Learning Module 6: Medium Voltage Power Circuit Breakers. 101 Basic Series

Similar documents
Learning Module 5: Fundamentals of Circuit Breakers. 101 Basic Series

MAHALAKSHMI ENGINEERING COLLEGE TIRUCHIRAPALLI

Learning Module 10: Loadcenters. 101 Basic Series

Medium Voltage Metal-Enclosed Switches

Medium Voltage Metal-Enclosed Switches

Design Standards NEMA

Metal-Enclosed Switches. Medium Voltage. Medium Voltage Metal-Enclosed Switches Contents

MAGNETIC MOTOR STARTERS

Power systems Protection course

School of Electrical and Information Engineering. ELEC High Voltage. University of Sydney. Dr Keith Mitchell. Engineering

Circuit breaker interlocking and operation requirements SIEMENS

Type SDV6 distribution circuit breaker. Top performance - proven reliability. Answers for energy.

Medium Voltage Standby non-paralleling Control GUIDE FORM SPECIFICATION

Miniature circuit breaker Application guide

www. ElectricalPartManuals. com Section 13 Switchgear Low Voltage

Introduction to Circuit Breaker. Working Principle of Circuit Breaker

R-MAG Vacuum Circuit Breaker with Magnetic Actuator Mechanism 15.5 kv - 27 kv; 1200 A A

Breaking new ground. A circuit breaker with the capacity to switch 15 large power plants

Unitole UP kv Primary substations Motor control centres

Pretest Module 29 High Voltage Unit 1

Busway. Siemens STEP 2000 Course. STEP 2000 Courses distributed by

Low Voltage Switchgear Type WL Low Voltage Metal-Enclosed Switchgear

R-MAG. Vacuum Circuit Breaker with Magnetic Actuator Mechanism

EE 741 Over-voltage and Overcurrent. Spring 2014

Power/Vac Vacuum Replacement Breakers for GE Magne-Blast Type AM & AMH Breakers

Chapter 6 Generator-Voltage System

Tradition. Technology. Innovation.

DESIGN GUIDELINES LOW VOLTAGE SWITCHGEAR PAGE 1 of 5

Longest Life Product for Electric Furnace Applications! 100,000 Operations No Routine Maintenance Required!

FUSES. Safety through quality

SION Vacuum Circuit-Breakers. Answers for energy. Medium-Voltage Equipment Selection and Ordering Data. Catalog HG

TECHNICAL SPECIFICATION OF 11KV SF6 / VCB METAL ENCLOSED, INDOOR (PANEL TYPE) / OUTDOOR RING MAIN UNIT (RMU). (IEC standard equipment)

University of Houston Master Construction Specifications Insert Project Name

HD4. Gas insulated MV circuit-breakers kv A ka

Power Break II Switchboard

SWITCHGEAR DIVISION PRODUCT PROFILES

Bolted contact switches. Pringle switches

A comparison of metal-enclosed load interrupter (ME) switchgear and metal-clad (MC) switchgear

UNIVERSITY OF WASHINGTON Facilities Services Design Guide. Electrical. Switchboards. Basis of Design. Design Evaluation

Unitole UP kv Primary substations Motor control centres

SIEMENS. Series 8100oT Vacuum Controllers. www. ElectricalPartManuals. com. Bulletin CC

Critical Power Switchboards. Selection and Application Guide

A system fault contribution of 750 mva shall be used when determining the required interrupting rating for unit substation equipment.

SWITCHCRAFT. Switchcraft Europe GmbH SWITCHCRAFT

High-Voltage Circuit-Breakers 3AP1/ kv up to 550 kv. Power Transmission and Distribution

Outdoor live tank SF 6. circuit breaker Type OHB for 24/36/40.5 kv applications

Using new Magnetically Actuated Vacuum Interrupter technology for safe and reliable medium voltage circuit breaker switching in mines

AIR INSULATED EXTENDABLE SWITCHGEAR UP TO 12KV GUIDE

Product guide. Enclosed NEMA starters. Answers for industry.

OHB Outdoor sulphur Hexafluoride circuit-breaker

Types of Motor Starters There are several types of motor starters. However, the two most basic types of these electrical devices are:

Power/Vac Switchgear Concepts And Basic Configurations

B kv T&D GAS INSULATED SWITCHGEAR

5kV to 38kV, 630 Amp to 4000 Amp Indoor or Outdoor Application

VersaRupter 5-38 kv Load Interrupter Switch. Technical Guide

Study of Fault Clearing by A Circuit Breaker In Presence of A Shunt Capacitor Bank

SECTION LOW VOLTAGE DISTRIBUTION EQUIPMENT

AIR CORE REACTORS. Phoenix Electric Corporation

STEP Motor Control Centers

CSDA Best Practice. Hi-Cycle Concrete Cutting Equipment. Effective Date: Oct 1, 2010 Revised Date:

THE BEST ELECTRICAL CONTROLS BUSINESS ON THE PLANET! Unmatched Service Superior Product Quality Advantage Pricing

SION Vacuum Circuit-Breakers. Answers for energy. Medium-Voltage Equipment Selection and Ordering Data. Catalog HG

Boric Acid Fuse Links

Fuseology. Fuse Holders, Fuse Blocks, Power Distribution Blocks & Surge Suppression. Optima Fuse Holders & Overcurrent Protection Modules.

Power & High Voltage Joslyn Hi-Voltage Overhead Reclosers & Switches H-220. Series HVI Hi-Velocity Interrupter Attachment

Horizontal Circuit Switchers

Design considerations for generator set mounted paralleling breakers

The Physics of the Automotive Ignition System

The University of New South Wales. School of Electrical Engineering and Telecommunications. Industrial and Commercial Power Systems Topic 2

Gas-insulated medium-voltage switchgear. For marine and offshore applications. Answers for energy.

Air-insulated switchgear UniGear type ZS1

2000 Cooper Bussmann, Inc. Page 1 of 9 10/04/00

RBA Catalog Numbers and Information

SION vacuum circuit-breaker.

ABB AG - EPDS. Ultra-Fast Earthing Switch UFES active internal arc protection

B kv Gas-insulated Substations

Modular medium-voltage switchgear. NorMax

Simplified Guide To Understanding Short-Circuit Current Rating FIND IT, FIX IT, FORGET IT

Ensuring the Safety Of Medical Electronics

SafeGear Motor Control Center Arc Resistant Metal-Clad Construction Brochure

Advanced Guide To Understanding Assembly Short-Circuit Current Rating WITH ENGINEERING SOLUTIONS AND OVERCURRENT PROTECTION DEVICES TO ENHANCE SCCR

Metal Clad Air Insulated Switchgear

HHD. High Voltage Fuses German DIN Standard. The temperature limiting function of the fuse striker pin. Design and construction.

Dead Tank Circuit Breaker 145PM40-C Compact design with enhanced reliability

Descriptive Bulletin. R-MAG TM magnetically actuated dead tank outdoor vacuum circuit breaker 15.5 kv - 38 kv

Product guide. Enclosed NEMA starters. usa.siemens.com/controls

Product Guide. enclosed NEMA STARTERS

Typical Specification

SafeGear Motor Control Center Arc Resistant Metal-Clad Construction Descriptive Bulletin

B-03 ELECTRICIAN TRAINING SKILL DEVELOPMENT GUIDE

Applications. Distribution transformers up to 2000 kva High-voltage motors up to 3 MW Capacitors up to1200 kvar MV voltage transformers Cable feeders

Medium-voltage fuses 3 kv 40.5 kv, 0.4 A 315 A

Horizontal Circuit Switchers

SF6 GAS INSULATED METAL ENCLOSED SWITCHGEAR (GIS)

CONTROLLIX CORPORATION CONTROLLIX.COM LOW VOLTAGE AUTOMATIC SWITCH CAPACITOR BANK SPECIFICATIONS

Electric Motor Controls BOMA Pre-Quiz

Medium Voltage Metal Enclosed Thyristor Switched Harmonic Filter Banks

Selective Coordination

Reducing. with Current. arc flash note 2. points of interest. Why Use Current Limiting Fuses. By mike lang, Principal field engineer

MOTOR CONTROLLERS. STATE the function of motor controllers.

Transcription:

Learning Module 6: Medium Voltage Power Circuit Breakers 101 Basic Series

What You Will Learn We ll step through each of these topics in detail: Introduction 4 Components 4 Frame 5 Operating Mechanism 5 Trip Unit 5 Trip Intelligence 6 Arc Extinguisher 7 Arc Extinguishing Technologies 7 Vacuum Interrupter Technology 7 Spiral Contacts 9 SF6 Gas Technology 9 Puffer-Type SF 6 Gas Technology 10 Rotary Arc-Type SF 6 Gas Technology 11 Review 1 12 Ratings 13 Ratings and Standards Vary 13 Maximum Voltage 14 Continuous Current 14 Enclosure and Mounting 14 Enclosure 14 Mounting 15 Fixed Mount 15 Drawout Mount 16 Standards 18 Helping the Customer 19 Circuit Breaker Details 19 Configuration and Accessory Details 19 Review 2 20 Glossary 21 Review 1 Answers 24 Review 2 Answers 24 Page 2

Welcome Welcome to Module 6, which is about Medium Voltage Power Circuit Breakers. By medium voltage, we mean a voltage range of 1000 volts to 38 kv. (Some consider 72.5 kv as the upper end of medium voltage, but we will work with 38 kv for the purpose of this training module.) Figure 1. Family of Medium Voltage Vacuum Circuit Breakers (ANSI and IEC Types) A Note on Font Styles Viewing the Glossary Like the other modules in this series, this one presents small, manageable sections of new material followed by a series of questions about that material. Study the material carefully, then answer the questions without referring back to what you ve just read. You are the best judge of how well you grasp the material. Review the material as often as you think necessary. The most important thing is establishing a solid foundation to build on as you move from topic to topic and module to module. Key points are in bold. Glossary items are italicized and underlined the first time they appear. Printed versions have the glossary at the end of the module. You may also browse the Glossary by clicking on the Glossary bookmark in the left-hand margin. Page 3

Introduction To understand where the medium voltage power circuit breaker fits into the scheme of things, you need to understand the basics of power distribution in an industrial environment. An industrial distribution system consists of: metering devices to measure power consumption main and branch disconnects protective devices switching devices to start and stop power flow conductors transformers Power may be distributed through various Switchgear and Switchboards, transformers and Panelboards. The medium voltage power circuit breaker is found in switchgear assembly. A switchgear assembly controls electric power circuits. Figure 2. Typical Industrial Power Distribution Components The Circuit Breaker is the main device the heart of the switchgear. It provides centralized control and protection of medium voltage power equipment and circuits. Its operation covers load switching, control and fault protection for generators, motors, transformers, capacitors and all types of feeder circuits. This type of power equipment is normally found in industrial, commercial and electric utility installations. Typical applications include electric utility systems, industrial distribution systems, commercial buildings, municipal pumping stations, and transportation systems. There are four main parts to a medium voltage power circuit breaker. These are: Frame Operating Mechanism Trip Unit Arc Extinguisher Page 4

Figure 3. Typical Medium Voltage Vacuum Circuit Breaker with Front Cover Removed, Exposing Operating Mechanism Frame Operating Mechanism Trip Unit A medium voltage power circuit breaker is essentially an assembly of parts on a rugged metal Frame. Depending upon factors such as ratings and interrupting method, they come in a variety of shapes, sizes and configurations. The medium voltage power circuit breaker uses a stored-energy Operating Mechanism to open the circuit breaker. It has a motor-charged, spring-type, storedenergy closing mechanism. Closing the breaker charges the accelerating springs. Protective relays on the control switch energize a shunt trip coil to release the accelerating springs and open the breaker. This is a trip-free design truly mechanically and electrically trip free. Breaker contacts will not touch or close onto a fault, even when a mechanical or electrical close command is issued. The manual controls are usually accessed from the front of the circuit breaker. Although medium voltage power circuit breakers are electrically operated, the closing springs can be charged manually. For more on operating mechanisms, see Module 5, Fundamentals of Circuit Breakers. A Trip Unit is typically integral to a circuit breaker. But, the medium voltage power circuit breaker uses externally mounted trip units to provide the operational intelligence. These devices are called Protective Relays. The protective relays are normally wired to the circuit breaker and Current Transformers. They are mounted on a panel or door of the switchgear assembly. They function to detect a defective line or apparatus, as well as dangerous or undesirable system conditions. The relay energizes the trip coil of the circuit breaker to clear a fault. Page 5

Figure 4. Typical Medium Voltage Switchgear Assembly with Protective Relays and Other Devices Shown Mounted on Compartment Doors Trip Intelligence The protective relay intelligence devices fall into two broad categories. These are: Electromagnetic The electromagnetic protective relay has been used widely in the industry for many years, with a high degree of success. It functions to tell the circuit breaker when to operate, based on the specific relay type selected. Many different types of electromagnetic protective relays are available, and each type performs rather specific functions. Common relay types include: instantaneous overcurrent, time overcurrent and overvoltage. Because these devices are limited in scope, a number of different relays (each with different protective capabilities) must be used to provide a comprehensive protective package. Microprocessor-Based The microprocessor-based protective relay is a multi-function device. It can provide all the features of several electromagnetic relays in one box. It is also easier to mount and wire. Overall, it is a smaller investment than an electromagnetic protective relay solution. Figure 5. Typical Medium Voltage Switchgear Assembly with Microprocessor-Based Devices Shown Mounted In most cases, only one device is required for each three-phase circuit, not one device for each phase. One of the more sophisticated microprocessorbased protective relays is capable of replacing the normal complement of three or four electromagnetic relays, as well as a number of associated meters and switches (Figure 6). Page 6

Figure 6. Typical Sophisticated Microprocessor-Based Protective Relay Arc Extinguisher Arc Extinguishing Technologies Vacuum Interrupter Technology Because these are individual devices, apart from the medium voltage circuit breaker itself, there will be no further discussion of the tripping intelligence in this module. The Arc Extinguisher extinguishes the Arc produced when the contacts are pulled apart to interrupt current flow. The higher the voltage, the harder it is to interrupt the flow of current. There are a number of arc extinguishing technologies in use today. We will look at the most prominent types in the next section. In a low voltage circuit breaker, using air or Arc Chutes is sufficient to extinguish an arc. In the medium voltage range, a different technology needs to be used. The main technology used today is the Vacuum Interrupter. The vacuum interrupter (VI) was briefly discussed in Module 5, Fundamentals of Circuit Breakers. Figure 7. Schematic for a Typical Vacuum Interrupter Basically, the vacuum interrupter is a pair of separable contacts (called primary contacts ) enclosed in a vacuum-tight envelope. The Envelope itself is a ceramic material, with a metal end plate brazed to each end. The metal plates seal the ends and provide support for the parts inside. Of the two contacts (also called electrodes ) inside, one is fixed. The other is movable, through a bellows-type connection. Various shields inside the envelope provide different types of protection to interrupter parts. Page 7

Figure 8 depicts the important arcing and interruption phenomena within a vacuum. Figure 8. Interruption in a Vacuum When the circuit breaker is closed, the contacts within the interrupter touch, allowing current to flow. When a fault occurs and interruption is required, the contacts are quickly separated and an arc forms. An arc is formed because the voltage tries to keep the current moving. Figure 9. Enclosing Contacts in a Vacuum The arc burns in the metal vapor evaporated from hot spots on the contact surfaces. This metal vapor continuously leaves the contact region and recondenses on the contact surfaces and surrounding metal shield, which protects the ceramic envelope. At Current Zero, the arc extinguishes, contact vapor production stops, and the original vacuum condition is restored. Current zero is a point in the AC current sine wave where the value is zero. Figure 10. Current Zero Points in an AC Cycle The vacuum in the envelope is considered a Dielectric. The Dielectric Strength is the maximum voltage the dielectric can withstand without breaking down. The Transient Recovery Voltage (TRV) is the most severe waveform the interrupter will Page 8

have to withstand. This is why the speed of the dielectric recovery and the strength of the dielectric inside the interrupter are critical issues for successful circuit interruption. If the dielectric does not reach sufficient strength fast enough, the arc will re-ignite. Vacuum interrupters for circuit breaker duty must be capable of interrupting currents of 12 to 50 ka (and up), at voltages up to 38 kv (Figure 11). Figure 11. Rear View of Circuit Breaker with Vacuum Interrupters Installed (One Per Phase) Spiral Contacts A newer technology is now being used in the vacuum interrupter. It involves using spiral-shaped copper-chrome contacts inside the vacuum tube. They provide a self-induced magnetic effect that moves the arc root around the contact periphery. This very efficient arc control method prevents hot spots, minimizing contact erosion. Figure 12. Spiral Contacts SF 6 Gas Technology Another arc extinguishing technology is SF 6 (sulfur hexafluoride) technology. It is popular outside the United States. It is specifically associated with European manufacturers of medium and higher voltage circuit breakers. SF 6 technology was briefly discussed in Module 5, Fundamentals of Circuit Breakers. The main contacts are enclosed in a chamber of SF 6 gas, which happens to be a very good dielectric (Figure 13). Page 9

Figure 13. Enclosing Contacts in SF 6 Gas Puffer-Type SF 6 Gas Technology In short, this arc interruption technology results the in arc energy being used and absorbed, while the arc is simultaneously cooled. There are several SF 6 interrupter designs, but only two types will be covered here: Puffer Rotary Arc The puffer-type of SF 6 interrupter is the older of the two SF 6 technologies. It is more capable but more complicated than the rotary arc-type. The interrupter is shown below in the closed position, and in the opening sequence. Figure 14. Typical SF 6 Puffer Interrupter in Closed Position Figure 15. Typical SF 6 Puffer Interrupter During Opening Sequence High Current Arc on Left and Near Current Zero on Right Page 10

Rotary Arc-Type SF 6 Gas Technology During current interruption, a piston compresses the SF 6 gas in a cylinder, all of which is enclosed in an epoxy-type enclosure. After the main current-carrying contacts part, the current transfers to the arcing contacts. Once the arcing contacts part, the SF 6 gas in the compression chamber blasts the arc through the nozzle. The heat created by the arc breaks the SF 6 molecules into fluorine and sulfur. Arc energy is absorbed and the arc is cooled. As current zero is approached, the heat energy subsides as more SF 6 gas enters the system. At current zero, the high-pressure SF 6 gas flows through the nozzle and extinguishes the arc. Compressing the SF 6 gas requires significant mechanical energy. A circuit breaker equipped with this type of technology requires a higher-energy operating mechanism than is required by an equivalent vacuum circuit breaker. In addition, this interrupter type has a large number of parts. Rotary arc SF 6 technology is less complicated in design than the puffer type. It has fewer parts and does not require such a high-energy operating mechanism. However, it is not effective over as wide a range of short circuit currents and voltages as the SF 6 puffer or vacuum. Suitable applications are somewhat limited. Figure 16 shows a typical SF 6 rotary arc interrupter. Figure 16. Cross-Sectional View of Typical SF 6 Rotary Arc Interrupter As the contacts part, the arc transfers from the main contacts to an annular contact. This causes the current to switch into the coil behind it. The coil s magnetic field, produced by the load current itself, causes the arc to rotate rapidly. The arc is cooled by moving through the SF 6 gas. The SF 6 gas is normally at rest inside this interrupter. The arc s movement acts like a mixer, mixing hotter and cooler gas. This helps cool the arc. Contact erosion is also reduced due to this rapid arc movement. As current zero is approached, the dwindling arc must sustain enough speed to be lost in the SF 6 environment in order to withstand the transient recovery voltage. (This is mentioned because the magnetic field produced by the load current causes the all important arc rotation. As the current decreases, the magnetic field decreases, and the arc rotation slows.) At current zero, the arc is cooled and extinguished. Page 11

Review 1 Answer the following questions without referring to the material just presented. Begin the next section when you are confident that you understand what you ve already read. 1. The is the heart of the switchgear. 2. There are four main parts to a medium voltage power circuit breaker. These are: 3. A microprocessor-based trip intelligence is superior to an electromagneticbased trip intelligence. In your own words, explain why. 4. Vacuum interrupters for circuit breaker duty must be capable of interrupting currents of to ka (and up), at voltages up to kv. 5. SF 6 arc extinguishing technology is popular outside the United States. The two mostly commonly used types are and. Page 12

Ratings Ratings and Standards Vary Medium voltage power circuit breaker ratings vary in different parts of the world. As a matter of fact, medium voltage is not uniformly defined around the world. Although the standard we are using in this training module defines medium voltage as 1000 volts to 72.5 kv (a commonly accepted medium voltage range in the United States, as well as other parts of the world), one foreign country considers 1000 volts and above to be high voltage. Medium voltage power circuit breaker ratings charts specify many different types of ratings. Usually, a chart indicates the ratings required by the governing standards where the circuit breaker is applied. ANSI or IEC is normally the governing standard for medium voltage power circuit breakers. ANSI is associated with U.S. standards, and IEC is associated with international standards. However, neither the standards nor the ratings charts are identical. Charts also vary from manufacturer to manufacturer (Figures 17 and 18). To give an idea of the differences, consider the following example. Figure 17. Partial Sample of a Medium Voltage ANSI Ratings Chart Breaker Type Medium Voltage (ka rms) Continuous Current (Amps) Short Circuit Current (ka rms) 270VCP-W750 27 600 1200 2000 270VCP-W1000 27 600 1200 2000 270VCP-W1250 27 600 1200 2000 16 22 25 Figure 18. Partial Sample of a Medium Voltage IEC Ratings Chart Breaker Type Voltage Class (ka rms) Normal Current (Amps) Short Circuit Current (ka rms) 240VCP-W16 24 630 1250 2000 240VCP-W20 24 630 1250 2000 240VCP-W25 24 630 1250 2000 16 20 25 All of the indicated ratings are important. A number of them are merely calculations. For the sake of this discussion, we will cover only three of them. These are: Maximum Voltage Continuous Current Page 13

Short Circuit Current These three ratings are common to both ANSI- and IEC-rated circuit breakers. In most instances, a grasp of these three ratings will allow you to assist a customer with a medium voltage power circuit breaker selection. Maximum Voltage This is the maximum voltage at which the breaker can operate. It is termed Maximum Voltage on ANSI charts and Voltage Class on IEC charts. The operating voltage where the circuit breaker is applied should not exceed the circuit breaker s rated maximum voltage. Typical maximum voltage ratings encountered with ANSI applications are: 4.76, 8.25, 15, 27 and 38 kv. Typical voltage classes encountered with IEC applications are: 3.6, 7.2, 12, 17.5 and 24 kv. Continuous Current This is the amount of current the breaker can carry continuously at 60 cycles without exceeding the temperature rise limit. It is termed Continuous Current on ANSI charts and Normal Current on IEC charts. This maximum rating should always be in excess of the utilization equipment rating to provide for a short-time overload capability. Typical continuous current currents encountered with ANSI applications are: 600, 1200, 2000 and 3000 amps. Typical normal currents encountered with IEC applications are: 630, 1250 and 2000 amps. Short Circuit Current Enclosure and Mounting This is the level of three-phase short circuit current that the circuit breaker can safely interrupt. The Short Circuit Current is a rating at the circuit breaker s maximum voltage (ANSI) or voltage class (IEC). Typical short circuit currents encountered with ANSI applications are: 16, 29, 33, 37 and 63 ka. Typical short circuit currents encountered with IEC applications are: 16, 25, 31.5, and 40 ka. Enclosure The medium voltage power circuit breaker is always placed in a switchgear assembly. The switchgear assembly is usually referred to as a Metal-Enclosed Assembly. The phrase metal-clad means that compartments within the switchgear assembly are separated by metal barriers (Figure 19). Figure 19. Typical Medium Voltage Metal-Clad Assembly Structure with Two Vacuum Circuit Breakers (Side View) Page 14

This is different from a metal enclosed assembly, where the equipment is enclosed, but not necessarily separated by barriers. The metal enclosed assembly is typically associated with low voltage equipment. Figure 20. Typical Vacuum Switchgear Assembly with One Circuit Breaker in Upper Compartment and One Below with Door Closed Mounting Fixed Mount There are two methods for mounting a circuit breaker in the switchgear. These are: Fixed Mount Drawout Mount Fixed Mount circuit breakers are usually found in outdoor applications. When installed outdoors, a special type of housing must be provided to protect the equipment from the elements. This outdoor protection is provided in a number of ways. Fixed medium voltage power circuit breaker designs exist for a limited range of applications and voltages. Page 15

In the Workplace This outdoor substation utilizes fixed medium voltage power circuit breakers to perform a series of capacitor switching functions. Fixed Medium Voltage Power Circuit Breaker Installed in Outdoor Enclosure Each breaker must be housed in a weatherproof enclosure to protect it from the elements. Drawout Mount The Drawout Mount (or removable) type is by far the most common medium voltage power circuit breaker in use. It is used almost exclusively through 38 kv. Prior to the introduction of vacuum designs, medium voltage power circuit breakers were much larger (Figure 21). For example, one vertical structure could accommodate one Magnetic Air Type Circuit Breaker. The circuit breaker was removable, typically rolled out of the structure on wheels. Figure 21. Typical Medium Voltage Magnetic Air Circuit Breaker (Front Barrier Removed) Today, medium voltage power circuit breakers are frequently small enough to be stacked two units high in one vertical compartment. The circuit breaker has three positions: DISCONNECT, TEST and CONNECT. Normally, the circuit breaker is manually pushed to the TEST position, then mechanically levered between the TEST and CONNECT positions (Figure 22). Page 16

The secondary and primary electrical connections are automatically connected or disconnected as the circuit breaker is levered from one position to another. Figure 22. Medium Voltage Vacuum Circuit Breaker Being Mechanically Levered Into Its Structure Most drawout medium voltage power circuit breakers can be completely removed from their compartments onto integral extension rails (Figure 23). This feature makes the task of inspecting the circuit breaker and the compartment much simpler. Figure 23. Medium Voltage Vacuum Circuit Breaker Shown Removed From Compartment on Extension Rails If the circuit breaker must be lifted from the extension rails onto the floor, integral wheels permit it to be rolled around outside of its structure. Page 17

Standards The testing required and the standards that must be met by a medium voltage power circuit breaker depend on the area of the world where the circuit breaker is applied. A medium voltage power circuit breaker must meet the requirements of ANSI, IEC, IEEE and NEMA to be considered world-class (Figure 24). Figure 24. Dominant Worldwide Standards In addition, UL is an important consideration in certain local areas. Standards and testing to prove compliance are rather stringent. This is because of the voltage and current levels associated with medium voltage equipment under abnormal (and even normal) operating conditions. The testing goes beyond just testing the circuit breaker itself. Because a medium voltage power circuit breaker must function properly with a compatible housing, it is tested separately and in combination with the structural assembly. For this reason, most circuit breaker manufacturers are also switchgear assembly manufacturers. Page 18

Helping the Customer Circuit Breaker Details Configuration and Accessory Details Now you should be ready to assist a customer in matching a product to an application. When you meet with the customer, conduct a short interview to obtain information in these two areas: Circuit Breaker Details Configuration and Accessory Details Before you can select a specific circuit breaker, get the following information from the customer: Which set of standards (ANSI or IEC) apply to the circuit breaker? What maximum voltage (ANSI) or voltage class (IEC) is required? What continuous current (ANSI) or normal current (IEC) is required? What short circuit current is required? This information alone should be enough to allow you to select an appropriate circuit breaker. However, the more information you have, the better. It is also important to know how the circuit breaker is to be configured. Ask the customer these three questions: Will the circuit breaker be drawout or fix mounted? Will the circuit breaker be used indoors or outdoors? Will circuit breakers be stacked two to a vertical structure, or mounted one per structure? Medium voltage circuit breakers do not normally have a large number of accessory items. However, you should make yourself aware of anything additional the customer expects. Page 19

Review 2 Answer the following questions without referring to the material just presented. 1. For each rating type, identify it as being ANSI, IEC, or both. Normal Current Short Circuit Current Maximum Voltage 2. In your own words, explain the difference between a metal-clad assembly and a metal enclosed assembly. 3. There are two methods for mounting a circuit breaker in the switchgear. These are: 4. A medium voltage power circuit breaker must meet the requirements of,, and in order to be considered world-class. 5. There are seven main questions to ask a customer when attempting to match a product to an application. Name three of them. Page 20

Glossary ANSI Arc Arc Chute Arc Extinguisher Circuit Breaker Continuous Current Current Transformer Current Zero Dielectric Dielectric Strength Drawout Mount Envelope Fixed Mount Frame IEC IEEE Magnetic Air Type Circuit Breaker American National Standards Institute. It was organized to simplify and standardize production and construction. The effect generated when current is forced to be interrupted between two contacts. A component of the arc extinguisher in a low voltage circuit breaker. It elongates and cools an arc. A component of a circuit breaker. It actually interrupts the flow of current. A reusable overcurrent protection device. After tripping to break the circuit, it can be reset to protect the circuit again. The amount of current the breaker can carry continuously at 60 cycles without exceeding the temperature rise limit, according to ANSI charts. A step-down transformer that steps down supplied current to a current usable by control components such as relays and meters. Also Zero Point. A point in the AC current sine wave where the value is zero. The insulating medium between two contacts. Typical dielectrics are air, gas, ceramic or gas and ceramic. A vacuum is the only perfect dielectric. The maximum voltage a dielectric can withstand without breaking down. A mounting type for medium voltage power circuit breakers in which the breaker can be completely removed from its compartment onto integral extension rails. Main component of a vacuum interrupter. A sealed, evacuated ceramic enclosure, with a metal end plate brazed to each end. A mounting type for medium voltage power circuit breakers in which the breakers are fixed in place. Usually found in outdoor applications. A component of a medium voltage power circuit breaker. Its primary function is to provide a rigid, mechanically strong, insulated housing in which the other components are mounted. Abbreviation for International Electro-technical Commission. This organization is associated with equipment used internationally. Institute of Electrical and Electronic Engineers. A professional organization of scientists and engineers whose purpose is the advancement of engineering. A type of medium voltage power circuit breaker no longer in common use. Page 21

Maximum Voltage The highest voltage at which the breaker can operate, according to ANSI charts. The operating voltage where the circuit breaker is applied should not exceed the circuit breaker s rated maximum voltage. Medium Voltage A specific type of circuit breaker, used in a switchgear Power Circuit Breaker assembly, with a voltage range of 1000 volts to 38 kv. Metal-Clad Assembly Metal-Enclosed Assembly NEMA Normal Current Operating Mechanism Panelboard Protective Relay SF 6 Short Circuit Current Switchboard Switchgear Transient Recovery Voltage Trip Unit UL Equipment in the assembly is enclosed, and separated by metal barriers into individual compartments. Typically associated with medium voltage equipment. Equipment in the assembly is enclosed, but not necessarily separated by barriers. Typically associated with low voltage equipment. Abbreviation for National Electrical Manufacturers Association. An organization of manufacturers of electrical products. The amount of current the breaker can carry continuously at 60 cycles without exceeding the temperature rise limit, according to IEC charts. Opens and closes the contacts of a circuit breaker. A wall-mounted electrical power distribution device for use in commercial and industrial applications. It provides circuit control and overcurrent protection for light, heat or power circuits. The specific trip unit used with a medium voltage power circuit breaker. Functions to detect a defective line or apparatus, as well as dangerous or undesirable system conditions. An arc extinguishing technology involving the use of sulfur hexafluoride gas. A rating of the level of three-phase short circuit current that the circuit breaker can safely interrupt. The short circuit current is a rating at the circuit breaker s maximum voltage (ANSI) or voltage class (IEC). A floor-standing electrical power distribution device for use in commercial and industrial applications. It divides large blocks of electrical current into smaller blocks of current used by electrical equipment. An assembly of switching and interrupting devices, along with control, metering, protective and regulating equipment. The most severe waveform the vacuum interrupter will have to withstand. brain of a circuit breaker. Underwriters Laboratory. An independent laboratory that tests equipment to determine whether it meets certain safety standards when properly used. Page 22

Vacuum Interrupter Voltage Class An arc extinguishing technology. Features a pair of separable contacts enclosed in a vacuum-tight envelope. Because the environment inside the interrupter envelope is a vacuum, an arc cannot be sustained easily. The highest voltage at which the breaker can operate, according to IEC charts. The operating voltage where the circuit breaker is applied should not exceed the circuit breaker s rated voltage class. Page 23

Review 1 Answers 1. Circuit breaker Review 2 Answers 1. IEC Both ANSI Medium Voltage Power Circuit Breakers 2. Frame Operating Mechanism Trip Unit Arc Extinguisher 3. Answer should basically say: The microprocessor-based protective relay is a multi-function device. It can provide all the features of several electromagnetic relays in one box. It is also easier to mount and wire. Overall, it is a smaller investment than an electromagnetic protective relay solution. 4. 12, 50, 38 5. Puffer, Rotary Arc 2. Answer should basically say: A metal-clad assembly has internal compartments which are separated by metal barriers. A metal enclosed assembly does not necessarily have internal separation barriers 3. Fixed mount, Drawout mount 4. ANSI, IEC, IEEE and NEMA 5. Any three of the following: Which set of standards (ANSI or IEC) apply to the circuit breaker? What maximum voltage (ANSI) or voltage class (IEC) is required? What continuous current (ANSI) or normal current (IEC) is required? What short circuit current is required? Will the circuit breaker be drawout or fix mounted? Will the circuit breaker be used indoors or outdoors? Will circuit breakers be stacked two to a vertical structure, or mounted one per structure? Page 24