Front Wheel Only) 9 53 0-8 Tire, Rear 0 53 49-6 Tube, Rear (Service Item Only) 53 3 83-37 Rim Assembly, Rear - - 53 4 43-34 Sealant, Tire (0 oz. Tube) wheel_art_-vgt NOTE: All component dimensions given in U.S. inches inch = 5.4 mm
SCHEMATIC 38 SCH3 A AMMETER (OPTIONAL) RED FUSE BATTERY RED SOLENOID STARTER M WHITE PTO SWITCH (DISENGAGED) WHITE ELECTRIC CLUTCH S B M A G L A BLUE C A H D WHITE RED CLUTCH/BRAKE (PEDAL UP) GRAY B E REVERSE SWITCH (NOT IN REVERSE) 3 SEAT SWITCH (NOT OCCUPIED) 87 86 87A 85 30 RELAY BLUE 85 86 30 87 87A /WHITE 6 JUNCTION CONNECTOR CHASSIS HARNESS GRAY SHORTING CONNECTOR C B A F E D H G BLUE IGNITION UNIT (OPTIONAL) HOUR METER SPARK PLUGS GAP ( PLUGS ON TWIN CYL. ENGINES) PTO SWITCH (MATING SIDE) BLUE FUEL LINE BLUE V POWER OUTLET (OPTIONAL) NOTES ORANGE FUEL SHUT-OFF SOLENOID (IF EQUIPPED) RED CHARGING SYSTEM OUTPUT 9-5 AMP DC @ 3600 RPM REGULATOR STATOR 8 VOLTS AC @ 3600 RPM (REGULATOR DISCONNECTED) BROWN LIGHT SWITCH HEADLIGHTS IGNITION SWITCH POSITION CIRCUIT MAKE OFF RUN/OVERRIDE RUN M+G+A B+A B+A L+A START B+S+A 3 CHASSIS HARNESS CONNECTOR (MATING SIDE) 6 5 4 6 5 4 3 DASH HARNESS CONNECTOR WIRING INSULATED CLIPS NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR SERVICING OF UNIT, THEY SHOULD BE RE-INSTALLED TO PROPERLY SECURE YOUR WIRING. NON-REMOVABLE CONNECTIONS REMOVABLE CONNECTIONS 3
ELECTRICAL 3 T0S 90 30 33 7 79 8 9 4 8 99 00 34 7 4 43 4 6 40 5 8 55 6 0 With V Outlet Option 03 7 59 0 9 With Service Minder Option 05 46 4
ELECTRICAL 3 53 6 34-65 Battery 874 76 04- Bolt Hex Hd. /4-0 unc x 3/4 8 53 8 64-9 Battery Box 6 53 7 6-38 Switch Interlock 53 8 37-59 Harness Socket Light 53 00 4-5 Bulb, Light # 56 4 53 40 0-53 Cable Battery 5 53 4 8-95 Cable Starter 6 53 7 5-58 Fuse 7 873 5 04-00 Nut Keps Hex /4-0 unc 8 53 4 54-9 Cable Ground " Blk. 6 Ga. 9 53 40 5-45 Switch Seat 30 53 9 33-50 Switch Ignition 33 53 4 9-35 Key/Chain 34 53 07- Switch Light/Reset 40 53 40 96-4 Harness Ignition Dash 4 87 7 04-08 Screw Thd. Cut /4-0 x / 4 53 3 5-63 Cover Terminal Red 43 53 9 5-07 Solenoid 46 53 4 39-3 Gauge Hourmeter 50 53 7 46-5 Switch PTO 55 87 49 05- Screw Thdrol. 5/6-8 x 3/4 7 53 9 4-76 Harness Chassis 79 53 7 5-4 Socket Asm. Bulb Twistlock 8 53 40 96-5 Relay Harness 90 53 40 07-4 Cover Terminal Battery 9 53 9 0-70 Strap Battery 99 87 67 04- Screw Hex Wsh. Thdrol. /4-0 x 3/4 00 89 09 4-6 Washer 9/3 x 7/8 x 6 Ga. 0 53 9 83-7 Pigtail 0 53 40 44-54 Harness Pigtail 05 53 40 75-68 Switch reverse NOTE: All component dimensions given in U.S. inches inch = 5.4 mm 5
CHASSIS AND ENCLOSURES 39 04 0 08 8 5 3 39 38 03 06 34 4 4 30 07 5 5 37 30 09 76 37 34 0 76 77 75 05 50 78 96 95 76 76 8 6 36 6 37 94 36 94 68 8 36 30 35 34 30 99 3 3 6 83 68 80 8 8 65 68 58 8 94 68 7 89 59 30 89 8 5 chassis-tex_gt Husq_4_r 5 59 89 6
CHASSIS AND ENCLOSURES 39 53 4-83 Drawbar Lower 3 53 40 50- Logo 5 53 40 87-0 Dash 4 53 4 0-46 Hood 5 53 9 89-07 Lens LH 8 53 40-86-07 Grille/Lens Asm. 5 53 9 89-06 Lens RH 34 53 9 6-5 Plate Engine 36 87 06 05- Screw 5/6-8 x 3/4 37 53 40 8-5 Fender 5 873 68 05-00 Nut Lock 5/6-8 58 53 4-8 Drawbar Upper 68 87 49 05-08 Screw Thdrol. 5/6-8 x / 30 53 9 6- Screw 0 x 3/4 Single Lead-Hex 37 53 40 75-90 Bumper Dash 50 53 9 85- Air Duct 5 53 9 95-35 Shield Browning 59 87 00 06- Screw 3/8-6 x 3/4 6 53 40 8-6 Console Fuel Window 6 53 4 4-3 Screw 65 53 9 68-6 Support Tank Rear 75 53 9 63-04 Crossmember 76 53 40 07-76 Screw 0-4 x 5/8 77 53 9 5-7 Bushing Steering 78 53 9 97-8 Cargo Net Asm. 80 53 4 50-64 Chassis 8 53 40 30-5 Bushing Mtg. Fender Crgo 8 53 40 68-59 Dash Lower 83 874 78 05-0 Bolt Fin. Hex 5/6-8 unc x -/4 89 87 00 05- Screw 5/6-8 x 3/4 94 873 90 05-00 Nut Lock Hex Flange 5/6-8 95 53 40 4-37 Plug Hole Dash Lower 96 53 40 0-99 Console Asm. Deck Lift 99 53 9 8-59 Plate Deck Lift 0 53 40 30-48 Vent Side Hood RH 03 53 40 30-76 Vent Side Hood LH 04 53 4 66-3 Vent Top Hood 05 53 40 7-09 Skirt Hood Side RH 06 53 40 7- Skirt Hood Side LH 07 53 9 7-98 Bezel RH 08 53 9 7-99 Bezel LH 09 53 9 9-30 Insert Hex Top RH 0 53 9 9-3 Insert Hex Top LH 53 9 9-3 Insert Hex Bottom RH 53 9 9-33 Insert Hex Bottom LH 3 874 76 05- Bolt 5/6-8 x 3/4 4 53 40 9-67 Clip Retainer Tinner 7 53 40 9-67 Rod Pivot 8 53 9 63-95 X-Piece Hood Stop 53 9 89-09 Reflector LH 8 53 9 5-6 Stud Fastner 30 53 7 0-65 Bolt Shoulder 5/6-8 34 53 40 47-4 Bumper Hood 35 53 40 6-9 Spacer Fender 36 873 93 05-00 Nut Lock 5/6-8 unc 38 53 40 86-06 Trim 39 53 04-5 Nut, Push NOTE: All component dimensions given in U.S. inches inch = 5.4 mm 7
DRIVE 40 74 0 74 70 56 3 09 5 06 9 6 07 43 6 6 97 96 7 35 4 84 5 80 5 5 5 85 64 60 67 60 88 70 5 6 5 86 89 49 59 53 08 5 4 0 87 50 5 90 5 9 59 6 63 5 66 5 33 30 5 6 5 7 5 53 05 83 6 73 30 05 33 drive-tex_k46_pedal_55 73 83 8
DRIVE 40 NO. NO. DESCRIPTION - - - - - - - - - Transaxle, TUFFTORQ K46 BT 53 35-83 Key /4 x.5 5 89 3 3-6 Washer 3/3 x 3/6 x 6 Ga. 7 53 4 36-78 Spring, Brake 6 53 9 96-79 Spring Return Cruise 9 53 40 38-06 Rod, Brake 33 8 00 00-0 Ring E 35 53 9 95-9 Rod, Brake, Park 4 53 48-7 Cover, Foot Pedal 49 87 06-4 Bolt 50 53 9 43-7 Pulley Idler Flat 5 873 90 06-00 Lock Nut 3/8-6 5 53 9 43-6 Idler V-Groove 90" Offset 56 53 3 09-69 V-Belt, Drive 64 53 9 78-65 Shaft Asm. Pedal Brake Control 70 53 40 05-30 Console Asm. 73 874 49 05-44 Bolt Hex Flghd. 5/6-8 x Gr. 5 74 53 4 4-3 Screw /4 x / 80 53 4 00-4 Bracket Strap Torque 9 874 76 05-0 Bolt Fin. Hex 5/6-8 unc x.5 99 53 40 59-03 Rod Bypass 6 873 90 05-00 Nut Lock Hex Flange 5/6-8 5 87 00 05- Screw 5/6-8 x 3/4 43 87 49 05-08 Screw 5/6-8 x / 53 53 47-88 Retainer Spring 59 876 0 04- Pin Cotter /8 x 3/4 60 53 6 94-84 Retainer Clip 6 53 0 57-09 Spring, Return, Clutch 63 53 40 0-34 Rod Pedal Control 66 53 9 7-90 Nut Push.65 67 53 40 5-57 Latch Brake Parking 70 53 9 43- Keeper Belt Centerspan NO. NO. DESCRIPTION 7 87 06-6 Bolt Rdhd. Sqnk. 3/8-6 unc x 83 53 3 70-57 Spacer Split 84 53 40 3-8 Handle Parking Brake 85 87 06-0 Bolt Rdhd. Sqnk. 3/8-6 x -/ 86 53 9 43- Spacer Retainer 87 89 3 3-0 Washer 88 53 9 43-3 Link Clutch Ground Drive 89 53 9 43-7 Bellcrank Ground Drive 90 53 9 43-8 Keeper Bellcrank Ground Drive 96 87 00 06-6 Screw 3/8-6 x 97 53 9 58-04 Link Clutch Anti-Rotation 05 53 7-48 Washer 06 53 9 78-67 Bracket Mount Latch Cruise 07 53 9 78-68 Latch Control Cruise 08 53 9 78-69 Gear Sector Control Cruise 09 53 9 95-9 Rod Control Cruise 0 53 9 78-60 Rocker Asm. Pedal Control 53 0-83 Bearing Nylon 3 53 40 3-9 Knob Control Cruise 4 53 40 7- Pedal Forward 5 53 40 7-3 Pedal Reverse 6 53 9 6-3 Bracket Pulley Idler 0 53 9 89-08 Reflector RH 53 40 3-87 Retainer Spring Clip Handle 879 0-0 Washer /3 x -/4 x 0 Ga. 5 53 40 33-9 Keeper Belt Trans. 6 53 40 5-64 Bracket Mount Touque 30 53 8 89-67 Washer Hardened NOTE: All component dimensions given in U.S. inches inch = 5.4 mm 9
ENGINE 4 0 8 87 8 8 45 84 6 5 8 37 69 7 37 3 9 4 4 70 79 9 9 85 SPARK ARRESTER KIT 90 0 07 05 0 08 engine-tex_6-kohl 07 06 0
ENGINE 4 - - - - - - Engine Kohler Model No. SV70 53 4 97-3 Muffler 9 53 9 43-0 Keeper Belt Engine 53 40 00-08 Clutch Electric 53 40 50-97 Pulley Engine 5 53 9 34-99 Tank Fuel 8 53 9 4-67 Cap Asm. 0 53 8 9-37 Control Throttle 53 9 6- Screw 0 x 3/4 Single Lead Hex 53 9 5-96 Control Choke 8 53 4-58 Fuel Line 9 53 3 7-80 Spark Arrester Kit 3 53 4 50-06 Clip Push-In Hinged 37 53 34-87 Clamp Hose 4 53 6-97 Washer -/ OD x 5/3 ID x.50 4 80 04 07-00 Washer Lock 7/6 45 873 5 04-00 Nut Keps Hex /4-0 unc 6 53 4 66-9 Shield Heat 69 53 8 60-54 Gasket 70 53 4 67-00 Pipe Exhaust RH 7 53 4 66-99 Pipe Exhaust LH 79 53 9 3-34 Screw Socket Hd. 5/6-8 x.75 8 53 4 84-56 Tube Drain Oil Easy 8 53 8 6-54 Plug Drain Oil 84 87 06-6 Screw 3/8-6 x 85 53 7 39-37 Bolt Hex 7/6-0 x 4 x Gr. 5-.5 Thr. 87 537 7 8-77 Bolt 5/6-8 unc x 3/4 w/sems. 90 87 00 06-6 Screw 3/8-6 x 9 53 8 74-95 Bushing.375 OD 0 87 00 05- Screw 5/6-8 x 3/4 05 53 4 56-06 Shield Side LH 06 53 4 56- Shield Side RH 07 53 3 77-9 Screw Thdrol. /4-0 x 5/8 08 53 4 05-3 Cover Asm. Eng. NOTE: All component dimensions given in U.S. inches inch = 5.4 mm
STEERING ASSEMBLY 4 6 5 45 6 3 8 64 63 8 60 57 63 57 9 8 7 66 9 59 35 8 67 9 8 7 8 58 6 8 4 67 8 6 6 4 5 6 5 3 68 69 70 4 5 3 8 steering-tex_special_8_w8 53
STEERING ASSEMBLY 4 53 4 64-80 Wheel, Steering Husq SR 53 8 47-06 Axle Asm., Front 4 53 40 30-87 Spindle Asm., LH 5 53 40 30-88 Spindle Asm., RH 6 53 49-3 Bearing, Race Thrust Harden 7 53 7-48 Washer 5/3 x -5/8 x 6 Ga. 8 8 00 00-9 Ring, Clip #T5304-75 9 53-3 Cap, Spindle 3 53 7-49 Washer 5/3 x -/4 x 6 Ga. 4 80 04 06-00 Washer, Lock Hvy. Hlcl. Spr. 3/8 5 873 54 06-00 Nut, Crown Lock 3/8-4 unf 6 53 9 47-46 Shaft Steering 9 53 9 47-9 Plate Steering 53 8 67-37 Adapter, Wheel Steering 53 9 48-45 Bushing, Strg. Blk. 6 53 4 59-87 Insert, Wheel Steering Husq SR 8 87 00 06- Screw 3/8-6 x 3/4 35 53 9 47-3 Gear, Sector Plate 45 89 8 38- Washer 9/6 ID x -3/8 OD Ga. 5 873 94 08-00 Nut Hex Jam Toplock /-0 unf 53 53 8 89-67 Washer Hardened.793 x.637 x.060 57 53 40 74-65 Bracket Upstop 58 53 9 47-47 Bolt Shoulder Sector Pivot CFM 59 53 9 47-48 Washer Thrust Sector Steering 60 873 97 0-00 Nut Flange Lock 5/8-6 53 9 47-40 Draglink LH 6 53 9 47-4 Draglink, RH 63 87 00 05- Screw 5/6-8 x 3/4 64 53 9 98-49 Retainer Clip Spring Steering 66 87 0 07-48 Bolt Hex Fghd. 7/6-4 x 3 Serr. 67 53 9 47-37 Bushing PM Front Axle 68 873 90 07-00 Nut Lock Flange 7/6-4 Gr. 5 69 53 9 9-6 Washer.5 x.505 x.8 70 53 9 6-97 Bracket Deck Susp. Front 8 53 40 60-3 Bushing Metal, Axle, Cast NOTE: All component dimensions given in U.S. inches inch = 5.4 mm 3
MOWER DECK 44 4
MOWER DECK 44 53 40 50-50 Mower Housing 53 40 55-06 Cover Mandrel RH 3 53 40 55-07 Cover Mandrel LH 5 53 46-70 Retainer Spring 6 53 9 5-86 Arm Suspension 8 53 9 30-03 Bolt/Washer Asm. 7/6-0 unf 53 40 53-80 Blade Mower 3 53 9 8-7 Shaft Assembly, Mandrel 4 53 8 7-8 Housing, Mandrel 5 53 04-85 Bearing, Ball, Mandrel 9 53 9 65-39 Bolt, Shoulder 873 68 05-00 Nut 3 53 9 5-57 Bracket, Deflector 4 53 0 53-04 Cap, Sleeve 5 53 9 70-6 Spring, Torsion, Deflector 6 53 04-5 Nut, Push 7 53 4 53-69 Shield, Deflector 9 53 3 4-9 Rod, Hinge 30 53 7 39-84 Screw Thdrol. Rolling Wsh. Hd. 3 53 8 76-90 Washer, Spacer 3 53 9 74-73 Pulley, Mandrel 33 53 40 0-34 Nut, Toplock, Flanged 34 87 06- Bolt Carr. Sh. 3/8-6 x -/ Gr. 5 36 53 9 73-79 Pulley, Idler, Flat 40 873 90 06-00 Nut, Lock Flg. 3/8-6 unc 46 53 3 77-9 Screw 55 53 9 7-49 Arm, Idler 56 53 9 90-9 Spacer, Retainer 57 87 00 06-6 Screw Hex Wsh. Thd. 3/8-6 x 59 53 4 0-43 Guard, Tuv. Idler (94) 6 874 5 06-36 Bolt 3/8-6 unc x -/4 Gr. 5 68 53 40 5-43 V-Belt 69 87 4 05-05 Bolt 6 53 9 34-06 Bolt, Shoulder 7 53 7 48-73 Wheel, Gauge 8 873 90 06-00 Nut Lock 3/8-6 unc 9 89 3 0- Washer 3/3 x -/4 x Ga. 45 53 9 3-97 Pulley Idler 47 53 9 7-5 Spring Return 88 53 9 5-6 Stud Fastener 89 873 90 05-00 Nut Lock Hex Flange 96 53 4 35-4 Washer 3/3 x x / Ga. 97 89 3 3- Washer 3/3 x 3/6 x Ga. 98 53 40 3-49 Baffle Center Front 99 53 40 3-50 Baffle Front RH 0 87 67 06-08 Screw 3/8-6 x / - - 53 9 8-70 Mandrel Assembly (Includes housing, shaft assembly, and bearing only - pulley/nut/ washer and blade bolt/washers not included) - - 53 4 64-4 Replacement Mower, Complete NOTE: All component dimensions given in U.S. inches inch = 5.4 mm 5
SEAT ASSEMBLY 4 8 7 8 4 7 40 0 6 37 44 43 37 3 seat-tex_7-vgt 53 40 66- Seat 53 8 0-66 Bracket Pivot Fender 3 53 4 06-75 Strap, Asm. Fender 6 873 80 06-00 Nut, Lock w/ins. 3/8-6 unc 7 53 4-8 Spring, Seat Cprsn. 8 53 7 8-77 Bolt 5/6-8 unc x 3/4 w/sems. 0 53 9 69-77 Pan, Seat 53 7 8-5 Bolt, Shoulder 5/6-8 37 873 80 05-00 Nut, Lock 5/6-8 unc 6 40 53 9 76-6 Handle Slide Seat 4 53 9 8-00 Spring Latch Seat 43 874 76 06- Bolt Fin. Hex 3/8-6 unc x 3/4 44 89 3 38- Washer 3/3 x -3/8 x Ga. NOTE: All component dimensions given in U.S. inches inch = 5.4 mm
MOWER LIFT 45 7 87 87 3 89 90 98 0 97 00 88 97 9 0* 89 87 lift-tex_7_r *Key 9 may be substituted for Key 0 53 9 5-3 Shaft Asm., Lift 3 53 9 5-30 Lever Asm., Lift RH 7 53 4 5-55 Grip, Lever 0 53 9 63-4 Spring Torsion 87 53 9 4-09 Pin Cotter 7/6 Bow Tie Lock 88 53 4 07-0 Spring Lift Assist 89 89 9 9- Washer Clear Zinc 90 53 9 4-08 Pin Cotter 5/6 Bow Tie Lock 9 53 9 5-8 Link Lift Susp. Mower Rear 7 97 87 06 06- Screw 3/8-6 x.75 Smgml. Tap/R.Z 98 53 9 5-70 Link Lift Susp. Front Mower 00 873 93 06-00 Nut Lock 3/8-6 unc 0 53 40 70-03 Link Asm Lift FXD NOTE: All component dimensions given in U.S. inches inch = 5.4 mm