EP Series Generator Set Specification Super Quiet, Superior Life! Page - 1 - of 5
3-Phase, 50Hz@1500RPM Prime Power Standby Power Votage kw kva Amps 380 120 150 227.9 400 120 150 216.5 415 120 150 208.7 440 120 150 196.8 380 133.3 166.7 253.2 400 133.3 166.7 240.6 415 133.3 166.7 231.9 440 133.3 166.7 218.7 Noise Leve at 7 meters (dba) 69.1 Notes 1) Ambient reference conditions: 1,000 mbar, 27, 30% reative humidity; 2) Standby Power: the maximum power avaiabe under varying oads. Ony for standby and emergency use. No overoad is permissibe. Prime Power: the maximum power avaiabe under varying oads for continuous operation. A 10% overoad is permissibe for 1 hour every 12 hours. Features Benefits Exceent cooing system, reiabe operation under harshest Function stabiity credibiity, service convenience. conditions. Low operating cost resuts in optima economy. PLC-5220 contro pane with AMF function. With sound attenuated encosures avaiabe with high Gets the job done wherever you are. Ease of instaation, operation, and maintenance. protection against water and dust. Designed with safety in mind earth eakage protection. Leroy Somer Aternator, IP 23 cass H insuation. Performance Specification and Craftwork Performance Specification Teephone Interference, Eectromagnetism Efficiency of Rated Power 96.3% TIF 50 Time needed from start-up to fu oad (inductive) 125 seconds THF 2% Time needed from start-up to 50% oad 8 seconds Radio interference in compiance with BS800 and VED (inductive) aowed LEVELS G and N. 1.1 times overoad operation time (hour) 1 2.0 time overoad operation time (minute) 1 Votage Reguation, steady state ±1% Votage Reguation, transient state 20%-15% Votage Sette Time Votage Fuctuation Ratio 0.5% Frequency Reguation, steady state Frequency Reguation, transient state ±5% Frequency Sette Time Frequency Fuctuation Ratio 0.5% Recovery Time 5 seconds ±0.5% adjustabe 5 seconds 0.5 seconds Craftwork Stee base frame with AV mounting standard 8h fue tank with fexibe rubber fue tube, fue eve indicator and drainage Overa sprayed powder coating Whoe set documents, incuding Instaation Manua, Operation Manua, Spare Parts Cataog, Circuit Diagram Criterion ISO3046, ISO8528, BS4999, BS5514, BS5000PT99!AS1359, IEC34 UTE5100, VDE0530 ISO9001:2000 www. powerinkgenset. com Page - 2 - of 5
Engine Specification Aternator Specification Brand Perkins (UK) Brand Leroy Somer Mode 1006TAG2 Mode LSA44.2M95 No. of Cyinders and Cyce 6L, 4 Stroke Rated Output (kva) 150 Induction TCA Ratedcurrent ( A) 216.5 Compression Ratio 17.25 1 Exciter Brushess Dispacement (L) 6 THF(BS EN60034-1) <2% Bore x Stroke(mm) 105x 127 Bearing number Singe Ambient Temp ( ) 25 Windings 100% Copper Continuous Rated Power (kw) - Connection Type Star Connection Speed (rev/min) 1500 Insuation Cass Cass H Cooing Air Fow (L/min) 154 Winding Pitch 2/3 Air Intake Fow (m³/min) 10.1 Amortisseur Winding Fu Exhaust Gas Fow (m³/min) 29.1 A.V.R. Mode R438 Votage Reguation (no Exhaust Temp ( ) 580 ± 0.5% oad- fu oad) Starting E Underspeed Protection Standard Battery Votage/Capacity 12VDC/250A/300 Protection IP23 Fue Consumption (L/h) 110% oad Phase Sequence A(U), B(V), C(W) 100% oad 41 TIF (NEMA MG 1-22) <50 75% oad 31 Excitation Sef-excited, PMG optiona 50% oad 20 AmbientTemp ( ) 40 Governor Type E Stator Rated Temp ( ) 125 Cooing Fue Radiator Type of Injection Direct Face Area (m 2 ) 0.401 Fue injection pump Dephi rotary Rows and Materias 4 Brass Fue atomiser 0.35 mm diamete Width of Matrix (mm) 637 Height of Matrix (mm) 630 Nozze pressure Pressure Cap Setting (kpa) 68.9 Fue Lift Pump opening (MPa) 24.7 Fow/hour (L/h) 122.4 Fan Pressure (kpa) 30 Diameter (mm) 635 Governor Type Eectronic Drive Ratio 1.25: 1 Lubricating Number of Bades 10 Lubricating Oi Capacity Materia Composite Tota (L) 19 Type - Minimum (L) 16 Cooant Tota Capacity Lubricating Oi Pressure With Radiator (L) 37.22 Reief Vave Open(kPa) 345-414 Without (L) Radiator 12.7 Exhaust Norma ( ) temperature 105-125 Eectrica Max. Back Pressure (kpa) TBA Aternator (A/V) 55/12(or 24) Exhaust Outet Size (mm) 78 Starting Motor (V) 12/24 www. powerinkgenset. com Page - 3 - of 5
Contro PLC-702 DSE-702 key manua start modue is a manua engine contro modue designed to contro the engine via a key switch and push buttons on the front pane. The modue is used to start and stop the engine and indicate faut conditions, automaticay shutting down the engine and giving a true first up faut condition of an engine faiure. Standard Contro Function Manua Engine Contro Modue Low Oi Pressure High Engine Temperature Auxiiary Shutdown Overspeed Protection Protection hod-off timer Charge Faiure warning PLC-5220 DSE-5220 contro panne is appied Microprocessor contro, with high stabiity and credibiity Mains suppy and generator operation monitoring Indicating operation status and faut conditions Mutipe protections; mutipe parameters dispay, ike pressure, temp. Manua and automatic work mode seectabe Rea time cock for time and date dispay, overa runtime dispay, 99 og entries Overa power output dispay Integra speed/frequency detecting, teing status of start, rated operation, overspeed Communication with PC via RS485 OR RS232 interface, using MODBUS protoco. Dimension and Weight Length Width Height, (mm) Weight (kg) 3242 1150 1780 2303 www. powerinkgenset. com Page - 4 - of 5
Optiona Engine Aternator Generator Set Fue Canopy Cooant heater Lubricating Space heater AVR PMG with reguator Anti-damp and anti-corrosion treatment Anti-condensation heater Toos with the machine Low fue eve aarm Automatic fue feeding system Traier Exhaust Cooing Contro Pane Votages Oi with the machine Protection board from hotness Low frequency siencer Front heat protection 50 radiator Cooant (-30 O C) Remote contro pane Automatic paraeing contro pane Automatic Transfer Switch (ATS) 415/240V 400/230V 380/220V 220/127V 200-115V Air Switch Paraeing Contro ATS Mobie Traier Loca Distributor Page - 5 - of 5