Tech Spec IC-8-F 2-WHEE DRIVE * Capacity n utriggers...18, lbs. * Pick and carry capacity up t...11,7 lbs. * Height...7 3 * Width...6 6 * Sheave height...up t 46 * Hrizntal Reach...up t 4 * Tight turning radius * 2-Wheel drive standard * 4-Wheel steer standard * 4-Wheel drive ptinal * Pwershift transmissin * Fully hydraulic cntrls fr smth precise peratins * Independent utrigger cntrls
Tech Spec 4-Wheel Drive 4-Wheel Steer * Capacity n utriggers...18, lbs. * Pick and carry capacity up t...11,7 lbs. * Height...7 3 * Width...6 6 * Sheave height...up t 46 * Hrizntal Reach...up t 4 * Tight turning radius...11 8 * 4-Speed synchrmesh transmissin * Independent utrigger cntrls * 4-Wheel hydraulic internal wet disc brakes
M A I N B O O M 1 ' B O O M E X T. 3 6 7 3 6 7 IC-8-1F IC 8 1F 8 2" 2 2" BOOM CAPACITIES APPY TO OPERATION ON FIRM EVE SURFACE MAIN BOOM OR EXTENSION CAPACITIES IN POUNDS 36 ROTATION OVER FRONT OAD RADIUS 5 6 8 1 12 14 16 18 2 22 24 26 28 3 BOOM EXTENSION * FEET ANGE 3 96 79 575 4 17 1 125 77 31 655 2425 555 1975 465 1625 395 14 355 1275 3 175 275 925 2 775 2 675 195 117 14 84 63 465 365 3 25 2 19 165 1425 18 1 125 77 655 555 465 4 38 3 28 26 125 24 11 225 1-FOOT BOOM EXTENSION - STRAIGHT OR OFFSET MAIN BOOM ANGE 225 3 26 24 225 32 27 25 6 5 35 3 7 7 42 33 28'-2" 22'-6" 16'-11" 7 1'-4 3/4" * USE FOR STRAIGHT BOOM EXTENSION. USE, OR 3 FOR OFFSET BOOM EXTENSION. BOOM EXTENSION OADS MUST NOT EXCEED MAIN BOOM CAPACITY. 3 7/16" 11 1/2" 11'-7 1/2" 36 USE SINGE PART OAD INE FOR OADS TO 9 (WT. 9) 41 USE TWO PART OADINE FOR OADS TO 18 (WT. 124) 5'-9 1/2" 5'-1" 57 1/8" 37' 36' 7 6 6'-6" 9'-7" 34' 18 1/2" 12" 32' 3' 9" 28' 26' 24' 22' 2' 3 C OAD 2'-2" EXTENDED 8'-2" RETRACTED C ROTATION 26 3/4" 18' 16' 14' 12' 1' 22 7'-3" 5'-8 3/4" 3'-5" 21 8' 6' 1" C 4' 6' 8' 1' 12' 14' 16' 18' 2' 22' 24' 26' 28' 3' RADIUS IN FEET FROM C ROTATION TO OAD 1'-7" 3'-6 3/4" 3'- 1/4" 7'- 3/4" 12'-9 1/2" 2'-8 1/2"
M A I N B O O M 1 ' B O O M E X T. 3 4 5 6 7 1 5 3 6 7 IC-8-2F IC-8-2F 9'-6" - 24'-" BOOM CAPACITIES APPY TO OPERATION ON FIRM EVE SURFACE MAIN BOOM OR EXTENSION CAPACITIES IN POUNDS 36 ROTATION OVER FRONT OAD RADIUS FEET 5 6 8 1 12 14 16 18 2 22 24 26 28 3 32 34 BOOM EXTENSION ANGE * 3 95 78 55 39 29 23 185 5 13 11 925 85 7 6 5 425 17 1 125 77 655 555 5 395 325 2875 2475 225 2 1775 1625 14 116 12 825 62 5 355 285 24 25 175 5 135 1175 125 9 8 18 1 125 77 655 555 5 365 33 31 275 25 23 21 195 1-FOOT BOOM EXTENSION - STRAIGHT OR OFFSET MAIN BOOM ANGE 3 6 7 225 26 24 32 27 5 35 7 42 225 25 3 33 31'-9" 25'-" 18'-2" 7 1'-4 3/4" * USE FOR STRAIGHT BOOM EXTENSION. USE, OR 3 FOR OFFSET BOOM EXTENSION. BOOM EXTENSION OADS MUST NOT EXCEED MAIN BOOM CAPACITY. 5'-1 3/4" 11 1/2" 36 USE SINGE PART OAD INE FOR OADS TO 9 (WT. 9) 41 USE TWO PART OADINE FOR OADS TO 18 (WT. 124) 3 7/16" 11'-7 1/2" 5'-9 1/2" 5'-1" 4' 1" 4' 38' 36' 34' 32' 3' 7 6 18 1/2" 12" 57 1/8" 6'-6" 9'-7" 28' 26' 24' 22' 2' 3 C OAD 9" 24'-" EXTENDED 9'-6" RETRACTED C ROTATION 26 3/4" 18' 16' 14' 7'-3" 5'-8 3/4" 12' 3'-5" 1' 22 21 8' 6' 1" C 4' 6' 8' 1' 12' 14' 16' 18' 2' 22' 24' 26' 28' 3' 32' 34' RADIUS IN FEET FROM C ROTATION TO OAD 2'-11" 3'- 1/4" 3'-6 3/4" 7'- 3/4" 12'-9 1/2" 2'-8 1/2"
M A I N B O O M 1 ' B O O M E X T. 3 6 7 3 6 7 IC-8-3F IC-8-3F 11'-6" - 3'-" BOOM * CAPACITIES APPY TO OPERATION ON FIRM EVE SURFACE MAIN BOOM OR EXTENSION CAPACITIES IN POUNDS 36 ROTATION OVER FRONT OAD RADIUS FEET 5 6 8 1 12 14 16 18 2 22 24 26 28 94 755 525 36 265 25 16 125 85 75 65 55 3 32 34 36 35 25 2 38 4 1 BOOM EXTENSION ANGE * 3 225 3 26 24 225 17 14 1 77 61 52 44 365 35 265 23 25 185 165 5 14 125 11 1 32 27 25 114 1 81 61 4 34 27 22 18 5 135 1 1 75 65 55 4 6 5 35 3 18 14 1 77 61 52 44 39 34 35 28 255 235 9 2 195 18 165 14 1-FOOT BOOM EXTENSION - STRAIGHT OR OFFSET MAIN BOOM ANGE USE FOR STRAIGHT BOOM EXTENSION. USE, OR 3 FOR OFFSET BOOM EXTENSION. BOOM EXTENSION OADS MUST NOT EXCEED MAIN BOOM CAPACITY. 7 7 42 33 37'-5" 28'-9" 2'-" 7 1'-4 3/4" 5'-1 3/4" 36 USE SINGE PART OAD INE FOR OADS TO 9 (WT. 9) 41 USE TWO PART OADINE FOR OADS TO 18 (WT. 124) 3 7/16" 11 1/2" 46' 4" 46' 44' 42' 4' 38' 36' 34' 32' 3' 28' 26' 24' 22' 2' 18' 16' 14' 12' 1' 8' 6' 1" C 4' 7 6 3 6' 8' 1' 12' 14' 16' 18' 2' 22' 24' 26' 28' 3' 32' 34' 36' 38' 4' RADIUS IN FEET FROM C ROTATION TO OAD 18 1/2" C OAD 12" 4'-11" 3'-" EXTENDED 11'-6" RETRACTED 22 9" 3'- 1/4" 5'-9 1/2" 3'-6 3/4" 11'-7 1/2" C ROTATION 7'- 3/4" 12'-9 1/2" 57 1/8" 26 3/4" 5'-1" 6'-6" 9'-7" 7'-3" 5'-8 3/4" 3'-5" 21 2'-8 1/2"
IC-8-F GENERA: Weight: IC-8-1F IC-8-2F IC-8-3F 4-Wheel Steer,73 lbs.,93 lbs. 16,23 lbs. 4-Wheel Drive 16,43 lbs. 16,63 lbs. 16,93 lbs. Bm Mvement: Rtatin Cntinuus Cntinuus Cntinuus Elevatin º t 7º º t 7º º t 7º Extensin 12 ft. 14 ft. 6 in. 18 ft. 6 in. Bm Speeds: Rtatin 2. RPM 2. RPM 2. RPM Elevatin 1. sec. 1. sec. 1. sec. Extensin 17. sec. 21. sec. 27. sec. Turning Radius: Standard Optinal (C/ f Outside 4-Wheel Steer 4-Wheel Drive Steering Wheel) 1 ft. 9 in. 11 ft. 8 in. Aisle Width fr 9º Turn: 9 ft. 7 in. 9 ft. 9 in. ENGINE: Standard Optinal Make GM Cummins Mdel 3. EFI* 4B3.9 Type Gas Diesel N. Cyl. 4 4 Displacement 181 CID 239 CID HP @ Gv. Speed 69 8 Fuel Tank Capacity: 2 Gallns * Electrnic Fuel Injectin with Dual Fuel TRANSMISSION: 2-Wheel Drive: Pwershift transmissin with 4-speeds in frward and reverse. Prvides pwershifts at any engine speed in any gear. All shifting is dne with a single lever electrical cntrl munted n the steering clumn. Multiple-disc clutch packs perated by slenid valve prvide frward, neutral, reverse & speed selectin. Equipped with il cler and filter. Trque cnverter has stall rati f 2.2:1. Gradeability 7 percent. Frward/Reverse Travel Drawbar Gear Gear Ratis Speed Pull First 5.72:1 4 MPH 1,9 lbs. Secnd 3.23:1 7 MPH 6,9 lbs. Third 1.77:1 12 MPH 3,27 lbs. Furth 1.:1 22 MPH 1,78 lbs. TRANSMISSION: (Cnt d) 4-Wheel Drive: Remte munted synchrmesh 4-speed. Frward, neutral and reverse cntrl munted n steering clumn. 4-speed cntrl has side lever & push buttn knb fr electric declutching. Can be shifted while in mtin. Equipped with il cler and filter. Trque cnverter has stall rati f 2.2:1. Gradeability 72 percent. Frward/Reverse Travel Drawbar Gear Gear Ratis Speed Pull First 4.29:1 5 MPH 11,5 lbs. Secnd 2.66:1 8 MPH 7,7 lbs. Third 1.41:1 MPH 3,67 lbs. Furth.77:1 27 MPH 1,93 lbs. AXES: Frnt: Planetary drive/steer axle with 11.98:1 rati. Differential is imited Slip. Axle munted rigidly t frame. Rear: 2-Wheel Drive: Axle with 1-1/2 degree scillatin in either directin. 4-Wheel Drive: Planetary drive/steer axle with 11.98:1 rati. Differential is imited Slip. 1-1/2 degree scillatin in either directin. STEERING: Hydraulic steering unit with tw cylinders attached t each axle. Rear axle is the primary steer. An electric switch in the peratr s cmpartment is used t select rear-wheel steering r fur-wheel rund steering. BRAKES: 2-Wheel Drive 4-Wheel Drive Frnt Internal wet Internal wet disc brakes disc brakes Rear Drum type Internal wet disc brakes Parking Disc type Disc type TIRES: 2-Wheel Drive 1. x, lad range J radial, highway type tread. 4-Wheel Drive 1. X, mining & industrial, 16 ply rating.
Tech Spec CHASSIS: Carg Deck: 64 square feet f deck area.* 14, lbs. capacity n deck when lad is centered ver r between axles.** A strage bx is lcated in frnt carg deck. Steps lcated n frnt crners. * 54 Square feet with Cummins engine. **14, punds allwed at creep speed f 2 feet in 3 minutes. Outriggers: Fur hydraulic utriggers f bx beam cnstructin with direct-cnnected hlding valves. Independent cntrls fr each utrigger. Each cylinder equipped with direct-cnnected hlding valves. Outrigger pad dimensin 9 x 12. Accessry Strage Bx: Strage bx lcated in frnt carg deck. ifting Rings ifting rings at each crner f carg deck s sling can be attached fr lifting crane. OPERATOR COMPARTMENT: Operatr s cntrl statin prvides ne-psitin access t all perating functins. Includes adjustable peratr s seat, retracting seat belt, fire extinguisher and bubble level. EECTRICA: 12 Vlt System Instrument Package: Fuel, ammeter, il pressure, water temperature, transmissin il temperature gauges & hurmeter. Als included are warning lights fr lw transmissin pressure, turn signal, high beams, hazard lights, parking brake & 4-wheel drive. ighting Package: One pair headlights with Hi and w beams, back-up lights, integral tail, brake, frnt and rear turn signals & emergency flasher switch at peratr s statin. 12V hrn actuated by buttn n shifting cntrl. EECTRICA: (Cnt d) Back-Up Alarm: Prvides pulsating sund frm 97 db alarm when transmissin is in reverse. Cnfrms t SAE J994b. Outrigger Alarm System Tw-tne alarm is activated when utrigger dwn cntrls are perated. HYDRAUIC SYSTEM: Tandem pump, direct-driven by engine crankshaft, rated at 17 & 32 GPM at rated RPM. Hydraulic il tank capacity f 22 gallns. BOOM ASSEMBY: Three-sectin bm assembly equipped with bearing pads, duble-acting hydraulic cylinders with direct-cnnected hlding valves & bm angle indicatr n each side f bm. Bm Rtatin: Heavy-duty ball bearing rtatin gear with external teeth. Rtatin is pwered by hydraulic mtr and wrm gear drive. Bm Hist: Turret munted planetary gear hist hydraulically pwered with a bare drum line pull f 1, lbs. at a line speed f 11 FPM. Includes dwnhaul weight, swivel hk & sheave blck fr 2-part line and 125 ft. f 9/16 hist rpe. Anti-Tw-Blck Device: Prevents damage t hist rpe and/r crane cmpnents frm pulling lad hk against tip. Sheave Blck, Tw-Part: Single sheave blck fr 2-part line requirements. Rated Capacity imiter: Warns peratr f impending verlad with audible and visual signals. Prevents verlad by stpping bm functins that cause verlads.
IC-8-F isted belw are brief descriptins f each ptin available fr the IC-8-F Industrial Cranes. Cnsult the IC-8-F Engineering Spec fr additinal infrmatin n each ptin. MODES: IC-8-1F Industrial Crane with 8 2-2 2 Bm IC-8-2F Industrial Crane with 9 6-24 Bm IC-8-3F Industrial Crane with 11 6-3 Bm ENGINE: Diesel Engine Cummins - 4B3.9 Spark Arrester Muffler Installed in additin t std. muffler. Catalytic Cnverter Reduces engine emissins. Engine Heater Engine clant heater installed t circulate warm water thrugh engine. Plugs int 12 vlt AC. Ether Injectin System Ether starting aid cntrlled by switch in peratr cmpartment and injects ether directly int intake manifld. Engine Shut Dwn Gauges Shuts engine ff when high water temperature r lw engine il pressure ccurs. (Diesel Only) AXE & STEERING OPTIONS: 4-Wheel Steer & 4-Wheel Drive TIRE OPTIONS: Mining & Industrial Tires 1. x, 16-Ply Rating 1. x, Nn Marking Slid Rubber Tires: 8.25 x 8.25 x Nn-Marking Fam Filling f Tires Spare Tire & Wheel Highway Tread, 1. x Mining & Industrial, 1. x Mining & Industrial, Nn Marking CHASSIS OPTIONS: Auxiliary Winch Munted behind frnt bumper, hydraulically driven with cntrl in peratr s cnsle. CHASSIS OPTIONS: (Cnt d) Pintle Hk: Pintle Hk, Rear Pintle Hk, Frnt Headlight and Taillight Grilles Welded steel prtective grilles fr headlights and taillights. Rear Wrk ight Grilles Prtective grilles fr wrklights. Rearview Mirrrs One munted n right-hand deck stake & ne munted n left-hand deck stake. OPERATOR COMPARTMENT OPTIONS: Operatr Guard Tubular steel weldment with heavy expanded steel mesh tp sectin. Operatr Guard Cver Clear vinyl cver which ges ver Operatr Guard, fr inclement weather peratins. Operatr Guard Dr Hinged dr cvers peratr cmpartment side pening. All-Weather Cab Rigid-munted canpy sectin & remvable hinged dr. Includes heater, electric windshield wiper, ne sliding glass windw in the dr & ne in the right side f canpy. Defrster fan & dme light included. Cab Heater Heater with tw-speed fan fr units withut All Weather Cab. Windshield Washer Includes reservir pump and nzzle. Flr Mat Vinyl mat with fam backing. Operatr Suspensin Seat Prvides additinal peratr cmfrt. Nise Reductin Kit Includes flr mat, cntrl valve and side panels f fam backed vinyl fr nise reductin. Air Cnditining Air Cnditiner with R134 clant. EECTRICA OPTIONS: Strbe ights Yellw strbe light munted n each side f turret weight bx. Amber Rtating Beacns Amber rtating beacn munted n each side f turret weight bx. Bm Wrk ights One wrk light munted t bm t light bm tip and ne wrk light munted t turret t light grund under bm tip. Wrk ights-rear Tw wrk lights recessed in rear bumper. BOOM ATTACHMENTS: Bm Extensin, 1 Ft Bm stwable. Bm Extensin, 1 Ft, Offsettable Same as abve item, except the bm extensin is ffsettable t 3 different psitins; degrees (inline), degrees and 3 degrees ffset. Searcher Hk: Nse Munt Shuld yu, as an end user, require an ptin r special equipment n yur IC-8-F that is nt listed n ur sales literature, please cntact yur dealer salespersn r the factry t receive a special quted price. Cpyright 23 Brdersn Manufacturing Crp. Specificatins Subject t Change Frm #CC13F (12/2)