MANUAL MODEL NO. WZ145H9RBA Lawn Tractor 007 5 1 9-4 Rev..1.0 RH PRINTED IN U.S.A.
HOW TO USE THIS MANUAL This manual is designed to provide the customer with a means to identify the parts on his/her tractor when ordering repair parts. The illustrations may or may not represent the actual assemblies; therefore, it is not recommended to use this manual as a guide to assemble or disassemble the tractor. Some hardware and parts are drawn larger in order to more readily identify them. Each tractor has its own model number. The model number for your tractor can be found on the fender under the seat. When ordering parts, always give the following information: Product - Tractor Model Number - WZ145H9RBA Part Number Part Description TABLE OF CONTENTS SCHEMATIC... ELECTRICAL...4-5 CHASSIS AND ENCLOSURES...6-7 DRIVE...-9 STEERING ASSEMBLY...10-11 SEAT...1 DECALS...1 ENGINE...14-15 MOWER LIFT...-17 MOWER...1-19 BAGGER...0-1 WARRANTY...
TRACTOR- -MODEL NO. WZ145H9RBA, PRODUCT NO. 964 79 11-00 SCHEMATIC 1VDC RED AMMETER (OPTIONAL) A RED FUSE BATTERY RED STARTER SOLENOID STARTER M WHITE BLACK B S M BLACK G L A1 A BLACK CLUTCH / BRAKE (PEDAL UP) ATT'MENT CLUTCH (CLUTCH OFF) FBI BUZZER FBI SWITCH BLACK ORANGE GREEN GREEN SEAT SWITCH (NOT OCCUPIED) OPERATOR PRESENCE RELAY 5 6 7 0 7A BLACK 5 6 BLACK 7 0 7A BAGGER RELAY 5 6 BAGGER INTERLOCK (NO BAG, CHUTE OR PLUG) BLACK 7 0 BLUE BLACK FUEL LINE CARBURETOR SOLENOID (IF SO EQUIPPED) RED RED 7A MOWER ENGAGED RELAY IGNITION UNIT CHARGING SYSTEM OUTPUT AMP DC @ 600 RPM SPARK PLUGS GAP ( PLUGS ON TWIN CYL. ENGINES) VOLTS AC MIN. @ 600 RPM (CHARGING SYSTEM DISCONNECTED) DIODE ALTERNATOR LIGHTING SYSTEM OUTPUT 5 AMP AC @ 600 RPM 14 VOLTS AC MIN. @ 600 RPM (LIGHTS OFF) IGNITION SWITCH BROWN BLACK POSITION CIRCUIT OFF M+G+A1 RUN/LIGHT B+A1 RUN B+A1 START B + S + A1 MAKE NONE A+L NONE NONE WIRING INSULATED CLIPS NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR SERVICING OF UNIT, THEY SHOULD BE REPLACED TO PROPERLY SECURE YOUR WIRING. NON-REMOVABLE CONNECTIONS REMOVABLE CONNECTIONS PTO SWITCH POSITION CIRCUIT OFF C + G, B + H ON C + F, B + E, A + D HEADLIGHTS NOTE YOUR TRACTOR IS EQUIPPED WITH A SPECIAL ALTERNATOR SYSTEM. THE LIGHTS ARE NOT CONNECTED TO THE BATTERY, BUT HAVE THEIR OWN ELECTRICAL SOURCE. BECAUSE OF THIS, THE BRIGHT- NESS OF THE LIGHTS WILL CHANGE WITH ENGINE SPEED. AT IDLE THE LIGHTS WILL DIM. AS THE ENGINE IS SPEEDED UP, THE LIGHTS WILL BECOME THEIR BRIGHTEST. 7 7A 6 5 0 RELAY H G F C E D A B
TRACTOR- -MODEL NO. WZ145H9RBA, PRODUCT NO. 964 79 11-00 ELECTRICAL 1 4 41 4 7 7 6 40 7 7 4 1 5 0 4 5 9 66 7 66 1 5 59 4
TRACTOR- -MODEL NO. WZ145H9RBA, PRODUCT NO. 964 79 11-00 ELECTRICAL 1 5 4-65 Battery 74 76 04-1 Bolt Hex Hd 1/4-0 Unc x /4 5 17 61- Switch Interlock 1 5 17 56-5 Harness Asm Light W/415J 5 00 41-5 Bulb Light #1156 4 5 1 47-0 Cable Starter 6Ga 11" Red 5 5 59-7 Cable Battery Crd 56" Red 6 5 17 51-5 Fuse 7 7 51 04-00 Nut Keps Hex 1/4-0 Unc 5 1 77-5 Cable Ground 6Ga 1" Black 9 5 07-4 Switch Plunger Normal Op Olive 0 5 17 55-66 Switch Ignition 5 14 04-01 Key Ign 40 5 17 97- Harness Ign 41 71 11 04-0 Bolt Flk Fin Hex 1/4-0 Unc x 1/ 4 5 1 15-6 Cover Terminal Red 4 5 17-61 Solenoid 4 5 14 0-44 Adapter Ammeter Rectangular 5 5 14 19-40 Protection Wire Loop 5 5 94-19 Buzzer Crd 59 5 1 0-79 Switch FBI CRD 66 17 49 06-0 Screw Thdrol /- x 1/ Ty-Tt 1 5 10 97-4 Relay Asm NOTE: All component dimensions given in U.S. inches. 1 inch = 5.4 mm. 5
TRACTOR- -MODEL NO. WZ145H9RBA, PRODUCT NO. 964 79 11-00 CHASSIS AND ENCLOSURES 17 1 56 9 5 4 1 66 19 1 1 17 17 16 6 19 171 190 5 171 6 5 0 9 09 4 5 5 5 1 51 5 55 57 17 17 19 170 65 0 1 11 14 69 15 09 9 09 54 175 09 6 15 179 14 4 10 09 5 4 6 6 6 7 145 7 1 1 5 07 09 4 05 4 05 6 0 6
TRACTOR- -MODEL NO. WZ145H9RBA, PRODUCT NO. 964 79 11-00 CHASSIS AND ENCLOSURES 1 5 17 46-0 Chassis 5 1 0-4 Drawbar 17 06 06-1 Screw /- x /4 5 5 15 5-7 Bumper Hood/Dash 6 5 1 44-19 Saddle 5 1 64-71 Clip Insulator 1/ Mtg. Hole 9 5 1 54-0 Dash 10 7 14 06-0 Bolt, Carriage /- x /4 11 5 17 49-96 Panel, Dash, L.H. 1 5 14 56-60 Clip 1 5 1 17-19 Panel, Asm. Dash R.H. 15 74 1 05-1 Screw, Machine, Truss Head 5/-1 Unc x /4 7 51 05-00 Nut 17 5 15 9-55 Hood 1 5 1 49-1 Bumper Hood 4 74 7 06- Bolt 5 19 1 1-1 Washer 1/ x 1/ x 1 Ga. 6 7 0 06-00 Nut 5 17 91-01 Grille /Lens Asm 9 5 1-54 Lens, Grille 0 5 1 1-59 Fender 1 5 51-56 Bracket, Fender Support 5 1 11-9 Footrest, L.H. 4 5 1 11-94 Footrest, R.H. 5 7 11 06-06 Bolt 7 17 49 05-0 Screw Thdrol 5/-1 x 1/ TYT 5 1 17-4 Bracket Asm Pivot Mower Rear 51 7 0 04-00 Nut Lock w/insert 1/4-0 Unc 5 19 09 14- Washer 9/ x 7/ x Ga. 5 5 14 46-97 Bracket Grille LH 54 5 14-64 Screw Hex WSHD -1 x 7/ 55 5 14 46-96 Bracket Grille RH 57 74 7 04-1 Bolt Fin Hex 1/4-0 Unc x.75 69 5 14 4- Screw Hx Wsh Hi-Lo 1/4-1/ 9 5 1 1-60 Console Crd Auto 145 5 15 65-4 Rod Pivot Chassis/Hood 5 1 0- Bracket Exten Chassis Lh CRD 5 1 0- Bracket Exten Chassis Rh CRD 4 5 56-05 Support Battery CRD 5 5 1 1-56 Cover Battery 170 5 17-6 Backplate CRD 171 7 14 06-0 Bolt Rdhd Sqnk /- x -1/ Gr. 5 17 19 1 0- Washer 1/ x 1-1/4 x Ga. 17 7 51 06-00 Nut, Keps Hex /- Unc 175 5 1 0-10 Guard Trap 179 5 1 0-76 Rod Pivot FBI CRD 14 5 17 46-6 Bracket Actuator Bagger CRD 15 5 1 11-01 Knob Rod Brake Parking 16 5 07-9 Latch Asm Mulch/Bagger 17 5 1 50-04 Nut Weld 1 19 06 1- Washer #10 19 10 07 10-00 Washer Lock #10 190 71 0 10-10 Screw Pan Hd Phillip 10-4 x 5/ 19 5 9-7 Nut, Push 05 17 49 06-0 Screw Thdrol /- x 1/ 07 17 67 05-0 Screw Thdrol 5/-1 x 1/ 0 17 67 06-0 Screw Thdrol /- x 1/ 09 17 00 06-1 Screw Hex Wsh Thdrol /- 1 5 15 6-9 Insert Lens Refl ective 14 5 1 47- Retainer Spring 56 5 1 1-61 Cover Fender Rack 65 5 1 57-04 Seal RH Side Bagger 66 5 1 57-0 Seal LH Side Bagger NOTE: All component dimensions given in U.S. inches. 1 inch = 5.4 mm. 7
TRACTOR- -MODEL NO. WZ145H9RBA, PRODUCT NO. 964 79 11-00 DRIVE 77 77 74 7 75 76 145 1 10 4 40 4 9 56 66 51 14 5 6 54 17 179 179 177 10 7 51 4 50 49 47 50 150 151 17 1 1 11 50 59 17 1 156 5 6 14 159 1 0 15 171 4 1 10 7 9 5 6 5 7 6 6 5 6 6 55 5 5 5 15 7 4 4 96 5 6 51 50 0 9 171 0 50 6 55 55 5 5 6 14 16 07 14 199 5 199 51 199 197 1 199 4 15 17 95 96 6 71 00 7 6 65 0 9 4 57 1 1 1 1 10 47 64 171 67 6 61 51 66 65 6 6
TRACTOR- -MODEL NO. WZ145H9RBA, PRODUCT NO. 964 79 11-00 DRIVE 1 - - - - - - - Transaxle Hydro Gear 1-0510 (Order parts from transaxle manufacturer) 5 56-19 Rod, Shift Fender Adjust Lt 9 5 1 0-54 Clutch Asm Noram 10 76 0 04- Pin, Cotter 1/ x 1 14 10 04 04-00 Washer, Lock Hvy Helical 7 0 05-00 Nut Lock Hex W/Ins 5/-1 Unc 1 5 1 05-64 Knob 5 17 56-07 Rod, Brake 4 7 5 06-00 Nut 5 5 10 6- Spring, Rod, Brake 6 19 1 1- Washer 1/ x 1/ x Ga. 7 76 0 04-1 Pin, Cotter 1/ x /4 5 17 57-65 Rod, Parking Brake 9 5 07-7 Cap, Parking Brake 0 5 95-9 Bracket, Mfg. Transaxle 4 5 17 55-7 Shaft, Asm Pedal Foot CRD 5 5 1 01- Bearing, Nylon 6 19 1 - Washer 1/ x 1 x Ga. 7 5 1 49-6 Pin, Roll / x 1" 5 59-6 Pulley Flat Composite.06" 9 74 76 06-44 Bolt Fin Hex /- Unc x -/4 40 5 1 49-65 Spacer, Split 95 x 59 Bzp 4 19 1 1-1 Washer 1/ x 1/ x 1 Ga. 4 19 11 10-1 Washer 11/ x 5/ x 1 Ga. 47 5 1 77- Pulley, Idler, V Groove Plasitc 4 5 15 44-07 Bellcrank Clutch Grnd Drv 49 5 1-05 Retainer, Belt Style Spring 50 7 11 06-1 Bolt /- x 1-1/ Gr. 5 51 7 6 06-00 Nut, Crownlock /- Unc 5 7 6 05-00 Nut Crownlock 5/-1 5 5 10 57-10 Link, Clutch 7.66 55 5 10 57-09 Spring, Return, Clutch 56 17 06 06-0 Screw /- x 1-1/4 57 5 17 01-40 V-Belt Kev 11" 0650 CRD 6 5 1 5- Cover, Pedal 65 10 04 07-00 Washer 66 5 15 47-7 Keeper, Belt Engine F-Proof 71 5 91- Strap, Torque, Lh 7 5 91- Strap, Torque, Rh 74 5 1 70-57 Spacer, Split 75 5 1 17-49 Washer 5/ x 1-1/4 x Ga. 76 1 00 00-01 Ring, E 77 5 1 5- Key, Square 7 5 1 17-4 Washer 5/ x 1-5/ x Ga. 1 5 17 00-06 Asm, Shaft,Cross Rear 5 57-11 Spring, Torsion 19 17 1- Washer 17/ x /4 x Ga. 4 5 17 00-07 Link, Transaxle 95 5 17 00-15 Control Asm Bypass Hydro 96 5 1 47- Spring, Retainer 1 10 7 90 06-00 Nut Lock Flg. /- Unc 145 74 49 05-44 Bolt Hex FGHD 5/-1 x Gr 5 150 5 5-50 Bushing, Bellcrank Grnd Dr 151 19 1-10 Washer 1/ x x 10 Ga. 156 5 60-0 Washer Srrted 5/ID x 1.15 15 5 55-9 Bracket Shift Mount 159 5 54-94 Hub Tapered Flange Shift Lt 0 19 9 0- Washer 9/ x 1-1/4 x Ga. 1 7 14 04-06 Bolt Rdhd Sqnk 1/4-0 x /4 Gr 5 7 6 04-00 Nut Crownlock 1/4-0 Unc 74 7 04- Bolt Hex Fin 1/4-0 Unc x 1 Gr 5 4 19 09 10-10 Washer 5/ x.1 x 10 Ga. 5 5 56- Bracket Pivot Lever 6 5 6-0 Screw 5/-1 x 5/ 7 5 55- Bracket Support Shift CRD 5 54-9 Bolt Shoulder 5/-1 x.561 9 5 55-0 Plate Fastening Lt 171 17 49 06-0 Screw Thdrol /- x 1/ Ty-Tt 17 5 17 0-71 Shaft Asm Shifter Frt CRD 177 5 59- Keeper Flat Idler.06" CRD 17 5 59- Keeper Belt Idler 1." CRD 179 5 1 09-5 Washer Sintered 10 5 56-0 Pulley, Idler, Flat 1."CRD 11 5 1 0-11 Bracket Idler Ground Drive CRD 1 5 1 6- Keeper Belt.5" Od V-Idler CRD 1 5 17 90-50 Pulley V-Idler.50" Od CRD 14 17 49 06-44 Screw Hexwsh Thdrol /- x -/4 15 5 17 00-0 Link Shift 16 5 56-14 Hub Tapered Round CRD 17 17 5 05-0 Screw Thdrol 5/-1 x 1.5 197 5 96-1 Nyliner Snap-In 5/ 199 5 96-1 Bolt Shoulder 5/-1 Unc 00 7 14 05-0 Bolt RDHD SQNK 5/-1 x 1 0 71 17 07-0 Bolt Hex 7/-0 x 5 07 5 9-45 Washer Nylon Rear 14 5 17 56-09 Shaft Asm. Brake 15 5 17 56-5 Rod Brake Hydro 50 17 06 06-1 Screw /- x.75 5 5 17 50- Bracket Cable Chassis 54 17 00 06- Screw /- x 1 55 5 17 56-0 Brace Shaft Brake Mtg. 5 5 17 0-6 Clip Retainer 59 5 1 0-1 Bracket Pulley 61 5 1 14-94 Pulley Idler 6 17 00 06-1 Screw /- x /4 64 5 1 19-95 Bracket Clutch Mounting 65 5 1 0-1 Spacer Idler Chassis 66 5 1 0-61 Shield Idler Mower 67 7 14 06-6 Bolt /- x -1/4 69 5 1 4-0 Guard Muffl er NOTE: All component dimensions given in U.S. inches 1 inch = 5.4 mm 9
TRACTOR- -MODEL NO. WZ145H9RBA, PRODUCT NO. 964 79 11-00 STEERING ASSEMBLY 1 9 1 41 4 7 7 6 51 44 54 91 4 71 6 67 67 9 46 6 1 67 17 65 46 7 6 5 7 5 6 11 4 9 4 15 15 15 9 40 10 4 5 4 6 10
TRACTOR- -MODEL NO. WZ145H9RBA, PRODUCT NO. 964 79 11-00 STEERING ASSEMBLY 1 5 17 59-04 Steering Wheel 5 17-9 Front Axle Assembly 5 9-40 Spindle Assembly, L.H. 4 5 9-9 Spindle Assembly, R.H. 5 5 1 49-1 Bearing, Race, Thrust, Hardened 6 5 1 17-4 Washer 5/ x 1-5/ x Gauge 1 00 00-9 Ring, Klip 10 5 17 51-1 Link, Drag 11 10 04 06-00 Washer, Lock 1 7 94 0-00 Nut Hex Jam Toplock 1/-0 Unf 1 5 1 65-1 Spacer Axle 15 5 14 5-1 Nut Hex Flange Lock 17 5 1 06-41 Shaft Assembly, Steering 9 17 06 06-1 Screw /- x /4 5 17 01-6 Rod, Tie 19 11 1- Washer 11/ x /4 x Ga. 4 10 04 05-00 Washer Lock Hvy Hlcl Spr 5/ 5 7 54 05-00 Crownlock Nut 5/-4 Unf 6 5 15 50-99 Bushing, Steering 7 5 15 9-7 Screw TT #I0- x 5 x / Flange 5 17 59-05 Cap Wheel Steering 9 19 1-1 Washer 9/ x -/ x 1 Ga. 40 5 1 47-01 Nut Lock Center /-4 Unf 41 5 10 07-11 Adaptor, Steering Wheel 4 5 96- Boot, Steering Dash P/L Mtl 4 5 1 17-49 Washer 5/ x 1-1/4 x Gauge 44 5 1 06-40 Extension Steering 46 5 1 1- Cap, Spindle 51 7 54 04-00 Nut Crownlock 1/4-54 71 1 04-0 Bolt Hex 1/4- Unf x 1-1/4 65 5 0-67 Spacer Axle 67 7 14 06-1 Bolt Rdhd Sq /- x -1/4 6 5 9-7 Brace Axle 71 5 17 51-46 Steering Asm. 5 9-5 Bracket Susp. Chassis Front 7 5 17 9-66 Washer Flat.71 x 1-1/ x.14 5 17 51-1 Bolt Shoulder 7/-0 Unc 91 5 17 55-5 Clip Steering NOTE: All component dimensions given in U.S. inches. 1 inch = 5.4 mm. 11
TRACTOR- -MODEL NO. WZ145H9RBA, PRODUCT NO. 964 79 11-00 SEAT ASSEMBLY 1 14 10 9 7 9 7 5 6 1 4 5 6 15 5 1 17 1 4 1 5 1 74-7 Seat 5 14 05-51 Bracket Pnt Pivot Seat (blk ) 71 11 06- Bolt Fin Hex /- x 1 4 19 1-10 Washer Flat 1/ x 1 x 10 Ga. 5 5 14 50-06 Clip Push In Hinged 6 7 0 06-00 Nut Lock Hex W/Ins /- 7 5 1 41-1 Spring Seat Cprsn 50 Blk Zi 17 00 06- Screw /- x 1.5 9 19 1-14 Washer 1/ x 1 x 14 Ga 10 5 1 4-9 Pan Pnt Seat (blk ) 1 5 1 1-46 Bracket Pnt Mounting Switch 1 5 1 1-4 Bushing Snap Blk Nyl 50 Id 14 7 05 04-1 Bolt Rdhd Sht Nk 1/4-0 x 1-1/ 15 5 1 4-00 Spacer Split 5 1 1-50 Spring Cprsn 17 5 1 9-76 Nut Lock 1/4 Lge Flg Gr 5 Zinc 1 5 17 1-5 Bolt Shoulder 5/-1 Unc-A 7 0 05-00 Nut Hex Lock w/ins 5/-1 71 11 0-14 Bolt Hex Black 4 19 17 19-1 Washer 17/ x 1-/ x 1 Ga. 5 5 1 70-1 Bolt Shoulder 5/-1 x 6 6 10 04 0-00 Washer Lock Hvy HLCL NOTE: All component dimensions given in U.S. inches. 1 inch = 5.4 mm 1
MAX +_90N MAX +_150N TRACTOR- -MODEL NO. WZ145H9RBA, PRODUCT NO. 964 79 11-00 DECALS 14 4 14 5 9 1 17 6 0 11 1 5 14 54-9 Decal Read Owner s Manual Sym 5 1 47-67 Decal Hp Engine 5 17 6-69 Decal Hood Rh 4 5 17 6-71 Decal Hood Lh 5 5 71-0 Decal Wheel Steering 6 5 1 04- Decal 100 DBA 5 1 04-5 Decal Rear Plate 9 5 7-69 Decal Fender 10 5 14 50-05 Decal Bat Dan/Poi P/L Sym Wpn 11 5 1 1-66 Decal Mower Cut Finger Symbol 1 5 15 97-7 Decal Brake/Clutch Symbol Lt 1 1 10 14 5 15 97-6 Decal Chassis Hot Muffl er 17 5 14 0-7 Decal Saddle Brake Parking 0 5 69-60 Decal Bypass Fender CRD 1 5 6-6 Decal Hex Belt Sch 9 CRD 5 1-11 Decal Lift Handle 5 1 10-90 Pad Footrest RH 5 1 10-91 Pad Footrest LH 5 1 6-1 Decal Bagger Frame 5 1 5-06 Manual Operator's (Euro) 5 1 5-9 Manual Operator's (Scan) 5 1 9-4 Manual Parts WHEELS & TIRES 1 6 5, 7 4,10,9 11 1 5 05 91-9 Cap Value Tire 5 06 51-9 Stem Value 5 10 6- Tire F Ts 15 x 6 0-6 Service 4 5 05 99-04 Tube Inner Front #5060 5 5 14 14-46 Rim Asm 6"front Silver Service 6 5 1 49-57 Fitting Grease 7 5 1 49-59 Bearing Flange 5 14 14-47 Rim Asm "rear Silver Service 9 5 1 4-6 Tire R Ts 0 x - Service 10 5 1 49-6 Tube Rear 9 5 x Service 11 5 17 50-9 Cap Axle Blk 1 50 x 1 00 - - 5 14 4-4 Sealant, Tire (10 oz. tube) NOTE: All component dimensions given in U.S. inches 1 inch = 5.4 mm 1
TRACTOR- -MODEL NO. WZ145H9RBA, PRODUCT NO. 964 79 11-00 ENGINE 1 7 5 1 1 4 6 7 44 14 46 7 7 1 45 11 41 9 OPTIONAL EQUIPMENT Spark Arrester 14
TRACTOR- -MODEL NO. WZ145H9RBA, PRODUCT NO. 964 79 11-00 ENGINE 1 5 17 05-51 Control Throt/Ck 17 7 04-0 Screw Hex Thd Cut 1/4-0 x 1/ - - - - - - - - Engine B&S Model H07 (Order parts from engine manufacturer) 4 5 1 7-5 Muffler 1 5 5-91 Gasket Muffl er 14 5 14 4-56 Tube Drain Oil Easy 11 05 06-00 Washer Lock Ext Tooth / 5 9-7 Shield Brn/Dbr Guard 5 5 1 09-45 Control Choke 6 7 9 06-00 Nut Keps /-4 Unf 9 5 1 71-0 Kit Spark Arrestor (Flat Scrn) 1 5 1 55-4 Tank Fuel.00 5 14 05-7 Cap Asm Fuel W/sym Vented 5 1 4-7 Clamp Hose Blk 7 5 1 70-40 Line Fuel 5 1-54 Plug Drain Oil Easy 41 5 1 9-77 Stem Fuel Line 44 17 67 04-1 Screw Hexwsh thdrol 1/4-0 x /4 45 17 00 06-1 Screw Hexwsh Thdr /- x /4 46 19 09 14- Washer 9/ x 7/ x Ga. 7 5 1 9-06 Screw Socket Head 5/-1 x 1 7 17 06 06-0 Screw /- x 1/4 1 7 51 04-00 Nut Keps Hex 1/4-0 Unc 11 5 1 49-5 Bushing NOTE: All component dimensions given in U.S. inches 1 inch = 5.4 mm 15
TRACTOR- -MODEL NO. WZ145H9RBA, PRODUCT NO. 964 79 11-00 MOWER LIFT 7 5 11 1 4 6 1 6 5 1 4 1 19 1 0 15 0 17 1 0 1 1 1 19 0 15
TRACTOR- -MODEL NO. WZ145H9RBA, PRODUCT NO. 964 79 11-00 MOWER LIFT 1 5 15 94-60 Washer Asm Inner Spring W/ Plunger 5 15 94-71 Shaft Asm. Lift 5 10 57-67 Pin Groove 4 1 00 00-0 E Ring #51-6 5 19 1-1 Washer 1/ x 1 x 1 Ga. 6 5 1 01- Bearing Nylong 7 5 10 94-1 Grip Handle Bicycle 5 1 45-6 Button Plunger Black 11 5 5-9 Link Asm Lift L.H. 1 5 5-1 Link Asm Lift R.H. 1 5 1 46-70 Retainer Spring 15 5 17 - Link Front 7 5 0-00 Nut Jam Hex 1/-1 Unc 17 5 17 56-9 Trunnion Blk Zinc 1 7 0 0-00 Nut Lock w/wsh 1/-1 Unc 19 5 1 9-6 Arm Suspension Mower 0 5 5-5 Retainer Spring 1 5 9-65 Bearing, Pvt. Lift. 7 54 06-00 Nut Crownlock /-4 NOTE: All component dimensions given in U.S. inches 1 inch = 5.4 mm 17
TRACTOR- -MODEL NO. WZ145H9RBA, PRODUCT NO. 964 79 11-00 MOWER 40 56 55 40 7 6 4 6 6 1 151 15 157 67 156 15 155 6 6 46 117 119 44 1 4 0 0 7 17 11 0 1 4 1 61 0 14 40 7 6 6 40 15 15 154 5 19 6 4 1 1 1 0 14 1 1 1 11 1 5 1 5 6 40 7 1 119 117 1 14 10 1 46 1 15 11 46 14 11 69 45 1 9 9 0 1
TRACTOR- -MODEL NO. WZ145H9RBA, PRODUCT NO. 964 79 11-00 MOWER 1 5 55-5 Housing Asm. Mower 7 14 05-06 Bolt Rdhd Sqnk 5/-1 Unc x /4 5 55-69 Bracket Asm. S-Bar Chass 4 5 55-5 Bracket Bar Sway Deck 5 5 1 46-70 Retainer Spring 6 5 55-57 Bar Sway 5 1 17-1 Bolt /-4 x 1.5 Gr Patched 9 10 0 06-00 Washer Lock Hvy / Unplated 11 5 17 00-7 Blade -1 Lh 1 5 1 76-45 Shaft Asm. W/Lower Bearing 14 5 1 7-74 Housing Mandrel Vented (Machd) 15 5 11 04-5 Bearing Ball Mandrel 5 17 00- Blade -1 Rh 17 7 14 06-10 Bolt Carriage /- x 1-1/4 1 7 11 06-06 Bolt Rdhd Sqnk /- x /4 19 5 1-7 Bolt Shoulder 5/-1 Thd Form 0 5 1 17-1 Bolt /-4 x 1.5 Gr Ptch Lhthd 1 7 6 05-00 Nut Crown Lock 5/-1 5 5-4 Bracket Idler Sprt RR 5 54-46 Bracket Idler Sprt RF 4 5 5-4 Bracket Suspension LF 5 5 5-44 Bracket Suspension RF 6 5 5-7 Brace Support Susp Frt 7 5 55-6 Bracket Asm. Susp RR 5 55-67 Bracket Asm. Susp LR 0 5 17 9-4 Screw Thd Rolling 1 5 1 99-6 Washer Spacer Mower Vented 5 15 5-1 Mandrel Pulleys 5 17-4 Nut Flg Top Lock 4 5 5-9 Bracket Gauge Wheel Lf 5 5 5- Bracket Gauge Wheel Rf 6 5 14 67-6 Pulley Idler V-Groove Dim 4.5 7 19 1 1- Washer 11/ x 1/ x Ga 40 7 6 06-00 Nut Crownlock /- Unc 44 5 17 55- Cover Mandrel Lh 45 5 17 55-9 Cover Mandrel Rh 46 5 1 77-9 Screw Thd Roll 1/4-0 x 5/ 55 5 54-45 Arm Idler 56 5 57- Spacer Retainer Mower 61 5 59-45 Spring Tension Belt 67 5 10 69- Knob 6 5 1 0-17 Hex-Belt 69 5 54- Shaft Asm W/Lwr Brg Rh Thd CRD 4 5 15 60-5 Keeper Belt Idler 1 5 1 4-19 Bolt Shoulder 117 5 1 9-57 Wheel Gage Donut Wide 11 7 9 06-00 Nut Centerlock /- Unc 119 19 1 14-14 Washer / x 7/ x 14 Ga. 14 7 11 06-1 Bolt Carr Sh /- x 1-1/ Gr5 10 7 11 05-06 Bolt Rdhdsqnk 5/-1 Unc x /4 11 5 56-61 Chute Bagger CRD 9cm 151 5 96-70 Bracket Clutch Cable 15 5 17 60-74 Cable Clutch 15 5 96-74 Washer Flat 154 5 96-75 Spring Retainer 155 5 96-71 Spring Retention Lever Clutch 156 5 96-7 Spacer Clutch Cable 157 5 96-69 Rod Clutch Cable 15 17 7 04-0 Screw Thd Cut 1/4-0 x 1/ 1 5 1 04-1 Blade Cross LH 5 1 60-1 Adapter 5 1 04-19 Blade Cross RH -- 5 1 1-57 Mandrel Asm Service -- 5 1 1-5 Mandrel Asm CRD Lh Threads SVC -- 5 1 17-65 Replacement Mower Complete NOTE: All component dimensions given in U.S. inches 1 inch = 5.4 mm 19
TRACTOR- -MODEL NO. WZ145H9RBA, PRODUCT NO. 964 79 11-00 BAGGER 9 11 1 17 1 5 41 17 4 5 1 9 4 1 1 7 19 6 19 14 0 41 1 4 7 9 4 1 1 14 6 7 10 1 6 4 6 4 7 7 11 7 5 6 4 15 1 5 0
TRACTOR- -MODEL NO. WZ145H9RBA, PRODUCT NO. 964 79 11-00 BAGGER 1 5 5-49 Tube Handle Bagger CRD 7 14 04- Bolt Carriage 1/4-0 x.0 Gr.5 5 1 9-76 Nut Lock 1/4 Lge Flg Gr. 5 Zinc 4 5 99- Handle Bagger w/lvrs Blk CRD 5 74 9 10-4 Screw Pan Head #10-4 x 1.50 Blk 6 74 9 10- Screw Pan Hd 7 7 40 10-00 Nut Wiz Lock Hex Serr/Hd 10-4 5 1 1-54 Cover Bagger 9 7 14 04-1 Bolt Carriage 1/4-0 x.5d x Gr.5 10 5 1 1- Tube Support Bagger CRD 11 5 57-19 Bracket Support Upper Bag CRD 1 5 96-5 Bracket Horiz Adj Bagger Lh 1 7 11 06-06 Bolt Rdhd Sht Sqnk /- x /4 14 74 5 06-6 Bolt RDHD SQNK /- x -1/4 Gr.5 15 5 1 46-70 Retainer Spring 7 90 06-00 Nut Lock Flg /- Unc 17 7 14 05-06 Bolt Rdhd Sht Sqnk 5/ -1 Unc x /4 1 19 11 1- Washer 11/ x /4 x Ga. 19 7 90 05-00 Nut Lock Hex Flange 5/-1 0 5 96-4 Bracket Horiz Adj Bagger Rh 1 5 1 0-0 Bag Asm CRD 5 57-1 Bracket Side Bagger CRD 5 57- Tube Upper Bagger CRD 4 5 57- Tube Pivot Bagger CRD 5 5 1 01-4 Tube Front Bagger CRD 6 5 57-5 Tube Lower Bagger CRD 5 57-7 Grip Handle 1 5 1 47- Retainer Spring 1" Zinc/Cad 5 1 6-75 Rivet Rd Hd Drilled / Dia 5 55-71 Plug Mulch 9 4 5 55-70 Handle Mulcher 5 5 55-7 Pin Mulcher 6 19 1 0- Washer 1/ x 1-1/4 x Ga. 7 5 17 54-01 Plug Support Bagger CRD 7 01 05-0 Bolt 5/-1 x -1/ 9 5 1 09-5 Seal 41 5 96- Bracket Pnt Adj Pvt Bagger CRD 4 7 0 05-00 Nut Crownlock 5/-1 Blk D 4 5 17 40- Plug Tubing End NOTE: All component dimensions given in U.S. inches 1 inch = 5.4 mm 1
SERVICE NOTES
LIMITED WARRANTY The Manufacturer warrants to the original consumer purchaser that this product as manufactured is free from defects in materials and work man ship. For a period of one (1) year from date of purchase by the original consumer purchaser, we will repair or replace, at our option, without charge for parts or labor incurred in replacing parts, any part which we fi nd to be defective due to materials or workmanship. This Warranty is subject to the following limitations and exclusions. 1. This warranty does not apply to the engine. Please contact your nearest dealer where they will send the machine to the engine manufacturer.. Transportation charges for the movement of any power equipment unit or attachment are the responsibility of the purchaser. Transportation charges for any parts submitted for replacement under this warranty must be paid by the purchaser unless such return is requested by your dealer.. Battery Warranty: On products equipped with a Battery, we will replace, without charge to you, any battery which we fi nd to be defective in manufacture, during the fi rst ninety (90) days of ownership. After ninety (90) days, we will exchange the Battery, charging you 1/1 of the price of a new Battery for each full month from the date of the original sale. Battery must be maintained in accordance with the instructions furnished. 4. The Warranty period for any products used for rental or commercial purposes is limited to 90 days from the date of original purchase. 5. This Warranty applies only to products which have been properly assembled, adjusted, operated, and maintained in ac cor - dance with the instructions furnished. This Warranty does not apply to any product which has been subjected to alteration, misuse, abuse, improper assembly or installation, delivery damage, or to normal wear of the product. 6. Exclusions: Excluded from this Warranty are belts, blades, blade adapters, normal wear, normal adjustments, stan dard hardware and normal maintenance. 7. In case of any problem within the boundaries of this warranty, contact the nearest department store, indicate the model number, serial number and the date of purchase of your machine. This warranty does not apply to accidental damages. All implicit warranties are limited to the same time frames. Or contact: E.M. Services 54 Rue Lambrechts 9400 Courbevoie France Telephone: (1) 466707 Fax: (1) 4667095 THIS WARRANTY DOES NOT APPLY TO INCIDENTAL OR CONSEQUENTIAL DAMAGES. ANY IMPLIED WAR RAN TIES ARE LIMITED TO THE SAME TIME PERIODS STATED HEREIN.
007