GENESIS Model #B0 INT L GENESIS Model #I0 Rev. 0 PARTS MANUAL PN and MICROFICHE PN /
TABLE OF CONTENTS Parts Manual A AIR VENT........................... B BATTERY BOX....................... C BILGE PUMP......................... B CARBURETOR....................... C- COOLING SYSTEM.................... B0 CRANKCASE......................... C CRANKSHAFT and PISTON.............. C CYLINDER and MANIFOLD.............. C DECALS............................ A DRIVE SYSTEM....................... B ELECTRICAL BOX..................... B- ENGINE FOGGING SYSTEM............. C ENGINE MOUNTING................... B EXHAUST SYSTEM.................... B FRONT STORAGE COMPARTMENT........ A0 FUEL SYSTEM........................ A FUEL TANK.......................... A FUEL/WATER SEPARATOR.............. C B C D E F H HULL and BODY...................... A- M MAGNETO........................... C OIL PUMP........................... C OIL TANK........................... B PART NUMBER INDEX.................. C-D PROPULSION........................ B R REVERSE........................... B SEAT............................... A SHROUD............................ A- STARTING MOTOR.................... C0 STEERING........................... B- T TOOL KIT........................... C O P S W WATER INLET........................ B WATER SIPHON...................... C The illustrations used in this Parts Manual are for reference to replacement parts only. This manual is not to be used for assembly.
GENESIS WATERCRAFT SPECIFICATIONS CAPACITIES ENGINE Fuel Tank Reserve Fuel Tank Injection Oil Reservoir Gas Type CARBURETION Carburetor Type and Number Carburetion Idle Speed COOLING Cooling System Type Overheating Warning US Gallons (. l) N/A Quarts (. l) Regular Unleaded Octane or Octane Oxygenated -0mm (CDK) 0 0 RPM Water Cooled, Thermostat Pop off Warning Light/RPM Limit Engine Type Induction Type Exhaust System Lubrication Oil Type Number of Cylinders Bore Stroke Displacement Compression Ratio Maximum Power (approx.) Maximum Torque (approx.) RPM Limiter Operation PROPULSION Polaris Marine 00 Case Reed Water Cooled/Injected Oil Injection Polaris Premium or Premium Gold -cycle Oil mm 0mm cc Effective : 00 00 RPM 00 DIMENSIONS Number of Passengers Length, Overall Width, Overall Height, Overall Dry Weight Load Limit Hull/Deck Material - Persons. (0. cm). ( cm) (.0 cm) 0 lbs. ( kg) 00 lbs. ( kg) FRC Propulsion System Jet Pump Type Transmission Minimum Water Level for Jet Pump Impeller Diameter Impeller Jet Drive Axial Flow, Single Stage Direct Drive feet (0 cm). (.0 cm) Blade, Slim Hub ELECTRICAL Alternator Output Ignition System Spark Plug Type Spark Plug Gap Starting System Ignition Timing; BTDC @000 RPM Battery. amps/0 watt at 00 RPM CDI NGK BPRES.0 (0. mm) Electric Starter V, A Polaris Industries Inc. reserves the right to make changes in design and specifications and/or to make additions or improvements to its products without notice.
POLARIS WATERCRAFT PUBLICATION NUMBERS OWNER S PARTS PARTS ASSEMBLY MODEL MODEL # MANUAL MANUAL MICROFICHE INSTRUCTIONS GENESIS B0 INT L GENESIS I0
SHROUD 0 0 0 0 A
SHROUD 0 Gauge, MFI, Digital Gasket, MFI 00 Connector, Deutsche 000- Line, Pitot, Formed End 0 Spring, MFI Mounting 0 Kit - MFI Button Replacement 0 Bezel, MFI, Overlay 0- Lid, Console 0 Spring, Torsion, Console 0 Seal, Console Lid 0 Nut Pad, Console Screw 0 Washer, Lock Washer 0000 Screw 0000 Knob, Choke 0 Screw Plate, Hook 0 Gasket, Mirror, LH Gasket, Mirror, RH - - Asm., Mirror, Starboard Asm., Mirror, Port 0 Rivet 0 Mount, Shroud 0 Nut, Hex 0 Nut, Nylok Washer Nut 00 Cable, Choke Bumper, Corner, Shroud 0 Bracket, Support, Shroud Bolt Grommet, Deck, Wire Harness 0 Strap, Tool Kit, Lower 0- Cover, Wire, Shroud Kit, Tool (See Tool Kit Pg. C) 00 Strap, Tool Kit, Upper 0 Ring, Retaining 0 Screw Washer, Lock 0 0- Shroud, Steering Gasket, Door 0 Plate, Latch, Receiver Washer, Flat 0 Screw Gasket, Console Hook Hook, Console Pin, Hinge Hinge, Console Asm., Console Latch / A
HULL and BODY 0 0 0 0 0 0 0 0 0 0 0 A
HULL and BODY - - Pad, Footwell, Front, LH Pad, Footwell, Front, RH - 0- Pad, Footwell, Rear, LH Pad, Footwell, Rear, RH - - Pad, Footwell, Center, LH Pad, Footwell, Center, RH 00- Pad, Boarding 00 Plunger, Side Latch Nut Washer 0 Washer, Lock Screw 0 Washer 0- Handle, Grab w/cross Member Seal, Tow Hook Hook, Tow 0 Nut 0 0 Pad, Heel, LH Pad, Heel, RH 0- Bumper, Rear Rivet - Plug, Bumper, Rear 0 Nut 0 Washer 0-0- Bumper, Corner, LH Bumper, Corner, RH Screw 0- Plug, Bumper 0 Screw Screw - - Sponson w/cover, LH Sponson w/cover, RH - - Cover, Sponson, LH Cover, Sponson, RH 0 Washer Insert 0 - Rail, Rub, LH/RH Screw 00 Bracket, Mount, Ladder Nut 0 Ladder, Boarding Washer, Lock - Bumper, Front Seal, Grab Handle 0 Gasket, Rear Storage Bucket 0 Bucket, Rear Storage 0 U-Bolt, Seat, Rear 0 Nut 0 Washer, Dish, Rubber 00 Plunger, Latch / A
HULL and BODY 0 Gasket, Receptacle Receptacle, Seat Base 0 Rivet 0 Nut 00 Plug, Bilge 0 Washer, Dish, Rubber 00 U-Bolt Screw A 0 Flange, Air Inlet 0 Gasket, Air Inlet 00 Clamp, Hose Duct, Air Inlet Strap, Bow Gasket 0 Washer Grommet, Access /
FRONT STORAGE COMPARTMENT 0 0 0 0 Latch, Door 0-0 Door, Compartment 0 Asm., Door Hinge 0 Washer 0 Nut Screw 0 Screw Washer, Lock Washer 0 Washer Washer, Lock 0 Screw Seal, Door Rivet 00 Cable, Limiter, Hinge 0 Asm., Access Panel A0 0 Washer 0 Spring, Gas Screw 0 Boot, Gas Spring Grommet, Access Cover, Fire Extinguisher 00 Asm., Fire Extinguisher Container (Incl. and Container) Container, Fire Extinguisher Hook 0 Clip Rivet 00 Strap, Rubber 0 Bumper, Rubber 0 Seal, Storage Compartment 0 Insert /
DECALS RH 0 LH 0 Kit - Decals (Incl. All Except Seat Decals) 00 Decal - Warning, Rear 0 Decal - POLARIS, Seat 0 Decal - Fuel, Off/On 0 Decal - POLARIS, 00 Decal - Fire Extinguisher 0 Decal - Star Emblem 0 Decal - GENESIS Emblem 0 Decal - Upper Deck, Front, RH A 0 Decal - Refueling Warning 0 0 Decal - Upper Deck, Rear, RH 00 Decal - Recommended Oil, Premium 0 Decal - POLARIS, Hull 0 Decal - Sidewall, RH 0 Decal - MFI Instruments 0 Decal - Caution, Capsize 0 Decal - Sidewall, LH 0 Decal - Warning, Seat/Engine 0 Decal - Upper Deck, LH /
FUEL TANK 0 0 0 Clip, Strap Hook, Strap, Narrow Rivet 0 Strap, Rubber Tank, Oil (See Oil Tank Pg. B) Hook, Strap 00 Strap, Battery Holddown 00 Coupling, End, Fuel Cap Chain Screw 0 000 Chain 0 Cap, Fuel, Ratchet 0 Seal, Fuel Cap A Rivet Inlet, Fuel Seal, Fuel Inlet Nut, Fuel Inlet 00 Clamp, Hose Hose, Fuel Fill 00 Clamp 0 0 Asm., Fuel Sender 0 Pad, Fuel Tank 0 Tank, Fuel 0 Pad, Fuel Tank, Side /
FUEL SYSTEM 0 0 Screw 0 Washer -00 Knob, Fuel Valve Nut, Fuel Valve 0 Valve, On/Off 00 Clamp, Hose 00- AR Line, Fuel 00 T-Clip Separator, Fuel Water (See Fuel/Water Separator Pg. C, Ref. ) 0 0 Fitting, Tee 0 Grommet, Vent 00 Cable Tie 00 Connector, /-/ 00 Cable Tie 00 Valve, Relief Check 0 Value, Vacuum Check Asm., Fuel Sender (See Fuel Tank Pg. A, Ref. 0) 00 Fitting, Tee / A
SEAT 0 0 0 Strap w/clips, Seat - Cover, Seat 0 AR Staple - Shield, Seat, Front, RH 0 Trim, Seat, Front Seal, Seat, Front Screw Bumper, Seat - Shield, Seat, Front, LH 0 0 Bumper, Seat, Oval 0 Screw Washer, Lock Washer Plate, Bottom, Seat Base Latch Plate, Seat Base Latch 00 Spring, Seat Base Latch A Handle, Seat Base Latch Plate, Top, Seat Base Latch - Asm., Seat, Front (Incl. -) 0 Trim, Seat, Rear Seal, Seat, Rear - Shield, Seat, Rear, RH - End Cap, Seat Clip, Xmas Tree - Cover, Seat, Rear Decal - POLARIS, Seat (See Decals Pg. A, Ref. ) 00 Kit - Vinyl Decal Application (For Seat Decals) - Asm., Seat, Rear (Incl.,,-,0-,) - Shield, Seat, Rear, LH /
OIL TANK 0 Cap, Oil Tank Rivet 0 Inlet, Oil Gasket, Oil Inlet 00 Clamp, Hose 00 Elbow, 0 Degree 0 Sender, Oil Level 000 Clamp, Hose 000- AR Line, Fuel 0 00 Filter, Oil 00 Clamp, Hose 0 Tank, Oil 0 Valve, Check, Vacuum 00-0 AR Fuel Line Hose, Oil Fill / B
STEERING 0 0 Screw Washer, Lock Washer 0- Pad, Handlebar - Pad, Handlebar, Bottom 0 Screw 0 Clamp, Handlebar - Handle, Grab 00 Cable, Throttle 0 0 Switch, STOP/BILGE/CHOKE/RVS 00 Lanyard w/whistle 00-00 Handlebar w/grip Column, Steering Housing, Steering 0 Washer B Bearing, Steering 0 Support, Steering 0 Rivet Gasket, Steering Housing 0 Screw 00 Clamp, Throttle Block 0 Ring, Retaining 0 Washer 0 Lever, Throttle, Thumb 0 Pin, Retaining Screw Washer, Lock 0 Washer 0 Block, Throttle, Split /
STEERING 0 0 0 0 Boot, Steering 0 Nut 0 Screw Washer 000 Rod End Nut, Nylok 0 Washer, Steering Seal 0 Nut, Steering Cable (Special) 00 Cable, Steering 0 Nut 00 Washer Washer, Lock 00 Seal, Rod 00 Tube, Guide 00 Rod End Washer Nut 0 Screw Column, Steering (See Steering Pg. B, Ref. ) 0 0 Bolt Washer Bracket, Support, Steering / B
ENGINE MOUNTING 0 0 0 Switch, Temperature 00 Decal - Spark Plug Screw Ground, Spark Plug Spark Plug, NGK BPRES (See Cylinder and Manifold Pg. C, Ref. ) Decal - Warning (See Cylinder and Manifold Pg. C, Ref. ) 0 Plate, Mount, Front 0 Washer, Lock 0 Screw 0 AR Shim, Plate Mount 00 Mount, Engine AR Plate, Motor Mount 0 Washer, Lock Nut, Hex Washer Nut, Nylok 0 Washer, Lock Screw 0 Kit - Short Block, 00 Triple NOTE: The Short Block assembly contains a crankcase assembly, cylinder and cylinder head assembly, and a piston & crankshaft assembly. 0 0 Clip, Retainer 0 Bolt B /
DRIVE SYSTEM 0 0 0 Coupler, Drive 0 O-Ring 0 Decal - Coupler, Drive Shaft Screw Bracket, Coupler Shroud 0 Shroud, Coupler Washer 0 Washer, Lock Rivet 0 00-. AR Trim, Edge 0 O-Ring B 0 Bumper, Drive Shaft 0 Shaft, Drive 00 Fitting, Lubrication 000 Seal, Bearing Bearing, DU Asm., Bearing Housing (Incl. -) 000 Clamp, Hose 0 Hose, Bearing Housing 0 Nut, Shaft, Thru-Hull Fitting, Shaft, Thru-Hull /
PROPULSION 0 0 0 0 0 Seal, Water Pipe 0 Seal, Siphon Tube 0 Pipe, Water Nut, Nylok Bracket, Steering Cable Washer, Stud Seal Stud, Pump Mounting Pipe, Water, Engine 0 O-Ring 0 00 Bearing 00 Spacer, Bearing 0 Stator 0 O-Ring 0 O-Ring 00 Shaft, Stub 00 Seal, Stator Bearing 00 Spacer, Impeller Impeller 00-00 Hose, Water 0 00 Cable Tie 0 Screw 0 Anode, Zinc Housing, Pump Washer 0 O-Ring Screen, Engine Inlet Wedge, Pump Bolt Washer 0 0 Washer, Lock 0 Nozzle, Steering, SLT Bearing, Steering Nozzle 0 Collar Screw 00 Nozzle Cone, Pump 0 Screw / B
REVERSE 0 0 0 0 Cover 0 Screw O-Ring Screw Plate w/bushing, Switch 0 Switch, Reverse Limit 0 Asm., Reverse Motor 00 Seal, Oil Screw 0 Washer, Lock 0 Washer, Dish 0 Washer Bracket, Motor 00 Pin, Cotter Linkage, Reverse 0 Pin, Roll Washer, Flat Screw B 0 Screw 0 Washer, Lock 0 Plate, Cable 00 Nut 00 Washer Seal, Rod 00 Cable, Reverse Seal, Rod 0 Nut 00 Rod End Nut, Nylok 0 Screw Washer 00 Collar Washer Screw 0 Gate, Reverse, Directional /
EXHAUST SYSTEM 0 0 0 0 0 Gasket, Exhaust, Flange 00 Asm., Manifold, Exhaust (Incl.,) 00 Fitting, Exhaust Screen 0 Fitting, Exhaust Injector 00 Fitting, Water Inlet 00 Clamp Hose, Coupler Screw Conduit 0 Hose, Pipe/Silencer 0 Pipe, Exhaust Grommet, Rubber 00 Clamp, Hose Tube, Spacer Washer, Flat 0 Washer, Lock Screw B Conduit Hose, Outlet/Exhaust, LH 0 Screw 0 Fitting, Exhaust, Hull Bottom, LH 0 Clip, Strap D-Hook 0 Strap, Rubber Rivet Foam, Cradle, Silencer Insert 0-0 Silencer, Exhaust Hose, Exhaust Crossover 0 0 Fitting, Exhaust, Hull Bottom, RH Hose, Exhaust Outlet 0 Fitting, Exhaust 00 Clamp /
AIR VENT Screw 0 Washer, Lock Washer Spacer -0 Silencer, Intake, Top 00 Decal - 00 Intake Silencer 000 Filter, Intake Silencer / B
COOLING SYSTEM 0 0 Gasket Fitting, Thru-Hull 00 Clamp, Hose Hose, Water 00 Clamp, Hose Fitting, Inlet, Water (See Exhaust System Pg. B, Ref. ) Asm., Manifold, Exhaust (See Exhaust System Pg. B, Ref. ) 00 Cable Tie Fitting, Injector, Exhaust (See Exhaust System Pg. B, Ref. ) 0 Fitting, Screen, Exhaust (See Exhaust System Pg. B, Ref. ) - Conduit, Flex Hose, Water In 0 Plug, Pipe 000 Thermostat, Degrees F. 0 Gasket, Thermostat 00 Cover, Thermostat 00 Spring, Compression Valve, Pop-Off 00 Seal, Thermostat Housing 0 Hose, Water, Outlet / B0
WATER INLET 0 0 00 Cable Tie, 000- Line, Pitot, Formed End 00 Nut Washer 0 Gasket, Pitot Pitot 0 Scoop, Inlet Insert 0 Plate, Ride 0 0 Screw 0 Grate, Inlet / B
BILGE PUMP Gasket Fitting, Water, Thru-Hull 00 Clamp, Hose - Conduit, Flex Hose, Bilge Pump 0 Pump, Bilge Screw Washer, Flat / B
ELECTRICAL BOX GENESIS REV FUEL/ BILGE/ CROSST SOLENOID BLANK MFD ST/SP OIL TEMP ALK 0 0 0 0 B
ELECTRICAL BOX 0 Nut Washer Bumper, Rubber Solenoid, Starter (See Magneto Pg. C, Ref. ) Screw Washer, Lock 0 Mount, Ignition Box Cover, Electrical Box Seal, Plastic 0 0 Screw 0 Nut Washer, Lock Washer 0 Washer, Dish, Rubber Plate, Bottom 0 Latch Pin, Latch Asm., Electrical Box Accessory (Incl.,,,) 000 Regulator, Start/Stop, LR0 0 000 Regulator, Rectifier, Cut/Off, LR- 0 Asm., Terminal Board D-Hook Controller (See Magneto Pg. C, Ref. ) 0 Plate, Box Top Strap, Battery Holddown 0 Breaker, Circuit Coil, Ignition, Triple (See Magneto Pg. C, Ref. ) Asm., Electrical Box, Ignition (Incl.,,,) Bracket, Coil/Solenoid 0 0 Harness, Bilge Pump, Connector 0 Harness, Wire, MFD 0 Harness, Cross Talk 00 Cable, Battery/Solenoid 00 Cable, Solenoid/Starter 0 Harness, Wire Stator 0 Harness, Stop Switch 0 Harness, RVS 0 Harness, RVS 0 Harness, Oil/Fuel 0 00 Boot, Threaded O-Ring 0 Decal - High Voltage Warning 0 Decal - Reset Plate, Stator Washer / B
WATER SIPHON -. Conduit, Wire,. cm 0 Elbow, Siphon Hose 00 Cable Tie 00-00 Line, Fuel 00 Anchor, Cable Tie 0 Pickup, Siphon w/strainer / C
BATTERY BOX 0 0 Cover, Battery 0 Grommet, Vent 00 Cable Tie 00 Connector AR Tube, Battery Vent 000 Battery, Amp 00 Kit - Battery Bolt C 000 Cable, Ground, Battery/Engine Strap, Battery Holddown 0 Hook, Strap, Narrow 00 Bracket, Strap Screw Tray, Battery 0 Rivet /
CRANKCASE 0 0 0 Kit - Crankcase, 00 (Incl. -0) 0 Bushing 0 Plug, Timing Hole Bushing 0 Spring 0 Bushing 0 Cover, Flywheel Screw O-Ring 0 0 Screw C 0 Gasket, Flywheel Cover Screw 00 Dowel, Pin O-Ring 0 Asm., Flywheel Housing (Incl.,) Screw 0 Plug Screw Stud, Cylinder Flange 0 00 Pin, Dowel /
CYLINDER and MANIFOLD 0 0 0 Screw 0 Decal - Warning 0-0 Manifold, Outlet, Water 00 Gasket, Water, Manifold 00 Spark Plug, NGK BPRES 0-0 Cover, Head, Big Bore, Red 0 O-Ring Ring, Head 00 Head, Cylinder 0 Kit - Asm., Triple Crankcase (See Crankcase Pg. C, Ref.) 0 Asm., Triple Reed Block Stuffer, Reed Block 0 Adaptor, Carburetor, Cylinder 0 Screw Screw 00 Retainer 00 Gasket, Carburetor 0 Gasket, Cylinder Base 00 Cylinder, mm 0 0 Nut 0 O-Ring O-Ring Screw Screw / C
CRANKSHAFT and PISTON 0 0 0 Kit - Crankshaft, 00 Triple (Incl.,,-) 00 Circlip, Piston 000 Pin, Piston 0 0 0 0 00 0 Kit - Piston Asm. (Std.)(Incl.,,) Kit - Piston Asm. (.mm O/S) (Incl.,,) Kit - Piston Asm. (.0mm O/S) (Incl.,,) Kit - Piston Rings (Standard) Kit - Piston Rings (.mm O/S) Kit - Piston Rings (.0mm O/S) 0 Kit - Connecting Rod Asm. Bearing Key, Woodruff 0 Bushing C Coupler, Pump Drive 0 Nut (See Magneto Pg. C, Ref. ) Washer (See Magneto Pg. C, Ref. 0) 00 Seal 0 Ring, Retaining 0 Bearing, Ball, Deep Groove Crankweb, MAG, Big Bore Crankweb, Center, Big Bore 0 Labyrinth Crankweb, PTO, Big Bore Seal 0 0 Ring, Retaining, Internal 0 O-Ring Collar, Crankshaft /
OIL PUMP 000 Cable, Oil Pump 00-00 Line, Fuel 000 Clamp O-Ring C 0 E-Ring, Retaining Washer, Nylon 0 Screw 00 Asm., Oil Pump (Incl. ) /
C CARBURETOR 0 0 0 0
CARBURETOR Asm., Carburetor, Keihin 000 Kit - Carb Rebuild (Incl.,,,) 00 Screw, Fuel Pump 00 Kit - Fuel Pump Body 00 Kit - Gasket, Fuel Pump 00 Nozzle, PTO 00 Hose, Fuel 00 Cable Tie Screw 0 Base, Intake Silencer 00 Gasket, Carb, Upper 0 00 Block, Jet (Rear & Center) 00 Joint, Connecting 00 Tube, Rubber 00 Kit - Check Valve, Mid Range ( Per Carb) 00 Screen, Fuel Strainer 00 Kit - Accelerator Pump ( Per Carb) 00 Kit - Needle Valve ( Per Carb) 00 00 00 Jet, Main (Per Carb) Mag Jet, Main (Per Carb) Center Jet, Main (Per Carb) PTO 00 Jet, Pilot ( Per Carb) 00 Jet, Pilot ( Per Carb) 0 00 Screw, Jet Block Cover 00 Cover, Jet Block 000 Kit - Diaphragm, Jet Block ( Per Carb) 00 Screw, Jet Block ( Per Carb) 00 Block, Jet, Accelerator Pump (Front) 00 O-Ring, Jet Block 00 Kit - Idler Mixture Screw ( Per Carb) 000 Cap, Limiter 00 Collar 00 O-Ring, Valve Seat 0 00 Kit - Check Valve, Main ( Per Carb) 00 Kit - Idle Stop Screw 00 Nozzle, Magneto, Keihin 00 E-Clip 00 Coller 000 Spring, Torsion 00 Washer 00 Lever, Synchronizing 00 Washer, Lock 00 Nut, Throttle Shaft 0 00 Kit - Synchronizing Screw 00 Tube, Rubber 00 Hose, Fuel, Accelerator Pump 00 T-Fitting 00 Plate, Connecting 00 Screw, Connecting Plate 00 Nozzle, Center, Keihin 00 Gasket, Carb / C
MAGNETO 0 0 000 Stator, Ignition Washer Screw Screw Clamp 0 O-Ring Holder, Magnet 00 Asm., Flywheel (Incl.,,) 0 Kit - Timing Screws 0 0 Washer C 0 Nut 0 Harness, Wire 00 Controller 00 Coil, Ignition, Triple 00 Solenoid, Starter 00- Wire, Spark Plug 00 Cable Tie 00 Cable Tie, 00- Wire, Spark Plug 0 00- Wire, Spark Plug /
STARTING MOTOR 0 0 00 Starter, Big Bore (Incl.,-) 0 Bolt, Through 0 Screw 0 Brush (Incl. -) 0 Nut 0 Washer, Spring 0 Washer 00 O-Ring 0 Spring, Brush 00 Ring, Rubber 0 00 Asm., Rear Bracket 0 AR Washer, Thrust C0 0 Washer, Thrust 00 Asm., Armature 00 Asm., Front Bracket 0 O-Ring 0 Washer, Thrust 0 Ring, Snap 0 Stopper 0 Cover 0 0 Spring Bushing, Flange 00 Asm., Gear (Incl. -) 00 Asm., Bendix (Incl. -) /
FUEL/WATER SEPARATOR 0 Screw Washer, Lock 0 Washer, Dish Spacer C 00 Separator, Fuel/Water (Incl. -) 00 O-Ring 0 Element 0 Spring 00 Float /
TOOL KIT Asm., Tool Kit (Incl. -,,) Wrench, Spark Plug Wrench, Open End (0mm-mm) Screwdriver Manual, Owners, Watercraft Pouch, Tool Kit Wrench, / Allen, Plated / C
ENGINE FOGGING SYSTEM INT L GENESIS I0 0 0 Kit - Engine Fogging 00 Cable Tie 00 Clamp, Hose 00 Clamp, Hose 0 Fitting, Tee 0 Decal - Engine Primer 00 AR Line, Oil 0 Primer, Engine, Fog Screw (See Fuel/Water Separator Pg. C, Ref. ) Washer, Lock (See Fuel/Water Separator Pg. C, Ref. ) 0 Washer, Dish (See Fuel/Water Separator Pg. C, Ref. ) C Separator, Fuel/Water (See Fuel/Water Separator Pg. C, Ref. ) 0 Decal - Fogging Oil Only Washer Nut 00 Valve, Check, Vent 0 Fitting, 0 Degree Tank, Oil 0 Gasket, Overflow Cap Cap, Oil Bottle 0 0 Screw Bracket, Oil Tank /
Part Ref. Grid 0......... A0 0.......... B 00........ A0 00.......... A 00.......... A 0......... C 0.......... C 0......... C............. C 00.......... B 0......... B 0-0..... B......... B 00......... B 0......... B 00-00..... B 0......... A 0......... B 00......... B 0.......... B 00......... B 00......... B... B 0.......... B 0.......... B 0.......... B 0000......... A 0000......... A 00.......... C 00......... C 00.......... C 00.......... C 00....... 0.. C 00......... C 000......... C 00......... C 00......... C 00....... 0.. C 000............. C 0.......... C 00......... C 0............. C 0.......... C 0......... B 0.......... C 00.......... C 0.......... C 0.......... C 0.......... C 0.......... C 0............ A 0.......... C 0.......... A 0....... 0.. B Part PART NUMBER INDEX Ref. C Grid 0....... 0. A 0.......... B 0.......... B 0........ B 0......... B 0.......... B 0.......... B 0........ B 0........ B 0........ B... C 0....... 0. B 0........ B 0........ B 0........ B 0........ B 0........ B 0........ A 0........ A0 00....... 0.. B 00.......... C -..... A -..... A......... A......... A........ B........ B......... A 0......... A0 -.... A -.... A -..... A -.... A......... A 00......... A 0......... A............ C....... 0. A0............ C 00......... C 00......... B 00.......... C 000.......... C 00.......... C 00......... C 00......... C 00....... 0.. C 00.......... C 00......... C 00......... C 00......... C 000......... C 00......... C 00......... C Part Ref. Grid 00.......... C 00......... C 00......... C 00......... C 00......... C 000......... C 00......... C 00......... C 00......... C 00......... C 00......... C 00......... C 00......... C 00......... C 00......... C 00......... C 00......... C 00......... C 00......... C 00......... C 00.......... C 00....... 0.. C 00......... C 00......... C 00.......... C 00......... C0 00......... C0 0......... C 0......... C0 0........ C0 0......... C0 0........ C0 0......... C0 0......... C0 0......... C0 0........ C0 0......... C0 00........ C0 0........ C0 0........ C0 0........ C0 00........ C0 00........ C0 00....... 0. C0 00......... C 00......... C 0......... C 0......... C 00......... C 0.......... A 0.......... A 00....... 0.. B.......... C 0.......... C 0.......... C
Part Ref. Grid.......... C.. C0......... B 0......... C 000......... B 00.......... B 00......... B 00......... C 000.......... C 00......... C 00-.... 0.. C 00-...... C 00-...... C 00......... C 00.......... C 00......... C 00........ B 000........ B 000.......... C 00.......... A 00........ B 000....... 0. B 00............ C0 00........ C0 000.......... C 00......... B 00......... B 00.......... B 00......... B 00......... B 00......... A 00.......... A 0......... B 0......... B 00........ B0 0......... C......... C......... B......... C......... C......... C......... C......... B 0......... B 0......... B......... B......... A... B.. B......... B.......... B......... B........ A......... B Part PART NUMBER INDEX Ref. D Grid 0........ B........ B......... A......... B.. B 0......... A... B 0........ A0 0......... B 0....... 0.. B.......... B.......... C.......... B......... A 0......... A.......... C....... 0.. A........ B......... B....... 0.. A........ A0.. A 0... C......... A 00......... C 00......... A....... 0.. B......... B.......... B.......... B........ C.......... B.. C........ B......... A 0........ A0 00........ A0.. A 0......... C 0......... B 0........ A... C 0......... B 0.......... B... B 0........ B0 0......... B 0......... B 0......... B 0......... B 00........ B0 0.......... C 0......... C 0.......... B Part Ref. Grid 0.......... B.......... C... C 0........ A 0.......... C........ B... C........ B -..... A......... C......... B........ B0......... B....... 0.. A........ A......... B....... 0.. A....... 0.. A....... 0. A0......... C.......... B......... C 0......... A......... B......... A......... A.. A0......... B0....... 0. B0.......... A.......... B....... 0.. B 0......... B......... B......... B......... B......... B......... B 0......... A........ A........ A........ A 0.......... C......... B0.. B......... A......... B......... B......... B......... C......... B........ A0........ A0....... 0.. B 0.......... B
Part Ref. Grid -..... A 0.......... C.......... C -0...... B......... C.......... C......... B........ C........ C 0........ B......... B........ B.......... C........ A........ A.......... A........ B0 0.......... B -00..... A......... B.......... B........ A 00-...... A 0......... B 0-0.... A0 0-..... A 0-... 0.. A 0........ A 0......... A 0-...... A 0......... B 00......... B 0......... B 0......... B 0-..... A 0-..... A 0-..... A 0-..... A 0-...... B 0......... A 0......... A -..... A -..... A -.... A -.... A......... B 0.......... C......... B......... B 0-..... A 0.......... A......... A.......... B -...... B Part PART NUMBER INDEX Ref. D Grid -...... B -.... A......... A -..... A -..... A -..... A -..... A 0.......... B 0.......... C......... A -........ C -..... B0 -...... B....... 0.. A........ A0 -... 0.. A......... A........ A 0....... 0. A 0........ A0......... A......... A 0......... A....... 0. A......... A......... A.......... B......... B 0-0...... C 0.......... C 0......... C 0.......... B 0......... B 0........ B 0......... B 0......... B 0....... 0.. B 0......... B 0-0...... C 0......... A 0.......... B 0......... B 0........ C 0......... B 0.......... B......... B0.. B 0......... A... B........ A 0......... C......... B......... A.......... B Part Ref. Grid.......... A -...... A 0-...... A -...... A -...... A -...... A -...... A......... A......... A 0........ A......... B 0........ A 00......... C... C 00.......... C 00.......... C 0......... C 00........ B0 0.......... C 0.. C0 0.......... A 0........ A0 0.......... A 00........ A 000........ B0 00........ A 0........ B0 0......... C 00........ C 00........ A 00........ A... C 00.......... B 0....... 0. A 0........ A... B 00.......... B 0........ C 0......... C 0......... A 0.......... B 00......... B 000.......... B 00......... B 0........ B 0........ A 0.......... B 0.......... C 0........ C 0......... C 0......... A 00.......... B 0......... A 00........ A 0........ B
Part Ref. Grid 0........ A 0......... A 00......... A 0........ A 0........ A 0........ A 0........ A 0....... 0. A 0......... A 0......... A 00.......... B 00......... A 0........ A 0......... A 0......... A 00........ A 0... B.. B0... C... C... C.. C 000.......... B 00......... A 00......... B 00........ A 00......... B 00....... 0. B 00.......... C 00......... B 00......... B0.. B 00......... A.. B0.. C 00......... A 00........ A.. B... C... C 00......... C 000.......... B 000.......... C 000.......... C 00......... B 00......... C 00......... B 000....... 0. A 00......... A.. A 00.......... B 00.......... B 00......... A 00.......... B Part PART NUMBER INDEX Ref. D Grid 00......... B 00........ A0 00.......... B 000......... B......... B......... A.......... A 0......... B 0......... A.. A0 0.. C 0.......... B 0......... B 0......... B 0......... A 0....... 0. B......... B 0.......... B......... C.......... B......... A.......... B......... B......... B 0......... A 0......... B 0.......... C 0......... A......... A......... C......... C.......... B 0......... A.. A0 0........ A 0... C... C 0......... C.. C0......... C.......... C.......... C......... B......... C.......... C......... B....... 0.. B......... A 0.......... B......... C......... B.......... B......... C.......... B Part Ref. Grid......... B 0.......... B 0... B......... A... A......... A0......... A.......... C........ A0... B 0....... 0. B 0......... C.......... B....... 0.. B......... A....... 0.. B.......... B 0......... B......... A... B.. C.......... B... B 0.......... B... B......... B.......... A.......... B....... 0.. B......... B 00......... B 0......... A... A... A.. A0 0......... A... A.. B 0......... A... A 0......... C 00......... B 0....... 0.. C 0........ B......... A 0.......... A 0......... B 0.......... B 0......... B... B 0... B... B......... A.. A0... B
Part Ref. Grid....... 0.. B.. C........ A0... B 0... B.. B......... A... B... B... B......... B.......... B.. B......... A 0.. A0... B... B.. B.. B....... C......... A.. A.. B......... A 0... A.. A0.. A... B 0......... A... B......... B Part PART NUMBER INDEX Ref. Grid.......... A......... B......... B 0......... A... A... B.. B.. C......... B....... 0.. A... B......... B 0......... A.. A0 0.......... C 0....... 0.. C 0........ C0.......... B.......... C......... B.......... C 0......... A... B 0......... B 0........ A0... B......... B........ A........ A0.......... B........ A0 Part Ref. Grid......... A... B... B......... A 00......... B 0......... A... A... B 0......... B 0......... C 0......... B 00....... 0.. C 00......... C 0......... B 0.......... C 0....... 0.. C 0......... C 0......... A.......... C 00-.... 0.. B 000-..... B 00-.... A 00-00...... C 00-00..... B 00-0..... B 00-00...... C 00......... C 000-...... A 000-..... B 0......... A......... C D
In order to better serve you, this postage-paid mailer is provided for your convenience to report an error or relay a suggestion relative to any Polaris Publication. or FAX your report to: --0 POLARIS PUBLICATIONS REPORT Publication Machine Publ. Date Page Report of Error Suggestion Name Company Address City, State, Zip Phone ( ) Date Thank you for your help! Mailing Instructions Please fold the top portion down first then fold the bottom portion up second so the open edge is located at the top. Tape the open edge. / Rev. 0
NO POSTAGE NECESSARY IF MAILED IN THE UNITED STATES BUSINESS REPLY MAIL FIRST CLASS PERMIT NO. ROSEAU, MINNESOTA POSTAGE WILL BE PAID BE ADDRESSEE ATTN: TECHNICAL PUBLICATIONS POLARIS SALES INC. 0 TH AVE. S.W. ROSEAU, MN
In order to better serve you, this postage-paid mailer is provided for your convenience to report an error or relay a suggestion relative to any Polaris Publication. or FAX your report to: --0 POLARIS PUBLICATIONS REPORT Publication Machine Publ. Date Page Report of Error Suggestion Name Company Address City, State, Zip Phone ( ) Date Thank you for your help! Mailing Instructions Please fold the top portion down first then fold the bottom portion up second so the open edge is located at the top. Tape the open edge. / Rev. 0
NO POSTAGE NECESSARY IF MAILED IN THE UNITED STATES BUSINESS REPLY MAIL FIRST CLASS PERMIT NO. ROSEAU, MINNESOTA POSTAGE WILL BE PAID BE ADDRESSEE ATTN: TECHNICAL PUBLICATIONS POLARIS SALES INC. 0 TH AVE. S.W. ROSEAU, MN
In order to better serve you, this postage-paid mailer is provided for your convenience to report an error or relay a suggestion relative to any Polaris Publication. or FAX your report to: --0 POLARIS PUBLICATIONS REPORT Publication Machine Publ. Date Page Report of Error Suggestion Name Company Address City, State, Zip Phone ( ) Date Thank you for your help! Mailing Instructions Please fold the top portion down first then fold the bottom portion up second so the open edge is located at the top. Tape the open edge. / Rev. 0
NO POSTAGE NECESSARY IF MAILED IN THE UNITED STATES BUSINESS REPLY MAIL FIRST CLASS PERMIT NO. ROSEAU, MINNESOTA POSTAGE WILL BE PAID BE ADDRESSEE ATTN: TECHNICAL PUBLICATIONS POLARIS SALES INC. 0 TH AVE. S.W. ROSEAU, MN
PRINTED IN THE USA PARTS MANUAL PN and MICROFICHE PN /