DESCRIPTION PARTS IDENTIFICATION GUIDE INDEX ID. PAGE NO. DESCRIPTION PAGE NO. DECK - OVERHEAD VIEW (includes the following) Aft Side Rails Anchor Lid & Hardware Bow Light Bow Rails Fuel Fill Horn & Grill Motor Box Rails Ski Tow & Stern Rails Stern Light Swim Platform Lids & Hardware W/S Brace Windshield & Gate Strap HULL & DECK EXTERIOR (includes the following) Bow & Stern Eyes Bow Chafe Option Cleats Docking Lights Option Drain Plug Ladder Rubrail & Insert Swim Platform Option Thru-Hulls Transom Stereo Remote Option Transom Trim Panel Option Vents & Covers GRAPHICS (includes the following) Chaparral Lettering & Bird Extended Hull Decal Hull Flares Hull Stripes JD Power 5 Yr Warranty Model Designator Protected Design Decal Sport Flare DASH / HELM (includes the following) Battery Switch Panel Compass Option Console & Dash Kit Cupholder Depth Finder Option Fire Extinguisher Box Fire Extinguisher Light Instument Panels Port Console, Tub, Glovebox, & Power Plug Shifters & Engine Components Starboard Console Access Door Steering Cable Steering Wheel & Helm Stereo & Components Walk Thru Door & Hardware 8 9 0,4,5 6,8 7,9
DESCRIPTION PARTS IDENTIFICATION GUIDE INDEX ID. PAGE NO. DESCRIPTION PAGE NO. COCKPIT (includes the following) Bow Cushion Hinges Cockpit SSI Designators Cockpit Table, Components & Storage Courtesy Lights Cup Holders Filler Cushion Option Fire Port Grab Handles Igloo Cooler, Tub & Retainers Motor Box & Components Pedestals Radio Box Retainer Ski Lid, Hardware & Mat Speaker Back Cover Transom Door, Stops & Jams DECK - UNDERSIDE VIEW (includes the following) Aft Liner Drain Blower Hoses Bow Cooler Drain Cup Holder Tub Fiberglass Footrests Port Dash Ice Chest Hose Ski Storage Drain Stern Ice Chest Drains ENGINE WELL / HULL INTERIOR (includes the following) Battery Cables & Boots Battery Tray Bilge Blower Bilge Pump Bushing Ski Storage Fire Extinguisher Fire Extinguisher Option Float Switch Fuel Shut-Off Option Fuel Tanks & Components Quick & Quiet Thru-Hull Exhaust Option Screw Jack (Deck Support) Storage Tub 0,, 4 5 6 7
DESCRIPTION PARTS IDENTIFICATION GUIDE INDEX ID. PAGE NO. DESCRIPTION PAGE NO. CANVAS (includes the following) Canvas Bimini Tops & Boots Canvas Bow Covers Canvas Cockpit Covers Canvas Mooring Cover Canvas Packages Canvas Travel Cover Canvas Windscreens INTERIOR (includes the following) Aft Cushions & Skins Bow Wraps, Cushions & Skins Bucket Seats & Skins Glove Box Carpet Motor Box Backrests, Cushions & Skins Optional Bow Filler Cushion & Skin Optional Snap-In Carpet Starboard Rear Side Panel & Skin Stern Backrests, Cushions, & Skins Stern Table Top Filler Cushion & Skin SIDE PANELS (includes the following) Port Arm Rest & Skin Port & Starboard Side Panels & Skins Starboard Shifter Panel & Skin BULKHEADS (includes the following) Bow Bulkheads & Skins Motor Box & Motor Room Bulkheads & Skins Port & Starboard Dash Bulkheads & Skins CARPET BOARDS (includes the following) Gas Tank Cover Board & Skin Port Engine Boards & Skins Port Storage Board & Skin N/A 9 0 4 5 6 7
Deck - Overhead View 5 4 6 4 5 5 6 0 9 8 7
Deck - Overhead View Item No. Part Number Description Qty. U.O.M. 80P COMBO BOW LIGHT W/ PLUG EA M-6-8 LATCH/FLUSH SS (5000 MIN) EA 570 90/00/0SSI BOW RAIL PR 4 00475 STB. FRONT ANODIZED SMALL (Windshield) EA 5 5 AFT SIDE RAIL EA 6 046-SPL-00-P SLIDE COVER LIGHT BASE EA 6a 6SPL00 0DEG 66IN POLELIGHT(50) EA 7 4490-00 STBD. STERN LID EA 8 66448-.5 INCH FLUSH SKI TOW EA 8a U740-0 DANGER USING SKI EYE EA 9 5 AFT MOTOR BOX RAIL EA 0 4490-00 PORT STERN LID EA 540-SPL-004 GAS FILL/VENT(5) EA a U808-0 SYMBOL FUEL CE LABEL (CE Pkgs) EA 00476 PORT FRONT ANODIZED SMALL (Windshield) EA INT-STR8S 8 INCH STRAP W/ SNAP EA 4 44900-0 SMALL ANCHOR LID EA 4a 568 WASHER (CLEAR) EA 4b 00500 ANCHOR RETAINER BRACKET EA 4c 7090 SLIDING WINDOW LOCK-SS EA 4d CHAP-0 8 LB. SAND ANCHOR (Option: Anchor) EA 4e U770-0 DANGE ANCHOR MAY MOVE EA 5 6644- HINGE STRAP 4 INCH - 94 EA 6 00479 DOOR 6/ (Windshield) EA 6a R-96 90/00 W/S BRACE(00) SET 6b U778-0 NOTICE SECURE WINDSHIELD EA Parts Not Pictured Which Are Associated With Deck Overhead: Not Pictured 079 DROP IN HORN EA Not Pictured 4 SS HORN GRILL EA Not Pictured 90 WHITE SCREW MOUNT GRILL EA NOTE: Numbers with letter designations represent parts included with primary numbered part for which there is no photo representation.
PARTS IDENTIFICATION GUIDE Go Back Hull / Deck Exterior 6 4 7 5 8 9 4 0 9 7 9 7 6 8 5 4 0 7 7 8 4 8 6 5 9 0 9
Hull / Deck Exterior Item No. Part Number Description Qty. U.O.M. 66009-6 INCH CLEAT-HOLLOW BASE (Standard) 6 EA 6656-6 IN FLUSH CLEAT-STUD MT. (Option: Premium Pkg) 6 EA STA46H SS INSERT /4 X 4 EA 4 048RB969-0Z WHITE RUBRAIL 0FT EA 5 STA75I47.75 /4 X 47 /4 SS RUBRAIL EA 6 067A VENT PORT EA 7 048RB969-05Z 6FT. WHITE RUBRAIL EA 8-6/ SWIM PLATFORM (Option: Swim Platform) EA 8a U595-0 SWIM PLATFORM LABEL (Option: Swim Platform) EA 8b 5768A TRIM LIMIT SPACER (Option: Swim Platform Mercury Engines) EA 8c 850887 TRIM LIMIT KIT (Option: Swim Platform Volvo Engines) 0.5 EA 9 B-048 SMALL SS RUBRAIL END CAP (Option: Swim Platform) PR 0 700 /4 SS SHORT THRU HULL (Port Stern Ice Chest Drain) EA 700 /4 SS SHORT THRU HULL (Port Dash Ice Chest Drain) EA 585- SS DOCKING LIGHT W/PLUG (Option: Premium Pkg) SET 6/0BC 6/0 BOW CHAFE (Option: Premium Pkg) EA 4 BOWSW00 / X 7/6 BOW EYE EA 4a ALHSWXX.5X5 ANCHOR LINE HANGER EA 5 700 /4 SS SHORT THRU HULL (Bow Ice Chest) EA 6 700 /4 SS SHORT THRU HULL (Bilge Drain) EA 7 7006 / SS SHORT THRU HULL (Option: CE Manual Bilge Pump) EA 8 700 /4 SS SHORT THRU HULL (Stbd Stern Ice Chest) EA 9 067B VENT STBD EA 9a VHF-WS IN. SAND FLANGE 4 EA 0 JBLREM5W JBL WHITE REMOTE (Option: Premium Pkg) EA 0a 0-097-H 5FT.STERO REMOTE HARNESS (Option: Premium Pkg) EA 0b 0-07-C Y-REMOTE HARNESS(Option: Premium Pkg) EA -0478-P SE TRANSOM TRIM PANEL(Option: Conv Pkg) EA H-8 6IN. GRABRAIL(00) (Option: Swim Platform) EA 640.8 X.8 FM HINGE (Option: Swim Platform) EA 4 TDL-XP STEP LADDER W/HAND GRIP EA 4a U77-0 DANGER USING BOARDING EA 5 048RB969-04Z 4 FT. WHITE RUBRAIL (Option: Swim Platform) EA 5a STA75I SS INSERT /4 x IN (Option: Swim Platform) EA 6 M-6-8 LATCH/FLUSH SS(5000 MIN) (Option: Swim Platform) EA 7 STESW005 / X STERN EYE EA 8 IST5800 SWIM PLATFORM LID (Option: Swim Platform) EA 8a IST4059 OPT LATCH LOCK FOR SWIM (Option: Swim Platform) EA 9 PS-0 /4 PLATFORM BRACE(50) (Option: Swim Platform) EA 0 74--PLB DRAIN PLUG(50) EA 0a 0-0444-H TRANSOM DRAIN WIRE (Part of Panel Kit) EA Parts Not Pictured Which Are Associated With Hull / Deck Exterior: Not Pictured U685-0 WINTERIZED LABEL EA NOTE: Numbers with letter designations represent parts included with primary numbered part for which there is no photo representation.
Graphics 6 7 8 4 7 7 7 8 4 5 6
Graphics Item No. Part Number Description Qty. U.O.M. U564-0 00 DESIGNATOR EA QMI-50 LARGE CHROME DESIGNATOR EA QMI-504 CHAPARRAL CHROME BIRD EA 4 QMI-50 CHAPARRAL CHROME LETTERS EA 5 U656-0 EXTENDED V-HULL DECAL EA 6 U7649-0 000 PROTECTED DESIGN EA Not Pictured 57-00 5YR WARRANTY JD POWER EA BLUE / WHITE BOATS W/ CHAMPAGNE INTERIOR 7 U68-05 GOLD /4" HULL STRIPE 50 FT 8 U6794-07 SM. SSI HULL FLARE BL/GLD SET BLUE / WHITE BOATS W/ PLATINUM INTERIOR 7 U68-0 PEWTER /4" HULL STRIPE 50 FT 8 U6794-04 SSI SM. BLUE HULL FLARE SET BLACK / WHITE BOATS W/ CHAMPAGNE INTERIOR 7 U68-05 GOLD /4" HULL STRIPE 50 FT 8 U6794-0 SSI SM. HULL GOLD/MAGN. SET BLACK / WHITE BOATS W/ PLATINUM INTERIOR 7 U68-0 PEWTER /4" HULL STRIPE 50 FT 8 U6794-0 SSI SM HULL BLACK/PEWTER SET BURGUNDY / WHITE BOATS W/ CHAMPAGNE INTERIOR 7 U68-05 GOLD /4" HULL STRIPE 50 FT 8 U6794-09 SM SSI HULL FLARE BG/GLD SET BURGUNDY / WHITE BOATS W/ PLATINUM INTERIOR 7 U68-0 PEWTER /4" HULL STRIPE 50 FT 8 U6794-0 SM SSI HULL FLARE BG/PTR SET YELLOW / WHITE BOATS W/ CHAMPAGNE INTERIOR 7 U68-05 GOLD /4" HULL STRIPE 50 FT 8 U6794-08 SM SSI HULL FLARE YEL/GLD SET YELLOW / WHITE BOATS W/ PLATINUM INTERIOR 7 U68-0 PEWTER /4" HULL STRIPE 50 FT 8 U6794-06 SSI SM. YELLOW HULL FLARE SET WHITE / WHITE BOATS W/ CHAMPAGNE INTERIOR 7 U68-05 GOLD /4" HULL STRIPE 50 FT 8 U6794-0 SSI SM. HULL GOLD/MAGN. SET WHITE / WHITE BOATS W/ PLATINUM INTERIOR 7 U68-0 PEWTER /4" HULL STRIPE 50 FT 8 U6794-0 SSI SM HULL BLACK/PEWTER SET NOTE: Numbers with letter designations represent parts included with primary numbered part for which there is no photo representation.
Graphics 6 7 8 4 7 7 7 8 4 5 6
Graphics WIDE BAND GEL BLUE / CHAMPAGNE INTERIOR Not Pictured U9088-0 " GOLD HULL STRIPE 50 FT WIDE BAND GEL BLUE / PLATINUM INTERIOR Not Pictured U9088-0 " SILVER HULL STRIPE' 50 FT WIDE BAND GEL BLACK / CHAMPAGNE INTERIOR Not Pictured U9088-0 " GOLD HULL STRIPE 50 FT WIDE BAND GEL BLACK / PLATINUM INTERIOR Not Pictured U9088-0 " SILVER HULL STRIPE' 50 FT WIDE BAND GEL BURGUNDY / CHAMPAGNE INTERIOR Not Pictured U9088-0 " GOLD HULL STRIPE 50 FT WIDE BAND GEL BURGUNDY / PLATINUM INTERIOR Not Pictured U9088-0 " SILVER HULL STRIPE' 50 FT WIDE BAND GEL YELLOW / CHAMPAGNE INTERIOR Not Pictured U9088-0 " GOLD HULL STRIPE 50 FT WIDE BAND GEL YELLOW / PLATINUM INTERIOR Not Pictured U9088-0 " SILVER HULL STRIPE' 50 FT WIDE BAND GEL W/ SPORT GRAPHICS WHITE / CHAMPAGNE INTERIOR Not Pictured U9998-0 SM SSI SPORT FLARE GOLD SET Not Pictured U9088-0 " GOLD HULL STRIPE 50 FT WIDE BAND GEL W/ SPORT GRAPHICS WHITE / PLATINUM INTERIOR Not Pictured U9998-0 SM SSI SPORT FLARE/SILVER SET Not Pictured U9088-0 " SILVER HULL STRIPE' 50 FT NOTE: Numbers with letter designations represent parts included with primary numbered part for which there is no photo representation.
Dash / Helm PORT & STARBOARD 4 7 8 9 0 5 6 6 7 8 5 9 0 4 6 4 4 40 4 5 6 9 7 8 6 5 4 9 0 8 7
Dash / Helm PORT & STARBOARD Item No. Part Number Description Qty. U.O.M. 48 PORT DASH ASSY-NO W/GRAIN (Champagne Interior) EA a 4 MARBLE PORT DASH (Platinum Interior) EA MP5056 GLOVE BOX LOCK & KEY BLK. EA a 00 DURACON CATCH BLACK FW500 EA U570-0 GLOVE BOX DECAL EA 4 76 DOOR KEEPER POWDER COATED EA 5 SSL-70 SHUTTER BAR LATCH EA 6 IST78 0SSI WALK THRU DOOR EA 7 00-0009 STEREO FACEPLATE/ALUMINUM (Part of Panel Kit) EA 7a 696 TACH GAUGE/LCD Hr W/ DELAY, W/ LOGO (Part of Panel Kit) EA 7b 697 SPEEDO GAUGE, 65 MPH, W/LOGO (Part of Panel Kit) EA 7c 654 FUEL GAUGE (Part of Panel Kit) EA 7d 65 VOLTMETER GAUGE (Part of Panel Kit) EA 7e 65 OIL PRESSURE GAUGE (Part of Panel Kit) EA 7f 65 WATER TEMP. GAUGE (Part of Panel Kit) EA 7g 650 TRIM GAUGE (Part of Panel Kit) EA 8 MR-6 JBL STEREO/CD PLAYER EA 8a SEA-ANT AM/FM ANTENNA EA 8b SEA-STRAP 8 IN. SUPPORT STRAP EA 9 700-VRCOEM V DELUXE POWER PLUG (Part Of Panel Kit) EA 0 IST8 SSI GLOVE BOX INSERT EA CB6.LANYARD SSI GLOVE BOX LANYARD EA CB500.FA.5 X 0. CLEAR HINGE EA PP-8 PUSH PLUG - VINYL EA a 4-040 /4 IN. MULTIFLEX FT 4 APD-90F 90 DEG. WHITE FLAT DRAIN EA 5 CB50400-FA.5 X.4 HINGE EA 6 DS-CHTNSBT D.S. CUPHOLDER TAN (Champagne Interior) EA 6a DS-CHLGYSBT LT. GRAY DBL. DRINK CUP (Platinum Interior) EA 6b 50-080 /8 IN CLEAR PVC TUBING FT 7 74-6 IN. DOOR STICK W/ RADIUS EA 8 44 MARBLE STARBOARD DASH (Platinum Interior) EA 8a 47 STARBOARD DASH (Champagne Interior) EA 9 F-50-C COMPASS WITH PLUG (Option: Conv Pkg) EA 0 05-0005-00-A DASH ASSEMBLY CHAMP.TAUPE (Champagne Interior) EA 0a 05-0005-00-A DASH ASSEMBLY PLAT. GRAY (Platinum Interior) EA 0b 09-0008-B 0SSI PANEL KIT EA 0c 0-00-A ENGINE HARNESS (Part of Panel Kit) EA 0d 05-007-A BATTERY SWITCH PANEL ( Part of Panel Kit) EA 440-86860 CHROME BEZEL HOLE PLUG EA DSO DEPTH SOUNDER (Option: Conv Pkg) EA a SN00 THRU HULL TRANSDUCER (Option: Conv Pkg) EA b HN07 7' TRANSDUCER HRNS (Option: Conv Pkg) EA c IS009 DEPTH SOUNDER INSTRUCTION (Option: Conv Pkg) EA 47 LIGHT (Option: Fire Extinguisher) EA 4 U579-0 STEERING WHEEL DOME EA 5 JBLREM5B JBL BLK REMOTE EA 6 498000 FIRE EXTINGUISHER BOX EA 6a IST404 STORAGE BOX CLEAT EA 7 45604 0SSI/WTT CAPACITY PLATE EA 8 U77-0 CO/OPERATOR/BOATMAN COMBO EA 9 MS455CB MODEL 4 WHEEL (Champagne Interior) EA 9a MS4557CB MODEL 4 GRAY STEERING (Platinum Interior) EA 9b SSC66 6 FT. STEERING CABLE EA 0 MS60767CB MAHOGANY STEERING WHEEL (Option: Mahog. Wheel & Conv Pkg) EA 0a 67055 STEERING WHEEL COVER (Option: Mahog. Wheel & Conv Pkg) EA 0b 4-000 STEERING WHEEL DOME.4" (Option: Mahog. Wheel & Conv Pkg) EA SB7484 90 DEGREE BEZEL EA
Dash / Helm PORT & STARBOARD 4 7 8 9 0 5 6 6 7 8 5 9 0 4 6 4 4 40 4 5 6 9 7 8 6 5 4 9 0 8 7
Dash / Helm PORT & STARBOARD Item No. Part Number Description Qty. U.O.M. SH95 QUICK CONNECT TILT HELM (Option: Conv Pkg) EA 05-008-A 0SSI BREAKER PANEL TAUPE (Champagne Interior) KIT a 05-009-A 0SSI BREAKER PANEL GRAY (Platinum Interior) EA b 790-0080007 GROUND STRIP COVER (Part Of Panel Kit) EA c 0-0444-H TRANSOM DRAIN WIRE (Part Of Panel Kit) EA 4 05-005-A SSI PORT SWITCH PANEL (Part of Panel Kit) EA 4a 05-006-A SSI STBD SWITCH PANEL(Part of Panel Kit) EA 4b 0-005-A 0SSI DISTRIBUTION HRNS (Part of Panel Kit) EA 5 M-4-8 LATCH/LOCK SS (5000 MIN) EA 6 0500 STBD ACCESS DOOR X.75 EA 7 SH950 SPLINE TILT MECHANISM (Option: Tilt Wheel & Conv Pkg) EA 8 SH5084 HELM-NON TILT W/ SPLINE EA 9 00WX/4 WHITE TEXTURE TRIM 6.67 FT 40 U767-0 WARNING OPEN DOORS MAY EA 4 88709A0 GENII SIDE MOUNT SHIFTER (Mercruiser Engines Only) EA 4a 5-0400 4MM PITOT TUBING (Mercruiser Engines Only) 0 FT 4b 54K8 SPRING HOSE CLAMP /4 IN (Mercruiser Engines Only) EA 4c 6708-5 #8 HOSE CLAMP (7/6 - ) (Mercruiser Engines Only) EA 4d -00 / FLAME RETARDANT SPLIT CONDUIT (Mercruiser Engines Only) 6 FT 4e -00 / FLAME RETARDANT SPLIT CONDUIT (Mercruiser Engines Only) 9 FT 4f CC6794 4 FT MERC CONTROL CABLE (Mercruiser Engines Only - Shifter) EA 4g CC6795 5 FT MERC CONTROL CABLE (Mercruiser Engines Only - Throttle) EA 4h 5768A TRIM LIMIT SPACER (Mercruiser Engines w/swim Platform) EA 4i 87659A CONTROL TRIM HARNESS (Mercruiser Engines Only) EA 4 858878 CONTROL W/SHUTDOWN SWITCH (Volvo Engines Only) EA 4a CC66 6 FT CONTROL CABLE (Volvo Engines Only - Shifter) EA 4b CC65 5 FT CONTROL CABLE (Volvo Engines Only - Throttle) EA 4c 687 SPEEDO KIT W/OUT HOSE (Volvo Engines Only) EA 4d 5-0400 4MM PITOT TUBING (Volvo Engines Only) FT 4e 54K8 SPRING HOSE CLAMP /4 IN (Volvo Engines Only) EA 4f 40-840 MIDGET VENT / X /4 (Volvo Engines Only) EA 4g 6B04 /4 FORGED BRASS ST ELBOW (Volvo Engines Only) EA 4h TI-T-DO-50 /4 INCH CLAMP (Volvo Engines Only) EA 4i 94-B BLACK CAP LG.045 x.465 (Volvo Engines Only) EA 4j -00 / FLAME RETARDANT SPLIT CONDUIT (Volvo Engines Only) 5 FT 4k IST064 VOLVO MOTOR SHIM (Volvo Engines Only) EA 4l 850887 TRIM LIMIT KIT (Volvo Engines w/ Swim Platform) 0.5 EA 4m U78-0 CAULK BEFORE INSTALLING (Volvo Engines Only) EA Parts Not Pictured Which Are Associated With Dash / Helm Not Pictured U780-0 SAFETY ORANGE SYMBOL CE (CE Pkgs) EA Not Pictured CAN0SSI CONFORMITY PLATE (Canadian Boats) EA Not Pictured CH-660 0SSI METAL CE PLATE (CE Pkgs) EA NOTE: Numbers with letter designations represent parts included with primary numbered part for which there is no photo representation.
Cockpit 5 6 4 7 8 STARBOARD COCKPIT 9 0 4 9 0 PORT COCKPIT
Cockpit Item No. Part Number Description Qty. U.O.M. MS-60BW JBL SPEAKERS 4 EA a 5700 SPEAKER BACK COVER (Igloo Cooler Tub) EA DS-CHSDSBT D.S. CUPHOLDER SAND 5 EA H0-000 INCH BUTT HINGE 4 EA 4 066 IGLOO COOLER W/BACKER EA 5 I6776 5QT MARINE COOLER EA 6 CLML--MB SAND COURTESY LIGHT W/ EA 7 IST4 SIDE ENTRANCE DOOR CLEAT EA 8 IST406 IGLOO COOLER RETAINER EA 9 QMI-50 SMALL CHROME DESIGNATOR EA 0 U554-0 SSI DESIGNATOR EA 75907-0 86/60 7" PED EA -0000 BUCKET SEAT STB.CHAMPAGNE (Champagne Interior) EA a -0000 BUCKET SEAT STB. PLATINUM (Platinum Interior) EA -00004 BUCKET SEAT PT. CHAMPAGNE (Champagne Interior) EA a -0000 BUCKET SEAT PT. PLATINUM (Platinum Interior) EA b 75058 BASE MOUNTING RINGS PR 4 46 CONTOUR GRAB HANDLE-PEARL (Champagne Interior) EA 4a 405 CONTOUR GRAB HANDLE-WHITE (Platinum Interior) EA Parts Not Pictured Which Are Associated With Cockpit: Not Pictured 008T 0SSI WTT OPT. TUBING KIT (Option: Bow Filler Cushion) EA Not Pictured IST489 OPT. FILLER CUSHION SUPPORT (Option: Bow Filler Cushion) EA Not Pictured IST407 OPT. HOLE ROD HOLDER (Option: Bow Filler Cushion) EA Not Pictured INT-STRS INCH STRAP W/SNAP (Option: Bow Filler Cushion) EA Not Pictured U767-0 WARNING OPEN DOORS MAY EA Not Pictured U78-0 IN CASE OF FIRE/SECURE EN EA Not Pictured IST4 SIDE ENTRANCE DOOR CLEAT EA NOTE: Numbers with letter designations represent parts included with primary numbered part for which there is no photo representation.
Cockpit 4 5 5 4 8 0 7 6 9 7 6 8 AFT STORAGE / ENGINE LID LOOKING STBD / AFT 6 9 0 5 4 PORT SIDE OF AFT ENTRANCE PORT AFT STORAGE
Cockpit Item No. Part Number Description Qty. U.O.M. -06 FIBERGLASS MOTOR BOX EA a SHCSSS/4C /4-0 x SOC HD C/S S/S (Leveler) EA b KNOB9RWT COVER(Leveler) EA c NJMSS/4C THIN NUT (Leveler) EA d BWFBB/4C T-NUT (Leveler) EA 5 5.5 SS GRAB RAIL EA -SPL-00 LATCH CLAMP(00/6MONTHS) EA 4 8-40 HOLE PLUG EA 4a 7575-40 FLOOR BASE EA 5 40- X FLUSH MOUNT HINGE EA 6 845 IN. HATCH LIFT PIN EA 7 0FH85 0 SKI LOCKER LID EA 7a 0905-00 FLEXIBLE PVC ROD HOLDER EA 8 CB004-09SS X X 4 HINGE EA 9 DP40-B 4 IN. BLK. PLATE (00BX) EA 0 4-04 ANGLE BRACKET X X /8 - IN 5 EA 4640400 SSI SPORT STORAGE TUB EA R-048 SCREW JACK (50) EA IST07 RADIO BOX RETAINER (Motor Lid Support) EA 4 SL9-70- 70LB GAS SHOCK EA 4a SL85- LARGE SHOCK CLIP MM 4 EA 5 R-06 SHOCK BRACKET W/MM(00) EA 5a R-58 SS SHOCK BRACKET W/ MM EA 6 SL50BP- 90 DEGREE BRACKET-BLACK EA 7 SL-40-40LB GAS SHOCK EA 8 SL40BP- FLAT BRACKET-BLACK EA 9 APD-90F 90 DEG. WHITE FLAT DRAIN (Ski Locker) EA 9a 4-040 /4 IN. MULTIFLEX FT 0 HRA7.5GR-80.5 GRAY HERONAIR 80.5 X 7.5 EA 6605- PAD EYE EA BCORD-4BW /4IN SHOCK CORD FT a FPH- SMALL HOOKS EA b INT-STRS INCH STRAP W/SNAP EA c SC-WTP-SR WHITE SEAT CLEATS 4 EA 4-058 0SSI COCKPIT TABLE EA a 7559-74 /4 LEGS EA b 7559-8 7 / LEGS EA 4 7554 TABLE BASE EA 5 IST468 DOOR JAM EA 5a IST69 0SSI TRANSOM DOOR EA 6 6860WW FIRE PORT (Standard) EA 6a DP40-8 4 INCH WHITE DECK PLATE (Option: CE Packages) EA NOTE: Numbers with letter designations represent parts included with primary numbered part for which there is no photo representation.
Deck - Underside View 4 5 6 PORT DASH AREA PORT AFT AREA 7 9 8 STARBOARD BOW AREA STARBOARD DASH AREA 4 STARBOARD AFT AREA 0 STARBOARD MIDSHIP AREA
Deck - Underside View Item No. Part Number Description Qty. U.O.M. 068 CUP HOLDER TUB EA 40-000 IN BLOWER/VENT HOSE-BLK @ 6 FT APD-90F 90 DEG. WHITE FLAT DRAIN (Stern Ice Chest) EA a PP-8 PUSH PLUG - VINYL EA 4 4-040 /4 IN. MULTIFLEX @. FT 5-04 FIBERGLASS PORT FOOTREST EA 6 4-040 /4 IN. MULTIFLEX (Port Dash Ice Chest) FT 7-05 FIBERGLASS STBD FOOTREST EA 8 APD-90F 90 DEG. WHITE FLAT DRAIN (Bow Cooler) EA 8a PP-8 PUSH PLUG - VINYL EA 9 4-040 /4 IN. MULTIFLEX.5 FT 0 APD-90F 90 DEG. WHITE FLAT DRAIN (Ski Storage) EA APD-90F 90 DEG. WHITE FLAT DRAIN (Aft Liner) EA a 4-040 /4 IN. MULTIFLEX FT NOTE: Numbers with letter designations represent parts included with primary numbered part for which there is no photo representation.
Engine Well / Hull Interior 9 8 7 6 5 PORT SIDE OF ENGINE WELL FLOOR LOOKING AFT 4 INSIDE STARBOARD SIDE OF ENGINE WELL 5 4 0 5 INSIDE ENGINE WELL FORWARD OF ENGINE 6 7 8 6 9 0 5 4
Engine Well / Hull Interior Item No. Part Number Description Qty. U.O.M. 7P " BLOWER W/ PACKARD PLUG EA 40-000 IN.BLOWER/VENT HOSE-BLK FT U7408-0 LEAKING FUEL DECAL EA 4 0-04-R 4IN POSITIVE BATT.CABLE (To On/Off Switch) EA 4a 8NV0 SINGLE BATT. BOOT RED EA 4b 458N0V0 DUAL BATT. BOOT RED EA 4c 8NV4 SINGLE BATT. BOOT BLACK EA 4d 458N0V4 DUAL BATT. BOOT BLACK EA 5 9090- BATTERY TRAY EA 5a 0-048-R 48IN POSITIVE BATT.CABLE EA 6 0-048-Y 48IN GROUND BATTERY CABLE EA 7 4640400 SSI SPORT STORAGE TUB EA 8 890 MERCURY 50 EXHAUST KIT W/CONNECTOR (Option: Qk & Qt Thru Hull 5.0 to 50mag) EA 8a 894 VOLVO 50 EXHAUST KIT W/CONNECTOR (Option: Qk & Qt Thru Hull 5.0 to 5.7) EA 9 R-048 SCREW JACK(50) EA 0 404PC V500 BILGE PUMP W/PLUG EA 40P FLOAT SWITCH W/O COVER EA 60-080 /8 IN. FUEL LINE TYPE A.8 FT a 470K5 FUEL TROL (Option: Int'l Fuel Shut Off) EA b DBN /4X/8 BRASS BARB HOSE (Option: Int'l Fuel Shut Off) EA c 6708-5 #8 HOSE CLAMP (7/6-) (Option: Int'l Fuel Shut Off) EA d 94-B BLK CAP LG..045 X.465 (Option: Int'l Fuel Shut Off) EA e 0-0-H 99-SS FUEL SHUTOFF HRNS. (Option: Int'l Fuel Shut Off) EA f 0-00085-A SS FUEL SWITCH (Option: Int'l Fuel Shut Off) EA -00 / FLAME RET.SPLIT COND. 5 FT 4 4-040 /4 IN. MULTIFLEX 7 FT 5 SN00 THRU HULL TRANSDUCER (Option: Conv Pkg) EA 5a HN07 7' TRANSDUCER HRNS (Option: Conv Pkg) EA 6 4-000 FIRE EXTINGUISHER BRACKET (Option: Fire Extinguisher) EA 6a 954DP DIAPHRAGM PUMP W/SS HAND. (Option: CE Pkgs) EA 6b 0905-00 FLEXIBLE PVC ROD HOLDER (Option: CE Pkgs) EA 6c 4-0 / IN MULTIFLEX-BLACK (Option: CE Pkgs).6 FT 6d 4-0 / IN MULTIFLEX-BLACK (Option: CE Pkgs) FT 6e 674-5 #4 HOSE CLAMP (-) (Option: CE Pkgs) 4 EA 6f NC40 /IN. ALUM. CUSH.CLAMP (Option: CE Pkgs) 4 EA 6g 94-B BLK CAP LG..045 X.465 (Option: CE Pkgs) 4 EA 7 CG-00-FM00 00CFM FM00 FIRE EXTING. (Option: Int'l Fire Extinguisher) EA 8 CG-00-FE4 EXTINGUISHER (Option: Fire Extinguisher) EA 9 50-0L /IN FUEL FILL HOSE 6.67 FT 0 60-0580 5/8 FUEL LINE TYPE A 7.5 FT SX00064AE09ND ALUM CHANNEL W/END PLATE EA 8-CHAPX0 /4 X INCH RUBBER.5 FT a 8-CHAPX0 /4 X INCH RUBBER 6.5 FT 50 BUSHING SKI STORAGE EA 4 0905-00 FLEXIBLE PVC ROD HOLDER EA 5 FT5607 56G FUEL TANK 0/0WTT EA 5a DBN /4X/8 BRASS BARB HOSE EA 5b 6B04 /4 FORGED BRASS ST ELBOW EA 5c E48-55-480 55 GAL. ALUM. FUEL TANK (Option: Int'l Alum Fuel Tank) EA 5d 8-CHAPX0 /4 X INCH RUBBER (Option: Int'l Alum Fuel Tank) 5 FT 6 05-007-A BATTERY SWITCH PANEL ( Part of Panel Kit) EA
Canvas Part Number Description Qty. U.O.M. 997 - - - - 0 BIMINI TOP & BOOT EA 896- - - - 6/0 WINDSCREEN EA 05 SHOCKCORD LACING KNOB WHITE 8 EA 99745007 TRAVEL COVER EA OPTION: CANVAS PACK 896 - - - - SIDE CURTAINS SET 896 - - - -06 TONNEAU COVER EA 997 - - - - 5 0 AFT CURTAIN EA OPTION: COCKPIT & BOW COVER 997 - - - - 5 COCKPIT COVER EA 896- - - - 06 TONNEAU COVER EA OPTION: COCKPIT COVER 997 - - - - 5 COCKPIT COVER EA OPTION: MOORING COVER 99748006 MOORING COVER EA Note: To identify canvas color selections place the width & color designations below into the spaces provided in the part numbers. 000 - Diklon Navy Blue 600 - Yellow 00 - Burgundy 6008 - Jet Black 000 - Beige
0 SSi INTERIOR 5 6 4 7 8 9 0 0 9 8 4 6 7 4 5
0 SSi INTERIOR Item No. Part Number Description Qty. U.O.M. 407INT Port Corner Bow Wrap ea a 407INT-S Port Corner Bow Wrap Skin ea 4076INT Port Rear Bow Cushion ea a 4076INT-S Port Rear Bow Cushion Skin ea 4075INT Port Bow Cushion ea a 4075INT-S Port Bow Cushion Skin ea 4 4070INT Port Side Bow Wrap ea 4a 4070INT-S Port Side Bow Wrap Skin ea 5 40709INT Center Bow Wrap ea 5a 40709INT-S Center Bow Wrap Skin ea 6 4074INT Center Bow Cushion ea 6a 4074INT-S Center Bow Cushion Skin ea 7 40708INT STB Side Bow Wrap ea 7a 40708INT-S STB Side Bow Wrap Skin ea 8 407INT STB Bow Cushion ea 8a 407INT-S STB Bow Cushion Skin ea 9 407INT STB Rear Bow Cushion ea 9a 407INT-S STB Rear Bow Cushion Skin ea 0 40707INT STB Corner Bow Wrap ea 0a 40707INT-S STB Corner Bow Wrap Skin ea -0000 Bucket Seat Port Platinum ea a -00004 Bucket Seat Port Champagne ea -0000 Bucket Seat STB. Platinum ea a -0000 Bucket Seat STB. Champagne ea 4070INT Port Stern Cushion ea a 4070INT-S Port Stern Cushion Skin ea 4 40700INT Port Stern Backrest ea 4a 40700INT-S Port Stern Backrest Skin ea 5 40699INT Motor Box Backrest ea 5a 40699INT-S Motor Box Backrest Skin ea 6 4070INT Motor Box Cushion ea 6a 4070INT-S Motor Box Cushion Skin ea 7 4070INT Motor Box Door Backrest ea 7a 4070INT-S Motor Box Door Backrest Skin ea 8 40704INT Motor Box Filler Cushion ea 8a 40704INT-S Motor Box Filler Cushion Skin ea 9 4069INT STB Rear Side Panel ea 0 4069INT-S STB Rear Side Panel Skin ea 0a 407SNC Optional Snap In Carpet ea 40705INT Stern Table Top Cushion ea a 40705INT-S Stern Table Top Cushion Skin ea 4077INT Optional Bow Filler Cushion ea a 4077INT-S Optional Bow Filler Cushion Skin ea 40706INT Bow Seating Assembly ea a 40706INT-S Bow Seating Assembly Skin ea 4 40698INT Stern Seating Assembly ea 4a 40698INT-S Stern Seating Assembly Skin ea not pictured 008T Optional Tubing Kit ea not pictured 40068SNC SSi Glove Box Carpet ea For part numbers with an "INT", "OPT" or "SNC" suffix, add "-90" extension for a CHAMPAGNE boat; "-90" for PLATINUM boat. NOTE: Numbers with letter designations represent parts included with primary numbered part for which there is no photo representation.
0 SSi SIDE PANELS 6 4 5
0 SSi SIDE PANELS Item No. Part Number Description Qty. O.U.M 40694INT Port Upper Side Panel ea a 40694INT-S Port Upper Side Panel Skin ea b U554-0 SSI Designator ea 40696INT Port Arm Rest ea a 40696INT-S Port Arm Rest Skin ea 40697INT Port Lower Side Panel ea a 40697INT-S Port Lower Side Panel Skin ea 4 4069INT STB Upper Side Panel ea 4a 4069INT-S STB Upper Side Panel Skin ea b U554-0 SSI Designator ea 5 4069MINT Starboard Shifter Panel (Mercury) ea 5a 4069MINT-S Starboard Shifter Panel (Mercury) Skin ea 5b 4069VINT Starboard Shifter Panel (Volvo) ea 5c 4069VINT-S Starboard Shifter Panel (Volvo) Skin ea 6 40695INT Port Side Panel Assembly ea 6a 40695INT-S Port Side Panel Assembly Skin ea For part numbers with an "INT", "OPT" or "SNC" suffix, add "-90" extension for a CHAMPAGNE boat; "-90" for PLATINUM boat. NOTE: Numbers with letter designations represent parts included with primary numbered part for which there is no photo representation.
0 SSi BULKHEADS 4 5 6 7 8 9 FOAM FOAM WOOD WOOD
0 SSi BULKHEADS Item No. Part Number Description Qty. U.O.M. 4070INT Motor Box Bulkhead ea a 4070INT-S Motor Box Bulkhead Skin ea 407INT Motor Room Close Out # ea a 407INT-S Motor Room Close Out # Skin ea 4078INT STB Dash Bulkhead ea a 4078INT-S STB Dash Bulkhead Skin ea 4 4079INT Port Dash Forward Bulkhead ea 4a 4079INT-S Port Dash Forward Bulkhead Skin ea 5 407INT Port Rear Bulkhead ea 5a 407INT-S Port Rear Bulkhead Skin ea 6 4078INT Port Bow Bulkhead ea 6a 4078INT-S Port Bow Bulkhead Skin ea 7 4079INT STB Bow Bulkhead ea 7a 4079INT-S STB Bow Bulkhead Skin ea 8 407INT Motor Room Close Out # ea 8a 407INT-S Motor Room Close Out # Skin ea 9 4074INT Motor Room Close Out # ea 9a 4074INT-S Motor Room Close Out # Skin ea For part numbers with an "INT", "OPT" or "SNC" suffix, add "-90" extension for a CHAMPAGNE boat; "-90" for PLATINUM boat. NOTE: Numbers with letter designations represent parts included with primary numbered part for which there is no photo representation.
0 SSi CARPET BOARDS 4
0 SSi CARPET BOARDS Item No. Part Number Description Qty. O.U.M 4075INT Port Storage Board ea a 4075INT-S Port Storage Board Skin ea 40740INT Gas Tank Cover Board ea a 40740INT-S Gas Tank Cover Board Skin ea 4077INT Port Engine Board # ea a 4077INT-S Port Engine Board # Skin ea 4 4076INT Port Engine Board # ea 4a 4076INT-S Port Engine Board # Skin ea For part numbers with an "INT", "OPT" or "SNC" suffix, add "-90" extension for a CHAMPAGNE boat; "-90" for PLATINUM boat. NOTE: Numbers with letter designations represent parts included with primary numbered part for which there is no photo representation.