SOLNOI VLVS direct operated core disc 1/ U N NO 3 1 2 3/2 Series 32 TURS Three way solenoid valves with orifice and pipe connections in valve body Valves are designed to handle relatively high pressure 3way applications Valves do not require a minimum operating pressure The solenoid valves satisfy all relevant irectives NRL ifferential pressure Maximum viscosity Response times 55 bar [1 bar = 1kPa] 65cST (mm 2 /s) 5 25 ms fluids () temperature range (TS) seal materials () air, inert gas, water, oil 2 to + 9 2 to + NR (nitrile) UR (urethane) MTRILS IN ONTT WIT LUI () nsure that the compatibility of the fluids in contact with the materials is verified rass body Stainless steel body ody and seat rass ISI 33 SS ore tube Stainless steel Stainless steel ore and plugnut Stainless steel Stainless steel Springs Stainless steel Stainless steel Sealings NR NR iscs NR or UR NR isc holder & core guide Shading coil opper Silver 2 1 P MP RP LP Not vailable Not vailable Not vailable 1,5W16,7W Low Reduced Medium asic POWR LVLS cold electrical holding values (watt) SPIITIONS operating pressure flow pipe orifice differential (bar) prefix optional solenoids coefficient level basic catalogue number size size max. (PS) Kv P NM TX / Ix IP65 min. air/water() 7&9 x d x e mb x mb NPT (mm) (m 3 /h) (l/m) ~ = ~/= N M PV S brass stainless st. U Universal 1/,8 1,6 2,,2,8,1,3 1,3 1,7 N Normally closed 1/,8 1,6 2, 3,2,2,8,1,21,3 1,3 1,7 3,5 NO Normally open,8,2,3 1,6,8 1,3 1/ 2,,1 1,7 3,2,21 3,5 27 9 7 5 15 1 6 55 17 1 5 19 5 35 11 8 11 7 1,5/11,2 1,5/11,2 1,5/11,2 1,5/11,2 1,5/11,2 vailable feature vailable feature in only Not available (1) UR discs 3217 (1) 32172 3217 3218 (1) 32182 3218 32186 3219 (1) 32192 3219 32196 322 3222 3223 322 3225 ll leaflets are available on: www.asco.com 1 816217/R1
SRIS 32 PRIX TL prefix description level 1 2 3 5 6 7 LP RP MP P xplosionproof NM 7, 9 Zinc plated steel conduit V xplosionproof NM 7, 9 316 SS conduit M Waterproof IP67 Metal enclosure (N/I 6797+18+31)* T Threaded conduit/hole (M2 x 1,5) N lameproof luminium (N/I 6791, 67931)* P V ncapsulated epoxy moulded (N/I 67918)* S Solenoid with spade plug connector (N/I 673) W P Waterproof IP67 Metal enclosure W S Waterproof IP67 316 SS enclosure W S M Waterproof IP67 316 SS enclosure (N/I 6797+18+31)* W S N lameproof 316L SS (N/I 6791, 67931)* T Threaded conduit (1/2" NPT) lass attery charging circuit T lass igh temperature X Other special constructions SUIX TL suffix description level 1 2 3 5 LP RP MP P PM (ethylenepropylene) R (chloroprene) N Oxygen service (R (chloroprene)) N V PM (fluoroelastomer) and parts cleaned for oxygen service T PT (polytetrafluoroethylene) V PM (fluoroelastomer) W UR (urethane) O poxy coating on all external surfaces M Mounting bracket P ry gas, nonlubricated air construction Q Long life, quiet operation construction M O Push type manual operator M S Screw type manual operator vailable feature Standard feature for 3217, 3218 and 3219 Not available * TX/Ix valves using these solenoids are approved according to N 13631 (non electrical) PROUT SLTION UI STP 1 Select basic catalogue number, including pipe thread indentification letter. Refer to the specifications table on page 1. xample: 3222 STP 2 Select prefix (combination). Refer to the specifications table on page 1 and the prefix table on page 2, respect the indicated level. xample: PV STP 3 Select suffix (combination) if required. Refer to the suffix table on page 2, respect the indicated level. xample: T STP Select voltage. Refer to standard voltages on page 3. xample: 2V / STP 5 inal catalogue / ordering number. xample: PV3222 T 2V / OPTIONS & SSORIS ll leaflets are available on: www.asco.com 2 catalogue number S 3217 S 32172 S 3217 S 3218 S 32182 S 3218 S 32186 S 3219 S 32192 S 3219 S 32196 S 322 S 3222 S 3223 S 322 S 3225 spare parts kit no. (1) ~ = 32112 3211 32116 321 3211 3212 3213 32182 32183 3218 3218 312189 312191 312191 312193 312193 322 3221 3221 32226 32227 32227 32228 3225 32255 32255 32255 31219 312192 312192 31219 31219 (1) Standard prefixes/suffixes are also applicable to kits (2) Mounting holes in body (3) Mounting bracket supplied standard with valve mouting bracket no. 162951 (3) 162951 (3) 162951 (3) 162951 (3) 162951 (3) ORRIN XMPLS VLVS: prefix () pipe thread basic number () WST 32192 23V / 5 z ST 3218 V 23V / 5 z S 3219 M 2V / WP 3217 MS 2V / WS 32182 VP 2V / 3217 Q 23V / 5 z 3219 O 23V / 5 z 322 MO 2V / 6 z ORRIN XMPLS KITS: prefix basic number WSM 32183 3212 V (5) 32255 MO (5) WP 322 MS suffix () Prefix and V should always be used in conjunction with change letter in the basic number (5) asic kit number applies to S coil construction voltage suffix 816217/R1
SRIS 32 XPLNTION O TMPRTUR RNS O SOLNOI VLVS Valve temperature range Operator ambient temperature range Total temperature range The valve temperature range (TS) is determined by the selected seal material, the temperature range for proper operation of the valve and sometimes by the fluid (e.g. steam) The operator ambient temperature range is determined by the selected level and the safety code The temperature range of the complete solenoid valve is determined by the limitations of both temperature ranges above LTRIL RTRISTIS oil insulation class lectrical safety I 335 Standard voltages (=) 2V 8V (~) 2V 8V 115V 23V/5z; other voltages and 6z are available on request prefix option inrush ~ asic (P) ratings holding ~ operator ambient electrical replacement coil / kit hot/cold temperature enclosure safety code = range protection ~ = (N 6529) (V) (V) (W) (W) ( ) (1) 23V/5 z 2V/ S 55, 23, 1,5 9,/11,2 to +75 N 673 IP65, moulded 25117 2512 12 S 78, 35, 16,7 to +5 N 673 IP65, moulded 25217 12 WP/WS 55, 23, 1,5 9,/11,2 to +75 N 673 IP67, steel/ss 5117 512 3 WP/WS 78, 35, 16,7 to +5 N 673 IP67, steel/ss 5217 3 N/WSN 55, 23, 1,5 6 to+25//6 II2 x d II b T6/T5/T, II2 x tb III b IP66/67, alu./ss 5117 56 N/WSN 9,/11,2 6 to+/6/75 II2 x d II b T6/T5/T, II2 x tb III b IP66/67, alu./ss 512 56 N/WSN 78, 35, 16,7 6 to + II2 x d II b T, II2 x tb III b IP66/67, alu./ss 5217 56 M/WSM 55, 23, 1,5 9,/11,2 to + II2 x e mb II b T3, II2 x tb III b IP66/67, steel/ss 99117 91312 3 PV 55, 23, 1,5 9,/11,2 to +65 II2/ x mb II b T3(~)/T(=), x mb III b IP67, moulded (3) (3) 78 5, 25, 1,1 9,/11,6 to +52/ NM type 7 and 9 NM X 2386157 238716 91 7,, 17,1 to +52 NM type 7 and 9 NM X 23861157 91 (1) Temperature range can be limited by sealings (3) Multiple coil kits are available under TX/Ix, contact us (2) Refer to the dimensional drawings on pages to 5 Not available LTRIL ONNTIONS prefix connection S, Spade plug connector with cable gland N1753183 (ISO ) for cables with an outer diameter from 6 to 1 mm. WP, WS, M, WSM M22 cable gland for cables with an outer diameter from 7 to 12 mm. With an internal and external facility for an earthing or bonding conductor. N, WSN 1/2" NPT threaded cable entry. nclosures are supplied without cable gland. PV Mouldedin cable, standard length 2 m ITIONL OPTIONS x mb (prefix "PV") execution can be supplied in various cable lengths ompliance with "UL", "S" and other local approvals available on request 1/2" NPT (prefix "T") and M2 x 1,5 (prefix "T") conduits (aluminium or 316 SS) available for steel solenoid housing Special mouldedin solid state components for peak voltage suppression and/or rectification (four diode bridge) Mounting brackets for brass body valves, suffix M INSTLLTION Multi language installation/maintenance instructions are included with each valve The solenoid valves can be mounted in any position without affecting operation Stainless steel valves are standard supplied with mounting brackets Threaded pipe connection identifier is = NPT (NSI 1.2.3) eclarations of conformity are available on request type (2) ll leaflets are available on: www.asco.com 3 816217/R1
SRIS 32 IMNSIONS (mm), WIT (kg) TYP 1: TYP 2: poxy moulded poxy moulded S: I 335 / ISO S: I 335 / ISO 3217 / 172 / 17 / 18 / 182 / 18 / 32186 / 19 / 192 / 19 / 196 322 / 22 / 23 / 2 / 25 36 K 36 K L TYP 3: TYP : Metal, epoxy coated / ISI 316 SS Metal, epoxy coated / ISI 316 SS WP / WS: I 335 WP / WS: I 335 M / WSM: N 6797, 18 and 31 M / WSM: N 6797, 18 and 31 3217 / 172 / 17 / 18 / 182 / 18 / 32186 / 19 / 192 / 19 / 196 322 / 22 / 23 / 2 / 25 TYP 5: TYP 6: luminium, epoxy coated / ISI 316L SS luminium, epoxy coated / ISI 316L SS N / WSN: N/I 6791 and N/I 67931 N / WSN: N/I 6791 and N/I 67931 3217 / 172 / 17 / 18 / 182 / 18 / 32186 / 19 / 192 / 19 / 196 322 / 22 / 23 / 2 / 25 1/2 NPT 9 1/2 NPT 9 36 36 15 15 M5 69 M5 66 816217/R1 ll leaflets are available on: www.asco.com
SRIS 32 IMNSIONS (mm), WIT (kg) TYP 7: TYP 8: poxy encapsulated poxy encapsulated PV: N/I 67918 PV: N/I 67918 3217 / 172 / 17 / 18 / 182 / 18 / 32186 / 19 / 192 / 19 / 196 322 / 22 / 23 / 2 / 25 36 36 TYP 9: TYP 1: poxy encapsulated poxy encapsulated : IS6 NSI / NM Type 7 and 9 : IS6 NSI / NM Type 7 and 9 NOT: applicable to solenoid only NOT: applicable to solenoid only 3217 / 172 / 17 / 18 / 182 / 18 / 32186 / 19 / 192 / 19 / 196 322 / 22 / 23 / 2 / 25 36 36 type prefix/option level K L weight 1 S P 8 5 3 3 5 21 36 7 95 18,55 kg 2 S P 8 5 3 22 6 5 62 69 9 17,55 kg 3 WP, WS, M/WSM P 12 82 3 77 21 36 79 15,6 kg WP, WS, M/WSM P 12 82 22 36 6 77 62 77 13,7 kg 5 N/WSN P 97 73 13 5 21 36 1 13 1,6 kg 6 N/WSN P 97 22 36 12 5 62 6 12 128 1,75 kg 7 PV P 67 5 3 5 21 36 63 9,6 kg 8 PV P 67 5 22 36 6 5 62 65 91,7 kg 9 P 77 51 3 5 21 36 69 9,7 kg 1 P 77 51 22 37 6 5 62 66 92,7 kg ll leaflets are available on: www.asco.com 5 816217/R1
SRIS 32 MOUNTIN RKTS 38 25, 7,5 63,5 6 racket number : 168 Material : Zinc plated steel racket number : 162951 Material : Zinc plated steel STIONL RWIN 2 1 xecution: Stainless Steel ISI 316 SS ll leaflets are available on: www.asco.com 6 PI21 vailability, design and specifications are subject to change without notice. ll rights reserved. 816217/R1