Parts Manual REGENT / 500 / 2500 SERIES LAWN TRACTORS & MOWER DECKS 4HP GEAR TRACTORS Mfg. No. Description 92593 Regent 4HP Gear 92595 54G, 4HP Gear 9259 254G, 4HP Gear 92599 Regent 4HP Gear (Export) MOWER DECKS 9235 3 Mower Deck 9259 3 Mower Deck 9244 44 Mower Deck 925 44 Mower Deck 4HP HYDRO TRACTORS Mfg. No. Description 92354 Regent 4HP Hydro 925 54H, 4HP Hydro 9259 254H, 4HP Hydro 920 Regent 4HP Hydro (Export) HP GEAR TRACTORS Mfg. No. Description 920 Regent HP Gear 9229 5G, HP Gear HP HYDRO TRACTORS Mfg. No. Description 922 Regent HP Hydro 923 5H, HP Hydro 9235 25H, Hp Hydro SPORTS SERIES TRACTORS Mfg. No. Description 923 Packers Regent 4HP Hydro 9295 Vikings Regent 4HP Hydro 92959 Steelers Regent 4HP Hydro 929 Panthers Regent 4HP Hydro 9293 Chiefs Regent 4HP Hydro 9295 Colts Regent 4HP Hydro 929 Badgers Regent 4HP Hydro 9299 Hawkeyes Regent 4HP Hydro 929 Wolverines Regent 4HP Hydro 9293 Spartans Regent 4HP Hydro 9295 Nittany Lions Regent 4HP Hydro Rev. 5/9 TP 400-409-02-RG-SMA
MANUFACTURING, INC. 500 N Spring Street / PO Box 99 Port Washington, WI 5304-099 USA Copyright 99 Simplicity Manufacturing, Inc. All Rights Reserved. Printed In USA.
Table of Contents This Manual Covers The Following Products: 4HP GEAR LAWN TRACTORS PAGES 92593 Regent 4HP Gear 2, 4,,, 0, 2, 92595 54G, 4HP Gear 24, 2, 30, 32, 34 9259 254G, 4HP Gear 3, 3, 40, 42 92599 Regent 4HP Gear (Export) 4HP HYDRO LAWN TRACTORS PAGES 92354 Regent 4HP Hydro 2, 4,,,, 20, 925 54H, 4HP Hydro 2, 2, 30, 32, 34 9259 254H, 4HP Hydro 3, 3, 40, 42 920 Regent 4HP Hydro (Export) HP GEAR LAWN TRACTORS PAGES 920 Regent HP Gear 2, 4,,, 0, 2, 9229 5G, HP Gear 24, 2, 30, 32, 34, 3, 44, 4, 4 HP HYDRO LAWN TRACTORS PAGES 922 Regent HP Hydro 2, 4,,,, 20, 923 5H, HP Hydro 2, 2, 30, 32, 34, 9235 25H, Hp Hydro 3, 44, 4, 4 3 MOWER DECKS PAGES 9235 3 Mower Deck 34, 3, 3, 40, 42 9259 3 Mower Deck 44 MOWER DECKS PAGES 9244 44 Mower Deck 34, 3, 44, 4, 4 925 44 Mower Deck LAWN TRACTOR COMPONENTS Frame.....................................2 Steering....................................4 Engine & Electric Clutch - 4HP & HP B&S....... Gear Transaxle - Peerless Model MST 205-55A Drive & Belt Group - Gear Models............. Control Rod Group - Gear Models............0 REFERENCE: Transaxle Service Parts - Peerless MST 205-55A..............2 Hydro Transaxle - Hydro-Gear 3-0500 & 322-050 Drive & Belt Group - Hydro Models........... Control Rod Group - Hydro Models........... Transaxle Service Parts - Hydro-Gear 3-0500 & 322-050......20 Electrical - Gear Models.......................24 Electrical - Hydro Models......................2 Hood, Dash & Fuel Tank......................2 Seat & Deck................................30 Wheels & Tires.............................32 Decals - Safety & Common....................34 Decals - Brand & Model.......................3 SPORTS SERIES TEAM TRACTORS Please cross-reference the pages listed for Regent 4HP Hydro Mfg. No. 92354 above for all mechanical components of the following Sports Series Team Tractors: 923 Packers Regent 4HP Hydro 9295 Vikings Regent 4HP Hydro 92959 Steelers Regent 4HP Hydro 929 Panthers Regent 4HP Hydro 9293 Chiefs Regent 4HP Hydro 9295 Colts Regent 4HP Hydro 929 Badgers Regent 4HP Hydro 9299 Hawkeyes Regent 4HP Hydro 929 Wolverines Regent 4HP Hydro 9293 Spartans Regent 4HP Hydro 9295 Nittany Lions Regent 4HP Hydro NOTE: Mower Decks for these tractors should cross-reference the pages listed for 3 Mower Deck, Mfg. No. 9235 for all mechanical components. MOWER DECK COMPONENTS 3 Mower Deck - Deck, Arbors & Blades.........3 3 Mower Deck - Clutch & Support.............40 3 Mower Deck - Height Adjustment Rollers......42 44 Mower Deck - Housing, Arbors & Blades......44 44 Mower Deck - Clutch & Support.............4 44 Mower Deck - Height Adjustment & Rollers....4 REFERENCE INFORMATION: Part Number Index..........................50 Torque Specification Chart.........Inside Back Cover Copyright 99 Simplicity Manufacturing, Inc. All Rights Reserved. TP-400-409-02-RG-SMA
Frame NOTE: Unless noted otherwise, use the standard hardware torque specification chart. A-RG42050A 2 3 4 5 2 9 0 3 2 0 2 2 24 23 2 22 20 9 3 4 5 2 92354 Regent 4HP Hydro 925 54H, 4HP Hydro 9259 254H, 4HP Hydro 92593 Regent 4HP Gear 92595 54G, 4HP Gear 9259 254G, 4HP Gear 92599 Regent 4HP Gear-Export 920 Regent 4HP Hydro-Export 920 Regent HP Gear 922 Regent HP Hydro 9229 5G, HP Gear 923 5H, HP Hydro 9235 25H, HP Hydro Copyright 99 Simplicity Manufacturing, Inc. All Rights Reserved. 2 TP-400-409-02-RG-SMA
Frame REF NO. PART NO. QTY. DESCRIPTION 505 PLUG, Hole (Gear Models only) 2 44 PAD, Footrest, RH (Hydro Models) 2 50 PAD, Footrest, RH (Gear Models) 3 0435 2 FASTENER, Panel 4 44 PAD, Footrest, LH 5 935255 4 NUT, Tinn, 5/- 93059 4 SCREW, Whiz, 5/- x 3/4 595 WRAPPER, Rear Frame (Hydro Models) 59 WRAPPER, Rear Frame (Gear Models) 333 FRAME ASSEMBLY 9 5033 CARRIER ASSEMBLY (Gear Models) 9 04 CARRIER ASSEMBLY (Hydro Models) 0 92045 2 CAPSCREW, 3/- x -/4 294 BUSHING 2 92435 2 WASHER, 3/ 3 93045 2 NUT, Flange Lock, 3/- 4 4533 SPACER 5 3400 TORSION BAR 932 NUT, Hex, 5/- 9943 NUT, Hex, Nylon Lock, 5/- 92023 WASHER, Large 9 25 2 WASHER, Spring 20 9052 WASHER, 3/4 x -/4 x /2 2 440 BUSHING 22 344 SPACER 23 35 J-HOOK 24 9043 CARRIAGE BOLT, 5/- x 3-/4 Footnotes: 92354 Regent 4HP Hydro 925 54H, 4HP Hydro 9259 254H, 4HP Hydro 92593 Regent 4HP Gear TP-400-409-02-RG-SMA 92595 54G, 4HP Gear 9259 254G, 4HP Gear 92599 Regent 4HP Gear-Export 920 Regent 4HP Hydro-Export 3 920 Regent HP Gear 922 Regent HP Hydro 9229 5G, HP Gear 923 5H, HP Hydro 9235 25H, HP Hydro
Steering NOTE: Unless noted otherwise, use the standard hardware torque specification chart. A-RG4205A 2 30 3 29 4 4 2 2 9 5 2 0 2 25 9 24 3 2 23 4 22 5 20 9 3 92354 Regent 4HP Hydro 925 54H, 4HP Hydro 9259 254H, 4HP Hydro 92593 Regent 4HP Gear 92595 54G, 4HP Gear 9259 254G, 4HP Gear 92599 Regent 4HP Gear-Export 920 Regent 4HP Hydro-Export 920 Regent HP Gear 922 Regent HP Hydro 9229 5G, HP Gear 923 5H, HP Hydro 9235 25H, HP Hydro Copyright 99 Simplicity Manufacturing, Inc. All Rights Reserved. 4 TP-400-409-02-RG-SMA
Steering REF NO. PART NO. QTY. DESCRIPTION 34 STEERING WHEEL ASSY., (Incl. CAP Ref. 2) 2 409 CAP, Steering Wheel 3 4400 TUBE, Flex 4 90540 PIN, Spring, 5/ x 2-/2 5 44 SHAFT ASSY., Steering 93350 2 CARRIAGE BOLT, 3/- x 904 4 WASHER 92352 2 NUT, Flange Lock,Whiz, 3/- 9 929 CAPSCREW, 3/- x -3/ 0 922 WASHER 335 STEERING GEAR ASSY. 2 349 DRAG LINK 3 93045 3 NUT, Hex, Flange Lock. 3/- 4 0 3 KLIPRING 5 3453 ARM, Steering, LH 900 2 WASHER 350 2 SPINDLE ASSY. 39 2 SPACER 9 9243* 2 WASHER, 5/ (Early units only) 20 3454 TIE ROD 2 3452 ARM, Steering, RH 22 902 2 CARRIAGE BOLT, 3/- x -/4 23 93335 CARRIAGE BOLT, 5/- x 24 043 SPACER 25 93504 NUT, Hex, Flange Lock, 5/- 2 44 2 SCREW, Taptite, 5/- x 3/4 2 00 BUSHING 2 440 BUSHING 29 0350 PLATE, Steering, Mounting 30 9934 PIN, Cotter, 3/ x -/4 Footnotes: * Early style units only. If tractor is NOT equipped with washers (Ref 9), do not add them when servicing. 92354 Regent 4HP Hydro 925 54H, 4HP Hydro 9259 254H, 4HP Hydro 92593 Regent 4HP Gear TP-400-409-02-RG-SMA 92595 54G, 4HP Gear 9259 254G, 4HP Gear 92599 Regent 4HP Gear-Export 920 Regent 4HP Hydro-Export 5 920 Regent HP Gear 922 Regent HP Hydro 9229 5G, HP Gear 923 5H, HP Hydro 9235 25H, HP Hydro
Engine & Electric Clutch - 4 & HP Briggs & Stratton NOTE: Unless noted otherwise, use the standard hardware torque specification chart. A-RG42052A 2 3 34 33 2 4 32 5 29 30 9 9 0 2 0 RH Front LH Front & LH Rear 3 2 2 23 RH Rear 25 24 2 3 4 See specific Transaxle Drive Groups for pulley part number. 5 22 20 2 9 92354 Regent 4HP Hydro 925 54H, 4HP Hydro 9259 254H, 4HP Hydro 92593 Regent 4HP Gear 92595 54G, 4HP Gear 9259 254G, 4HP Gear 92599 Regent 4HP Gear-Export 920 Regent 4HP Hydro-Export 920 Regent HP Gear 922 Regent HP Hydro 9229 5G, HP Gear 923 5H, HP Hydro 9235 25H, HP Hydro Copyright 99 Simplicity Manufacturing, Inc. All Rights Reserved. TP-400-409-02-RG-SMA
Engine & Electric Clutch - 4 & HP Briggs & Stratton REF NO. PART NO. QTY. DESCRIPTION 4540 PLENUM (Hydro Models) 555 PLENUM (Gear Models) 2 902 2 CLAMP, Hose 3 HOSE, Fuel, Cut to 2 length (Hydro Models) 3 HOSE, Fuel, Cut to 9-/ length (Gear Models) 4 34 KNOB, Throttle Control 5 9049 2 SCREW, Plastite, /4-0 x 5/ 320 FILTER, Fuel 03 CONTROL ASSY., Throttle * ENGINE, 4HP or HP Briggs & Stratton 9 93323 2 WASHER (HP Units Only) 0 0449 2 GUIDE, Belt, Wireform (HP Units Only) 93059 3 SCREW, Hex Hd., Taptite, 3/- x -/5 (HP Hydro Only) 9235 3 SCREW, Hex Hd., Taptite, 3/- x -/4 2 053 SLEEVE, Clutch Anchor 3 3 WASHER 4 053 CLUTCH, Electric 5 55 PLATE, Muffler Duct 935255 4 PAL NUT, 5/- 33 DUCT, Muffler, Lower 05249 2 SPACER 9 0524 2 PIVOT, Hood 20 930595 2 SCREW, Hex, Whiz, 5/- x -/4 2 93059 2 SCREW, Hex, Flange Whiz, 5/- x 3/4 22 500 DUCT, Muffler, Upper 23 9245 4 SCREW, Taptite, 5/- x /2 24 9030 CAPSCREW, Hex, /-20 x 2-/2 25 999 LOCKWASHER, / 2 9242 2 SCREW, Taptite, /4-20 x 3/ 2 5005 MUFFLER ASSY. 2 935 2 LOCKWASHER, 5 29 9322 2 CAPSCREW, Socket Hd., 5/- x 3/4 30 500 GASKET, Muffler 3 93059 SCREW, Hex Hd., Taptite, 3/- x -/2 3 903 SCREW, Hex Hd., Taptite, 3/- x 2.0 (HP Hydro Only) 32 0405 DRAIN VALVE, Oil 33 92042 WASHER, External Tooth 3/ 34 9950 NUT, Hex, Jam Lock, 3/- Footnotes: * See your local Briggs & Stratton distributor for service parts. 92354 Regent 4HP Hydro 925 54H, 4HP Hydro 9259 254H, 4HP Hydro 92593 Regent 4HP Gear TP-400-409-02-RG-SMA 92595 54G, 4HP Gear 9259 254G, 4HP Gear 92599 Regent 4HP Gear-Export 920 Regent 4HP Hydro-Export 920 Regent HP Gear 922 Regent HP Hydro 9229 5G, HP Gear 923 5H, HP Hydro 9235 25H, HP Hydro
Drive & Belt Group Gear Models NOTE: Unless noted otherwise, use the standard hardware torque specification chart. 2 A-RG42053A 3 4 5 4 3 32 33 34 35 9 0 2 2 3 9 29 2 5 30 See Transaxle Control Rod Group for spring part number. 24 23 2 See Rear Wheels & Tires Group for wheels, tires, & attaching hardware. 3 25 22 9 4 20 5 2 25 2 3 92593 Regent 4HP Gear 92595 54G, 4HP Gear 9259 254G, 4HP Gear 92599 Regent 4HP Gear-Export 920 Regent HP Gear 9229 5G, HP Gear Copyright 99 Simplicity Manufacturing, Inc. All Rights Reserved. TP-400-409-02-RG-SMA
Drive & Belt Group Gear Models REF NO. PART NO. QTY. DESCRIPTION 5044 V-BELT, 93-/4 2 9203 RING, Retaining 3 9230 CAPSCREW, Hex Hd., 3/- x 2 4 924940 3 WASHER, Plain, 3/ 5 45 PULLEY, Idler, V 294 SPACER 995 2 LOCKWASHER, 3/ 9950 NUT, Hex, Full, 3/- 9 44 PULLEY ASSY. 0 90523 KEY, Woodruff #9 * GEAR TRANSMISSION, 5-Speed 2 9300 2 SCREW, Taptite, 5/- x 5/ 3 9055 SCREW, Taptite, 5/- x 2-/2 4 993 2 WASHER 5 03 2 ANCHOR, Torsion Bar 9255 2 NUT, Hex, Flange Whiz, 5/- 9943 4 NUT, Hex, Nylon Lock, 5/- 502 LINK, Shift, Lower 9 9950 3 NUT, Hex, Full, 5/- 20 455 LEVER, Shift 2 90555 CARRIAGE BOLT, 5/- x -/2 22 9239 WASHER, Plain 23 994 LOCKWASHER, /4 24 922234 CAPSCREW, Hex, /4-2 x 5/ 25 90223 3 CARRIAGE BOLT, 5/- x -/4 2 5029 LINK, Shift, Upper 2 34 2 BUSHING, Plastic, 5/ 2 4 BELLCRANK ASSY. 29 9233 GREASE FITTING 30 9295 CAPSCREW, Hex Hd., 3/- x 3/4 3 935 2 LOCKWASHER, 5/ 32 4544 GUARD, Belt 33 93333 CARRIAGE BOLT, 5/- x 3/4 34 453 2 PULLEY, Half 35 22042 2 KEY 3 90425 CLIP, Tinnerman Footnotes: *See your local Tecumseh/Peerless distributor for service parts. (See pages 2-5 for service parts listing.) 92593 Regent 4HP Gear 92595 54G, 4HP Gear 9259 254G, 4HP Gear 92599 Regent 4HP Gear-Export 920 Regent HP Gear 9229 5G, HP Gear TP-400-409-02-RG-SMA 9
Control Rod Group Gear Models NOTE: Unless noted otherwise, use the standard hardware torque specification chart. A-RG42054A Install into notch in wrapper. 2 3 4 5 Hook under Tinnerman Clip {See Gear Transaxle Drive & Belt Group} 2 To Top of Frame. 2 5 2 30 3 9 2 29 3 4 2 0 Install in lanced notch in top of frame. 24 25 2 3 5 23 22 9 2 20 92593 Regent 4HP Gear 92595 54G, 4HP Gear 9259 254G, 4HP Gear 92599 Regent 4HP Gear-Export 920 Regent HP Gear 9229 5G, HP Gear Copyright 99 Simplicity Manufacturing, Inc. All Rights Reserved. 0 TP-400-409-02-RG-SMA
Control Rod Group Gear Models REF NO. PART NO. QTY. DESCRIPTION 343 KNOB, Plastic, Gear Shift 2 45 ROD, Shift 3 5302 SPRING, Gear Shift 4 435 ROD, Parking Brake 5 355 KNOB, Plastic, Parking Brake 34 SPRING, Return 944 3 PIN, Cotter, 3/32 x 3/4 90044 WASHER, 5/ 9 4 ROD, Brake 0 504 SPRING, Brake Rod 9943 5 NUT, Nylon Lock, 5/- 2 9932 3 WASHER, Plain, 5/ 3 34 2 BUSHING, 5/ 4 93353 CARRIAGE BOLT, 3/- x -3/4 5 50 2 SPRING, Idler 3433 BRACKET, Idler 029 PULLEY, Backside 92352 NUT, Hex, Flange Whiz, 3/- 9 924940 WASHER, Plain, 3/ 20 995 LOCKWASHER, 3/ 2 929 CAPSCREW, 3/- x -3/4 22 0352 GUARD 23 452 PULLEY, Idler, V 24 34 CLAMP, Tube 25 93333 4 CARRIAGE BOLT, 5/- x 3/4 2 3 FOOT PEDAL ASSY. 2 43 PAD, Foot Pedal 2 434 LEVER, Parking Brake 29 35 GUIDE, Brake Rod 30 3432 ROD, Clutch 3 944 2 PIN, Cotter, 3/32 x Footnotes: *See your local Tecumseh/Peerless distributor for transaxle service parts. (See pages 2-5 for service parts listing.) 92593 Regent 4HP Gear 92595 54G, 4HP Gear 9259 254G, 4HP Gear 92599 Regent 4HP Gear-Export 920 Regent HP Gear 9229 5G, HP Gear TP-400-409-02-RG-SMA
REFERENCE Transaxle Service Parts Peerless Model MST 205-55A (Gear Models) NOTE: Unless noted otherwise, use the standard hardware torque specification chart. A-RG42055A Copyright 99 Tecumseh Products Company. All Rights Reserved. 92593 Regent 4HP Gear 92595 54G, 4HP Gear 9259 254G, 4HP Gear 92599 Regent 4HP Gear-Export 920 Regent HP Gear 9229 5G, HP Gear Copyright 99 Simplicity Manufacturing, Inc. All Rights Reserved. 2 TP-400-409-02-RG-SMA
REFERENCE Transaxle Service Parts Peerless Model MST 205-55A (Gear Models) REF NO. PART NO. QTY. DESCRIPTION 244 Transaxle Cover 2 00A 2 Needle Bearing 5/ ID 3 02 Transaxle Case 4 395 Countershaft 5 409 Output Shaft 34 Spur Gear (3 teeth) A 35 Spur Gear (5 teeth-steel) 330 Spur Gear ( teeth-steel) 923A 2 Shift Key 9 4352 Shift Collar 0 43 Shift Rod & Fork 334 Bevel Gear (30 teeth) 2 309 Input Bevel Pinion (3 teeth) 3 32 2 Bevel Gear ( teeth-steel)(incl. 4) 4 32 2 Bevel Gear ( teeth-steel)(incl. 3) 5 32A Ring Gear (43 teeth) 39 Drive Pin 02 Spacer 20 920 Ball 5/ dia 2 920 Set Screw 3/- x 3/ 22 9209 Spring 25 9203A Screw /4-20 x -/4 25A 92 2 Screw /4-20 X -3/ 2 9225 4 Retaining Ring (pkg of 2) 2 92035 Retaining Ring 2 040 Retaining Ring 29 002 4 Washer 29A 00 Washer 29B 05 2 Thrust Washer 30 00 4 Washer 3 000 2 Washer (.05 wide) (USE AS NEEDED) 3A 095 2 Flat Washer (.02 wide) 32 03 Oil Seal 5/ 34 094 2 Bushing 35 093 2 Flanged Bushing 35A 09 2 Flanged Bushing 3/4 3 9005 Brake Disk 3 9000 Brake Pad Plate 3 9902 2 Brake Pad (pkg of 2) 39 02 2 Dowel Pin 40 920A Washer 4 9009 Brake Lever 42 9203A Screw /4-20 x -/4 42A 9205A Screw /4-20 x 2-/4 43 9205 Locknut 5/-24 44 90025 Brake Pad Holder 45 0 Spacer 4 0 Brake Lever Bracket 4 4942 Axle (2-/32 long) Footnotes: Peerless transmission parts must be ordered through your local Tecumseh/Peerless distributor. Copyright 99 Tecumseh Products Company. All Rights Reserved. Reference Nos 4 through 0 are listed on the following pages. 92593 Regent 4HP Gear 92595 54G, 4HP Gear 9259 254G, 4HP Gear 92599 Regent 4HP Gear-Export 920 Regent HP Gear 9229 5G, HP Gear TP-400-409-02-RG-SMA 3
REFERENCE Transaxle Service Parts Peerless Model MST 205-55A (Gear Models) NOTE: Unless noted otherwise, use the standard hardware torque specification chart. A-RG42055A Copyright 99 Tecumseh Products Company. All Rights Reserved. 92593 Regent 4HP Gear 92595 54G, 4HP Gear 9259 254G, 4HP Gear 92599 Regent 4HP Gear-Export 920 Regent HP Gear 9229 5G, HP Gear Copyright 99 Simplicity Manufacturing, Inc. All Rights Reserved. 4 TP-400-409-02-RG-SMA
REFERENCE Transaxle Service Parts Peerless Model MST 205-55A (Gear Models) REF NO. PART NO. QTY. DESCRIPTION 4 49 Axle (-3/ long) 49 35 Spur Gear (29 teeth-steel) 50 354 Spur Gear (23 teeth-steel) 5 352 Spur Gear (9 teeth-steel) 52 350 Spur Gear ( teeth-steel) 53 34 Spur Gear (5 teeth-steel) 5 355 Spur Gear ( teeth-steel) 5 353 Spur Gear ( teeth-steel) 5 35 Spur Gear (2 teeth-steel) 59 349 Spur Gear (24 teeth-steel) 0 345 Spur Gear (25 teeth) 3 0 Countershaft Spacer -/ x 3/ 4 02 Brake Shaft Spacer -3/ X 3/ 5 09 Washer 394 Input Shaft 39 Shifter & Brake Shaft 9 920 Retaining Ring 0 Spacer B 092 O Ring 2A 09 O Ring 2 925 Threaded Plug 9/- 3 040 2 Needle Bearing 3/4 5 04 2 Sleeve.999 ID 0090 Washer 0A Inverted Retaining Ring 2 333 Bevel & Spur Gear (30 & 3 teeth) 3 33 Spur Gear (2 teeth) 5 9254 Oil Fill Plug 09 Oil Seal 9/ 50 093 Liquid Gasket RTV Silicone 5 0 2 Oil Seal 3/4 0 30229A Gear Oil 0W90 Footnotes: Peerless transmission parts must be ordered through your local Tecumseh/Peerless distributor. Copyright 99 Tecumseh Products Company. All Rights Reserved. Reference Nos through 4 are listed on the previous pages. 92593 Regent 4HP Gear 92595 54G, 4HP Gear 9259 254G, 4HP Gear 92599 Regent 4HP Gear-Export 920 Regent HP Gear 9229 5G, HP Gear TP-400-409-02-RG-SMA 5
Drive & Belt Group Hydro Models NOTE: Unless noted otherwise, use the standard hardware torque specification chart. A-RG4205A 44 2 3 43 4 32 3 30 22 4HP Models (32-0500) 24 23 2 2 33 34 HP Models (322-050) HP Models (322-050) 22 25 2 45 25 35 3 2 29 4HP Models (32-0500) 20 2 2 2 29 2 20 4 42 Torque to 350-400 in. lbs. 40 5 39 3 3 4 9 0 3 2 4 5 Torque to 0-00 in. lbs. 5 2 2 4 2 2 9 See Rear Wheels & Tires for wheels, tires, and mounting hardware. 92354 Regent 4HP Hydro 925 54H, 4HP Hydro 9259 254H, 4HP Hydro 920 Regent 4HP Hydro-Export 922 Regent HP Hydro 923 5H, HP Hydro 9235 25H, HP Hydro Copyright 99 Simplicity Manufacturing, Inc. All Rights Reserved. TP-400-409-02-RG-SMA
Drive & Belt Group Hydro Models REF NO. PART NO. QTY. DESCRIPTION 0209 BELT, Drive (HP Models - 322-050 Transaxle) 235 BELT, Drive (4Hp Models - 3-0500 Transaxle) 2 44 SCREW, Taptite, 5/- x 3/4 3 9 2 SPACER 4 00 TIE, Cable 5 4524 GUIDE, Belt, Wireform 90509 SCREW, Taptite, #0-24 x -/4 905 WASHER, /4 x -/4 x 5/4 52 SPRING, Conical 9 922 WASHER, 3/32 x -/4 x / 0 92039 NUT, Hex, Full Lock, /4-20 092 LEVER, Release 2 0990 SPACER 3 9055 SCREW, Taptite, 5/- x 2-/2 4 3 TRANSMISSION, Hydro (4HP Models - 3-0500 Translaxle) 4 99 TRANSMISSION, Hydro (HP Models - 322-050 Transaxle) 5 22042 2 KEY 03 2 ANCHOR, Torsion Bar 9255 4 NUT, Hex, Flange Whiz, 5/- 9339 SCREW, Flange Whiz, 5/- x -/2 9 93559 SCREW, Flange Whiz, 5/- x 2-/4 20 9222 2 CAPSCREW, 5/- X -3/4 2 932 2 NUT, Hex, Full, 5/- 22 935 2 LOCKWASHER, 5/ 23 4544 GUARD, Belt (4HP - Models - 3-0500 Transaxle) 24 93333 CARRIAGE BOLT, 5/- x 3/4 (4HP - Models - 3-0500 Transaxle) 25 453 2 PULLEY, Half (4HP - Models - 3-0500 Transaxle) 25 PULLEY (HP Models - 322-050 Transaxle) 2 5550 SPACER 2 39 LEVER ASSY., Speed Control 2 90044 3 WASHER 29 93504 2 NUT, Flange, Centerlock, 5/- 30 3 ROD, Neutral Adj. 3 93335 CARRIAGE BOLT, 5/- x 32 929 CAPSCREW, Hex, 5/- x 2-/2 33 5 SPRING, Torsion 34 35 SPACER, 5/ x /2 x -/2 35 9243 WASHER 3 355 LEVER, Speed Control 3 53 FITTING 3 3322 TUBE, Vent 39 54 PLUG, Vent 40 09 PULLEY ASSY., (Trans. Input) 4 99 LOCKWASHER, /2 42 9922 NUT, Hex, Jam, /2-20 43 0933 FAN, Hydro 44 93395 3 SCREW, Taptite, /4-20 x -/ 45 24 KEY, Pulley (HP Models - 322-050 Transaxle) 4 92332 CAPSCREW, Hex, 5/- x 3/4 (HP Models - 322-050 Transaxle) 4 00 ARM, Speed Control (HP Models - 322-050 Transaxle) Footnotes: (See pages 20-23 for transaxle service parts listing.) 4HP Models are equipped with Hydro Gear 3-0500 Transaxles. HP Models are equipped with Hydro Gear 322-050 Transaxles. 92354 Regent 4HP Hydro 925 54H, 4HP Hydro 9259 254H, 4HP Hydro TP-400-409-02-RG-SMA 920 Regent 4HP Hydro-Export 922 Regent HP Hydro 923 5H, HP Hydro 9235 25H, HP Hydro
Control Rod Group Hydro Models NOTE: Unless noted otherwise, use the standard hardware torque specification chart. A-RG4205A 2 3 4 29 3 5 2 2 9 22 2 30 3 35 9 34 33 9 Install to Top of Frame. 0 9 2 2 25 24 3 32 9 20 9 0 Install to Top of Frame. 23 2 22 2 3 2 5 4 92354 Regent 4HP Hydro 925 54H, 4HP Hydro 9259 254H, 4HP Hydro 920 Regent 4HP Hydro-Export 922 Regent HP Hydro 923 5H, HP Hydro 9235 25H, HP Hydro Copyright 99 Simplicity Manufacturing, Inc. All Rights Reserved. TP-400-409-02-RG-SMA
Control Rod Group Hydro Models REF NO. PART NO. QTY. DESCRIPTION 944 4 PIN, Cotter, 3/32 x 3/4 2 924940 2 WASHER, Plain, 3/ 3 3429 ROD, Control 4 355 KNOB, Plastic, Parking Brake 5 435 ROD, Parking Brake 343 ROD, Brake 0909 SPRING, Brake Rod 9943 5 NUT, Hex, Nylon Lock, 5/- 9 93353 CARRIAGE BOLT, 3/- x -3/4 0 50 2 SPRING, Idler 3433 BRACKET, Idler 2 029 PULLEY, Backside 3 92352 NUT, Hex, Flange Whiz, 3/- 4 929 CAPSCREW, 3/- x -3/4 5 995 LOCKWASHER, 3/ 0352 GUARD 452 PULLEY, Idler, V 34 2 BUSHING, 5/ 9 9932 5 WASHER, Plain, 5/ 20 453 2 SPACER 2 44 2 CLAMP 22 92039 NUT, Hex, Nylon Lock, /4-20 23 34 CLAMP, Tube 24 93333 4 CARRIAGE BOLT, 5/- x 3/4 25 3434 LEVER, Hydro Control 2 5025 2 BUSHING, Plastic 2 3 FOOT PEDAL ASSY. 2 43 PAD, Foot Pedal 29 342 PEDAL, Foot, Directional 30 90554 CAPSCREW, /4-20 x 2-/4 3 3432 ROD, Clutch 32 35 GUIDE, Brake Rod 33 434 LEVER, Parking Brake 34 932 NUT, Hex, Full, 5/- 35 935 LOCKWASHER, 5/ 3 03900 SPACER 3 93335 CARRIAGE BOLT, 5/- x Footnotes: (See pages 20-23 for transaxle service parts listing.) 92354 Regent 4HP Hydro 925 54H, 4HP Hydro 9259 254H, 4HP Hydro 920 Regent 4HP Hydro-Export 922 Regent HP Hydro 923 5H, HP Hydro 9235 25H, HP Hydro TP-400-409-02-RG-SMA 9
Transaxle Service Parts Hydro Gear 3-0500 & 322-050 (Hydro Models) 40 50 3 2 29 52 5 4 30 35 4 2 34 32 33 55 5 3 5 3 322-050 ONLY 5 24 54 4 3 43 A-RG4205A 53 2 Hook on screw located on upper housing assembly. 49 39 42 3 44 49 4 2 25 3 5 59 4 42 22 23 2 3 Hook end of spring () on screw located here. 5 5 20 9 2 NOTE: Unless noted otherwise, use the standard hardware torque specification chart. 4 45 4 0 9 92354 Regent 4HP Hydro 925 54H, 4HP Hydro 9259 254H, 4HP Hydro 920 Regent 4HP Hydro-Export 922 Regent HP Hydro 923 5H, HP Hydro 9235 25H, HP Hydro Copyright 99 Simplicity Manufacturing, Inc. All Rights Reserved. 20 TP-400-409-02-RG-SMA
Transaxle Service Parts Hydro Gear 3-0500 & 322-050 (Hydro Models) REF NO. PART NO. QTY. DESCRIPTION 03 SEAL-LIP 2 04 RING, Retaining 3 05 SEAL-LIP 4 0990 ARM-BYPASS 5 0990 SET SCREW 0995 2 PIN-ACTUATING 099 WASHER, / x / x.00 (4Hp Models Only - 3-0500 Transaxle) 0999 NUT, Hex, Lock, 5/-24 (4Hp Models - 3-0500 Transaxle) 9 NUT, HEX 5/-24 (HP Models Only - 322-050 Transaxle) 9 0992 SEAL-LIP.0 x.25 x. 0 09922 RING, Retaining 3 ARM, Actuating (4Hp Models - 3-0500 Transaxle) 3 ARM, Actuating (HP Models - 322-050 Transaxle) 2 443 CASTLE NUT, 5/-24 3 43 PUCK, Dampener 4 099 ARM, Control (HP Models - 322-050 Transaxle) 4 43 ARM, Control (4Hp Models - 3-0500 Transaxle) 5 442 DRIVE PIN 443 EXTENSION SPRING 444 STUD, 5/-24 40 COMPRESSION SPRING 9 54 RING-WIRE, Retaining 20 542 BEARING, Shaft Ball 2 543 2 BEARING, Cradle 22 544 BEARING, Thrust.30 x.52 x.3 23 545 SWASHPLATE, Variable 24 54 BLOCK-CYLINDER PUMP ASSY. 25 54 ARM, Trunnion 2 54 GUIDE-SLOT 2 549 SHAFT, Motor 2 550 BEARING, Thrust.42 x. x. 29 55 BLOCK-CYLINDER (MOTOR) ASSY. 30 552 ACTUATOR-BYPASS 3 553 CENTER SECTION ASSEMBLY (4Hp Models - 3-0500 Transaxle) 3 59 CENTER SECTION ASSEMBLY (HP Models - 322-050 Transaxle) 32 554 SEAL-LIP.2 x.42 x. 33 555 RING, Retaining 34 55 2 WASHER 35 55 OIL FILTER ELEMENT 3 55 BOLT, 5/- x -3/4 3 559 4 BRAKE ROTOR/STATOR KIT 3 52 2 SEAL 3/4 x -/4 x /4 39 53 SHAFT, Input 40 54 2 BOLT, /4-20 x -3/ 4 55 2 PIN 42 50 2 SEAL, Wiper 43 5 SPRING, Block 44 52 WASHER, Block Thrust 45 53 CAP-VENT ASSEMBLY Footnotes: 4HP Models are equipped with Hydro Gear 3-0500 Transaxles. HP Models are equipped with Hydro Gear 322-050 Transaxles. 92354 Regent 4HP Hydro 925 54H, 4HP Hydro 9259 254H, 4HP Hydro 920 Regent 4HP Hydro-Export 922 Regent HP Hydro 923 5H, HP Hydro 9235 25H, HP Hydro TP-400-409-02-RG-SMA 2
Transaxle Service Parts Hydro Gear 3-0500 & 322-050 (Hydro Models) 40 50 3 2 29 52 5 4 30 35 4 2 34 32 33 55 5 3 5 3 322-050 ONLY 5 24 54 4 3 43 A-RG4205A 53 2 Hook on screw located on upper housing assembly. 49 39 42 3 44 49 4 2 25 3 5 59 4 42 22 23 2 3 Hook end of spring () on screw located here. 5 NOTE: Unless noted otherwise, use the standard hardware torque specification chart. 5 4 45 4 20 9 2 0 9 92354 Regent 4HP Hydro 925 54H, 4HP Hydro 9259 254H, 4HP Hydro 920 Regent 4HP Hydro-Export 922 Regent HP Hydro 923 5H, HP Hydro 9235 25H, HP Hydro Copyright 99 Simplicity Manufacturing, Inc. All Rights Reserved. 22 TP-400-409-02-RG-SMA
Transaxle Service Parts Hydro Gear 3-0500 & 322-050 (Hydro Models) REF NO. PART NO. QTY. DESCRIPTION 4 54 FITTING-O RING ASSEMBLY 4 59 DIFFERENTIAL ASSEMBLY (4Hp Models - 3-0500 Transaxle) 4 9 DIFFERENTIAL ASSEMBLY (HP Models - 322-050 Transaxle) 4 50 2 WASHER-3/4 x.5 x.3 49 5 2 SLEEVE BEARING 50 52 HOUSING, Lower 5 53 UPPER HOUSING ASSEMBLY (4Hp Models - 3-0500 Transaxle) 5 94 UPPER HOUSING ASSEMBLY (HP Models - 322-050 Transaxle) 52 5233 BYPASS PLATE 53 944 COTTER PIN 54 99 JACK SHAFT/PINION GEAR ASSEMBLY (HP Models Only - 322-050 Transaxle) 55 5 2 CAPSCREW M x 20 LG (HP Models Only - 322-050 Transaxle) 5 5 JACK SHAFT (HP Models Only - 322-050 Transaxle) 5 59 2 WASHER / x x.5 (HP Models Only - 322-050 Transaxle) 5 95 3 BOLT, 3/-24 x 2.5 (HP Models Only - 322-050 Transaxle) 59 5 NUT-HEX LOCK 5/-24 (HP Models Only - 322-050 Transaxle) Footnotes: 4HP Models are equipped with Hydro Gear 3-0500 Transaxles. HP Models are equipped with Hydro Gear 322-050 Transaxles. 92354 Regent 4HP Hydro 925 54H, 4HP Hydro 9259 254H, 4HP Hydro 920 Regent 4HP Hydro-Export 922 Regent HP Hydro 923 5H, HP Hydro 9235 25H, HP Hydro TP-400-409-02-RG-SMA 23
Electrical Group - Gear Models NOTE: Unless noted otherwise, use the standard hardware torque specification chart. 3 39 A-RG42059A 2 3 3 5 3 4 30 3 32 33 2 23 35 34 34 22 35 29 To right rear engine mtg. bolt. 9 (Black & Tan) 2 2 2 To solenoid (Black & Yellow) To circuit breaker (Red) 0 0 20 To clutch 25 24 23 22 2 5 (Green & Yellow) To starter motor 2 3 4 To alternator To headlight To magneto & fuel shut-off To right rear engine mtg. bolt 9 To headlight 92593 Regent 4HP Gear 92595 54G, 4HP Gear 9259 254G, 4HP Gear 92599 Regent 4HP Gear-Export 920 Regent HP Gear 9229 5G, HP Gear Copyright 99 Simplicity Manufacturing, Inc. All Rights Reserved. 24 TP-400-409-02-RG-SMA
Electrical Group - Gear Models REF NO. PART NO. QTY. DESCRIPTION 93333 CARRIAGE BOLT, 5/- x 3/4 2 35 CLAMP, Battery 3 9932 WASHER, Plain, 5/ 4 9943 NUT, Hex, Nylon Lock, 5/- 5 045 CAP, Vent, Battery 525 BATTERY 0453 HOSE, Drain 4 SWITCH, Seat 9 500 WIRE ASSY., Seat Switch 0 504 2 TUBE, Shrink 50 WIRE ASSY., Transmission 2 5434 SWITCH, Transmission 3 5540 SEAL, O-Ring 4 0025 WASHER, 5/ 5 45 WIRING HARNESS 40 SWITCH, Pedal, N.C., Gray 0439 SWITCH, Pedal, N.O., Black 9324 3 TIE 9 9343 CLIP, Wire 20 22023 COVER, Terminal 2 92023 2 NUT, Hex, 5/-24 NF 22 935 2 LOCKWASHER, 5/ 23 0344 2 CABLE, (Solenoid to Starter & Battery to Ground) 24 523 WIRE ASSY. 25 92429 SCREW, Taptite, -20 x 5/ 2 523 CIRCUIT BREAKER 2 5290 SOLENOID 2 0399 SWITCH, Headlights 29 42 SWITCH, PTO 30 50 SWITCH, Ignition, -Pole 3 4055 NUT, Hex, Flange, 5/- 32 0434 COVER, Ignition 33 4054 2 KEY, Ignition 34 922 2 NUT, Hex, /4-20 35 994 2 LOCKWASHER, /4 3 03 CABLE, Battery, Positive 3 29 BOOT, Insulator 3 9239 2 WASHER, /4 39 92334 2 CAPSCREW, Hex Hd., /4-20 x 3/4 Footnotes: 92593 Regent 4HP Gear 92595 54G, 4HP Gear 9259 254G, 4HP Gear 92599 Regent 4HP Gear-Export 920 Regent HP Gear 9229 5G, HP Gear TP-400-409-02-RG-SMA 25
Electrical Group - Hydro Models NOTE: Unless noted otherwise, use the standard hardware torque specification chart. A-RG4200A 2 33 34 35 3 4 2 2 2 29 32 9 3 30 3 30 5 24 25 23 22 2 To right rear engine mtg. bolt. To solenoid (Black & Yellow) To circuit breaker (Red) 9 (Black & Tan) 0 To clutch 20 9 2 3 To starter motor 4 To alternator To headlight 5 To magneto To right rear engine mtg. bolt To headlight 92354 Regent 4HP Hydro 925 54H, 4HP Hydro 9259 254H, 4HP Hydro 920 Regent 4HP Hydro-Export 922 Regent HP Hydro 923 5H, HP Hydro 9235 25H, HP Hydro Copyright 99 Simplicity Manufacturing, Inc. All Rights Reserved. 2 TP-400-409-02-RG-SMA
Electrical Group - Hydro Models REF NO. PART NO. QTY. DESCRIPTION 93333 CARRIAGE BOLT, 5/- x 3/4 2 35 CLAMP, Battery 3 9932 WASHER, Plain, 5/ 4 9943 NUT, Hex, Nylon Lock, 5/- 5 045 CAP, Vent, Battery 525 BATTERY 0453 HOSE, Drain 4 SWITCH, Seat 9 500 WIRE ASSY., Seat Switch 0 504 TUBE, Shrink 500 WIRING HARNESS 2 0439 SWITCH, Pedal, N.O., Black 3 40 SWITCH, Pedal, N.C., Gray 4 9324 3 TIE 5 9343 CLIP, Wire 22023 COVER, Terminal 92023 2 NUT, Hex, 5/-24 NF 935 2 LOCKWASHER, 5/ 9 0344 2 CABLE, (Solenoid to Starter & Battery to Ground) 20 523 WIRE ASSY. 2 92429 SCREW, Taptite, /4-20 x 5/ 22 523 CIRCUIT BREAKER 23 5290 SOLENOID 24 0399 SWITCH, Headlights 25 42 SWITCH, PTO 2 50 SWITCH, Ignition, -Pole 2 4055 NUT, Hex, Flange, 5/- 2 0434 COVER, Ignition 29 4054 2 KEY, Ignition 30 922 2 NUT, Hex, /4-20 3 994 2 LOCKWASHER, /4 32 03 CABLE, Battery, Positive 33 29 BOOT, Insulator 34 9239 2 WASHER, /4 35 92334 2 CAPSCREW, Hex Hd., /4-20 x 3/4 Footnotes: 92354 Regent 4HP Hydro 925 54H, 4HP Hydro 9259 254H, 4HP Hydro 920 Regent 4HP Hydro-Export 922 Regent HP Hydro 923 5H, HP Hydro 9235 25H, HP Hydro TP-400-409-02-RG-SMA 2
Hood, Dash & Fuel Tank NOTE: Unless noted otherwise, use the standard hardware torque specification chart. 2 3 A-RG420A 4 9 2 5 2 0 2 3 2 4 5 25 24 9 23 20 22 2 4 92354 Regent 4HP Hydro 925 54H, 4HP Hydro 9259 254H, 4HP Hydro 92593 Regent 4HP Gear 92595 54G, 4HP Gear 9259 254G, 4HP Gear 92599 Regent 4HP Gear-Export 920 Regent 4HP Hydro-Export 920 Regent HP Gear 922 Regent HP Hydro 9229 5G, HP Gear 923 5H, HP Hydro 9235 25H, HP Hydro Copyright 99 Simplicity Manufacturing, Inc. All Rights Reserved. 2 TP-400-409-02-RG-SMA
Hood, Dash & Fuel Tank REF NO. PART NO. QTY. DESCRIPTION 442 FUEL TANK (Incl. Fitting & Grommet, Refs 2 & 2) 2 4020 CAP, Fuel Tank 3 5044 STRAP 4 92039 0 NUT, Hex, Nylon Lock, /4-20 5 90353* A/R WASHER, /4 903 4 PAL NUT, /4-20 453 BULKHEAD 90295 SCREW, Hex, Whizlock, /4-20 x 5/ 9 925003 4 SCREW, Taptite, /4-20 x /2 0 5495 GROMMET, Strip 49 DASHBOARD 2 2434 2 CLIP 3 4353 LIGHT BAR ASSY. (Incl. Ref. Nos. 4, 5, & ) 4 4 2 SOCKET, Bulb 5 4 BEZEL 3 2 BULB, #5 45 LENS 45 2 HINGE, Hood 9 042 2 SPACER, Hood 20 042 2 CLIP, Hairpin 2 4350 PANEL, Side, LH, Orange 2 44350 PANEL, Side, LH, Red 22 435 PANEL, Side, RH, Orange 22 4435 PANEL, Side, RH, Red 23 4352 GRILLE, Orange 23 44352 GRILLE, Red 24 003 SPACER 25 9223 CAPSCREW, Hex, /4-20 x -/2 2 4349 HOOD, Orange 2 44349 HOOD, Red 2 5423 FITTING, Fuel 2 54930 GROMMET, Fuel Fitting Footnotes: 92354 Regent 4HP Hydro 925 54H, 4HP Hydro 9259 254H, 4HP Hydro 92593 Regent 4HP Gear TP-400-409-02-RG-SMA 92595 54G, 4HP Gear 9259 254G, 4HP Gear 92599 Regent 4HP Gear-Export 920 Regent 4HP Hydro-Export 29 920 Regent HP Gear 922 Regent HP Hydro 9229 5G, HP Gear 923 5H, HP Hydro 9235 25H, HP Hydro
Seat & Deck NOTE: Unless noted otherwise, use the standard hardware torque specification chart. 2 A-RG4202A HP Models 24 25 2 22 23 3 2 2 2 4 29 5 20 9 9 9 0 5 2 4 9 3 92354 Regent 4HP Hydro 925 54H, 4HP Hydro 9259 254H, 4HP Hydro 92593 Regent 4HP Gear 92595 54G, 4HP Gear 9259 254G, 4HP Gear 92599 Regent 4HP Gear-Export 920 Regent 4HP Hydro-Export 920 Regent HP Gear 922 Regent HP Hydro 9229 5G, HP Gear 923 5H, HP Hydro 9235 25H, HP Hydro Copyright 99 Simplicity Manufacturing, Inc. All Rights Reserved. 30 TP-400-409-02-RG-SMA
Seat & Deck REF NO. PART NO. QTY. DESCRIPTION 339 SEAT ASSY. (Incl. Seat Cover, Ref. 2) 2 442 COVER, Seat 3 3595 SLIDE, Seat 4 934 4 SCREW, Hex, Whiz, 5/- x /2 5 3594 PAN, Seat 932 2 NUT, Hex, Full, 5/- 935 2 LOCKWASHER, 5/ 435 2 BAR ASSY., Seat Pivot 9 93059 SCREW, Whiz, 5/- x 3/4 0 394 2 STOP, Seat, Rubber 43 SEAT DECK, Orange 443 SEAT DECK, Red 2 935255 2 NUT, Tinn 3 932 4 NUT, Hex, Lock, 5/- 4 4909 GUARD, Splash, Pod 5 490 CONTROL POD, Gear 4542 CONTROL POD, Hydro 900 3 SCREW, Taptite, 5/- x 5/ 000 CLAMP, Wire (Middle Bolt Only) 9 9932 3 WASHER, 5/ 20 9 3 SPACER 2 504 CAP 22 359 LEVER, Seat Latch 23 590 SPRING, Extension 24 43 2 SIDE PANEL, Seat Slide 25 9943 2 NUT, Nylock, 5/- (HP Models Only) 2 0925 2 WASHER (HP Models Only) 2 042 2 SPRING, Seat (HP Models Only) 2 5 PLATE, Spring Support (HP Models Only) 29 93335 CARRIAGE BOLT, 5/- x.0 (HP Models Only) Footnotes: 92354 Regent 4HP Hydro 925 54H, 4HP Hydro 9259 254H, 4HP Hydro 92593 Regent 4HP Gear TP-400-409-02-RG-SMA 92595 54G, 4HP Gear 9259 254G, 4HP Gear 92599 Regent 4HP Gear-Export 920 Regent 4HP Hydro-Export 3 920 Regent HP Gear 922 Regent HP Hydro 9229 5G, HP Gear 923 5H, HP Hydro 9235 25H, HP Hydro
Wheels & Tires NOTE: Unless noted otherwise, use the standard hardware torque specification chart. A-RG4203A REAR WHEELS & TIRES 2 Simplicity Models 9 3 4 5 AGCO-Allis & Massey Ferguson Models 2 0 FRONT WHEELS & TIRES Simplicity Models 5 20 20 2 22 4 5 AGCO-Allis & Massey Ferguson Models 24 3 9 23 2 92354 Regent 4HP Hydro 925 54H, 4HP Hydro 9259 254H, 4HP Hydro 92593 Regent 4HP Gear 92595 54G, 4HP Gear 9259 254G, 4HP Gear 92599 Regent 4HP Gear-Export 920 Regent 4HP Hydro-Export Copyright 99 Simplicity Manufacturing, Inc. All Rights Reserved. 920 Regent HP Gear 922 Regent HP Hydro 9229 5G, HP Gear 923 5H, HP Hydro 9235 25H, HP Hydro 32 TP-400-409-02-RG-SMA
Wheels & Tires REF NO. PART NO. QTY. DESCRIPTION 22042 2 KEY 2 3 2 REAR WHEEL & TIRE ASSY - HP Models (Includes Refs. 3, 4, & 5) 2 2 REAR WHEEL & TIRE ASSY - 4HP Models (Includes Refs. 3, 4, & 5) 3 503 2 TIRE, Turf Trac, x.50- - 4HP Models 3 33 2 TIRE, Turf Trac, 20 x.00- - HP Models 4 32 2 WHEEL, Metallic Gray,, Rear 5 2353 4 VALVE STEM & CAP 90202 0 WASHER (Qty. used on Simplicity Gear models, 4 on AGCO-Allis & Massey Ferguson Gear Models) 9 2 SPACER (Hydro Models) 5043 2 SPACER (Gear Models) 9294 2 E-RING 9 492 2 HUB CAP, -3/4 Black, Rear Scalloped (Simplicity Models) 0 904 2 WASHER (AGCO-Allis & Massey Ferguson Models) 0435 4 RETAINER, Cap (AGCO-Allis & Massey Ferguson Models) 2 59 4 CAP, Axle (AGCO-Allis & Massey Ferguson Models) 3 34 2 FRONT WHEEL & TIRE ASSY - 4HP Models (Includes Refs. 4,, & 9) 3 29 2 FRONT WHEEL & TIRE ASSY - HP Models (Includes Refs. 4,, & 9) 4 5032 2 WHEEL ASSY, Metallic Gray,, Front (Includes Refs. 5 & ) 5 3 4 BEARING 920 2 FITTING, Grease 5030 2 TIRE, 5 x.00- - 4HP Models 30 2 TIRE, 5 x.50- - HP Models 4090 2 TUBE, Tire, Front 9 0 2 KLIPRING, 3/4 20 4925 2 HUB CAP, 5-3/4, Black, Front Scalloped (Simplicity Models) Footnotes: 92354 Regent 4HP Hydro 925 54H, 4HP Hydro 9259 254H, 4HP Hydro 92593 Regent 4HP Gear TP-400-409-02-RG-SMA 92595 54G, 4HP Gear 9259 254G, 4HP Gear 92599 Regent 4HP Gear-Export 920 Regent 4HP Hydro-Export 33 920 Regent HP Gear 922 Regent HP Hydro 9229 5G, HP Gear 923 5H, HP Hydro 9235 25H, HP Hydro
09 OFF RUN START 530 Decals - Safety & Common NOTE: Unless noted otherwise, use the standard hardware torque specification chart. 2 A-RG4204A LAWN TRACTORS DRIVE BELTS & MOWER BLADES Transmission Belt Gear 5044 Hydro 235 3" Mower Drive Belt 54 Mower Blade - Left 045 Mower Blade - Right 040 44" Mower Deck Drive Belt 03 Drive Belt 02 Mower Belt 0400 3" / 44" Snowthrower Drive Belt 24 For safety and reliability, insist on genuine Simplicity Manufacturing, Inc. belts and blades...our name stamped on the part is your assurance of quality. THROTTLE Choke 2 Fast Slow To Start Engine Seat must be occupied, ground speed control pedal in neutral, PTO switch must be off, and clutch/brake pedal depressed. When Operator Leaves Seat Put ground speed control pedal in neutral, turn PTO switch off, and set parking brake. Traction Control To stop tractor motion, fully depress clutch/brake pedal. On hydrostatic drive tractors, movement of traction pedal from neutral, in either direction, increases ground speed. To Operate PTO Clutch The operator must be in seat. To engage PTO, pull PTO switch up. To disengage PTO, push PTO switch down. ROTATING BLADES CUT OFF ARMS AND LEGS STOP MOWER WHEN CHILDREN ARE NEAR. NO RIDERS THEY FALL OFF. OPERATION PTO Switch WARNING DO NOT TOW TRACTOR! Damage may result to transmission Ignition Switch Parking Brake To Set Parking Brake Pull knob UP while clutch/brake pedal is depressed. Release clutch/brake pedal while holding knob. To Release Parking Brake Depress clutch/brake pedal. Push knob DOWN while clutch/brake pedal is depressed. Mower DOWN Clutch/Brake Mower Pedal Height Adjust Mower UP AVOID SERIOUS INJURY OR DEATH Read operator's manual(s). If you cannot back up a hill, do not operate on it. Know location and function of all controls. Go up and down slopes, not across. Keep safety devices (guards, shields, and switches) If machine stops going uphill, stop blade and in place and working. back down slowly. Remove objects that could be thrown by the blade. Do not mow when children or others are around. Be sure blade(s) and engine are stopped before Never carry children. placing hands or feet near blade(s). Look down and behind before and while backing. When leaving machine, shut off engine, remove Avoid sudden turns. key, and set parking brake. DANGER DANGER OPERATING ON SLOPES CAN BE DANGEROUS SEE OPERATOR'S MANUAL. IF YOU CANNOT BACK-UP A HILL DO NOT DRIVE ON IT. 4 3 3 4 5 5 TRANSMISSION RELEASE VALVE LEVER PULL REARWARD TRACTOR MAY NOW BE MOVED BY MANUALLY PUSHING OR PULLING. DANGER DANGER ROTATING CUTTING BLADE Do not operate mower without deflector or entire grass catcher in place. 042 ROTATING CUTTING BLADE Do not put hands or feet under mower deck while blade is rotating. 042 92354 Regent 4HP Hydro 9259 254G, 4HP Gear 9229 5G, HP Gear 925 54H, 4HP Hydro 92599 Regent 4HP Gear-Export 923 5H, HP Hydro 9259 254H, 4HP Hydro 920 Regent 4HP Hydro-Export 9235 25H, HP Hydro 92593 Regent 4HP Gear 920 Regent HP Gear 92595 54G, 4HP Gear 922 Regent HP Hydro Copyright 99 Simplicity Manufacturing, Inc. All Rights Reserved. 9235 3 Mower Deck 9259 3 Mower Deck 9244 44 Mower Deck 925 44 Mower Deck 34 TP-400-409-02-RG-SMA
Decals - Safety & Common REF NO. PART NO. QTY. DESCRIPTION 3459 DECAL, Belt/Blade 2 340 DECAL, Operating Instructions 3 092 DECAL, Logo, USA 4 09 DECAL, Release Valve (Hydro only) 5 042 DECAL, Danger, Rotating Cutting Blade 042 DECAL, Danger, Chute in Place 044 DECAL, Cutting Width, 3 044 DECAL, Cutting Width, 44 * DECAL, OPEI (Not Serviced) 9 * PLATE, Manufacturing No./Serial No. (Not Serviced) 0 * DECAL, Decibel (Export only) * DECAL, CE (Export only) Footnotes: *Not a serviceable part. 92354 Regent 4HP Hydro 9259 254G, 4HP Gear 9229 5G, HP Gear 925 54H, 4HP Hydro 92599 Regent 4HP Gear-Export 923 5H, HP Hydro 9259 254H, 4HP Hydro 920 Regent 4HP Hydro-Export 9235 25H, HP Hydro 92593 Regent 4HP Gear 920 Regent HP Gear 92595 54G, 4HP Gear 922 Regent HP Hydro TP-400-409-02-RG-SMA 35 9235 3 Mower Deck 9259 3 Mower Deck 9244 44 Mower Deck 925 44 Mower Deck
Decals - Brand & Model NOTE: Unless noted otherwise, use the standard hardware torque specification chart. A-RG4205A 4 3 2 5 2 2 92354 Regent 4HP Hydro 9259 254G, 4HP Gear 9229 5G, HP Gear 925 54H, 4HP Hydro 92599 Regent 4HP Gear-Export 923 5H, HP Hydro 9259 254H, 4HP Hydro 920 Regent 4HP Hydro-Export 9235 25H, HP Hydro 92593 Regent 4HP Gear 920 Regent HP Gear 92595 54G, 4HP Gear 922 Regent HP Hydro Copyright 99 Simplicity Manufacturing, Inc. All Rights Reserved. 9235 3 Mower Deck 9259 3 Mower Deck 9244 44 Mower Deck 925 44 Mower Deck 3 TP-400-409-02-RG-SMA
Decals - Brand & Model REF NO. PART NO. QTY. DESCRIPTION 202 DECAL, Simplicity 2 090 DECAL, Touch-Up Paint 3 345 DECAL, Hood, Simplicity, LH 3 345 DECAL, Hood, Simplicity, RH 4 39 2 DECAL, Hood, Hydro 4 4 55 2 DECAL, Hood, 5-Speed 4 4 3 2 DECAL, Hood, Hydro 4 3 2 DECAL, Hood, 5-Speed 5 49 DECAL, Hood, 54H, LH 5 49 DECAL, Hood, 54H, RH 5 49 DECAL, Hood, 54G, LH 5 499 DECAL, Hood, 54G, RH 5 39 DECAL, Hood, 5H, LH 5 40 DECAL, Hood, 5H, RH 5 4 DECAL, Hood, 5G, LH 5 42 DECAL, Hood, 5G, RH 092 2 DECAL, AGCO Allis 4900 DECAL, Hood, 254H, LH 490 DECAL, Hood, 254H, RH 4902 DECAL, Hood, 254G, LH 4903 DECAL, Hood, 254G, RH 43 DECAL, Hood, 25H, LH 44 DECAL, Hood, 25H, RH 433 2 DECAL, Massey Ferguson Footnotes: 92354 Regent 4HP Hydro 9259 254G, 4HP Gear 9229 5G, HP Gear 925 54H, 4HP Hydro 92599 Regent 4HP Gear-Export 923 5H, HP Hydro 9259 254H, 4HP Hydro 920 Regent 4HP Hydro-Export 9235 25H, HP Hydro 92593 Regent 4HP Gear 920 Regent HP Gear 92595 54G, 4HP Gear 922 Regent HP Hydro TP-400-409-02-RG-SMA 3 9235 3 Mower Deck 9259 3 Mower Deck 9244 44 Mower Deck 925 44 Mower Deck
3 Mower Deck - Housing, Arbors & Blades NOTE: Unless noted otherwise, use the standard hardware torque specification chart. 29 30 3 3 35 34 33 32 3 3 4 5 5 0 2 9 A-RG420A 3 2 4 5 35 34 3 9 0 2 2 3 4 5 2 2 25 24 22 23 9 2 22 23 20 24 9235 3 Mower Deck 9259 3 Mower Deck Copyright 99 Simplicity Manufacturing, Inc. All Rights Reserved. 3 TP-400-409-02-RG-SMA
3 Mower Deck - Housing, Arbors & Blades REF NO. PART NO. QTY. DESCRIPTION 449 2 NUT, Hex, Flange, 9/- 2 35 4 WASHER, Belleville 3 30 PULLEY, LH 4 92332 LOCKNUT, 5/- 5 3 2 HUB 399 2 COVER, Arbor Housing 059 4 BEARING 3204 2 SPACER 9 0335 2 GASKET, Foam 0 333 2 ARBOR HOUSING ASSY. (Incl. Fitting Ref. ) 0434 2 FITTING, Grease 2 432 BELT STOP, LH 3 932 4 NUT, Hex, 5/- 4 935 4 LOCKWASHER, 5/ 5 924940 4 WASHER, Flat, 3/ 93000 5 SCREW, Taptite, 5/- x -/2 39 2 WASHER 32 2 SHAFT, Arbor 9 39 2 SHIELD, Grass, Lower 20 045 BLADE, Mower, -/ 2 040 BLADE, Mower, 22-/4 22 309 2 WASHER, Hex 23 59 2 WASHER, Spring 24 92349 2 CAPSCREW, Hex, Hd., /-4 x 25 44 SCREW, Taptite, 5/- x 3/4 2 MOWER DECK HOUSING, 3, Orange 2 MOWER DECK HOUSING, 3, Black 2 933 2 CARRIAGE BOLT, /4-20 x / 2 05449 DEFLECTOR, Plastic 29 905 NUT, Push 30 90353 2 WASHER, Plain 3 043 CLAMP 32 9932 WASHER, Plain, 5/ 33 0500 SPRING 34 994 2 LOCKWASHER, /4 35 922 2 NUT, Hex, /4-20, Unc 3 009 ROD, Deflector, Front 3 434 PULLEY, RH 3 4322 BELT STOP, RH Footnotes: 9235 3 Mower Deck 9259 3 Mower Deck TP-400-409-02-RG-SMA 39
3 Mower Deck - Clutch & Support NOTE: Unless noted otherwise, use the standard hardware torque specification chart. A-RG420A 2 3 4 2 0 5 9 Hook Spring (Ref ) to capscrew when assembled. 9 20 2 5 4 3 2 0 Hook Spring (Ref 20) here when assembled. 9235 3 Mower Deck 9259 3 Mower Deck Copyright 99 Simplicity Manufacturing, Inc. All Rights Reserved. 40 TP-400-409-02-RG-SMA
3 Mower Deck - Clutch & Support REF NO. PART NO. QTY. DESCRIPTION 54 V-BELT 2 90339 2 NUT, Hex, Centerlock, 3/- 3 92255 WASHER, Plain 4 550 PULLEY, Idler 5 553 HUB, Insert 490 ARM, Clutch 5435 SPRING 929 CAPSCREW, Hex Hd., 3/- x -3/4 9 4255 SPACER, Idler Arm 0 92435 2 WASHER 92205 CAPSCREW, 3/- x -/4 2 99439 2 NUT, Hex, Lock, 3/- 3 924940 2 WASHER, Plain, 3/ I.D. 4 50 2 SPACER 5 35 HITCH 35 ROD, Mower Hitch 559 ROD, Latch 90093 2 NUT, Push, 3/ 9 9059 NUT, Push, /2 20 0 SPRING 2 9299 2 CAPSCREW, Hex, 3/- x -/2 Footnotes: 9235 3 Mower Deck 9259 3 Mower Deck TP-400-409-02-RG-SMA 4
3 Mower Deck - Height Adjustment Rollers NOTE: Unless noted otherwise, use the standard hardware torque specification chart. A-RG420A 3 4 5 9 2 3 4 0 2 5 24 25 9 20 2 22 23 42 43 2 9 4 40 2 2 2 4 29 3 4 30 39 3 3 3 3 32 35 33 34 9235 3 Mower Deck 9259 3 Mower Deck Copyright 99 Simplicity Manufacturing, Inc. All Rights Reserved. 42 TP-400-409-02-RG-SMA
3 Mower Deck - Height Adjustment Rollers REF NO. PART NO. QTY. DESCRIPTION 44 SCREW, Taptite, 5/ x 3/4 2 490 UP-STOP 3 929 2 CAPSCREW, 5/- x -/4 4 90044 WASHER 5 9004 SPRING, Clip 4529 ROD, Transport 003 2 SPACER 9002 4 WASHER, /2 9 92332 4 NUT, Lock, 5/- 0 4553 U-BRACKET 90223 CARRIAGE BOLT, 5/- x -/4 2 29 ARM, Rear 3 4 GRIP 4 454 ADJUSTMENT ARM 5 93353 CARRIAGE BOLT, 3/- x -3/4 432 ROCKER ARM ASSY. 423 SPRING 93045 2 NUT, Flange Lock, 3/ 9 534 STRAP 20 49 ECCENTRIC 2 9244 WASHER, Flat, 5/ 22 935 LOCKWASHER, 5/ 23 932 NUT, 5/- 24 9950 NUT, Hex, 3/ 25 995 LOCKWASHER, 3/ 2 0402 NUT, Adjuster 2 9023 4 SPACER 2 4 2 ARM ASSY. 29 92333 2 CAPSCREW, 5/- x 30 9033 2 SCREW, Taptite, 5/- x 3 902 2 PIN 32 9022 2 CLIP, Hair 33 40 5 GAUGE WHEEL 34 5399 4 E-RING, /2 35 4 2 ARM ASSY., Adjustable 3 42 SHAFT, Gauge Wheel 3 4 BRACKET, Gauge Wheel 3 924940 4 WASHER, Flat, 3/ 39 05 SPACER 40 5024 SPACER 4 9230 CAPSCREW, 3/- x -/4 42 43 ARM, Pitch 43 93352 CARRIAGE BOLT, 3/- x -/2 Footnotes: 9235 3 Mower Deck 9259 3 Mower Deck TP-400-409-02-RG-SMA 43
44 Mower Deck - Housing, Arbors & Blades NOTE: Unless noted otherwise, use the standard hardware torque specification chart. Torque nuts to 50-0 ft. lbs. A-RG4209A 2 5 3 2 Apply gasket former to this surface if foam gasket (Ref.0) is not used. 5 9 3 4 0 9 5 35 32 2 29 3 32 33 30 3 34 2 25 2 Apply gasket former to this surface if foam gasket (Ref. 0) is not used. 2 0 3 4 2 2 25 4 24 23 5 22 4 5 9 20 2 Torque capscrews to 50-0 ft. lbs. 9 20 2 9244 44 Mower Deck 925 44 Mower Deck Copyright 99 Simplicity Manufacturing, Inc. All Rights Reserved. 44 TP-400-409-02-RG-SMA
44 Mower Deck - Housing, Arbors & Blades REF NO. PART NO. QTY. DESCRIPTION 449 3 NUT, Hex, Flange, 9/- 2 35 WASHER, Belleville 3 3 3 PULLEY 4 3 HUB, Adapter 5 5529 3 COVER, Arbor Housing 0202 3 BEARING 524 3 SPACER 523 3 SPACER 9 059 3 BEARING 0 0335 3 GASKET, Foam 333 3 ARBOR HOUSING ASSY. (Incl. Fitting Ref. 2) 2 0434 3 FITTING, Grease 3 0433 COVER, Arbor 4 44 SCREW, Hex, Taptite, 5/- x 3/4 5 39 3 WASHER 32 SHAFT, Arbor (LH) 39 3 SHIELD, Grass, Lower 0400 3 BLADE, Mower, -/ 9 309 3 WASHER, Hex 20 59 3 WASHER, Spring 2 92349 3 CAPSCREW, Hex, Hd., /-4 x 22 309 2 SHAFT, Arbor (Center & RH) 23 MOWER HOUSING ASSY., Mower (Orange) 23 MOWER HOUSING ASSY., Mower (Black) 24 53 COVER, Arbor 25 933 2 CARRIAGE BOLT, /4-20 x / 2 905 2 NUT, Push On 2 90353 2 WASHER, Plain 2 043 CLAMP 29 9932 WASHER, Plain, 5/ 30 0500 SPRING 3 994 2 LOCKWASHER, /4 32 922 2 NUT, Hex, /4-20 33 009 ROD, Deflector, Front 34 055 PLUG, Hole 35 05449 DEFLECTOR, Plastic 3 33 HUB, Pulley Footnotes: 9244 44 Mower Deck 925 44 Mower Deck TP-400-409-02-RG-SMA 45
44 Mower Deck - Clutch & Support NOTE: Unless noted otherwise, use the standard hardware torque specification chart. A-RG4200A Arbor Drive Pulley Arbor Drive Pulley 2 3 2 4 Engine Pulley Adjustable Idler Pulley Arbor Drive Pulley 3 5 4 0 9 25 24 20 23 9 3 5 Hook Spring (Ref 25) here when assembled. 22 2 9244 44 Mower Deck 925 44 Mower Deck Copyright 99 Simplicity Manufacturing, Inc. All Rights Reserved. 4 TP-400-409-02-RG-SMA
44 Mower Deck - Clutch & Support REF NO. PART NO. QTY. DESCRIPTION 54 V-BELT 2 92230 CAPSCREW, Hex Hd., 3/- x 2-/4 3 924940 WASHER, 3/ 4 550 PULLEY ASSEMBLY 5 553 HUB, Insert 535 GRIP, Lever 54 ARM, Idler 995 LOCKWASHER, Spring, 3/ 9 9950 NUT, Hex, 3/- 0 93045 NUT, Hex Flange Lock, 3/- 52 SPRING 2 90339 NUT, Hex, Center Lock, 3/- 3 92435 2 WASHER 4 4255 SPACER, Idler Arm 5 92205 CAPSCREW, 3/- x -/4 9299 2 CAPSCREW, Hex, 3/- x -/2 924940 2 WASHER, 3/ 50 2 SPACER 9 9934 WASHER 20 99439 2 NUT, Hex Lock, 3/- 2 35 ROD, Mower Hitch 22 559 ROD, Latch 23 35 HITCH 24 9059 NUT, Push, /2 25 5302 SPRING Footnotes: 9244 44 Mower Deck 925 44 Mower Deck TP-400-409-02-RG-SMA 4
44 Mower Deck - Height Adjustment & Rollers NOTE: Unless noted otherwise, use the standard hardware torque specification chart. A-RG420A 2 3 4 5 2 4 9 3 4 20 5 2 0 22 23 24 9 25 2 2 4 2 29 30 4 3 4 43 29 30 4 45 44 43 39 40 3 3 35 34 33 32 42 4 34 33 34 3 32 9244 44 Mower Deck 925 44 Mower Deck Copyright 99 Simplicity Manufacturing, Inc. All Rights Reserved. 4 TP-400-409-02-RG-SMA
44 Mower Deck - Height Adjustment & Rollers REF NO. PART NO. QTY. DESCRIPTION 44 CAPSCREW, Hex Hd, Taptite, 5/ x 3/4 2 555 BRACKET, Upstop 3 929 2 CAPSCREW, 5/- x -/4 4 90044 WASHER, 5/ 5 4553 BRACKET, U 003 2 SPACER 92332 4 NUT, Hex Lock, 5/- 9004 SPRING CLIP 9 4529 ROD, Transport 0 509 ARM, Rear 90223 CARRIAGE BOLT, 5/- x -/4 2 4 GRIP 3 454 ARM, Adjustment 4 93353 CARRIAGE BOLT, 3/- x -3/4 5 423 SPRING 93045 2 NUT, Hex Flange Lock, 3/- 932 2 NUT, Hex, 5/- 935 2 LOCKWASHER, 5/ 9 92332 CAPSCREW, Hex Hd, 5/- x 3/4 20 50 QUADRANT BRACKET, Mower Height Adjust 2 5 ARM ASSEMBLY, Rocker 22 534 2 STRAP 23 49 ECCENTRIC 24 9244 WASHER 25 9950 NUT, Hex, 3/ 2 995 WASHER, Lock, 3/ 2 0402 NUT, Adjuster 2 93352 CARRIAGE BOLT, 3/- x -/2 29 9033 4 CAPSCREW, Hex Hd, Taptite 5/- x.0 30 9023 4 SPACER 3 92333 2 CAPSCREW, 5/- x.0 32 5399 4 E-RING, /2 33 9002 4 WASHER, /2 34 40 5 WHEEL, Gauge 35 4 2 ARM ASSEMBLY 3 902 2 PIN 3 9022 2 CLIP, Hairpin 3 4 2 ARM ASSEMBLY, Adjustable 39 50 2 STRAP 40 4 BRACKET, Gauge Wheel 4 524 ROD, Mower Hitch 42 9059 NUT, Push, /2 43 924940 4 WASHER, 3/ 44 05 SPACER 45 52 ARM, Pitch 4 2 SPACER 4 9230 CAPSCREW, 3/- x -/4 Footnotes: 9244 44 Mower Deck 925 44 Mower Deck TP-400-409-02-RG-SMA 49
Part Number Index by Page Number Part No. Page No Ref No. Part No. Page No Ref No. Part No. Page No Ref No. Part No. Page No Ref No. Part No. Page No Ref No. * * * 34 * 34 9 * 34 0 * 34 0025 24 4 0 40 20 0202 44 0209 22023 24 20 22023 2 5302 0 3 5302 4 25 504 0 0 50 40 4 50 4 52 5399 42 34 5399 4 32 590 30 23 50 0 5 50 0 24 45 2353 32 5 2434 2 2 320 3 3 45 5 440 2 2 440 4 2 30229A 2 0 02 2 3 244 2 49 2 4 4942 2 4 394 2 395 2 4 39 2 409 2 5 309 2 2 32A 2 5 32 2 3 32 2 4 330 2 333 2 2 334 2 33 2 3 345 2 0 34 2 53 349 2 59 350 2 52 35 2 5 352 2 5 353 2 5 354 2 50 355 2 5 35 2 49 34 2 35 2 A 000 2 3 002 2 29 00A 2 2 0090 2 00 2 30 040 2 3 00 2 29A 05 2 29B 09 2 5 093 2 35 094 2 34 095 2 3A 09 2 35A 4352 2 9 43 2 0 02 2 39 0 2 45 0 2 3 02 2 4 04 2 5 0 2 4 02 2 39 2 2 0 040 2 2 0A 2 03 2 32 0 2 5 09 2 09 2 2A 092 2 B 093 2 50 9000 2 3 9009 2 4 90025 2 44 9005 2 3 92035 2 2 9203A 2 25 9203A 2 42 9205 2 43 920A 2 40 920 2 20 920 2 2 9209 2 22 9205A 2 42A 9225 2 2 923A 2 9254 2 5 925 2 2 920 2 9 92 2 25A 9902 2 3 90523 0 920 32 9950 34 92042 33 9233 29 9203 2 9294 32 93059 93059 3 9324 24 9324 2 4 9343 24 9 9343 2 5 90202 32 903 3 9055 3 9055 3 90554 30 03 24 3 03 2 32 05 42 39 05 4 44 0 4 4 0 32 9 500 30 5423 2 2 5434 24 2 54930 2 2 5529 44 5 59 3 23 59 44 20 5044 34 2 34 0 3 34 4090 32 44 4 2 44 2 44 3 25 44 42 44 44 4 44 4 523 24 24 523 2 20 523 24 2 523 2 22 534 42 9 534 4 22 535 4 00 4 2 294 2 294 9 3 9 30 20 9 32 2 4 4 202 3 235 59 32 2 25 2 9 3 3 29 24 3 29 2 33 3 2 34 0 550 40 4 550 4 4 525 24 525 2 5290 24 2 5290 2 23 3 2 3 4 44 23 99 4 00 4 0435 32 0344 24 23 0344 2 9 0350 4 29 0399 24 2 0399 2 24 03900 3 0402 42 2 0402 4 2 0400 44 040 3 2 042 34 5 042 34 0434 3 0434 44 2 0434 24 32 0434 2 2 0435 2 3 0433 44 3 0439 24 0439 2 2 0449 0 044 34 044 34 045 24 5 045 2 5 0453 24 0453 2 042 2 9 042 2 20 042 30 2 045 3 20 043 3 3 043 44 2 0500 3 33 0500 44 30 055 44 34 0524 9 05249 05449 3 2 05449 44 35 059 3 059 44 9 03 20 04 20 2 05 20 3 009 3 3 009 44 33 029 0 029 2 0335 3 9 0335 44 0 03 0933 43 000 30 0352 0 22 0352 0405 32 053 4 053 2 09 34 4 092 3 092 34 3 090 3 2 0909 0925 30 2 092 09 40 0990 2 0990 20 4 0990 20 5 099 20 4 0995 20 099 20 0999 20 0992 20 9 09922 20 0 043 4 24 003 2 24 003 42 003 4 309 3 22 309 44 9 30 3 3 3 44 3 3 32 5 39 3 9 39 44 399 3 3204 3 3322 3 333 3 0 333 44 335 4 333 2 3400 2 5 342 29 3429 3 343 3432 0 30 3432 3 Copyright 99 Simplicity Manufacturing, Inc. All Rights Reserved. 50 TP-400-409-02-RG-SMA