IPL 0 0 ILLUSTRATED PARTS MANUAL Model STWC Wildcat This manual contains the illustrated parts list for MODELS: STWCV-CV with a serial number of E0000 to E STWCV-KA-LC with a serial number of E0000 to E STWCV-Ka with a serial number of D0000 to D STWCV-KA-LC with a serial number of D00000 to D0 STWCV-KA-LC with a serial number of D000 to D STWCV-CV with a serial number of D0000 to D SMTC-V with a serial number of D000 to D SMWC-V with a serial number of D0000 to D SMWC-V with a serial number of D0000 to D 00 Scag Power Equipment Division of Metalcraft of Mayville, Inc. Part 0 Printed /0 Printed in USA
R Table of Contents Table of Contents V & V CUTTER DECKS... V CUTTER DECK... CUTTER DECK CONTROLS... SHEET METAL COMPONENTS... STWC ROLL-OVER PROTECTION SYSTEM... DRIVE SYSTEM COMPONENTS... ENGINE AND ATTACHING PARTS... STEERING COMPONENTS... BRAKE COMPONENTS... FUEL AND HYDRAULIC SYSTEM...0 ELECTRICAL SYSTEM - KOHLER & KAWASAKI AIR-COOLED... ELECTRICAL SYSTEM - HP KAWASAKI LIQUID-COOLED... HYDRAULIC PUMP ASSEMBLY... REPLACEMENT DECALS AND INFORMATION PLATES... ELECTRICAL SCHEMATIC - KOHLER & KAWASAKI AIR-COOLED...0 ELECTRICAL SCHEMATIC - HP KAWASAKI LIQUID-COOLED... I
R Section V & V CUTTER DECKS, A 0 0 0 0 * 0 0 0 0 * " cutter deck has a notch for anti-scalp roller STC 00 CD Rev.
R Section V & V CUTTER DECKS Part Description Part Description 0 0 0 0 00-0 -0 000-00- 00-0 00-0 000-000- 00-000-0 000-0 000-00-0 00-0 000-00-0 000-0- 000-0 000-000- 00-0 000-0 0-0 -0 0 0 Cutter Deck Velocity Plus Cutter Deck Velocity Plus Boss, Spring Anchor Nut, /- Serrated Flange Wing Nut, /- Anti-Scalp Wheel Bolt, Carriage /- x Bracket, Anti-Scalp Wheel Bolt, Serrated Flange /- x Flatwasher, / Hardened Locknut, /- Center Lock Discharge Chute Discharge Chute Bolt, Hex Head /- x -/, Rear Bolt, Hex Head /- x -/, Front Nut, Elastic Stop /- Nut, /- UNC Shaft, Roller Bolt, Hex Head /- x -/ Roller, Rear Bolt, Hex Head /- x -/ Key, / x / x " Spring, Idler LH Flatwasher, / Bolt, Hex Head /- x -/ Gr. Nut, Serrated Flange /- Bolt, Hex Head /- x -/ Bushing,. ID Oilite Lockwasher / Flatwasher / Bolt, Hex Head /- x -/ Gr. Nut, Elastic Stop /- Bolt, Hex Head /- x -/ Spring, Idler RH Bracket, Spring Anchor LH V Bracket, Spring Anchor LH V U-Nut, /- Spindle Assembly Shaft, Spindle Seal Upper Bearing Assembly Grease Fitting Valve, Grease Relief Housing, Spindle Spacer, Outside Spacer, Inside Seal, Lower Bushing, Bottom Nut, Special -/ - Spacer, Spindle Cutter Blade. Cutter Blade Pulley, Idler Dia. Bearing Idler Arm Assy. 0 0 0 000-0 0 000-00- 000- -0 000-0 0 000-00- 00-0 0 000-0 000-00- 000-0 000-000- 00-0 000-000-0 Idler Pivot Belt Cover (V) Belt Cover (V) Hub, Tapered -/ Bore Idler Arm Bolt, Hex Head /-0 x Grade Pulley. Pulley. Turbo Baffle, Bolt On Push Arm Shaft Push Arm (Includes,0,) Nut, /- UNF Nut, Elastic Stop /- Rod End, / Male RH Thread Bolt, Hex Head /- x -/ Grease Fitting, 0 Degree Belt, Cutter Deck Drive (V) Belt, Cutter Deck Drive (V) Bolt, Hex Head /- x Spring, Discharge Chute Baffle Custom-Cut, V (-Position) Baffle Custom-Cut, V (-Position) Baffle Weldment, V (-Position) Baffle Custom-Cut, V (-Position) Bolt, Carriage /- x Nut, Elastic Stop /- Grade Flatwasher / Belt, RH Cutter Deck Belt, RH Cutter Deck Pulley, Idler Dia. Pulley, Double Groove Pulley, Double Groove Bolt, Special Lever Assy., Deck Level Bolt, Carriage /- x -/ Flatwasher, /-.00 x. x.0" Nut, Elastic Stop /- Dust Shield Lockwasher / Bracket, Spring Anchor RH Bracket, Spring Anchor RH Bolt, Hex Head /- x -/ Gr. Bolt, Hex Head /- x Nut, Center Lock /- Wear Pad Idler Pivot Bolt, Carriage /- x / Flatwasher, /
R Section V CUTTER DECK 0 0 "A" "A" 0 0 0 0 0 0 0 0 0 0 0, A 0 STWC 00 CD
R Section V CUTTER DECK Part Description 0 0 0 0 Part Description 0 0 0 0-0 000-00- 00-0 00-0 000-000- 00-000-0 000-0 000-00-0 00-0 000-00-0 000-0- 000-0 000-0 00-0 0 0-0 -0 0 Cutter Deck Velocity Plus Boss, Spring Anchor Bracket, LH Spring Anchor V Wing Nut, /- Anti-Scalp Wheel Bolt, Carriage /- x Bracket, Anti-Scalp Wheel Bolt, Serr. Flng. /- x Flatwasher, / Hardened Locknut, /- Center Lock Discharge Chute Bolt, Hex Hd. /- x -/, Rear Bolt, Hex Hd. /- x -/, Front Nut, Elastic Stop /- Nut, /- UNC Shaft, Roller Bolt, Hex Hd. /- x -/ Roller, Rear Bolt, Hex Hd. /- x -/ Key, / x / x Spring, LH Deck Drive Flatwasher, / (. x. x.") Bolt, Hex Hd. /- x -/ Grd. Nut, Serr. Flng. /- Bolt, Hex Hd. /-0 x Grd. Bushing,. ID Oilite Lockwasher / Flatwasher / Spring, RH Deck Drive Nut, Elastic Stop /- Idler Arm Assembly, LH Drive Idler Arm Assembly, RH Drive Pulley, Tapered Bore. Dia. U-Nut, /- Spindle Assembly Shaft, Spindle Seal Upper Bearing Assembly Grease Fitting Valve, Grease Relief Housing, Spindle Spacer, Outside Spacer, Inside Seal, Lower Bushing, Bottom Nut, Special -/ - Spacer, Spindle Cutter Blade Pulley, Double Groove. Dia. Dust Shield Idler Pulley, Dia. 0 0 000-00- 000- -0 000-0 000-00-0 000-000-0 000-000- 00-0 000-0 000-000-0 00-0 000-000- 00-000- 000-000- 00-0 Idler Pulley, Dia. Belt Cover (V) Hub, Tapered -/ Bore Idler Pulley, -/ Dia. Pivot, Idler Bearing Turbo Baffle, Bolt On Push Arm Shaft Push Arm (Incl., 0, ) Nut, /- UNF Nut, Elastic Stop /- Rod End, / Male RH Thread Bolt, Hex Hd. /- x -/ Grease Fitting, 0 Degree Belt, Deck Drive V Bolt, Hex Hd. /- x Spring, Discharge Chute Baffle Weldment, V Bolt, Carriage /- x Flatwasher, / (. x. x.") Bolt, Hex Hd. /- -/ Belt, Deck Drive RH Wheel, Anti Scalp Roller Shaft Bolt, Special Bolt, Carriage /- x -/ Lever Assy., Deck Level Bolt, Hex Hd. /- x -/ Grd. Bolt, Hex Hd. /- x Nut, Serr. Flng. /- Lockwasher, / Pivot, Idler Short Bolt, Carr. /- x / Wear Pad Flatwasher, / (. x. x.0") Nut, Center Lock / Bolt, Hex Hd. /- x Bolt, Hex Hd. /- x -/ Nut, Elastic Stop /- Flatwasher, / (.00 x.0 x.0") Bolt, Hex Hd. /- x -/ Bolt, Hex Hd. /- x Nut, Elastic Stop /- Pulley, Double Groove." Dia.
R Section CUTTER DECK CONTROLS 0 0 0 CUTTER DECK STC 00 CDC
R Section CUTTER DECK CONTROLS 0 0 0 Part 000-000- 0 000-00-0 00-0 000-0 0 00-0 000-0 00-0 000-00-0 00-0 000-0 00-0 00-0 0-0 000-00-0 000-0 000-000- 00-0 0 000-00- 0 0 00-000-0 00-0 Description Rod, Deck Lift Linkage Nut, Jam /-0 LH Thread Rod End, /-0 Female LH Thread Retaining Ring, / Ext. E Slide, Deck Height Adjust Pin, Deck Lift Bracket, Cutting Height Adjustment Bolt, Hex Hd. /- x -/ Bushing.0" OD Nut, Elastic Stop /- Lever, Deck Latch Slide, Cutting Height Capscrew, /- x Flathead Hex Socket Grd. Guide, Short Bolt, Carriage /- x Guide, Long Spring, Helper Nut, /- Center Lock Flatwasher, / (. x. x.0") Nut, /- Serr. Flng. Bolt, Hex Hd. /- x -/ Swivel Joint LH Cotter Pin, / x Nut, Serr. Flng. /- Bolt, Hex Hd. /- x -/ Nut, Serr. Flng. /- Nut, Elastic Stop /- Chain Grease Fitting, /- Self Tap Torsion Spring Lever Assy., Deck Level Stud, /- x 0 Pin Lanyard Nut, /- UNC Swivel Joint RH Bolt, Hex Hd. /- x Rod End, /-0 Female RH Thread Bolt, Hex Hd. /- x -/ Spacer Locknut, /-0 Spacer Nut, /-0 UNF-B RH Thread Nut, Elastic Stop /- Lift Bellcrank Weldment, LH Rear Lift Bellcrank Weldment, RH Rear Flatwasher,.0 (.0 x. x.0") Retaining Ring, Ext. Hair Pin Cotter,." x -/ Grip, Deck Latch Lever
R Section SHEET METAL COMPONENTS hp Kawasaki a a 0 0 0 0 0 0 STWC 00 SMC
R Section SHEET METAL COMPONENTS Part Description 0 0 Part Description 0 0 0 000-00-0 ** 000-000-0 00-0 000-000- 00-0 00-00-0 000-00-0 0-0 00-0 000-0 - Main Frame Assembly w/decals Bolt, Hex Hd. /- x -/ Back Cover Nut, Serr. Flng. /- Plate, Seat Mounting Cushion Cover Pin Retainer, Spring Spring Battery (not available through Scag) Battery Cover Battery Hold Down Pad Bolt, Carr. /- x / Battery Box Roll Pin, Spring / x / Nut, Serr. Flng. /- Bolt, Hex Hd. /- x Pad, Rubber Bolt, Hex Hd. /-0 x -/ Nut, Serr. Flng. /-0 Seat Base Support Nut, Elastic Stop /- Seat Assembly w/adj. Rails & Seat Belt Armrest Cover Armrest, RH Armrest Cover Armrest, LH Seat Track Set Footplate Nut, Elastic Stop /- Bolt, Hex Hd. /- x Cable, Seat Stop Weldment, Caster Support (V) Weldment, Caster Support (V) Cap, Grease Nut, Elastic Stop.0- Bearing Set Plug, /- Seal,.0 OD x. ID Nut, Elastic Stop /- Yoke, Front Caster Wheel Bolt, Hex Hd. /- x -/ Sleeve Caster Wheel Assembly (Incl. thru ) Tire, x.- Smooth Seal Rim (Incl. Item ) Roller Bearing Fitting, Grease 000-00- 000-0 000-0 0 000-0 000-000-0 0-0 00-0 000-0 000-0 Mounting Bracket, Oil Tank Mounting Bracket, Fuel Tank Seat Pan Spacer, Caster Wheel Bolt, Hex Hd. /- x -/ Nut, Elastic Stop /- Lockwasher, / Bolt, Hex Hd. /-0 x / Support Weldment, Oil Cooler Bolt, Carriage /- x Bracket, Fuel Valve Bracket, Hour Meter Bolt, Hex Hd. /- x -/ Lockwasher. / Spring U-Nut, /- Support Weld, Oil Cooler - hp Kaw. Locknut, /- Center Lock Spring, Seat Latch Seat Latch Weldment Bolt, Hex Hd. /- x Seat Stop Bolt, Hex Hd. /- x
STC / STWC SUSPENSION SEAT - ILLUSTRATED PARTS LIST Part 000-000- 0 0 000-0 Description Suspension Seat Assembly w/seat belt Bolt, Hex Head /-0 x Flatwasher, /-.00 x. x.0 Retractable Seat Belt Armrest Only Armrest Assembly Kit, LH Armrest Assembly Kit, RH Back Cushion Kit Lumbar Kit Knob Kit Shock Absorber Kit Seat Adjustment, Track Set Weight Adjustment Kit Knob Kit Seat Cushion Kit Seat Drain Kit (Included with Seat Cushion) Bolt, Hex Head /- x -/" Spacer Wire Harness Adapter
R Section STWC ROLL-OVER PROTECTION SYSTEM STWC 00 ROPS
R Section STWC ROLL-OVER PROTECTION SYSTEM Part 000-00- 000- -0 00-0 00-0 000-000- 000- Description STWC Foldable ROPS Bolt, Hex Hd. /- x -/ Nut, Center Lock /- Retractable Seat Belt Flatwasher, / (. x. x.") Thumb Screw, /- NC x / Hair Pin, Cotter Pin Nut, Center Lock /- Bracket, Stop Bolt, Hex Hd. /- x -/ Bolt, Hex Hd. /-0 x Flatwasher, / (.00 x. x.0")
R Section DRIVE SYSTEM COMPONENTS 0 0 STWC 00 DSC
R Section DRIVE SYSTEM COMPONENTS 0 0 Part 00-0 00-0 0 000-0 00-00-0 0 000-0 000-000- 000-0 0 0 00-0 000-000-0 000-0 000-00-0 Description Nut, Elastic Stop /- Nut, Serr. Flng. /- Spring, Pump Idler Spacer Bolt, Hex Hd. /- x -/ Idler Arm Assy., Pump Drive Key, x x mm Belt, Transmission Pulley, -/ Dia. Idler Flatwasher, / (. x. x.") Pulley,." OD Taper Bore Hub, Tapered, mm Bore Bolt, /- x Pivot, Idler Bearing Bolt, Hex Hd. /-0 x Grd. Bolt, Hex Hd. /- x -/ Bolt, Hex Hd. /- x -/ Pulley,." Dia. -. Bore Clamp Plate Hex Hd. Capscrew, /-0 x / Control Lever, Pump Bolt, Hex Hd. /- x Lockwasher, / Block, Pump Control Roll Pin Bolt, Hex Hd. /- x -/ Grd. Nut, Serr. Flng. /- Pulley, Dia. Idler Bracket
R Section ENGINE AND ATTACHING PARTS SC 00 EAPKA
R Section ENGINE AND ATTACHING PARTS Part 00 0 00-0 000-000- 000-000- 00-000- 00-0 Description Engine, Kohler Command hp Engine, HP Kohler Engine, HP Kawasaki Engine, HP Kawasaki Liquid-Cooled Bumper, Rear Weight, Rear (Shield) V Only Shield, Rear V Only Nut, Serr. Flng. /- Extension, Oil Drain - Kohler, Kawasaki HP Extension, Oil Drain. - Kawasaki Bolt, Carr. /- x Bolt, Hex Hd. /- x -/ Muffler - Kohler Muffler - Kawasaki Muffler - Kawasaki HP Liquid-Cooled Bracket, Muffler Plate, Skid Bolt, Hex Hd. /- x -/ Bolt, Hex Hd. /- x Screw, /- x / Guard, Carb Inlet - Kawasaki Only Bolt, Hex Hd. /- x -/ Nut, Serr. Flng. /-
R Section STEERING COMPONENTS 0 0 0, A, A To Pump STC 00 SSC REV
R Section STEERING COMPONENTS 0 0 0 Part 0 000-0 000-0 000-000-0 00-0 0 000-000- 000-0 000-0 000- * * 000-0 000-0 00-0 00-0 000-00- -0 00-0-0 00-0 000-0 0 00-000-0 000-0 Description Grip, Control Lever Handle Bar, LH (Incl. item ) Handle Bar, RH (Incl. item ) Bolt, Hex Hd. /- x Lockwasher, / Knob Flatwasher, / (. x. x.0") Roll Pin, Spring / x / Pivot, Control Lever Nut, Elastic Stop /- Rod End, /- RH Female Nut, /- RH Thread Rod, Pump Control Linkage Nut, /- UNF-B LH Thread Rod End, /- LH Thread Pin Retainer Bolt, Hex Hd. /- x -/ Bolt, Hex Hd. /- x -/ Spacer, Pump Damper Plate, Control Lever Bolt, Hex Hd. /- x Gas Damper Gas Damper Bolt, Hex Hd. /- x Block, Clamping Bolt, Carriage, /- x / Control Plate - LH w/decal Control Plate - RH w/decal Nut, Serr., Flng., /- Nut, Elastic Stop /-0 Bolt, Hex Hd. /- x / Shaft, Steering Control Nut, Elastic Stop /- Grease Fitting, /- Self Tap Spacer, Control Control Lever Assy RH (Incl. & ) Control Lever Assy LH (Incl. & ) Nut, Elastic Stop /- Bushing Flatwasher, / (. x. x.0") Retaining Ring, / Ext. Bracket, Switch Actuator Bolt, Hex Serr. Flng. /- x / Bolt, Carr. /-0 x / Bracket, Control Return Spring Pin Retainer Bolt, Carriage /- x -/ Rubber Spacer * Indentify the Gas Damper installed using the colored print and part number labeled on the Gas Damper. See Figure Below. - Damper (orange colored print) - Damper (blue colored print) STABILUS STAB-O-SHOC DO NOT OPEN. DO NOT HEAT OBSERVE DISPOSAL INSTRUCTIONS PQ /0 A xxx
R Section BRAKE COMPONENTS 0 0 0 0 0 STC 00 BSC
R Section BRAKE COMPONENTS 0 0 0 Part 00-0 0 000-0 000-000- 00-0 00-0 0 00-0 00-0 0 0 000-000- 00-00-0 0-0 000-000-0 00-00-0 000-000- 00-0 000-0 00-0 00-0 -0 00-0 0 000-000- 000-0 Description Nut, Serr. Flng. /- Spring Bolt, Hex Hd. /- x / Bolt, Hex Hd. /- x -/ Bolt, Hex Hd. /- x -/ Nut, /- Center Lock Wheel Motor, Hydro-Gear Key, Woodruff / x Wheel Hub Assembly Brake Band Assembly Bushing, Self Align Nut, Hex Castle.0-0 UNEF Cotter Pin, / x -/ Lug Nut, /-0 (") Wheel Assembly x. - ( ) Wheel Assembly x. - ( ) Wheel Assembly x - (") Rim ( ) Rim ( ) Rim w/stem ("/ ) Tire x. - Tire x - Brake Rod Stud, /- x -/ Nut, /- UNF Plate Weldment, Motor Backing Clevis Pin, / x. Pin, Rue Cotter / Dia. Brake Linkage LH Brake Linkage RH Grease Fitting, /- Nut, /- UNF Retaining Ring,." Ext. Nut, Elastic Stop /- Flatwasher, / (. x. x.") Bolt, Hex Hd. /- x -/ Grd. Bolt, Hex Hd. /- x -/ Cotter Pin, / x / Bolt, Hex Hd. /- x -/ Brake Shaft Nut, Elastic Stop /- Rod End, /- LH Thread Clevis Pin, / x.0" Clevis, /- Grip, Brake Lever Nut, Serr. Flng. /- Brake Lever (Incl. item ) Bolt, Hex Hd. /- x -/ Nut, /- UNF-B LH Thread Lever, Brake Shaft Weldment, Pivot Pin, Pivot Bolt, Serr. Flng. /-0 x.
R Section FUEL AND HYDRAULIC SYSTEM e G a B a 0 0 B n n f f 0 K G c d c d J 0 0 K m 0 J e m To engine l l 0 STWC 00 FHS 0
R Section FUEL AND HYDRAULIC SYSTEM 0 0 0 0 Part -0-0 -0-000-0-0 0-0 000-0 00-0 000-0 00-0 000-0 000-0 000-0 0 0-0 - - 0-0 - 00-0 00-0 00-0 -0 00-0 0-0 0 0 0 00- ** 0 000-0 000-0-0 Description Pump, BDP-A- (LH) Pump, BDP-A- (RH) Elbow, 0 Degree /" O-Ring x /" Hose Fitting, / JIC x /" O-Ring Hose, /" Pushlock (Specify length) Bushing Fitting Elbow, 0 Degree /" O-Ring x /" Hose Hose Clamp,." Dia. Hose Assembly Roll Pin Fitting, / JIC x / O-Ring O-Ring Bolt, Hex Hd. /- x -/ Bolt, Hex Hd. /-0 x -/ Lockwasher Nut, Elastic Stop /- Control Lever Bolt, Hex Hd. /- x / Lockwasher, / Flatwasher, / (. x. x.0") Cap, Hydraulic Tank Insert, Filler Neck Control Block Clamp Plate Hydraulic Tank Assembly w/fittings O-Ring Tee Fitting, O-Ring to Barb Clamp,." Max. /." Min. Dia. Bushing Elbow, 0." Hose Clamp Fuel Hose, /" ID Non-Perm. Bracket Fuel Valve Clamp, Fuel Hose /" Hose ID Valve, Fuel Shutoff Clamp,." Max. /." Min. Dia. Fitting, /" O-Ring x /" Hose Nut, Serr. Flng. /- Flatwasher, / (. x. x.") Oil Filter Filter Head Assembly Fitting, /" O-Ring x /" Hose Plug, /- O-Ring Hose, Filter Inlet Fuel Tank RH Cap, Fuel Tank (incl. item #) Tank Bushing Elbow, 0 Degree w/screen Fuel Tank LH Hose, / Pushlock Long Cooler, Transmission Screw, /-0 x Gasket, Gas Tank Cap Fuel Filter Hose Assembly Bolt, Hex Hd. /- x -/ Nipple, Oil Filter.0- UNF-A x -/ Bolt, Hex Hd. /- x O-Ring, / ** Available through the individual engine manufacturer.
R Section ELECTRICAL SYSTEM - KOHLER & KAWASAKI AIR-COOLED 0 0 0 0 0 SCAG POWER EQUIPMENT STWC 00 ESKH
R Section ELECTRICAL SYSTEM - KOHLER & KAWASAKI AIR-COOLED 0 0 0 Part 0 0-0 0-0 0 00-0 000-0 0 00-0 0 00-0 ** 000-000-0 0-0- 0 00-00- 00-00- 000-0 0-0 00-000-0 000-0 000-0 0 Description Hourmeter Fuse, 0 Amp Key, Ignition Key Assembly w/fob Nut, Hex /- Lockwasher, / Internal Electric PTO Clutch GT. Switch, Ignition Switch, PTO Relay Lockwasher, # External Tooth Nut, Hex #- Switch, N/O Panel, Instrument Choke Control - Kohler (Qty ) Choke & Throttle Control - Kawasaki (Qty ) Clamp Switch, Seat Module, Interlock Screw, #- x. Phillips Head Battery (Not Available Through Scag) Bolt, Hex Hd. /-0 x. Nut, Hex /-0 Cable, Battery Black (negative) Cable, Battery Red (positive) Wiring Harness, Main Pulley,." OD x." Bore Nut, Elastic Stop /- Key Mounting Bracket, Hour Meter Screw, #- x. Phillips Head Adaptor, Wiring Harness Key, / x / x -/ Flatwasher, / (. x -/ x / ) Lockwasher, / Bolt, Hex Hd. /-0 x -/ UNF (A Only) Screw, #- x / Bolt, Hex Hd. /- x / Lockwasher, / Flatwasher, / (. x. x.0") Backing Plate Rubber Pad, Clutch Stop Plate, Backing Throttle Control - Kohler & Kawasaki (Qty ) Fuse Holder Cover, Sealed Double Clip, Wire Double Fuse Assembly, Sealed (incl. items,,, )
R Section ELECTRICAL SYSTEM - HP KAWASAKI LIQUID-COOLED 0 0 0 0 0 SCAG POWER EQUIPMENT STWC 00 ESKALC
R Section ELECTRICAL SYSTEM HP KAWASAKI LIQUID-COOLED 0 0 0 Part 0 0-0 0-0 0 00-0 000-0 0 00-0 0 00-0 ** 000-000-0 0-0- 0 00-00- 00-00- 000-0 0-0 00-000-0 000-0 000-0 0 Description Hourmeter Fuse, 0 amp Key, Ignition Key Assembly w/fob Nut, Hex /- Lockwasher, / Internal Electric PTO Clutch GT. Switch, Ignition Switch, PTO Relay Lockwasher, # External Tooth Nut, Hex #- Switch, N/O Panel, Instrument Choke & Throttle Control - Kawasaki (Qty ) Clamp Switch, Seat Module, Interlock Screw, #- x. Phillips Head Battery (Not Available Through Scag) Bolt, Hex Hd. /-0 x. Nut, Hex /-0 Cable, Battery Black (negative) Cable, Battery Red (positive) Wiring Harness, Main Pulley,." OD x." Bore Nut, Elastic Stop /- Key Mounting Bracket, Hour Meter Screw, #- x. Phillips Head Adaptor, Wiring Harness Key, / x / x -/ Flatwasher, / (. x -/ x / ) Lockwasher, / Bolt, Hex Hd. /-0 x -/ UNF (A Only) Screw, #- x / Bolt, Hex Hd. /- x / Lockwasher, / Flatwasher, / (. x. x.0") Backing Plate Rubber Pad, Clutch Stop Plate, Backing Water Temp. Gauge Sender Unit, Water Temp Cover, Sealed Double Clip, Wire Double Fuse Assembly, Sealed (incl. items,,, ) Fuse Holder
R Section HYDRAULIC PUMP ASSEMBLY Overhaul Seal Kit 0 0 PORT "A" SIDE PORT "B" SIDE 0
R Section HYDRAULIC PUMP ASSEMBLY 0 0 Part HG 0 HG 0 HG 0 HG 0 HG HG 0 HG 0 HG 00-0 HG 00 HG 00 HG 0 HG 0 HG HG 0 HG 0 HG 0 HG 000 HG 000 HG HG 000 HG 0 HG 0000 HG 0000 HG 0 HG 00 HG 0 HG 00-00 HG 00 HG 0 HG 0 Description Housing Kit End Cap Kit Straight Headless Pin Hex Flng. Bolt, M-. x 0mm Housing O-Ring Charge Pump Kit Gerotor Assembly O-Ring Socket Head Screw, M x.0-0mm Bypass Valve Kit Pumpshaft Kit Ball Bearing, x 0 x mm Lip Seal Retaining Ring Spacer Cylinder Block Kit Block Spring Block Thrust Washer Valve Plate Swash Plate Ball Thrust Bearing Trunnion Arm Slot Guide Check Valve Kit (.0 Orifice) port A on Left Hand Pump, port B on Right Hand Pump Charge Relief Kit Trunnion Seal with Retainer Straight Thread Plug Straight Headless Pin Overhaul Seal Kit System Check Relief Kit, port B on Left Hand Pump, port A on Right Hand Pump * Common hardware which should be purchased locally. All bolts Grade plated, all other fasteners zinc plated.
R Section REPLACEMENT DECALS AND INFORMATION PLATES MANUFACTU UNDER ONE OR MORE OF THE FOLLOWING PATENTS:,,00,,0,0,,,,,,,,0,,,,,,,,,0,,0,,,,,,,,,0,,,,, 0 PATENTS PENDING forward f r reverse 0 Heavy-Duty Commercial WarninG install BelT cover Before operating machine read operator's manual 0 STWC 00 RDP
R Section REPLACEMENT DECALS AND INFORMATION PLATES ** Part 0 0 00 0 0 0 0 0 0 0 0 0 Description Decal, Danger-Spinning Blades Decal, Warning-Rotating Blades Decal, V Decal, V Decal, V Decal, ROPS Decal, Patents Decal, Traction Control Decal, Heavy Duty Commercial Decal, Metalcraft - Made in USA Decal, Belt Cover Decal, Instrument Panel Decal, Fuel Valve Position Decal, Cutting Height Bottom Row of Holes Decal, Wildcat Decal, Seat Support Decal, Rear Bumper Decal, Front Footplate Decal, Discharge Chute Decal, Cutting Height Top Row of Holes Decal, ROPS Spanish Decal Kit, STC / STWC (not shown) R STWC 00 RDP
R Section ELECTRICAL SCHEMATIC - KOHLER & KAWASAKI AIR-COOLED PTO SWITCH KEY SWITCH DIODE RELAY KAWASAKI ADAPTER HARNESS WHITE MAGNETO W/YEL STRIPE FUEL SOLENOID YELLOW RECTIFIER GRN W/WHT STRIPE SOLENOID MAIN HARNESS KOHLER ADAPTER HARNESS GRN W/WHT STRIPE WHITE ENGINE PLUG YELLOW SOLENOID "B+" MAIN HARNESS LIGHT BLUE BLUE LIGHT BLUE BLUE BLACK BLACK W/YEL STRIPE GRN W/BLK STRIPE GREEN GRN W/WHT STRIPE YELLOW WHITE WHITE YELLOW W/YEL STRIPE GREEN GRN W/WHT STRIPE GRN W/BLK STRIPE 0 AMP FUSES BRAKE INTERLOCK SWITCH PINK ORANGE L.H. NEUTRAL SWITCH BLACK GROUND BLACK BLACK BROWN SEAT SWITCH CLUTCH DIODE MODULE PLUG BLACK BLACK DIODE (00V A) ORANGE W/WHT STRIPE STARTER STWC Electrical Schematic NEG POS HOURMETER TO ENGINE ADAPTER HARNESS STARTER SOLENOID R.H. NEUTRAL SWITCH 0
R Section ELECTRICAL SCHEMATIC - HP KAWASAKI LIQUID-COOLED PTO SWITCH WATER TEMP GAUGE KEY SWITCH RELAY GRN W/BLK STRIPE GRN W/WHT STRIPE W/YEL STRIPE YELLOW GREEN BLACK BLACK BLACK BLUE LIGHT BLUE WHITE W/BLACK STRIPE LIGHT BLUE BLUE BLACK GRN W/WHT STRIPE YELLOW WHITE 0 AMP FUSES BRAKE INTERLOCK SWITCH PINK L.H. NEUTRAL SWITCH ORANGE BLACK GROUND BLACK BLACK BROWN SEAT SWITCH CLUTCH MODULE PLUG ORANGE W/WHITE STRIPE DIODE (00V A) TO ENGINE ADAPTER HARNESS WHITE POS NEG HOURMETER ADAPTER HARNESS WHITE YELLOW R.H. NEUTRAL SWITCH MAIN HARNESS GRN W/WHT STRIPE WHITE W/BLACK STRIPE W/YEL STRIPE SOLENOID "B+"