Illustrated Parts List Hydrostatic Lawn Tractor IMPORTANT: Read safety rules and instructions carefully before operating equipment. Warning: This unit is equipped with an internal combustion engine and should not be used on or near any unimproved forestcovered, brush-covered or grass-covered land unless the engine s exhaust system is equipped with a spark arrester meeting applicable local or state laws (if any). If a spark arrester is used, it should be maintained in effective working order by the operator. In the State of California the above is required by law (Section of the California Public Resources Code). Other states may have similar laws. Federal laws apply on federal lands. A spark arrester for the muffler is available through your nearest engine authorized service dealer or contact the service department, P.O. Box 3 Cleveland, Ohio -00. PRINTED IN U.S.A. MTD LLC, P.O. BOX 3 CLEVELAND, OHIO -00 FORM 0-05B.fm (/00)
SECTION : PARTS LIST FOR MODELS ZH & TH 0 3 3 3 0 REF. PART. 0-0 Self-tapping Screw, #- x.50. 0-05 Self-tapping Screw, /-0 x.50 3. -0 AB Screw 5/- x 0.5. 0-3 Screw, #0-3 x. 5. 0-A Socket Cap Screw, 5/- x.. 0- TT Screw 3/- x.0. - Hex Nut 3/-. -0 Sealant. -00 Exhaust Gasket 0. -03 Foam. -005 Hose Clamp. 3-0 Lock Washer. 3-00 Flat Washer. 5B35 Casing Clamp. 5-0535 Fuel Line Hose. 5-05 Deflector: Muffler. 5-0 Muffler: Dual Inlet. 5-050 Exhaust Pipe RH 0. 5-05 Exhaust Pipe LH. 5- Oil Drain. 5-3 Hose: Oil Drain Extension 3. 5-3 Oil Drain Cap. 3-0B Heat Shield: Muffler. 3-0C Heat Shield 5 NOTE: For painted parts, please refer to the list of color codes below. Please add the applicable color code, wherever needed, to the part number to order a replacement part. For instance, if a part numbered 00-xxxx is painted Yard-Man Green, the part number to order would be 00- xxxx-05. Yard-Man Green: 05 Yard-Man Yellow: 0 Powder Black: 03 5
0 3 3 35 3 3 3 0 3 3 0 3
REF. PART 0- Hex Cap Screw, /-0 x.5 0-05 Self-tapping Screw, /-0 x.5 3-0 Hex Nut, /-0 0-05 Self-tapping Screw, /- x.5 5 0-0 Pan Phillips Screw, /-0 x.5 0-05 Hex Cap Screw, 5/- x. -0 U-type Speed Nut, /-0-0A Flange Lock Nut, 5/- -00 Speed Nut 0 - Hood Latch Rod 3- RH Head Light Lens 3- LH Head Light Lens -A Hood Support Rod 3-0A Hood 3-C LH Side Panel 3-C RH Side Panel 3-03 Lock Washer, / 3-03 Flat Washer,.3 x.5 x.0 3-03 Flat Washer,. x. x.03 3- Flat Washer,.3 x.0 x.03 0 0-0 Self-tapping Screw, /-0 x 0.5 3-00A Hood Heat Shield w/o Intake Bellow 0-0 AB Screw, 5/- x.5 3 0-05 Self-tapping Screw, /-0 x.50 REF. PART 0-3 Torx Screw, #-3 x.35-0 Hex Nut, -3 3-00C Dash Panel, -style 3-00 Parking Brake Button 3-5 Throttle Control Lever 3-0 Cruise Control Button -55 Brake/Cruise Pivot Rod 3-0B Dash Support Tube 3 3-3 Intake Bellow (Model TH) 3-3 Intake Bellow (Model ZH) 5-05D Fuel Tank, 3-gallon 3 5-003 Fuel Cap 35-5 Ignition Key w/ plastic cover - Ignition Key w/o plastic cover 3 3-000A Grille Support Bracket 3 - Systems Indicator Monitor 3 - Ignition Switch 0-005 Headlight Assembly 3-5 RH Headlight Reflector 3- LH Headlight Reflector -0B Headlight Wire Harness -0 Tractor Wire Harness (Model TH) -0 PTO Wire Harness (Model ZH) NOTE: For painted parts, please refer to the list of color codes below. Please add the applicable color code, wherever needed, to the part number to order a replacement part. For instance, if a part numbered 00-xxxx is painted Yard-Man Green, the part number to order would be 00-xxxx-05. Yard-Man Green: 05 Yard-Man Yellow: 0 Powder Black: 03
3 0 5 3 3 3 3 3 3 5 50 5 0 0 3 5 5 3 35 5 53 3
REF. PART -0 Deck Stabilizer Rod 3-0 Lift Shaft Assembly 3-0 Clevis Pin,.5 x. -00 Hex Nut, /- 5-03 Flange Lock Nut, 3/- -0A Flange Lock Nut, 5/- -3 Hex Nut, /- -00 Internal Cotter Pin -05 Internal Cotter Pin 0-00 E-ring 0-03 Handle Grip 3-0 Torsion Spring 3- Extension Spring 3-0 Flat Washer, 5/ 3-0 Lock Washer, / 3- Flat Washer,.3 x.0 x. 3- Flat Washer,.5 x. x.0 3-0A Hex Cap Screw, 5/- x. 3-03 Shoulder Screw, 3/- 0-0 Hex Flange Bearing -0 Snap Flange Bearing -0 Lift Cable,. 3 -A Lift Handle 5-5 Roller Pulley 3-0A Arm Lift 3-00A Deck Stabilizer Bracket 0-00A Carriage Bolt, 5/ x. 0-00A Self-tapping Screw, 5/- x. REF. PART 0-05 Self-tapping Screw, /- x.5 3-0 Lift Lever Cover 3 3-3 Cover w/ Cup Holder 3 3- Flat Washer,.3 x.0 x.03 3-0 Lift Adjustment Bracket 3 3- Fender 35 3- Seat Mounting Bracket 3 0- Screw, #0- x.35 3 - Hex Flange Lock Nut, /-0 3 0-0A Seat Adjuster Grip 3 3-00 Spacer 0 3-0 Compression Spring,. x.5 3-0 Spring Washer,.5 x.5 x.0 3-00 Flat Washer,.3 x. x.03 3 3-0A Shoulder Screw,. x.5,/-0 3-0 Shoulder Screw 5 3-0 Seat Stop 3-03 Seat Pivot Bracket 3-03 Seat Adjustment Lever 3-053 Seat Adjustment Selector 5-00 High Back Seat, Yellow (Model ZH) 5-00 Med. Back Seat, Yellow (Model TH) 50 35-05 RH Foot Pad 5 35-05 LH Foot Pad - Foot Pad Clips (Not Shown) 5-0 Cotter Pin 53 3-05 Trim Strip 5 3-00A Seat Lift Bracket NOTE: For painted parts, please refer to the list of color codes below. Please add the applicable color code, wherever needed, to the part number to order a replacement part. For instance, if a part numbered 00-xxxx is painted Yard-Man Green, the part number to order would be 00-xxxx-05. Yard-Man Green: 05 Yard-Man Yellow: 0 Powder Black: 03
3 3 3 5 3 3 0 0 0 3 3 3 3 3 0 For reference only
REF. PART 0-0A Self-tapping Screw, 5/- x.5 0-00A Self-tapping Screw, - x. 3 3-0B RH Pivot Support Bracket 3-0A LH Pivot Support Bracket 5 3-0 Pivot Bar Bracket 0-05 Hex Cap Screw, 3/- x (Grade 5) -0 RH Drag Link -0A LH Drag Link -00 Jam Nut, /-0 (Grade ) 0-0 Hex Nut, 3/- (Grade ) -03 Flange Lock Nut, 3/- -05 Flange Lock Nut, /-0-0A Flange Lock Nut, 5/- -50D Steering Gear, /0 Ratio -5 Steering Pinion Gear 3-0A Ball Joint, /-0 3-0 Lock Washer, 3/ 3- Flat Washer,.5 x. x.0 3-00A Steering Shaft,. OD x. 0-05 Plastic Bushing,.3 ID -05 Hex Flange Bearing, 5/ 3-03B Shoulder Spacer,.3 ID 3 3-000 Steering Wheel: 3 Spoke REF. PART 3-005 Steering Wheel Cap 3-00A LH Axle Assembly,.5 Diameter 3-00A RH Axle Assembly,.5 Diameter -03B Cast Iron Pivot Bar w/ Fittings,.5-03 Flange Lock Nut, 3/- -0 Cotter Pin -03 Push Cap,.50 3 3-0 Bell Washer,.3 x. 3 3-05 Flat Washer,.35 x.5 x.0 3-0 Bell Washer,.3 x. x.0 3 3-0 Shoulder Screw,.5 x., 3/- 35 0-03 Hex Bolt, 5/- X 3 3-005A Wheel Assembly Complete, x x 3-0 Rim Only w/ Plastic Bearing 3-05 Air Valve (Not Shown) 3-3 Tire Only, Square Shoulder 3 3-0 Hub Cap 3 3-053E Steering Support Bracket 3 3-03 Shoulder Screw, 3/- 0 0-005 Hex Screw3/- x.0 Switch Plate 0-0 AB Screw #0- x 0.5 NOTE: For painted parts, please refer to the list of color codes below. Please add the applicable color code, wherever needed, to the part number to order a replacement part. For instance, if a part numbered 00-xxxx is painted Yard-Man Green, the part number to order would be 00-xxxx-05. Yard-Man Green: 05 Yard-Man Yellow: 0 Powder Black: 03 3
3 5 53 3 3 3 5 0 35 3 3 0 3 55 55 0 3 5 5 3 5 5 3 5 0 5 0 3 3 Attach Spring Ref. 3 0 5 50 3 3
REF. PART 0 Transaxle Mounting Bracket -03 Hydrostatic Transmission 3-0A Reverse Wire Harness Adapter & Ground 3-0 Bell Washer,.3 x. 5 3-0 Double Idler Bracket Assembly 0-0 Hex Cap Screw, 5/- x.5 0-0 Screw, #- x.5 0-03 Hex Cap Screw, 3/- x.5 0-0 AB Screw, 5/- x.5 0 0-05 Self-tapping Screw, /-0 x.35 0-0 Screw, #- x.35 0- Hex Cap Screw, 3/- x. 0-3 Hex Cap Screw, 5/- x.0-0 Ferrule, 5/- -03 Ferrule, 3/- -03 Hex Nut, /-0-03 Flange Lock Nut, 3/- -0 Flange Lock Nut, /-0-0 Hex Nut, 5/- 0 - Hex Nut, 3/- -00 Internal Cotter Pin -0 Cotter Pin 3-0 Cable Tie - Short Spring Switch -0 Insulator Nut Plate 3-A 0-inch Fan 3-00 Extension Spring,. x.03 3-0 Extension Spring,.5 x.0 3-0 Wire Ring 3-0A Extension Spring,.5 x 3. 3 3-0 Extension Spring,.5 x.0 3 3-3 Extension Spring, 3/ x. 3-00 Flat Washer,.35 x. x.03 3 3-03 Lock Washer 35 3-0 Lock Washer, 3/ 3 3-0 Flat Washer,.3 x. x.05 3 3-0 Lock Washer, / 3 3-0 Flat Washer,.0 x. x.5 3 3-03B Shoulder Spacer,.3 0 - Hydrostatic Bypass Rod -50 Hydrostatic Brake Rod REF. PART -5 Hydrostatic Control Rod 3 50-0535 Spacer,.3 x. x. 5-03 Drive Belt 5 5-0 V-idler Pulley, 3.0 5-0A Flat Idler Pulley,.5 5- Input Pulley, 5.0 3-00 Transmission Torque Bracket 3-0 Switch Actuator Bracket 50-003B Brake Control Assembly 5-00 Drive Control Assembly 5 3-0C Hydro Pedal Assembly 53 0-050 Self-tapping Screw, 5/- x.5 5 0-0A Self-tapping Screw, 5/- x.5 55-03 Ferrule, /-0 5-3 Pin, 3/- x.3 5 3-05 Compression Spring,.05 OD x. 5 5-0A Engine Pulley 5 3-03 Extension Spring,.50 OD x.3 0 35-0 Drive Pedal Pad 35- Brake Pedal Pad 3-03 Flat Washer,. x. x.0 3 3-0 Flat Washer,. x. x.0 3-0 Ext. Lock Washer 5 0-B TT Screw 5/- x 0.5 3-05 Shoulder Screw,.3 x. 0-0 Hex Cap Screw, 5/- x.5-0 Hex Flange Bearing -5B Split Hex Flange Bearing 0 - Cruise Control Rod - Brake Lock Control Rod -0 Cruise Latch 3 3-0 Flat Washer,.3 x.50 x.0 3-053E Steering Support Bracket 5 3-03C Drive Lockout Bracket 3-03 Brake Pedal 3-00 Wheel Assembly Complete0 x x Square Shoulder 3-000 Rim Assembly Only 3-05 Air Valve (Not Shown) 3- Tire Only, 0 x x, Square Shoulder 3-0A Deluxe Hub Cap (Ref. Required) 3-0 Flat Washer,.350 x.5 x.0 NOTE: For painted parts, please refer to the list of color codes below. Please add the applicable color code, wherever needed, to the part number to order a replacement part. For instance, if a part numbered 00-xxxx is painted Yard-Man Green, the part number to order would be 00-xxxx-05. Yard-Man Green: 05 Yard-Man Yellow: 0 Powder Black: 03
3 3 3 3 3 35 3 3 3 0 3 3 3 55 5 5 5 53 5 A A 0 3 3 50 5 5 0 5 5 5 5 0 5 0 Model ZH 5 3 0 0 B B 5
REF. PART -00 PTO Engage Lever Assembly 3-050 PTO Engage Plate Assembly 3 0-0 Carriage Screw, 5/- x.00 0-050 Hex Cap Screw, 3/- x.5 5 0-03 Hex Cap Screw, 3/- x 5.5 0-3 Hex Head Washer Screw, 5/- x.5-0 Push Nut, 3/ -03 Flange Lock Nut, 3/- -0A Flange Lock Nut, 5/- 0-0 Hex Nut, 5/- -00 Cotter Pin, / x. -00 Speed Nut,.3 3-A PTO Knob 3-0 Extension Spring,.5 x.5 3-0A Belt Guard 3-00 Flat Washer,.50 x.50 x.0 3-0 Lock Washer, 5/ 3-00 Flat Washer,.35 x. x.03 3-0 Flat Washer, 5/ 0 3-00 Flat Washer,.0 x.5 x.05 3-0 Bell Washer,.3 x. x.0 3-0 Flat Washer,.0 x. x.5 3 3-03A Shoulder Spacer,. -00 Hex Split Flange Bearing,.5 -D PTO Engagement Handle - Belt Keeper Rod -0B Spacer, 3/ x.5 5-0B Idler Pulley, 3.5 5-0 Idler Pulley,.0 3-0A Engagement Stop 3 3-0B Deck Stop 3 0-00A Self-Tapping Screw, 5/- x. 3-0035 Compression Spring,. x 3. 3 3-0 Battery Strap 35 3-00 Shoulder Screw,. x.5, /-0 3 3-00 Bell Washer,.5 x.0 x.0 3-05 Flange Lock Nut, /-0 3 3-03A Hitch Plate REF. PART 3 3-03 Battery Tray 0 - Solenoid, -Volt, 00 Amp 0-05 Self-Tapping Screw, /-0 x.5 3-0 Lock Washer, / 3 3-0C Lower Frame Assembly -0 -Volt Battery, 0 CCA 5 0-05 Hex Cap Screw, /-0 x. -0 Hex Sems Nut, /-0 - Wing Nut, /-0 3-5 Extension Spring,.50 x 5.0 0- Hex Cap Screw, 5/- x.5 50 50-05 Spacer Cup 5 0- Hex Head Cap Screw, /-0 x. 5 3-0 Lock Washer, / 53 3-03 Flat Washer,.50 x. 5 5-03B Engine Pulley, 3.5 OD x 5.5 55 5-0 PTO Belt 5 3-053E Steering Support Bracket 5-0 Keeper Pin, 5/ x.5 5 3-0 Belt Guard 5 3-03 Lock Washer 0-0 Hex Nut 3-0/ Idler Bracket Assembly 0 3-5 Shoulder Screw / x.50 3 0-3 Hex Screw 3/- x.5 0-05 Hex Screw 3/- x.5 5 3-0 Extension Spring 5-0 PTO Belt (Model ZH) -0 Electric PTO Clutch (Model ZH) 3-05 Shoulder Spacer 0-3 Hex Cap Screw 0-5A Switch Switch Plate 0-0 Screw #0- x 0.5 3 0-3 Hex Cap Screw 3/- x.0 3-003 Anti-Rotation Bracket (Model ZH) 5 0- Hex Cap Screw 5/- x 0. NOTE: For painted parts, please refer to the list of color codes below. Please add the applicable color code, wherever needed, to the part number to order a replacement part. For instance, if a part numbered 00-xxxx is painted Yard-Man Green, the part number to order would be 00-xxxx-05. Yard-Man Green: 05 Yard-Man Yellow: 0 Powder Black: 03 35
Cutting Deck: Model ZH 3 35 3 0 3 3 3 3* 3 3 3 0 5 3 3 3 5 5 0 0 50 53 5 55 5 55 5 * See pages 3 and 3 for break-down of the assembly. 3
Cutting Deck: Model ZH REF. PART. 3-05C Deck Assembly. Spindle Plate 3. -00A Spindle Assembly. -0 Spindle Assembly: Double Pulley 5. 3-0 Deck Hanger Bracket Assembly LH. 0-0 Carriage Screw /-0 x 0.50. 0-03 Hex Screw 3/- x.5. 0-050 Hex Screw /-0 x.0 0. 0-05 Hex Screw 3/- x.0. 0-05 Hex Screw 5/- x.. 0-05 TT Screw /-0 x 0.5. 0-050 TT Screw 5/- x 0.5. 0-003 Carriage Screw /-0 x 0.5. 0-05 Hex Screw /-0 x 0.0. 0-0A LD Screw 5/- x 0.5. -0 Sems Nut /-0. -0A Flange Nut. -03 Lock Nut 3/- 0. -0 Hex Nut /-0. - Lock Nut /-0. -00 Cotter Pin 3. -53B Gear Adjustment. -0 Push Nut. 3-0 Compression Spring. 3-05A Extension Spring. 3-03 Extension Spring. 3-03 Deck Wheel REF. PART. -00 Grass Catcher Pin. 3-0 Lock Washer 3. 3-00 Bell Washer 3. 3-03 Shoulder Spacer. 3-0 Shoulder Screw 3. - Deck Release Handle 35. 5-03 V-Belt 3. 5-0 V-Belt 3. 5-0B Idler Pulley 3. 3-0A Idler Bracket 0. 3-0 Deck Skirt: Center. 3-0 Deck Skirt RH. 3-0 Belt Cover LH 3. 3-005A Belt Cover RH. 3-0 Chute Stop 5. 0-05 Machine Screw. 3-03 Flat Washer. -0 Hex Nut. - Wing Nut. 3-3 Mulch Plug 50. 3-03B Chute Deflector: Side Discharge 5. -00 Speed Nut 5. -0 Hinge Pin 53. 03-3A Mounting Bracket 5. 3-00 Torsion Spring 55. -0 Blade:. Star 5. -0 Blade:. Star NOTE: For painted parts, please refer to the list of color codes below. Please add the applicable color code, wherever needed, to the part number to order a replacement part. For instance, if a part numbered 00-xxxx is painted Yard-Man Green, the part number to order would be 00-xxxx-05. Yard-Man Green: 05 Yard-Man Yellow: 0 Powder Black: 03 3
3 Cutting Deck: Model TH 5 0 5 35 3 53 3 5 3 3 3 3 50 3 3 5 3 0 55 3 5 5 5 0 3 5 5 0 3 5 3 0 0 3 5 3 5
Cutting Deck: Model TH Ref. No. Part No. Description. Brake Assembly: Deck. C Belt Cover 3. Spindle Plate. -00A Spindle Assembly 5. -05 Spindle Assembly: Double Pulley. 3-0 Bracket: Deck Hanger LH. 3-05C Deck Assembly. 0-0 Carriage Screw /-0 x 0.50. 0-03 Hex Screw 3/- x.5 0. 0-050 Hex Screw /-0 x.0. 0-05 Hex Screw 3/- x.0. 0-05 Hex Screw 5/- x.. 0-05 TT Screw /-0 x 0.5. 0-050 TT Screw 5/- x 0.5. 0-003 Carriage Screw /-0 x 0.5. 0-05 Hex Screw /-0 x 0.0. 0-005 Hex Screw 5/- x.5. 0-0A LD Screw 5/- x 0.5. 0- Hex Screw 5/- x.5 0. -00 Grass Catcher Pin. -03 Belt Guard Pin. -5 Pin 3. -0 Hex Sems Nut /-0. -0A Flange Nut. -03 Flange Lock Nut. -0A Flange Lock Nut. -0 Hex Nut /-0. -0 Hex Nut 5/-. - Hex Flange Nut /-0. -00 Cotter Pin 3. -53B Gear Adjustment 3. -0 Push Nut. 3-0 Compression Spring 3. 3-0A Extension Spring 35. 3-05A Extension Spring 3. 3-03 Extension Spring 3. 3-5 Extension Spring 3. 3-03 Deck Wheel 3. 3-0 Lock Washer 0. 3-00 Flat Washer Ref. No. Part No. Description. 3-00 Bell Washer. 3-0A Flat Washer 3. 3-03 Spacer. 3-0 Shoulder Screw 5. -0 Cable Bracket. - Deck Release Handle Rod. -03 Shoulder Spacer. 50-0 Spacer. 5-03 V Belt 50. 5-0A V Belt 5. 5-0B Idler Pulley 53. 3-0A Idler Bracket 5. 3-0 Deck Skirt: Center 55. 3-0 Deck Skirt: RH 5. 3-0 Chute Stop 5. 3- Belt Cover 5. -0 Blade:. Star 5. -0 Blade:. Star 0. 3-03B Chute Deflector: Side Discharge. 3-3 Mulch Plug. - Wing Nut 3. -0 Hex Nut. 0-05 Machine Screw 5. 3-03 Flat Washer. 03-3A Mounting Bracket. -00 Speed Nut. 3-00 Torsion Spring. -0 Hinge Pin 0. -0A Flange Nut. 5- Deck Pulley. 50-05 Spacer 3. -0 Ball Bearing. -03 Spacer 5. -00 Spindle Housing. 3 Shoulder Bearing. 3-0 Spindle Shaft. -0A Flange Lock Nut 0. 5-003 Pulley. 50-0 Spacer. 3-00 Spindle Shaft 3