Fall 2017 Service Dealer Guide Volume 2 Turbocharger Trans Actuator Exhaust Up Pipe Trailer Brake Control Coupling Oil Pump Cam Phaser Formerly Dealer Only Parts Now Available in the Aftermarket! ADVANTAGE SOLUTIONS DESIGNED FOR TECHNICIANS www.napaonline.com
ADVANTAGE When you see this Extended Alignment Pin Failed Pin PROBLEM: Original actuator fork typically fails due to broken alignment pin and excessive wear on contact pads ADVANTAGE Completely redesigned actuator fork, with an extended alignment pin and contact pads, help prevent wear You Know It s IMPROVED NAPA Solutions products redesigned to improve the original Part Shown: 4WD Actuator Fork NOE 600-2017-1: Ascender, Bravada, Rainier, Trailblazer, Envoy, 9-7x 2009-02 2 Tech Support Available: 1-800-868-5777
BODY OVER 10 SKUS OVER 5 SKUS Antenna Masts Provides reception for radio unit NOE 819-8273-1: Hyundai Accent, Elantra, Tucson, Veracruz 2012-05; Infiniti EX35, FX35, FX45 2009-03; Kia Rondo, Sedona 2016-05; Nissan Altima, Cube, Juke, Murano, Rogue, Sentra, Versa 2017-03 Restores the ability to receive signal from local and satellite radio stations Direct-fit replacement for original equipment designs Automatic Transmission Shift Lever Knobs Attaches to shift lever to change gears NOE 819-8132-1: Chevrolet Camaro 2002-01, Cavalier 2005-97 Matches the overall aesthetic design of the original knob Backed by a Limited Lifetime Warranty Battery Tray Brace Secures battery to chassis NOE 819-8410-1: Chrysler 200 2014-11, Sebring 2010-07, Dodge Avenger 2014-08 Durable steel construction, coated for extra protection against corrosion Includes necessary mounting hardware for a complete repair Battery Tray Holds vehicle battery in place NOE 819-8413-1: Cadillac Escalade 2006-04; Chevrolet Avalanche, Silverado, Suburban, Tahoe 2007-05; GMC Sierra, Yukon 2007-05 Includes all mounting hardware Easy to install, direct-fit replacement OVER 5 SKUS Bumper Cover Grilles Protects fog light components from road debris and moisture NOE 641-8546-1: Ford Explorer 2005-03 Made of sturdy impact-resistant material for added durability and a longer service life Center Console Hinge Repair Kit Repair kit for a broken or damaged center dash console NOE 819-8264-1: Ford Focus 2007-04 Includes required washers and screws for a complete repair 2017 SERVICE DEALER GUIDE VOLUME 2 KNOW HOW 3
BODY OVER 10 SKUS Center Console Latches Secures console lid in closed position NOE 730-0232-1: Ford F-150 2003-97 Includes required bolts for a complete repair Cowl Cover Covers the gap between the vehicle hood and windshield NOE 819-8305-1: Chevrolet Avalanche, C1500, C2500, C3500, K1500, K2500, Silverado, Suburban, Tahoe 2007-99 Mounting hardware included for a complete installation Made of high-quality materials to match the aesthetic design of the original cover OVER 30 SKUS Door Latch Assemblies Controls the vehicle s locks and holds the door shut while driving NOE 655-4200-1: Dodge B1500, B2500, B3500, Ram Van 2003-95 Direct-fit replacement for original equipment designs Mechanical components wear, crack or become frozen into position from corrosion resulting in the inability to open, close or lock the vehicle doors properly OVER 500 SKUS Door Lock Actuator Motors Electric motor located inside door latch controls lock and unlock functions NOE 655-8916-1: Buick Terraza, Saturn Relay 2007-05; Chevrolet Uplander, Venture, Pontiac Montana, Trans Sport 2009-97; Oldsmobile Silhouette 2004-97 Integrated with high-quality electric motor and latch NAPA Solutions has leading coverage on many early and late model DLAs including integrated door lock actuators Door Mirror Switch NOE 730-7398-1: Chevrolet Silverado; GMC Sierra 2014-07 Plug and play installation requires no programming Designed to match the appearance of the original switch 4 Install Videos at YouTube.com/NAPASolutions
BODY OVER 5 SKUS NOE 819-8261-1: Dodge Ram 1500, 2500 2005-02 Door Window Switch Bezels Replaces worn out or cracked door switch trim panels NOE 819-8263-1: Dodge Ram 1500, 2500 2005-02 Designed to match the appearance of the original Normal wear and tear, visible cracks in plastic Fuel Door Hinge A direct replacement, easy to install fuel door hinge assembly NOE 730-6331-1: Ford F-150, Lobo 2008-04, Lincoln Mark LT 2008-06 Built with upgraded materials to resist bending and snapping Fuel Filler Door Switch Remotely operates fuel door lock mechanism NOE 730-7671-1: Volkswagen Golf 2007-99, Jetta 2006-99, Passat 2005-98 Restores the ability to release the fuel door or hold it closed Glove Box Door Replacement glove box door now available for late-model Volkswagen Golf and Jetta applications NOE 730-6397-1: Volkswagen Golf 2001-99, Jetta 2005-99 Matches the aesthetic design of the original door Easy-to-install, no special tools required Grab Handle Replacement interior pillar trim panel with integrated grab handle NOE 819-8981-1: Dodge Ram 1500/2500/3500/4500/5500 2010-02 Made to match the aesthetics of the original grab handle Durable plastic construction to withstand years of use 2017 SERVICE DEALER GUIDE VOLUME 2 KNOW HOW 5
BODY OVER 20 SKUS OVER 40 SKUS Headlight Level Sensors Communicates the appropriate headlight level to the light adjusting motor NOE 690-0263-1: Honda CR-Z, Insight 2011 Reduce repair costs - replace the failed sensor, instead of replacing the entire headlight assembly Manufactured with thicker materials for increased durability against water intrusion, dirt and debris Hood Latch Assemblies Keeps the vehicle s hood closed NOE 876-0800-1: Nissan Altima 2017-07 Durable steel construction features protective coating for added corrosion resistance OVER 30 SKUS Liftgate Lock Actuators Electric motor that opens, locks and unlocks the vehicle liftgate NOE 655-6264-1: Jeep Commander 2010-06, Grand Cherokee 2010-05, Liberty 2012-02 High failure rate during cold weather months Direct replacement for a proper fit every time Original electrical motor wears out over time, resulting in inoperable liftgate OVER 5 SKUS Liftgate Release Switches Restores proper operation to the liftgate door release NOE 730-4970-1: Cadillac Escalade 2014-07; Chevrolet Suburban, Tahoe 2014-07; GMC Yukon 2014-07 Built with superior materials to withstand water, dust and dirt intrusion Easy to install - secure fit connector is plug and play Internal electrical or mechanical failure results in the inability to open or unlock the liftgate 6
BODY OVER 5 SKUS Overhead Console Light Housing Housing for the vehicle s overhead dome/map light NOE 730-6301-1: Chrysler Town and Country, Voyager 2007-01; Dodge Caravan, Grand Caravan 2007-01 Includes switches and bulbs for a complete repair Direct replacement for a proper fit every time Sun Visor Clips Holds sun visor in place NOE 819-5284-1: Chevrolet Express; GMC Savana 2014-03 Direct-fit replacement, matches the original design OVER 25 SKUS Switches - Door Mirror Driver side power mirror switch to adjust side view mirrors NOE 730-7662-1: Ford E-150, 250, E-Super Duty, Expedition, F-150, F-Super Duty, Fusion 2016-05; Lincoln Mark LT 2008-06; Mercury Milan 2009-06 Designed to match the appearance of the original switch Easy to install, plug and play design Internal electrical or mechanical failure results in the inability to adjust side view mirrors LIVE TECH SUPPORT! Need help with a technical question? Connect online live or call our ASE certified technicians (toll-free). NAPASolutionsChat.com 866.933.2911 2017 SERVICE DEALER GUIDE VOLUME 2 KNOW HOW 7
BODY OVER 10 SKUS Tailgate Moldings Protects the top of the truck s tailgate NOE 819-8265-1: Dodge Ram 1500/2500/3500 2010-09; Ram 1500/2500/3500 2016-10 Easy-to-install, DIY-friendly replacement project Replacement molding matches the original equipment look and design USB Port Cover USB port cover replacement NOE 819-8231-1: Various Chrysler, Jeep, Ram 2014-11, Dodge 2014-10 Protects USB port/accessory power outlet socket from dirt and debris Easy to install OVER 20 SKUS Vent Window Motor Opens and closes rear vent windows NOE 655-3202-1: Toyota Sienna 2016-04 Durable, molded plastic housing protects gear armatures and motor against water intrusion Mounting bracket included for a complete installation Window Guides Secures window glass to regulator NOE 819-8997-1: Ford F-150 2004-01 Save time and money by replacing the failed original window guide, instead of the entire window glass Direct replacement for a proper fit every time OVER 85 SKUS Windshield Washer Nozzles Sprays washer fluid on windshield NOE 819-8345-1: Dodge Caliber 2012-07 Replacement of a failed washer nozzle will restore the proper spray pattern, keeping your windshield clear and your vision of the road unobstructed Ideal for repairing damage incurred during car washes or snow and ice removal Exposed to extreme weather like snow, ice and hail. The original nozzle clogs or cracks, resulting in a poor spray pattern 8
BRAKE OVER 130 SKUS PROBLEM: Original steel lines rust from exposure to moisture and corrosive road treatments. ADVANTAGE Upgraded stainless steel resists rust and corrosion. Preformed sectional design solution saves installation time. Brake Hydraulic Line Kits - Stainless Steel Steel brake lines carry pressurized fluid from the master cylinder to the brake caliper or cylinder at the wheel UP 919-0222-1: Chevrolet Tahoe; GMC Yukon 2000-95 UP 919-0223-1 Chevrolet K1500; GMC K1500 1998-95 UP 919-0225-1 Chevrolet K1500 Suburban; GMC K1500 Suburban 1999-95 NAPA SOLUTIONS ASSORTMENT TRAYS Keep hardware and high replacement repair components within arm s reach visit NAPAOnline.com to view our entire collection of assortments 2017 SERVICE DEALER GUIDE VOLUME 2 KNOW HOW 9
CHASSIS PROBLEM: The original unit frequently requires replacement due to brittle plastic construction. ADVANTAGE Upgraded lines to brass for increased durability and a longer service life. Air Suspension Compressor Line Repair Kit Connects the air suspension lines NOE 949-1038-1: Ford Country Squire, Expedition, Explorer, Grand Marquis 2016-87; Lincoln Continental, Mark VII, Mark VIII, Navigator, Town Car 2016-85; Mercury Colony Park, Grand Marquis, Mountaineer 2010-85 OVER 15 SKUS OVER 40 SKUS Axle Pivot Bushings Bushing used as the mounting point for crossmember NOE 523-0066-1: Toyota Corolla 2011-09, Prius 2009-05 Built with top quality materials for increased durability and a longer service life Available separately, eliminating the need to buy a whole set for a single repair Body Mount Sets Secures frame or subframe to vehicle body and dampens road noise and vibration NOE 924-0327-1: Ford Crown Victoria 2011-03; Lincoln Town Car 2011-04; Mercury Grand Marquis, Marauder 2011-03 All necessary bushings and hardware are included for a complete repair (where applicable) Made of high-quality material to resist compression, cracking and separating Coil Spring Bracket Mounting point for the front upper suspension spring NOE 523-0210-1: Mercedes-Benz 2003-96 Features an epoxy coating for high corrosion resistance and increased protection against the elements Made of durable steel for a longer service life Coil Spring Mount Kit Mounting point for coil spring NOE 523-0263-1: Jeep Wrangler 2015-07 Save time and money by replacing the failed original mounts, instead of the entire axle assembly Constructed of durable steel for a longer service life 10
CHASSIS OVER 5 SKUS NOE 523-0218-1: Chevrolet & GMC 2007-99 (rear left, rear right - rearward position) Frame Repair Kits Weld on frame repair kit replaces the rusted section of the vehicle frame NOE 523-0217-1: Chevrolet & GMC 2007-99 (rear left, rear right - forward position) Reduce repair costs - replace just the rusted section of the frame, instead of purchasing an entirely new vehicle frame Durable steel construction coated with weldable rust resistant primer for a longer service life OVER 5 SKUS Located behind the dust cover Jounce Bumpers Prevents damage to the vehicle s control arm, frame, shock mount and other suspension components NOE 523-0258-1: Dodge 2010-08, Jeep 2016-07, Ram 2015-11 Constructed of upgraded material to resist compression, cracking and separating Made of polystyrene foam for long-lasting durability OVER 15 SKUS NOE 730-6780: Chevrolet, GMC, 2000-88 Shock Mounts Bracket used to mount the shock or strut to inside fender well NOE 523-0054-1: Ford F Super Duty 1993-90, F-250 1993-87, F-350 1993, F350 1992-85 Mounting hardware included for a complete repair (where applicable) Built with upgraded bushings for long-lasting resistance to wear and tear Rust damage leads to deterioration resulting in an unstable suspension 2017 SERVICE DEALER GUIDE VOLUME 2 KNOW HOW 11
OVER 65 SKUS CHASSIS Steering Shafts Restores proper rotation to vehicle steering wheel NPS 7-0102-1: Chevrolet Colorado 2012-04, GMC Canyon 2012-04, Hummer H3 2010-06, H3T 2010-09 U-joints use precision engineered needle bearings for a smoother operation Easy to install - no special tools needed Loose steering and/or complete inability to steer vehicle properly NPS 7-0107-1 GM Minivans: Montana, Silhouette, Trans Sport, Venture 2005-97 NPS 7-0159-1 GM Express & Savana Vans 2002-96 NPS 7-0259-1 Dodge Dakota 2000-97, Durango 2000-99 NPS 7-0284-1 Jeep Cherokee 1994-84, Comanche 1992-86, Wagoneer 1990-84 OVER 35 SKUS NOE 611-3413: Cadillac 2006-02, Chevrolet & GMC 2014-99 Suspension Control Arm Bumpers Prevents suspension damage during excessive travel NOE 611-3410-1: Cadillac Escalade 1999; Chevrolet Avalanche, Silverado, Suburban, Tahoe 2012-99; GMC Savana, Sierra, Yukon 2012-99 Replacement prevents damage to control arm frame, shock mounts and other suspension components Made of polyurethane foam for long lasting durability 12 Install Videos at YouTube.com/NAPASolutions
CHASSIS OVER 120 SKUS OVER 10 SKUS Suspension Control Arm Bushings Connecting point between control arm and vehicle frame or subframe NOE 523-0668-1: Nissan Murano 2007-03 Save time and money by replacing the worn bushing, instead of the control arm assembly Built with thicker, upgraded rubber to avoid deterioration Suspension Knuckles Connects the wheels to the suspension NOE 697-0912-1: Ford Explorer; Mercury Mountaineer 2005-02 Direct replacement for a proper fit and trouble-free installation Built with rust resistant coating Suspension Stabilizer Bar Bushing Mounts the sway bar to the chassis NHD 928-5603-1: Chevrolet; GMC 2009-90 Includes all mounting hardware for a complete repair Direct replacement for a proper fit every time Original bushing rusts and deteriorates over time, resulting in loose steering and clunking noise from the vehicle suspension Suspension Trailing Arm Bushing Connects the trailing arm to vehicle frame NOE 523-0239-1: Volkswagen Cabrio, Corrado, Golf, Jetta 2002-92 Reduce repair cost - replace the worn original bushing instead of the entire trailing arm assembly, saving time and money Truck Cab Mount The mounting point between the vehicle body and frame NOE 730-6278-1: Ford Ranger 1997-86 Manufactured with a rust resistant coating for a longer service life Easy to install, direct-fit replacement 2017 SERVICE DEALER GUIDE VOLUME 2 KNOW HOW 13
DIESEL OVER 5 SKUS NOE 601-1064-1: Ford F Super Duty 2010-05 (right) Diesel Glow Plug Wiring Harnesses Provides power to vehicle glow plugs NOE 601-1065-1: Ford F Super Duty 2010-08 (left) Direct replacement ensures a proper fit every time No special tools required during installation Connection points on harness become brittle and crack OVER 5 SKUS Not for sale in NY or CA Filters 99% of Engine-out Soot/PM (Particulate Matter) Diesel Particulate Filters (DPF) New! Light and medium duty DPF, now available in the aftermarket New platinum metals provide: Cleaner exhaust Increased durability Less frequent DPF regeneration NOE 600-9897-1: Dodge Sprinter 2500, 3500; Freightliner Sprinter 2500, 3500 2009-07; Mercedes-Benz Sprinter 2500, 3500 2014-10 100% new, not remanufactured - no core charge Includes all gaskets and hardware for a complete repair (where applicable) The original DPF becomes clogged with soot build-up, resulting in loss of vehicle power and gas mileage Engine Oil Cooler Mount Mounts the oil cooler to the engine block NOE 601-1061-1: Ford Excursion 2003-00, F Super Duty, F-250, F-35, F-59, F-650, F-750 2003-94 Avoid the expense of purchasing an entire oil cooler kit for oil cooler mount repairs Durable aluminum and steel construction for a longer service life Engine Valve Cover Gasket Prevents leaks between valve cover and engine cylinder head NOE 600-2331-1: Ford 2010-03, IC 2007, IC Corporation 2008-05, International 2009-02 Includes all necessary gaskets, seals and grommets for a complete repair Gasket is constructed of high-quality materials for increased durability against extreme underhood temperatures 14
DIESEL Fuel Injection Feed Line Seal Seals fuel line through the valve cover NOE 601-1055-1: Chevrolet C4500 Kodiak, C5500 Kodiak, Silverado; GMC C4500 Topkick, 5500 Topkick, Sierra 2004-02 Save time and money by replacing the failed original seal instead of purchasing an entirely new valve assembly Direct replacement for a proper fit every time Fuel Injector Line Delivers pressurized fuel from the high pressure fuel rail to the fuel injector connector tube NOE 827-1132-1: Ford F Super Duty 2010-08 Includes inlet and return lines and mounting hardware for a complete repair OVER 5 SKUS Nitrogen Oxide (NOx) Sensors Detects nitrogen oxide levels in the vehicle s exhaust system NHD 731-7796-1: Blue Bird, Freightliner, Unclassified 2012-10, Sterling 2010 Anti-seize coating pre-applied to prevent sensor damage from high engine temperatures Required to pass state emissions (in applicable states) Turbocharger Up Pipe Kits Routes exhaust gases from the exhaust manifold to the turbocharger NOE 601-2018-1: Ford E-350 Club Wagon, E Super Duty, Excursion, F Super Duty 2010-05 Stainless steel tubular construction protects against cracks and warping Includes all required gaskets, bolts and nuts for a complete installation FREE NEW PRODUCT ALERTS! Hundreds of Exclusive New Parts Delivered to Your Email Every Month! Sign Up Today! Visit NAPASolutionsEmail.com 2017 SERVICE DEALER GUIDE VOLUME 2 KNOW HOW 15
MEDIUM DUTY A GROWING CATEGORY OF TOW TRUCKS LANDSCAPERS CABLE / TV SERVICE Freightliner OVER 35 SKUS Coolant Reservoirs NHD 605-0141-1: M2 2016-12 Radiator Grilles NHD 424-5202: Columbia 2014-00 International OVER 80 SKUS Coolant Reservoirs NHD 448-5104: 3000, 4000, 7000, 8000 Series; IC School Bus w/dt466 Engine 2007-06 EGR Valves NHD 600-9962-1: 1000, 3000, 4000, 7000 Series; IC School Bus w/ DT466 & MaxxForce DT Engines 2010-07 Ford OVER 550 SKUS Valve Covers NOE 601-5116-1 [R]: 7.3L engines 2003-96 16 Product training available at NAPAtraining.com
OVER 1,600 SKUS IDEAL FOR: MEDIUM DUTY UTILITY COMPANIES MUNICIPALITIES REFUSE TRUCKS Chevrolet / GMC OVER 700 SKUS Chevrolet Roof Marker Lights NOE 735-5026: C4500, C5500, C6500, C7500, C8500 Kodiak 2009-05 GMC EGR Valves NOE 776-0203-1: 7.4L engines 2000-93 Isuzu OVER 240 SKUS Multifunction Switches NOE 233-0906-1: NPR, NPR-HD, NQR w/ Exhaust Brake 2004-03 Timing Cover Kits NOE 601-5220-1: 4.8L, 5.3L, 6.0L NPR, NPR-HD 2007-2003 Hino OVER 55 SKUS Coolant Reservoirs NHD 448-5751: 165, 185, 238, 258LP, 268, 338, Dutro, FD, 145, 258ALP, 268A, 338CT, 358, 308 2010-05 Headlight Assemblies NHD 800-5759 [R] & NHD 800-5760 [L]: 258ALP, 258LP, 268, 268A, 338, 338CT, 145, 165, 185 2014-06 2017 SERVICE DEALER GUIDE VOLUME 1 KNOW HOW 17
DRIVETRAIN NOE 666-2075-1 Hyundai Santa Fe, Tucson 2017-13; Kia Sorento, Sportage 2017-13 All Wheel Drive Coupling Oil Pumps Pressurizes the rear differential when the All-Wheel-Drive (AWD) feature is activated NOE 666-2060-1: Volvo S60, XC70 2009-03, S80 2008-04, V70 2002-01, XC90 2008-03 NOE 666-2061-1 Volvo S60 2002 O-ring included for a complete repair Easy-to-install, just plug into mating component, no programming required during installation Build up of engine sludge combined with dirt, contamination and old engine oil damages mechanical components OVER 10 SKUS Differential Covers Protects and seals the back of the differential housing NOE 666-2023-1: Nissan Titan 2015-04 Comes with a pre-installed magnet in housing cover Includes high-quality rubber fill plug (where applicable) Drive Shaft Pinion Yoke Transmits power from the transfer case to the differential NOE 600-1118: Cadillac Escalade 2005-02; Chevrolet Tahoe; GMC Yukon 2005-00 Manufactured from durable steel for a longer service life Direct-fit for a proper fit every time Locking Hub Service Kit Seals the front locking hub NOE 666-2025-1: Ford F Super Duty Trucks 2016-04 Includes all gaskets, seals and screws for a complete locking hub repair Easy to install, direct-fit replacement Located behind wheel hub Failure results in loss of Four-Wheel-Drive (4WD) 18 Tech Support Available: 1-800-868-5777
ELECTRONICS OVER 45 SKUS Air Bag Impact Sensors Alerts onboard computer system in the event of sudden or extreme deceleration NOE 731-8009-1: Ford, Lincoln, Mercury 2017-09 Plug and play design for easy installation without the need to program Includes mounting hardware for a complete repair (where applicable) Automatic Transmission Pressure Sensor Transducer Signals PCM/TCM to shift gears in the transmission NOE 731-8170-1: Chrysler, Dodge, Jeep, Mitsubishi, Ram 2016-00 Direct-fit, plug and play installation OVER 5 SKUS Automatic Transmission Throttle Valve Controls the transmission throttle pressure NOE 609-0045-1: Dodge Dart 2016-13, Ram 2500/3500 2009-05 Restores the ability to shift in and out of gear smoothly Hassel-free installation, no need to disassemble transmission during repair Battery Fuses Protects electrical circuits from overload NOE 926-0013-1: Mitsubishi Lancer 2004-03 Restores proper operation to electronic accessories throughout the vehicle Easy to install - no special tools required OVER 260 SKUS OVER 5 SKUS Door Window Switches Driver and passenger side switches to open/close vehicle window NOE 901-2990-1: Chevrolet Trailblazer 2009-06, Trailblazer EXT 2006 Designed to match the exact fit, form and function of the original switch Easy plug-and-play installation, no programming required High Intensity Discharge Headlight Igniters Ignites electrical voltage to operate vehicle HID bulbs NOE 731-8106-1: BMW 2010-99; Land Rover 2009-02; Mazda 2008-05; Mercedes 2017-94; Mini 2008-02; Porsche 2004-97 Save time and money by replacing the failed headlight igniter, instead of the entire headlight assembly Direct replacement for over one million late-model Acura and Honda applications 2017 SERVICE DEALER GUIDE VOLUME 2 KNOW HOW 19
ELECTRONICS OVER 20 SKUS HID Lighting Ballasts Controls voltage to vehicle headlamps NOE 731-8201-1: Mazda 3 2015-14, CX-5, CX-9 2015-13 Restores proper operation of your vehicle s headlights and helps to improve overall performance An immediate, must-fix item - replacement is necessary for passing state inspections (in applicable states) Located under the headlight assembly Internal electrical or mechanical failure results in inoperable headlights PROBLEM: The original unit typically requires replacement due to failed electronic resistors on the internal circuit board. ADVANTAGE Design incorporates upgraded resistors for added durability and to prevent future burnout. Information Display Modules Provides fuel level, outdoor temperature, and compass information to driver NOE 599-0958-1: Toyota Tacoma 2009-05 OVER 10 SKUS Park Assist Cameras Captures image behind vehicle when in reverse, reducing blind spots NOE 731-8080-1: Chevrolet Cheyenne, Silverado; GMC Sierra 2009 Upgraded camera lens provides a wider angle and clearer resolution Coating added for additional protection of the electrical components Corrosion and exposure to environmental contaminants results in image not displaying correctly 20 Install Videos at YouTube.com/NAPASolutions
ELECTRONICS OVER 40 SKUS Parking Aid Sensors Alerts drivers to close-proximity objects NOE 731-8189-1: Ford F-150 2014-09; Lincoln Mark LT 2014-10 Sensor is sealed to prevent moisture and debris from entering unit Comes with matching connectors and fully compatible electronics for a complete repair (where applicable) Shift Interlock Actuator Enables vehicle transmission to move smoothly in and out of gear NOE 609-0390-1: Ford F-150 2010-04; Lincoln Mark LT 2008-06 Built with high-quality electric solenoid Housing material protects motor from damage ensuring a longer service life OVER 15 SKUS Trailer Brake Control Module Activates the trailer brakes along with the vehicle brakes to ensure a safe stop at all times NOE 731-7690-1: Ford F-150 2014-12 Allows driver to adjust trailer brake force depending on trailer weight and driving conditions Transmission Control Modules Combines the valve body solenoids, pressure and temperature switches into one complete unit NOE 609-0350-1: Ford Edge, Explorer, Flex, Fusion, Taurus 2017-07; Lincoln MKS, MKT, MKX, MKZ 2017-07; Mercury Sable 2009-08 Completely remanufactured and vehicle simulator tested for durability and quality assurance Contains all new gaskets, grommets and seals VISIT US ON! INSTANT ACCESS TO A LIBRARY OF VIDEOS, INCLUDING: Installation Product Spotlights Training and Much More! YOUTUBE.COM/NAPASOLUTIONS 2017 SERVICE DEALER GUIDE VOLUME 2 KNOW HOW 21
ENGINE OVER 10 SKUS NOE 700-7006-1 Ford E Super Duty, F Super Duty, F59, F650 2016-08 Engine Oil Coolers Cools and regulates engine oil temperatures NOE 700-7005-1: Ford Expedition, F-150, F-250, F-350, Lobo 2014-97; Lincoln Blackwood Navigator 2014-98 Corrosion-resistant for extra protection against the elements Durable aluminum construction for long-lasting performance Internal or external leaks results in oil in engine coolant or higher than normal system operating temperatures LOCATION OF ORIGINAL BOLT PROBLEM: The original design requires labor-intensive drilling and tapping to remove the original bolt. ADVANTAGE Reduces labor time by eliminating the need to remove the cylinder head during installation, significantly reducing repair costs and saving money. Engine Timing Chain Guide Bolt Retains timing chain guide NOE 917-0954-1: GM, Buick, Chevrolet, GMC, Oldsmobile, Pontiac, Saturn 2015-00; Saab 9-3, 9-3X 2010-03 22
MARKET LEADING COVERAGE ENGINE VVT SOLUTIONS PROGRAM NAPA Solutions VVT program provides the aftermarket s most comprehensive coverage for over 190 million vehicles on the road today. OVER 175 SKUS NOE 600-3728: Subaru Forester 2013-05, Impreza 2010-06, Legacy 2013-07 Engine Variable Timing Solenoids Activates variable valve timing by controlling air flow and pressure NOE 600-3714: Lexus 2012-10, Pontiac 2010-09, Scion 2013-05, Toyota 2013-0 Vehicle simulator tested to ensure quality assurance Includes all gaskets needed for a complete repair (where applicable) OVER 25 SKUS IMPROVED ROTOR STRONGER ALLOY PLATE PROBLEM: The original sprocket wears leading to poor engine performance. ADVANTAGE NAPA Solutions new rotor design reduces friction and provides smoother engagement for a longer service life and improved overall performance. Engine Variable Timing Sprockets Adjusts camshaft timing for optimal engine performance and efficiency NOE 610-0111-1: Ford 2011-04, Lincoln 2011-05, Mercury 2010-06 NOE 610-0031-1: Chevrolet 2012-08, GMC 2012-08, Hummer 2010-08, Isuzu 2008-06, Saab 2009-08 NOE 599-9912-1: Buick 2011-09, Buick 2007-06, Chevrolet 2011-06, Pontiac 2010-06, Saturn 2009-06 2017 SERVICE DEALER GUIDE VOLUME 2 KNOW HOW 23
ENGINE OVER 25 SKUS Turbochargers Provides pressurized air to the engine to increase performance NOE 776-0168-1: Buick Encore 2017-13; Chevrolet Cruze, Cruze Limited, Sonic, Trax 2017-12 Balance tested individually with results included in product packaging All installation components included for a complete repair Turbocharger Diverter Valves Recirculates excess boost back into the air intake when the throttle is closed NOE 911-0240-1: Audi A3, A4, A5, A6, A8, Allroad, Q3, Q5, RS7, S6, S7, S8, TT 2016-05; Volkswagen Beetle, CC, EOS, Golf, GTI, Jetta, Passat, Tiguan 2016-06 Coated with zinc chromate for corrosion resistance Direct replacement for a proper fit every time NOE 917-0146-1 BMW 545i, 550i, 645Ci, 650i, 745i, 745Li, 750i, 750Li, 60i, 760Li, Alpina B7, X5 2010-02 Vacuum Pump Repair Kits Seals the vacuum pump mechanism NOE 776-7000-1: Volvo S60, S80, V60, V70, XC60, XC70, XC90 2015-07 Includes all gaskets and hardware for a complete vacuum pump repair Save time, money and labor by replacing the failed original gasket, instead of the entire vacuum pump assembly Original O-rings degrade over time causing vacuum leaks resulting in a malfunctioning HVAC system FREE NEW PRODUCT ALERTS! Hundreds of New Parts Delivered to Your Email Every Month! Sign Up Today! Visit NAPASolutionsEmail.com See ProLink or PartsPro SE for complete application details 24
FUEL & EMISSIONS OVER 5 SKUS Capless Fuel Funnel Used to pour fuel additives into capless fuel tanks NOE 819-8378-1: Ford, Mercury; Chrysler; Dodge; Jeep, 2017-09 Fits a wide range of gas tanks including capless fuel tanks found on popular Ford vehicles Ideal for emergency roadside fill ups and when fuel additives are needed Engine Intake Manifold Flap Motors Regulates air flow into the motor of the vehicle NOE 602-1553-1: Mercedes-Benz E320, GL320, ML320, R320, R350 2013-07 Direct-fit replacement for original equipment designs Replacement prevents possible engine damage OVER 25 SKUS OVER 40 SKUS Evaporative Emissions System Leak Detection Pumps Monitors the EVAP system for leaks NOE 776-6001-1: BMW 2016-00; Hyundai 2005-00; Mazda 2009-06; Volkswagen 2017-11 Helps to reduce atmospheric pollution due to hydrocarbon emissions Direct-fit replacement for original equipment designs Fuel Lines Transfers fuel to the vehicle s engine NOE 827-1340-1: Chevrolet Express, G30; GMC G3500, Savana 2002-96 Constructed of high-quality fuel-grade nylon or coated steel for long-lasting durability against fluctuating under hood temperatures (where applicable) Easily fits into mating fuel fitting or fuel barb OVER 5 SKUS PROBLEM: Original fuel lines rust from exposure to moisture and corrosive road treatments. ADVANTAGE Upgraded to stainless steel to resist rust and corrosion. Preformed section design solution saves installation time. Fuel Line Kits - Stainless Steel Transfers fuel to the vehicle s engine NOE 827-1180-1: Chevrolet Silverado; GMC Sierra 2003-99 2017 SERVICE DEALER GUIDE VOLUME 2 KNOW HOW 25
FUEL & EMISSIONS PROBLEM: When original sensor fails, the dealer only offers a complete replacement of both the hose and sensor assembly. ADVANTAGE Replacement sensor saves money by enabling the replacement of only the failed original part. Fuel Pressure Sensor Part of the EVAP system that monitors fuel tank pressure levels NOE 600-5991-1: Ford 2014-00, Lincoln 2009-07, Mercury 2010-02 OVER 20 SKUS 6 SKUS Secondary Air Injection Pumps Injects fresh air into the exhaust system to reduce emissions NOE 776-5162-1: Volvo 960 1997-95, S90, V90 1998-97 Quality tested to meet the fit, function and endurance of the original pump Turbocharger Boost Solenoids Regulates air pressure to the turbo waste gate actuator NOE 776-0003-1: Audi A3, Q3 2016-15; Volkswagen Beetle, Golf, Jetta, Passat 2016-12 Vehicle try-on and material tested to meet product standards for quality Direct replacement is easy to install and requires no special tools during installation 60 SKUS Vapor Canister Vapor Canisters Stores excess fuel vapors from the gas tank until ready to be released into the combustion chamber NOE 776-5283-1: Subaru Forester 2008-04, Impreza 2007-04 Replacement helps control hydrocarbon emissions from escaping into the environment Direct replacement for a proper fit every time Physical damage, cracking or over filling of the fuel tank 26 Tech Support Available: 1-800-868-5777
FUEL & EMISSIONS OVER 90 SKUS Vapor Canister Purge Valves Releases fuel vapor into the intake manifold NOE 776-5221-1 Porsche 911 2005-98, Boxster 2004-97 NOE 600-3704: GM 2017-16, GM 2014-04, ISUZU 2016-12, SAAB 2009-05, Workhorse 2012-08 Mounting hardware included for a complete repair (where applicable) OVER 5 SKUS Shut off Valves Vapor Canister Shut-Off Valves Restores on-board diagnosis of the EVAP system NOE 776-5258-1: Acura RSX 2006-05; Honda Accord, Civic, Insight, S2000 2009-03 Mounting hardware included for a complete repair LIVE TECH SUPPORT! Need help with a technical question? Connect online live or call our ASE certified technicians (toll-free). NAPASolutionsChat.com 866.933.2911 2017 SERVICE DEALER GUIDE VOLUME 2 KNOW HOW 27
HEATING & COOLING 80 SKUS NOE 660-2072-1 Buick Allure, LaCrosse 2009-05; Chevrolet Impala, Monte Carlo 2005-04; Pontiac Grand Prix 2008-04 Air Conditioning Bypass Pulleys Replaces seized air conditioning compressor to restore vehicle function without shortening belt NOE 660-1982-1 Jeep Grand Cherokee 2004-99, Wrangler 2006-00 NOE 660-1994-1: Dodge Dakota, Ram 1500 2007-04; Jeep Commander, Grand Cherokee 2007-05; Mitsubishi Raider 2009-06 Mounting bracket included for a complete repair Eliminate the need to install a completely new A/C Seized air conditioning compressor, resulting in breakage or compressor noise from serpentine belt OVER 5 SKUS Coolant Heat Storage Tank Pump Circulates water in the coolant heater storage tank NOE 902-0611-1: Toyota Prius 2009-04 Easy to install, direct-fit replacement for original equipment designs Engine Coolant Filler Necks Transfer engine coolant NOE 605-3283-1: Buick Terraza 2007-06; Chevrolet Impala, Monte Carlo, Uplander 2011-06; Pontiac Montana 2009-06; Saturn Relay 2007-06 Designed to withstand extreme changes in temperature that frequently cause the original housing to become brittle, crack and leak Heater Water Pump Ensures proper coolant flow throughout the vehicle s heating system NOE 902-0610-1: Toyota Prius 2009-04 Constructed of high-quality materials for increased durability and longer service life Direct replacement for a proper fit every time HVAC Heater Control Valve Controls coolant flow from the engine to the heater core, providing heat to the passenger compartment NOE 731-7751-1: Toyota Prius 2009-04 Replace only the failed control valve versus the more costly entire assembly 28 Install Videos at YouTube.com/NAPASolutions
HEATING & COOLING OVER 100 SKUS PROBLEM: Original Y-connectors are made of plastic and frequently leak due to cracking. ADVANTAGE NAPA Solutions upgrades the Y-connector material to aluminum for increased durability and a longer service life. HVAC Heater Hose Assemblies Ensures proper coolant circulation NOE 901-0967-1: Chrysler Town & Country 2016-11; Dodge Grand Caravan 2017-11 NOE 827-5713-1 Ford Expedition; Lincoln Navigator 2010-07 NOE 827-5726-1 Ford Explorer; Mercury Mountaineer 2010-06 NOE 809-5237 Subaru Legacy, Outback 2009-07 Turbocharger Coolant Line Drains coolant from the turbocharger NOE 730-0117-1: Subaru Baja 2006-04, Legacy, Outback 2009-05 Complete Kit - Includes necessary gaskets and seals for a complete repair (where applicable) Nickel plated to prevent rust and corrosion (where applicable) General wear and rust damage leads to coolant leaks FREE NEW PRODUCT ALERTS! Hundreds Of New Parts Delivered To Your Email Every Month! Sign Up Today! Visit NAPASolutionsEmail.com 2017 SERVICE DEALER GUIDE VOLUME 2 KNOW HOW 29
HARD TO FIND A full line of merchandised parts offering direct-replacements for a wide variety of in-demand fixes. HUNDREDS OF HARD TO FIND SKUS NAPAOnline.com EXTERIOR Antenna Base Plate Gasket Creates water tight seal between antenna base and body NOE 819-8521-1: Honda Civic 1995-92 INTERIOR MAINTENANCE UNDERCAR Auto Transmission Shifter Repair Kit Releases shifter from park position NOE 819-8288-1: Honda Accord 2005-03 Bumper Trim HVAC Heater Control Knobs NOE 819-8244-1: Chevrolet 2014-07, GMC 2014-07 NOE 735-4271-1: Chrysler,Dodge, Eagle 1997-94 Restores the overall look and appearance of the bumper UNDERHOOD Matches the exact fit and appearance of the original OVER 15 SKUS Windshield Washer Cap Tailgate Latches Secures tailgate to the body of the vehicle NOE 819-5029-1: Ford 2015-97, Lincoln 2008-06 30 Cap seal prevents contaminants from entering fluid NOE 819-8496-1: Honda 2013-09, 2006-02, 1996-85
WHEELS OVER 25 SKUS NOE 610-3171-1: Dodge Journey 2017-0 Spare Tire Hoists Holds spare tire in place underneath the vehicle NOE 610-3044-1: Buick Rendezvous 2007-02; Pontiac Aztek 2005-01 Coated finish to prevent rust and corrosion Includes mounting hardware for a complete repair (where applicable) Original hoist metal wears and cracks from rust damage OVER 120 SKUS Spare Tire Jack Handles / Wheel Lug Wrenches Direct replacement spare tire tool kit NOE 926-0809-1: Dodge Ram 1500 2010-03, Ram 1500 2017-10 Constructed of steel and powder-coated for long-lasting durability Includes tool kit sleeve and easily fits within the vehicle storage compartment Wheels (Alloy) Mounts tire to wheel hub NOE 939-0600-1: Pontiac G6 2009-05 Fully compatible with original wheel covers and all TPMS sensors Orders received by 3 p.m. EST. will ship the same business day Alloy Wheels NOE 939-0612-1 Nissan Sentra 2006-04 NOE 939-0603-1 NOE 939-0616-1 Toyota Camry 2014-12 Volkswagen Jetta 2007-05 Steel Wheels NOE 939-0618-1 Toyota Sienna 2007-04 NOE 620-1090-1 Ford F Super Duty 2015-08 NOE 620-1063-1 Dodge Ram 4500/5500 2010-08, Ram 4500/5500 2014-11 2017 SERVICE DEALER GUIDE VOLUME 2 KNOW HOW 31
JOIN NOW! GET ALERTS ON HUNDREDS OF NEW PRODUCTS RELEASED EACH MONTH! New Product Alerts Service Dealer Guide Alerts Special Events Sign up or visit napasolutionsemail.com VIEW OUR VIDEOS! NEW VIDEOS ADDED ON A REGULAR BASIS! New Product Videos Training and Installation Videos For instant access or visit YouTube.com/NAPASolutions E-LEARNING LOG-ON TO TEST YOUR KNOWLEDGE Diesel Parts NAPA Service Dealer Guides And more Visit NAPATraining.com NAPA Solutions, Inc. 3400 East Walnut Street Colmar, PA 18915 Corporate Office and Customer Service: 1-800-523-2492 New Product Idea Hotline: 1-800-336-3575 2017 No reproduction in whole or in part without prior written approval. SDG2017v1 2017030