This PI has been revised to add the Saturn VUE and update the Parts Information table and Warranty Information. Please discard PI0746D.

Similar documents
PRELIMINARY INFORMATION

Document ID: The following diagnosis might be helpful if the vehicle exhibits the symptoms described in this PI.

Document ID:

INFORMATION. Information on High Feature V6 Timing Chain Kits and Chain Guide Replacements, DTCs P0008, P0009, P0016, P0017, P0018 and/or P0019

Information on High Feature V6 Timing Chain Kits and Chain Guide Replacements, DTCs P0008, P0009, P0016, P0017, P0018 and/or P0019

11/3/2017 Timing Chain TSB Title: F 03/03/2015 Engine - Timing Chain Kits and Chain Guide Replacement

If this concern is encountered, follow the guidelines below to install the necessary timing chain service kit:

Upon investigation, the technician may find one or more of the following DTCs stored: 2015 General Motors. All rights reserved.

#PIP5038B: SES Light, Engine Misfire, and/or Shudder - Inspect Ignition Coils - (Jun 4, 2013)

# F: Engine Misfire/Tick Noise. Malfunction Indicator Lamp ( MIL) Illuminated with DTC P0300 Set - (Dec 12, 2017)

Groan, Squeak or Rubbing Type Noise When Turning Steering Wheel

1 of 13 2/10/2016 6:46 PM


POSSIBLE OIL CONSUMPTION - OIL LEAKS - BLUE SMOKE FROM THE EXHAUST - MIL - OR FUEL TRIM CODES

Document ID: General Motors Corporation. All rights reserved.

Subject: Engine Oil Consumption on High Feature V6 Engines - Air Cleaner Housing Test, Repair Procedure (Install Piston Rings, Service PCV System)

Document ID: This PI was superseded to change labor operation time from.4 to.5. Please discard PIP4307G.

This Bulletin has been revised to update Warranty Information. Please discard Corporate Bulletin Number L.

Chevrolet Avalanche, Silverado 1500, Suburban, Tahoe

Diagnosis and Repair - Malfunction Indicator Lamp (MIL) Illuminated, Reduced Engine Power Message Displayed, DTC P2135 Set

# : Revised Engine Cranks But Does Not Run Diagnostic - (Sep 26, 2003)

Document ID: The technician may observe on a scan tool DTC P0116 and/or P1400 set as Current or in History.

Possible Oil Consumption - Oil Leaks - Blue Smoke From The Exhaust - MIL - Or Fuel Trim Codes

14582 Special Coverage Adjustment Throttle Body Reduced Power Mode

BES Subject: Temporary reduction in power brake assist in extreme cold weather


1 of 12 12/28/2015 8:40 PM

Condition/Concern. Recommendation/Instructions. Bulletin No.: PIT5501A Date: Apr-2016

Document ID: LEA (2.4L), LFW (3.0L), LFX (3.6L) 2018 General Motors. All rights reserved.

Tech-Note. The following GM Service Bulletin pertains to possible intake manifold leaks affecting Saturn VUE 3.0L.

Engine Controls - Revised DTC 0090 Diagnostics

#PIP4949E: Duramax Diesel Hard Start No Start P0087 P0088 P0191 P128E Or Injection Pump Replacement - (Jun 8, 2015)

Condition. Correction

#14404A: SPECIAL COVERAGE ADJ... Document ID#

14329A - SPECIAL COVERAGE ADJUSTMENT - LOSS OF POWER STEERING ASSIST

#PI0462: Steering Wheel Adjustment (Tilt/Telescope) Lever Sticks, Binds - (May 9, 2011)

10134C Special Coverage Adjustment Catalytic Converter Warranty Extension

2007 Chevrolet Suburban C1500. Excessive Engine Oil Consumption (Verify Condition, Inspect Valve Stems, Replace Cylinder Heads if Necessary)

Rough Idle Crank No Start Extended Crank Or Misfire Due to Excessive Carbon On Top of the Valves or Sticking Valves

Repair content for 2005 GMC W4500 Forward

#PIP4158D: Low Oil Pump Pressure Due To Sticking Oil Pressure Relief Valve - (Jan 18, 2012)

ID: # H:

FuseMaster Application Information February 14, 2019

# P: Car and Truck Fix it Right the First Time Issues - (Apr 11, 2012)

#PI0356A: Water Leak Guidelines for Interior Odor/Musty Smell or Rear Seat Footwell Full of Water - (Jun 8, 2011)

# : SMU - Revised DTC P0341 Camshaft Position (CMP) Sensor Performance - (Feb 20, 2002)

This bulletin is being revised to update the Warranty information. Please discard Corporate Bulletin Number (Section Suspension).

#PI0412: No Crank/No Start, Dead Battery Due to Parasitic Drain/Discharge - (Jan 12, 2012)

Steering Feels Loose / Excessive Lash / Fluid Leak At Lash Adjuster (Adjust Steering Gear)

2006 Eclipse 3.8L V6 models produced between 6/13/05 6/22/05 (between VIN 6E VIN 6E005929)

Document ID: Some customers may comment that the service rear axle message is displayed on the driver information center (DIC).

#PI0646: Park Assist Blocked See Owners Manual Displayed in Driver Information Center (DIC) - (Jan 12, 2012)

Service Bulletin TECHNICAL

14404 Special Coverage Adjustment Transmission Clutch Wave Plate

Engine Oil Leak at Crankshaft Rear Main Oil Seal (Replace with Revised Crankshaft Rear Main Oil

60 Degree V6 Engine Oil Leak at Crankshaft Front Oil Seal (Use New Crankshaft Front Oil Seal Installer Tool EN-48869)

# : SMU - Revised DTC P0201-P (Sep 16, 2002)

#PIP4138R: SES Light, Misfire, DTC P0300, And/or A Chirp, Squeak, Squeal, Or Tick Noise - Potential - (Oct 15, 2018)

# Q: Car and Truck Fix it Right the First Time Issues - (May 15, 2012)

11/12/2017 # C: MIL Illuminated, DTCs P0442, P0446, P0455 or P0449 Set - Fuel Tank Hard to Fill - Moisture, Water, Corrosion at EVAP Can

Preliminary Information

#14515B: Product Safety - Chassis Electronic Control Module Internal Contamination - (Feb 2, 2015)

#PIT5509C: Diagnostic Tip - Check and/or Service Trailer Brake System message DTC C (Jun 6, 2017)

Document ID: Upon investigation the Technician may observe on a scan tool one or more of the following DTCs set:

Important: If valve body cleaning is not required, Do Not disassembly bores unless it is necessary to verify movement of valves.

11340C Special Coverage Adjustment Timing Chain Wear

Document ID# Cadillac CTS

Document ID: The following diagnosis might be helpful if the vehicle exhibits the symptom(s) described in this PI.

#PIT5272B: Diagnostic Tip: Whistle Noise from Inside Vehicle - (Nov 13, 2018)

Service Bulletin CL Warranty Extension: EGR Port Clogging. December 17, (Supersedes , dated October 26, 2001)

#PIT5438E: Click / Rattle / Tick / Pop / Creak / or Squeak Noise from Dash Area - (Oct 29, 2018)

Service Bulletin PRELIMINARY INFORMATION

# D: No Reverse, Second Gear or Fourth Gear (Replace Reaction Sun Shell with More Robust Heat Treated Parts) - (Jun 10, 2008)

OnStar Diagnostic Alerts Feature. Advanced Diagnostics Proactive Alert. Bulletin No.: PI1250E Date: 25-Apr-2016

DTC P0118 Engine Coolant Temperature (ECT) Sensor Circuit High Voltage

#97-T-20A: MIL (Service Engine Soon Telltale Lamp) On and EGR DTCs P0401, P0404, P0405, P1404 and/or P1406 in PCM Memory - (Jan 6, 2003)

DTC P1515 Control Module Throttle Actuator Position Performance

LA1, LNJ, LG8, LL1, LX9, L82, LL2, LB8, LHO, LG5, LB6, LE2, LQ1, LH7, LC1, L44, LZ4, LZE, LZ9, LGD, LZ8, LZG)

Diagnostic Tip - Check and/or Service Trailer Brake System message DTC C1114

#PIP4862A: Service Rear Axle Message Displayed DTC C0407 Sym64 - (Sep 21, 2011)

Document ID:

SPECIAL COVERAGE. SUBJECT: Special Coverage Adjustment Engine Balance Chain and Fuel Pump

2000 Buick Century Buick Riviera Buick Park Avenue Buick LeSabre Buick Regal Buick Century

#16-NA-102: Duramax Diesel Hard Start, No Start, DTCs P0087, P0088, P0191, P128E or Injection Pump Replacement - (Apr 14, 2016)

11/30/2017 # F: Engine Oil Leak at Crankshaft Rear Main Oil Seal (Install Revised Crankshaft Rear Main Oil Seal Using Revised Rear Main S

Equipped with Engine RPOs listed in the Table Below and MULTEC 2 Fuel Injectors

Some customers may comment that the Service 4WD light is on, the 4WD system is inoperative or the 4WD switch indicator lights are blinking.

GUIDE ID: GM VEHICLE COMPATIBILITY. Make Model Trim Years Firmware Diag

2010 Chevy Truck Suburban 2WD V8-5.3L

Repair content for 2005 GMC W4500 Forward

FOR HELP WITH USING witech FOR ECU FLASH REPROGRAMMING, CLICK ON THE APPLICATION S HELP TAB.

DTC P0135, P0141, P0155, or P0161 (w/lr4 and LM7 w/ Delphi HO2S)

ALLDATA Online Buick Lucerne V6-3.8L VIN 2 - Recall - Heated Windshield... Recall - Heated Windshield Washer Module Short Circuit

Preliminary Information

UNITED STATES DISTRICT COURT EASTERN DISTRICT OF MICHIGAN SOUTHERN DIVISION

# D: Information on Higher Than Expected Oil Consumption - (Nov 16, 2016)

SPECIAL COVERAGE. SUBJECT: Special Coverage Adjustment Plugged PCV Orifice in Intake Manifold

PQC Telephone Number. US Cars and Trucks

Intake Manifold Replacement

Coaxial Cable Repair Kit Now Available

Transcription:

Malfunction Indicator Lamp (MIL) On, Poor Acceleration, Throttle Body Freezing, Multiple DTCs Set, Ice Deposits and/or Oil Deposits Present in Air inlet Duct 2008-2011 Buick Enclave 2007-2011 Chevrolet Malibu 2009-2011 Chevrolet Traverse 2007-2011 GMC Acadia 2007-2010 Pontiac G6 2007-2009 Saturn AURA 2007-2010 Saturn OUTLOOK 2008 2010 Saturn VUE Equipped with 3.6L Engine (RPOs LY7, LLT) This PI has been revised to add the Saturn VUE and update the Parts Information table and Warranty Information. Please discard PI0746D. Condition/Concern Some customers may comment that the malfunction indicator lamp (MIL) is on. They may also comment on poor engine performance and/or reduced acceleration. The reduced engine power will be experienced after initial cold start up or driving in low ambient temperatures.

Technicians may find DTCs P0101, P0171, P0172, P0174, P0175, P1516, P2177, P2178, P2179, P2180, P2187, P2188, P2189 and/or P2190 along with either ice or oil deposits in the air inlet duct. Ice formation is caused by condensation freezing at the base of the throttle body with additional collection of ice formation deposits in the air inlet duct. Freezing condensation forms after the vehicle has been driven and then parked in low ambient temperatures. Oil deposits are the collection of the engine vapors, fuel dilution and oil mist at the base of the throttle body with additional formation collecting in the duct. Recommendation/Instructions (2007-2008 Enclave, Malibu, Traverse, Acadia, G6, AURA, OUTLOOK, VUE) 1. Remove both camshaft covers for servicing of the PCV system. Refer to Camshaft Cover Replacement Left and Right Side in SI. 3. Replace the bank1 camshaft cover gasket. 4. Reassemble the bank1 camshaft cover. the camshaft cover bolts to 10 Nm (89 lb in). 5. Replace the bank2 camshaft cover and replace the camshaft cover gasket.

6. Reassemble the bank2 camshaft cover. the camshaft cover bolts to 10 Nm (89 lb in). 7. Install new PCV foul air tube. Parts Information (2007-2008 Enclave, Malibu, Acadia, G6, AURA, OUTLOOK, VUE) 19301853 Tube, PCV (Enclave, Traverse, Acadia, OUTLOOK) 12616914 Tube, PCV (Malibu, G6, AURA, VUE) 12641261 Seal, CM/SHR CVR (RH) (LY7) For vehicles repaired under the 5 year/100,000 mile (160,000 km) Powertrain Coverage (Code P) warranty, use: 4080098* Labor Operation Tube/Covers/Seal (Enclave, Acadia, OUTLOOK) Labor Time 3.2 hrs Tube/Covers/Seal (Malibu, G6, AURA, VUE) *This is a unique Labor Operation for Bulletin use only. It will not be published in the Labor Time Guide. 2.3 hrs Recommendation/Instructions (2009-2010 Enclave, Malibu, Traverse, Acadia, G6, 2009 AURA, OUTLOOK, VUE) 1. Remove both camshaft covers for servicing of the PCV system. Refer to Camshaft Cover Replacement Left and Right Side in SI. 3. Replace the bank1 camshaft cover gasket. 4. Reassemble the bank1 camshaft cover.

the camshaft cover bolts to 10 Nm (89 lb in). 5. Replace the bank2 camshaft cover and replace the camshaft cover gasket. 6. Reassemble the bank2 camshaft cover. the camshaft cover bolts to 10 Nm (89 lb in). Parts Information (2009-2010 Enclave, Malibu, Traverse, Acadia, G6, 2009 AURA, OUTLOOK, VUE) 12647772 Cover, CM/SHF (LH) (LLT) 12641261 Seal, CM/SHR CVR (RH) (LLT, LY7) For vehicles repaired under the 5 year/100,000 mile (160,000 km) Powertrain Coverage (Code P) warranty, use: 4080098* Labor Operation Tube/Covers/Seal (Malibu, G6, AURA, VUE) *This is a unique Labor Operation for Bulletin use only. It will not be published in the Labor Time Guide. Tube/Covers/Seal (Enclave, Acadia, Traverse, OUTLOOK) 2.3 hrs Labor Time 3.9 hrs Recommendation/Instructions (2011 Enclave, Malibu, Traverse, Acadia) 1. Remove the bank2 camshaft cover for servicing of the PCV system. Refer to Camshaft Cover Replacement Left Side in SI. 3. Replace the bank2 camshaft cover and replace the camshaft cover gasket. 4. Reassemble the bank2 camshaft cover.

the camshaft cover bolts to 10 Nm (89 lb in). Parts Information (2011 Enclave, Malibu, Traverse, Acadia) 12647772 Cover, CM/SHF (LH) (LLT) For vehicles repaired under warranty, use: Labor Operation Labor Time 4060970 Camshaft Cover Replacement Use Published Labor Operation Time

2024 © autodocbox.com Privacy Policy | Terms of Service | Feedback